LTE RPESS
Radio Planning Process
RA41203EN20GLA0
RA41203EN20GLA0
RA41203EN20GLA0
RA41203EN20GLA0
Module Objectives
After completing this module, the participant should be able to:
List the main steps of the radio planning process
Review the basic parameters important in the dimensioning phase
Describe the typical actions of the nominal planning and of pre-launch
optimisation
RA41203EN20GLA0
RA41203EN20GLA0
Nominal Planning
Detailed Planning
getting Sites
Dimensioning
Pre-launch
Optimisation
RA41203EN20GLA0
RA41203EN20GLA0
Pre-planning
Optimisation
Model tuning
Pre-planning
information
Site selection
Pre-launch
optimisation
Coverage and
capacity planning
Dimensioning
Configuration
planning
Pre-launch
Post-launch
optimisation
optimsation
Parameter
planning
RA41203EN20GLA0
RA41203EN20GLA0
Dimensioning
Following planning parameters are already decided in the dimensioning
phase:
Basic spectrum usage
Operating bandwidth
Coding schemes & modulations
BLER
eNodeB basic configurations
RF unit type (feederless, 3-sector RF module)
1+1+1/omni
Antenna types
Capacity license size (e.g. MIMO or no MIMO)
RF features
Scheduler type, extended cell range (if applicable to the release)
RA41203EN20GLA0
RA41203EN20GLA0
Nominal planning
planning tool
Based on coverage thresholds:
Capacity analysis
Site surveys
Site pre-validation
RA41203EN20GLA0
RA41203EN20GLA0
Detailed planning
Typical actions:
RA41203EN20GLA0
RA41203EN20GLA0
Pre-launch optimization
Target: to pass the cluster acceptance
can be done as part of the cluster acceptance
Typical actions:
Drive test measurements & analysis
eNodeB data base parameter assessment/cross checking
Antenna tilt & azimuth tuning based on drive test analysis
RA41203EN20GLA0
RA41203EN20GLA0