2. Show the relation of output and input voltage of the following circuit is
integration.
EXPERIMENT
1. Inverting Amplifier
The configuration and pin diagram of the opamp is given Figure 3.
b. Apply 500Hz, 0.5 Vpp triangular wave from the input. Observe the
output with oscilloscope. Plot input and output waveforms.
c. Add DC offset to the input signal, is there any change on the output
signal? Why?
4. Integrator
a. Build the circuit shown in Figure 7. R=5k and C=0.1F. Dont forget
to connect pin 4 to -15 V and and pin 7 to +15 V. Do not turn on the
supply yet. You can leave pin 1,5, and 8 unconnected.
b. Apply 60Hz, 0.5 Vpp square wave from the input. Observe the
output with oscilloscope. Plot input and output waveforms.
c. Change the function generator back to a sine wave input, sweep
frequency from 100Hz to 100kHz and observe the change of the
gain with frequency.