Study
DOCUMENT TITLE:
Client:
Location:
Project No:
Contract No:
RIP
RL
DESCRIPTION
ORIG.
CHKD
EBATECH
REV
DATE
PAGES
CLIENT
APPROVED BY
Summary_rev.000.docx
Page 1 of 4
Preliminary Report
No. 0001
Rev. 0
TABLE OF CONTENTS
1.
1.1
1.2
Summary_rev.000.docx
Page 2 of 4
Preliminary Report
No. 0001
1.
Rev. 0
EXECUTIVE SUMMARY
1.1
Summary
1.1.1
Study Objectives
The studies are required to size preliminary ratings for substation
equipment (circuit breaker, disconnect switches, bus bar and etc.)
1.1.2
1.1.3
Assumptions
The following were assumed in this preliminary report:
1.1.4
Faulted Buses:
The following were assumed to be the faulted bus in this study (please
refer to Appendix 1):
Summary_rev.000.docx
Page 3 of 4
Preliminary Report
No. 0001
1.1.5
Rev. 0
Other information:
This section is provided to understand the softwares report in contrast
with the typical breaker rating. The tabulation of important terms for
short circuit is given below:
ETAP ANSI
Duty Report
Interrupting Symmetrical
kA rms
Interrupting Adjusted kA
rms
1.2
Typical ANSI
Breaker Rating
Rated Interrupting kA
Maximum Interrupting
kA
Momentary
Asymmetrical kA rms
Momentary
Asymmetrical kA peak
Description
Rated short circuit
interrupting kA in rms
Maximum short circuit
interrupting kA in rms
Close and latch
capability in
asymmetrical kA rms
Close and latch
capability in
asymmetrical kA peak
Appendix
1.2.1
List of Appendix
Below are the descriptions of Appendices that are included in this
document:
Appendix 1 Single Line Diagram
Appendix 2 SLD with ANSI Duty Result
Appendix 3 Short Circuit Report
Appendix 4 ANSI Duty Report
Summary_rev.000.docx
Page 4 of 4