means:
A. Some specific areas where coastal state legislation doesn???t allow any bilge water/slop
discharges
B. Areas as defined by Annex-1 where no bilge water/slop discharges are allowed
C. Areas as defined by Annex-1, where special mandatory methods are adopted for the
prevention of sea pollution by oil
D. Areas as defined by Coastal state regulations(e.g. OPA-90), where special mandatory
methods are adopted for the prevention of sea pollution by oil
2. In which of the following documents on board, authentic information about the circumstances and
procedures to obtain Radio Medical Advice can be found?
A.
B.
C.
D.
3. Which of the following documents carried by a ship is not issued under the SOLAS convention?
A.
B.
C.
D.
4. When using the rainwater collection tubes on a liferaft, the FIRST collection should be
A.
B.
C.
D.
5. Which of the following is not an exception provided under MARPOL, Annex-1, regarding the
discharge of oil or oily mixture into the sea?
A. Discharge for the purpose of securing safety of a ship
B. Discharge for the purpose of saving life at sea
C. Discharge resulting due to damage to the ship because of Master???s fault even if the
Master/Owner of the ship has taken all reasonable precautions to prevent/minimize
discharge
D. Discharge resulting due to damage to the ship not because of Master???s fault, but because
of a third party???s fault and action awaited by Master from that third party to prevent
/minimize discharge
6. Under OPA 90, who is responsible for mobilizing Oil Spill Removal Organization (OSRO), in the event
of spill of oil or Noxious liquid Substances?
A.
B.
C.
D.
Master
USCG
Qualified Individual
Technical Superintendent
7. As per definition of MARPOL Annex-1, a Crude oil tanker means a tanker designed to carry:
A.
B.
C.
D.
Council
Assembly
Facilitation Committee
None of the above
13.5 Kgs
23 Kgs
9 Kgs
46 Kgs
10. Under which maritime instrument is a Certificate of Financial Responsibility (COFR) issued?
A.
B.
C.
D.
CLC 1992
Fund convention
LLMC
OPA 1990
11. If you observe any situation which presents a safety or pollution hazard during fuel transfer
operations on a MODU, which of the listed actions should be taken first?
A.
B.
C.
D.
12. As per the definition of MARPOL, Annex-1, a combination carrier means a ship designed to carry:
A. Crude oil and refined oil products at the same time in different tanks
B. Refined oil products and chemical products at the same time in different tanks
C. A combination of different products at the same time, sometimes also known as a parcel
tanker
D. Either oil or solid cargoes in bulk
13. As per Marpol requirements, Every crude oil tanker of ______________ tones deadweight and
above delivered after 1st June 1982, shall be fitted with a cargo tank cleaning system using
_______________
A.
B.
C.
D.
14. As per requirements of Marpol Annex -1, all ships of 400 gross tonnage and above:
A. Can carry fuel oil in fore peak, aft peak tanks and deep tanks
B. Cannot carry fuel oil in fore peak tank
C. Can carry fuel oil forward of collision bulkhead or aft of machinery space forward bulkhead,
but not in the cargo area in case of tankers
D. Cannot carry more than 600 m3 of oil fuel in any single fuel tank
15. Which of the following is a man overboard maneuver?
A.
B.
C.
D.
UNCLOS I, 1958
UNCLOS II, 1960
UNCLOS III, 1974
The IMO convention
17. After a person has been revived by artificial respiration, they should be
A.
B.
C.
D.
17. Dumping of wastes at sea is controlled by which of the following IMO conventions?
A.
B.
C.
D.
Marpol 73/78
London convention
Hongkong convention
Kenya convention
18. The angular movement of a vessel about a horizontal line drawn from its bow to its stern is
A.
B.
C.
D.
pitching
rolling
heaving
swaying
19. To prevent oil from escaping into the sea when ballasting through the cargo piping system, you
should FIRST
A.
B.
C.
D.
yaw
sway
surge
heave
21. Which of the following documents carried by a ship is not issued under the MARPOL convention?
A.
B.
C.
D.
IOPP certificate
Oil Record Book
SOPEP
Safety Management Certificate.
22. When a vessel is floating upright, the distance from the keel to the metacenter is called the
A.
B.
C.
D.
metacentric differential
height of the baseline
height of the metacenter
righting arm
23. Voyage data recorders (VDR) or simplified voyage data recorders (S-VDR) are required to be
installed on board certain ships as per_____________
A.
B.
C.
D.
ISPS code
ISM code
Chapter V of Solas
None of the above
Sea anchor
Fishing tackle
Drinking water cans
Life Jacket
25. As per STCW code, the abilities specified under standards of competence are grouped under
_______ functions, for the purpose of issuing certificates of competency.
A.
B.
C.
D.
Seven
Four
Six
Three
26. Under which IMO convention is Voyage Data Recorder- Certificate of compliance issued?
A.
B.
C.
D.
COLREG 1972
SAR 1979
SOLAS 1974
SALVAGE 1989
27. As required by Reg.31 of Annex 1 of Marpol the ODMCS should be provided with a recording
device for ____________ recording the discharge in litres per nautical mile and total quantity
discharged. This discharge should be kept onboard at least for a period of:
A.
B.
C.
D.
Intermittent, 1 year
Continuous, 1 year
Intermittent, 3 years
Continuous, 3 years
28. Changing rescuers while carrying out artificial respiration should be done
A.
B.
C.
D.
29. As per definition of MARPOL Annex-1, a product tanker is one which can carry:
A.
B.
C.
D.
31. In the first 24 hours after abandoning a vessel, water should be given only to personnel who are
A.
B.
C.
D.
thirsty
sick or injured
wet
awake
32. Which of the following conditions can lead to degradation of foam compounds?
A.
B.
C.
D.
33. In which of the following conditions, the IG blower fans should shut down automatically?
A.
B.
C.
D.
34. As regulation 12 of Annex 1 of MARPOL, all ships of __________ gross tonnage and above shall be
provided with a sludge tank for collection of oil residues
A.
B.
C.
D.
35. Life buoy self-activating smoke signals should emit smoke of visible colour for at least
______________ in calm waters.
A.
B.
C.
D.
5 minutes
15 minutes
30 minutes
60 minutes
37. Divisions constructed of steel which can withstand a standard fire test for 30min without passage
of flame or smoke are classified as____________________
A.
B.
C.
D.
B class divisions
A class divisions
A30 class divisions
B 30 class divisions
38. When applying chest compressions on an adult victim during CPR, the sternum should be
depressed about
A.
B.
C.
D.
39. As per requirements of Marpol, Annex 1, all ships delivered on or after 1st Aug. 2010 with an
aggregate oil fuel capacity 600 m3 and above, the oil fuel can be carried in:
A. Any of the tanks without any restriction
41. The purpose of inert gas systems aboard tank vessels is to __________.
A.
B.
C.
D.
42. In reference to accidental oil pollution, the most critical time during bunkering is when ________
a.
b.
c.
d.
44. Your ship is sinking rapidly. A container containing an inflatable liferaft has bobbed to the surface
upon functioning of the hydrostatic release. Which action should you take?
a. Cut the painter line so it will not pull the liferaft container down.
b. Swim away from the container so you will not be in danger as it goes down.
c. Take no action because the painter will cause the liferaft to inflate and open the
container.
d. Manually open the container and inflate the liferaft with the hand pump.
45. The atmosphere in a tank is too lean if it is __________.
a. incapable of supporting combustion because the hydrocarbon content is below the
LFL (LowerFlammable Limit)
shape
shallow draft
large sail area
All of the above
47. What is the generally accepted method of determining whether the atmosphere within a cargo
tank is explosive, too rich, or too lean to support combustion?
a.
b.
c.
d.
Use the open flame test on a small sample that has been taken from the tank.
Send a gas sample ashore for laboratory analysis.
Enter the tank with an oxygen analyzer.
Use an explosimeter
48. Before using a fixed CO2 system to fight an engine room fire, you must __________.
a.
b.
c.
d.
49. You are fighting a fire in the electrical switchboard in the engine room. You should secure the
power, then__________.
a.
b.
c.
d.
50. The minimum concentration of a vapor in air which can form an explosive mixture is called the
__________.
a.
b.
c.
d.
auto-ignition point
flash point
lower explosive limit (LEL)
threshold limit value (TLV)
51. The deck water seal of the inert gas system __________.
a. cools the inert gas and prevents soot from entering the cargo tanks
b. acts as an emergency system shutdown when the inlet pressures exceed the safe working
pressure inthe hazardous zone
c. prevents the backflow of hydrocarbon gasses into nonhazardous areas
d. relieves sudden large overpressures in the system
52. The explosive range of petroleum vapors mixed with air is __________.
a.
b.
c.
d.
0% to 1%
1% to 10%
10% to 15%
12% to 20%
53. Fuel oil tank vents are fitted with a screen which will stop __________.
a.
b.
c.
d.
1. Personnel who are moving or handling material aboard ship should NOT follow which of the listed
practices?
A. Signaling that all personnel are clear before lifting or lowering material.
B. Examining material for sharp edges or protruding points before handling.
C. Closing, tagging, or securing valves that permit entrance of steam, water, or air into a fitting
or other equipment.
D. Throwing materials from high places to the deck
2. Which of the following statements is true?
A. Ballast water exchange at mid ocean eliminates completely the risks associated with
introduction of non-native organisms and pathogens in alien habitats.
B. In the flow through method, the water pumped through a tank should be at least 3 times
the tank volume.
C. Over pressurization of a tank cannot take place during the flow through method.
D. Air pipes on ballast tanks are designed for continuous overflow.
3. The most common cause of engine room fires is:
A. Spontaneous combustion of oily rags
B. Back fire of boilers
C. Ignition sources coming in contact with stored fuel /lubes
5. As per MARPOL annex-1, the ???instantaneous rate of discharge of oil content??? means:
A. The rate of discharge of oil-water mixture in litres per hour at any instant divided by the
speed of the ship in knots at the same instant
B. The rate of discharge of oil in litres per hour at any instant divided by the speed of the ship
in knots at the same instant
C. The average rate of discharge of oil-water mixture in litres per hour divided by the average
speed of the ship in knots
D. The average rate of discharge of oil mixture in litres per hour divided by the average speed
of the ship in knots
8. Which of the following conditions need NOT be satisfied while discharging oil or oil mixtures from
ships into the sea?
A.
B.
C.
D.
11. Which of the following instruments set out carrier's obligations and liabilities with respect to
carriage of goods?
A.
B.
C.
D.
Hague Rules
Hamburg Rules
Hague- Visby rules
All of the above
12. Where would you find a list of the lifesaving equipment onboard your supply boat?
A.
B.
C.
D.
Ship's articles
Station bill
Certificate of Inspection
U. S. Coast Guard Regulations
15
30
45
80
15. Which of the following codes has been issued under both SOLAS and MARPOL conventions?
A.
B.
C.
D.
STCW code
IMDG code
IGC code
ISM code
.BWM
..
.
..
.Agent
.Broker
.Chandler
.None
20.Sewage (disinfected )and communited sewage can be discharged from how many Miles
A. 3 NM from land provided if enroute
23. According to Indian merchant ship act 1958, registrar of ports of Mumbai,Chennai,kolkatta
A.
B.
C.
D.
A.DG shipping
B.MMD
C.Principle officer respective MMD
D.surveyer
A.ISPS
B.ISM
C.LLA
solas
25.What is the minimum percentage of oxygen required before making an entry into an enclosed
space?
A.
B.
C.
D.
20%
18%
11%
21%
26.Selective catalytic reduction is a secondary method for reduction of which of the following
emissions?
A.
B.
C.
D.
SOX
NOX
Carbon oxides
All of the above
27. Air is removed from refrigration sytem by (1)________ at reciver after (2)________(3)________
Gas in receiver. Humidificaton is process of adding water/moiture to discharged airof AC blower.
Demumidification is process of removing water/moisture from air supplied from AC system. For
colecting gas in receiver you need to close the outlet valve of receiver with compressor running
1.PURGING 2.COLLECTING . 3. CONDENSATING
28. One of the important precautions against cold injuries and frost bite would be:
A.
B.
C.
D.
Wear several layers of light clothing rather than one heavy layer of clothing
Wear tight fitting gloves
Rub numb areas of body to warm them up
Work while facing the wind
29. Where would you look to find out what your duties are during a fire?
A.
B.
C.
D.
Ship's articles
Station bill
Certificate of Inspection
U.S. Coast Guard Regulations
31. When administering only mouth-to-mouth resuscitation, you should continue the victim's
ventilation rate at how many inflations per minute?
A.
B.
C.
D.
4
8
12
20
32. Freight paid by charterers on a quantity of cargo short-shipped, i.e quantity agreed upon but not
loaded by the charterer, is called:
A.
B.
C.
D.
Pro-rata freight
Back Freight
Dead freight
None of the above
33. Which of the following extinguishing medium should never be used when fighting fire involving
magnesium?
a. Halon
CLC
LLMC
Fund convention
Athens Convention
35. In refrigeration system vegetable room and meat rooms are maintained at different
A.
B.
C.
D.
36. The working duration of a 1200 litres SCBA bottle, after allowing for a reserve of 10 mins
is____________________ (if 1800litres =40mins)
A.
B.
C.
D.
30 mins
40 mins
20 mins
50 mins
* watering of fire
* starving of fire
* cooling
* smothering of fire
38. The number within bracket of a resolution, say A.526 (13) refers to ____.
a.
b.
c.
d.
39. Certificate of insurance or other financial security in respect of civil liability for bunker oil
pollution damage is issued under what?
A. CLC 1969.
B. MARPOL convention.
Heaving,
yawing,
Swaying,
pitching
41. The stretcher normally used for rescue of casualties from engine room spaces, holds, pump-rooms
etc., is known as _____________________
A.
B.
C.
D.
Williamson stretcher
Neil Hobson stretcher
Neil Robertson stretcher
Stokes stretcher
42. Rolling is the angular motion of the vessel about what axis?
A.
B.
C.
D.
Longitudinal
Transverse
Vertical
Centerline
44. When the height of the metacenter has the same value as the height of the center of gravity, the
metacentric height is equal to
A.
B.
C.
D.
45. The emergency generator should be capable of being started and be able to supply required load
within a maximum of ________________
A. 30 seconds
B. 1 min
C. 45 seconds
D. 2 mins
46. Which of the following kinds of total flooding system is most suited for very large spaces like car
carrier car decks?
A.
B.
C.
D.
47. You are the 4th engineer of a ship. Your 3rd engineer handsover the watch to you and informs you
that the OWS is running with the ppm showing as zero. After taking over the watch and during your
rounds you find out that the rinsing fresh water to 15 ppm device was crack open. After closing the
same you find that the ppm rose to 15 and the OWS stopped after giving alarm. What should you do?
A. Nothing, as Marpol regulations are satisfied till the oily water is being pumped through OWS
and oil content is below 15 ppm
B. Should suspend the operation immediately, inform the Chief engineer about the same and
take appropriate action to restore correct OWS operation
C. Should never touch OWS and any stoppages to be informed either to Chief Engineer or 2nd
engineer
D. If no visible traces of oil are seen on the sea surface and oily water mixture is being pumped
through an OWS, then there is no harm in pumping out with fresh water crack open, to keep
the OWS running as it may give false alarm without Fresh water. This is a practical approach
to run OWS without any trouble without violating Marpol regulations
48. All entries in the Oil record Book part-I are to be:
At least in English, Spanish or national language
At least in English, Spanish or French
At least in English or Spanish
At least in English or national language
49. Plasma reduction system is a secondary method of reduction of which of the following kinds of
emissions?
A.
B.
C.
D.
SOX
Greenhouse gases
NOX
All of the above
50. Back flow towards machinery spaces of cargo vapours in an Inert gas system is prevented
by_____________________
A.
B.
C.
D.
51. Which of the following is not a requirement under MARPOL Annex VI, for new engines?
A. All engines above 130 KW to be tested and issued with EIAPP certificate and Nox Technical
file.
B. Life boat engines and emergency diesel engines to be also tested and issued with EIAPP
certificate and Nox Technical File
C. Periodical verification of EIAPP certificate is mandatory even when there has been no
modification in the engine
D. Engines installed prior to the Nox technical code being applicable will not be subject to
certification and testing unless they undergo major conversion
52. An oil record book Part-I shall be retained onboard for a period of:
A.
B.
C.
D.
55. The maximum capacity of an Oil fuel tank for any ship built on or after 1st Aug. 2010 as restricted
by Marpol, Annex 1 is: (minimum capacity 600m3)
A. 600 m3
B. 1200 m3
C. 2500 m3
D. 3000 m3
56. Each fire pump on a MODU must have a pressure gage located
A.
B.
C.
D.
57. Which of the devices listed must be used in conjunction with the portable in-line foam
proportioner to produce foam?
A.
B.
C.
D.
58. As per the Indian Merchant Shipping Act, 1958, which of the following statements about
ownership of Indian Flag ships is False?
A. A company or body established by or under any Central or State Act, which has its principal
business in India, may be registered as owner by its name
B. Joint owners shall be considered as constituting one person
C. A person can be registered as owner of a fractional part of a share in a ship, the number of
shares being ten
D. Not more than the names of Ten individuals shall be entitled to registered at the same time as
joint owners of any one ship
59. The external flotation bladder on an immersion suit should be inflated
A.
B.
C.
D.
SECTION -3
1.
2.
3.
Greenhouse gas.
SOx
NOx
None of the above
4.
What Agreement of hire called, in which the owner agreed to transport an agreed volume of
cargo over a specific period. The charter designates cargoes and loading date but owner nominate
suitable vessel which are not normally named in agreement.
a.
b.
c.
d.
5.
6.
Time charter.
Voyage charter.
Bare boat charter.
Contract of frightment.
12 to 15 times/min.
16 to 18 times/min.
2 to 5 times/min.
18 to 19 times/min.
Movement of ship about an imaginary line joining aft and fore perpendicular is?
a.
b.
c.
d.
Pitching
Heaving
Sway
roll
7.
Which of the following anti fouling paint is an accepted alternative to now banned TBT based
paint.
a.
b.
c.
d.
8.
Oil or oily mixture discharge into the sea from E/R of ships of 10,000 GRT & above, in special
areas is _______.
a.
b.
c.
d.
9.
10.
200
150
100
250
Each section on a sprinkler system should not contain more than _____sprinkler heads.
a.
b.
c.
d.
24.
12.
ORB has to be regularly updated without delay and each completed page has to be _____.
a.
b.
c.
d.
11.
Not allowed.
Allowed, provided ship is proceeding en route & discharge through oil filtering
equipment with oil content less than 15ppm except in Atlantic Ocean.
Allowed, provided ship is proceeding en route & discharge through oil filtering
equipment with oil content less than 5ppm except in Atlantic Ocean.
Allowed but outside 12Nm from the Nearest Land.
200
150
100
250
First rain water collected over canopy rain water harvesting arrangement has to be ____.
a.
b.
c.
d.
25. In which of the following condition FD fan of Inert gas generator will be tripped?
a. Low sea water level in Deck water seal
b. Low sea water level in scrubber tower
(and two more options... there)
26. Under following,which is not mandatory
A.
B.
C.
D.
LSA
FSS
BLU
FTP
A.every 18 hrs
B.Every 24 hrs
C.Continously
D.Once in two weeks
A.Inland water
B.terristrial water
C.Contigeous areas
D.Continental self
D. none
32. Intact stability book is provided by...:
A.
B.
C.
D.
a.. SOLAS
b.. MARPOL
c..Load Line Convention
d.. Load line Protocol
34. Compliance with which of the following ILO conventions is checked during Port State Control
Inspections?
A.
B.
C.
D.
35. A coastal can take necessary action on the high seas to mitigate, prevent or eliminate
danger of OIL pollution to its coastline following a maritime casualty. Which IMO instrument
guarantees this right to the coastal state?
A.
B.
C.
D.
UNCLOS
MARPOL 73/78
INTERVENTION 1969
London Convention
36. Probably the largest amount of information covering the various aspects of oil spill response in
one place on the net. Which of the following codes is mandatory for chemical tankers constructed on
or after 1July 1986? ( before July 1986 for BCH code)
A. IGC code
B. BCH code
C. IBC code
D. IMDG code
37. A clean ballast tank is one which:(if SBT option A)
a. Is not allowed to carry any oil cargo and solely to be used for the purpose of carriage
of ballast water
b. Is used for the carriage of oil cargo, but has to be cleaned thoroughly prior carriage of
ballast water during ballast voyage
c. Is allowed to carry some white and clean oil cargoes and has to be cleaned up
thoroughly
for the carriage of ballast water
d. Is a tank which was previously being used for the carriage of oil cargo, but was
converted to a ballast tank during last dry-docking, but still has a common pumping
system
for remaining cargo tanks and the converted clean ballast tank
38. A representative sample of fuel oil delivered on board during bunkering is to be retained on
board ________________________
A. For a period of 6 months
B. Till the time the oil is substantially consumed
C. For a period of 12 months
D. Till the time the oil is substantially consumed but not less than 12 months
39. The validity of which of the following certificates is not 5 years?
A.
B.
C.
D.
40. U r fighting with fire with jet hose and multiple fire where wil u first impinge water
a)
b)
c)
d)
CRB
ORB
Procedure and arrangement manual
Bulk carrier booklet
STCW code
ISPC
MARPOL73/78
ISM code
Annex 6
Annex 7
Annex 8
Annex 9
12
14
18
24
15
10
20
30
A.
B.
C.
D.
CORE 1974
CLC 1969
FUND 1971
LLMC 1976
Explosive meter
O2 analyser
LEL
none
30sec
1min
3min
2min
53. Annex I collection of residue tank washing and also oily mixture to be
A.
B.
C.
D.
Bilge tank
Sludge tank
Oily bilge tank
Slop tank
Fire in metal
Fire in liquid
Fire in electrical system
None
1800L
1200L
1500L
600L
SOLAS CH-IV
SOLAS & MARPOL
SOLAS CH-XI
UNCLDS
58. A state party to treaty or convention after the convention been recognized and signed by other
parties and enter into force this action is called.
A.
B.
C.
D.
Ratification
Acceptance
Approval
Accusation
59. in special areas any discharge of oil and oil mixtures from machinery spaces
A.
B.
C.
D.
Prohibited
Enroute and min 12NM
En route and min 50NM
En route with oil filtering equipment
60. standard discharge connection flange as per MARPOL ANNEX I Regulation( od-pcd-th)
A.
B.
C.
D.
200,185,15
215,183,20
205,185,50
200,183,20
1.
Recharging a previously used cartridge-operated dry chemical fire extinguisher is
accomplished by ______________.
a.
b.
c.
d.
2.
a.
b.
c.
d.
e.
3.
In the event of a galley fire on board a general cargo ship, most dry chemical or carbon dioxide
portable extinguishers are automatically activated through the action of a stainless steel cable, spring
and a ____________.
(a)
(b)
(c)
(d)
(e)
4.
The stability of a vessel is normally the greatest when all fuel and water tanks are full because
the _____________.
(A)
(B)
(C)
(D)
5.
6.
7.
Which of the listed systems related to an engineer's signal alarm panel is required to be
indicated by a continuously illuminated light?
(a)
(b)
(c)
(d)
8.
(a)
(b)
(c)
(d)
9.
Halon 1211
Carbon dioxide
Foam
Dry chemical
Bunker "C", a grade "E" combustible liquid, will _______.
(A)
(B)
(C)
(D)
. C) or more
10.
Which of the following statements describes the advantage of using a Halon fire extinguisher
versus a CO2 fire extinguisher?
(A)
(B)
(C)
(D)
11.
(A)
(B)
(C)
(D)
12.
13.
Certificate of Inspection
Muster stations Chart
Ship's Articles
Fire Control Plan
(D)
14.
What is the usual effect of moving weight from the main deck to a position lower in the
vessel?
(A)
(B)
(C)
(D)
15.
The inclining experiment conducted on a merchant ship is the method for determining the
exact location of the __________.
(A)
(B)
(C)
(D)
16.
A.
B.
C.
D.
17.
While wearing a demand-type self-contained breathing apparatus the alarm bell begins
ringing. Which of the following conditions does this indicate?
A.
B.
C.
D.
18.
You are replacing a section of heavy piping on deck and using a chain fall to lift the pipe.
Which of the following precautions should be taken to prevent personal injury?
A.
B.
C.
D.
Position several men under the pipe so they can catch it if it falls.
Attach lines to the ends of the pipe and have your helpers steady the load.
Place an old mattress under the hoist to prevent the load from hitting the deck.
Have a first aid kit at the job site.
19.
With regards to the load line marks, the reason for the placement of mark "WNA" is
______________.
A.
B.
C.
D.
20.
A.
B.
C.
D.
21.
The safe and efficient use of the face piece of a demand-type self-contained breathing
apparatus is directly influenced by ____________.
A.
B.
C.
D.
22. immediately after abandon ship vessel, look out in life raft for
A.
B.
C.
D.
Survivors in water
Food and water
Land
none
23. What is placed on the underside of an inflatable liferaft to help prevent it from being skidded by
the wind or overturned?
A.
B.
C.
D.
A.Ballast bags
B.A keel
C.Strikes
D.Sea anchor
Council,
Assembly,
Safety Committee
Pollution prevention committee
Council,
Assembly,
Safety Committee
Pollution prevention committee
NEW SECTION - 1
B. International tonnage certificate (it is valid until ship is sent for scrap.)
C. Cargo Ship safety certificate
D. Safety Management Certificate
which of these devices prevents the back flow of hydrocarbon??
A. pv breaker
B. pv valve
C. deck water seal
D. scrubber
The flammable limit of methane by volume is 5%to 15%,if the combustible gas indicator
reading is 50% when sampling a compartment containing methane a flammable vapour concentration
at the sample point is
1. 0.5% by volume
2. 2.5% by volume
3. 7.5% by volume
4. 50% by volume
The explosive range of methane is 5% to 15% by volume in air ,This mean a vapor/air mixture of
1. 3% methane by volume is too rich to burn
2. 20% methane by volume is too lean to burn
3. 10% methane by volume is too rich to burn
4. 5% methane by volume will give a reading of 100% LEL on a combustible gas indicator
Intact stability booklet comes under
1.Solas,
2.Marpol
3.Loadline convention
4.Tonnage convention
D. All entries are to be signed by officer or officers in charge concerned, the Chief engineer and the
Master
Which of the following IMO conventions has entered into force?