1
2 (ii) F directly proportional to (mv mu) / change of
momentum // F change of momentum
1
TOTAL 8 M
6 (a) Light that has one colour / wavelength / frequency 1
1
(b) M1 Overlapping between crest and crest / trough and
trough producing a constructive interference / bright
fringes
M2 Overlapping between crest and trough producing a
destructive interference / dark fringes
1
1
2
(c) (i) Diagram 6.1 < Diagram 6.2 / vice-versa // a1 < a2 / vice-
versa
1
4
(ii) Same / equal
1
(iii) Same / equal / D1 = D2
1
(iv) Diagram 6.1 > Diagram 6.2 / vice-versa
1
(d)
x
1
1 1
TOTAL 8 M
7 (a)(i) A material( that can) conduct (electricity) better than
insulators but not as good as metal conductor
1
1
(ii) Diagram 7.1 1
1
(iii) M1 A diode only allow current to flow in one direction //
Diode is in forward biased
M2 Resistance of diode is low
1
1
2
(b) (i)
1
2
(ii) Capacitor 1
SKEMA/4531/2 SET 1 MODUL G-CAKNA
PANEL MODUL G-CAKNA 4
QUESTION MARKING SCHEME
SUB-
MARK
TOTAL
MARK
(c) (i) (ii)
(iii)
M1 Susunan diod betul
M2 Kedudukan kapasitor selari dengan R (Terima tanpa
label symbol betul)
M3 Bentuk waveform betul
* Terima kedudukan diod dan waveform terbalik
1
1
1
3
(d) Full wave rectification 1 1
TOTAL 10 M
8 (a) - an unstable nuclei//unstable isotope 1 1
(b)(i) Fast moving electron 1
2
(ii) G-M tube 1
(c) (i) -not strong enough to pass through the juice 1
2
(ii) - will not be stopped by the juice 1
(d) Lead container 1 1
(e) (i) E 1
3
(ii) M1 the most radioactive emission pass through the
juice
M2 the reading of rate meter is the highest
1
1
(f) (i) still there is reading shown
1
3
(ii) M1 back ground reading
M2 back ground reading is from radioactive
materials naturally present in soil, rock or
cosmic radiation
1
1
TOTAL 12 M
SKEMA/4531/2 SET 1 MODUL G-CAKNA
PANEL MODUL G-CAKNA 5
QUESTION MARKING SCHEME
SUB-
MARK
TOTAL
MARK
9 (a) Quantity of heat required by 1 kg of mass to increase the
temperature by 1
o
C
1 1
(b) (i) Mass of cooking oil in Diagram 9.1 < Diagram 9.2 // vice-
versa
1
3
(ii) Quantity of heat is equal / same
1
(iii) final temperature in Diagram 9.1 > Diagram 9.2
1
(c) M1 When mass of cooking oil is small, the fish is
overcooked /scorched // vice-versa
M2 When mass is small, increase in temperature is
high // mass inversely proportional to increase in
temperature
1
1
2
(d) M1 During the day, the sea and the land receive the
same amount of heat from the sun
M2 Land heated to a high temperature because land
has low specific heat capacity // vice-versa
M3 During night, air above the land and sea release
Heat
M4 Temperature of the sea decreases slowly because
water has low specific heat capacity // vice-versa
1
1
1
1
4
(e) M1 Size of fan big
M2 More wind blows to cool the hot water faster
M3 Number of fins many
M4 Can cool the engine faster
M5 Cooling liquid is water
M6 High specific capacity// high boiling
point//cheap//easily available//does not react with
the inner part of engine
M7 Liquid that has high specific heat capacity
M8 Transfer large quantity of heat with small increase
in temperature
M9 Liquid of high boiling point
1
1
1
1
1
1
1
1
1
10
SKEMA/4531/2 SET 1 MODUL G-CAKNA
PANEL MODUL G-CAKNA 6
QUESTION MARKING SCHEME
SUB-
MARK
TOTAL
MARK
M10 Not easy to vapor when absorb heat from the
engine
1
TOTAL 10 M
10 (a) Current that produced when there is a relative motion
between a wire conductor and a solenoid, the magnetic
field is cuts
1 1
(b)(i) M1 The height is equal
M2 Number of turns in Diagram 10.1 < Diagram 10.2 //
vice-versa
M3 Angle of deflection in Diagram 10.1 < Diagram 10.2
// vice-versa
1
1
1
3
(ii) M1 When number of turns increases, angle of deflection
increases // vice-versa
M2 When the induced current produced increases, the
deflection of the galvanometer increases // vice-
versa
1
1
2
(c)(i) Lenzs law (Correct spelling)
1 1
(ii) M1 When ac current produced, the soft iron core is
magnetised and demagnetized
M2 Producing a changing magnetic flux
M3 Producing an induced voltage at secondary coil
1
1
1
3
(d) M1 Increase speed of rotation
M2 Increase the rate of cutting of magnetic flux
M3 Use a stronger magnet
M4 To produce more magnetic flux
M5 Increase the number of turns at coil
M6 More magnetic flux is cut
M7 The coil is wound on a soft iron core
M8 Increase the strength of magnetic flux
1
1
1
1
1
1
1
1
10
SKEMA/4531/2 SET 1 MODUL G-CAKNA
PANEL MODUL G-CAKNA 7
QUESTION MARKING SCHEME
SUB-
MARK
TOTAL
MARK
M9 Increase the area of cross section/
thickness / diameter of wire at coil
M10 Decrease resistance, more current is induced
1
1
TOTAL 20 M
11 (a) (i) Convex lens
1
(ii)
M1 Object at u < f
M2 Ray refract to F and ray pass through center of lens
M3 Virtual line and image is labeled
M4 State : Virtual, Upright, Magnified
1
1
1
1
4
(b) (i)
M1
1
5
//
100
5
M2 0.2 m // 20 cm
1
1
5
(ii)
M1
1
20
1
30
M2 60 cm // 0.6 m (Dengan unit)
1
1
(iii)
60
30
// 2 (tanpa unit)
1
SKEMA/4531/2 SET 1 MODUL G-CAKNA
PANEL MODUL G-CAKNA 8
(c)
Characteristics Explanation
Type of lenses
Jenis kanta:
convex
Produce real image
Focal length of objective
lens,fo / Focal length of
eyepiece lens,fe
Jarak fokus kanta objek fo/
Jarak fokus kanta mata fe,
4 cm / 6 cm
Both lenses have high
power of the lens to
produce bigger image
Distance between two
lenses, L (cm)
Jarak antara
dua kanta,
L (cm)
L > fo + fe
Normal adjustment to
produce sharp image
Power of eyepiece
Kuasa
kanta mata
High / tinggi
Eyepiece act as
magnifying glass to
magnified the image
Choosen : R Because R are convex
lenses,has f0= 4 cm and
fe = 6 cm, L > fo + fe and
has high power of
eyepiece.
1, 1
1, 1
1 , 1
1.1
1,1
10
TOTAL 20 M
12 (a) 1 000 J of energy is consumed in 1 s when connected to a
240 V power supply
1 1
(b) (i) M1 1 000 x 2 x 60 x 60
M2 7.2 x 10
6
J (With unit)
1
1
4
(ii)
M1
1000
240
M2 4.17 A (with unit)
1
1
(c) (i) M1 When high current flows / short circuit occurs
M2 The wire in the fuse will melt and break the circuit
1
1
2
(ii) 5 A
1 1
(iii) M1 Live wire
M2 Because live wire carries current
1
1
2
SKEMA/4531/2 SET 1 MODUL G-CAKNA
PANEL MODUL G-CAKNA 9
QUESTION MARKING SCHEME
SUB-
MARK
TOTAL
MARK
(d) M1 Melting point is low
M2 Easy to break the circuit when high current flows
through it
M3 Low specific heat capacity
M4 Easy to get hot
M5 High resistance
M6 Easy to get hot
M7 Thickness of wire small / thin wire
M8 High resistance // Easy to hot // less mass //
requires small space
M9 M
M10 Because (M1,3,5 & 7 / M2,4.6.8)
1
1
1
1
1
1
1
1
1
1
10
TOTAL 20 M
SKEMA TAMAT.
Skema ini adalah cadangan jawapan. Jika ada jawapan lain yang setara
adalah mengikut budi bicara tuan/puan.