property they are not to be used on other work and are to be returned These drawings and copies thereof furnished by the architect are his user thereof becomes indebted to the architect for full commission. thereof is used in any manner without the consent of the architect the P R O J E C T N U M B E R D R A WN B Y D A T E S C A L E planner interiors NCARB CERTIFICATE # 42,136 Ph: 305-532-6161 * Fax: 305-532-6151 architect ARCHITECTURE LICENSE # AR14022 1665 WASHINGTON AVE. 2nd. FLOOR MIAMI BEACH, FLORIDA 33139 CHARLES H. BENSON & ASSOCIATES ARCHITECTS, P.A. MIAMI BEACH, FL. 33139 302- 336 COLLINS AVENUE JHPSB COLLINS VENTURES, LLC NEW 20 UNIT CONDO FOR: 21411 Urban Robot LLC AS SHOWN 8-25-14 LC26000510 URBAN ROBOT LLC STATE OF FLORIDA REGISTERED LANDSCAPE ARCHITECT BUSINESS ISSUED FOR CONSTRUCTION ISSUED FOR PERMIT ISSUED FOR BIDDING DESIGNER: Thomas Juul-Hansen, LLC 40 WORTH STREET, SUITE 814 New York, NY 10013 Tel (212) 929.7109 Fax (212) 929.7116 L-001 TREE DISPOSITION PLAN HPB FINAL SUBMITTAL 011 010 009 008 007 006 005 004 003 002 001 012 013 PARKING GYM LOBBY UNENCLOSED FORECOURT WATER FEATURE U P R C 2 4 " D R C 2 4 " D U P R C 2 4 " D R C 2 4 " D U P U P 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 25 26 28 32 33 34 35 42 36 37 40 39 36 3 63 6 43 38 3 6 24 36 36 27 29 3 6 30 31 41 36 U P U P U P D N EXISTING LOBBY EXIST. RECEPTION DESK EX ISTIN G C O R R ID O R EXIST. ROOM 116 EXIST. ROOM 114 EXIST. ROOM 112 EXIST. ROOM 110 EXIST. ROOM 108 EXIST. ROOM 106 EXIST. ROOM 104 EXIST. OFFICE EXIST. ROOM 117 EXIST. ROOM 115 EXIST. ROOM 111 EXIST. ROOM 109 EXIST. ROOM 107 EXIST. ROOM 105 EXIST. ROOM 102 EXIST. ROOM 101 EXISTING PORCH PER V IO U S PA V ER W A LK W A Y 3 R D
S T COLLINS CT. PAD MOUNTED TRANS- FORMER PER V IO U S PA V ER W A LK W A Y COLLINS AVE No. Botanical Name Common Name DBH Spread Ht. Action Reason / Notes 001 Ficus benjamina Weeping Fig 16" 24' 24' REMOVE impedes future construction, non-native, never specimen size 002 Cocos nucifera Coconut Palm 7" 14' 16' TO REMAIN street tree in good condition 003 Cocos nucifera Coconut Palm 7" 14' 18' TO REMAIN street tree in good condition 004 Cocos nucifera Coconut Palm 7" 14' 24' TO REMAIN street tree in good condition 005 Cocos nucifera Coconut Palm 7" 14' 24' TO REMAIN street tree in good condition 006 Cocos nucifera Coconut Palm 7" 14' 24' TO REMAIN street tree in good condition 007 Cocos nucifera Coconut Palm 7" 14' 18' TO REMAIN street tree in good condition 008 Cocos nucifera Coconut Palm 9" 15' 20' TO REMAIN street tree in good condition 009 Cocos nucifera Coconut Palm 9" 15' 32' TO REMAIN street tree in good condition 010 Cocos nucifera Coconut Palm 9" 15' 28' TO REMAIN street tree in good condition 011 Cocos nucifera Coconut Palm 9" 15' 28' TO REMAIN street tree in good condition 012 Cocoloba diversifolia Pigeon Plum 2.5" 7' 12' TO REMAIN street tree in good condition 013 Cocoloba diversifolia Pigeon Plum 2.5" 7' 12' TO REMAIN street tree in good condition N SCALE: 1/8" = 1'-0" 1 TREE DISPOSITION PLAN (PROPOSED BUILDING FLOOR PLANS SHOWN) 000 000 000 EXISTING TREE TO REMOVE EXISTING TREE TO RELOCATE EXISTING TREE TO REMAIN TREE DISPOSITION LEGEND 001 002 003 007 010 NW CORNER OF PROPERTY NEIGHBORING POINCIANA NOTES URBAN ROBOT LLC MI A MI BEA CH, FL 3 3 13 9 T.786.246.4857 | F.786.768.2537 WWW. URBANROBOT. NET 420 LI NCOLN ROAD S.406 LANDSCAPE ARCHITECT: EXISTING TREE SCHEDULE AND DISPOSITION 011 010 009 008 013 012 007 001 001 006 005 004 003 002 PROJECT INFORMATION REFER TO ARCHITECTURE FOR SITE, BUILDING & ZONING INFORMATION. PLANTING ALL PLANT MATERIAL SHALL MEET OR EXCEED THE MINIMUM STANDARDS FOR FLORIDA NUMBER ONE AS PROVIDED IN THE MOST CURRENT EDITION OF "GRADES AND STANDARDS FOR NURSERY PLANTS, PART I AND II". STREET TREES STREET TREES SHALL MEET CMB REQUIREMENTS AND THE STANDARDS OUTLINED IN THE MIAMI DADE COUNTY STREET TREE MASTER PLAN. PUBLIC WORKS REMOVE AND REPLACE SIDEWALK. RECONSTRUCT SWALE. MILL AND RESURFACE 2 IN. AVG. USING TYPE S-III ASPHALT MIX DESIGN ON THE DRIVING LANE. ANY WORK AND/OR IMPROVEMENTS TO THE RIGHT OF WAY INCLUDING LANDSCAPING AND IRRIGATION REQUIRE A SEPARATE CMB PUBLIC WORKS DEPT. ROW CONSTRUCTION PERMIT. upon demand at the completion of work. If this drawing or any part property they are not to be used on other work and are to be returned These drawings and copies thereof furnished by the architect are his user thereof becomes indebted to the architect for full commission. thereof is used in any manner without the consent of the architect the P R O J E C T N U M B E R D R A WN B Y D A T E S C A L E planner interiors NCARB CERTIFICATE # 42,136 Ph: 305-532-6161 * Fax: 305-532-6151 architect ARCHITECTURE LICENSE # AR14022 1665 WASHINGTON AVE. 2nd. FLOOR MIAMI BEACH, FLORIDA 33139 CHARLES H. BENSON & ASSOCIATES ARCHITECTS, P.A. MIAMI BEACH, FL. 33139 302- 336 COLLINS AVENUE JHPSB COLLINS VENTURES, LLC NEW 20 UNIT CONDO FOR: 21411 Urban Robot LLC AS SHOWN 8-25-14 LC26000510 URBAN ROBOT LLC STATE OF FLORIDA REGISTERED LANDSCAPE ARCHITECT BUSINESS ISSUED FOR CONSTRUCTION ISSUED FOR PERMIT ISSUED FOR BIDDING DESIGNER: Thomas Juul-Hansen, LLC 40 WORTH STREET, SUITE 814 New York, NY 10013 Tel (212) 929.7109 Fax (212) 929.7116 L-100 LEVEL 1 PLANTING PLAN HPB FINAL SUBMITTAL 25' 25' 25' 25'-6" (EXISTING) 25'-6" (EXISTING) 33'-6" (EXISTING) 16' (EXISTING) 6' 6' 4' 2'-6" 4' 2'-6" EXISTING STREET LAMP EXISTING STREET LAMP EXISTING PARKING METER MACHINE EXISTING STREET LAMP EXISTING STREET LAMP EXISTING PARKING METER MACHINE NEW TREE WELL AND STREET TREE EXISTING TREE WELL AND NEW STREET TREE NEW TREE WELL AND STREET TREE ADDAPAVE (TYPICAL OF ALL STREET TREES) PARKING GYM LOBBY UNENCLOSED FORECOURT WATER FEATURE Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td TR TR TR TR TR TR TR TR TR TR TR TR TR TR TR TR TR TR TR TR TR TR TR TR TR TR TR TR TR TR TR EC EC EC EC EC EC fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm CD CD EC CN EC EC EC CN CN Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm U P U P U P U P 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 25 26 28 32 33 34 35 42 36 37 40 39 43 38 24 27 29 30 31 41 U P U P U P D N EXISTING LOBBY EXIST. RECEPTION DESK EX ISTIN G C O R R ID O R EXIST. ROOM 116 EXIST. ROOM 114 EXIST. ROOM 112 EXIST. ROOM 110 EXIST. ROOM 108 EXIST. ROOM 106 EXIST. ROOM 104 EXIST. OFFICE EXIST. ROOM 117 EXIST. ROOM 115 EXIST. ROOM 111 EXIST. ROOM 109 EXIST. ROOM 107 EXIST. ROOM 105 EXIST. ROOM 102 EXIST. ROOM 101 EXISTING PORCH PER V IO U S PA V ER W A LK W A Y 3 R D
S T COLLINS CT. PAD MOUNTED TRANS- FORMER Fm Fm Fm Fm CG CG Td Td Td Td CG Td Td Fm Fm Fm MF MF MF MF MF MF MF MF MF MF MF MF MF PER V IO U S PA V ER W A LK W A Y MF MF MF MF MF MF MF MF MF MF MF MF MF COLLINS AVE CITY SIDEWALK; SEE CIVIL ENG. PLANTING SOIL GEOTEXTILE FABRIC #57 AGGREGATE, 2-3" DEPTH ADDAPAVE PER MANUF. RECOMMENDATIONS CONCRETE CURB; SEE CIVIL ENG. EXISTING SUBGRADE TRENCH DRAIN & IRRIGATION SLEEVING DRAIN GRATE TREE ROOTBALL; SIZE VARIES Abbv. Botanical Name Common Name Qty Specifications TREES & PALMS CN Cocos nucifera Coconut Palm 3 20-22' OA,8-9' GW, Straight Trunks, Matching (street trees) CG Caesalpinia granadillo Bridalveil Tree 3 200 gal, single leader standard, 4" CAL, 16' OA, 10' SPR MF Myrcianthes fragrans Simpson Stopper 26 100 gal, Standard, 3" CAL, 12-14' OA, 8' SPR TR Thrinax radiata Florida Thatch Palm 31 Single trunk, 12' OA, min 4.5' CT, intact stems on trunk, matching EXISTING TREES & PALMS EC Cocos nucifera Coconut Palm 10 Existing to Remain CD Coccoloba diversifolia Pigeon Plum 2 Existing to Remain SHRUBS & ACCENTS Td Tripsacum dactyloides Fakahatchee Grass 78 7 gal full Fm Ficus microcarpa 'Green Island' Green Island Ficus 139 7 gal GROUNDCOVERS &VINES [hatch] Ficus microcarpa 'Green Island' Green Island Ficus 170 Liner --170 sq. ft. @ 8" o.c. fr Ficus repens Creeping Fig 39 1 gal ?? Something for the alleyway Something for the alleyway 1 gal Abbv. Botanical Name Common Name Qty Specifications TREES & PALMS CN Cocos nucifera Coconut Palm 3 20-22' OA,8-9' GW, Straight Trunks, Matching (street trees) CG Caesalpinia granadillo Bridalveil Tree 3 200 gal, single leader standard, 4" CAL, 16' OA, 10' SPR MF Myrcianthes fragrans Simpson Stopper 26 100 gal, Standard, 3" CAL, 12-14' OA, 8' SPR TR Thrinax radiata Florida Thatch Palm 31 Single trunk, 12' OA, min 4.5' CT, intact stems on trunk, matching EXISTING TREES & PALMS EC Cocos nucifera Coconut Palm 10 Existing to Remain CD Coccoloba diversifolia Pigeon Plum 2 Existing to Remain SHRUBS & ACCENTS Td Tripsacum dactyloides Fakahatchee Grass 78 7 gal full Fm Ficus microcarpa 'Green Island' Green Island Ficus 139 7 gal GROUNDCOVERS &VINES [hatch] Ficus microcarpa 'Green Island' Green Island Ficus 170 Liner --170 sq. ft. @ 8" o.c. fr Ficus repens Creeping Fig 39 1 gal ?? Something for the alleyway Something for the alleyway 1 gal Abbv. Botanical Name Common Name Qty Specifications TREES & PALMS CN Cocos nucifera Coconut Palm 3 20-22' OA,8-9' GW, Straight Trunks, Matching (street trees) CG Caesalpinia granadillo Bridalveil Tree 3 200 gal, single leader standard, 4" CAL, 16' OA, 10' SPR MF Myrcianthes fragrans Simpson Stopper 26 100 gal, Standard, 3" CAL, 12-14' OA, 8' SPR TR Thrinax radiata Florida Thatch Palm 31 Single trunk, 12' OA, min 4.5' CT, intact stems on trunk, matching EXISTING TREES & PALMS EC Cocos nucifera Coconut Palm 10 Existing to Remain CD Coccoloba diversifolia Pigeon Plum 2 Existing to Remain SHRUBS & ACCENTS Td Tripsacum dactyloides Fakahatchee Grass 78 7 gal full Fm Ficus microcarpa 'Green Island' Green Island Ficus 139 7 gal GROUNDCOVERS &VINES [hatch] Ficus microcarpa 'Green Island' Green Island Ficus 170 Liner --170 sq. ft. @ 8" o.c. fr Ficus repens Creeping Fig 39 1 gal ?? Something for the alleyway Something for the alleyway 1 gal N SCALE: 1/8" = 1'-0" 1 LEVEL 1 PLANTING PLAN 2 Typical Addapave Detail 3 Thrinax radiata 4 Tripsacum dactyloides 5 Cocos nucifera 001 002 003 007 010 NW CORNER OF PROPERTY NEIGHBORING POINCIANA NOTES GREEN ISLAND FICUS SYMBOL LEGEND PLANT SCHEDULE & SPECIFICATIONS N.T.S. PLANT SCHEDULE & SPECIFICATIONS continued URBAN ROBOT LLC MI A MI BEA CH, FL 3 3 13 9 T.786.246.4857 | F.786.768.2537 WWW. URBANROBOT. NET 420 LI NCOLN ROAD S.406 LANDSCAPE ARCHITECT: PROJECT INFORMATION REFER TO ARCHITECTURE FOR SITE, BUILDING & ZONING INFORMATION. PLANTING ALL PLANT MATERIAL SHALL MEET OR EXCEED THE MINIMUM STANDARDS FOR FLORIDA NUMBER ONE AS PROVIDED IN THE MOST CURRENT EDITION OF "GRADES AND STANDARDS FOR NURSERY PLANTS, PART I AND II". STREET TREES STREET TREES SHALL MEET CMB REQUIREMENTS AND THE STANDARDS OUTLINED IN THE MIAMI DADE COUNTY STREET TREE MASTER PLAN. PUBLIC WORKS REMOVE AND REPLACE SIDEWALK. RECONSTRUCT SWALE. MILL AND RESURFACE 2 IN. AVG. USING TYPE S-III ASPHALT MIX DESIGN ON THE DRIVING LANE. ANY WORK AND/OR IMPROVEMENTS TO THE RIGHT OF WAY INCLUDING LANDSCAPING AND IRRIGATION REQUIRE A SEPARATE CMB PUBLIC WORKS DEPT. ROW CONSTRUCTION PERMIT. FOUNDATIONS / STRUCTURAL ANY STRUCTURAL BUILDING FOUNDATION THAT MAY PROJECT INTO A LANDSCAPED AREA SHALL BE DESIGNED TO BE A MINIMUM OF 42" BELOW GRADE IN ORDER TO AVOID ANY CONFLICT WITH THE ROOT SYSTEM OF THE PLANT MATERIAL. upon demand at the completion of work. If this drawing or any part property they are not to be used on other work and are to be returned These drawings and copies thereof furnished by the architect are his user thereof becomes indebted to the architect for full commission. thereof is used in any manner without the consent of the architect the P R O J E C T N U M B E R D R A WN B Y D A T E S C A L E planner interiors NCARB CERTIFICATE # 42,136 Ph: 305-532-6161 * Fax: 305-532-6151 architect ARCHITECTURE LICENSE # AR14022 1665 WASHINGTON AVE. 2nd. FLOOR MIAMI BEACH, FLORIDA 33139 CHARLES H. BENSON & ASSOCIATES ARCHITECTS, P.A. MIAMI BEACH, FL. 33139 302- 336 COLLINS AVENUE JHPSB COLLINS VENTURES, LLC NEW 20 UNIT CONDO FOR: 21411 Urban Robot LLC AS SHOWN 8-25-14 LC26000510 URBAN ROBOT LLC STATE OF FLORIDA REGISTERED LANDSCAPE ARCHITECT BUSINESS ISSUED FOR CONSTRUCTION ISSUED FOR PERMIT ISSUED FOR BIDDING DESIGNER: Thomas Juul-Hansen, LLC 40 WORTH STREET, SUITE 814 New York, NY 10013 Tel (212) 929.7109 Fax (212) 929.7116 L-101 LEVEL 2 PLANTING PLAN HPB FINAL SUBMITTAL 4'-3 5/8" 13'-6" 5 '-6 " BENCH BENCH 18" x 36" STEPPING STONES BROMELIAD GROUNDCOVER "CARPET" DWARF MEXICAN PETUNIA "CARPET" BRIDAL WREATH VINE OVERHANGS PLANTER STONE SURROUND TO MATCH PATIO STONE PATIO TO MATCH HOT TUB SURROUND BENCH BENCH U P D N U P D N U P D N U P D N 2 C 1 B R - 1 W C 1 4 7 0 S F 2 F 3 B R - 4 W C 2 2 0 0 S F 2 E 2 B R - 2 W C 1 2 1 5 S F M A S T E R B E D R O O M B R 2 2 B 3 B R - 4 W C 2 1 5 0 S F (2 4 0 0 S F ) 2 A 3 B R - 4 W C 2 1 5 0 S F (2 4 4 0 S F ) M A S T E R B E D R O O M B R 2 B R 3 B R 2 B R 3 M A S T E R B E D R O O M M A S T E R B E D R O O M M A S T E R B E D R O O M B R 2 B R 2 B R 2 2 D 2 B R - 2 W C 1 2 1 5 S F 2 E 6 0 0 S F U N E N C L O S E D T E R R A C E 2 D 4 2 6 S F U N E N C L O S E D T E R R A C E 2 B 1 5 5 S F U N E N C L O S E D T E R R A C E 2 B 2 3 0 S F U N E N C L O S E D T E R R A C E 2 A 3 8 0 S F U N E N C L O S E D T E R R A C E Jb Jb Lc Bo Bo Bo Bo Jb Jb Jb Jb Jb Jb Jb Jb Jb Jb Jb Jb Jb Jb Jb Jb Jb Jb Jb Jb Jb Ao Ao Az Az Az Az Re Re Re pbm pbm Ao CG Pm Ds Ai Lc Fl Nc Nc Nc PP PP PP PP PP PP PP PP PP PP Pn Pn Pn 8FT DINING TABLE 4'x6' HOT TUB Ga LAWN LAWN Pn Pn Pn Pn Pm CN Pn Pn Pn Pn Pn Pn Pn MF PO Ga Am MC Az Az Az Az Az Az Az Az Az Re Lc Nc Nc Fl Nc Nc Nc PP PP PP PP PP PP PP PP PP PP Bo Bo Bo Bo Bo Bo Bo Pn Pn Pn Pn Pn Pn Pn Pn Pn CN Bo Bo Bo Bo Am Bo Jb Ga Jb Jb MF Pm CG pbm Ao Bo Bo Bo PO Ao Ga Ao Ds MC Az Az Az Az Az Az Az Az Az Re Lc Nc Nc Fl Nc Nc Nc PP PP PP PP PP PP PP PP PP PP Bo Bo Bo Bo Bo Bo Bo Pn Pn Pn Pn Pn Pn Pn Pn Pn CN Bo Bo Bo Bo Am Bo Jb Ga Jb Jb MF Pm CG pbm Ao Bo Bo Bo PO Ao Ga Ao Ds MC Az Az Az Az Az Az Az Az Az Re Lc Nc Nc Fl Nc Nc Nc PP PP PP PP PP PP PP PP PP PP Bo Bo Bo Bo Bo Bo Bo Pn Pn Pn Pn Pn Pn Pn Pn Pn CN Bo Bo Bo Bo Am Bo Jb Ga Jb Jb MF Pm CG pbm Ao Bo Bo Bo PO Ao Ga Ao Ds LAWN LAWN LAWN STONE TILE T.B.D. BY ARCHITECT STONE TILE T.B.D. BY ARCHITECT STONE TILE T.B.D. BY ARCHITECT STONE TILE T.B.D. BY ARCHITECT PLANTER PLANTER W /D W /D W /D Hc Hc Hc Hc Hc Hc Hc Hc Hc Td Mc Td Td Td Td Hc Td Hc Td Hc Td Hc Td Hc Td Hc SECOND FLOOR Abbv. Botanical Name Common Name Qty Specications TREES & PALMS CG Caesalpinia granadillo Bridalveil Tree 4 200 gal, single leader standard, 4" CAL, 16' OA, 10' SPR CN Cocos nucifera Coconut Palm 4 20-22' OA, 8-9' GW, Straight Trunks, Matching (street trees) MC Michelia champaca Gold-Orange Michelia 4 65 gal, 10' OA MF Myrcianthes fragrans Simpson Stopper 4 100 gal multi-stemmed (if bush, to be limbed up onsite) PO Plumeria obtusa 'Dwarf Singapore Pink' Dwarf Singapore Pink Frangipani 4 Single trunk, 12' OA, min 4.5' CT, intact stems on trunk, matching PP Plumeria pudica Bridal Bouquet 40 25 gal SHRUBS & ACCENTS Ai Alcantarea imperialis Same 1 15 gal Ao Alcantarea odorata Same 12 15 gal Am Alocasia macrorrhiza 'Black Stem' Black Stem Elephant Ear 4 7 gal Az Alpinia zerumbet Shell Ginger Green 31 7 gal Bo Begonia odorata 'Alba' White Begonia 49 3 gal Ds Dioon spinulosum Mexican Cycad 4 25 gal Fl Ficus lyrata Fiddle Leaf Ficus 4 15 gal bush 7-8' OA Ga Gardenia augusta 'Miami Supreme' Same 8 15 gal standard grafted Hc Heliconia caribaea x bihai 'Jacquinii' Heliconia 15 15 gal Jb Justicia brandegeana Red Shrimp Plant 32 3 gal Lc Leea coccinea 'Rubra' Red Leea 5 15 gal Mc Medinilla cumingii Same 4 7 gal Nc Neomarica caerulea Apostles Iris 18 3 gal Pm Philodendron magnicum Same 5 15 gal Pn Psychotria nervosa Wild Coffee 41 7 gal full Re Rhapis excelsa Lady Palm 6 45 gal Florida Fancy Td Tabernaemontana divaricata Crape Jasmine 10 15 gal bush GROUNDCOVERS &VINES [hatch] Microsorum scolopendrium Wart Fern 340 1 gal -- 200 sq. ft. @ 10" o.c. [hatch] Neoregelia Bossa Nova Same 150 1 gal -- 200 sq. ft. @ 15" o.c. [hatch] Neoregelia Fireball Same 85 1 gal -- 70 sq. ft. @12" o.c. pbm Philodendron Burle Marx Same 5 3 gal [hatch] Ruellia brittoniana 'Compacta' or 'Dwarf' Dwarf Mexican Petunia 40 1 gal -- 30 sq. ft. @12" o.c. [hatch] Sedum sarmentosum Star Sedum 260 1 gal -- 350 sq. ft. every 15" o.c. [hatch] Stephanotis oribunda Bridal Wreath Vine 70 7 gal -- 70 linear ft. every 32" o.c. SECOND FLOOR Abbv. Botanical Name Common Name Qty Specications TREES & PALMS CG Caesalpinia granadillo Bridalveil Tree 4 200 gal, single leader standard, 4" CAL, 16' OA, 10' SPR CN Cocos nucifera Coconut Palm 4 20-22' OA, 8-9' GW, Straight Trunks, Matching (street trees) MC Michelia champaca Gold-Orange Michelia 4 65 gal, 10' OA MF Myrcianthes fragrans Simpson Stopper 4 100 gal multi-stemmed (if bush, to be limbed up onsite) PO Plumeria obtusa 'Dwarf Singapore Pink' Dwarf Singapore Pink Frangipani 4 Single trunk, 12' OA, min 4.5' CT, intact stems on trunk, matching PP Plumeria pudica Bridal Bouquet 40 25 gal SHRUBS & ACCENTS Ai Alcantarea imperialis Same 1 15 gal Ao Alcantarea odorata Same 12 15 gal Am Alocasia macrorrhiza 'Black Stem' Black Stem Elephant Ear 4 7 gal Az Alpinia zerumbet Shell Ginger Green 31 7 gal Bo Begonia odorata 'Alba' White Begonia 49 3 gal Ds Dioon spinulosum Mexican Cycad 4 25 gal Fl Ficus lyrata Fiddle Leaf Ficus 4 15 gal bush 7-8' OA Ga Gardenia augusta 'Miami Supreme' Same 8 15 gal standard grafted Hc Heliconia caribaea x bihai 'Jacquinii' Heliconia 15 15 gal Jb Justicia brandegeana Red Shrimp Plant 32 3 gal Lc Leea coccinea 'Rubra' Red Leea 5 15 gal Mc Medinilla cumingii Same 4 7 gal Nc Neomarica caerulea Apostles Iris 18 3 gal Pm Philodendron magnicum Same 5 15 gal Pn Psychotria nervosa Wild Coffee 41 7 gal full Re Rhapis excelsa Lady Palm 6 45 gal Florida Fancy Td Tabernaemontana divaricata Crape Jasmine 10 15 gal bush GROUNDCOVERS &VINES [hatch] Microsorum scolopendrium Wart Fern 340 1 gal -- 200 sq. ft. @ 10" o.c. [hatch] Neoregelia Bossa Nova Same 150 1 gal -- 200 sq. ft. @ 15" o.c. [hatch] Neoregelia Fireball Same 85 1 gal -- 70 sq. ft. @12" o.c. pbm Philodendron Burle Marx Same 5 3 gal [hatch] Ruellia brittoniana 'Compacta' or 'Dwarf' Dwarf Mexican Petunia 40 1 gal -- 30 sq. ft. @12" o.c. [hatch] Sedum sarmentosum Star Sedum 260 1 gal -- 350 sq. ft. every 15" o.c. [hatch] Stephanotis oribunda Bridal Wreath Vine 70 7 gal -- 70 linear ft. every 32" o.c. SECOND FLOOR Abbv. Botanical Name Common Name Qty Specications TREES & PALMS CG Caesalpinia granadillo Bridalveil Tree 4 200 gal, single leader standard, 4" CAL, 16' OA, 10' SPR CN Cocos nucifera Coconut Palm 4 20-22' OA, 8-9' GW, Straight Trunks, Matching (street trees) MC Michelia champaca Gold-Orange Michelia 4 65 gal, 10' OA MF Myrcianthes fragrans Simpson Stopper 4 100 gal multi-stemmed (if bush, to be limbed up onsite) PO Plumeria obtusa 'Dwarf Singapore Pink' Dwarf Singapore Pink Frangipani 4 Single trunk, 12' OA, min 4.5' CT, intact stems on trunk, matching PP Plumeria pudica Bridal Bouquet 40 25 gal SHRUBS & ACCENTS Ai Alcantarea imperialis Same 1 15 gal Ao Alcantarea odorata Same 12 15 gal Am Alocasia macrorrhiza 'Black Stem' Black Stem Elephant Ear 4 7 gal Az Alpinia zerumbet Shell Ginger Green 31 7 gal Bo Begonia odorata 'Alba' White Begonia 49 3 gal Ds Dioon spinulosum Mexican Cycad 4 25 gal Fl Ficus lyrata Fiddle Leaf Ficus 4 15 gal bush 7-8' OA Ga Gardenia augusta 'Miami Supreme' Same 8 15 gal standard grafted Hc Heliconia caribaea x bihai 'Jacquinii' Heliconia 15 15 gal Jb Justicia brandegeana Red Shrimp Plant 32 3 gal Lc Leea coccinea 'Rubra' Red Leea 5 15 gal Mc Medinilla cumingii Same 4 7 gal Nc Neomarica caerulea Apostles Iris 18 3 gal Pm Philodendron magnicum Same 5 15 gal Pn Psychotria nervosa Wild Coffee 41 7 gal full Re Rhapis excelsa Lady Palm 6 45 gal Florida Fancy Td Tabernaemontana divaricata Crape Jasmine 10 15 gal bush GROUNDCOVERS &VINES [hatch] Microsorum scolopendrium Wart Fern 1 gal [hatch] Neoregelia Bossa Nova Same 1 gal [hatch] Neoregelia Fireball Same 1 gal pbm Philodendron Burle Marx Same 5 3 gal [hatch] Ruellia brittoniana 'Compacta' or 'Dwarf' Dwarf Mexican Petunia 1 gal [hatch] Stephanotis oribunda Bridal Wreath Vine 7 gal SECOND FLOOR Abbv. Botanical Name Common Name Qty Specications TREES & PALMS CG Caesalpinia granadillo Bridalveil Tree 4 200 gal, single leader standard, 4" CAL, 16' OA, 10' SPR CN Cocos nucifera Coconut Palm 4 20-22' OA, 8-9' GW, Straight Trunks, Matching (street trees) MC Michelia champaca Gold-Orange Michelia 4 65 gal, 10' OA MF Myrcianthes fragrans Simpson Stopper 4 100 gal multi-stemmed (if bush, to be limbed up onsite) PO Plumeria obtusa 'Dwarf Singapore Pink' Dwarf Singapore Pink Frangipani 4 Single trunk, 12' OA, min 4.5' CT, intact stems on trunk, matching PP Plumeria pudica Bridal Bouquet 40 25 gal SHRUBS & ACCENTS Ai Alcantarea imperialis Same 1 15 gal Ao Alcantarea odorata Same 12 15 gal Am Alocasia macrorrhiza 'Black Stem' Black Stem Elephant Ear 4 7 gal Az Alpinia zerumbet Shell Ginger Green 31 7 gal Bo Begonia odorata 'Alba' White Begonia 49 3 gal Ds Dioon spinulosum Mexican Cycad 4 25 gal Fl Ficus lyrata Fiddle Leaf Ficus 4 15 gal bush 7-8' OA Ga Gardenia augusta 'Miami Supreme' Same 8 15 gal standard grafted Hc Heliconia caribaea x bihai 'Jacquinii' Heliconia 15 15 gal Jb Justicia brandegeana Red Shrimp Plant 32 3 gal Lc Leea coccinea 'Rubra' Red Leea 5 15 gal Mc Medinilla cumingii Same 4 7 gal Nc Neomarica caerulea Apostles Iris 18 3 gal Pm Philodendron magnicum Same 5 15 gal Pn Psychotria nervosa Wild Coffee 41 7 gal full Re Rhapis excelsa Lady Palm 6 45 gal Florida Fancy Td Tabernaemontana divaricata Crape Jasmine 10 15 gal bush GROUNDCOVERS &VINES [hatch] Microsorum scolopendrium Wart Fern 340 1 gal -- 200 sq. ft. @ 10" o.c. [hatch] Neoregelia Bossa Nova Same 150 1 gal -- 200 sq. ft. @ 15" o.c. [hatch] Neoregelia Fireball Same 85 1 gal -- 70 sq. ft. @12" o.c. pbm Philodendron Burle Marx Same 5 3 gal [hatch] Ruellia brittoniana 'Compacta' or 'Dwarf' Dwarf Mexican Petunia 40 1 gal -- 30 sq. ft. @12" o.c. [hatch] Sedum sarmentosum Star Sedum 260 1 gal -- 350 sq. ft. every 15" o.c. [hatch] Stephanotis oribunda Bridal Wreath Vine 70 7 gal -- 70 linear ft. every 32" o.c. SECOND FLOOR Abbv. Botanical Name Common Name Qty Specications TREES & PALMS CG Caesalpinia granadillo Bridalveil Tree 4 200 gal, single leader standard, 4" CAL, 16' OA, 10' SPR CN Cocos nucifera Coconut Palm 4 20-22' OA, 8-9' GW, Straight Trunks, Matching (street trees) MC Michelia champaca Gold-Orange Michelia 4 65 gal, 10' OA MF Myrcianthes fragrans Simpson Stopper 4 100 gal multi-stemmed (if bush, to be limbed up onsite) PO Plumeria obtusa 'Dwarf Singapore Pink' Dwarf Singapore Pink Frangipani 4 Single trunk, 12' OA, min 4.5' CT, intact stems on trunk, matching PP Plumeria pudica Bridal Bouquet 40 25 gal SHRUBS & ACCENTS Ai Alcantarea imperialis Same 1 15 gal Ao Alcantarea odorata Same 12 15 gal Am Alocasia macrorrhiza 'Black Stem' Black Stem Elephant Ear 4 7 gal Az Alpinia zerumbet Shell Ginger Green 31 7 gal Bo Begonia odorata 'Alba' White Begonia 49 3 gal Ds Dioon spinulosum Mexican Cycad 4 25 gal Fl Ficus lyrata Fiddle Leaf Ficus 4 15 gal bush 7-8' OA Ga Gardenia augusta 'Miami Supreme' Same 8 15 gal standard grafted Hc Heliconia caribaea x bihai 'Jacquinii' Heliconia 15 15 gal Jb Justicia brandegeana Red Shrimp Plant 32 3 gal Lc Leea coccinea 'Rubra' Red Leea 5 15 gal Mc Medinilla cumingii Same 4 7 gal Nc Neomarica caerulea Apostles Iris 18 3 gal Pm Philodendron magnicum Same 5 15 gal Pn Psychotria nervosa Wild Coffee 41 7 gal full Re Rhapis excelsa Lady Palm 6 45 gal Florida Fancy Td Tabernaemontana divaricata Crape Jasmine 10 15 gal bush GROUNDCOVERS &VINES [hatch] Microsorum scolopendrium Wart Fern 340 1 gal -- 200 sq. ft. @ 10" o.c. [hatch] Neoregelia Bossa Nova Same 150 1 gal -- 200 sq. ft. @ 15" o.c. [hatch] Neoregelia Fireball Same 85 1 gal -- 70 sq. ft. @12" o.c. pbm Philodendron Burle Marx Same 5 3 gal [hatch] Ruellia brittoniana 'Compacta' or 'Dwarf' Dwarf Mexican Petunia 40 1 gal -- 30 sq. ft. @12" o.c. [hatch] Sedum sarmentosum Star Sedum 260 1 gal -- 350 sq. ft. every 15" o.c. [hatch] Stephanotis oribunda Bridal Wreath Vine 70 7 gal -- 70 linear ft. every 32" o.c. N SCALE: 3/16" = 1'-0" 1 LEVEL 2 PLANTING PLAN NOTES WART FERN SYMBOL LEGEND PLANT SCHEDULE & SPECIFICATIONS continued PLANT SCHEDULE & SPECIFICATIONS PLANT SCHEDULE & SPECIFICATIONS continued LAWN DWARF MEXICAN PETUNIA NEOREGELIA FIREBALL NEOREGELIA BOSSA NOVA BRIDAL WREATH VINE STAR SEDUM URBAN ROBOT LLC MI A MI BEA CH, FL 3 3 13 9 T.786.246.4857 | F.786.768.2537 WWW. URBANROBOT. NET 420 LI NCOLN ROAD S.406 LANDSCAPE ARCHITECT: PROJECT INFORMATION REFER TO ARCHITECTURE FOR SITE, BUILDING & ZONING INFORMATION. PLANTING ALL PLANT MATERIAL SHALL MEET OR EXCEED THE MINIMUM STANDARDS FOR FLORIDA NUMBER ONE AS PROVIDED IN THE MOST CURRENT EDITION OF "GRADES AND STANDARDS FOR NURSERY PLANTS, PART I AND II". STREET TREES STREET TREES SHALL MEET CMB REQUIREMENTS AND THE STANDARDS OUTLINED IN THE MIAMI DADE COUNTY STREET TREE MASTER PLAN. PUBLIC WORKS REMOVE AND REPLACE SIDEWALK. RECONSTRUCT SWALE. MILL AND RESURFACE 2 IN. AVG. USING TYPE S-III ASPHALT MIX DESIGN ON THE DRIVING LANE. ANY WORK AND/OR IMPROVEMENTS TO THE RIGHT OF WAY INCLUDING LANDSCAPING AND IRRIGATION REQUIRE A SEPARATE CMB PUBLIC WORKS DEPT. ROW CONSTRUCTION PERMIT. upon demand at the completion of work. If this drawing or any part property they are not to be used on other work and are to be returned These drawings and copies thereof furnished by the architect are his user thereof becomes indebted to the architect for full commission. thereof is used in any manner without the consent of the architect the P R O J E C T N U M B E R D R A WN B Y D A T E S C A L E planner interiors NCARB CERTIFICATE # 42,136 Ph: 305-532-6161 * Fax: 305-532-6151 architect ARCHITECTURE LICENSE # AR14022 1665 WASHINGTON AVE. 2nd. FLOOR MIAMI BEACH, FLORIDA 33139 CHARLES H. BENSON & ASSOCIATES ARCHITECTS, P.A. MIAMI BEACH, FL. 33139 302- 336 COLLINS AVENUE JHPSB COLLINS VENTURES, LLC NEW 20 UNIT CONDO FOR: 21411 Urban Robot LLC AS SHOWN 8-25-14 LC26000510 URBAN ROBOT LLC STATE OF FLORIDA REGISTERED LANDSCAPE ARCHITECT BUSINESS ISSUED FOR CONSTRUCTION ISSUED FOR PERMIT ISSUED FOR BIDDING DESIGNER: Thomas Juul-Hansen, LLC 40 WORTH STREET, SUITE 814 New York, NY 10013 Tel (212) 929.7109 Fax (212) 929.7116 L-102 ROOF LEVEL PLANTING PLAN HPB FINAL SUBMITTAL LOUVERED TRELLIS BELOW LOUVERED TRELLIS BELOW LOUVERED TRELLIS BELOW LOUVERED TRELLIS BELOW Td Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss CU Sr Sm Sm TR TR Td Aa No Td No No Ss Ss CN CN CN PR PR PR PR PR OUTDOOR KITCHEN JACUZZI 75' X 22'-8" POOL MECHANICAL 1580 SF MECHANICAL 1135 SF PLANTING 3745 SF PLANTING 3745 SF ROOF TERRACE 6025 SF D N D N D N D N No No No No No No No No Aa Sm Sm No No No No No No No Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss PO PO Abbv. Botanical Name Common Name Qty Specifications TREES & PALMS CU Coccoloba uvifera Seagrape 1 15' OA, 22' SPR, multi trunk or with character CN Cocos nucifera Coconut Palm 3 20-22' OA, 8-9' GW, Straight Trunks, Matching (street trees) PO Plumeria obtusa 'Dwarf Singapore Pink' Dwarf Singapore Pink Frangipani 2 Single trunk, 12' OA, min 4.5' CT, intact stems on trunk, matching PR Phoenix roebelenii Pygmy Date Palm 5 45 gal, triple, 8' OA TR Thrinax radiata Florida Thatch Palm 2 Multi, 5-7' OA SHRUBS & ACCENTS Aa Agave americana Century Plant 2 25 gal, 4'x4' No Nerium oleander 'Petite' Dwarf Oleander 19 7 gal, full Ss Scaevola spp. Inkberry 215 7 gal Sr Serenoa repens 'Cinerea' Silver Saw Palmetto 1 30 gal, 3'x4' Sm Suriana maritima Bay Cedar 4 25 gal, multi-trunk small tree, 4-5' OA Td Tripsacum dactyloides Fakahatchee Grass 3 7 gal, full GROUNDCOVERS &VINES [hatch] Ipomoea pes-caprae Railroad Vine 1150 1 gal -- 1,000 sq. ft. @ 12" o.c. N SCALE: 3/16" = 1'-0" 1 ROOF LEVEL PLANTING PLAN 2 Coccoloba uvifera - low and spreading NOTES RAILROAD VINE OVERHANGING EDGE SYMBOL LEGEND PLANT SCHEDULE & SPECIFICATIONS URBAN ROBOT LLC MI A MI BEA CH, FL 3 3 13 9 T.786.246.4857 | F.786.768.2537 WWW. URBANROBOT. NET 420 LI NCOLN ROAD S.406 LANDSCAPE ARCHITECT: PROJECT INFORMATION REFER TO ARCHITECTURE FOR SITE, BUILDING & ZONING INFORMATION. PLANTING ALL PLANT MATERIAL SHALL MEET OR EXCEED THE MINIMUM STANDARDS FOR FLORIDA NUMBER ONE AS PROVIDED IN THE MOST CURRENT EDITION OF "GRADES AND STANDARDS FOR NURSERY PLANTS, PART I AND II". STREET TREES STREET TREES SHALL MEET CMB REQUIREMENTS AND THE STANDARDS OUTLINED IN THE MIAMI DADE COUNTY STREET TREE MASTER PLAN. PUBLIC WORKS REMOVE AND REPLACE SIDEWALK. RECONSTRUCT SWALE. MILL AND RESURFACE 2 IN. AVG. USING TYPE S-III ASPHALT MIX DESIGN ON THE DRIVING LANE. ANY WORK AND/OR IMPROVEMENTS TO THE RIGHT OF WAY INCLUDING LANDSCAPING AND IRRIGATION REQUIRE A SEPARATE CMB PUBLIC WORKS DEPT. ROW CONSTRUCTION PERMIT. upon demand at the completion of work. If this drawing or any part property they are not to be used on other work and are to be returned These drawings and copies thereof furnished by the architect are his user thereof becomes indebted to the architect for full commission. thereof is used in any manner without the consent of the architect the P R O J E C T N U M B E R D R A WN B Y D A T E S C A L E planner interiors NCARB CERTIFICATE # 42,136 Ph: 305-532-6161 * Fax: 305-532-6151 architect ARCHITECTURE LICENSE # AR14022 1665 WASHINGTON AVE. 2nd. FLOOR MIAMI BEACH, FLORIDA 33139 CHARLES H. BENSON & ASSOCIATES ARCHITECTS, P.A. MIAMI BEACH, FL. 33139 302- 336 COLLINS AVENUE JHPSB COLLINS VENTURES, LLC NEW 20 UNIT CONDO FOR: 21411 Urban Robot LLC AS SHOWN 8-25-14 LC26000510 URBAN ROBOT LLC STATE OF FLORIDA REGISTERED LANDSCAPE ARCHITECT BUSINESS ISSUED FOR CONSTRUCTION ISSUED FOR PERMIT ISSUED FOR BIDDING DESIGNER: Thomas Juul-Hansen, LLC 40 WORTH STREET, SUITE 814 New York, NY 10013 Tel (212) 929.7109 Fax (212) 929.7116 L-200 LEVEL 1 LANDSCAPE LIGHTING HPB FINAL SUBMITTAL SPOT LIGHT (TYPICAL) STEP LIGHT (TYPICAL) WELL LIGHT (TYPICAL) PARKING GYM LOBBY UNENCLOSED FORECOURT WATER FEATURE Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td Td TR TR TR TR TR TR TR TR TR TR TR TR TR TR TR TR TR TR TR TR TR TR TR TR TR TR TR TR TR TR TR fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr fr Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm Fm U P R C 2 4 " D R C 2 4 " D U P R C 2 4 " D R C 2 4 " D U P U P 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 25 26 28 32 33 34 35 42 36 37 40 39 36 3 63 6 43 38 3 6 24 36 36 27 29 3 6 30 31 41 36 U P U P U P D N EXISTING LOBBY EXIST. RECEPTION DESK EX ISTIN G C O R R ID O R EXIST. ROOM 116 EXIST. ROOM 114 EXIST. ROOM 112 EXIST. ROOM 110 EXIST. ROOM 108 EXIST. ROOM 106 EXIST. ROOM 104 EXIST. OFFICE EXIST. ROOM 117 EXIST. ROOM 115 EXIST. ROOM 111 EXIST. ROOM 109 EXIST. ROOM 107 EXIST. ROOM 105 EXIST. ROOM 102 EXIST. ROOM 101 EXISTING PORCH PER V IO U S PA V ER W A LK W A Y 3 R D
S T COLLINS CT. PAD MOUNTED TRANS- FORMER Fm Fm Fm Fm CG CG Td Td Td Td CG Td Td Fm Fm Fm MF MF MF MF MF MF MF MF MF MF MF MF MF PER V IO U S PA V ER W A LK W A Y MF MF MF MF MF MF MF MF MF MF MF MF MF COLLINS AVE 302 COLLINS AVE: LANDSCAPE LIGHTING SCHEDULE FOR LEVEL 1 Locations shown are approximate; verify exact xture placement and orientation in the eld with Landscape Architect Verify zoning & controls with Landscape Architect Verify xtures and nishes with Landscape Architect before purchase All xtures to be UL rated !"#$%& '()*+,- /"0- 1+234*" 5,236 72#- 8 9%6-& 7%: ;2<2=- >2#0 ?%&%, @04AB C%&*2=- '(3(BD @*D-, E-#2,FB !"#$ &'()$ 38 8-k Llghung uelLa SLar 8 wau LLu/2.7k (e36) WhlLe SpoL (S) 12vAC Machlned SLalnless SLeel (MAC) 90 Cap (8) *+&& &'()$ 43 8-k Llghung Well SLar 8 wau LLu/2.7k (e36) WhlLe Medlum llood (MlL) 12vAC Machlned SLalnless SLeel (MAC) - lnsLallauon musL comply wlLh ClLy of Mlaml 8each sLreeL Lree llghung requlremenLs !$+" &'()$ 6 8LCA 2009 LLu 4.3 wau LLu 3000k WhlLe - 120v (lnLegral LlecLronlc LLu urlver) Sllver (SLv) - Wall mounLed on slde walls of sLalrcases 302 COLLINS AVE: LANDSCAPE LIGHTING SCHEDULE FOR LEVEL 1 Locations shown are approximate; verify exact xture placement and orientation in the eld with Landscape Architect Verify zoning & controls with Landscape Architect Verify xtures and nishes with Landscape Architect before purchase All xtures to be UL rated !"#$%& '()*+,- /"0- 1+234*" 5,236 72#- 8 9%6-& 7%: ;2<2=- >2#0 ?%&%, @04AB C%&*2=- '(3(BD @*D-, E-#2,FB !"#$ &'()$ 38 8-k Llghung uelLa SLar 8 wau LLu/2.7k (e36) WhlLe SpoL (S) 12vAC Machlned SLalnless SLeel (MAC) 90 Cap (8) *+&& &'()$ 43 8-k Llghung Well SLar 8 wau LLu/2.7k (e36) WhlLe Medlum llood (MlL) 12vAC Machlned SLalnless SLeel (MAC) - lnsLallauon musL comply wlLh ClLy of Mlaml 8each sLreeL Lree llghung requlremenLs !$+" &'()$ 6 8LCA 2009 LLu 4.3 wau LLu 3000k WhlLe - 120v (lnLegral LlecLronlc LLu urlver) Sllver (SLv) - Wall mounLed on slde walls of sLalrcases N SCALE: 1/8" = 1'-0" 1 LEVEL 1 LANDSCAPE LIGHTING PLAN FIXTURE LEGEND SPOT LIGHT WELL LIGHT STEP LIGHT LIGHT FIXTURE SCHEDULE LANDSCAPE LIGHTING SPECIFICATIONS 1. All work shall comply with these drawings, the latest version of the Florida Building Code, and all Applicable Codes and Regulations. Code Compliance is the complete responsibility of the Contractor and any modications required shall be performed at no additional charge. 2. The Contractor is to familiarize himself with and conrm all Drawings, Specications, and existing materials and conditions prior to Bid and commencing the work. Notify the Landscape Architect immediately of any discrepancies. The contractor shall include in his Bid all costs necessary for a complete and operational installation and shall visit the job site prior to bid date. 3. All materials furnished on the job site shall be new and stored in such a manner as to protect them from the elements. 4. Lighting plans are schematic in nature. Fixture symbols are not to scale. Verify exact location and orientation of each xture in the eld with Landscape Architect (L.A.). Verify all quantities, dimensions, and conditions in the eld. Conrm xture nishes & specs with Landscape Architect before purchase. 5. All Contractors are to keep the job site clean and free of debris at all times. 6. Do not scale drawings. Dimensions and/or existing conditions govern. Notify the Landscape Architect immediately of any discrepancies. Stop work in areas of discrepancy until all issues are resolved. 7. All work shall be in strict accordance with the best practices of the construction trade. 8. Contractor to coordinate programming, controls, and electrical with MEP & L.A. 9. All details, sections, diagrams, etc. are intended to be typical and shall be construed to apply to any similar situation elsewhere in the project. 10. The Contractor shall verify all utilities and placement locations of pipe, conduit, equipment, ductwork, etc., prior to submitting Bid to the Owner. 11. Where conicts and/or variances exist in the Drawings or Specications, the arrangement of better quality, greater quantity, and higher cost shall be included in the Bid price. The Landscape Architect will have the nal decision regarding item and manner in which work shall be installed. 12. All xtures to be UL-listed and wet-rated. 13. Owner cannot guarantee that internal changes have not occurred since these Drawings have been prepared. It is the responsibility of the Contractor to eld check all dimensions and conditions. 14. Any penetrations or modications to structural steel or concrete must be coordinated with the project's Structural Engineer. All lumber in contact with concrete or masonry shall be pressure treated. 15. The Contractor shall check in with the on-site Construction Manager prior to start of work. During construction, the Contractor shall coordinate all work with the Owner and the on-site Construction Manager. 16. The Contractor shall verify the locations of site utilities prior to the commencement of work. Existing utilities shall be protected or rerouted as required to accommodate the new work. 17. The Contractor shall inspect the surfaces and substrate conditions on/in which the work shall be performed. Beginning of work means acceptance of existing surfaces, substrates and conditions. 18. Prior to nal acceptance, Contractor shall adjust all lighting to Owner's satisfaction. 19. The Landscape Architect shall have nal decision as to whether work of poor quality and/or substandard workmanship shall be repaired or replaced. 20. The Contractor shall arrange for all building permits and inspections by the building authorities. Cost of all permits, fees, and special inspections shall be in the Bid wherever necessary. 21. The Contractor shall provide proof of insurance and shall not send or employ for this project any laborers or subcontractors. Insurance shall provide protection against public liability and property damage for duration of work. 22. The Contractor shall provide a minimum of one full year warranty for any and all labor and materials they provide, install, or apply. 23. The Contractor shall verify the condition of all existing materials, system, or devices prior to reuse or connection to such materials, systems or devices. Contractor shall bear the full responsibility for reuse of such items and shall provide a minimum 1 year guarantee for all work, materials, and system. 24. These drawings and documents, as instruments of service, are the property of the Landscape Architect and may not be used or reproduced in any manner without his/her express consent. 25. It shall not be the intent of these plans and/or specications to show every minor detail of construction. The Contractor shall be expected to furnish and install all items for a complete system and provide all requirements necessary for equipment to be placed in proper working order. 26. All conduit runs are shown diagrammatically. Exact routing shall be determined in the eld, unless otherwise noted. 27. As-Built drawings shall be furnished to the Owner upon completion of work. URBAN ROBOT LLC MI A MI BEA CH, FL 3 3 13 9 T.786.246.4857 | F.786.768.2537 WWW. URBANROBOT. NET 420 LI NCOLN ROAD S.406 LANDSCAPE ARCHITECT: 35 57 6 upon demand at the completion of work. If this drawing or any part property they are not to be used on other work and are to be returned These drawings and copies thereof furnished by the architect are his user thereof becomes indebted to the architect for full commission. thereof is used in any manner without the consent of the architect the P R O J E C T N U M B E R D R A WN B Y D A T E S C A L E planner interiors NCARB CERTIFICATE # 42,136 Ph: 305-532-6161 * Fax: 305-532-6151 architect ARCHITECTURE LICENSE # AR14022 1665 WASHINGTON AVE. 2nd. FLOOR MIAMI BEACH, FLORIDA 33139 CHARLES H. BENSON & ASSOCIATES ARCHITECTS, P.A. MIAMI BEACH, FL. 33139 302- 336 COLLINS AVENUE JHPSB COLLINS VENTURES, LLC NEW 20 UNIT CONDO FOR: 21411 Urban Robot LLC AS SHOWN 8-25-14 LC26000510 URBAN ROBOT LLC STATE OF FLORIDA REGISTERED LANDSCAPE ARCHITECT BUSINESS ISSUED FOR CONSTRUCTION ISSUED FOR PERMIT ISSUED FOR BIDDING DESIGNER: Thomas Juul-Hansen, LLC 40 WORTH STREET, SUITE 814 New York, NY 10013 Tel (212) 929.7109 Fax (212) 929.7116 L-201 LEVEL 2 LANDSCAPE LIGHTING HPB FINAL SUBMITTAL U P D N U P D N U P D N U P D N 2 C 1 B R - 1 W C 1 4 7 0 S F 2 F 3 B R - 4 W C 2 2 0 0 S F 2 E 2 B R - 2 W C 1 2 1 5 S F M A S T E R B E D R O O M B R 2 2 B 3 B R - 4 W C 2 1 5 0 S F (2 4 0 0 S F ) 2 A 3 B R - 4 W C 2 1 5 0 S F (2 4 4 0 S F ) M A S T E R B E D R O O M B R 2 B R 3 B R 2 B R 3 M A S T E R B E D R O O M M A S T E R B E D R O O M M A S T E R B E D R O O M B R 2 B R 2 B R 2 2 D 2 B R - 2 W C 1 2 1 5 S F 2 E 6 0 0 S F U N E N C L O S E D T E R R A C E 2 D 4 2 6 S F U N E N C L O S E D T E R R A C E 2 B 1 5 5 S F U N E N C L O S E D T E R R A C E 2 B 2 3 0 S F U N E N C L O S E D T E R R A C E 2 A 3 8 0 S F U N E N C L O S E D T E R R A C E Jb Jb Lc Bo Bo Bo Bo Jb Jb Jb Jb Jb Jb Jb Jb Jb Jb Jb Jb Jb Jb Jb Jb Jb Jb Jb Jb Jb Ao Ao Az Az Az Az Re Re Re pbm pbm Ao CG Pm Ds Ai Lc Fl Nc Nc Nc PP PP PP PP PP PP PP PP PP PP Pn Pn Pn 8FT DINING TABLE 4'x6' HOT TUB Ga LAWN Pn Pn Pn Pn Pm CN Pn Pn Pn Pn Pn Pn Pn MF PO Ga Am MC Az Az Az Az Az Az Az Az Az Re Lc Nc Nc Fl Nc Nc Nc PP PP PP PP PP PP PP PP PP PP Bo Bo Bo Bo Bo Bo Bo Pn Pn Pn Pn Pn Pn Pn Pn Pn CN Bo Bo Bo Bo Am Bo Jb Ga Jb Jb MF Pm CG pbm Ao Bo Bo Bo PO Ao Ga Ao Ds MC Az Az Az Az Az Az Az Az Az Re Lc Nc Nc Fl Nc Nc Nc PP PP PP PP PP PP PP PP PP PP Bo Bo Bo Bo Bo Bo Bo Pn Pn Pn Pn Pn Pn Pn Pn Pn CN Bo Bo Bo Bo Am Bo Jb Ga Jb Jb MF Pm CG pbm Ao Bo Bo Bo PO Ao Ga Ao Ds MC Az Az Az Az Az Az Az Az Az Re Lc Nc Nc Fl Nc Nc Nc PP PP PP PP PP PP PP PP PP PP Bo Bo Bo Bo Bo Bo Bo Pn Pn Pn Pn Pn Pn Pn Pn Pn CN Bo Bo Bo Bo Am Bo Jb Ga Jb Jb MF Pm CG pbm Ao Bo Bo Bo PO Ao Ga Ao Ds LAWN LAWN LAWN PLANTER PLANTER W /D W /D W /D Hc Hc Hc Hc Hc Hc Hc Hc Hc Td Mc Td Td Td Td Hc Td Hc Td Hc Td Hc Td Hc Td Hc 302 COLLINS AVE: LANDSCAPE LIGHTING SCHEDULE FOR LEVEL 2 Locations shown are approximate; verify exact xture placement and orientation in the eld with Landscape Architect Verify zoning & controls with Landscape Architect Verify xtures and nishes with Landscape Architect before purchase All xtures to be UL rated !"#$%& '()*+,- /"0- 1+234*" 5,236 72#- 8 9%6-& 7%: ;2<2=- >2#0 ?%&%, @04AB C%&*2=- '(3(BD @*D-, E-#2,FB !"#$ &'()$ 38 8-k Llghung uelLa SLar 8 wau LLu/2.7k (e36) WhlLe SpoL (S) 12vAC Machlned SLalnless SLeel (MAC) 90 Cap (8) 302 COLLINS AVE: LANDSCAPE LIGHTING SCHEDULE FOR LEVEL 1 Locations shown are approximate; verify exact xture placement and orientation in the eld with Landscape Architect Verify zoning & controls with Landscape Architect Verify xtures and nishes with Landscape Architect before purchase All xtures to be UL rated !"#$%& '()*+,- /"0- 1+234*" 5,236 72#- 8 9%6-& 7%: ;2<2=- >2#0 ?%&%, @04AB C%&*2=- '(3(BD @*D-, E-#2,FB !"#$ &'()$ 38 8-k Llghung uelLa SLar 8 wau LLu/2.7k (e36) WhlLe SpoL (S) 12vAC Machlned SLalnless SLeel (MAC) 90 Cap (8) *+&& &'()$ 43 8-k Llghung Well SLar 8 wau LLu/2.7k (e36) WhlLe Medlum llood (MlL) 12vAC Machlned SLalnless SLeel (MAC) - lnsLallauon musL comply wlLh ClLy of Mlaml 8each sLreeL Lree llghung requlremenLs !$+" &'()$ 6 8LCA 2009 LLu 4.3 wau LLu 3000k WhlLe - 120v (lnLegral LlecLronlc LLu urlver) Sllver (SLv) - Wall mounLed on slde walls of sLalrcases N SCALE: 3/16" = 1'-0" 1 LEVEL 2 LANDSCAPE LIGHTING PLAN FIXTURE LEGEND SPOT LIGHT LIGHT FIXTURE SCHEDULE LANDSCAPE LIGHTING SPECIFICATIONS 1. All work shall comply with these drawings, the latest version of the Florida Building Code, and all Applicable Codes and Regulations. Code Compliance is the complete responsibility of the Contractor and any modications required shall be performed at no additional charge. 2. The Contractor is to familiarize himself with and conrm all Drawings, Specications, and existing materials and conditions prior to Bid and commencing the work. Notify the Landscape Architect immediately of any discrepancies. The contractor shall include in his Bid all costs necessary for a complete and operational installation and shall visit the job site prior to bid date. 3. All materials furnished on the job site shall be new and stored in such a manner as to protect them from the elements. 4. Lighting plans are schematic in nature. Fixture symbols are not to scale. Verify exact location and orientation of each xture in the eld with Landscape Architect (L.A.). Verify all quantities, dimensions, and conditions in the eld. Conrm xture nishes & specs with Landscape Architect before purchase. 5. All Contractors are to keep the job site clean and free of debris at all times. 6. Do not scale drawings. Dimensions and/or existing conditions govern. Notify the Landscape Architect immediately of any discrepancies. Stop work in areas of discrepancy until all issues are resolved. 7. All work shall be in strict accordance with the best practices of the construction trade. 8. Contractor to coordinate programming, controls, and electrical with MEP & L.A. 9. All details, sections, diagrams, etc. are intended to be typical and shall be construed to apply to any similar situation elsewhere in the project. 10. The Contractor shall verify all utilities and placement locations of pipe, conduit, equipment, ductwork, etc., prior to submitting Bid to the Owner. 11. Where conicts and/or variances exist in the Drawings or Specications, the arrangement of better quality, greater quantity, and higher cost shall be included in the Bid price. The Landscape Architect will have the nal decision regarding item and manner in which work shall be installed. 12. All xtures to be UL-listed and wet-rated. 13. Owner cannot guarantee that internal changes have not occurred since these Drawings have been prepared. It is the responsibility of the Contractor to eld check all dimensions and conditions. 14. Any penetrations or modications to structural steel or concrete must be coordinated with the project's Structural Engineer. All lumber in contact with concrete or masonry shall be pressure treated. 15. The Contractor shall check in with the on-site Construction Manager prior to start of work. During construction, the Contractor shall coordinate all work with the Owner and the on-site Construction Manager. 16. The Contractor shall verify the locations of site utilities prior to the commencement of work. Existing utilities shall be protected or rerouted as required to accommodate the new work. 17. The Contractor shall inspect the surfaces and substrate conditions on/in which the work shall be performed. Beginning of work means acceptance of existing surfaces, substrates and conditions. 18. Prior to nal acceptance, Contractor shall adjust all lighting to Owner's satisfaction. 19. The Landscape Architect shall have nal decision as to whether work of poor quality and/or substandard workmanship shall be repaired or replaced. 20. The Contractor shall arrange for all building permits and inspections by the building authorities. Cost of all permits, fees, and special inspections shall be in the Bid wherever necessary. 21. The Contractor shall provide proof of insurance and shall not send or employ for this project any laborers or subcontractors. Insurance shall provide protection against public liability and property damage for duration of work. 22. The Contractor shall provide a minimum of one full year warranty for any and all labor and materials they provide, install, or apply. 23. The Contractor shall verify the condition of all existing materials, system, or devices prior to reuse or connection to such materials, systems or devices. Contractor shall bear the full responsibility for reuse of such items and shall provide a minimum 1 year guarantee for all work, materials, and system. 24. These drawings and documents, as instruments of service, are the property of the Landscape Architect and may not be used or reproduced in any manner without his/her express consent. 25. It shall not be the intent of these plans and/or specications to show every minor detail of construction. The Contractor shall be expected to furnish and install all items for a complete system and provide all requirements necessary for equipment to be placed in proper working order. 26. All conduit runs are shown diagrammatically. Exact routing shall be determined in the eld, unless otherwise noted. 27. As-Built drawings shall be furnished to the Owner upon completion of work. URBAN ROBOT LLC MI A MI BEA CH, FL 3 3 13 9 T.786.246.4857 | F.786.768.2537 WWW. URBANROBOT. NET 420 LI NCOLN ROAD S.406 LANDSCAPE ARCHITECT: upon demand at the completion of work. If this drawing or any part property they are not to be used on other work and are to be returned These drawings and copies thereof furnished by the architect are his user thereof becomes indebted to the architect for full commission. thereof is used in any manner without the consent of the architect the P R O J E C T N U M B E R D R A WN B Y D A T E S C A L E planner interiors NCARB CERTIFICATE # 42,136 Ph: 305-532-6161 * Fax: 305-532-6151 architect ARCHITECTURE LICENSE # AR14022 1665 WASHINGTON AVE. 2nd. FLOOR MIAMI BEACH, FLORIDA 33139 CHARLES H. BENSON & ASSOCIATES ARCHITECTS, P.A. MIAMI BEACH, FL. 33139 302- 336 COLLINS AVENUE JHPSB COLLINS VENTURES, LLC NEW 20 UNIT CONDO FOR: 21411 Urban Robot LLC AS SHOWN 8-25-14 LC26000510 URBAN ROBOT LLC STATE OF FLORIDA REGISTERED LANDSCAPE ARCHITECT BUSINESS ISSUED FOR CONSTRUCTION ISSUED FOR PERMIT ISSUED FOR BIDDING DESIGNER: Thomas Juul-Hansen, LLC 40 WORTH STREET, SUITE 814 New York, NY 10013 Tel (212) 929.7109 Fax (212) 929.7116 L-202 ROOF LEVEL LANDSCAPE LIGHTING HPB FINAL SUBMITTAL LOUVERED TRELLIS BELOW LOUVERED TRELLIS BELOW LOUVERED TRELLIS BELOW LOUVERED TRELLIS BELOW Td Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss CU Sr Sm Sm TR TR Td Aa No Td No No Ss Ss CN CN CN PR PR PR PR PR OUTDOOR KITCHEN JACUZZI 75' X 22'-8" POOL MECHANICAL 1580 SF MECHANICAL 1135 SF PLANTING 3745 SF PLANTING 3745 SF ROOF TERRACE 6025 SF D N D N D N D N No No No No No No No No Aa Sm Sm No No No No No No No Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss PO PO 302 COLLINS AVE: LANDSCAPE LIGHTING SCHEDULE FOR ROOF Locations shown are approximate; verify exact xture placement and orientation in the eld with Landscape Architect Verify zoning & controls with Landscape Architect Verify xtures and nishes with Landscape Architect before purchase All xtures to be UL rated !"#$%& '()*+,- /"0- 1+234*" 5,236 72#- 8 9%6-& 7%: ;2<2=- >2#0 ?%&%, @04AB C%&*2=- '(3(BD @*D-, E-#2,FB !"#$ &'()$ 13 8-k Llghung uelLa SLar 8 wau LLu/2.7k (e36) WhlLe SpoL (S) 12vAC Machlned SLalnless SLeel (MAC) 90 Cap (8) *+&& &'()$ 42 8LCA 2272LLu 6.3 wau LLu 3000k WhlLe - 120v (lnLegral LlecLronlc LLu urlver) Sllver (SLv) - 302 COLLINS AVE: LANDSCAPE LIGHTING SCHEDULE FOR LEVEL 1 Locations shown are approximate; verify exact xture placement and orientation in the eld with Landscape Architect Verify zoning & controls with Landscape Architect Verify xtures and nishes with Landscape Architect before purchase All xtures to be UL rated !"#$%& '()*+,- /"0- 1+234*" 5,236 72#- 8 9%6-& 7%: ;2<2=- >2#0 ?%&%, @04AB C%&*2=- '(3(BD @*D-, E-#2,FB !"#$ &'()$ 38 8-k Llghung uelLa SLar 8 wau LLu/2.7k (e36) WhlLe SpoL (S) 12vAC Machlned SLalnless SLeel (MAC) 90 Cap (8) *+&& &'()$ 43 8-k Llghung Well SLar 8 wau LLu/2.7k (e36) WhlLe Medlum llood (MlL) 12vAC Machlned SLalnless SLeel (MAC) - lnsLallauon musL comply wlLh ClLy of Mlaml 8each sLreeL Lree llghung requlremenLs !$+" &'()$ 6 8LCA 2009 LLu 4.3 wau LLu 3000k WhlLe - 120v (lnLegral LlecLronlc LLu urlver) Sllver (SLv) - Wall mounLed on slde walls of sLalrcases N SCALE: 3/16" = 1'-0" 1 ROOF LEVEL LANDSCAPE LIGHTING PLAN FIXTURE LEGEND SPOT LIGHT WALL LIGHT LIGHT FIXTURE SCHEDULE LANDSCAPE LIGHTING SPECIFICATIONS 1. All work shall comply with these drawings, the latest version of the Florida Building Code, and all Applicable Codes and Regulations. Code Compliance is the complete responsibility of the Contractor and any modications required shall be performed at no additional charge. 2. The Contractor is to familiarize himself with and conrm all Drawings, Specications, and existing materials and conditions prior to Bid and commencing the work. Notify the Landscape Architect immediately of any discrepancies. The contractor shall include in his Bid all costs necessary for a complete and operational installation and shall visit the job site prior to bid date. 3. All materials furnished on the job site shall be new and stored in such a manner as to protect them from the elements. 4. Lighting plans are schematic in nature. Fixture symbols are not to scale. Verify exact location and orientation of each xture in the eld with Landscape Architect (L.A.). Verify all quantities, dimensions, and conditions in the eld. Conrm xture nishes & specs with Landscape Architect before purchase. 5. All Contractors are to keep the job site clean and free of debris at all times. 6. Do not scale drawings. Dimensions and/or existing conditions govern. Notify the Landscape Architect immediately of any discrepancies. Stop work in areas of discrepancy until all issues are resolved. 7. All work shall be in strict accordance with the best practices of the construction trade. 8. Contractor to coordinate programming, controls, and electrical with MEP & L.A. 9. All details, sections, diagrams, etc. are intended to be typical and shall be construed to apply to any similar situation elsewhere in the project. 10. The Contractor shall verify all utilities and placement locations of pipe, conduit, equipment, ductwork, etc., prior to submitting Bid to the Owner. 11. Where conicts and/or variances exist in the Drawings or Specications, the arrangement of better quality, greater quantity, and higher cost shall be included in the Bid price. The Landscape Architect will have the nal decision regarding item and manner in which work shall be installed. 12. All xtures to be UL-listed and wet-rated. 13. Owner cannot guarantee that internal changes have not occurred since these Drawings have been prepared. It is the responsibility of the Contractor to eld check all dimensions and conditions. 14. Any penetrations or modications to structural steel or concrete must be coordinated with the project's Structural Engineer. All lumber in contact with concrete or masonry shall be pressure treated. 15. The Contractor shall check in with the on-site Construction Manager prior to start of work. During construction, the Contractor shall coordinate all work with the Owner and the on-site Construction Manager. 16. The Contractor shall verify the locations of site utilities prior to the commencement of work. Existing utilities shall be protected or rerouted as required to accommodate the new work. 17. The Contractor shall inspect the surfaces and substrate conditions on/in which the work shall be performed. Beginning of work means acceptance of existing surfaces, substrates and conditions. 18. Prior to nal acceptance, Contractor shall adjust all lighting to Owner's satisfaction. 19. The Landscape Architect shall have nal decision as to whether work of poor quality and/or substandard workmanship shall be repaired or replaced. 20. The Contractor shall arrange for all building permits and inspections by the building authorities. Cost of all permits, fees, and special inspections shall be in the Bid wherever necessary. 21. The Contractor shall provide proof of insurance and shall not send or employ for this project any laborers or subcontractors. Insurance shall provide protection against public liability and property damage for duration of work. 22. The Contractor shall provide a minimum of one full year warranty for any and all labor and materials they provide, install, or apply. 23. The Contractor shall verify the condition of all existing materials, system, or devices prior to reuse or connection to such materials, systems or devices. Contractor shall bear the full responsibility for reuse of such items and shall provide a minimum 1 year guarantee for all work, materials, and system. 24. These drawings and documents, as instruments of service, are the property of the Landscape Architect and may not be used or reproduced in any manner without his/her express consent. 25. It shall not be the intent of these plans and/or specications to show every minor detail of construction. The Contractor shall be expected to furnish and install all items for a complete system and provide all requirements necessary for equipment to be placed in proper working order. 26. All conduit runs are shown diagrammatically. Exact routing shall be determined in the eld, unless otherwise noted. 27. As-Built drawings shall be furnished to the Owner upon completion of work. URBAN ROBOT LLC MI A MI BEA CH, FL 3 3 13 9 T.786.246.4857 | F.786.768.2537 WWW. URBANROBOT. NET 420 LI NCOLN ROAD S.406 LANDSCAPE ARCHITECT: 15 36 upon demand at the completion of work. If this drawing or any part property they are not to be used on other work and are to be returned These drawings and copies thereof furnished by the architect are his user thereof becomes indebted to the architect for full commission. thereof is used in any manner without the consent of the architect the P R O J E C T N U M B E R D R A WN B Y D A T E S C A L E planner interiors NCARB CERTIFICATE # 42,136 Ph: 305-532-6161 * Fax: 305-532-6151 architect ARCHITECTURE LICENSE # AR14022 1665 WASHINGTON AVE. 2nd. FLOOR MIAMI BEACH, FLORIDA 33139 CHARLES H. BENSON & ASSOCIATES ARCHITECTS, P.A. MIAMI BEACH, FL. 33139 302- 336 COLLINS AVENUE JHPSB COLLINS VENTURES, LLC NEW 20 UNIT CONDO FOR: 21411 Urban Robot LLC AS SHOWN 8-25-14 LC26000510 URBAN ROBOT LLC STATE OF FLORIDA REGISTERED LANDSCAPE ARCHITECT BUSINESS ISSUED FOR CONSTRUCTION ISSUED FOR PERMIT ISSUED FOR BIDDING DESIGNER: Thomas Juul-Hansen, LLC 40 WORTH STREET, SUITE 814 New York, NY 10013 Tel (212) 929.7109 Fax (212) 929.7116 L-203 LANDSCAPE LIGHTING SPECIFICATIONS HPB FINAL SUBMITTAL SUBMTTAL DATE !"#"!$ DRAWNG NUMBER &'()))*+) 40429 Brickyard Drive Madera, CA 93636 USA 559.438.5800 FAX 559.438.5900 www.bklighting.com info@bklighting.com PROJECT: THIS DOCUMENT CONTAINS PROPRIETARY INFORMATION OF B-K LIGHTING, INC. AND ITS RECEIPT OR POSSESSION DOES NOT CONVEY ANY RIGHTS TO REPRODUCE, DISCLOSE ITS CONTENTS, OR TO MANUFACTURE, USE OR SELL ANYTHING IT MAY DESCRIBE. REPRODUCTION, DISCLOSURE OR USE WITHOUT SPECIFIC WRITTEN AUTHORIZATION OF B-K LIGHTING, INC. IS STRICTLY FORBIDDEN. CATALOG NUMBER LOGIC Material Blank - Aluminum B - Brass S - Stainless Steel Series DS - Delta Star Finish Lens Type Cap Style Example - DS - LED - e22 - SP - A7 - BZW - 12 - 11 - A - 360SL Optics* 360SL - 360SL Rotational Knuckle Mounting System DS A - 45 B - 90 D - 45 less Weep Hole E - 90 less Weep Hole ( Interior Use Only) ( Interior Use Only) Option Shielding 11 - Honeycomb Baffle 12 - Soft Focus Lens 13 - Rectilinear Lens LED NSP - Narrow Spot (Red Indicator) SP - Spot (Green Indicator) MFL - Medium Flood (Yellow Indicator) WFL - Wide Flood (Blue Indicator) TYPE: CATALOG NUMBER: SOURCE: NOTES: LED Type BK No. CCT (Typ.) Input Watts (Typ.) CRI (Typ.) e36 2700K 8.4 90 e22 3100K 8.4 90 e23 4100K 8.4 75 e27 Amber (590nm) 7.9 - LM79 DATA Beam Type AngIe VisuaI Indicator Narrow Spot 14 Ped Dot Spot 18 Green Dot Medium Flood 25 Yellow Dot Wide Flood 36 Blue Dot *OPTICAL DATA Minimum Rated Life (hrs.) 70% of initiaI Iumens (L70) 50,000 50,000 50,000 50,000 L70 DATA !"# %&'()&*' DELTA STAR 7" 1 5/8" 1" Dia 2 1/4" 4 3/4" Locking O-Ring Compression Knuckle Adjust-e-Lume Output Intensity** (Choose factory setting) A9 (Standard), A8, A7, A6, A5, A4, A3, A2, A1 **Please see Adjust-e-Lume photometry to determine desired intensity. Source LED - e Technology with Integral Dimming Driver (25W min. load when dimmed) *Requires magnetic LowVoltage dimmer TECHNOLOGY with e36 - 8WLED/2.7K e22 - 8WLED/3K e23 - 8WLED/4K e27 - 8WLED/Amber Input VoIts InRush Current DimmabIe Operation Ambient Temperature 12vAC/DC 50/60Hz <1A (non-dimmed) Magnetic Low voltage Dimmer -10F-130F DRIVER DATA Powder Coat Color Satin Wrinkle Bronze BZP BZW Black BLP BLW White (Gloss) WHP WHW Aluminum SAP - Verde - VER AluminumFinish Machined MAC Polished POL MitiqueTM MIT Machined MAC Polished POL Brushed BRU Interior use only. Brass Finish Stainless Finish PremiumFinish ABP Antique Brass Powder CMG Cascade Mountain Granite RMG Rocky Mountain Granite AMG Aleutian Mountain Granite CRI Cracked Ice SDS Sonoran Desert Sandstone AQW Antique White CRM Cream SMG Sierra Mountain Granite BCM Black Chrome HUG Hunter Green TXF Textured Forest BGE Beige MDS Mojave Desert Sandstone WCP Weathered Copper BPP Brown Patina Powder NBP Natural Brass Powder WIR Weathered Iron CAP Clear Anodized Powder OCP Old Copper Also available in RAL Finishes See submittal SUB-1439-00 WELL STAR SUBMTTAL DATE !"#"!$ DRAWNG NUMBER &'()))*+# 40429 Brickyard Drive Madera, CA 93636 USA 559.438.5800 FAX 559.438.5900 www.bklighting.com info@bklighting.com !"# %&'()&*' PROJECT: THIS DOCUMENT CONTAINS PROPRIETARY INFORMATION OF B-K LIGHTING, INC. AND ITS RECEIPT OR POSSESSION DOES NOT CONVEY ANY RIGHTS TO REPRODUCE, DISCLOSE ITS CONTENTS, OR TO MANUFACTURE, USE OR SELL ANYTHING IT MAY DESCRIBE. REPRODUCTION, DISCLOSURE OR USE WITHOUT SPECIFIC WRITTEN AUTHORIZATION OF B-K LIGHTING, INC. IS STRICTLY FORBIDDEN. 12" (305mm) (2) Stainless Steel fat Head Hex Head Screws Block Oxide 6" Dia. (152mm) .120" Wall, Steel Housing (152mm) 6" Dia 12" (305mm) (152mm) 6" Dia For Remote Transformer See Sheets TRSS Series, TR Series, Power Pipe, Power II or Power Canopy in Accessory Section. Tempered Glass Lens Cast Iron Well Cover (Cast 35, Gray Iron-ASTMA43) 4 3/8" O.C. (111mm) 5 (1524mm) 12 Ga. 2 low voltage direct burial cable CATALOG NUMBER LOGIC Series WS - Well Star Finish Example WS - LED - e22 - NSP - A7 - CIF - 13 - 11 LED Type Lens 12 - Soft Focus Lens 13 - Rectilinear Lens LED WS Optics* Shielding 11 - Honeycomb Baffle NSP - Narrow Spot (Red Indicator) SP - Spot (Green Indicator)
MFL - MediumFlood (YellowIndicator) WFL - Wide Flood (Blue Indicator) TYPE: CATALOG NUMBER: SOURCE: NOTES: BK No. CCT (Typ.) Input Watts (Typ.) CRI (Typ.) e36 2700K 8.4 90 e22 3100K 8.4 90 e23 4100K 8.4 75 e27 Amber (590nm) 7.9 - LM79 DATA Beam Type AngIe VisuaI Indicator Narrow Spot 14 Ped Dot Spot 18 Green Dot Medium Flood 25 Yellow Dot Wide Flood 36 Blue Dot *OPTICAL DATA Minimum Rated Life (hrs.) 70% of initiaI Iumens (L70) 50,000 50,000 50,000 50,000 L70 DATA Adjust-e-Lume Output Intensity** (Choose factory setting) A9 (Standard), A8, A7, A6, A5, A4, A3, A2, A1 **Please see Adjust-e-Lume photometry to determine desired intensity. Source LED - e Technology with Integral Dimming Driver (25W min. load when dimmed) *Requires magnetic LowVoltage dimmer TECHNOLOGY with Input VoIts InRush Current DimmabIe Operation Ambient Temperature 12vAC/DC 50/60Hz <1A (non-dimmed) Magnetic Low voltage Dimmer -10F-130F DRIVER DATA e36 - 8WLED/2.7K e22 - 8WLED/3K e23 - 8WLED/4K e27 - 8WLED/Amber Unfinished, Cast Iron CIF Powder Coat Color Wrinkle Bronze BZW Black BLW White (Gloss) WHW Verde VER Cast Iron Finish PremiumFinish ABP Antique Brass Powder CMG Cascade Mountain Granite RMG Rocky Mountain Granite AMG Aleutian Mountain Granite CRI Cracked Ice SDS Sonoran Desert Sandstone AQW Antique White CRM Cream SMG Sierra Mountain Granite BCM Black Chrome HUG Hunter Green TXF Textured Forest BGE Beige MDS Mojave Desert Sandstone WCP Weathered Copper BPP Brown Patina Powder NBP Natural Brass Powder WIR Weathered Iron CAP Clear Anodized Powder OCP Old Copper Also available in RAL Finishes See submittal SUB-1439-00 !"#$% &'() +,-./01% +,-2$01% 3-4156$% 7-4-,% 8#19-:;% <-.9=9$.% !"#$%&' 1000 BEGA Way, Carpinteria, CA 93013 ( 805j 684-0533 FAX ( 805j 566-9474 www. bega-us . com >0-#",96?1 &'()@AB CDEF A#.51$. DGHEF Recessed wall luminaire I5J#; ) & 7 )**+,"- FKG L I'M N EO PEC F !"#$%&'( 8:$ #9$0$ .9$ 05;1 54/J9:/J ?-/;9:6 Q91? 9:1$6,54 Q9,9:6 0-J#5,1J$:1K M9$ 05;19:6; 5,$ J5,9:$ 6,5.$R 0-##$, =,$$ ( 0.3% copper content} A360.0 a|um|num a||oy. )&*+"$#,-( One p|ece d|e cast a|um|num facep|ate, 18" th|ck, sat|n g|ass |ens. Facep|ate |s secured by two (2}, socket head, sta|n|ess ;1$$4R 05#19S$ ;0,$Q; 1?,$5.$. 9:1- ;159:4$;; ;1$$4 9:;$,1; 9: 1?$ hous|ng cast|ng. Oont|nuous h|gh temperature O-r|ng gasket for Q$51?$, 196?1 -#$,519-:K )+-*.,%*/+( 4.5 W |ED |um|na|re, 6.5 tota| system watts, -30 O start 1$J#$,51/,$K T:1$6,54 ECD 3 1?,-/6? CPP 3 $4$01,-:90 I'M .,9S$, 0-10v d|mm|ng. |ED modu|e(s} are ava||ab|e from factory for easy rep|acement. w|th a >80 ORl. Ava||ab|e |n 4000K (>80 ORl}; add ;/==9U VF 1- -,.$,K 0%&%$1( )44 &'() ;15:.5,. =9:9;?$; 5,$ #-4"$;1$, #-Q.$, 0-51 Q91? m|n|mum 3 m|| th|ckness. These |um|na|res are ava||ab|e |n four standard BEGA co|ors: B|ack (B|K}; Wh|te (WHT}; Bronze (BRZ}; S||ver (S|v}. To spec|fy, add appropra|te suff|x to cata|og number. 7/;1-J 0-4-,; ;/##49$. -: ;#$0954 -,.$,K 234 0$,19=9$. 1- AKBK 5:. 75:5.95: ;15:.5,.;R ;/915W4$ =-, Q$1 |ocat|ons. Protect|on c|ass lP64. 5#6%&/%,- 5#6-&$( EE !$;1$. 9: 500-,.5:0$ Q91? I<@PX@DO A B C !"#$% &'() +,-./01% +,-2$01% 3-4156$% 7-4-,% 8#19-:;% <-.9=9$.% !"#$%&' 1000 BEGA Way, Carpinteria, CA 93013 ( 805j 684-0533 FAX ( 805j 566-9474 www. bega-us . com >0-#",96?1 &'()@AB CDEF A#.51$. DGHEF !"#$%&'( I9$@05;1 54/J9:/J K91? 9:1$6,54 K9,9:6 0-J#5,1J$:1L I9$ cast|ngs are mar|ne grade, copper free ( 0.3% copper content} A360.0 a|um|num a||oy. )&*+"$#,-( 8:$ #9$0$ .9$@05;1 54/J9:/J =50$#451$L EMN 1?90OP 1$J#$,$. 645;;Q 04$5, K91? K?91$ 1,5:;4/0$:1 0$,5J90 0-519:6L Facep|ate |s secured by four (4} socket head, sta|n|ess stee|, 05#19R$ ;0,$K; 1?,$5.$. 9:1- ;159:4$;; ;1$$4 9:;$,1; 9: 1?$ ?-/;9:6 05;19:6L 7-:19:/-/; ?96? 1$J#$,51/,$ 8@,9:6 65;O$1 =-, K$51?$, 196?1 -#$,519-:L )+-*.,%*/+( 6.5W |ED |um|na|re, 9 tota| system watts, -30O start temperature. lntegra| 120v through 277v e|ectron|c |ED dr|ver, 0-10v d|mm|ng. |ED modu|e(s} are ava||ab|e from factory for easy rep|acement. Standard |ED co|or temperature |s 3000K w|th an 85 ORl. Ava||ab|e |n 4000K (85 ORl}; add suff|x K4 to order. 0".-( |EDs supp||ed w|th |um|na|re. Due to the dynam|c nature of |ED techno|ogy, |ED |um|na|re data on th|s sheet |s subject 1- 0?5:6$ 51 1?$ .9;0,$19-: -= &'()@ABL S-, 1?$ J-;1 0/,,$:1 1$0?:9054 .515P #4$5;$ ,$=$, 1- KKKLT$65@/;L0-JL 1%&%$2( )44 &'() ;15:.5,. =9:9;?$; 5,$ #-4"$;1$, #-K.$, 0-51 K91? m|n|mum 3 m|| th|ckness. Ava||ab|e |n four standard BEGA co|ors: B|ack (B|K}; Wh|te (WHT}; Bronze (BRZ}; S||ver (S|v}. To spec|fy, add appropr|ate suff|x to cata|og number. Oustom co|ors supp||ed -: ;#$0954 -,.$,L 345 0$,19=9$. 1- ALBL 5:. 75:5.95: ;15:.5,.;P ;/915T4$ =-, K$1 |ocat|ons. Protect|on c|ass lP65 6-%'2.( CLC 4T;L 7#8%&/%,- 7#8-&$( 131 Tested |n accordance w|th |M-79-08 Recessed wall luminaires shielded Recessed |um|na|res $2%-+:-: 496?1 |amp ) & 7 ))*) +", 6.5W |ED G UM G UM F EM A C B A C B 1 Spot Light 2 Well Light 3 Step Light 4 Wall Light LANDSCAPE LIGHTING SPECIFICATIONS 1. All work shall comply with these drawings, the latest version of the Florida Building Code, and all Applicable Codes and Regulations. Code Compliance is the complete responsibility of the Contractor and any modications required shall be performed at no additional charge. 2. The Contractor is to familiarize himself with and conrm all Drawings, Specications, and existing materials and conditions prior to Bid and commencing the work. Notify the Landscape Architect immediately of any discrepancies. The contractor shall include in his Bid all costs necessary for a complete and operational installation and shall visit the job site prior to bid date. 3. All materials furnished on the job site shall be new and stored in such a manner as to protect them from the elements. 4. Lighting plans are schematic in nature. Fixture symbols are not to scale. Verify exact location and orientation of each xture in the eld with Landscape Architect (L.A.). Verify all quantities, dimensions, and conditions in the eld. Conrm xture nishes & specs with Landscape Architect before purchase. 5. All Contractors are to keep the job site clean and free of debris at all times. 6. Do not scale drawings. Dimensions and/or existing conditions govern. Notify the Landscape Architect immediately of any discrepancies. Stop work in areas of discrepancy until all issues are resolved. 7. All work shall be in strict accordance with the best practices of the construction trade. 8. Contractor to coordinate programming, controls, and electrical with MEP & L.A. 9. All details, sections, diagrams, etc. are intended to be typical and shall be construed to apply to any similar situation elsewhere in the project. 10. The Contractor shall verify all utilities and placement locations of pipe, conduit, equipment, ductwork, etc., prior to submitting Bid to the Owner. 11. Where conicts and/or variances exist in the Drawings or Specications, the arrangement of better quality, greater quantity, and higher cost shall be included in the Bid price. The Landscape Architect will have the nal decision regarding item and manner in which work shall be installed. 12. All xtures to be UL-listed and wet-rated. 13. Owner cannot guarantee that internal changes have not occurred since these Drawings have been prepared. It is the responsibility of the Contractor to eld check all dimensions and conditions. 14. Any penetrations or modications to structural steel or concrete must be coordinated with the project's Structural Engineer. All lumber in contact with concrete or masonry shall be pressure treated. 15. The Contractor shall check in with the on-site Construction Manager prior to start of work. During construction, the Contractor shall coordinate all work with the Owner and the on-site Construction Manager. 16. The Contractor shall verify the locations of site utilities prior to the commencement of work. Existing utilities shall be protected or rerouted as required to accommodate the new work. 17. The Contractor shall inspect the surfaces and substrate conditions on/in which the work shall be performed. Beginning of work means acceptance of existing surfaces, substrates and conditions. 18. Prior to nal acceptance, Contractor shall adjust all lighting to Owner's satisfaction. 19. The Landscape Architect shall have nal decision as to whether work of poor quality and/or substandard workmanship shall be repaired or replaced. 20. The Contractor shall arrange for all building permits and inspections by the building authorities. Cost of all permits, fees, and special inspections shall be in the Bid wherever necessary. 21. The Contractor shall provide proof of insurance and shall not send or employ for this project any laborers or subcontractors. Insurance shall provide protection against public liability and property damage for duration of work. 22. The Contractor shall provide a minimum of one full year warranty for any and all labor and materials they provide, install, or apply. 23. The Contractor shall verify the condition of all existing materials, system, or devices prior to reuse or connection to such materials, systems or devices. Contractor shall bear the full responsibility for reuse of such items and shall provide a minimum 1 year guarantee for all work, materials, and system. 24. These drawings and documents, as instruments of service, are the property of the Landscape Architect and may not be used or reproduced in any manner without his/her express consent. 25. It shall not be the intent of these plans and/or specications to show every minor detail of construction. The Contractor shall be expected to furnish and install all items for a complete system and provide all requirements necessary for equipment to be placed in proper working order. 26. All conduit runs are shown diagrammatically. Exact routing shall be determined in the eld, unless otherwise noted. 27. As-Built drawings shall be furnished to the Owner upon completion of work. URBAN ROBOT LLC MI A MI BEA CH, FL 3 3 13 9 T.786.246.4857 | F.786.768.2537 WWW. URBANROBOT. NET 420 LI NCOLN ROAD S.406 LANDSCAPE ARCHITECT: