06-10-2009
To select the VCR, After turning on the projector (if needed) and sound
record player, or system (see above), press “VCR,” “PHONO,” or
tape player: “TAPE” on the white keypad.
Volume up and down buttons are on the left side of the white keypad.
SU Media Services • 540-665-4551 • www.su.edu/library/media
Ruebush 207 • page 2 of 2 rev. 06-10-2009
No sound? Try these steps while playing sound from your source (Laptop, DVD, etc.).
● The sound system may have been left on before you entered the room (in which case pressing
“ON/OFF BUTTON FOR SOUND SYSTEM ONLY” would have turned it off). Open the door of the
black cabinet and look through the see-through panel labeled “Amplifier.” When the amplifier is on,
it lights up; when the amplifier is off, it is not lit. If you cannot tell whether it is on or off, press the
button labeled “ON/OFF BUTTON FOR SOUND SYSTEM ONLY” again in the lower right of the
white keypad. The amplifier should light up. Then, press the source button again for whichever
source your sound is coming from (Laptop, DVD, etc.).
●
Press and hold the volume up button (on the left of the white keypad) to make sure the volume is
not turned down.
● Make sure the volume is not turned down or muted on your sound source (for example, if you are
playing music from iTunes on your computer, make sure the volume is not muted or turned down on
the iTunes volume control or on your system's volume control).
●
Use the transport control buttons (play, stop, etc.) on the right side of
the white keypad to control the DVD player.
Please report any problems – Visit www.su.edu/library/media and click on “Report an Issue.”
Need more help or training on audio-visual equipment? We're here to help.
Visit www.su.edu/library/media and click on “Request a Support Appointment.”