@As
\B
|A.
|B.
|C.
|D.
6 months
year
3 years
5 years
@There is a difference between join type and weld type. Which of the following i
s considered a joint type?
\C
|A. groove
|B. fillet
|C. tee
|D. spot
@The term "stick Welding" is commonly used to refer to:
\A
|A. SMAW
|B. GTAW
|C. GMAW
|D. FCAW
@The term "TIG" is commonly used to refer to:
\B
|A. SMAW
|B. GTAW
|C. GMAW
|D. FCAW
@The term "MIG" is commonly used to refer to:
\C
|A. SMAW
|B. GTAW
|C. GMAW
|D. FCAW
@The heat affected zone of a weld is the:
\B
|A. portion of the base metal that has been melted and re-solidified
|B. portion of the base metal that has been melted but where properties have bee
n altered by the welding heat
|C. portion of the base metal that is added to produce the weld joint
|D. original metal that is welded
@Arc strikes form a discontinuity that is caused by:
\C
|A. excessive heat during the welding process
|B. use of improper or wet process
|C. welding operator error
|D. molten particles splashed out of the molten puddle
@Weld splatter form a discontinuity that is caused by:
\D
|A. excessive heat during the welding process
|B. use of improper or wet process
|C. normal welding operation
|D. molten particles splashed out of the molten puddle
@Which of the following discontinuities would you find in weldments?
\A
|A. Porosity
|B. blow holes
|C. cold shuts
|D. burst
@Which of the following discontinuities would you expect to find in a weld that
has been in service?
\A
|A.
|B.
|C.
|D.
cracks
blow holes
cold shuts
burst
actual throat
theoretical throat
crown
leg length
@GTAW produces coalescence by heating metals with an arc between the work and a:
\C
|A. bare filler metal electrode
|B. covered tungsten electrode
|C. bare tungsten electrode
|D. covered filler metal electrode
@The distance from the root of the fillet weld to the crown in a convex fillet w
eld is the:
\A
|A. actual throat
|B. theoretical throat
|C. crown
|D. leg length
@Which of the following describes a joint type that could be joined with a fille
t weld?
\C
|A. Single-V
|B. Edge joint
|C. Tee-joint
|D. Double level
@Crown reinforcement and root reinforcement are both considered when measuring t
he:
\B
|A.
|B.
|C.
|D.
\C
|A.
|B.
|C.
|D.
crater crack
undercut
lack of penetration
underfill
@A small star shaped pattern at the termination point of a weld bead is usually
an indication of:
\A
|A. crater crack
|B. undercut
|C. lack of penetration
|D. underfill
@Tungsten inclusions and suckback are most characteristic of which welding proce
ss?
\C
|A. SMAW
|B. GMAW
|C. GTAW
|D. FCAW
@In
\C
|A.
|B.
|C.
|D.
lack of penetration
porosity
underfill
crater crack
undercut