This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws.
f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 1 of 120
The information contained is accurate to the best of our knowledge. 12 Volt Resource LLC makes no representation or warranty with respect to the information contained in this document including its accuracy or completeness. 12 Volt Resource LLC disclaims all liability or responsibility for errors or omissions therein or any decision made by the recipient in reliance thereon.
nstallations should be attempted by experienced installers only. Proper installation remains the responsibility of the installer. t is the installer's responsibility to test and verify all circuitry with the proper test equipment prior to installation.
Additional nformation:
This information is sorted alphabetically by vehicle model. f there are multiple years for a particular vehicle model, then the oldest year comes first.
The installation notes referenced below and the full installation guide are located in the nstall nstructions & Notes folder on this CD-ROM.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 2 of 120
NOTES: All Mercedes Diesel Vehicles Manufactured between 1983 and 1988 *MAY* require a vacuum switch be added. See Note #240 Mercedes Vacuum Motor Diagram.
Mercedes-Benz 190D 1984-1993
FUNCTON COLOR LOCATON Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS OEM Alarm Disarm: N/A Dome Lights/Superv: BROWN/GRAY AND GRAY SEE NOTES BELOW * OEM Horn: BLACK/YELLOW/PNK (+) STEERNG COLUMN HARNESS Power Lock: GREEN, BLUE OR YELLOW ALL THREE WRES ARE AT VACUUM PUMP ** Power Unlock: VACUUM DOOR LOCKS ALL THREE WRES ARE AT VACUUM PUMP ** Trunk Release: NO COLOR AVALABLE Alarm nput Wire: BROWN/GRAY AND GRAY SEE NOTES BELOW *
NOTES: * Rear Pin Switch And BLUE Door Lock Wire Can Be Found Below Driver Step Plate n Protective Tubing. ** See Note #210 - Mercedes Vacuum Door Lock Diagram. *** Split Parking Light System - must use relays to isolate the circuits from each other..
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 3 of 120
NOTES: All Mercedes Diesel Vehicles Manufactured between 1983 and 1988 *MAY* require a vacuum switch be added. See Note #240 Mercedes Vacuum Motor Diagram.
Mercedes-Benz 190E 1984-1993
FUNCTON COLOR LOCATON Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS OEM Alarm Disarm: N/A Dome Lights/Superv: BROWN/GRAY AND GRAY SEE NOTES BELOW * OEM Horn: BLACK/YELLOW/PNK (+) STEERNG COLUMN HARNESS Power Lock: GREEN, BLUE OR YELLOW ALL THREE WRES ARE AT VACUUM PUMP ** Power Unlock: VACUUM DOOR LOCKS ALL THREE WRES ARE AT VACUUM PUMP ** Trunk Release: NO COLOR AVALABLE Alarm nput Wire: BROWN/GRAY AND GRAY SEE NOTES BELOW *
NOTES: * Rear Pin Switch And BLUE Door Lock Wire Can Be Found Below Driver Step Plate n Protective Tubing. ** See Note #210 - Mercedes Vacuum Door Lock Diagram. *** Split Parking Light System - must use relays to isolate the circuits from each other..
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 4 of 120
FUNCTON COLOR LOCATON Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS OEM Alarm Disarm: N/A Dome Lights/Superv: SEE NOTES BELOW * OEM Horn: N/A Power Lock: N/A *** Power Unlock: N/A Trunk Release: N/A Alarm nput Wire: SEE NOTES BELOW *
NOTES: * Split System- Fronts Are BROWN/GRAY (-) At Driver Pin Switch Or BROWN/GRAY/RED (-) At Passenger Pin Switch. Fronts Are Negative And Driver Pin Switch Should Cover Both Front Doors. Rears Are GRAY (+) At either Pin Switch. Rears Are Positive.* Split Parking Light System - must use relays to isolate the circuits from each other. *** Must add door lock actuators - See Note #204
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 5 of 120
NOTES: All Mercedes Diesel Vehicles Manufactured between 1983 and 1988 *MAY* require a vacuum switch be added. See Note #240 Mercedes Vacuum Motor Diagram.
Mercedes-Benz 240D 1980-1983
FUNCTON COLOR LOCATON Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS OEM Alarm Disarm: N/A Dome Lights/Superv: SEE NOTES BELOW * OEM Horn: N/A Power Lock: N/A *** Power Unlock: N/A Trunk Release: N/A Alarm nput Wire: SEE NOTES BELOW *
NOTES: * Split System- Fronts Are BROWN/GRAY (-) At Driver Pin Switch Or BROWN/GRAY/RED (-) At Passenger Pin Switch. Fronts Are Negative And Driver Pin Switch Should Cover Both Front Doors. Rears Are GRAY (+) At Either Pin Switch. Rears Are Positive.** Split Parking Light System - must use relays to isolate the circuits from each other. *** must add door lock actuators - see Note #204
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 6 of 120
NOTES: * Diagnostic Connector Located On Driver Wheelwell Next To gnition Control Module. See Note #235- See Powering Extra gnitions Diagram
Mercedes-Benz 260E 1987
FUNCTON COLOR LOCATON Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS OEM Alarm Disarm: N/A Dome Lights/Superv: SEE NOTES BELOW ** OEM Horn: N/A Power Lock: BLUE DRVER'S KCK OR AT VACUUM PUMP **** Power Unlock: SNGLE WRE SYSTEM DRVER'S KCK OR AT VACUUM PUMP **** Trunk Release: N/A Alarm nput Wire: SEE NOTES BELOW **
NOTES: * 2 Starter Wires- Cut Both And Treat As One Single Wire. ** Fronts- BROWN/GRAY (-) At Passenger Pin Switch. Rears- '85 300D & CD: BROWN/BLACK (-). 260E & 87 300D, E & TD: BROWN/GRAY At Driver Rear Pin Switch. *** Split Parking Light System - must use relays to isolate the circuits from each other.. **** See Note #210 - Mercedes Vacuum Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 7 of 120
NOTES: All Mercedes Diesel Vehicles Manufactured between 1983 and 1988 *MAY* require a vacuum switch be added. See Note #240 Mercedes Vacuum Motor Diagram.
Mercedes-Benz 260E 1988
FUNCTON COLOR LOCATON Constant +12 Volts: RED GNTON SWTCH HARNESS OEM Alarm Disarm: N/A Dome Lights/Superv: SEE NOTES BELOW * OEM Horn: N/A Power Lock: BLUE DRVER'S KCK PANEL OR VACUUM PUMP *** Power Unlock: SNGLE WRE SYSTEM DRVER'S KCK PANEL OR VACUUM PUMP *** Trunk Release: N/A Alarm nput Wire: SEE NOTES BELOW *
NOTES: * Split System: Fronts- BROWN/GRAY (-) At Passenger Pin Switch Or Dome Light. Rears- '85 300D & CD: BROWN/BLACK (-). 260E, '87 300D, E & TD: BROWN/GRAY (-) At Driver Rear Pin Switch. ** Split Parking Light System - must use relays to isolate the circuits from each other.. *** See Note #210 - Mercedes Vacuum Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 8 of 120
FUNCTON COLOR LOCATON Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS OEM Alarm Disarm: N/A Dome Lights/Superv: SEE NOTES BELOW * OEM Horn: N/A Power Lock: N/A *** Power Unlock: N/A *** Trunk Release: N/A Alarm nput Wire: SEE NOTES BELOW *
NOTES: * Split System, Fronts- BROWN/GRAY (-) At Driver Pin Switch, BRN/GRY/RED (-) At Passenger Pin Switch. Fronts Are Negative And Driver Pin Switch Should Cover Both Front Doors. Rears Are GRAY (+) At Either Rear Pin Switch. Rear Doors Are Positive. ** Split Parking Light System - must use relays to isolate the circuits from each other. *** Must add door lock actuators - See Note #204
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 9 of 120
FUNCTON COLOR LOCATON Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS OEM Alarm Disarm: N/A Dome Lights/Superv: SEE NOTES BELOW * OEM Horn: N/A Power Lock: N/A *** Power Unlock: N/A Trunk Release: N/A Alarm nput Wire: SEE NOTES BELOW *
NOTES: * Split System, Fronts- BROWN/GRAY (-) At Driver Pin Switch, BRN/GRY/RED (-) At Passenger Pin Switch. Fronts Are Negative And Driver Pin Switch Should Cover Both Front Doors. Rears Are GRAY (+) At Either Rear Pin Switch. Rear Doors Are Positive. ** Split Parking Light System - must use relays to isolate the circuits from each other.. *** Must add door lock actuators - See Note #204
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 10 of 120
280 CE 1987 -1993
KEY T-HARNESS MMOBLZER N/A N/A N/A
FUNCTON COLOR LOCATON 12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS STARTER PURPLE/WHTE (+) GNTON SWTCH HARNESS STARTER 2 N/A GNTON 1 RED/BLACK (+) GNTON SWTCH HARNESS GNTON 2 RED/YELLOW (+) GNTON SWTCH HARNESS GNTON 3 N/A ACCESSORY/HEATER BLOWER 1 RED/GREEN (+) GNTON SWTCH HARNESS ACCESSORY/HEATER BLOWER 2 N/A KEYSENSE N/A PARKNG LGHTS ( - ) N/A PARKNG LGHTS ( + ) GREEN/WHTE (+) and GRAY (+) Use both, See NOTE *1 @ HEADLGHT SWTCH POWER LOCK BLUE or GREEN, See NOTE *2 N DRVER KCK or PUMP UNDER SEAT POWER UNLOCK Same wire, See NOTE *2 DOOR TRGGER BROWN/GRAY (-) and GRAY/BLUE (-) Use both, See NOTE *3 @ PASSENGERS PN SWTCHES or THEFT MODULE, See NOTE *4 DOMELGHT SUPERVSON BROWN/GRAY (-) @ PASSENGERS PN SWTCHES or THEFT MODULE, See NOTE *4 TRUNK RELEASE N/A SLDNG POWER DOOR N/A
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 11 of 120
HORN BLACK/YELLOW (+) @ THEFT MODULE, See NOTE *4 TACH GREEN or GREEN/YELLOW @ DAGNOSTC CONNECTOR, See NOTE *5 WAT TO START LGHT N/A BRAKE BLACK/RED (+) @ SWTCH ABOVE BRAKE PEDAL FACTORY ALARM DSARM GREEN/YELLOW (-) @ THEFT MODULE, See NOTE *4 ANT-THEFT N/A
EXTRA NFORMATON NOTE *1 this vehicle has 2 Parking Light wires that will require 2 EXTRA Relays part #775 to solate, to connect, . NOTE *2 this vehicle has a Vacuum Door Locking System that will requires 2 extra relays part#775, the wire is a the Drivers kick panel or at the pump under the rear seat, to connect, . NOTE *3 the BROWN/GRAY (-) is for the FRONT DOORS, the GRAY/BLUE (-) is for the REAR DOORS. When connecting to an ALARM SYSTEM, use both DOOR TRGGER wires and DODE SOLATE. to connect. NOTE *4 the THEFT MODULE is located in the PASSENGER FOOTWELL under the carpet and behind a PLASTC or WOOD cover against the firewall. NOTE *5 the DAGNOSTC CONNECTOR is covered by a BLACK round cap and is located between the LEFT FRONT HEADLGHT and the Shock tower under the Hood.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 12 of 120
FUNCTON COLOR LOCATON Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS OEM Alarm Disarm: N/A Dome Lights/Superv: SEE NOTES BELOW * OEM Horn: N/A Power Lock: N/A Power Unlock: N/A Trunk Release: N/A Alarm nput Wire: SEE NOTES BELOW *
NOTES: * Split System, Fronts- BROWN/GRAY (-) At Driver Pin Switch, BRN/GRY/RED (-) At Passenger Pin Switch. Fronts Are Negative And Driver Pin Switch Should Cover Both Front Doors. Rears Are GRAY (+) At Either Rear Pin Switch. Rear Doors Are Positive. ** Split Parking Light System - must use relays to isolate the circuits from each other..
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 13 of 120
FUNCTON COLOR LOCATON Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS OEM Alarm Disarm: N/A Dome Lights/Superv: SEE NOTES BELOW * OEM Horn: N/A Power Lock: N/A Power Unlock: N/A Trunk Release: N/A Alarm nput Wire: SEE NOTES BELOW *
NOTES: * Split System, Fronts- BROWN/GRAY (-) At Driver Pin Switch, BRN/GRY/RED (-) At Passenger Pin Switch. Fronts Are Negative And Driver Pin Switch Should Cover Both Front Doors. Rears Are GRAY (+) At Either Rear Pin Switch. Rear Doors Are Positive. ** Split Parking Light System - must use relays to isolate the circuits from each other..
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 14 of 120
FUNCTON COLOR LOCATON Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS OEM Alarm Disarm: N/A Dome Lights/Superv: SEE NOTES BELOW * OEM Horn: N/A Power Lock: N/A *** Power Unlock: N/A Trunk Release: N/A Alarm nput Wire: SEE NOTES BELOW *
NOTES: * Split System, Fronts- BROWN/GRAY (-) At Driver Pin Switch, BRN/GRY/RED (-) At Passenger Pin Switch. Fronts Are Negative And Driver Pin Switch Should Cover Both Front Doors. Rears Are GRAY (+) At Either Rear Pin Switch. Rear Doors Are Positive. ** Split Parking Light System - must use relays to isolate the circuits from each other. *** Must add actuators - See Note #204
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 15 of 120
Make: Model: Year: Mercedes-Benz 300 Series 1988-1992
NOTES: All Mercedes Diesel Vehicles Manufactured between 1983 and 1988 *MAY* require a vacuum switch be added. See Note #240 Mercedes Vacuum Motor Diagram.
Mercedes-Benz 300 Series 1988-1992
FUNCTON COLOR LOCATON Constant +12 Volts: RED GNTON SWTCH HARNESS OEM Alarm Disarm: N/A Dome Lights/Superv: BROWN/WHTE OR BROWN/VOLET (-) AT PN SWTCH OEM Horn: N/A Power Lock: BLUE DRVER'S KCK OR AT VACUUM PUMP ** Power Unlock: SNGLE WRE SYSTEM DRVER'S KCK OR AT VACUUM PUMP ** Trunk Release: N/A Alarm nput Wire: BROWN/WHTE OR BROWN/VOLET (-) AT PN SWTCH
NOTES: * Split Parking Light System - must use relays to isolate the circuits from each other.. ** See Note #210 - Mercedes Vacuum Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 16 of 120 Make: Model: Year: Mercedes-Benz 300CD 1980-1984
NOTES: * Diesel Engine. ** All Mercedes Diesel Vehicles Manufactured Between 1983 - 1988 Require A Vacuum Pump Motor Be Added. See Note #240 - Mercedes Vacuum Motor Diagram.
Mercedes-Benz 300CD 1980-1984
FUNCTON COLOR LOCATON Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS ** OEM Alarm Disarm: N/A Dome Lights/Superv: SEE NOTES BELOW ***** OEM Horn: N/A Power Lock: N/A ***** Power Unlock: N/A Trunk Release: N/A Alarm nput Wire: SEE NOTES BELOW *****
NOTES: *** Split Parking Light System - must use relays to isolate the circuits from each other. **** Split System, Front Doors- BROWN/GRAY (-) At Driver Pin Switch or BROWN/GRAY/RED (- ) At Passenger Pin Switch. Front Doors Are Negative, Driver Pin Switch Should Cover Both Front Doors. Rear Doors- GRAY (+) At Either Rear Pin Switch. Rear Doors Are Positive. ***** See Note #204 for door lock information
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 17 of 120
NOTES: * Diesel Engine. ** All Mercedes Diesel Vehicles Manufactured Between 1983 - 1988 Require A Vacuum Pump Motor Be Added. See Note #240 - Mercedes Vacuum Motor Diagram.
Mercedes-Benz 300CD 1985
FUNCTON COLOR LOCATON Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS OEM Alarm Disarm: N/A Dome Lights/Superv: SEE NOTES BELOW **** OEM Horn: N/A Power Lock: BLUE DRVER'S KCK OR AT VACUUM PUMP ***** Power Unlock: SNGLE WRE SYSTEM DRVER'S KCK OR AT VACUUM PUMP ***** Trunk Release: N/A Alarm nput Wire: SEE NOTES BELOW ****
NOTES: *** Split Parking Light System - must use relays to isolate the circuits from each other.. **** Split System, Front Doors- BROWN/GRAY (-) At Driver Pin Switch or BROWN/GRAY/RED (- ) At Passenger Pin Switch. Front Doors Are Negative, Driver Pin Switch Should Cover Both Front Doors. Rear Doors- GRAY (+) At Either Rear Pin Switch. Rear Doors Are Positive. ***** See Note #210 - Mercedes Vacuum Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 18 of 120
NOTES: * Diesel Engine. ** All Mercedes Diesel Vehicles Manufactured Between 1983 - 1988 Require A Vacuum Pump Motor Be Added. See Note #240 - Mercedes Vacuum Motor Diagram.
Mercedes-Benz 300D 1980-1984
FUNCTON COLOR LOCATON Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS OEM Alarm Disarm: N/A Dome Lights/Superv: SEE NOTES BELOW **** OEM Horn: N/A Power Lock: N/A Power Unlock: N/A Trunk Release: N/A Alarm nput Wire: SEE NOTES BELOW ****
NOTES: *** Split Parking Light System - must use relays to isolate the circuits from each other.. **** Fronts- BROWN/GRAY (-) At Passenger Pin Switch. Rears- '85 300D & CD: BROWN/BLACK (-). 260E & 87 300D, E & TD: BROWN/GRAY At Driver Rear Pin Switch.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 19 of 120 Make: Model: Year: Mercedes-Benz 300D 1985
NOTES: * Diesel Engine. ** All Mercedes Diesel Vehicles Manufactured Between 1983 - 1988 Require A Vacuum Pump Motor Be Added. See Note #240 - Mercedes Vacuum Motor Diagram.
Mercedes-Benz 300D 1985
FUNCTON COLOR LOCATON Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS OEM Alarm Disarm: N/A Dome Lights/Superv: SEE NOTES BELOW **** OEM Horn: N/A Power Lock: BLUE DRVER'S KCK OR AT VACUUM PUMP ***** Power Unlock: SNGLE WRE SYSTEM DRVER'S KCK OR AT VACUUM PUMP ***** Trunk Release: N/A Alarm nput Wire: SEE NOTES BELOW ****
NOTES: *** Split Parking Light System - must use relays to isolate the circuits from each other.. **** Fronts- BROWN/GRAY (-) At Passenger Pin Switch. Rears- '85 300D & CD: BROWN/BLACK (-). 260E & 87 300D, E & TD: BROWN/GRAY At Driver Rear Pin Switch. ***** See Note #210 - Mercedes Vacuum Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 20 of 120 Make: Model: Year: Mercedes-Benz 300D 1987
NOTES: * Diagnostic Plug Located On Driver Wheelwell Next To gnition Control Module; Diesel Engine. ** All Mercedes Diesel Vehicles Manufactured Between 1983 - 1988 Require A Vacuum Pump Motor Be Added. See Note #240 - Mercedes Vacuum Motor Diagram.
Mercedes-Benz 300D 1987
FUNCTON COLOR LOCATON Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS OEM Alarm Disarm: N/A Dome Lights/Superv: SEE NOTES BELOW *** OEM Horn: N/A Power Lock: BLUE DRVER'S KCK OR AT VACUMM PUMP ***** Power Unlock: SNGLE WRE SYSTEM DRVER'S KCK OR AT VACUMM PUMP ***** Trunk Release: N/A Alarm nput Wire: SEE NOTES BELOW ***
NOTES: *** Fronts- BROWN/GRAY (-) At Passenger Pin Switch. Rears- '85 300D & CD: BROWN/BLACK (-). 260E & 87 300D, E & TD: BROWN/GRAY At Driver Rear Pin Switch. **** Split Parking Light System - must use relays to isolate the circuits from each other.. ***** See Note #210 - Mercedes Vacuum Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 21 of 120
300 D 1990 -1992
KEY T-HARNESS MMOBLZER N/A N/A N/A
FUNCTON COLOR LOCATON 12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS STARTER PURPLE/WHTE (+) GNTON SWTCH HARNESS STARTER 2 N/A GNTON 1 BLACK/RED (+) GNTON SWTCH HARNESS GNTON 2 N/A GNTON 3 N/A ACCESSORY/HEATER BLOWER 1 PNK/GREEN (+) GNTON SWTCH HARNESS ACCESSORY/HEATER BLOWER 2 N/A KEYSENSE N/A PARKNG LGHTS ( - ) N/A PARKNG LGHTS ( + ) GRAY/WHTE (+) and GRAY (+) Use both, See NOTE *1 @ HEADLGHT SWTCH POWER LOCK BLUE or GREEN, See NOTE *2 POWER UNLOCK Same wire, See NOTE *2 DOOR TRGGER BROWN/GRAY (-) @ PASSENGERS PN SWTCHES DOMELGHT SUPERVSON USE DOOR TRGGER TRUNK RELEASE N/A SLDNG POWER DOOR N/A HORN N/A TACH BLACK @ DAGNOSTC CONNECTOR or GNTON COL WAT TO START LGHT N/A BRAKE BLACK/RED (+) @ SWTCH ABOVE BRAKE PEDAL FACTORY ALARM DSARM GREEN/BLUE (-) @ THEFT MODULE ANT-THEFT N/A
EXTRA NFORMATON NOTE *1 this vehicle has 2 Parking Light wires that will require 2 extra Relays part #775, to connect, . NOTE *2 this vehicle has a Vacuum Door Locking System that will requires 2 extra relays part #775, the wire is a the Drivers kick panel or at the pump under the rear seat, to connect, .
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 22 of 120
NOTES: All Mercedes Diesel Vehicles Manufactured between 1983 and 1988 *MAY* require a vacuum switch be added. See Note #240 Mercedes Vacuum Motor Diagram. * Diagnostic Connector Located On Driver Wheelwell Next To gnition Control Module.
Mercedes-Benz 300E 1986
FUNCTON COLOR LOCATON Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS OEM Alarm Disarm: N/A Dome Lights/Superv: SEE NOTES BELOW *** OEM Horn: N/A Power Lock: BLUE DRVER'S KCK PANEL OR AT PUMP **** Power Unlock: SNGLE WRE SYSTEM DRVER'S KCK PANEL OR AT PUMP **** Trunk Release: N/A Alarm nput Wire: SEE NOTES BELOW ***
NOTES: ** Split Parking Light System - must use relays to isolate the circuits from each other.. *** Front Doors- BROWN/GRAY (-) At Passenger Pin Switch Or Front Dome Light. Rear Doors- '85 300D & CD; BROWN/BLACK (-). '87 300D, E & TD; BROWN/GRAY (-) At Driver Rear Pin Switch. **** See Note #210 - Mercedes Vacuum Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 23 of 120
NOTES: All Mercedes Diesel Vehicles Manufactured between 1983 and 1988 *MAY* require a vacuum switch be added. See Note #240 Mercedes Vacuum Motor Diagram. * Diagnostic Connector Located On Driver Wheelwell Next To gnition Control Module.
Mercedes-Benz 300E 1987
FUNCTON COLOR LOCATON Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS OEM Alarm Disarm: N/A Dome Lights/Superv: SEE NOTES BELOW *** OEM Horn: N/A Power Lock: BLUE DRVER'S KCK PANEL OR AT PUMP **** Power Unlock: SNGLE WRE SYSTEM DRVER'S KCK PANEL OR AT PUMP **** Trunk Release: N/A Alarm nput Wire: SEE NOTES BELOW ***
NOTES: ** Split Parking Light System - must use relays to isolate the circuits from each other.. *** Front Doors- BROWN/GRAY (-) At Passenger Pin Switch Or Front Dome Light. Rear Doors- '85 300D & CD; BROWN/BLACK (-). '87 300D, E & TD; BROWN/GRAY (-) At Driver Rear Pin Switch. **** See Note #210 - Mercedes Vacuum Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 24 of 120
300 E 1988 -1993
KEY T-HARNESS MMOBLZER N/A N/A N/A
FUNCTON COLOR LOCATON 12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS STARTER PURPLE (+) GNTON SWTCH HARNESS STARTER 2 N/A GNTON 1 PNK/RED (+) GNTON SWTCH HARNESS GNTON 2 PNK/YELLOW (+) GNTON SWTCH HARNESS GNTON 3 N/A ACCESSORY/HEATER BLOWER 1 PNK/GREEN (+) GNTON SWTCH HARNESS ACCESSORY/HEATER BLOWER 2 N/A KEYSENSE N/A PARKNG LGHTS ( - ) N/A PARKNG LGHTS ( + ) GREEN/WHTE (+) and GRAY (+) Use both, See NOTE *1 @ HEADLGHT SWTCH POWER LOCK BLUE or GREEN, See NOTE *2 POWER UNLOCK Same wire, See NOTE *2 DOOR TRGGER BROWN/GRAY (-) and BROWN/GRAY/BLACK (-) Use both, See NOTE *3 @ PN SWTCHES DOMELGHT SUPERVSON BROWN/GRAY (-) @ PASSENGERS PN SWTCH TRUNK RELEASE N/A SLDNG POWER DOOR N/A HORN BLACK/YELLOW/PNK (+) @ STEERNG COLUMN HARNESS TACH BLACK @ GNTON COL
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 25 of 120 WAT TO START LGHT N/A BRAKE BLACK/RED/WHTE (+) @ SWTCH ABOVE BRAKE PEDAL FACTORY ALARM DSARM GREEN/YELLOW (-) @ THEFT MODULE, See NOTE *4 ANT-THEFT N/A
EXTRA NFORMATON NOTE *1 this vehicle has 2 Parking Light wires that will require 2 extra Relays part #775, to connect, NOTE *2 this vehicle has aVacuum Door Locking System that will requires 2 extra relays part #775, the wire is a the Drivers kick panel or at the pump under the rear seat, to connect, . These wires are in a BLACK tube comming out of the Drivers Door. NOTE *3 the BROWN/GRAY (-) is at the RGHT PN SWTCH is for the FRONT DOORS, the BROWN/GRAY/BLACK (-) is at the REAR PN SWTCH is for the REAR DOORS When connecting to an ALARM SYSTEM use both DOOR TRGGER wires and DODE SOLATE. to connect, NOTE *4 the THEFT MODULE is located in the PASSENGER FOOTWELL under the carpet and behind a PLASTC or WOOD cover against the firewall.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 26 of 120
NOTES: * Diesel Engine. ** All Mercedes Diesel Vehicles Manufactured Between 1983 - 1988 Require A Vacuum Pump Motor Be Added. See Note #240 - Mercedes Vacuum Motor Diagram.
Mercedes-Benz 300SD 1983-1984
FUNCTON COLOR LOCATON Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS OEM Alarm Disarm: N/A Dome Lights/Superv: BROWN/WHTE (-) AT PN SWTCH OR COURTESY LGHT OEM Horn: N/A Power Lock: BLUE DRVER'S KCK PANEL OR AT PUMP **** Power Unlock: SNGLE WRE SYSTEM DRVER'S KCK PANEL OR AT PUMP **** Trunk Release: N/A Alarm nput Wire: BROWN/WHTE (-) AT PN SWTCH OR COURTESY LGHT
NOTES: *** Split Parking Light System - must use relays to isolate the circuits from each other.. **** See Note #210 - Mercedes Vacuum Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 27 of 120
NOTES: * Diesel Engine. ** All Mercedes Diesel Vehicles Manufactured Between 1983 - 1988 Require A Vacuum Pump Motor Be Added. See Note #240 - Mercedes Vacuum Motor Diagram.
Mercedes-Benz 300SD 1985
FUNCTON COLOR LOCATON Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS OEM Alarm Disarm: N/A Dome Lights/Superv: FRONT - BROWN/GRAY RGHT REAR - BROWN/WHTE (-) PN SW. OEM Horn: N/A Power Lock: BLUE DRVER'S KCK PANEL OR AT PUMP **** Power Unlock: SNGLE WRE SYSTEM DRVER'S KCK PANEL OR AT PUMP **** Trunk Release: N/A Alarm nput Wire: FRONT - BROWN/GRAY RGHT REAR - BROWN/WHTE (-) PN SW.
NOTES: *** Split Parking Light System - must use relays to isolate the circuits from each other.. **** See Note #210 - Mercedes Vacuum Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 28 of 120
NOTES: * A/C Compressor Control Relay Located n Engine Compartment Relay/Fuse Block n Driver Rear Corner Of Engine Compartment; Diesel Engine ** All Mercedes Diesel Vehicles Manufactured Between 1983 - 1988 Require A Vacuum Pump Motor Be Added. See Note #240 - Mercedes Vacuum Motor Diagram.
Mercedes-Benz 300SDL 1986-1987
FUNCTON COLOR LOCATON Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS OEM Alarm Disarm: N/A Dome Lights/Superv: SEE NOTES BELOW **** OEM Horn: N/A Power Lock: BLUE DRVER'S KCK PANEL OR AT PUMP ***** Power Unlock: VACUUM DOOR LOCKS DRVER'S KCK PANEL OR AT PUMP ***** Trunk Release: N/A Alarm nput Wire: SEE NOTES BELOW ****
NOTES: *** Split Parking Light System - must use relays to isolate the circuits from each other.. **** Split System, Front Doors- BROWN/GRAY (-) At Passenger Pin Switch Or At Dome Light. Rear Doors- BROWN/WHTE (-) Or BROWN/GRAY Dots (-) At Driver Rear Pin Switch Or Dome Light. ***** See Note #210 - Mercedes Vacuum Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 29 of 120
300 SE 1992
KEY T-HARNESS MMOBLZER N/A N/A N/A
FUNCTON COLOR LOCATON 12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS STARTER PURPLE (+) GNTON SWTCH HARNESS STARTER 2 N/A GNTON 1 PNK/RED (+) GNTON SWTCH HARNESS GNTON 2 PNK/YELLOW (+) GNTON SWTCH HARNESS GNTON 3 N/A ACCESSORY/HEATER BLOWER 1 PNK/GREEN (+) GNTON SWTCH HARNESS ACCESSORY/HEATER BLOWER 2 N/A KEYSENSE N/A PARKNG LGHTS ( - ) N/A PARKNG LGHTS ( + ) GRAY/WHTE (+) and GRAY (+) Use both, See NOTE *1 @ HEADLGHT SWTCH POWER LOCK BLUE or GREEN, See NOTE *2 POWER UNLOCK Same wire, See NOTE *2 N DRVERS KCK PANEL DOOR TRGGER BROWN/GRAY (-) and GRAY/BLUE (-) Use both, See NOTE *3 @ PN SWTCHES DOMELGHT SUPERVSON BROWN/GRAY (-) @ PASSENGERS PN SWTCH TRUNK RELEASE N/A SLDNG POWER DOOR N/A HORN BLACK/YELLOW/PNK (+) @ STEERNG COLUMN HARNESS TACH GREEN/YELLOW @ BACK of NSTRUMENT CLUSTER
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 30 of 120 WAT TO START LGHT N/A BRAKE BLACK/RED/WHTE (+) @ SWTCH ABOVE BRAKE PEDAL FACTORY ALARM DSARM GREEN/YELLOW (-) N DRVERS DOOR HARNESS ANT-THEFT N/A
EXTRA NFORMATON NOTE *1 this vehicle has 2 Parking Light wires that will require 2 extra Relays part #775, to connect, . NOTE *2 this vehicle has a Vacuum Door Locking System that will requires 2 extra relays part #775, the wire is a the Drivers kick panel or at the pump under the rear seat, to connect, . These wires are in a BLACK tube comming out of the Drivers Door. NOTE *3 the BROWN/GRAY (-) is at the RGHT PN SWTCH is for the FRONT DOORS, the BROWN/GRAY/BLACK (-) is at the REAR PN SWTCH is for the REAR DOORS When connecting to an ALARM SYSTEM, use both DOOR TRGGER wires and DODE SOLATE. to connect,
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 31 of 120
300 SL 1991
KEY T-HARNESS MMOBLZER N/A N/A N/A
FUNCTON COLOR LOCATON 12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS STARTER PURPLE (+) GNTON SWTCH HARNESS STARTER 2 N/A GNTON 1 PNK/RED (+) GNTON SWTCH HARNESS GNTON 2 PNK/BLACK (+) GNTON SWTCH HARNESS GNTON 3 N/A ACCESSORY/HEATER BLOWER 1 PNK/YELLOW (+) GNTON SWTCH HARNESS ACCESSORY/HEATER BLOWER 2 N/A KEYSENSE N/A PARKNG LGHTS ( - ) N/A PARKNG LGHTS ( + ) GRAY/WHTE (+) and GRAY (+) Use both, See NOTE *1 @ HEADLGHT SWTCH POWER LOCK BLUE or GREEN, See NOTE *2 POWER UNLOCK Same wire, See NOTE *2 N DRVERS KCK PANEL DOOR TRGGER GRAY/WHTE (-) @ PASSENGERS PN SWTCH DOMELGHT SUPERVSON USE DOOR TRGGER TRUNK RELEASE N/A SLDNG POWER DOOR N/A HORN BLACK/YELLOW (+) @ STEERNG COLUMN HARNESS TACH BLACK @ DAGNOSTC CONNECTOR behind drivers HEADLGHT WAT TO START LGHT N/A
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 32 of 120 BRAKE BLACK/RED (+) @ SWTCH ABOVE BRAKE PEDAL FACTORY ALARM DSARM WHTE (-) See NOTE *3 ANT-THEFT N/A
EXTRA NFORMATON NOTE *1 this vehicle has 2 Parking Light wires that will require 2 extra Relays part #775, to connect, . NOTE *2 this vehicle has a Vacuum Door Locking System that will requires 2 extra relays part #775, the wire is a the Drivers kick panel or at the pump under the rear seat, to connect, . These wires are in a BLACK tube comming out of the Drivers Door. NOTE *3 this WHTE wire is the same wire as the Arm wire. Locate this wire at the theft Module in the trunk by the gas filter and power antenna.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 33 of 120
FUNCTON COLOR LOCATON Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS OEM Alarm Disarm: N/A Dome Lights/Superv: SEE NOTES BELOW * OEM Horn: N/A Power Lock: N/A *** Power Unlock: N/A Trunk Release: N/A Alarm nput Wire: SEE NOTES BELOW *
NOTES: * Split System, Fronts- BROWN/GRAY (-) At Driver Pin Switch, BRN/GRY/RED (-) At Passenger Pin Switch. Fronts Are Negative And Driver Pin Switch Should Cover Both Front Doors. Rears Are GRAY (+) At Either Rear Pin Switch. Rear Doors Are Positive. ** Split Parking Light System - must use relays to isolate the circuits from each other. *** Must add actuators - See Note #204
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 34 of 120
NOTES: All Mercedes Diesel Vehicles Manufactured between 1983 and 1988 *MAY* require a vacuum switch be added. See Note #240 Mercedes Vacuum Motor Diagram.
Mercedes-Benz 300TD 1982-1984
FUNCTON COLOR LOCATON Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS OEM Alarm Disarm: N/A Dome Lights/Superv: SEE NOTE BELOW **** OEM Horn: N/A Power Lock: N/A Power Unlock: N/A Trunk Release: N/A Alarm nput Wire: SEE NOTE BELOW ****
NOTES: *** Split Parking Light System - must use relays to isolate the circuits from each other.. **** Split System, Front Doors- BROWN/GRAY (-) At Driver Pin Switch, BROWN/GRAY/RED (-) At Passenger Pin Switch. Driver Pin Switch Should Cover Both Doors. Rear Doors- GRAY (+) At Either Rear Pin Switch.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 35 of 120
NOTES: * Diesel Engine. ** All Mercedes Diesel Vehicles Manufactured Between 1983 - 1988 Require A Vacuum Pump Motor Be Added. See Note #240 - Mercedes Vacuum Motor Diagram.
Mercedes-Benz 300TD 1985-1986
FUNCTON COLOR LOCATON Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS OEM Alarm Disarm: N/A Dome Lights/Superv: SEE NOTES BELOW **** OEM Horn: N/A Power Lock: BLUE DRVER'S KCK OR AT VACUUM PUMP ***** Power Unlock: SNGLE WRE SYSTEM DRVER'S KCK OR AT VACUUM PUMP ***** Trunk Release: N/A Alarm nput Wire: SEE NOTES BELOW ****
NOTES: *** Split Parking Light System - must use relays to isolate the circuits from each other.. **** Split System- Front Doors; BROWN/GRAY (-) At Passenger Pin Switch. Rear Doors- '85 300D & CD; BROWN/BLACK (-). 260E, '87 300D E & TD; BROWN/GRAY (-) At Driver Rear Pin Switch Or Rear Dome Light. ***** See Note #210 - Mercedes Vacuum Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 36 of 120
NOTES: * Diagnostic Connector Located On Driver Wheelwell Next To gnition Control Module. ** All Mercedes Diesel Vehicles Manufactured Between 1983 - 1988 Require A Vacuum Pump Motor Be Added. See Note #240 - Mercedes Vacuum Motor Diagram.
Mercedes-Benz 300TD 1987
FUNCTON COLOR LOCATON Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS OEM Alarm Disarm: N/A Dome Lights/Superv: SEE NOTES BELOW **** OEM Horn: N/A Power Lock: BLUE DRVER'S KCK PANEL OR AT PUMP ***** Power Unlock: SNGLE WRE SYTEM DRVER'S KCK PANEL OR AT PUMP ***** Trunk Release: N/A Alarm nput Wire: SEE NOTES BELOW ****
NOTES: *** Split Parking Light System - must use relays to isolate the circuits from each other.. **** Split System- Front Doors; BROWN/GRAY (-) At Passenger Pin Switch. Rear Doors- '85 300D & CD; BROWN/BLACK (-). 260E, '87 300D E & TD; BROWN/GRAY (-) At Driver Rear Pin Switch Or Rear Dome Light. ***** See Note #210 - Mercedes Vacuum Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 37 of 120 Make: Model: Year: Mercedes-Benz 350 Series 1991-1992
FUNCTON COLOR LOCATON Start: VOLET OR VOLET/WHTE GNTON SWTCH HARNESS gnition #1: RED/BLACK OR PNK/RED GNTON SWTCH HARNESS gnition #2: gnition #3: Accessory: Brake Light: N/A Tach Signal: Parking Lights: GRAY/WHTE OR GRAY/YELLOW (+) AT LGHT SWTCH Headlights: N/A Diesel Glow Plug: Clutch Bypass Wire:
NOTES:
Mercedes-Benz 350 Series 1991-1992
FUNCTON COLOR LOCATON Constant +12 Volts: RED GNTON SWTCH HARNESS OEM Alarm Disarm: N/A Dome Lights/Superv: BROWN/WHTE (-) DRVER KCK PANEL OEM Horn: N/A Power Lock: BLUE DRVER'S KCK OR AT VACUUM PUMP * Power Unlock: SNGLE WRE SYSTEM DRVER'S KCK OR AT VACUUM PUMP * Trunk Release: N/A Alarm nput Wire: BROWN/WHTE (-) DRVER KCK PANEL
NOTES: * See Note #210 - Mercedes Vacuum Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 38 of 120
NOTES: All Mercedes Diesel Vehicles Manufactured between 1983 and 1988 *MAY* require a vacuum switch be added. See Note #240 Mercedes Vacuum Motor Diagram. See Note #235 - Powering Extra gnitions Diagram
Mercedes-Benz 380SE 1985
FUNCTON COLOR LOCATON Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS OEM Alarm Disarm: N/A Dome Lights/Superv: FRONT - BROWN/GREEN REAR - BROWN/WHTE (-) AT PN SWTCH OEM Horn: N/A Power Lock: BLUE DRVER'S KCK OR AT VACUUM PUMP ** Power Unlock: SNGLE WRE SYSTEM DRVER'S KCK OR AT VACUUM PUMP ** Trunk Release: N/A Alarm nput Wire: FRONT - BROWN/GREEN REAR - BROWN/WHTE (-) AT PN SWTCH
NOTES: * Split Parking Light System - must use relays to isolate the circuits from each other. ** See Note #210 - Mercedes Vacuum Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 39 of 120
NOTES: All Mercedes Diesel Vehicles Manufactured between 1983 and 1988 *MAY* require a vacuum switch be added. See Note #240 Mercedes Vacuum Motor Diagram.
Mercedes-Benz 380SEL 1982-1983
FUNCTON COLOR LOCATON Constant +12 Volts: RED GNTON SWTCH HARNESS OEM Alarm Disarm: N/A Dome Lights/Superv: FRONT - BROWN/GREEN REAR - BROWN/WHTE (-) AT PN SWTCH OEM Horn: N/A Power Lock: N/A **** Power Unlock: N/A Trunk Release: N/A Alarm nput Wire: FRONT - BROWN/GREEN REAR - BROWN/WHTE (-) AT PN SWTCH
NOTES: * Split Parking Light System - must use relays to isolate the circuits from each other. **** See Note #204 for door lock information
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 40 of 120 Make: Model: Year: Mercedes-Benz 380SL 1982-1983
NOTES: All Mercedes Diesel Vehicles Manufactured between 1983 and 1988 *MAY* require a vacuum switch be added. See Note #240 Mercedes Vacuum Motor Diagram.
Mercedes-Benz 380SL 1982-1983
FUNCTON COLOR LOCATON Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS OEM Alarm Disarm: N/A Dome Lights/Superv: BROWN/GRAY (-) AT PN SWTCH OEM Horn: N/A Power Lock: N/A Power Unlock: N/A Trunk Release: N/A Alarm nput Wire: BROWN/GRAY (-) AT PN SWTCH
NOTES: * Split Parking Light System - must use relays to isolate the circuits from each other..
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 41 of 120
NOTES: All Mercedes Diesel Vehicles Manufactured between 1983 and 1988 *MAY* require a vacuum switch be added. See Note #240 Mercedes Vacuum Motor Diagram. * Diagnostic Connector Located On Top Of Driver Wheelwell.
Mercedes-Benz 380SL 1985
FUNCTON COLOR LOCATON Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS OEM Alarm Disarm: N/A Dome Lights/Superv: BROWN/GRAY (-) PASSENGER PN SWTCH OEM Horn: N/A Power Lock: N/A Power Unlock: N/A Trunk Release: N/A Alarm nput Wire: BROWN/GRAY (-) PASSENGER PN SWTCH
NOTES: * Split Parking Light System - must use relays to isolate the circuits from each other..
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 42 of 120
Make: Model: Year: Mercedes-Benz 400 Series 1988-1992
FUNCTON COLOR LOCATON Start: VOLET/WHTE OR VOLET GNTON SWTCH HARNESS gnition #1: RED/BLACK OR PNK/BLACK - GNTON SWTCH HARNESS gnition #2: RED/YELLOW GNTON SWTCH HARNESS gnition #3: N/A Accessory: N/A Brake Light: N/A Tach Signal: BLACK AT COL OR AT DAGNOSTC PLUG Parking Lights: GRAY/WHTE (DR) & GRAY (PS) (+) AT HEADLGHT SWTCH * Headlights: N/A Diesel Glow Plug: Clutch Bypass Wire:
NOTES: All Mercedes Diesel Vehicles Manufactured between 1983 and 1988 *MAY* require a vacuum switch be added. See Note #240 Mercedes Vacuum Motor Diagram.
Mercedes-Benz 400 Series 1988-1992
FUNCTON COLOR LOCATON Constant +12 Volts: RED GNTON SWTCH HARNESS OEM Alarm Disarm: N/A Dome Lights/Superv: FRONT - BROWN/GRAY REAR - BROWN/GRAY (-) AT PN SWTCH OEM Horn: N/A Power Lock: BLUE DRVER'S KCK OR AT VACUUM PUMP ** Power Unlock: SNGLE WRE SYSTEM DRVER'S KCK OR AT VACUUM PUMP ** Trunk Release: N/A Alarm nput Wire: FRONT - BROWN/GRAY REAR - BROWN/GRAY (-) AT PN SWTCH
NOTES: * Split Parking Light System - must use relays to isolate the circuits from each other.. ** See Note #210 - Mercedes Vacuum Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 43 of 120
400 E 1992 -1993
KEY T-HARNESS MMOBLZER N/A N/A N/A
FUNCTON COLOR LOCATON 12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS STARTER PURPLE (+) GNTON SWTCH HARNESS STARTER 2 N/A GNTON 1 PNK/RED (+) GNTON SWTCH HARNESS GNTON 2 PNK/YELLOW (+) GNTON SWTCH HARNESS GNTON 3 N/A ACCESSORY/HEATER BLOWER 1 PNK/GREEN (+) GNTON SWTCH HARNESS ACCESSORY/HEATER BLOWER 2 N/A KEYSENSE N/A PARKNG LGHTS ( - ) N/A PARKNG LGHTS ( + ) GREEN/WHTE (+) and GRAY (+) Use both, See NOTE *1 @ HEADLGHT SWTCH POWER LOCK BLUE or GREEN, See NOTE *2 POWER UNLOCK Same wire, See NOTE *2 N DRVERS KCK PANEL DOOR TRGGER BROWN/GRAY (-) and BROWN/GRAY/BLACK (-) Use both, See NOTE *3 @ PN SWTCHES DOMELGHT SUPERVSON BROWN/GRAY (-) @ PN SWTCH TRUNK RELEASE N/A SLDNG POWER DOOR N/A HORN BLACK/YELLOW/PNK (+) @ STEERNG COLUMN HARNESS TACH BLACK @ GNTON COL
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 44 of 120 WAT TO START LGHT N/A BRAKE BLACK/RED/WHTE (+) @ SWTCH ABOVE BRAKE PEDAL FACTORY ALARM DSARM GREEN/YELLOW (-) N DRVERS DOOR HARNESS ANT-THEFT N/A
EXTRA NFORMATON NOTE *1 this vehicle has 2 Parking Light wires that will require 2 extra Relays part #775, to connect, . NOTE *2 this vehicle has a Vacuum Door Locking System that will requires 2 extra relays part #775, the wire is a the Drivers kick panel or at the pump under the rear seat, to connect, . These wires are in a BLACK tube comming out of the Drivers Door. NOTE *3 the BROWN/GRAY (-) is at the RGHT PN SWTCH is for the FRONT DOORS, the BROWN/GRAY/BLACK (-) is at the REAR PN SWTCH is for the REAR DOORS When connecting to an ALARM SYSTEM, use both DOOR TRGGER wires and DODE SOLATE. to connect,
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 45 of 120
NOTES: All Mercedes Diesel Vehicles Manufactured between 1983 and 1988 *MAY* require a vacuum switch be added. See Note #240 Mercedes Vacuum Motor Diagram.
Mercedes-Benz 420SEL 1986-1987
FUNCTON COLOR LOCATON Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS OEM Alarm Disarm: N/A Dome Lights/Superv: SEE NOTES BELOW ** OEM Horn: N/A Power Lock: BLUE DRVER'S KCK OR AT VACUUM PUMP *** Power Unlock: SNGLE WRE SYSTEM DRVER'S KCK OR AT VACUUM PUMP *** Trunk Release: N/A Alarm nput Wire: SEE NOTES BELOW **
NOTES: * Split Parking Light System - must use relays to isolate the circuits from each other.. ** Split System, Front Doors- BROWN/GRAY (-) At Passenger Pin Switch Or Front Dome Light. Rear Doors- BROWN/WHTE (-) Or BROWN/GRAY Dots (-) At Driver Rear Pin Switch Or Rear Dome Light. *** See Note #210 - Mercedes Vacuum Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 46 of 120
420 SEL 1988 -1991
KEY T-HARNESS MMOBLZER N/A N/A N/A
FUNCTON COLOR LOCATON 12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS STARTER PURPLE (+) GNTON SWTCH HARNESS STARTER 2 N/A GNTON 1 PNK/BLACK (+) GNTON SWTCH HARNESS GNTON 2 PNK/GREEN (+) GNTON SWTCH HARNESS GNTON 3 N/A ACCESSORY/HEATER BLOWER 1 PNK/YELLOW (+) GNTON SWTCH HARNESS ACCESSORY/HEATER BLOWER 2 N/A KEYSENSE N/A PARKNG LGHTS ( - ) N/A PARKNG LGHTS ( + ) GREEN/WHTE (+) and GRAY (+) Use both, See NOTE *1 @ HEADLGHT SWTCH POWER LOCK BLUE or GREEN, See NOTE *2 POWER UNLOCK Same wire, See NOTE *2 N DRVERS KCK PANEL DOOR TRGGER BROWN/GRAY (-) and BROWN/GRAY/BLACK (-) Use both, See NOTE *3 @ PN SWTCHES DOMELGHT SUPERVSON BROWN/GRAY (-) @ PASSENGERS PN SWTCH TRUNK RELEASE N/A SLDNG POWER DOOR N/A HORN BLACK/PNK (+) @ STEERNG COLUMN HARNESS TACH BLACK @ GNTON COL
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 47 of 120 WAT TO START LGHT N/A BRAKE BLACK/RED (+) @ SWTCH ABOVE BRAKE PEDAL FACTORY ALARM DSARM GREEN/YELLOW (-) @ THEFT MODULE in PASSENGERS footwell ANT-THEFT N/A
EXTRA NFORMATON NOTE *1 this vehicle has 2 Parking Light wires that will require 2 extra Relays part #775, to connect, . NOTE *2 this vehicle has a Vacuum Door Locking System that will requires 2 extra relays part #775, the wire is a the Drivers kick panel or at the pump under the rear seat, to connect, . These wires are in a BLACK tube comming out of the Drivers Door. NOTE *3 the BROWN/GRAY (-) is at the RGHT PN SWTCH is for the FRONT DOORS, the BROWN/GRAY/BLACK (-) is at the REAR PN SWTCH is for the REAR DOORS When connecting to an ALARM SYSTEM, use both DOOR TRGGER wires and DODE SOLATE. to connec,
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 48 of 120
Make: Model: Year: Mercedes-Benz 500 Series 1988-1992
FUNCTON COLOR LOCATON Start: VOLET/WHTE OR VOLET GNTON SWTCH HARNESS gnition #1: RED/BLACK OR PNK/BLACK - GNTON SWTCH HARNESS gnition #2: gnition #3: Accessory: Brake Light: N/A Tach Signal: BLACK AT COL Parking Lights: GRAY/WHTE (DR) & GRAY (PS) (+) AT HEADLGHT SWTCH * Headlights: N/A Diesel Glow Plug: Clutch Bypass Wire:
NOTES: All Mercedes Diesel Vehicles Manufactured between 1983 and 1988 *MAY* require a vacuum switch be added. See Note #240 Mercedes Vacuum Motor Diagram.
Mercedes-Benz 500 Series 1988-1992
FUNCTON COLOR LOCATON Constant +12 Volts: RED GNTON SWTCH HARNESS OEM Alarm Disarm: N/A Dome Lights/Superv: FRONT - BROWN/GRAY REAR - BROWN/GRAY (-) AT PN SWTCH OEM Horn: N/A Power Lock: BLUE DRVER'S KCK OR AT VACUUM PUMP ** Power Unlock: SNGLE WRE SYSTEM DRVER'S KCK OR AT VACUUM PUMP ** Trunk Release: N/A Alarm nput Wire: FRONT - BROWN/GRAY REAR - BROWN/GRAY (-) AT PN SWTCH
NOTES: * Split Parking Light System - must use relays to isolate the circuits from each other.. ** See Note #210 - Mercedes Vacuum Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 49 of 120
500 SEL 1993
KEY T-HARNESS MMOBLZER N/A N/A N/A
FUNCTON COLOR LOCATON 12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS STARTER PURPLE (+) GNTON SWTCH HARNESS STARTER 2 N/A GNTON 1 PNK/GREEN (+) GNTON SWTCH HARNESS GNTON 2 PNK/YELLOW (+) GNTON SWTCH HARNESS GNTON 3 N/A ACCESSORY/HEATER BLOWER 1 PNK/GREEN (+) GNTON SWTCH HARNESS ACCESSORY/HEATER BLOWER 2 N/A KEYSENSE N/A PARKNG LGHTS ( - ) N/A PARKNG LGHTS ( + ) GREEN/WHTE (+) and GRAY (+) Use both, See NOTE *1 @ THEFT MODULE, See NOTE *2 POWER LOCK BLUE/YELLOW (TYPE B) @ THEFT MODULE, See NOTE *2 POWER UNLOCK BLUE/BLACK (TYPE B) @ THEFT MODULE, See NOTE *2 DOOR TRGGER PNK/WHTE (-) and BROWN/WHTE (-) Use BOTH, See NOTE *3 @ THEFT MODULE, See NOTE *2 DOMELGHT SUPERVSON PNK/WHTE (-) @ THEFT MODULE, See NOTE *2 TRUNK RELEASE N/A SLDNG POWER DOOR N/A HORN BLACK/PNK (+) @ STEERNG COLUMN HARNESS
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 50 of 120 TACH BLACK @ GNTON COL WAT TO START LGHT N/A BRAKE BLACK/RED (+) @ SWTCH ABOVE BRAKE PEDAL FACTORY ALARM DSARM BLUE (-) @ THEFT MODULE, See NOTE *2 ANT-THEFT N/A
EXTRA NFORMATON NOTE *1 this vehicle has 2 Parking Light wires that will require 2 extra Relays part #775, to connect, . NOTE *2 the THEFT MODULE is located in the TRUNK on the PASSENGER side. NOTE *3 this vehicle has 2 DOOR TRGGER wires, when connecting to an ALARM SYSTEM use both DOOR TRGGER wires and DODE SOLATE, to connect, .
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 51 of 120
500 SL 1991
KEY T-HARNESS MMOBLZER N/A N/A N/A
FUNCTON COLOR LOCATON 12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS STARTER PURPLE (+) GNTON SWTCH HARNESS STARTER 2 N/A GNTON 1 PNK/RED (+) GNTON SWTCH HARNESS GNTON 2 PNK/BLACK (+) (Small wire) GNTON SWTCH HARNESS GNTON 3 N/A ACCESSORY/HEATER BLOWER 1 PNK/YELLOW (+) GNTON SWTCH HARNESS ACCESSORY/HEATER BLOWER 2 N/A KEYSENSE N/A PARKNG LGHTS ( - ) N/A PARKNG LGHTS ( + ) GREEN/WHTE (+) and GRAY (+) Use both, See NOTE *1 @ HEADLGHT SWTCH POWER LOCK BLUE or GREEN, See NOTE *2 POWER UNLOCK Same wire, See NOTE *2 N DRVERS KCK PANEL DOOR TRGGER GREY/WHTE (-) @ PASSENGERS PN SWTCH DOMELGHT SUPERVSON USE DOOR TRGGER TRUNK RELEASE N/A SLDNG POWER DOOR N/A HORN BLACK/YELLOW (+) @ STEERNG COLUMN HARNESS TACH BLACK @ DAGNOSTC CONNECTOR, behind drivers HEADLGHT
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 52 of 120 WAT TO START LGHT N/A BRAKE BLACK/RED (+) @ SWTCH ABOVE BRAKE PEDAL FACTORY ALARM DSARM WHTE (-) @ THEFT MODULE in TRUNK next to POWER ANTENNA ANT-THEFT N/A
EXTRA NFORMATON NOTE *1 this vehicle has 2 Parking Light wires that will require 2 extra Relays part #775, to connect, . NOTE *2 this vehicle has a Vacuum Door Locking System that will requires 2 extra relays part #775, the wire is a the Drivers kick panel or at the pump under the rear seat, to connect, . These wires are in a BLACK tube comming out of the Drivers Door.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 53 of 120
500 SL 1992
KEY T-HARNESS MMOBLZER N/A N/A N/A
FUNCTON COLOR LOCATON 12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS STARTER PURPLE (+) GNTON SWTCH HARNESS STARTER 2 N/A GNTON 1 PURPLE/RED (+) GNTON SWTCH HARNESS GNTON 2 PNK/YELLOW (+) GNTON SWTCH HARNESS GNTON 3 N/A ACCESSORY/HEATER BLOWER 1 PNK/GREEN (+) GNTON SWTCH HARNESS ACCESSORY/HEATER BLOWER 2 N/A KEYSENSE N/A PARKNG LGHTS ( - ) N/A PARKNG LGHTS ( + ) GREEN/RED (+) and GRAY (+) Use both, See NOTE *1 @ HEADLGHT SWTCH POWER LOCK BLUE or GREEN, See NOTE *2 POWER UNLOCK Same wire, See NOTE *2 N DRVERS KCK PANEL DOOR TRGGER BROWN/GRAY (-) @ PASSENGERS PN SWTCH DOMELGHT SUPERVSON USE DOOR TRGGER TRUNK RELEASE N/A SLDNG POWER DOOR N/A HORN BLACK/YELLOW (+) @ STEERNG COLUMN HARNESS TACH BLACK @ DAGNOSTC CONNECTOR or GNTON COL WAT TO START LGHT N/A BRAKE BLACK/RED (+) @ SWTCH ABOVE BRAKE PEDAL FACTORY ALARM DSARM WHTE (-) N PASSENGERS KCK PANEL ANT-THEFT N/A
EXTRA NFORMATON NOTE *1 this vehicle has 2 Parking Light wires that will require 2 extra Relays part #775, to connect, . NOTE *2 this vehicle has a Vacuum Door Locking System that will requires 2 extra relays part #775, the wire is a the Drivers kick panel or at the pump under the rear seat, to connect, . These wires are in a BLACK tube comming out of the Drivers Door.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 54 of 120
NOTES: All Mercedes Diesel Vehicles Manufactured between 1983 and 1988 *MAY* require a vacuum switch be added. See Note #240 Mercedes Vacuum Motor Diagram.
Mercedes-Benz 560SEC 1986-1991
FUNCTON COLOR LOCATON Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS OEM Alarm Disarm: N/A Dome Lights/Superv: SEE NOTES BELOW ** OEM Horn: N/A Power Lock: BLUE DRVER'S KCK OR AT VACUUM PUMP *** Power Unlock: SNGLE WRE SYSTEM DRVER'S KCK OR AT VACUUM PUMP *** Trunk Release: N/A Alarm nput Wire: SEE NOTES BELOW **
NOTES: * Split Parking Light System - must use relays to isolate the circuits from each other.. ** Split System, Front Doors- BROWN/GRAY (-) At Passenger Pin Switch Or At Dome Light. Rear Doors- BROWN/WHTE (-) Or BROWN/GRAY Dots (-) At Driver Rear Pin Switch Or Rear Dome Light. *** See Note #210 - Mercedes Vacuum Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 55 of 120
NOTES: All Mercedes Diesel Vehicles Manufactured between 1983 and 1988 *MAY* require a vacuum switch be added. See Note #240 Mercedes Vacuum Motor Diagram.
Mercedes-Benz 560SEL 1986-1991
FUNCTON COLOR LOCATON Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS OEM Alarm Disarm: N/A Dome Lights/Superv: SEE NOTES BELOW ** OEM Horn: N/A Power Lock: BLUE DRVER'S KCK OR AT VACUUM PUMP *** Power Unlock: SNGLE WRE SYSTEM DRVER'S KCK OR AT VACUUM PUMP *** Trunk Release: N/A Alarm nput Wire: SEE NOTES BELOW **
NOTES: * Split Parking Light System - must use relays to isolate the circuits from each other.. ** Split System, Front Doors- BROWN/GRAY (-) At Passenger Pin Switch Or At Dome Light. Rear Doors- BROWN/WHTE (-) Or BROWN/GRAY Dots (-) At Driver Rear Pin Switch Or Rear Dome Light. *** See Note #210 - Mercedes Vacuum Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 56 of 120
Make: Model: Year: Mercedes-Benz 560SL 1986-1991
FUNCTON COLOR LOCATON Start: VOLET/WHTE GNTON SWTCH HARNESS gnition #1: RED/BLACK GNTON SWTCH HARNESS gnition #2: RED/YELLOW GNTON SWTCH HARNESS gnition #3: N/A Accessory: N/A Brake Light: N/A Tach Signal: BLACK AT COL OR GREEN AT DAGNOSTC PLUG Parking Lights: GRAY/WHTE (DR) & GRAY (PS) (+) AT HEADLGHT SWTCH * Headlights: N/A Diesel Glow Plug: Clutch Bypass Wire:
NOTES: All Mercedes Diesel Vehicles Manufactured between 1983 and 1988 *MAY* require a vacuum switch be added. See Note #240 Mercedes Vacuum Motor Diagram.
Mercedes-Benz 560SL 1986-1991
FUNCTON COLOR LOCATON Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS OEM Alarm Disarm: N/A Dome Lights/Superv: BROWN/GRAY (-) PASSENGER PN SWTCH OEM Horn: N/A Power Lock: BLUE DRVER'S KCK OR AT VACUUM PUMP ** Power Unlock: SNGLE WRE SYSTEM DRVER'S KCK OR AT VACUUM PUMP ** Trunk Release: N/A Alarm nput Wire: BROWN/GRAY (-) PASSENGER PN SWTCH
NOTES: * Split Parking Light System - must use relays to isolate the circuits from each other.. ** See Note #210 - Mercedes Vacuum Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 57 of 120
Make: Model: Year: Mercedes-Benz C CIass 1994-1997
FUNCTON COLOR LOCATON Start: VOLET GNTON SWTCH HARNESS gnition #1: PNK/RED GNTON SWTCH HARNESS gnition #2: PNK/GREEN GNTON SWTCH HARNESS gnition #3: N/A Accessory: PNK/YELLOW GNTON SWTCH HARNESS Brake Light: BLACK/RED AT SWTCH ABOVE BRAKE PEDAL Tach Signal: GREEN/YELLOW CONNECTOR TO LEFT OF BRAKE PEDAL * Parking Lights: DRVER - GRAY/WHTE PASS. - GRAY AT HEADLGHT SWTCH ** Headlights: WHTE/YELLOW (+) AT HEADLGHT SWTCH Diesel Glow Plug: Clutch Bypass Wire:
NOTES: WE RECOMMEND NSTALLATON BY HGH LEVEL PROFESSONAL NSTALLERS ONLY. * Tach Also Found At ECM Located n The Rear Of The Passenger Side Engine Compartment.
Mercedes-Benz C CIass 1994-1997
FUNCTON COLOR LOCATON Constant +12 Volts: RED GNTON SWTCH HARNESS OEM Alarm Disarm: N/A Dome Lights/Superv: FRONT - BROWN/GRAY REAR - BROWN/GRAY/YELLOW DOTS BOTH(-) OEM Horn: BLACK OR BROWN/BLACK (-) STEERNG COLUMN HARNESS Power Lock: BLACK DRVER'S KCK PANEL *** Power Unlock: BLUE DRVER'S KCK PANEL *** Trunk Release: VOLET AT TRUNK RELEASE SWTCH Alarm nput Wire: FRONT - BROWN/GRAY REAR - BROWN/GRAY/YELLOW DOTS BOTH(-)
NOTES: ** Split Parking Light System - must use relays to isolate the circuits from each other.. Diode solate Each Wire. *** See Note #201 - Negative Pulse Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 58 of 120
Make: Model: Year: Mercedes-Benz C CIass 1998-2000
NOTES: THS S A DFFCULT VEHCLE. WE RECOMMEND NSTALLATON BE PERFORMED ONLY BY HGH LEVEL PROFESSONAL NSTALLERS. MAY BE EQUPPED WTH A TRANSPONDER. THE R TRANSPONDER CAN NOT BE BYPASSED AT THS TME. SEE Note #144 FOR RF BASED TRANSPONDERS.
Mercedes-Benz C CIass 1998-2000
FUNCTON COLOR LOCATON Constant +12 Volts: RED GNTON SWTCH HARNESS OEM Alarm Disarm: WHTE/GREEN Dome Lights/Superv: BROWN/GRAY & BROWN/PNK AT BCM N MDDLE TRUNK, DODE SOLATE BOTH OEM Horn: BLACK (-) STEERNG COLUMN HARNESS Power Lock: BLACK (-) N DRVER'S OR PASSANGER KCK PANEL** Power Unlock: BLUE (-) N DRVER'S OR PASSANGER KCK PANEL Trunk Release: VOLET (-) SWTCH N CONSOLE Alarm nput Wire: BROWN/GRAY & BROWN/PNK AT BCM N MDDLE TRUNK, DODE SOLATE BOTH
NOTES: ** See Note #201 Negative trigger door locks.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 59 of 120
Make: Model: Year: Mercedes-Benz C CIass 2001-2003
NOTES: WE RECOMMENDED NSTALLATON BY HGH LEVEL PROFESSONAL NSTALLERS ONLY! *Transponder Anti-Theft system. RF transponder can be bypassed with Universal Alarm Bypass Module. nfrared transponder can not be bypassed at this time.
Mercedes-Benz C CIass 2001-2003
FUNCTON COLOR LOCATON Constant +12 Volts: RED/PURPLE (20 AMP) GNTON SWTCH HARNESS OEM Alarm Disarm: BLUE DRVERS KCK PANEL Dome Lights/Superv: SEE NOTE BELOW* OEM Horn: BLACK/WHTE (+) AT HORN Power Lock: Black Driver Kick Panel Power Unlock: Blue Driver Kick Panel Trunk Release: BLACK (-) DRVER'S DOOR MODULE Alarm nput Wire: SEE NOTE BELOW*
NOTES: * Alarm trigger/Dome light supervision will be a BROWN/GRAY for the front doors, BROWN/PNK for the rear doors. These wires located at the BCM in the middle of the trunk.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 60 of 120
C 220 1994 -1996
KEY T-HARNESS MMOBLZER N/A N/A N/A
FUNCTON COLOR LOCATON 12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS See NOTE *1 STARTER PURPLE (+) GNTON SWTCH HARNESS See NOTE *1 STARTER 2 N/A GNTON 1 PNK/RED (+) GNTON SWTCH HARNESS See NOTE *1 GNTON 2 PNK/GREEN (+) GNTON SWTCH HARNESS See NOTE *1 GNTON 3 N/A ACCESSORY/HEATER BLOWER 1 PNK/YELLOW (+) GNTON SWTCH HARNESS See NOTE *1 ACCESSORY/HEATER BLOWER 2 N/A KEYSENSE N/A PARKNG LGHTS ( - ) N/A PARKNG LGHTS ( + ) GRAY (+) and GRAY/WHTE (+) use both, See NOTE *2 @ HEADLGHT SWTCH or bleow FUSE BOX POWER LOCK BLACK (TYPE B) N ETHER KCK PANEL See NOTE *3 POWER UNLOCK BLUE (TYPE B) N ETHER KCK PANEL See NOTE *3 DOOR TRGGER BROWN/GRAY (-) and BROWN/GRAY/YELLOW(-) Use both, See NOTE *4 @ DOOR PN SWTCHES or THEFT MODULE DOMELGHT SUPERVSON BROWN/GRAY (-) @ PASSENGER DOOR PN SWTCH TRUNK RELEASE N/A
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 61 of 120 SLDNG POWER DOOR N/A HORN N/A TACH GREEN/YELLOW @ Connector LEFT of BRAKE PEDAL WAT TO START LGHT N/A BRAKE BLACK/RED (+) @ SWTCH ABOVE BRAKE PEDAL FACTORY ALARM DSARM DSARMS WTH UNLOCK ANT-THEFT N/A
EXTRA NFORMATON NOTE *1 the GNTON HARNESS is accessible at the BOTTOM of the FUSE BOX, pull the fuse box up into the cowling area to get at the wire harness. NOTE: use the PURPLE/GREEN (+) wire to bypass the Factory Starter Kill for Remote Starter nstallation. NOTE *2 this vehicle has 2 Parking Light wires, it will require 2 extra Relays part #775, to connect, . NOTE *3 on base vehicles WTHOUT a FACTORY ALARM, the Lock and Unlock wires when using GNTON CONTROLLED DOOR LOCKS will cause the Factory Starter Kill to engage. DO NOT USE the GNTON CONTROLLED DOOR LOCKNG programs on this vehicle. NOTE *4 the BROWN/GRAY (-) at the PASSENGER DOOR PN SWTCH is for the FRONT DOORS and the BROWN/GRAY/YELLOW (-) at the REAR DOORS. These wires are also at the THEFT MODULE in the trunk. When connecting to an ALARM SYSTEM, use both DOOR TRGGER wires and DODE SOLATE, to connect, .
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 62 of 120
C 230 1997
KEY T- HARNES S MMOBLZER N/A N/A MERCEDES TRANSPONDER ANT-THEFT SYSTEM, Requires Bypass Module and extra gnition Key
FUNCTON COLOR LOCATON 12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS See NOTE *1 STARTER PURPLE (+) GNTON SWTCH HARNESS See NOTE *1 STARTER 2 N/A GNTON 1 PNK/RED (+) GNTON SWTCH HARNESS See NOTE *1 GNTON 2 PNK/GREEN (+) GNTON SWTCH HARNESS See NOTE *1 GNTON 3 N/A ACCESSORY/HEATER BLOWER 1 PNK/YELLOW (+) GNTON SWTCH HARNESS See NOTE *1 ACCESSORY/HEATER BLOWER 2 N/A KEYSENSE N/A PARKNG LGHTS ( - ) N/A PARKNG LGHTS ( + ) GRAY (+) and GRAY/WHTE (+) Use both, See NOTE *2 @ HEADLGHT SWTCH or below FUSE BOX, POWER LOCK BLACK (TYPE B) N ETHER KCK PANEL, See NOTE *3 POWER UNLOCK BLUE (TYPE B) N ETHER KCK PANEL, See NOTE *3 DOOR TRGGER BROWN/GRAY (-) and BROWN/GRAY/YELLOW (-) USE BOTH, See NOTE *4 @ PASSENGERS PN SWTCHES or THEFT MODULE DOMELGHT SUPERVSON BROWN/GRAY (-) @ PASSENGER DOOR PN SWTCH
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 63 of 120 TRUNK RELEASE N/A SLDNG POWER DOOR N/A HORN N/A TACH GREEN/YELLOW @ Connector LEFT of BRAKE PEDAL WAT TO START LGHT N/A BRAKE BLACK/RED (+) @ SWTCH ABOVE BRAKE PEDAL FACTORY ALARM DSARM DSARMS WTH UNLOCK ANT-THEFT TRANSPONDER ANT-THEFT SYSTEM, REQURES BYPASS MODULE AND EXTRA GNTON KEY TRANSPONDER @ GNTON SWTCH TUMBLER
EXTRA NFORMATON NOTE *1 the GNTON HARNESS is accessible at the BOTTOM of the FUSE BOX, pull the fuse box up into the cowling area to get at the wire harness. NOTE: use the PURPLE/GREEN (+) wire to bypass the Factory Starter Kill for Remote Starter nstallation. NOTE *2 this vehicle has 2 Parking Light wires, it will require 2 extra Relays part #775, to connect, . NOTE *3 on base vehicles WTHOUT a FACTORY ALARM, the Lock and Unlock wires when using GNTON CONTROLLED DOOR LOCKS will cause the Factory Starter Kill to engage. DO NOT USE the GNTON CONTROLLED DOOR LOCKNG programs on this vehicle. NOTE *4 this vehicle has 2 DOOR TRGGER wires, when connecting to an ALARM SYSTEM use both DOOR TRGGER wires and DODE SOLATE, to connect, .
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 64 of 120
C 230 1998 -2000
KEY T- HARNES S MMOBLZER N/A N/A MERCEDES TRANSPONDER ANT-THEFT SYSTEM, Requires Bypass Module and extra gnition Key
FUNCTON COLOR LOCATON 12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS STARTER PURPLE (+) GNTON SWTCH HARNESS STARTER 2 N/A GNTON 1 PNK/RED (+) GNTON SWTCH HARNESS GNTON 2 PNK/YELLOW (+) GNTON SWTCH HARNESS GNTON 3 N/A ACCESSORY/HEATER BLOWER 1 PNK/GREEN (+) GNTON SWTCH HARNESS ACCESSORY/HEATER BLOWER 2 N/A KEYSENSE N/A PARKNG LGHTS ( - ) N/A PARKNG LGHTS ( + ) GRAY (+) and GRAY/WHTE (+) Use both, See NOTE *1 @ HEADLGHT SWTCH POWER LOCK BLACK (TYPE B) @ DRVERS DOOR MODULE, See NOTE *2 POWER UNLOCK BLUE (TYPE B) @ DRVERS DOOR MODULE, See NOTE *2 DOOR TRGGER See NOTE *3 @ EACH PN SWTCH or THEFT MODULE, See NOTE *3 DOMELGHT SUPERVSON BROWN/GRAY (-) @ DRVERS PN SWTCH TRUNK RELEASE YELLOW (-) @ TRUNK RELEASE SWTCH or THEFT MODULE See NOTE *2 SLDNG POWER DOOR N/A
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 65 of 120 HORN N/A TACH BLACK or BLACK/WHTE @ GNTON COL PACK WAT TO START LGHT N/A BRAKE BLACK/RED (+) @ SWTCH ABOVE BRAKE PEDAL FACTORY ALARM DSARM DSARMS WTH UNLOCK ANT-THEFT TRANSPONDER ANT-THEFT SYSTEM, REQURES BYPASS MODULE AND EXTRA GNTON KEY, See NOTE *4 TRANSPONDER @ GNTON SWTCH TUMBLER
EXTRA NFORMATON NOTE *1 this vehicle has 2 Parking Light wires, it will require 2 extra Relays part #775, to connect, . NOTE *2 these wires can also be found at the THEFT MODULE which is part of the Pneumatic system Equipment Control Module in the Trunk on the Passenger side. NOTE *3 the DRVERS DOOR is a BROWN/GRAY (-) the PASSENGER DOOR is a BROWN/BLUE (-) the DRVERS REAR DOOR is a BROWN/GREEN (-) and the PASSENGER REAR DOOR is a BROWN/WHTE (-) when connecting to an ALARM SYSTEM, use all 4 DOOR TRGGER wires and DODE SOLATE, to connect, NOTE *4 SECURTY BYPASS MODULE will ONLY WORK with vehicles that have a SWTCHBLADE KEY, on vehicles with the SMART KEY a bypass is not available.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 66 of 120
C 280 1994 -1997
KEY T-HARNESS MMOBLZER N/A N/A N/A
FUNCTON COLOR LOCATON 12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS See NOTE *1 STARTER PURPLE (+) GNTON SWTCH HARNESS See NOTE *1 STARTER 2 N/A GNTON 1 PNK/RED (+) GNTON SWTCH HARNESS See NOTE *1 GNTON 2 PNK/GREEN (+) GNTON SWTCH HARNESS See NOTE *1 GNTON 3 N/A ACCESSORY/HEATER BLOWER 1 N/A ACCESSORY/HEATER BLOWER 2 PNK/YELLOW (+) GNTON SWTCH HARNESS See NOTE *1 KEYSENSE N/A PARKNG LGHTS ( - ) N/A PARKNG LGHTS ( + ) GRAY (+) and GRAY/WHTE (+) Use both, See NOTE *2 @ HEADLGHT SWTCH or below FUSE BOX POWER LOCK BLACK (TYPE B) N ETHER KCK PANEL, See NOTE *3 POWER UNLOCK BLUE (TYPE B) N ETHER KCK PANEL, See NOTE *3 DOOR TRGGER BROWN/GRAY (-) and BROWN/GRAY/YELLOW (-) USE BOTH, See NOTE *4 @ PASNEGER PN SWTCHES or THEFT MODULE DOMELGHT SUPERVSON BROWN/GRAY (-) @ PASSENGER DOOR PN SWTCH TRUNK RELEASE N/A
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 67 of 120 SLDNG POWER DOOR N/A HORN N/A TACH GREEN/YELLOW @ Connector LEFT of BRAKE PEDAL WAT TO START LGHT N/A BRAKE BLACK/RED (+) @ SWTCH ABOVE BRAKE PEDAL FACTORY ALARM DSARM DSARMS WTH UNLOCK ANT-THEFT N/A
EXTRA NFORMATON NOTE *1 the GNTON HARNESS is accessible at the BOTTOM of the FUSE BOX, pull the fuse box up into the cowling area to get at the wire harness. NOTE: use the PURPLE/GREEN (+) wire to bypass the Factory Starter Kill for Remote Starter nstallation. NOTE *2 this vehicle has 2 Parking Light wires, it will require 2 extra Relays part #775, to connect, . NOTE *3 on base vehicles WTHOUT a FACTORY ALARM, the Lock and Unlock wires when using GNTON CONTROLLED DOOR LOCKS will cause the Factory Starter Kill to engage. DO NOT USE the GNTON CONTROLLED DOOR LOCKNG programs on this vehicle. NOTE *4 this vehicle has 2 DOOR TRGGER wires, when connecting to an ALARM SYSTEM use both DOOR TRGGER wires and DODE SOLATE, to connect, .
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 68 of 120
C 280 1998 -2000
KEY T- HARNES S MMOBLZER N/A N/A MERCEDES TRANSPONDER ANT-THEFT SYSTEM, Requires Bypass Module and extra gnition Key
FUNCTON COLOR LOCATON 12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS STARTER PURPLE (+) GNTON SWTCH HARNESS STARTER 2 N/A GNTON 1 PNK/RED (+) GNTON SWTCH HARNESS GNTON 2 PNK/YELLOW (+) GNTON SWTCH HARNESS GNTON 3 N/A ACCESSORY/HEATER BLOWER 1 PNK/GREEN (+) GNTON SWTCH HARNESS ACCESSORY/HEATER BLOWER 2 N/A KEYSENSE N/A PARKNG LGHTS ( - ) N/A PARKNG LGHTS ( + ) GRAY (+) and GRAY/WHTE (+) Use both, See NOTE *1 @ HEADLGHT SWTCH POWER LOCK BLACK (TYPE B) @ DRVERS DOOR MODULE, See NOTE *2 POWER UNLOCK BLUE (TYPE B) @ DRVERS DOOR MODULE, See NOTE *2 DOOR TRGGER See NOTE *3 @ EACH PN SWTCH or THEFT MODULE, See NOTE *2 DOMELGHT SUPERVSON BROWN/GRAY (-) @ DRVERS PN SWTCH TRUNK RELEASE YELLOW (-) @ TRUNK RELEASE SWTCH or THEFT MODULE, See NOTE *2 SLDNG POWER DOOR N/A
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 69 of 120 HORN N/A TACH ANY wire NOT BLACK/YELLOW or BLACK/GREEN @ GNTON COL PACK WAT TO START LGHT N/A BRAKE BLACK/RED (+) @ SWTCH ABOVE BRAKE PEDAL FACTORY ALARM DSARM DSARMS WTH UNLOCK ANT-THEFT TRANSPONDER ANT-THEFT SYSTEM, REQURES BYPASS MODULE AND EXTRA GNTON KEY, See NOTE *4 TRANSPONDER @ GNTON SWTCH TUMBLER
EXTRA NFORMATON NOTE *1 this vehicle has 2 Parking Light wires, it will require 2 extra Relays part #775 to connect, . NOTE *2 these wires can also be found at the THEFT MODULE which is part of the Pneumatic system Equipment Control Module in the Trunk on the Passenger side. NOTE *3 the DRVERS DOOR is a BROWN/GRAY (-) the PASSENGER DOOR is a BROWN/BLUE (-) the DRVERS REAR DOOR is a BROWN/GREEN (-) and the PASSENGER REAR DOOR is a BROWN/WHTE (-) when connecting to an ALARM SYSTEM, use all 4 DOOR TRGGER wires and DODE SOLATE, to connect, . NOTE *4 SECURTY BYPASS MODULE will ONLY WORK with vehicles that have a SWTCHBLADE KEY, on vehicles with the SMART KEY a bypass is not available.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 70 of 120
CL CLASS 1998 -1999
KEY T- HARNES S MMOBLZER N/A N/A MERCEDES TRANSPONDER ANT-THEFT SYSTEM, Requires Bypass Module and extra gnition Key
FUNCTON COLOR LOCATON 12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS STARTER PURPLE (+) GNTON SWTCH HARNESS STARTER 2 N/A GNTON 1 PNK/YELLOW (+) GNTON SWTCH HARNESS GNTON 2 N/A GNTON 3 N/A ACCESSORY/HEATER BLOWER 1 N/A ACCESSORY/HEATER BLOWER 2 N/A KEYSENSE N/A PARKNG LGHTS ( - ) N/A PARKNG LGHTS ( + ) GRAY/PURPLE (+) and GRAY/RED (+) USE BOTH, See NOTE *1 @ HEADLGHT SWTCH POWER LOCK BLUE/YELLOW (TYPE B) N DRVERS KCK PANEL POWER UNLOCK BLUE/BLACK (TYPE B) N DRVERS KCK PANEL DOOR TRGGER BROWN/WHTE (-) N DRVERS KCK PANEL DOMELGHT SUPERVSON USE DOOR TRGGER TRUNK RELEASE N/A SLDNG POWER DOOR N/A HORN N/A TACH BLUE/YELLOW @ ANY FUEL-NJECTOR WAT TO START LGHT N/A BRAKE BLACK/RED (+) @ SWTCH ABOVE BRAKE PEDAL FACTORY ALARM DSARM DSARMS WTH UNLOCK ANT-THEFT TRANSPONDER ANT-THEFT SYSTEM, REQURES BYPASS MODULE AND EXTRA GNTON KEY, See NOTE *2 TRANSPONDER @ GNTON SWTCH TUMBLER
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 71 of 120 EXTRA NFORMATON NOTE *1 this vehicle has 2 Parking Light wires, it will require 2 extra Relays Part #775 to connect, . NOTE *2 SECURTY BYPASS MODULE will ONLY WORK with vehicles that have a SWTCHBLADE KEY, on vehicles with the SMART KEY a bypass is not available.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 72 of 120
CLK CLASS 1998 -2000
KEY T- HARNES S MMOBLZER N/A N/A MERCEDES TRANSPONDER ANT-THEFT SYSTEM, Requires Bypass Module and extra gnition Key
FUNCTON COLOR LOCATON 12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS STARTER PURPLE (+) GNTON SWTCH HARNESS STARTER 2 N/A GNTON 1 PNK/RED (+) GNTON SWTCH HARNESS GNTON 2 PNK/YELLOW (+) GNTON SWTCH HARNESS GNTON 3 N/A ACCESSORY/HEATER BLOWER 1 PNK/GREEN (+) GNTON SWTCH HARNESS ACCESSORY/HEATER BLOWER 2 N/A KEYSENSE N/A PARKNG LGHTS ( - ) N/A PARKNG LGHTS ( + ) GRAY/RED (+) and GRAY/BLACK (+) use both, See NOTE *1 @ LLUMNATON CONTROL MODULE, POWER LOCK BLACK (TYPE B) @ DRVERS DOOR MODULE, See NOTE *2 POWER UNLOCK BLUE (TYPE B) @ DRVERS DOOR MODULE, See NOTE *2 DOOR TRGGER BROWN/GRAY (-) and BROWN/BLUE (-) use both, See NOTE *3 @ EACH PN SWTCH or THEFT MODULE, See NOTE *2 DOMELGHT SUPERVSON TURNS ON with UNLOCK TRUNK RELEASE YELLOW (-) @ TRUNK RELEASE SWTCH or THEFT MODULE, See NOTE *2
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 73 of 120 SLDNG POWER DOOR N/A HORN N/A TACH ANY wire NOT BLACK/YELLOW or BLACK/GREEN @ GNTON COL PACK WAT TO START LGHT N/A BRAKE BLACK or BLACK/WHTE (+) @ SWTCH ABOVE BRAKE PEDAL FACTORY ALARM DSARM DSARMS WTH UNLOCK ANT-THEFT TRANSPONDER ANT-THEFT SYSTEM, REQURES BYPASS MODULE AND EXTRA GNTON KEY, See NOTE *4 TRANSPONDER @ GNTON SWTCH TUMBLER
EXTRA NFORMATON NOTE *1 this vehicle has 2 Parking Light wires, it will require 2 extra Relays to isolate, . You will need 2 relays one for each wire. The LLUMNATON CONTROL MODULE is attached to the back of the HEADLGHT SWTCH. NOTE *2 these wires can also be found at the THEFT MODULE which is part of the Pneumatic system Equipment Control Module in the Trunk on the Passenger side. NOTE *3 the DRVERS DOOR is a BROWN/GRAY (-) the PASSENGER DOOR is a BROWN/BLUE (-) when connecting to an ALARM SYSTEM use both DOOR TRGGER wires and DODE SOLATE, to connect, . NOTE *4 SECURTY BYPASS MODULE will ONLY WORK with vehicles that have a SWTCHBLADE KEY, on vehicles with the SMART KEY a bypass is not available.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 74 of 120
FUNCTON COLOR LOCATON Constant +12 Volts: RED GNTON SWTCH HARNESS OEM Alarm Disarm: BLUE DRVER'S KCK PANEL Dome Lights/Superv: GRAY/BLACK & GRAY/RED AT HEADLGHT SWTCH - BOTH (+) OEM Horn: BLACK/YELLOW/RED (+) AT O.E.M. ALARM N TRUNK Power Lock: BLUE/YELLOW DRVER'S KCK PANEL ** Power Unlock: BLUE/BLACK DRVER'S KCK PANEL ** Trunk Release: N/A Alarm nput Wire: GRAY/BLACK & GRAY/RED AT HEADLGHT SWTCH - BOTH (+)
NOTES: * Split Parking Light System - must use relays to isolate the circuits from each other.. ** See Note #201 - Negative Pulse Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 75 of 120
E CLASS 1997 -2002
KEY T- HARNES S MMOBLZER N/A N/A MERCEDES TRANSPONDER ANT-THEFT SYSTEM, Requires Bypass Module and extra gnition Key
FUNCTON COLOR LOCATON 12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS STARTER PURPLE (+) GNTON SWTCH HARNESS STARTER 2 N/A GNTON 1 PNK/RED (+) GNTON SWTCH HARNESS GNTON 2 PNK/YELLOW (+) GNTON SWTCH HARNESS GNTON 3 N/A ACCESSORY/HEATER BLOWER 1 PNK/GREEN (+) GNTON SWTCH HARNESS ACCESSORY/HEATER BLOWER 2 N/A KEYSENSE N/A PARKNG LGHTS ( - ) N/A PARKNG LGHTS ( + ) GRAY/BLACK (+) and GRAY/RED (+) use both, See NOTE *1 @ LLUMNATON CONTROL MODULE, POWER LOCK BLACK or BROWN/BLACK (TYPE B) See NOTE *2 N PASSENGER KCK PANEL POWER UNLOCK BLUE or BLUE/GREEN (TYPE B) See NOTE *2 N PASSENGER KCK PANEL DOOR TRGGER See NOTE *4 @ PSE Control Module, See NOTE *3 DOMELGHT SUPERVSON GRAY/BLACK (-) @ PSE Control Module, See NOTE *3 TRUNK RELEASE PURPLE (-) @ TRUNK RELEASE SWTCH SLDNG POWER DOOR N/A
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 76 of 120 HORN YELLOW/RED (+) @ HORN TACH ANY wire with a BLACK STRPE on it @ any GNTON COL WAT TO START LGHT N/A BRAKE BLACK/PURPLE (+) @ SWTCH ABOVE BRAKE PEDAL FACTORY ALARM DSARM DSARMS WTH UNLOCK ANT-THEFT TRANSPONDER ANT-THEFT SYSTEM, REQURES BYPASS MODULE AND EXTRA GNTON KEY See NOTE *5 TRANSPONDER @ GNTON SWTCH TUMBLER
EXTRA NFORMATON NOTE *1 the LLUMNATON CONTROL MODULE ia attached to the back of the Headlight Switch to connect, you will need 2 relays Part #775, one for each parking light wire. NOTE *2 to test these wires, you must incert the key in the Passenger Key Cylinder and Lock and Unlock for testing. NOTE *3 the PSE Control Module is located under the Rear Seat on the Passenger side of the vehicle. NOTE *4 the DRVERS DOOR is a BROWN/GREY (-) the PASSENGER DOOR is a BROWN/RED (- ), the DRVERS REAR DOOR is a BROWN/GREEN (-) and the PASSENGERS REAR DOOR is a BROWN/BLACK (-) When connecting to an ALARM SYSTEM, use all 4 DOOR TRGGER wires and DODE SOLATE, to connect, NOTE *5 the Bypass Module will ONLY work on vehicle that use the SWTCHBLADE KEY, on vehicles with the SMART KEY the bypass will not work.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 77 of 120
Make: Model: Year: Mercedes-Benz E300 1995
FUNCTON COLOR LOCATON Start: VOLET GNTON SWTCH HARNESS gnition #1: PNK/RED GNTON SWTCH HARNESS gnition #2: PNK/YELLOW GNTON SWTCH HARNESS gnition #3: GNTON SWTCH HARNESS Accessory: PNK/GREEN GNTON SWTCH HARNESS Brake Light: BLACK/RED AT SWTCH ABOVE BRAKE PEDAL Tach Signal: GREEN/YELLOW LEFT OF STEERNG COL. N MAN HARNESS Parking Lights: GRAY/WHTE AND GRAY AT LGHT SWTCH *** Headlights: Diesel Glow Plug: Clutch Bypass Wire:
NOTES:
Mercedes-Benz E300 1995
FUNCTON COLOR LOCATON Constant +12 Volts: RED GNTON SWTCH HARNESS OEM Alarm Disarm: Dome Lights/Superv: BROWN/GRAY (FRONT) BROWN/GRAY/YELLOW (REAR) ** OEM Horn: Power Lock: BLUE OR GREEN DRVER'S KCK PANEL OR AT** Power Unlock: BLUE OR GREEN VACUUM PUMP MOTOR Trunk Release: Alarm nput Wire: BROWN/GRAY (FRONT) BROWN/GRAY/YELLOW (REAR) **
NOTES: ** See Note #210 Vacuum Door Locks
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 78 of 120
FUNCTON COLOR LOCATON Constant +12 Volts: RED GNTON SWTCH HARNESS OEM Alarm Disarm: Dome Lights/Superv:
OEM Horn: Power Lock: Power Unlock: Trunk Release: Alarm nput Wire:
NOTES:
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 79 of 120
E 320 1994 -1995
KEY T-HARNESS MMOBLZER N/A N/A N/A
FUNCTON COLOR LOCATON 12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS See NOTE *1 STARTER PURPLE (+) GNTON SWTCH HARNESS See NOTE *1 STARTER 2 N/A GNTON 1 PNK/RED (+) GNTON SWTCH HARNESS See NOTE *1 GNTON 2 PNK/YELLOW (+) GNTON SWTCH HARNESS See NOTE *1 GNTON 3 N/A ACCESSORY/HEATER BLOWER 1 PNK/GREEN (+) GNTON SWTCH HARNESS See NOTE *1 ACCESSORY/HEATER BLOWER 2 N/A KEYSENSE N/A PARKNG LGHTS ( - ) N/A PARKNG LGHTS ( + ) GRAY (+) and GRAY/WHTE (+) Use both, See NOTE *2 @ HEADLGHT SWTCH POWER LOCK BLUE or GREEN (TYPE E) See NOTE *6 N ETHER KCK PANEL POWER UNLOCK Same wire, DOOR TRGGER BROWN/GRAY (-) and BROWN/GRAY/BLACK (-) use both, See NOTE *3 @ PASSENGER PN SWTCHES or THEFT MODULE, See NOTE *5 DOMELGHT SUPERVSON BROWN/GRAY (-) @ PASSENGER DOOR PN SWTCH TRUNK RELEASE N/A SLDNG POWER DOOR N/A
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 80 of 120 HORN BLACK/YELLOW/PNK (+) @ STEERNG COLUMN HARNESS TACH GREEN/YELLOW @ BACK of NSTURMENT CLUSTER See NOTE *4 WAT TO START LGHT N/A BRAKE BLACK/RED/WHTE (+) @ SWTCH ABOVE BRAKE PEDAL FACTORY ALARM DSARM GREEN/YELLOW (-) @ THEFT MODULE, See NOTE *5 ANT-THEFT N/A
EXTRA NFORMATON NOTE *1 the GNTON HARNESS is accessible at the BOTTOM of the FUSE BOX, pull the fuse box up into the cowling area to get at the wire harness. NOTE: use the PURPLE/GREEN (+) wire to bypass the Factory Starter Kill for Remote Starter nstallation. NOTE *2 this vehicle has 2 Parking Light wires, it will require 2 extra Relays part #775, to connect, . NOTE *3 the front doors are a BROWN/GRAY (-) at the PASSENGER PN SWTCH and the rear doors are a BROWN/GRAY/BLACK (-) at the rear pin switch. When connecting to an ALARM SYSTEM, use both DOOR TRGGER wires and DODE SOLATE, NOTE *4 the tach wire is at the 3-pin connector at the nstrument cluster or in the main harness left of the steering column. NOTE *5 the THEFT MODULE is under the passenger footwell on coupes and sedans and on convertibles it is in the Right side of the trunk. NOTE *6 this vehicle uses a Vacuum Door Locking System that will require 2 extra relays part #775, to connect,
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 81 of 120
E 320 1996
KEY T-HARNESS MMOBLZER N/A N/A N/A
FUNCTON COLOR LOCATON 12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS See NOTE *1 STARTER PURPLE (+) GNTON SWTCH HARNESS See NOTE *1 STARTER 2 N/A GNTON 1 PNK/RED (+) GNTON SWTCH HARNESS See NOTE *1 GNTON 2 PNK/YELLOW (+) GNTON SWTCH HARNESS See NOTE *1 GNTON 3 N/A ACCESSORY/HEATER BLOWER 1 PNK/GREEN (+) GNTON SWTCH HARNESS See NOTE *1 ACCESSORY/HEATER BLOWER 2 N/A KEYSENSE N/A PARKNG LGHTS ( - ) N/A PARKNG LGHTS ( + ) GRAY/BLACK (+) and GRAY/RED (+) use both, See NOTE *2 @ HEADLGHT SWTCH POWER LOCK BLACK (TYPE B) N DRVERS KCK PANEL POWER UNLOCK BLUE (TYPE B) N DRVERS KCK PANEL DOOR TRGGER BROWN/GRAY (-) N DRVERS KCK PANEL DOMELGHT SUPERVSON USE DOOR TRGGER TRUNK RELEASE BLACK (+) @ TRUNK RELEASE SWTCH SLDNG POWER DOOR N/A HORN BLACK/YELLOW/PNK (+) @ STEERNG COLUMN HARNESS
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 82 of 120 TACH GREEN/YELLOW @ BACK of NSTURMENT CLUSTER See NOTE *3 WAT TO START LGHT N/A BRAKE BLACK/RED/WHTE (+) @ SWTCH ABOVE BRAKE PEDAL FACTORY ALARM DSARM DSARMS WTH UNLOCK ANT-THEFT N/A
EXTRA NFORMATON NOTE *1 the GNTON HARNESS is accessible at the BOTTOM of the FUSE BOX, pull the fuse box up into the cowling area to get at the wire harness. NOTE: use the PURPLE/GREEN (+) wire to bypass the Factory Starter Kill for Remote Starter nstallation. NOTE *2 this vehicle has 2 Parking Light wires, it will require 2 extra Relays part #775, to connect, . NOTE *3 the tach wire is at the 3-pin connector at the nstrument cluster or in the main harness left of the steering column.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 83 of 120
E 320 CONVERTIBLE 1993
KEY T-HARNESS MMOBLZER N/A N/A N/A
FUNCTON COLOR LOCATON 12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS See NOTE *1 STARTER PURPLE (+) GNTON SWTCH HARNESS See NOTE *1 STARTER 2 N/A GNTON 1 PNK/RED (+) GNTON SWTCH HARNESS See NOTE *1 GNTON 2 PNK/YELLOW (+) GNTON SWTCH HARNESS See NOTE *1 GNTON 3 N/A ACCESSORY/HEATER BLOWER 1 PNK/GREEN (+) GNTON SWTCH HARNESS See NOTE *1 ACCESSORY/HEATER BLOWER 2 N/A KEYSENSE N/A PARKNG LGHTS ( - ) N/A PARKNG LGHTS ( + ) GRAY (+) and GRAY/WHTE (+) See NOTE *2 @ HEADLGHT SWTCH POWER LOCK BLUE or GREEN (TYPE E) See NOTE *6 N ETHER KCK PANEL POWER UNLOCK Same wire, DOOR TRGGER BROWN/GRAY (-) and BROWN/GRAY/BLACK (-) use both, See NOTE *3 @ PASSENGER PN SWTCHES DOMELGHT SUPERVSON BROWN/GRAY (-) @ PASSENGERS PN SWTCHES TRUNK RELEASE N/A SLDNG POWER DOOR N/A
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 84 of 120 HORN BLACK/YELLOW/PNK (+) @ STEERNG COLUMN HARNESS TACH GREEN/YELLOW @ BACK of NSTURMENT CLUSTER See NOTE *4 WAT TO START LGHT N/A BRAKE BLACK/RED/WHTE (+) @ SWTCH ABOVE BRAKE PEDAL FACTORY ALARM DSARM GREEN/YELLOW (-) @ THEFT MODULE, See NOTE *5 ANT-THEFT N/A
EXTRA NFORMATON NOTE *1 the GNTON HARNESS is accessible at the BOTTOM of the FUSE BOX, pull the fuse box up into the cowling area to get at the wire harness. NOTE: use the PURPLE/GREEN (+) wire to bypass the Factory Starter Kill for Remote Starter nstallation. NOTE *2 this vehicle has 2 Parking Light wires, it will require a extra Relay to isolate, . NOTE *3 the front doors are a BROWN/GRAY at the PASSENGER PN SWTCH and the rear doors are a BROWN/GRAY/BLACK (-) at the rear pin switch. When connecting to an ALARM SYSTEM, use both DOOR TRGGER wires and DODE SOLATE, to connect, NOTE *4 the tach wire is at the 3-pin connector at the nstrument cluster or in the main harness left of the steering column. NOTE *5 the THEFT MODULE is under the passenger footwell on coupes and sedans and on convertibles it is in the Right side of the trunk.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 85 of 120
E 420 1994 -1995
KEY T-HARNESS MMOBLZER N/A N/A N/A
FUNCTON COLOR LOCATON 12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS See NOTE *1 STARTER PURPLE (+) GNTON SWTCH HARNESS See NOTE *1 STARTER 2 N/A GNTON 1 PNK/RED (+) GNTON SWTCH HARNESS See NOTE *1 GNTON 2 PNK/YELLOW (+) GNTON SWTCH HARNESS See NOTE *1 GNTON 3 N/A ACCESSORY/HEATER BLOWER 1 PNK/GREEN (+) GNTON SWTCH HARNESS See NOTE *1 ACCESSORY/HEATER BLOWER 2 N/A KEYSENSE N/A PARKNG LGHTS ( - ) N/A PARKNG LGHTS ( + ) GRAY (+) and GRAY/WHTE (+) Use both, See NOTE *2 @ HEADLGHT SWTCH POWER LOCK BLUE or GREEN (TYPE E) See NOTE *6 N ETHER KCK PANEL POWER UNLOCK Same wire, DOOR TRGGER BROWN/GRAY (-) and BROWN/GRAY/BLACK (-) use both, See NOTE *3 @ PASSENGER PN SWTCHES DOMELGHT SUPERVSON BROWN/GRAY (-) @ PASSENGER DOOR PN SWTCH TRUNK RELEASE N/A SLDNG POWER DOOR N/A HORN BLACK/YELLOW/PNK (+) @ STEERNG COLUMN HARNESS TACH GREEN/YELLOW @ BACK of NSTURMENT CLUSTER See NOTE *4 WAT TO START LGHT N/A BRAKE BLACK/RED/WHTE (+) @ SWTCH ABOVE BRAKE PEDAL FACTORY ALARM DSARM GREEN/YELLOW (-) @ THEFT MODULE, See NOTE *5 ANT-THEFT N/A
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 86 of 120
EXTRA NFORMATON NOTE *1 the GNTON HARNESS is accessible at the BOTTOM of the FUSE BOX, pull the fuse box up into the cowling area to get at the wire harness. NOTE: use the PURPLE/GREEN (+) wire to bypass the Factory Starter Kill for Remote Starter nstallation. NOTE *2 this vehicle has 2 Parking Light wires, it will require 2 extra Relays part #775 to connect, . NOTE *3 the front doors are a BROWN/GRAY at the PASSENGER PN SWTCH and the rear doors are a BROWN/GRAY/BLACK (-) at the rear pin switch. When connecting to an ALARM SYSTEM, use both DOOR TRGGER wires and DODE SOLATE, to connect, NOTE *4 the tach wire is at the 3-pin connector at the nstrument cluster or in the main harness left of the steering column. NOTE *5 the THEFT MODULE is under the passenger footwell on coupes and sedans and on convertibles it is in the Right side of the trunk. NOTE *6 this vehicle uses a Vacuum Door Locking System that will require 2 extra relays part #775, to connect,
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 87 of 120
E 420 1996
KEY T-HARNESS MMOBLZER N/A N/A N/A
FUNCTON COLOR LOCATON 12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS See NOTE *1 STARTER PURPLE (+) GNTON SWTCH HARNESS See NOTE *1 STARTER 2 N/A GNTON 1 PNK/RED (+) GNTON SWTCH HARNESS See NOTE *1 GNTON 2 PNK/YELLOW (+) GNTON SWTCH HARNESS See NOTE *1 GNTON 3 N/A ACCESSORY/HEATER BLOWER 1 PNK/GREEN (+) GNTON SWTCH HARNESS See NOTE *1 ACCESSORY/HEATER BLOWER 2 N/A KEYSENSE N/A PARKNG LGHTS ( - ) N/A PARKNG LGHTS ( + ) GRAY/BLACK (+) and GRAY/RED (+) use both, See NOTE *2 @ HEADLGHT SWTCH POWER LOCK BLACK (TYPE B) N DRVERS KCK PANEL POWER UNLOCK BLUE (TYPE B) N DRVERS KCK PANEL DOOR TRGGER BROWN/GRAY (-) N DRVERS KCK PANEL DOMELGHT SUPERVSON USE DOOR TRGGER TRUNK RELEASE BLACK (+) @ TRUNK RELEASE SWTCH SLDNG POWER DOOR N/A HORN BLACK/YELLOW/PNK (+) @ STEERNG COLUMN HARNESS TACH GREEN/YELLOW @ BACK of NSTURMENT CLUSTER See NOTE *3 WAT TO START LGHT N/A BRAKE BLACK/RED/WHTE (+) @ SWTCH ABOVE BRAKE PEDAL FACTORY ALARM DSARM DSARMS WTH UNLOCK ANT-THEFT N/A
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 88 of 120
EXTRA NFORMATON NOTE *1 the GNTON HARNESS is accessible at the BOTTOM of the FUSE BOX, pull the fuse box up into the cowling area to get at the wire harness. NOTE: use the PURPLE/GREEN (+) wire to bypass the Factory Starter Kill for Remote Starter nstallation. NOTE *2 this vehicle has 2 Parking Light wires, it will require 2 extra Relays part #775 to connect, . NOTE *3 the tach wire is at the 3-pin connector at the nstrument cluster or in the main harness left of the steering column.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 89 of 120
E 500 1994
KEY T-HARNESS MMOBLZER N/A N/A N/A
FUNCTON COLOR LOCATON 12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS See NOTE *1 STARTER PURPLE (+) GNTON SWTCH HARNESS See NOTE *1 STARTER 2 N/A GNTON 1 PNK/RED (+) GNTON SWTCH HARNESS See NOTE *1 GNTON 2 PNK/YELLOW (+) GNTON SWTCH HARNESS See NOTE *1 GNTON 3 N/A ACCESSORY/HEATER BLOWER 1 PNK/GREEN (+) GNTON SWTCH HARNESS See NOTE *1 ACCESSORY/HEATER BLOWER 2 N/A KEYSENSE N/A PARKNG LGHTS ( - ) N/A PARKNG LGHTS ( + ) GRAY (+) and GRAY/WHTE (+) Use both, See NOTE *2 @ HEADLGHT SWTCH POWER LOCK BLUE or GREEN (TYPE E) See NOTE *5 N ETHER KCK PANEL POWER UNLOCK Same wire, DOOR TRGGER BROWN/GRAY (-) and BROWN/GRAY/BLACK (-) use both, See NOTE *3 @ PASSENGER PN SWTCHES DOMELGHT SUPERVSON BROWN/GRAY (-) @ PASSENGER DOOR PN SWTCH TRUNK RELEASE N/A SLDNG POWER DOOR N/A HORN BLACK/YELLOW/PNK (+) @ STEERNG COLUMN HARNESS TACH GREEN/YELLOW @ BACK of NSTURMENT CLUSTER See NOTE *4 WAT TO START LGHT N/A BRAKE BLACK/RED/WHTE (+) @ SWTCH ABOVE BRAKE PEDAL FACTORY ALARM DSARM GREEN/YELLOW (-) N DRVERS DOOR HARNESS ANT-THEFT N/A
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 90 of 120
EXTRA NFORMATON NOTE *1 the GNTON HARNESS is accessible at the BOTTOM of the FUSE BOX, pull the fuse box up into the cowling area to get at the wire harness. NOTE: use the PURPLE/GREEN (+) wire to bypass the Factory Starter Kill for Remote Starter nstallation. NOTE *2 this vehicle has 2 Parking Light wires, it will require 2 extra Relays part #775 to connect, . NOTE *3 the front doors are a BROWN/GRAY at the PASSENGER PN SWTCH and the rear doors are a BROWN/GRAY/BLACK (-) at the rear pin switch. When connecting to an ALARM SYSTEM, use both DOOR TRGGER wires and DODE SOLATE, to connect, NOTE *4 the tach wire is at the 3-pin connector at the nstrument cluster or in the main harness left of the steering column. NOTE *5 this vehicle uses a Vacuum Door Locking System that will require 2 extra relays part #775, to connect,
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 91 of 120
ML CLASS 2001 -2002
KEY T- HARNES S MMOBLZER N/A N/A MERCEDES TRANSPONDER ANT-THEFT SYSTEM, Requires Bypass Module and extra gnition Key
FUNCTON COLOR LOCATON 12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS STARTER WHTE (+) GNTON SWTCH HARNESS STARTER 2 N/A GNTON 1 PNK (+) GNTON SWTCH HARNESS GNTON 2 N/A GNTON 3 N/A ACCESSORY/HEATER BLOWER 1 GREY (+) GNTON SWTCH HARNESS ACCESSORY/HEATER BLOWER 2 N/A KEYSENSE ORANGE (+) (Required for Remote Start) GNTON SWTCH HARNESS PARKNG LGHTS ( - ) N/A PARKNG LGHTS ( + ) BLUE (+) and GREEN (+) Use both, See NOTE *1 @ HEADLGHT SWTCH, POWER LOCK WHTE (3wires) (TYPE C) See NOTE *2 @ BOTTOM of FUSE/RELAY BOX POWER UNLOCK GREEN and PNK (2wires) (TYPE C) See NOTE *2 @ BOTTOM of FUSE/RELAY BOX DOOR TRGGER GRAY (-) and WHTE (-) Use both, See NOTE *4 @ KEYLESS MODULE, See NOTE *3 DOMELGHT SUPERVSON GRAY (-) @ KEYLESS MODULE, See NOTE *3 TRUNK RELEASE GRAY (5-Wire) See NOTE *7 @ BOTTOM of FUSE/RELAY BOX
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 92 of 120 SLDNG POWER DOOR N/A HORN ORANGE (-) @ STEERNG COLUMN HARNESS TACH ANY wire NOT BLACK/YELLOW or BLACK/GREEN @ any GNTON COL WAT TO START LGHT N/A BRAKE LGHT BLUE (+) @ SWTCH ABOVE BRAKE PEDAL, TOP PLUG FACTORY ALARM DSARM DSARMS WTH FACTORY REMOTE ONLY
ANT-THEFT TRANSPONDER ANT-THEFT SYSTEM, REQURES BYPASS MODULE AND EXTRA GNTON KEY, See NOTE *5 TRANSPONDER @ GNTON SWTCH TUMBLER
EXTRA NFORMATON NOTE *1 this vehicle has 2 Parking Light wires, to connect will require 2 extra Relays part #775, to connect, . NOTE *2 there are (3) WHTE wires for LOCK, located in a GREEN Connector labled P/E. The DRVERS DOOR lock wire is in Pin 3, the PASSENGER DOOR lock wire is in Pin 4, and the REAR DOOR lock wire (does both) is in Pin 5. For the Unlock wires, it has GREEN wire for the DRVERS DOOR Unlock, this GREEN wire is in a RED Connector labled C/F and is in Pin 11, the PASSENGER DOOR wire is a PNK in a RED Connector labled C/E in Pin 9, and REAR DOORS Unlock is a PNK and in a GREEN Connector labled P/E Pin 12. NOTE *3 the KEYLESS MODULE is attached to the bottom of the FUSE/RELAY BOX. NOTE *4 the FRONT DOORS use the GREY (-) at Pin 1 and the REAR DOORS use the WHTE (-) wire at Pin 5, these wires are located in a BLACK 6- Pin plug Connector 5. NOTE *5 the TRANSPONDER SYSTEM works only with vehicles that use the SWTCHBLADE KEY. f vehicle is equipped with the SMART KEY the transponder bypass will not work. NOTE: on some vehicles it has been noted that after a few weeks of using the Remote Starter, the factory transponder key would get deleted, this required a trip to the dealership for reprogramming of this key. NOTE *6 the FUSE/RELAY BOX is located under the hood on the DRVERS SDE. NOTE *7 this vehicle uses a 5-Wire TRUNK/HATCH Release System, that will require an extra Relay Part #775, to connect, .
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 93 of 120
Make: Model: Year: Mercedes-Benz ML 320 1998-2000
FUNCTON COLOR LOCATON Start: WHTE GNTON SWTCH HARNESS ** gnition #1: TAN GNTON SWTCH HARNESS gnition #2: ORANGE GNTON SWTCH HARNESS gnition #3: Accessory: GRAY GNTON SWTCH HARNESS Brake Light: TAN AT SWTCH ABOVE BRAKE PEDAL Tach Signal: BLUE AT COL* Parking Lights: LT. GREEN & LT. BLUE BEHND FUSE PANEL *** Headlights: Diesel Glow Plug: Clutch Bypass Wire:
NOTES: NSTALLATON OF KEYLESS ENTRY OR REMOTE START SHOULD ONLY BE ATTEMPTED BY HGH LEVEL NSTALLERS. * Located Under Plastic Cover, Driver's Side Front Coil. ** This Vehicle s Equipped With A Transponder Type Of Passive Security System. RF transponders can be bypassed - See nstallation Note #144 Bypassing Transponder Theft Systems. R transponders can not be bypassed at this time.
Mercedes-Benz ML 320 1998-2000
FUNCTON COLOR LOCATON Constant +12 Volts: OEM Alarm Disarm: WHTE (-) AT KEYLESS ENTRY MODULE **** Dome Lights/Superv: TAN (-) AT KEYLESS MODULE ***** OEM Horn: Power Lock: WHTE (-) AT KEYLESS ENTRY MODULE BEHND Power Unlock: WHTE (-) FUSE PANEL; SNGLE WRE SYSTEM **** Trunk Release: Alarm nput Wire: TAN (-) AT KEYLESS MODULE *****
NOTES: **** This vehicle is equipped with a single wire which lock/arms and unlock/disarms the vehicle. First pulse locks, second unlocks. There is no reliable way to interface to the lock syste/OEM alarm at this time. ***** At Keyless Entry Module (Black Plug).
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 94 of 120
ML 430 1999 -2000
KEY T- HARNESS MMOBLZER N/A N/A TRANSPONDER, REQURES BYPASS and EXTRA GNTON KEY (Some Vehicles)
FUNCTON COLOR LOCATON 12 VOLT CONSTANT RED (+) @ GNTON KEY SWTCH STARTER WHTE (+) @ GNTON KEY SWTCH STARTER 2 N/A GNTON 1 TAN (+) @ GNTON KEY SWTCH GNTON 2 N/A GNTON 3 N/A ACCESSORY/HEATER BLOWER 1 GRAY (+) @ GNTON KEY SWTCH ACCESSORY/HEATER BLOWER 2 N/A KEYSENSE ORANGE (+) (Required for Remote Start) @ GNTON KEY SWTCH PARKNG LGHTS ( - ) N/A PARKNG LGHTS ( + ) BLUE (+) and GREEN (+) Use both, See NOTE *1 @ HEADLGHT SWTCH, POWER LOCK WHTE (TYPE C) @ KEYLESS MODULE, See NOTE *3 POWER UNLOCK GREEN and PNK (TYPE C) See NOTE *2 @ KEYLESS MODULE, See NOTE *3 DOOR TRGGER TAN (-) @ KEYLESS MODULE, See NOTE *3 DOMELGHT SUPERVSON USE DOOR TRGGER TRUNK RELEASE GRAY (5-Wire) See NOTE *5 @ KEYLESS MODULE, See NOTE *3 SLDNG POWER DOOR N/A
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 95 of 120 HORN ORANGE (-) @ STEERNG COLUMN HARNESS TACH ANY wire NOT BLACK/YELLOW or BLACK/GREEN @ any GNTON COL WAT TO START LGHT N/A BRAKE TAN (+) @ SWTCH ABOVE BRAKE PEDAL FACTORY ALARM DSARM DSARMS WTH FACTORY REMOTE ONLY
ANT-THEFT TRANSPONDER ANT-THEFT SYSTEM, REQURES BYPASS MODULE AND EXTRA GNTON KEY, See NOTE *4 TRANSPONDER @ GNTON SWTCH TUMBLER
EXTRA NFORMATON NOTE *1 this vehicle has 2 Parking Light wires, to connect will require 2 extra Relays part #775, to connect, . NOTE *2 the GREEN wire Unlocks only the DRVERS DOOR and the PNK wire Unlocks all the other doors. NOTE *3 the KEYLESS MODULE is located under the hood and below the under hood fusebox. NOTE *4 the TRANSPONDER SYSTEM works only with vehicles that use the SWTCHBLADE KEY. f vehicle is equipped with the SMART KEY the transponder bypass will not work. NOTE: on some vehicles it has been noted that after a few weeks of using the Remote Starter, the factory transponder key would get deleted, this required a trip to the dealership for reprogramming of this key. NOTE *5 this vehicle uses a 5-Wire TRUNK/HATCH Release System, that will require an extra Relay Part #775, to connect, .
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 96 of 120
Make: Model: Year: Mercedes-Benz S CIass 1994-1996
FUNCTON COLOR LOCATON Start: VOLET GNTON SWTCH HARNESS gnition #1: PNK/BLACK GNTON SWTCH HARNESS gnition #2: PNK/YELLOW GNTON SWTCH HARNESS gnition #3: N/A Accessory: N/A Brake Light: BLACK/RED (+) (+) AT BRAKELGHT SWTCH Tach Signal: BLACK (4 CYLNDER) DRVER FENDERWELL (COL BEHND/H'LGT) Parking Lights: GRAY/WHTE AND GRAY AT HEADLGHT SWTCH - BOTH (+) * Headlights: WHTE/YELLOW (+) AT HEADLGHT SWTCH Diesel Glow Plug: Clutch Bypass Wire:
NOTES:
Mercedes-Benz S CIass 1994-1996
FUNCTON COLOR LOCATON Constant +12 Volts: RED GNTON SWTCH HARNESS OEM Alarm Disarm: N/A Dome Lights/Superv: BROWN/GRAY (FRONT) BROWN/RED (REAR) BOTH (-) OEM Horn: BLACK/YELLOW/RED (+) AT O.E.M. ALARM N TRUNK Power Lock: BLUE/YELLOW DRVER'S KCK PANEL ** Power Unlock: BLUE/BLACK DRVER'S KCK PANEL ** Trunk Release: N/A Alarm nput Wire: BROWN/GRAY (FRONT) BROWN/RED (REAR) BOTH (-)
NOTES: * Split Parking Light System - must use relays to isolate the circuits from each other.. ** See Note #201 - Negative Pulse Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 97 of 120 Make: Model: Year: Mercedes-Benz S CIass 1998-1999
NOTES: We do not recommend installing ANY remote starter or aftermarket keyless entry into this vehicle. * This Vehicle s Equipped With A Transponder Type Of Passive Security System. See nstallation Note #144 - Bypassing Transponder Theft Systems. ** Split Parking Light System, Use Both Wires, Diode solate With 6 Amp Diodes.
Mercedes-Benz S CIass 1998-1999
FUNCTON COLOR LOCATON Constant +12 Volts: RED GNTON SWTCH HARNESS OEM Alarm Disarm: Dome Lights/Superv: BROWN/GRAY & BROWN/RED (-) AT FACTORY SECURTY MODULE *** OEM Horn: Power Lock: BLUE/YELLOW (-) N DRVER'S KCK PANEL **** Power Unlock: BLUE/BLACK (-) N DRVER'S KCK PANEL **** Trunk Release: Alarm nput Wire: BROWN/GRAY & BROWN/RED (-) AT FACTORY SECURTY MODULE ***
NOTES: *** Factory Alarm Module s Located n Trunk Behind Liner. Both Wires Must Be Connected, Diode solate. **** Wires Can Also Be Found At Factory Alarm Module n Trunk Behind Liner. See Note #201 Negative Trigger Door Locks.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 98 of 120 Make: Model: Year: Mercedes-Benz S CIass 2000-2002
NOTES: We do not recommend installing ANY remote starter or aftermarket keyless entry into this vehicle. * f Equipped With Smart Key, Cannot Add Remote Start. f Equipped With Switchblade Key, See nstallation Note #144 - Bypassing Transponder Theft Systems. ** Use Any Wire At Any Coil That s Not Black/Green or Black/Yellow.
Mercedes-Benz S CIass 2000-2002
FUNCTON COLOR LOCATON Constant +12 Volts: RED GNTON SWTCH HARNESS OEM Alarm Disarm: DSARMS WTH UNLOCK
Dome Lights/Superv: SEE NOTE BELOW *** OEM Horn: BLACK/YELLOW (+) AT HORN Power Lock: RED/BLUE DRVER'S DOOR MODULE **** Power Unlock: RED/BLUE DRVER'S DOOR MODULE **** Trunk Release: BROWN (-) AT RELEASE SWTCH Alarm nput Wire: SEE NOTE BELOW ***
NOTES: **** This vehicle is equipped with a single wire which lock/arms and unlock/disarms the vehicle. First pulse locks, second unlocks. There is no reliable way to interface to the lock syste/OEM alarm at this time.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 99 of 120
NOTES: We do not recommend installing ANY remote starter or aftermarket keyless entry into this vehicle. * f Equipped With Smart Key, Cannot Add Remote Start. f Equipped With Switchblade Key. f equipped with RF transponder see Note #144
NOTES: ** See Note #201 Negative Trigger Door Locks.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 100 of 120
S 320 1994 -1997
KEY T- HARNES S MMOBLZER N/A N/A MERCEDES TRANSPONDER ANT-THEFT SYSTEM, Requires Bypass Module and extra gnition Key
FUNCTON COLOR LOCATON 12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS, See NOTE *1 STARTER PURPLE (+) GNTON SWTCH HARNESS, See NOTE *1 STARTER 2 N/A GNTON 1 PNK/BLACK (+) GNTON SWTCH HARNESS, See NOTE *1 GNTON 2 PNK/YELLOW (+) GNTON SWTCH HARNESS, See NOTE *1 GNTON 3 N/A ACCESSORY/HEATER BLOWER 1 PNK/GREEN (+) GNTON SWTCH HARNESS See NOTE *1 ACCESSORY/HEATER BLOWER 2 N/A KEYSENSE N/A PARKNG LGHTS ( - ) N/A PARKNG LGHTS ( + ) GRAY (+) and GRAY/WHTE (+) See NOTE *2 @ HEADLGHT SWTCH POWER LOCK BLUE/YELLOW (TYPE B) N ETHER KCK PANEL POWER UNLOCK BLUE/BLACK (TYPE B) N ETHER KCK PANEL DOOR TRGGER BROWN/GRAY (-) and BROWN/RED (-) Use both, See NOTE *3 @ PN SWTCHES DOMELGHT SUPERVSON BROWN/GRAY (-) @ DRVERS PN SWTCH TRUNK RELEASE N/A
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 101 of 120 SLDNG POWER DOOR N/A HORN BLACK/YELLOW/RED (+) @ THEFT MODULE, See NOTE *4 TACH BLACK @ GNTON COL WAT TO START LGHT N/A BRAKE BLACK/RED/WHTE (+) @ SWTCH ABOVE BRAKE PEDAL FACTORY ALARM DSARM BROWN/YELLOW (-) @ THEFT MODULE, See NOTE *4 ANT-THEFT TRANSPONDER ANT-THEFT SYSTEM, REQURES BYPASS MODULE AND EXTRA GNTON KEY TRANSPONDER @ GNTON SWTCH TUMBLER
EXTRA NFORMATON NOTE *1 Remove the KNEE BOLSTER from dash to access the GNTON SWTCH HARNESS. NOTE *2 this vehicle uses 2 parking Light wires, to connect will require 2 extra relays Part #775, to connect, NOTE *3 the BROWN/GRAY(-) wire is at the Drivers pin switch and the BROWN/RED (-) wire is at the Drivers Rear Pin switch. You can also use the WHTE/PNK (-) for the front doors and the for the BROWN/PNK (-) for Rear doors at the THEFT MODULE in the trunk. When connecting to an ALARM SYSTEM, use all 4 DOOR TRGGER wires and DODE SOLATE, to connect, NOTE *4 the THEFT MODULE is located in the trunk behind the liner on the Right side.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 102 of 120
S 420 1994 -1997
KEY T- HARNES S MMOBLZER N/A N/A MERCEDES TRANSPONDER ANT-THEFT SYSTEM, Requires Bypass Module and extra gnition Key
FUNCTON COLOR LOCATON 12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS, See NOTE *1 STARTER PURPLE (+) GNTON SWTCH HARNESS, See NOTE *1 STARTER 2 N/A GNTON 1 PNK/BLACK (+) GNTON SWTCH HARNESS, See NOTE *1 GNTON 2 PNK/YELLOW (+) GNTON SWTCH HARNESS, See NOTE *1 GNTON 3 N/A ACCESSORY/HEATER BLOWER 1 PNK/GREEN (+) GNTON SWTCH HARNESS, See NOTE *1 ACCESSORY/HEATER BLOWER 2 N/A KEYSENSE N/A PARKNG LGHTS ( - ) N/A PARKNG LGHTS ( + ) GRAY (+) and GRAY/WHTE (+) Use both, See NOTE *2 @ HEADLGHT SWTCH, POWER LOCK BLUE/YELLOW (TYPE B) N ETHER KCK PANEL POWER UNLOCK BLUE/BLACK (TYPE B) N ETHER KCK PANEL DOOR TRGGER BROWN/GRAY (-) and BROWN/RED (-) Use both, See NOTE *3 @ PN SWTCHES DOMELGHT SUPERVSON BROWN/GRAY (-) @ DRVERS PN SWTCH TRUNK RELEASE N/A
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 103 of 120 SLDNG POWER DOOR N/A HORN BLACK/YELLOW/RED (+) @ THEFT MODULE, See NOTE *4 TACH BLACK, BLACK/WHTE or BLACK/YELLOW @ GNTON COL PACK WAT TO START LGHT N/A BRAKE BLACK/RED/WHTE (+) @ SWTCH ABOVE BRAKE PEDAL FACTORY ALARM DSARM BROWN/YELLOW (-) @ THEFT MODULE, See NOTE *4 ANT-THEFT TRANSPONDER ANT-THEFT SYSTEM, REQURES BYPASS MODULE AND EXTRA GNTON KEY, See NOTE *5 TRANSPONDER @ GNTON SWTCH TUMBLER
EXTRA NFORMATON NOTE *1 Remove the KNEE BOLSTER from dash to access the GNTON SWTCH HARNESS. NOTE *2 this vehicle uses 2 parking Light wires to connect will require 2 extra relays Part #775, to connect, NOTE *3 the BROWN/GRAY(-) wire is at the Drivers pin switch and the BROWN/RED (-) wire is at the Drivers Rear Pin switch. You can also use the WHTE/PNK (-) for the front doors, the BROWN/PNK (-) for Rear doors at the THEFT MODULE in the trunk. When connecting to an ALARM SYSTEM use all 4 DOOR TRGGER wires and DODE SOLATE, to connect, . NOTE *4 the THEFT MODULE is located in the trunk behind the liner on the Right side. NOTE *5 the bypass module will only work on vehicles that use the SWTCHBLADE KEYS on vehicles that use the SMART KEY the bypass will not work.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 104 of 120
S 500 1994 -1997
KEY T- HARNES S MMOBLZER N/A N/A MERCEDES TRANSPONDER ANT-THEFT SYSTEM, Requires Bypass Module and extra gnition Key
FUNCTON COLOR LOCATON 12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS, See NOTE *1 STARTER PURPLE (+) GNTON SWTCH HARNESS, See NOTE *1 STARTER 2 N/A GNTON 1 PNK/BLACK (+) GNTON SWTCH HARNESS, See NOTE *1 GNTON 2 PNK/YELLOW (+) GNTON SWTCH HARNESS, See NOTE *1 GNTON 3 N/A ACCESSORY/HEATER BLOWER 1 PNK/GREEN (+) GNTON SWTCH HARNESS, See NOTE *1 ACCESSORY/HEATER BLOWER 2 N/A KEYSENSE N/A PARKNG LGHTS ( - ) N/A PARKNG LGHTS ( + ) GRAY (+) and GRAY/WHTE (+) Use both, See NOTE *2 @ HEADLGHT SWTCH, POWER LOCK BLUE/YELLOW (TYPE B) N ETHER KCK PANEL POWER UNLOCK BLUE/BLACK (TYPE B) N ETHER KCK PANEL DOOR TRGGER BROWN/GRAY (-) and BROWN/RED (-) Use both, See NOTE *3 @ PN SWTCHES DOMELGHT SUPERVSON BROWN/GRAY (-) @ DRVERS PN SWTCH TRUNK RELEASE N/A
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 105 of 120 SLDNG POWER DOOR N/A HORN BLACK/YELLOW/RED (+) @ THEFT MODULE, See NOTE *4 TACH BLACK @ GNTON COL WAT TO START LGHT N/A BRAKE BLACK/RED/WHTE (+) @ SWTCH ABOVE BRAKE PEDAL FACTORY ALARM DSARM N/A ANT-THEFT TRANSPONDER ANT-THEFT SYSTEM, REQURES BYPASS MODULE AND EXTRA GNTON KEY, See NOTE *5 @ GNTON SWTCH TUMBLER
EXTRA NFORMATON NOTE *1 Remove the KNEE BOLSTER from dash to access the GNTON SWTCH HARNESS. NOTE *2 this vehicle uses 2 parking Light wires to connect will require 2 extra relays Part #775, to connect, NOTE *3 the BROWN/GRAY(-) wire is at the Drivers pin switch and the BROWN/RED (-) wire is at the Drivers Rear Pin switch. You can also use the WHTE/PNK (-) for the front doors and the for the BROWN/PNK (-) for Rear doors at the THEFT MODULE in the trunk. When connecting to an ALARM SYSTEM, use all 4 Door Trigger wires and DODE SOLATE, to connect, . NOTE *4 the THEFT MODULE is located in the trunk behind the liner on the Right side. NOTE *5 the bypass module will only work on vehicles that use the SWTCHBLADE KEYS on vehicles that use the SMART KEY the bypass will not work.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 106 of 120
S 600 1996
KEY T-HARNESS MMOBLZER N/A N/A N/A
FUNCTON COLOR LOCATON 12 VOLT CONSTANT Connect to BATTERY STARTER PURPLE (+) GNTON SWTCH HARNESS STARTER 2 N/A GNTON 1 PNK/BLACK/GREEN (+) GNTON SWTCH HARNESS GNTON 2 N/A GNTON 3 N/A ACCESSORY/HEATER BLOWER 1 PNK/YELLOW (+) GNTON SWTCH HARNESS ACCESSORY/HEATER BLOWER 2 PNK/YELLOW (+) GNTON SWTCH HARNESS KEYSENSE N/A PARKNG LGHTS ( - ) N/A PARKNG LGHTS ( + ) GRAY/RED (+) and GRAY/WHTE (+) use both, See NOTE *1 @ HEADLGHT SWTCH, POWER LOCK BLUE/GRAY (TYPE B) N DRVERS KCK PANEL POWER UNLOCK BLUE (TYPE B) N DRVERS KCK PANEL DOOR TRGGER BROWN/GRAY (-) and BROWN/RED (-) Use both, See NOTE *2 @ PASSENGER PN SWTCHES DOMELGHT SUPERVSON BROWN/GRAY (-) @ PASSENGER DOOR PN SWTCH TRUNK RELEASE N/A SLDNG POWER DOOR N/A HORN N/A TACH BLUE/GRAY @ GNTON COL
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 107 of 120 WAT TO START LGHT N/A BRAKE BLACK/RED/WHTE (+) @ SWTCH ABOVE BRAKE PEDAL FACTORY ALARM DSARM DSARMS WTH UNLOCK ANT-THEFT N/A
EXTRA NFORMATON NOTE *1 this vehicle uses 2 parking Light wires to connect will require 2 extra relays Part #775, , NOTE *2 this vehicle has 2 Door Trigger wires, when connecting to an ALARM SYSTEM, use both and DODE SOLATE, to connect, .
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 108 of 120
SL CLASS 1998 -1999
KEY T- HARNES S MMOBLZER N/A N/A MERCEDES TRANSPONDER ANT-THEFT SYSTEM, Requires Bypass Module and extra gnition Key
FUNCTON COLOR LOCATON 12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS STARTER PURPLE (+) GNTON SWTCH HARNESS STARTER 2 N/A GNTON 1 PNK/RED (+) GNTON SWTCH HARNESS GNTON 2 N/A GNTON 3 N/A ACCESSORY/HEATER BLOWER 1 PNK/GREEN (+) GNTON SWTCH HARNESS ACCESSORY/HEATER BLOWER 2 N/A KEYSENSE N/A PARKNG LGHTS ( - ) N/A PARKNG LGHTS ( + ) GRAY/RED (+) and GRAY/PURPLE (+) Use BOTH, See NOTE *1 @ HEADLGHT SWTCH, POWER LOCK GREEN or PNK (TYPE E) See NOTE *1 N PASSENGER KCK PANEL, POWER UNLOCK Same wire, DOOR TRGGER BROWN/GRAY (-) @ UNDER DASH LGHT DOMELGHT SUPERVSON USE DOOR TRGGER TRUNK RELEASE N/A SLDNG POWER DOOR N/A HORN N/A
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 109 of 120 TACH N/A WAT TO START LGHT N/A BRAKE BLACK/PURPLE (+) @ SWTCH ABOVE BRAKE PEDAL FACTORY ALARM DSARM N/A ANT-THEFT TRANSPONDER ANT-THEFT SYSTEM, REQURES BYPASS MODULE AND EXTRA GNTON KEY See NOTE *2 TRANSPONDER @ GNTON SWTCH TUMBLER
EXTRA NFORMATON NOTE *1 this vehicle uses Vacuum DOOR LOCKNG System (TYPE E) and requires 2 extra relays Part #775, to connect, . NOTE *2 the TRANSPONDER SYSTEM works only with vehicles that use the SWTCHBLADE KEY. f vehicle is equipped with the SMART KEY the transponder bypass will not work.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 110 of 120
Make: Model: Year: Mercedes-Benz SL300 1990-1992
FUNCTON COLOR LOCATON Start: VOLET GNTON SWTCH HARNESS gnition #1: PNK/RED GNTON SWTCH HARNESS gnition #2: PNK/BLACK GNTON SWTCH HARNESS gnition #3: Accessory: PNK/YELLOW GNTON SWTCH HARNESS Brake Light: BLACK/RED AT SWTCH ABOVE BRAKE PEDAL Tach Signal: BLACK AT DAGNOSTC PLUG* Parking Lights: GRAY/WHTE AND GRAY/RED AT LGHT SWTCH ** Headlights: Diesel Glow Plug: Clutch Bypass Wire:
NOTES: * Diagnostic Plug s Located Behind The Driver's Headlight.
Mercedes-Benz SL300 1990-1992
FUNCTON COLOR LOCATON Constant +12 Volts: RED GNTON SWTCH HARNESS OEM Alarm Disarm: WHTE (-) AT OEM ALARM MODULE Dome Lights/Superv: GRAY/WHTE (-) PASSENGER PN SWTCH OEM Horn: Power Lock: BLUE OR GREEN DRVER'S KCK PANEL OR AT Power Unlock: BLUE OR GREEN VACUUM PUMP MOTOR N TRUNK *** Trunk Release: N/A Alarm nput Wire: GRAY/WHTE (-) PASSENGER PN SWTCH
NOTES: ** Split Parking Light System - must use relays to isolate the circuits from each other. *** See Note #210 - Mercedes Vacuum Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 111 of 120
Make: Model: Year: Mercedes-Benz SL500 1990-1992
FUNCTON COLOR LOCATON Start: VOLET GNTON SWTCH HARNESS gnition #1: PNK/RED GNTON SWTCH HARNESS gnition #2: PNK/BLACK GNTON SWTCH HARNESS gnition #3: Accessory: PNK/YELLOW GNTON SWTCH HARNESS Brake Light: BLACK/RED AT SWTCH ABOVE BRAKE PEDAL Tach Signal: BLACK AT DAGNOSTC PLUG* Parking Lights: GRAY/WHTE AND GRAY/RED AT LGHT SWTCH ** Headlights: Diesel Glow Plug: Clutch Bypass Wire:
NOTES: * Diagnostic Plug s Located Behind The Driver's Headlight.
Mercedes-Benz SL500 1990-1992
FUNCTON COLOR LOCATON Constant +12 Volts: RED GNTON SWTCH HARNESS OEM Alarm Disarm: WHTE (-) AT OEM ALARM MODULE Dome Lights/Superv: GRAY/WHTE (-) PASSENGER PN SWTCH OEM Horn: Power Lock: BLUE OR GREEN DRVER'S KCK PANEL OR AT Power Unlock: BLUE OR GREEN VACUUM PUMP MOTOR N TRUNK *** Trunk Release: N/A Alarm nput Wire: GRAY/WHTE (-) PASSENGER PN SWTCH
NOTES: ** Split Parking Light System - must use relays to isolate the circuits from each other. *** See Note #210 - Mercedes Vacuum Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 112 of 120
SL 500 1995
KEY T-HARNESS MMOBLZER N/A N/A N/A
FUNCTON COLOR LOCATON 12 VOLT CONSTANT Connect to BATTERY STARTER PURPLE (+) GNTON SWTCH HARNESS STARTER 2 N/A GNTON 1 PNK/GREEN (+) GNTON SWTCH HARNESS GNTON 2 N/A GNTON 3 N/A ACCESSORY/HEATER BLOWER 1 PNK/RED (+) GNTON SWTCH HARNESS ACCESSORY/HEATER BLOWER 2 N/A KEYSENSE N/A PARKNG LGHTS ( - ) N/A PARKNG LGHTS ( + ) GRAY/RED (+) and GRAY/PURPLE (+) Use BOTH, See NOTE *1 @ HEADLGHT SWTCH, POWER LOCK BLUE or GREEN (TYPE E) See NOTE *2 N PASSENGER KCK PANEL, POWER UNLOCK Same wire, See DAGRAM DOOR TRGGER BROWN/GRAY (-) @ UNDER DASH LGHT DOMELGHT SUPERVSON USE DOOR TRGGER TRUNK RELEASE N/A SLDNG POWER DOOR N/A HORN N/A TACH N/A WAT TO START LGHT N/A BRAKE BLACK/RED (+) @ SWTCH ABOVE BRAKE PEDAL FACTORY ALARM DSARM N/A ANT-THEFT N/A
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 113 of 120
EXTRA NFORMATON NOTE *1 this vehicle has a 2 PARKNG LGHT wire System, that will require 2 extra Relays Part #775, to connect, . NOTE *2 this vehicle uses a Vacuum DOOR LOCKNG System (TYPE E) that will require 2 extra relays FUNCTON #775, to connect, .
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 114 of 120
SL 600 1996
KEY T-HARNESS MMOBLZER N/A N/A N/A
FUNCTON COLOR LOCATON 12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS STARTER PURPLE (+) GNTON SWTCH HARNESS STARTER 2 N/A GNTON 1 PNK/RED (+) GNTON SWTCH HARNESS GNTON 2 N/A GNTON 3 N/A ACCESSORY/HEATER BLOWER 1 PNK/GREEN (+) GNTON SWTCH HARNESS ACCESSORY/HEATER BLOWER 2 N/A KEYSENSE N/A PARKNG LGHTS ( - ) N/A PARKNG LGHTS ( + ) N/A POWER LOCK GREEN (1-Wire System) See NOTE *1 N PASSENGER KCK PANEL POWER UNLOCK Same wire See DAGRAM DOOR TRGGER BROWN/WHTE (-) @ UNDER DASH LGHT DOMELGHT SUPERVSON USE DOOR TRGGER TRUNK RELEASE N/A SLDNG POWER DOOR N/A HORN N/A TACH BLUE/GRAY @ GNTON COL WAT TO START LGHT N/A BRAKE BLACK/RED (+) @ SWTCH ABOVE BRAKE
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 115 of 120 PEDAL FACTORY ALARM DSARM WHTE (-) @ THEFT MODULE in TRUNK ANT-THEFT N/A
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 116 of 120
SLK CLASS 1998 -2000
KEY T- HARNES S MMOBLZER N/A N/A MERCEDES TRANSPONDER ANT-THEFT SYSTEM, Requires Bypass Module and extra gnition Key
FUNCTON COLOR LOCATON 12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS STARTER PURPLE (+) GNTON SWTCH HARNESS STARTER 2 N/A GNTON 1 PNK/RED (+) GNTON SWTCH HARNESS GNTON 2 PNK/YELLOW (+) or BLACK/YELLOW/GREEN (+) GNTON SWTCH HARNESS GNTON 3 N/A ACCESSORY/HEATER BLOWER 1 PNK/GREEN (+) GNTON SWTCH HARNESS ACCESSORY/HEATER BLOWER 2 N/A KEYSENSE N/A PARKNG LGHTS ( - ) N/A PARKNG LGHTS ( + ) GRAY/BLACK (+) and GRAY/RED (+) use both, See NOTE *1 @ LLUMNATON CONTROL MODULE, See NOTE *2 POWER LOCK BLACK (TYPE B) See NOTE *3 N DRVERS KCK PANEL POWER UNLOCK BLUE (TYPE B) See NOTE *3 N DRVERS KCK PANEL DOOR TRGGER BROWN/GRAY (-) and BROWN/PNK (-) Use BOTH, See NOTE *6 @ PN SWTCH or PSE Control Module, See NOTE *4 DOMELGHT SUPERVSON BROWN/GRAY (-) @ PN SWTCH or PSE Control Module, See NOTE *4 TRUNK RELEASE N/A SLDNG POWER DOOR N/A HORN BLACK/PNK (+) @ HORN TACH BLACK or BLACK/WHTE @ GNTON COL PACK WAT TO START LGHT N/A BRAKE BLACK/RED (+) @ SWTCH ABOVE BRAKE PEDAL FACTORY ALARM DSARM DSARMS WTH UNLOCK ANT-THEFT TRANSPONDER ANT-THEFT SYSTEM, REQURES BYPASS MODULE AND EXTRA GNTON KEY, See NOTE *5 TRANSPONDER @ GNTON SWTCH TUMBLER
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 117 of 120
EXTRA NFORMATON NOTE *1 this vehicle has 2 PARKNG LGHT wires that will require 2 extra relays part #775, to connect, . NOTE *2 the LLUMNATON CONTROL MODULE is part of the Headlight Switch. NOTE *3 these are the DRVERS DOOR KEY Cylinder wires when testing turn the key in the drivers door key cylinder. NOTE *4 the PSE Control Module is in the Trunk under the Jack Box. NOTE *5 the TRANSPONDER SYSTEM works only with vehicles that use the SWTCHBLADE KEY. f vehicle is equipped with the SMART KEY the transponder bypass will not work. NOTE *6 this vehicle has 2 Door Trigger wires, when connecting to an ALARM SYSTEM use both wires and DODE SOLATE, to connect, .
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 118 of 120
SLK CLASS 2001 -2002
KEY T- HARNES S MMOBLZER N/A N/A MERCEDES TRANSPONDER ANT-THEFT SYSTEM, Requires Bypass Module and extra gnition Key
FUNCTON COLOR LOCATON 12 VOLT CONSTANT RED (+) @ REAR of FUSE BOX, WHTE Plug STARTER PURPLE (+) @ REAR of FUSE BOX, WHTE Plug STARTER 2 N/A GNTON 1 PNK/RED (+) @ REAR of FUSE BOX, WHTE Plug GNTON 2 PNK/YELLOW (+) @ REAR of FUSE BOX, WHTE Plug GNTON 3 N/A ACCESSORY/HEATER BLOWER 1 PNK/GREEN (+) @ REAR of FUSE BOX, WHTE Plug ACCESSORY/HEATER BLOWER 2 N/A KEYSENSE N/A PARKNG LGHTS ( - ) N/A PARKNG LGHTS ( + ) GRAY/BLACK (+) and GRAY/RED (+) Use both, See NOTE *1 @ LLUMNATON CONTROL MODULE, See NOTE *2 POWER LOCK BLACK (TYPE B) See NOTE *3 N DRVERS KCK PANEL POWER UNLOCK BLUE (TYPE B) See NOTE *3 N DRVERS KCK PANEL DOOR TRGGER BROWN/GRAY (-) and BROWN/PNK (-) Use BOTH, See NOTE *6 @ PN SWTCH or PSE Control Module, See NOTE *4 DOMELGHT SUPERVSON BROWN/GRAY (-) @ PN SWTCH or PSE Control Module, See NOTE *4
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 119 of 120 TRUNK RELEASE N/A SLDNG POWER DOOR N/A HORN BLACK/PNK (+) @ HORN TACH See NOTE *6 @ any GNTON COL WAT TO START LGHT N/A BRAKE BLACK/RED (+) @ SWTCH ABOVE BRAKE PEDAL FACTORY ALARM DSARM DSARMS WTH UNLOCK ANT-THEFT TRANSPONDER ANT-THEFT SYSTEM, REQURES BYPASS MODULE AND EXTRA GNTON KEY, See NOTE *5 TRANSPONDER @ GNTON SWTCH TUMBLER
EXTRA NFORMATON NOTE *1 this vehicle uses 2 PARKNG LGHT wires, to connect will require 2 extra Relays part # 775, to connect, NOTE *2 the LLUMNATON CONTROL MODULE is part of the Headlight Switch. NOTE *3 these are the DRVERS DOOR KEY Cylinder wires when testing turn the key in the drivers door key cylinder. NOTE *4 the PSE Control Module is in the Trunk under the Jack Box. NOTE *5 the TRANSPONDER SYSTEM works only with vehicles that use the SWTCHBLADE KEY. f vehicle is equipped with the SMART KEY the transponder bypass will not work. NOTE *6 on the 2.3L use the wrie that is NOT RED/BLUE or BROWN, on the 3.2L use the wire that is NOT BLACK/YELLOW or BLACK/GREEN
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and unauthorized copy and should be reported immediately to fraud@12voltresource.com. Mercedes - Copyright 2004-2006 - 12 Volt Resource LLC Page 120 of 120
VITO (UK) 1998
KEY T-HARNESS MMOBLZER N/A N/A N/A
FUNCTON COLOR LOCATON 12 VOLT CONSTANT Connect to BATTERY STARTER BLACK/YELLOW (+) GNTON SWTCH HARNESS STARTER 2 N/A GNTON 1 BLACK (+) (HEAVY GAUGE) GNTON SWTCH HARNESS GNTON 2 N/A GNTON 3 N/A ACCESSORY/HEATER BLOWER 1 N/A ACCESSORY/HEATER BLOWER 2 N/A KEYSENSE N/A PARKNG LGHTS ( - ) N/A PARKNG LGHTS ( + ) BLACK/GREEN (+) and BLACK/WHTE (+) Use both, See NOTE *1 N LOOM FROM STEERNG COLUMN POWER LOCK BLUE/RED (TYPE C) @ MODULE, UNDER DRVERS SEAT POWER UNLOCK BLACK (TYPE C) @ MODULE, UNDER DRVERS SEAT DOOR TRGGER BROWN/WHTE (-) N DRVERS KCK WELL DOMELGHT SUPERVSON USE DOOR TRGGER TRUNK RELEASE N/A SLDNG POWER DOOR N/A HORN N/A TACH N/A WAT TO START LGHT N/A BRAKE N/A FACTORY ALARM DSARM N/A ANT-THEFT N/A
EXTRA NFORMATON NOTE *1 this vehicle has 2 PARKNG LGHT wires, to connect will require 2 extra Relays Part #775, .