This alarm indicates that receiveretry count threshold messageStart timing out
.
242. CBL: Device (s) OOS due to action on this device
This alarm indicates that one or moreCBLRelated equipment out of service.
This alarm is only to point out that exit Service but no alarms generated by the
equipment.
5.CBUS:
0. CBUS: Over 50% Boards Detected Clock Failure
This warning indicates that acageMore than50% GPROCAnd full-size board can not
be usedCBUSBus.
1. CBUS: Device Failure: Probable GCLK Card Failure
This alarm indicates that becauseGCLKHad been removed so thatCBUSDoes not work.
At this timeCBUSForOOS.
2. CBUS: Master CBUS Signal Provided By Slave GCLK
This alarm indicates that the primaryCBUSFrom StandbyGCLKReceive the clock sign
al.
3. CBUS: Local KSWX Clock Fiber Failur
This alarm indicates that connect tolclKSWXOfCBUSFiber problems. At this timeCB
USForOOS.
242. CBUS: Device (s) OOS due to action on this device
This alarm indicates that one or moreCBSRelated equipment out of service.
This alarm is only to point out that out of service but did notThere device ala
rm generated.
6.CELL:
0. CELL: Flow control procedure has started barring normal calls from access cla
sses 0-9
This alarm indicates that the process flow control system has started to work, w
ill0-9Some users likebarTo live.
0. CELL: Radio frequency losses while using an SDCCH - PM
This alarm indicates that becauseRFIssues suchSDCCHThe number of dropped calls b
eyond the threshold.
1. CELL: Attempt at allocating an SDCCH failed - PM The statistics show that si
nceSDCCHCongestion and makes theMSSendSDCCHThe number of reject messages beyond
the threshold.
2. CELL: Channel request from MS blocked - PM
The statistics showMSWas denied accessTCHThe number exceeds the threshold.
4. CELL: Class-mark update from MS protocol error - PM
This alarm indicates thatMSGet onClass-markAn error occurred while updating the
number of agreements in excess of the threshold.
6. CELL: Cipher mode command from MSC failed - PM
This alarm indicates that whenBSSToMSSendCipher mode commandAfterMSDoes not res
pond within a certain time so that The number of failures exceeds the threshold
encryption.
9. CELL: Intra-cell HO failed & recovered to original channel - PM
This alarm indicates that when performingintra_cellFailed to switch and return t