Anda di halaman 1dari 1

API 510 Data Sheets (misc.

other)
Study online at quizlet.com/_su8cq
1.

2.

Define - A flaw that may or may not


exceed the acceptance criteria

Imperfection

25.

NDE- number of CML's to obtain


thickness readings during inspection
(key word)

Representative

Define - alteration (key words)

Physical
change

26.

NDE- number of Nozzles to obtain


thickness readings during inspection
(key word)

Representative

RV's - how relief device intervals are


determined (key word)

Performance

RV's - how relief devices should be


transported

Upright

Weld qualification - maximum allowed


thickness on a WPS based on the plate
thickness (T) of a PQR test coupon

2T

Weld qualification - rejectable in Rt


when qualifying a welder

Crack, Lack of
fusion,
incomplete
penetration

Weld qualification - The "all-position"


test coupon

6G

Weld qualification - which welding


process can a welder not be qualified by
RT

GMAW - SC

Welding - minimum taper required for


shell welds with mismatch

3 to 1

Welding - processes that can be used


when substituting Preheat or controlled
deposition welding for a required
PWHT

SMAW,
GMAW,
GTAW

35.

Welding - variables needed on PQR

Essential

36.

Welding - variables needed on WPS

Essential &
Non- essential

Define - imperfection that exceeds the


acceptance criteria

Defect

Define - location on a vessel of Vessel


MAWP

Top

27.

5.

Define - RBI's two primary factors

Probability
consequence

28.

6.

Define - repair (key words)

Restore suitable

29.

Design - ASME section VIII stamp for


miniature vessels

UM

Design - ASME section VIII stamp for


relief devices

UV

Design - ASME section VIII stamp for


routine vessels

31.

Design - join category of a vessel


circumferential weld

32.

Design - joint category of the vessel


longitudinal weld

Design - marking on a nameplate


indicating vessel was PWHT

HT

Design - marking on nameplate


indicating vessel is in lethal service

Design - maximum set pressure for


single relief device on a vessel

MAWP

15.

Design - RT factors representing Full RT

RT-1, RT-2

16.

Design - RT factors representing Spot RT

RT-3

Design - vessel service that always


requires Full RT

Lethal

Design - weld type - butt double welded

Type 1

Design - weld type - butt single welded


with backing

Type 2

Design - weld type - butt single welded


without backing

Type 3

NDE - hole size that must be visible in RT


when using a hole-type IQI

2T

NDE - lead letter used during RT to check


for backscatter radiation

NDE - lead letter used during RT to


indicate film-side IQI

NDE - two primary Gamma-ray RT


sources

Ir 192, Co 60

3.

4.

7.

8.

9.

10.

11.

12.

13.

14.

17.

18.
19.

20.

21.

22.

23.

24.

30.

33.

34.

Anda mungkin juga menyukai