Crater compounds are black, adhesive residual oil based luburicants recommended for a range of industrial appliactions
where a heavy lubricating oil is required.
The range consists of Crater 2 and 5.
APPLICATIONS
Wire ropes
Flexible couplings
Enclosed gears and traction motor gearcases (where leakage is excessive with conventional lubricants)
BENEFITS
TYPICAL CHARACTERISTICS
Product Code
1060
1062
Grade
15R
0.988
1.004
284
290
Pour Point, C
36
395
1015
PACK SIZES
180kg, 450g bag
Crater
Page 1 / 2
SERVICE CONSIDERATIONS
It is preferable to have gears clean before Crater is applied for the first time. If this is not possible, then several
applications may be necessary to clean off the former lubricant and provide a proper film of Crater.
Application frequency and duration must be determined by the equipment operator in order to minimise wear. Large open
gear tooth wear is not only affected by the lubricant but is also strongly dependent upon proper gear tooth alignment.
Proper alignment must be maintained in order to realise maximum gear life.
When heating of Crater is required to facilitate application, a low temperature heating source should be used. The
circulation of hot water or exhaust steam through coils in a suitable container is a satisfactory method for heating Crater
without generating high heater surface temperatures that can lead to product degradation. Crater should be heated to the
minimum temperature necessary for satisfactory handling.
ENVIRONMENT, HEALTH AND SAFETY
Users should consult the MSDS, follow the precautions outlined and comply with all laws and regulations concerning its
use and disposal. Used packaging material should not be incinerated or exposed to flame. After use, protect your
environment. Do not pollute drains, soil or water with used product.
OTHER INFORMATION
For further information on Caltex products and services call the Lubelink Advisory Service on 1300 364 169 between
8.00am and 6.00pm (EST) Monday to Friday.
Information in this publication is accurate at the time of printing and reasonable care has been taken to ensure it is
complete and accurate. However, this information is subject to change (such as when formulations or usage and storage
information changes). Please visit www.caltex.com.au for the latest product information. Independent advice should be
sought before taking any action in reliance on the information in this publication, and Caltex Australia Limited and its
related bodies corporate accept no liability for any reliance on this publication's content.
Crater
Page 2 / 2