Modicon M258
Logic Controller Hardware Guide
04/2012
EIO0000000432.04
www.schneider-electric.com
The information provided in this documentation contains general descriptions and/or technical characteristics of the performance of the products contained herein. This documentation is not intended as a substitute for and is not to be used for determining suitability or reliability of these products for specific user applications. It is the duty of any such user or integrator to perform the appropriate and complete risk analysis, evaluation and testing of the products with respect to the relevant specific application or use thereof. Neither Schneider Electric nor any of its affiliates or subsidiaries shall be responsible or liable for misuse of the information contained herein. If you have any suggestions for improvements or amendments or have found errors in this publication, please notify us. No part of this document may be reproduced in any form or by any means, electronic or mechanical, including photocopying, without express written permission of Schneider Electric. All pertinent state, regional, and local safety regulations must be observed when installing and using this product. For reasons of safety and to help ensure compliance with documented system data, only the manufacturer should perform repairs to components. When devices are used for applications with technical safety requirements, the relevant instructions must be followed. Failure to use Schneider Electric software or approved software with our hardware products may result in injury, harm, or improper operating results. Failure to observe this information can result in injury or equipment damage. 2012 Schneider Electric. All rights reserved.
EIO0000000432 04/2012
Table of Contents
Safety Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . About the Book . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Chapter 1 TM5 System General Rules for Implementing . . . . . . . .
Installation Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Wiring Rules and Recommendations . . . . . . . . . . . . . . . . . . . . . . . . . . . . Environmental Characteristics. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
5 7 13
14 17 23
27
28 30 31 34
39
39
Chapter 4 TM258LD42DT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
General Description. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Characteristics of the Controller Power Distribution Module . . . . . . . . . . .
41
42 46
Chapter 5 TM258LD42DT4L. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
General Description. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Characteristics of the Controller Power Distribution Module . . . . . . . . . . .
49
50 54
Chapter 6 TM258LF42DT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
General Description. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Characteristics of the Controller Power Distribution Module . . . . . . . . . . .
57
58 62
Chapter 7 TM258LF42DT4L. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
General Description. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Characteristics of the Controller Power Distribution Module . . . . . . . . . . .
65
66 70
Chapter 8 TM258LF66DT4L. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
General Description. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Characteristics of the Controller Power Distribution Module . . . . . . . . . . .
73
74 78
Chapter 9 TM258LF42DR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
General Description. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Characteristics of the Controller Power Distribution Module . . . . . . . . . . .
81
82 86
EIO0000000432 04/2012
89
89
91
92 95 99 101 103
107
107
109
110 115 118 120
123
124 127 131 136 141
147
147
Glossary . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Index . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
151 159
EIO0000000432 04/2012
Safety Information
Important Information
NOTICE Read these instructions carefully, and look at the equipment to become familiar with the device before trying to install, operate, or maintain it. The following special messages may appear throughout this documentation or on the equipment to warn of potential hazards or to call attention to information that clarifies or simplifies a procedure.
EIO0000000432 04/2012
PLEASE NOTE Electrical equipment should be installed, operated, serviced, and maintained only by qualified personnel. No responsibility is assumed by Schneider Electric for any consequences arising out of the use of this material. A qualified person is one who has skills and knowledge related to the construction and operation of electrical equipment and its installation, and has received safety training to recognize and avoid the hazards involved.
EIO0000000432 04/2012
At a Glance
Document Scope The purpose of this document is to: show you how to install and operate your controller, show you how to connect the controller to a programming device equipped with SoMachine software help you understand how to interface the controller with I/O modules, HMI and other devices help you become familiar with the controller features. NOTE: Read and understand this document and all related documents (see page 8) before installing, operating or maintaining your controller. The users should read through the entire document to understand all its features.
EIO0000000432 04/2012
Validity Note This document has been updated with the release of SoMachine V3.1. The technical characteristics of the device(s) described in this manual also appear online. To access this information online:
Step 1 2 Action Go to the Schneider Electric home page www.schneider-electric.com. In the Search box type the model number of a product or the name of a product range. Do not include blank spaces in the model number/product range. To get information on a grouping similar modules, use asterisks (*). If you entered a model number, go to the Product datasheets search results and click on the model number that interests you. If you entered the name of a product range, go to the Product Ranges search results and click on the product range that interests you. If more than one model number appears in the Products search results, click on the model number that interests you. Depending on the size of your screen, you may need to scroll down to see the data sheet. To save or print a data sheet as a .pdf file, click Download XXX product datasheet.
4 5 6
The characteristics presented in this manual should be the same as those that appear online. In line with our policy of constant improvement we may revise content over time to improve clarity and accuracy. In the event that you see a difference between the manual and online information, use the online information as your reference. Related Documents
Title of Documentation Modicon M258 Logic Controller Programming Guide Reference Number EIO0000000402 (ENG); EIO0000000403 (FRE); EIO0000000404 (GER); EIO0000000405 (SPA); EIO0000000406 (ITA); EIO0000000407 (CHS) EIO0000000426 (ENG); EIO0000000427 (FRE); EIO0000000428 (GER); EIO0000000429 (SPA); EIO0000000430 (ITA); EIO0000000431 (CHS)
EIO0000000432 04/2012
EIO0000000450 (ENG); EIO0000000451 (FRE); EIO0000000452 (GER); EIO0000000453 (SPA); EIO0000000454 (ITA); EIO0000000455 (CHS) EIO0000000444 (ENG); EIO0000000445 (FRE); EIO0000000446 (GER); EIO0000000447 (SPA); EIO0000000448 (ITA); EIO0000000449 (CHS)
Modicon TM5 Expert (High Speed Counter) Modules Hardware EIO0000000462 (ENG); Guide EIO0000000463 (FRE); EIO0000000464 (GER); EIO0000000465 (SPA); EIO0000000466 (ITA); EIO0000000467 (CHS) Modicon TM5 Transmitter and Receiver Modules Hardware Guide EIO0000000468 (ENG); EIO0000000469 (FRE); EIO0000000470 (GER); EIO0000000471 (SPA); EIO0000000472 (ITA); EIO0000000473 (CHS) EIO0000000474 (ENG); EIO0000000475 (FRE); EIO0000000476 (GER); EIO0000000477 (SPA); EIO0000000478 (ITA); EIO0000000479 (CHS) 31006929 02 (ENG); 31006930 02 (FRE); 31006931 02 (GER); 31006932 02 (SPA) 840 USE 107 00 (ENG); 840 USE 107 01 (FRE); 840 USE 107 02 (GER); 840 USE 107 03 (SPA) BBV56040
You can download these technical publications and other technical information from our website at www.schneider-electric.com.
EIO0000000432 04/2012
DANGER
HAZARD OF ELECTRIC SHOCK, EXPLOSION OR ARC FLASH