PATENTED
CE CERTIFIED
ISO CERTIFIED
ELECTRICAL CONNECTION
2A
Fuse
Ignition
Switch
12 V Battery
Yellow wire from kit should be connected to 12V Battery after Ignition Switch.
Black wire can be grounded anywhere on vehicle or can be connected to
MECHANICAL CONNECTION
AIR
FILTER
CARBURETTOR
HOSE PIPE
(RUBBER)
Make a 4 mm Hole on the Rubber Hose which connects Air Filter and
Carburettor. Fix the Tube into the hole and glue it Silicon sealant (e.g. Anabond
666). Let it cure for 2 Hrs. in the same position and make sure that it is glued
tight to avoid any leakage
Cut extra length of tube, if not required. Also, use only required length of
electrical wires. We have provided extra length of electrical wires and gas tube,
to be used as spares
Note :
Take all necessary precautions to check and prevent leakage of gas. It is
HIGHLY INFLAMMABLE and dangerous when catches fire.
road.
CARBURETOR SETTINGS
After having installed the Cell and electrical connections made properly, you are
required to set the carburetor correctly to achieve better mileage.
1) Start the vehicle and run it idle for 1-2 minutes.
2) Release the Air Control Valve to allow for maximum air intake. Run the
vehicle for few minutes to ensure that the engine doesn't stop abruptly.
3) Now adjust the Fuel Control Valve so that the fuel supply is decreased to
minimal and engine runs in idle condition smoothly. Finer setting of fuel
supply will result in increased mileage of the vehicle.
4) Make sure to Fine Tune the Air Control Valve and Fuel Control Valve after
running the vehicle for every 200 - 300 Kms until better mileage is
achieved. As the carbon deposits on the inside wall of the engine is
removed, the vehicle performance will increase gradually.
5) Trick is to find Fine setting by "Allow Maximum Air" at maximum RPM and
"Reduce Fuel Supply".
6) Monitor the performance over 1000 Kms of running vehicle.
7) Test your vehicle for Exhaust Emission, Mileage, Engine Power Test (Dyno
Test) Before and After installing the kit.