SPECIFICATIONS Specifications Dimensions and weights 296 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Engine 296 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fuel 296 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Service specifications 297 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Tires 299 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fuses 300 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 06 12.21 SECTION 8 296 2007 YARIS HATCHBACK from Feb. 07Prod. (OM52754U) Dimensions and weights Overall length mm (in.) 3825 (150.6) Overall width mm (in.) 1695 (66.7) Overall height mm (in.) 1530 (60.2) Wheelbase mm (in.) 2460 (96.9) Front tread mm (in.) 1470 (57.9) 2 Rear tread mm (in.) 1460 (57.5) 2 Gross Vehicle Mass kg (lb.) 1460 (3220) Curb weight distribution ( front/ rear ) % 50/50 1 : With P175/65R14 81S tires 2 : With P185/60R15 84T tires 3 : For Canada only Engine Model: 1.5 L 4cylinder (1NZFE) Type: 4 cylinder in line, 4 cycle, gasoline Bore and stroke, mm (in.): 75.0 84.7 (2.95 3.33) Displacement, cm 3 (cu. in.): 1496 (91.3) Fuel Fuel type: Unleaded gasoline, Octane Rating 87 (Research Octane Number 91) or higher Fuel tank capacity, L (gal., Imp. gal.): 42 (11.1, 9.2) 06 12.21 Kerb weight kg (lb.) 1059 (2335) Curb weight distribution ( front/rear ) % 297 2007 YARIS HATCHBACK from Feb. 07Prod. (OM52754U) Service specifications ENGINE Valve clearance (engine cold), mm (in.): Intake 0.150.25 (0.0060.010) Exhaust 0.250.35 (0.0100.014) Spark plug type: DENSO SK16R11 NGK IFR5A11 Spark plug gap, mm(in.): 1.1 (0.043) Drive belt tension measured with Boroughs drive belt tension gauge No. BT3373F (used belt), lbf: Generator belt 10020 ENGINE LUBRICATION Oil capacity (drain and refill), L (qt., Imp. qt.): With filter 3.7 (3.9, 3.3) Without filter 3.4 (3.6, 3.0) Toyota Genuine Motor Oil is used in your Toyota vehicle. Use Toyota approved Toyota Genuine Motor Oil or equivalent to satisfy the following grade and viscos- ity. Oil grade: ILSAC multigrade engine oil Please contact your Toyota dealer for fur- ther details. Recommended oil viscosity: SAE 5W30 OIL008 Outside temperature COOLING SYSTEM Total capacity, L (qt., Imp. qt.): Manual transmission 4.8 (5.1, 4.2) Automatic transmission 4.7 (5.0, 4.1) Coolant type: Toyota Super Long Life Coolant is used in your Toyota vehicle at factory fill. In order to avoid technical problems, only use Toyota Super Long Life Cool- ant or similar high quality ethylene gly- col based nonsilicate, nonamine, non nitrite, and nonborate coolant with longlife hybrid organic acid technology. (Coolant with longlife hybrid organic acid technology is a combination of low phosphates and organic acids.) Do not use plain water alone. Please contact your Toyota dealer for further details. BATTERY Open voltage
at 20_C (68_F): 12.612.8 V Fully charged 12.212.4 V Half charged 11.812.0 V Discharged
: Voltage that is checked 20 minutes af-
ter the key is removed with all the lights turned off Charging rates: 5 A max. 06 12.21 298 2007 YARIS HATCHBACK from Feb. 07Prod. (OM52754U) CLUTCH Pedal free play, mm (in.): 515 (0.20.6) Fluid type: SAE J1703 or FMVSS No. 116 DOT 3 MANUAL TRANSAXLE Oil capacity, L (qt., Imp. qt.): 1.9 (2.0, 1.7) Oil type: Gear oil API GL4 or GL5 Recommended oil viscosity: SAE 75W90 AUTOMATIC TRANSAXLE Fluid capacity (drain and refill), L (qt., Imp. qt.): 2.5 (2.6, 2.2) Fluid type: Toyota Genuine ATF WS Change automatic transmission fluid only as necessary. Generally, it is necessary to change automatic transmission fluid only if your vehicle is driven under one of the Special Operating Conditions listed in your Scheduled Maintenance Guide or Owners Manual Supplement. When changing the automatic transmission fluid, use only Toyota Genuine ATF WS (ATF JWS3324 or NWS9638) to aid in assuring maximum transaxle performance. Notice: Using automatic transmission fluid other than Toyota Genuine ATF WS may cause deterioration in shift quality, locking up of your transmission accompanied by vibration, and ultimate- ly damage the automatic transmission of your vehicle. Please contact your Toyota dealer for fur- ther details. BRAKES Minimum pedal clearance when depressed with the pressure of 300 N (31 kgf, 67.4 lbf) with the engine running, mm (in.): With antilock brake system 73 (2.9) Without antilock brake system 70 (2.8) Pedal free play, mm (in.): 16 (0.040.24) Pad wear limit, mm (in.): 1.0 (0.04) Lining wear limit, mm (in.): 1.0 (0.04) Parking brake adjustment when pulled with the force of 200 N (20 kgf, 45 lbf): 69 clicks Fluid type: SAE J1703 or FMVSS No. 116 DOT 3 STEERING Wheel free play: Less than 30 mm (1.2 in.) 06 12.21 299 2007 YARIS HATCHBACK from Feb. 07Prod. (OM52754U) Tires Tire size and cold tire inflation pressure: Front and rear kPa (kgf/cm 2 or bar, psi) Tire size Front Rear Wheel size P175/65R14 81S 220 (2.2, 32) 220 (2.2, 32) 14 x 5J P185/60R15 84T 220 (2.2, 32) 220 (2.2, 32) 15 x 5 1/2J For sustained high speeds above 160 km/h (100 mph), in countries where such speeds are permitted by law, add 20 kPa (0.2 kgf/cm 2 or bar, 3 psi) to the front tires and rear tires, but never exceed the maximum cold tire inflation pressure molded on the tire sidewall. Spare Tire size Tire inflation pressure kPa (kgf/cm 2 or bar, psi) Wheel size T125/70D15 95M 420 (4.2, 60) 15 x 4T Wheel nut torque, Nm (kgfm, ftIbf): 103 (10.5, 76) NOTE: For a complete information on tires (e.g. replacing tires or replacing wheels), see Checking tire inflation pressure through Aluminum wheel precautions, page 274 through 281 in Section 72. 06 12.21 300 2007 YARIS HATCHBACK from Feb. 07Prod. (OM52754U) Fuses PS81501 Engine compartment Fuses (type A) 1. AM2 15 A: Starting system, multiport fuel injection system/sequential multi- port fuel injection system 2. HORN 10 A: Horn 3. EFI 20 A: Multiport fuel injection sys- tem/sequential multiport fuel injection system 4. SPARE 30 A: Spare fuse 5. SPARE 15 A: Spare fuse 6. SPARE 10 A: Spare fuse 7. FR DEF 20 A: No circuit PS81502 Instrument panel 8. ABS2/VSC2 30 A: Antilock brake sys- tem 9. HLP MAIN 30 A: No circuit 10. ST 30 A: Starting system 11. SLOCK 20 A: No circuit 12. DOME 15 A: Interior light, personal lights, theft deterrent system, audio system, wireless remote control system 13. ECUB 7.5 A: Engine immobilizer sys- tem, daytime running light system, front passenger occupant classification sys- tem, power windows, door lock system, theft deterrent system, meter and gauge PS81503 Instrument panel 14. ALTS 7.5 A: Charging system 15. ETCS 10 A: Multiport fuel injection system/sequential multiport fuel injec- tion system, electronic throttle control system 16. HAZ 10 A: Turn signal lights, emergen- cy flashers 17. HLP RH/HLP LO RH 10 A: Right hand headlight 18. HLP LH/HLP LO LH 10 A: Left hand headlight 19. EFI2 10 A: Multiport fuel injection sys- tem/sequential multiport fuel injection system 06 12.21 301 2007 YARIS HATCHBACK from Feb. 07Prod. (OM52754U) PS81504 Instrument panel 20. ACC2 7.5 A: Shift lock system 21. TAIL 10 A: Side marker lights, parking lights, tail lights, license plate lights, multiport fuel injection system/sequen- tial multiport fuel injection system 22. PANEL1 7.5 A: Illuminations, instru- ment panel light control, meter and gauge 23. A/C 7.5 A: Rear window defogger, air conditioning system 24. D DOOR 20 A: No circuit 25. RL DOOR 20 A: Rear passengers power window (left side) PS81505 Engine compartment 26. RR DOOR 20 A: Rear passengers power window (right side) 27. CIG 15 A: Power outlet 28. ACC 7.5 A: Door lock system, outside rear view mirrors, audio system 29. ID/UP/MIR HTR 10 A: Multiport fuel injection system/sequential multiport fuel injection system 30. IGN 7.5 A: Multiport fuel injection sys- tem/sequential multiport fuel injection system, engine immobilizer system, SRS airbag system, front passenger occupant classification system 31. MET 7.5 A: Meter and gauge 32. WIP 25 A: Windshield wiper 33. RR WIP 15 A: Rear wiper 34. WSH 15 A: Windshield wiper and rear wiper 35. ECUIG 10 A: Daytime running light system, antilock brake system, elec- tric power steering system, power win- dows, door lock system, theft deterrent system, electric cooling fan 36. GAUGE 10 A: Charging system, turn signal lights, emergency flashers, buckup lights, instrument panel light control, shift lock system, rear window defogger, air conditioning system, auto- matic transmission system 37. OBD2 7.5 A: Onboard diagnosis sys- tem 38. STOP 10 A: Stop lights, high mounted stop light, multiport fuel injection sys- tem/sequential multiport fuel injection system, shift lock system, antilock brake system 39. D/L 25 A: Door lock system 40. FR FOG 15 A: Front fog lights 41. AM1 25 A: Multiport fuel injection sys- tem/sequential multiport fuel injection system 06 12.21 302 2007 YARIS HATCHBACK from Feb. 07Prod. (OM52754U) Fuses (type B) 42. HTR SUB2 40 A: Air conditioning sys- tem 43. EPS 50 A: Electric power steering sys- tem 44. ABS1/VSC1 50 A: Antilock brake sys- tem 45. HTR 40 A: Air conditioning system 46. RDI 30 A: Electric cooling fan 47. HTR SUB1 30 A: Air conditioning sys- tem 48. HLP CLN/PWR HTR 30 A: No circuit 49. AMT 50 A: No circuit 50. DEF 30 A: Rear window defogger 51. PWR 30 A: Power windows Fuses (type C) 52. ALT 120 A: Charging system, HTR SUB2, EPS, ABS1/VSC1, HTR, ABS2/VSC2, HTR SUB1, RDI, DEF, FR FOG, OBD2, D/L, STOP and AM1 fuses 53. MAIN 60 A: EFI, HORN, AM2, ALTS, DOME, ST, ECUB, ETCS, HAZ, HLP LH/HLP LO LH and HLP RH/HLP LO RH fuses 06 12.21