Introduction
In this practice Packet Tracer Skills Assessment, you will:
Addressing Table
Device
Interface
Address
Subnet Mask
Default
Gateway
Fa0/0
10.10.10.129
255.255.255.248
n/a
S0/0/0
10.10.10.249
255.255.255.252
n/a
S0/1/0
10.10.10.253
255.255.255.252
n/a
S0/0/1
209.165.201.2
255.255.255.252
n/a
HQ
Fa0/0
10.10.10.121
255.255.255.248
n/a
Fa0/1
10.10.10.113
255.255.255.248
n/a
S0/0/0
10.10.10.250
255.255.255.252
n/a
Fa0/0.1
10.10.10.97
255.255.255.240
n/a
Fa0/0.10
10.10.10.1
255.255.255.192
n/a
Fa0/0.20
10.10.10.65
255.255.255.224
n/a
Fa0/1
10.10.10.114
255.255.255.248
n/a
S0/0/0
10.10.10.254
255.255.255.252
n/a
S1
VLAN 1
10.10.10.98
255.255.255.240
10.10.10.97
S2
VLAN 1
10.10.10.99
255.255.255.240
10.10.10.97
H1
NIC
10.10.10.10
255.255.255.192
10.10.10.1
H2
NIC
10.10.10.70
255.255.255.224
10.10.10.65
H3
NIC
10.10.10.125
255.255.255.248
10.10.10.121
NIC
Inside: 10.10.10.132
Outside: 128.107.0.10
255.255.255.248
10.10.10.129
R1
R2
NOTE: The password for user EXEC mode is cisco. The password for privileged EXEC mode
is class.
Configure EIGRP routing on HQ, R1, and R2 using the following parameters:
On HQ, enter the command redistribute static to propagate the default route to R1 and
R2.
b.
Configure the link between HQ and R2 so that the bandwidth of 128 is used in EIGRP
calculations.
c.
Configure R1 and R2 to summarize the following subnets into one advertised route to be
sent to HQ.
R1 and R2 Subnets
10.10.10.0/26
10.10.10.64/27
10.10.10.96/28
10.10.10.112/29
10.10.10.120/29
Configure a static NAT mapping for the Inside Web Server so that the inside IP address is
translated to the outside IP address when packets are routed to the Internet. Use the
addresses in the Addressing Table.
b.
c.
Use PUBLIC as the NAT pool name and translate all inside addresses to the
128.107.0.4/30 address space.
Configure PAT.
Verify that NAT is working.
b.
VTP server.
b.
Configure S1 interface Fa0/4 for access mode and assign it to VLAN 10.
b.
Use the information in the Addressing Table to configure R2 for inter-VLAN routing.
b.