Applies To:
09-099
December 18, 2009
PARTS INFORMATION
PROBABLE CAUSE
There is an excessive gap between the keyless
remotes printed circuit board and its lower cover.
VEHICLES AFFECTED
2008 Accord 4-Door ALL
2009 Accord 4-Door L4
From VIN 1HGCP2...9A000001 thru
1HGCP2...9A174234
From VIN JHMCP2...9C000001 thru
JHMCP2...9C018121
TOOL INFORMATION
HDS with software version 2.019.009 or later.
WARRANTY CLAIM INFORMATION
0.2 hour
Failed Part:
Defect Code:
03217
Symptom Code:
01201
Skill Level:
Repair Technician
1 of 4
CUSTOMER INFORMATION: The information in this bulletin is intended for use only by skilled technicians who have the proper tools, equipment,
and training to correctly and safely maintain your vehicle. These procedures should not be attempted by do-it-yourselfers, and you should not assume
this bulletin applies to your vehicle, or that your vehicle has the condition described. To determine whether this information applies, contact an
authorized Honda automobile dealer.
REPAIR PROCEDURE
NOTE: To program the new keyless remote module
using the HDS, you need these items:
The customers programmed ignition key that has
the bad keyless remote.
First password. (This five-character code is available
on the iN. Go to SERVICE, select Vehicle
Information from the left column, then select
Immobilizer Code Inquiry.)
# 0 PHILLIPS
SCREWDRIVER
KEYLESS
REMOTE
MODULE
TAPE
2 of 4
09-099
0 Seconds
START
1 Remove the old
keyless module.
II (On)
17 Seconds
FINISHED
3 While holding the new module in place,
turn the ignition switch to ON (II).
09-099
3 of 4
4 of 4
09-099