Anda di halaman 1dari 5

SKF Bearing Calculator

Calculation summary report


Published on 2015-01-05 10.00.00 GMT

SKF General Conditions for technical assistance and advice (available at www.skf.com) shall apply to this report.
SKF accepts no variation of any of these conditions unless confirmed in writing by SKF.
SKF is a registered trademark of the SKF Group.
SKF Group 2013
The contents of this publication are the copyright of SKF and may not be reproduced, duplicated, copied, transferred, distributed, stored, modified, downloaded or otherwise exploited for any
commercial use without the prior written approval of SKF.

1. Designation: 30306 J2/Q


Bearing Data
d

30.0 mm

72.0 mm

20.75 mm

56.1 kN

56 kN

1.1

Shaft and Housing tolerances and resultant fits

SKF is a registered trademark of the SKF Group. SKF Group 2013


Page 1

Note: The drawing displayed is only for general representation and may not be identical to the selected bearing
variant.
Input Parameters
Guidance required to select the fits?

true

15 kN

6 kN

r
Radial load
a
Axial load
Operating conditions

Rotating inner ring,


Stationary outer ring & Load
rotates with inner ring

Axial displacement of inner ring on shaft

false

Result

SKF is a registered trademark of the SKF Group. SKF Group 2013


Page 2

P
Equivalent dynamic bearing load

17.4 kN

Shaft tolerances:
Bearing bore tolerance class

Normal CL7C

Bearing bore tolerance values


Max. value / Min. value

+0.0 m / -12.0 m

Shaft tolerance class

h6

Shaft tolerance values


Max. value / Min. value

+0.0 m / -13.0 m

+2.0 m

+5.0 m

1
Diametrical smoothing value for bearing
bore
2
Diametrical smoothing value for shaft
outside diameter
Shaft fits
Maximum
interference (-)/ clearance (+)

Mean

Minimum

Shaft fits, theoretical values

-12 m

0 m

+13 m

Shaft fits, probable values

-8 m

0 m

+9 m

-5 m

+8 m

+20 m

Smoothed shaft fits, probable -1 m


values

+8 m

+16 m

Smoothed shaft fits,


theoretical values

Housing tolerances:
Bearing outer dia. tolerance class

Normal CL7C

Bearing outside diameter tolerance values


Max. value / Min. value

+0.0 m / -16.0 m

Housing tolerance class

P7

Housing bore tolerance values


Max. value / Min. value

-21.0 m / -51.0 m

+2.0 m

+12.0 m

1
Diametrical smoothing value for bearing
outside diameter
2
Diametrical smoothing value for housing
bore diameter

SKF is a registered trademark of the SKF Group. SKF Group 2013


Page 3

Housing fits
Maximum
interference (-)/ clearance (+)

Mean

Minimum

-51 m

-28 m

-5 m

-45 m

-28 m

-11 m

Smoothed housing fits,


theoretical values

-37 m

-14 m

+9 m

Smoothed housing fits,


probable values

-31 m

-14 m

+3 m

Housing fits, theoretical


values
Housing fits, probable values

SKF is a registered trademark of the SKF Group. SKF Group 2013


Page 4

Anda mungkin juga menyukai