information about the current set-carriers. In response to the target RAN generates a handover
command, and returns the source eNodeB.
3. Source eNodeB sends a message from the mobile team to EUTRA UE, which includes interRAT or message received from the target (in the case of transmission), or the target cell /
frequency and inter-RAT several parameters (in the case of COC).
4. After receiving the message from the mobility team EUTRA, UE starts timer T304 and
connect to the target node, or by using the radio to get the configuration (transfer) or by
initiating a connection (CBS) in accordance with the specifications of the target RAT.
The upper layers of the UE reports to the AS the target RAT, that the carriers are installed.
Consequently, UE may occur if some of the established carriers, were not admitted to the target
RAN node.
For CDMA2000
For CDMA2000, additional procedures have been defined to support the transfer of information
dedicated to the CDMA2000 upper layers, which are used to record the presence of the UE in
the core network before performing the handover target (the preregistration). These procedures
use SRB1.
Article Topics :
handover procedure, handover, source enodeb, mobility, target, procedure, network, enodeb