from following these instructions. They are to be used at your own risk. As alwa
ys, you should refer to a Factory Repair Manual for your vehicle!
This procedure details how to match new radio-frequency remotes to m
any VW/Audi vehicles. This does NOT show how to match Immobilizer components, se
e other items on the Car Info & Procedures Page to do that.
Procedure for matching radio-frequency remote controls to many VW & Audi
vehicles:
Check the Ross-Tech Wiki under Diagnostic Procedures for instructions sp
ecific to your vehicle.
Gather ALL the remotes you would like to match. Insert one key in the ig
nition and turn it ON.
[Select]
[46 - Cent. Conv.] or [35 - Cent. Locking] (whichever is applicable to
the car, as found here)
[Adaptation - 10]
Enter channel "01" (May be channel "21" in some Audi models).
[Read]
This will display the number of currently stored remotes in "Stored Valu
e".
Enter your total number of keys up to a maximum of 4(including any exist
ing keys) in "New Value"
[Test]
Verify that the number in "Test Value" is correct.
[Save]
Then press and hold (for at least one second) the UNLOCK button on the f
ob, at which time it will be learned. If you're programming more than one fob pr
ess and hold the UNLOCK button on the second fob for one second, press and hold
the UNLOCK button on the third fob for one second, etc. You have a total of 15
seconds to do them all.
The car may give you some sort of acknowledgement as each key is learned
(lights flash, horn beep, etc.)
If the above procedure does not work (neither Channel 01 nor Channel 21
are available), follow this procedure:
Insert a working (old) key in the ignition and turn to the ON position (
do not start car).
[Select]
[Adaptation - 10]
Enter channel "00"
[Read]
[Save]
When the prompt asks if you are sure you want to save a value of 0 to Ch
annel 00, click [Yes]
After doing so, no remotes will be matched. You'll need to follow the ap
propriate above procedure to match all of the remotes.