8
BatteryCare 9.8 adalah software perawatan baterai laptop modern, sebab software ini
akan memberi informasi detail tentang kondisi baterai yang terpasang pada laptop.
Software ini juga memonitor siklus-discharge baterai dan membantu meningkatkan
masa pakai baterai.
Yang paling penting dalam menggunakan software ini adalah melakukan Kalibrasi, ini
dijelaskan dibagian bawah.
Features
CPU and HDD temperature reading. Memonitor temperatur cpu dan harddrive,
sebab semakin tinggi temperatur akan menyerap daya battery lebih besar.
Automatic power plans switching. Tergantung sumber daya yang dipakai, dapat
otomatis berpindah pada power-plant yang sudah disetting sebelumnya.
Notification area information. Fitur popup yang berisi informasi penting tentang
battery, seperti temperatur, status charge, waktu tersisa, dan mode power plan.
info
tentang
remaining-time,
tingkat
Gambar gambar dibawah akan memberi gambaran jelas tentang apa yang diberikan oleh
software ini, klik gambar untuk tampilan lebih besar.
Melakukan Kalibrasi (calibration)
Biarkan battery selama 2 jam untuk mendinginkan panas dari proses charging.
Dalam periode ini laptop bisa dipakai seperti biasa, tetapi lepaskan adaptor.
Biarkan laptop discharge sampai hibernasi sendiri. Laptop bisa sambil tetap
digunakan.
Ketika laptop shutdown sendiri, biarkan dalam kondisi hibernasi selama 5 jam.
Hal ini diperlukan agar battery mencapai muatan-sisa 5%.
Tancapkan adaptor, dan biarkan mengisi non stop sampai full-charge 100%.
Setelah dilakukan kalibrasi, maka Battery Care akan memberikan informasi yang
benar tentang kondisi battery yang sesungguhnya. Gambar dibawah ini adalah urutan
langkah melakukan kalibrasi baterai untuk software Battery Care 9.8.
cara mengatasinya dengan kalibrasi,,
cara saya utk kalibrasi, charger dulu sampai full, setelah itu tingkatkan kecerahan layar monitor
hingga full,, setelah itu reboot saat booting tekan F8 nanti ada pilihan, dan pilih safe mode (charger
jangan dul dicabut),, nahhh window yg akan tampil adalah warna hitam, tanpa software tambahan yg
aktif,, setelah itu cabut charger, dan biarkan laptop hidup sampai mati (batre habis),,
biasanya ini saya lakukan saat waktu luang, saat saya sedang santai tidak memerlukan bantuan
laptop,, :)
setelah mati,, charger kembali sampai full (jg dulu dihidupkan), setelah full baru hidupkan kembali,,
jika ada pilihan lg, pilih start window normaly,
2.
3.
Immediately press the Esc key and press it repeatedly while the computer
starts.
The UEFI Start Up menu opens.
Figure 1: Startup Menu
4.
5.
6.
7.
8.
The Battery Test page shows Test in progress and the Estimated Time
Remaining.
Figure 5: Estimated Time Remaining
When the test completes, one of the messages and suggested actions from the
following table displays:
Status
Message
Suggested action
Passed
Calibrate
NOTE:Battery calibration
might take several hours to
complete and is best performed
during long periods when the
computer is not in use.
Weak
Replace
No Battery
Unknown
or
Very Weak
Back to top
2.
A welcome screen appears if it has not been deactivated. Use this screen to
set how HP Support Assistant handles updates, whether a taskbar icon or pop-ups
are displayed, and to share anonymous usage data with HP. Remove the check
next to Show this screen when I open HP Support Assistant to avoid seeing
this window in the future.
Figure 7: Welcome screen
3.
4.
5.
Click the Diagnostics tab, and then click the HP Battery Check box.
Figure 10: HP Battery Check
6.
HP Battery Check displays the test results when the test is complete.
Figure 12: Battery status
Passed
Calibrate
Replace
No Battery
With each status result you see, there are on-screen instructions. Follow the
instructions to calibrate or replace the battery as needed.
Back to top
2.
3.
1.
2.
3.
4.
Immediately press the Esc key and press it repeatedly while the computer
starts.
You might have to try this more than once to see the Startup Menu menu. If
Windows opens, shut down the computer and start again.
5.
6.
7.
Click Loop until error and allow the battery to fully discharge while doing the
test
NOTE:You are doing the Hard Disk Test only to drain or discharge the
battery, not to get the results of the test. The battery discharges and the
computer turns off before the test results display.
Step 3: Recharge the battery
1.
2.
3.
Check the battery charge. Turn on the computer and start Windows normally.
Click to go to the Desktop. Mouse over the battery icon in the system tray.
NOTE: If you plug in your power cord and immediately run the HP Battery
Check, you might get a false failure showing the battery is bad. If the
battery is in a low charge state (at less than 3%) you might also get a false
reading.
Step 4: Run the battery test
1.
2.
3.
Immediately press the Esc key and press it repeatedly while the computer
starts.
The Start Up menu opens.
Figure 14: Startup Menu
4.
5.
6.
7.
The Battery Test page shows Test in progress and displays the Estimated Time
Remaining.
The results of the battery test display on the Battery Test page. If the battery is
calibrated, theBattery Test reports PASSED .
If the battery status is Calibrate, follow the instruction to calibrate the battery. If
the battery does not calibrate a second time it might need to be replaced. Purchase
a new battery by contacting www.hp.com .
Biarkan baterai terpakai setidaknya selama dua jam dengan keadaan tersambung dengan
jaringan listrik. Ini akan memastikan baterai sudah agak dingin dari panas akibat proses
charging. Anda bisa tetap menggunakan laptop dengan normal. Tapi jangan dipakai untuk
pekerjaan yang berat. Lebih baik biarkan dia menyala tanpa dipakai.
seperti ini:
Lepas charger dari laptop dan jaringan listrik, dan biarkan laptop anda menyala sampai
baterainya habis, toh, tadi kan sudah diatur untuk pindah mode ke sleep atau hibernate
ketika tinggal 5% to?
Jika anda tidak sedang perlu menggunakannya dalam proses ini, aturlah supaya laptop
tidak ke mode sleep atau hibernate dalam keadaan idle. Jika nanti laptop anda masuk ke
mode power-saving ketika anda tinggalkan, ya, percuma saja kan, tidak bisa menguras
baterainya.
Baterai laptop anda akan terpakai dan laptop akan mati. Biarkan setidaknya 5 jam atau
lebih.
Silahkan charge ulang laptop anda sampai penuh 100%. Dalam proses ini anda boleh
menggunakannya secara normal.