Anda di halaman 1dari 1

1.10.1.6 Conductor Sizes.

Conductor sizes are expressed in square


millimetres (mm2) for stranded or in millimetres diameter (mm dia.)
for solid.
1.10.1.5 Conductors. Conductors normally used to carry current shall
be of copper unless otherwise provided in this Code. Where the
conductor material is not specified, the material and the sizes given in
this Code shall apply to copper conductors. Where other materials are
used, the size shall be changed accordingly.
Voltage, Nominal. A nominal value assigned to a circuit or system
for the purpose of conveniently designating its voltage class (e.g.,
120/240 volts, 480Y/277 volts, 600 volts). The actual voltage at which
a circuit operates can vary from the nominal within a range that
permits satisfactory operation of equipment.
Plenum. A compartment or chamber to which one or more air ducts
are connected and that forms part of the air distribution system.
Power Outlet. An enclosed assembly that may include receptacles,
circuit breakers, fuseholders, fused switches, buses, and watt-hour
meter mounting means; intended to supply and control power to
mobile homes, recreational vehicles, park trailers, or boats or to serve
as a means for distributing power required to operate mobile or
temporarily installed equipment.
Premises Wiring (System). That interior and exterior wiring,
including power, lighting, control, and signal circuit wiring together
with all their associated hardware, fittings, and wiring devices, both
permanently and temporarily installed, that extends from the service
point or source of power, such as a battery, a solar photovoltaic
system, or a generator, transformer, or converter windings, to the
outlet(s). Such wiring does not include wiring internal to appliances,
luminaires (fixtures), motors, controllers, motor control centers, and
similar equipment.
Service-Entrance Conductors, Overhead System. The service
conductors between the terminals of the service equipment and a point
usually outside the building, clear of building walls, where joined by
tap or splice to the service drop.
Structure. That which is built or constructed.
Service-Entrance Conductors, Underground System. The
service conductors between the terminals of the service equipment and
the point of connection to the service lateral.
1.3.1.1 Drawing Sheet Sizes.
Electrical plans and drawings shall be drawn on drawing sheets
of the following standard sizes:
760 mm x 1 000 mm
600 mm x 900 mm
500 mm x 760 mm

Anda mungkin juga menyukai