ADDENDUM No. 2
Summary Sheet
Sl.
No.
Tender
Document
Page no.
1.
Vol.-1 NIT
10
Clause 2.2.1 b
2.
Vol.-1 NIT
12
Clause 2.2.3 i
3.
Vol.-1 NIT
17
Clause 2.11
4.
Vol.-1 ITT
Clause 10.5
5.
Vol.-1 ITT
20
Form of Tender
Page 3 of 3
6.
Vol.-2
Technical
Specifications
44
7.
8.
9.
10.
15
Vol. 4 BOQ
11.
31
12.
32
13.
42
14.
50
Clause
no./Item no.
Remarks
Replace page 10
with 10 R
Replace page 12
with 12 R
Replace page 17
with 17R
Replace page 9
with 9R
Replace page 20
with 20R
Replace page 44
with 44R
Vol.-5
Drawings
16. List of approved makes
17. Soft Copy of Depot Layout Plan
15.
Addendum /
Corrigendum
Clause 2.2.1 b
modified
Clause 2.2.3 I
modified
Clause 2.11
modified
Clause 10.5
modified.
Form of Tender
Page 3 of 3
modified
a.
b.
True and proper setting out and layout of the Works, bench marks and provision of all
necessary labour, instruments and appliances in connection therewith as specified or
as directed;
c.
d.
e.
f.
g.
j.
Clearing of site and handing over of all the Works, as specified or as directed;
k.
l.
m.
n.
Any other item of work as may be required to be carried out for completing the work
under this Contract in all respects in accordance with the provisions of the Contract
and/or to ensure the structural stability and safety during and after construction.
o.
10R
appliances as per requirement, soil & waste pipe and disposal of sewage into
local bodies sewer lines or by other alternative method.
ii.
Storm water drainage system including drainage of the roof and railway
tracks consisting of vertical rain water pipes and open and underground
drainage system.
iii.
Plumbing & sanitary works for coach washing, bogie washing and other
washing facilities in the Depot including provision of water tanks, pumps,
supply pipes & drainage pipes.
iv.
v.
vi.
vii.
The work is to be constructed and maintained as per the relevant Codes, CPWD
Specifications, Special Specifications, Tender drawings as per Vol. I of the tender
documents or as directed by the Engineer
2.2.4
The value of the work shall be on rates accepted as per BOQs in letter of acceptance
subject to such additions thereto or deductions there from as may be made under the
provisions of the Contract.
The rates shall be inclusive of all cost but not limited to the cost such as for Plants,
Equipments, tools, all type of labors, supervision, all materials from the source of
supplies as approved by Engineer/Employer including all lead and lifts, transport, all
temporary
works,
erection,
maintenance,
contractors
profits&
Interfaces Work
In addition the Contractor shall be required to carry out various miscellaneous works
as per interfacing requirements.
The Scope of Work for various interfacing works for other Contracts e.g. Signalling
and Telecommunication, Traction Power & Power Distribution, Track work, Rolling
Stock, Pre Engineered buildings etc. shall be but not limited to as described below:
2.3.1
12R
2.9
Preliminary Drawings
Preliminary drawings as listed in Volume -V represent Employers proposal based on
preliminary design. Detailed working drawings will be given for construction of work
subsequently.
2.10
Construction Depot
For casting yard, batching plant and other activities land of suitable size as per
contractors plan accepted by DMRC shall be made available in the Depot area itself.
Contractor should plan execution of work accordingly.
2.11
Time Schedule
The agency shall submit with the tender "Time Schedule" for completion of various
portions of works. This schedule is to be within the overall completion period of 18
months. The intermediate milestones as mentioned in clause 17.0 of Special
Conditions of Contract are to be indicated specifically in the time schedule. The
detailed programme in the form of a quantified bar chart or CPM network shall include
all activities from start to completion.
SECTION 3
TENDER PRICES AND SCHEDULE OF PAYMENT
3.1
3.1.1
Tender Prices
a. Unless explicitly stated otherwise in the Tender Documents, the contract shall be
for the whole works, based on the Bill of Quantities and payment shall be as per
accepted rates of Contract.
b. All duties, taxes, fees, octroi, Labour cess and other levies, payable by the
Contractor under the Contract shall be included in the total Contract Price
submitted by the Tenderer, except Rajasthan VAT and Entry tax which shall be
reimbursed by DMRC on actuals against documentary proof based on tax invoices
raised by the tenderer.
c.
The evaluation of the Tender by the Employer shall be made on the basis of
quoted rates only.
d. The Contract Price quoted by the Tenderer is subject to adjustment during the
performance of the Contract in accordance with the provisions of Clauses 66.0
and 67.0 of the General Conditions of Contract.
3.1.2
The payment to the Contractor will also include the following. The prices and
measurements referred to will be based on actual measurements.
(ii)
(iii)
10.5
The tenderer should quote his rates inclusive of all taxes, duties, royalties, Labour cess
etc. except Rajasthan VAT & Entry Tax which shall be reimbursed as per guidelines
issued with the notification by Government of Rajasthan, Finance Department (Tax
division) dated 06-10-10. It should be noted that Jaipur Metro Rail Corporation is likely
to receive exemptions on customs duty, central excise duty. The successful tenderer (the
Contractor) shall maintain meticulous records of all the taxes and duties paid and provide
the same as and when required by the Employer to seek reimbursement. Alternatively,
the Employer may direct the Contractor to get the reimbursements based on exemption
certificates / governments order and it shall be obligatory on part of the Contractor to get
the exemptions / reimbursements as the case may be and pass it on to DMRC.
10.6
Delhi Metro Rail Corporation Ltd., a non-government Railway, is executing the work as
deposit work awarded by Jaipur Metro Rail Corporation again a non-government Railway
to DMRC and
extended to Jaipur Metro. Tenderers are requested to study the Section 65 & 66 of
Finance Act, 2007 (budget 2007-08) regarding Applicability of Service Tax along with
the relevant circulars and instructions in the matter issued by Ministry of Finance,
Department of Revenue and bid accordingly.
11.0
11.1
12.0
TENDER VALIDITY
12.1
The tender shall remain valid and open for acceptance for a period of 120 days from the
Last date of submission of tender as indicated in NIT.
12.2
In exceptional circumstances, prior to expiry of the original tender validity period, the
Employer may request the tenderers for a specified extension in the period of
validity
in writing or by Tele-fax. A tenderer may refuse the request without forfeiting his tender
security. A tenderer agreeing to the request, shall not be required or permitted to modify
his tender but will be required to extend the validity of his tender security
correspondingly.
13.0
TENDER SECURITY
13.1
The Tenderer shall furnish with his tender, a tender security in the form of Bank Draft in
favour of DMRC payable at New Delhi from a Scheduled Commercial Bank excluding
Regional Rural Bank (RRB) and Local Area Banks (LABs) based in India or Fixed
Deposit Receipt of a Scheduled Commercial bank excluding Regional Rural Bank (RRB)
and Local Area Banks (LABs)/ Post office based in India duly pledged in favour of
DMRC or in the form of an irrevocable Bank Guarantee (on the format given in Form B of
9R
FORM - A (PAGE 3 OF 3)
APPENDIX TO THE FORM OF TENDER
S. No
i.
REF TO
DESCRIPTION
REQUIREMENT
CLAUSE NO.
4.6.2
of
the
of
GCC
II.
Clause
the GCC
Price.
Insurance
of the GCC
10.1
GCC
specified in GCC
iii.
iii
of
the
15 days
of
the
18 Months
acceptance (LOA)
Iv
10.1
GCC
of the work
v.
10.8.2 of the
GCC
date
due
to
delays
by
the
Contractor
vi
Clause 17.3.1
of
certificate
and 21 of SCC
Date
: ..
Place
:.. .
the
12 months
GCC
20R
GENERAL SPECIFICATIONS
wastewater into the sewerage system. Leachate shall be separately collected and
transported to nearby STP for treatment and discharge into surface water.
Oil removal / interceptors shall be provided to treat oil waste from workshop areas
etc. .
The Contractor shall take measures to prevent discharge of oil and grease during
spillage from reaching drainage system or any water body through Spill Prevention
and Control Plan.
17.5
NOISE
General
(1)
Deleted
(2)
(b)
(3)
The Contractor shall ensure that noise generated by work carried out by the
Contractor and his sub-Contractors during day time and night time shall not
exceed the maximum permissible noise limits, whether continuously or
intermittently, as given in the Employers Environmental Quality Management
Manual. The same may be varied from time to time by and at the sole
discretion of the Employers Representative, In the event of a breach of this
requirement, the Contractor shall immediately re-deploy or adjust the relevant
equipment or take other appropriate measures to reduce the noise levels and
thereafter maintain them at levels which do not exceed the said limits. Such
measures may include without limitation the temporary or permanent
cessation of use of certain items of equipment.
(4)
Page 44 of 51
BOQ Abstract
Contract JP/EW/C4 : Civil works for construction of Depot cum Workshop at Mansarover on East West Corridor for Stage I of Jaipur Metro
Sl. No.
Description
Amount ( Rs)
Contractor's Percentage
(Above / Below / at par)
Structural work
Finishing work
Plumbing
Property Development
a) in figures..
b) in words
b) in words.
94147367.00
a) in figures
a) in figures..
b) in words
b) in words.
a) in figures
a) in figures..
b) in words
b) in words.
a) in figures
a) in figures..
b) in words
b) in words.
a) in figures
a) in figures..
b) in words
b) in words.
a) in figures
a) in figures..
b) in words
b) in words.
a) in figures
a) in figures..
b) in words
b) in words.
49127566.00
a) in figures
264951118.00
Boundary wall
7274251.00
683651822.00
24754956.00
PART- B On DSR-2007
6
5000000.00
a) in figures..
Total
1128907080.00
N.A.
b) in words.
Description
Section 1
Site Levelling
43894394.69
Section 2
Road work
30852820.32
Section 3
Earth Work
6243918.81
Section 4
Concrete Work
Section 5
Form work
Section 6
Reinforcement Work
62636875.00
Section 7
Miscellaneous
13864617.54
Total
107458491.90
0
264951118.00
BOQ(Structural)
Description
Qunatity
Unit Rate
Amount
1.2
1.3
1.4
108281
Sqm
3.01
325925.81
0.00
86964
Cum
175.00
15218700.00
0.00
124804.6
Cum
96.40
12031163.44
28850
Cum
550.00
15867500.00
Description
BOQ(Structural)
Qunatity
Unit Rate
1.5
1.6
300
300
300
sqm
sqm
sqm
Amount
301.25
120.50
241.00
0.00
90375.00
36150.00
72300.00
0.00
0.00
2738
Rm
90.38
247460.44
100
Rm
48.20
4820.00
43894394.69
BOQ(Structural)
Description
Qunatity
Unit Rate
Amount
2.1
Providing
and
laying
granular
base.(Included in Section-1, Item 1.4)
2.2
1725
Cum
550.00
a
b
2024
4113
Sqm
Sqm
12.15
9.64
2.4
deleted
2.5
1000
Cum
5000.00
5000000.00
0.00
350
Cum
6000.00
2100000.00
0.00
Cum
295.23
118092.00
2.3
2.6
2.7
sub
948750.00
0.00
0.00
24591.60
39649.32
0.00
0.00
0.00
(B)
RIGID PAVEMENTS
400
8231082.92
2.12
2.13
2.14
BOQ(Structural)
Description
Qunatity
Unit Rate
Amount
1351
Cum
2747.40
3711737.40
0.00
3782
Cum
5000.00
18910000.00
TOTAL (A
SUMMARY
B)
CARRIED
OVER
TO
30852820.32
3.1.1
3.1.2
16254
Cum
96.40
2431
Cum
84.35
1566885.60
0.00
205054.85
0.00
BOQ(Structural)
Description
Qunatity
Unit Rate
3.2
3.3
Amount
404
Cum
285.59
115378.36
0.00
7261
Cum
600.00
4356600.00
6243918.81
4.1.1
and
tie
beams,
under
floors,
4.1.3
4.1.4
4.2
6685
Cum
3230.00
21592550.00
0.00
56
Cum
3553.00
198968.00
0.00
224
Cum
3553.00
795872.00
0.00
501
Cum
4040.00
2024040.00
0.00
0.00
0.00
Description
BOQ(Structural)
Qunatity
Unit Rate
Amount
0.00
0.00
4.2.2
4.2.3
5500
Cum
4040.00
22220000.00
0.00
600
Cum
5400.00
3240000.00
0.00
2500
Cum
5400.00
13500000.00
0.00
0.00
0.00
4.2.4
deleted
4.2.5
169
Cum
5600.00
946400.00
0.00
557
Cum
5400.00
3007800.00
0.00
108
Cum
5000.00
540000.00
0.00
7775000.00
0.00
4.2.6
4.2.7
4.2.8
1555
Cum
5000.00
4.2.9
5500
Cum
5400.00
29700000.00
0.00
26
Cum
5000.00
130000.00
0.00
Description
BOQ(Structural)
Qunatity
Unit Rate
Amount
35
Cum
6000.00
210000.00
0.00
Cum
572.38
2861.90
0.00
0.00
0.00
0.00
0.00
0.00
0.00
350
Cum
4500.00
1575000.00
deleted
4.3.2
deleted
4.4
4.4.1
107458491.90
6.2
1325
MT
46250.00
61281250.00
0.00
30
MT
45187.50
1355625.00
62636875.00
BOQ(Structural)
Description
Qunatity
Unit Rate
Amount
7.2
7.3
7.4
11
MT
4759.75
52357.25
0.00
Cum
63865.00
319325.00
0.00
45
Cum
65793.00
2960685.00
0.00
60
MT
57237.50
3434250.00
0.00
500
Sqm
1072.45
536225.00
0.00
Structural
steel
inserts,
corner
7.6
0.00
0.00
90390.00
0.00
2892.00
0.00
7.6.1
Width 20 mm
3000
RM
30.13
7.6.2
Width 50 mm
50
RM
57.84
7.7
313939
Cucm
5.72
1795731.08
0.00
20
Sqm
161.47
3229.40
0.00
20
Sqm
55.43
1108.60
0.00
7.8
7.9
Description
BOQ(Structural)
Qunatity
Unit Rate
7.10
7.11
Amount
95880
Kg
7.23
693212.40
0.00
3139
45.79
143734.81
0.00
0.00
0.00
618
Rmt
1807.50
1117035.00
0.00
7.12
deleted
7.13
7.14
7.15
2
35
80
60
2
5
3687.30
Each
4609.13
Each
5530.95
Each
6452.78
Each
9218.25
Each
Each 11061.90
0.00
7374.60
161319.55
442476.00
387166.80
18436.50
55309.50
0.00
0.00
0.00
0.00
2
2
3
2
2
2
7374.60
Each
8603.70
Each
9832.80
Each
Each 11061.90
Each 12941.70
Each 14749.20
0.00
14749.20
17207.40
29498.40
22123.80
25883.40
29498.40
0.00
0.00
0.00
Description
BOQ(Structural)
Qunatity
Unit Rate
Amount
0.00
7.17
7.18
0.00
0.00
300
RM
2410.00
723000.00
0.00
0.00
0.00
15
Sqm
4860.97
72914.55
10
10
20
50
Each
Each
Each
Each
2287.09
7157.70
2169.00
1012.20
0.00
22870.90
71577.00
43380.00
50610.00
100
200
500
Shifts
Shifts
Shifts
571.17
361.50
233.77
0.00
57117.00
72300.00
116885.00
7.19
0.00
0.00
0.00
50
sqm.
210.88
10544.00
Description
BOQ(Structural)
Qunatity
Unit Rate
Amount
0.00
7.2 0
7.21
25
25
25
25
Nos.
Nos.
Nos.
Nos.
179.00
252.00
323.00
584.00
25
25
25
25
25
25
25
Nos.
Nos.
Nos.
Nos.
Nos.
Nos.
Nos.
137.00
204.00
295.00
759.00
1538.00
2145.00
4072.00
0.00
4475.00
6300.00
8075.00
14600.00
0.00
0.00
3425.00
5100.00
7375.00
18975.00
38450.00
53625.00
101800.00
13864617.54
264951118.00
Description
Section 1
Brick Work
16,001,215.00
Section 2
Stone Work
4,879,147.75
Section 3
Wood Work
Section 4
Steel Work
Section 5
Flooring
Section 6
Finishing
13632117.17
Section 7
Roofing
12768892.83
Section 8
Water Proofing
Section 9
Miscellaneous
Total for finishing
12090944.61
9,667,234.64
20,030,644.16
1,409,850.00
3667320.42
94147367.00
BOQ(Finishing)
Description
1.1
Quantity
Unit
Rate
Amount
2490
Cum
2831.75
7051057.50
0.00
1.2
a)
1.3
0.00
2435
Cum
3012.50
0.00
7335437.50
0.00
0.00
a)
4000
Sqm
361.50
0.00
1446000.00
0.00
1.4
4000
Sqm
42.18
168720.00
2.1
16,001,215.00
Granite Stone Black and Texture Over 1.0 sqm but upto
2.0 sqm
2.2
2271.00
Sqm
1800.00
4087800.00
0.00
4660.00
Metre
168.70
0.00
786142.00
0.00
BOQ(Finishing)
Quantity
Unit
Rate
Amount
30.00
Metre
138.58
4157.40
0.00
2.4
29.00
Each
36.15
1048.35
4,879,147.75
3.1
a)
18.00
Sqm
2711.25
48802.50
0.00
b)
292.00
Sqm
3133.00
914836.00
3.2
0.00
flush doors fixed with approved adhesive, pressed and
150.00
Sqm
795.30
119295.00
0.00
1153.00
Sqm
921.83
1062869.99
0.00
38.00
Sqm
27.72
1053.36
0.00
0.00
0.00
0.00
Description
BOQ(Finishing)
Quantity
19086.00
Unit
Kg.
Rate
361.50
Amount
6899589.00
0.00
0.00
3.6
2536.00
Kg.
379.58
0.00
962614.88
0.00
3.7
25.00
Sqm
319.33
7983.25
279.00
Sqm
1873.78
522784.62
0.00
0.00
0.00
3.8
7.00
Each
71.10
497.70
approved make)
0.00
3.9
0.00
0.00
a)
250 x 10 mm
b)
100 x 10 mm
3.10
280.00
Each
71.10
19908.00
50.00
Each
38.56
1928.00
0.00
0.00
marked anodised (anodic coating not less than grade AC
0.00
10 as per IS : 1868) transparent or dyed to required
colour or shade with nuts and screws etc. complete.
0.00
a)
250 x 16 mm
20.00
Each
150.63
3012.60
BOQ(Finishing)
Description
b)
300 x 16 mm
3.11
Quantity
Unit
Rate
113.00
Each
159.06
Amount
0.00
17973.78
0.00
0.00
0.00
0.00
a)
125 mm
b)
100 mm
3.12
248.00
Each
57.84
14344.32
33.00
Each
39.77
1312.41
0.00
0.00
0.00
0.00
a)
3.13
50.00
Each
81.94
4097.00
0.00
0.00
floors and cover plates with brass pivot and single piece
MS sheet outer box slide plate etc. complete as per the
direction of Engineer-in-charge.
0.00
a)
3.14
9.00
Each
2842.60
25583.40
0.00
100.00
Each
142.19
14219.00
0.00
3.15
10.00
Each
66.28
662.80
dyed to
required shade
500.00
kg
262.69
131345.00
Description
BOQ(Finishing)
Quantity
Unit
Rate
Amount
0.00
22.00
Each
964.00
21208.00
3.18
0.00
3.00
Sqm
2081.04
0.00
6243.12
0.00
13.00
Set
1924.39
25017.07
20.00
Pair
1086.91
21738.20
0.00
3.20 (a)
(b)
324.00
pairs
438.74
142151.76
120.00
pairs
628.29
75394.80
0.00
3.21
Designing , providing and fixing structually glazed fully
unitised curtain wall in fixed panels using Aluminum
sections of approved make conforming to IS:733 and
IS:1285, anodised transparent ( Bronze shade as per
approved sample shade according IS:1868, minimum
anodic coating of grade Ac 20) , with mullions fixed to
existing beams /column , through adequately designed
galvanised iron brackets. Complete drainage syatem is
incorporated in the design which drains water at every
split tansom in the unlikely event the water penetrates the
pressure seal.The system includes sealing with
approved sealant and complete with specially designed
extruded EPDM gaskets etc. to prevent water
penentration as per standards , curved panels at ends
including fixing of glass etc. complete as shown in
drawings abd as per direction of Architect/En-in-charge
(Glass to be paid for separatly).
89.00
Sqm.
8435.00
750715.00
3.22
BOQ(Finishing)
Description
Quantity
Unit
Rate
Amount
0.00
119.00
Sqm.
2229.25
265280.75
Sl .No.
0.00
3.23
deleted
0.00
0.00
3.24
50.00
Sqm.
101.22
5061.00
0.00
3.25
15.00
Sqm.
148.22
2223.30
0.00
3.26
5.00
Each
239.80
1199.00
12090944.61
BOQ(Finishing)
Quantity
Unit
Rate
Amount
769.00
metre
313.30
240927.70
70.00
metre
361.50
25305.00
a)
Profile B
b)
Profile C
4.2
0.00
0.00
with frame and diagonal braces of 40 x 40 x 6 mm angle
iron, 3 mm MS gusset plates at the junction and corners
5.00
sqm.
2169.00
10845.00
0.00
0.00
a)
b)
103591.00
Kg.
55.43
5742049.13
0.00
33411.00
Kg.
49.41
1650837.51
0.00
4.4
638.00
sqm.
1208.45
770991.10
4.5
120
each
357
0.00
42780.00
0.00
4.6
638
sqm
538
343499.20
4.7
0.00
20
each
42000
840000.00
9,667,234.64
Description
SECTION V FLOORING
5.1
BOQ(Finishing)
Quantity
Unit
Rate
Amount
1783
Sqm
556.60
992417.80
0.00
5.2
5.3
0.00
1136
Sqm
650.00
0.00
738400.00
0.00
751
Sqm
750.00
563250.00
5.4
5.5
669
Metre
37.36
24993.84
0.00
(sample of marble shall be approved by Engineer-inCharge) over 20 mm (average) thick base of cement
0.00
mortar 1:4 (1 cement : 4 coarse sand) laid and jointed
with grey cement slurry including rubbing and polishing
complete with :
0.00
a)
5.6
300
Sqm
1205.00
361500.00
0.00
300
cement slurry (in joints of marble stone flooring or tiles)
Sqm
8.44
2532.00
Description
BOQ(Finishing)
Quantity
Unit
Rate
Amount
0.00
11600
Sqm
482.00
5591200.00
5.8
a)
5.9
593
Sqm
216.90
128621.70
0.00
a)
18 mm thick
5.10
0.00
104
Sqm
198.83
0.00
20678.32
0.00
2724
Sqm.
662.75
1805331.00
0.00
5.12
Black Granite
560
Sqm
1800.00
0.00
1008000.00
0.00
248
Sqm
5784.00
1434432.00
BOQ(Finishing)
Description
Quantity
Unit
Rate
Amount
0.00
1556
Sqm.
2169.00
3374964.00
0.00
5.14
5.15
5.16
SECTION VI FINISHING
6.1
a)
6.2
a)
6.3
a)
6.4(a)
10
Sqm.
2675.10
26751.00
10
sqm
1506.25
15062.50
9190
Sqm
429.00
3942510.00
20,030,644.16
10110.00
Sqm
84.35
852778.50
0.00
0.00
15167.00
Sqm
96.40
4748.00
Sqm
78.33
6262.00
Sqm
850.00
0.00
1462098.80
0.00
0.00
0.00
371910.84
0.00
5322700.00
1000.00
Sqm.
850.00
850000.00
0.00
6.6
Description
BOQ(Finishing)
Quantity
Unit
Rate
Amount
0.00
0.00
46000.00
Sqm
56.64
2605440.00
6.7
a)
6.8
a)
6.9
0.00
0.00
0.00
1665.00
Sqm
20.49
34115.85
0.00
0.00
4966.00
Sqm
42.18
20.00
Sqm
90.38
0.00
209465.88
0.00
0.00
0.00
1807.60
0.00
6.10
0.00
a)
10.00
Sqm
3396.90
0.00
33969.00
0.00
6.11
10.00
Each
22526.87
225268.70
0.00
6.12
RM
3003.58
150179.00
6.14
a)
50 mm dia pipe
100.00
RM
3003.58
b)
25 mm dia pipe
100.00
RM
1501.79
6.15
1000.00
sqm.
337.40
50.00
Sqm
10512.42
525621.00
0.00
0.00
0.00
300358.00
0.00
150179.00
0.00
337400.00
Description
BOQ(Finishing)
Quantity
Unit
Rate
Amount
0.00
6.16
100.00
sqm
1988.25
7.1
i)
198825.00
13632117.17
iii)
iv)
v)
a)
18809.00
Sqm
542.25
10199180.25
0.00
BOQ(Finishing)
Sl .No.
Description
7.2
Providing and laying brick tiles of class designation 100
Quantity
Unit
Rate
Amount
0.00
7.3
100.00
Sqm
222.93
0.00
22293.00
716.00
sqm.
1662.90
1190636.40
design
mm)manufactured
ceiling
out
of
tiles
0.50
(600mm
mm
coil
600
coated
micron
primer
coat.
Tiles
shall
have
suspension
system,
duly
cross
braced
in
258.00
Sqm
5256.21
1356102.18
0.00
7.5
work
in
0.00
a)
manufacturers.
15 mm cement plaster 1:4 (1 cement : 4 sand)
7.6
deleted
CARRIED OVER TO SUMMARY
150.00
Sqm
4.54
681.00
0.00
12768892.83
I)
II)
III)
a)
8.2
a)
BOQ(Finishing)
Quantity
Unit
Rate
Amount
843
Sqm.
700.00
590100.00
0.00
0.00
1093
Sqm.
750.00
0.00
819750.00
1,409,850.00
BOQ(Finishing)
Quantity
Unit
Rate
Amount
100.00
100.00
sqm
sqm
174.73
174.73
17473.00
17473.00
0.00
50.00
RM
845.91
42295.50
9.2
0.00
9.3
6282.00
Kg
291.61
1831894.02
0.00
9.4
285.00
Sqm
51.82
14768.70
100.00
sqm
390.42
39042.00
9.7
0.00
10.00
sqm
11061.90
110619.00
0.00
40.00
Metre
525.38
21015.20
0.00
9.8
9.9
Extra for providing and fixing 6mm thick fire rated clear
glass of 60 minutes fire rating for vision panel of make
promat / pilkington in wooden doors. The glass to be
fixed after using 10 x 2 mm thick intumeasent fire and
smoke seal glazing tape on both sides of glass with 20 x
20 milimetre 16 guage mild steel glazed beads complete
as per direction of Architect / Engineer-in-charge.
(onlyvision clear area excluding thickness of beading
shall be measured for payment purposes)
Silicon water repellant solvent coating on exterior suface
om GRC tiles
2000.00
SqCm
3.62
7240.00
6262.00
sqm
250.00
1565500.00
3667320.42
TOTAL SUMMARY
94,147,367.00
Description
4
5
1,189,837
1,088,072
10,861,137
792,945
24,076,473
961,211
8,097,600
1,020,124
TOTAL AMOUNT
1,040,166
49,127,566.00
DESCRIPTION
Quantity
UNIT
Each
29377
4196.68
0
23
Each
105274
4577.12
0
21
Each
116517
5548.44
0
24
Each
36604
1525.15
10
Each
25
Each
34324
3432.42
6
Providing and fixing C.P. brass long neck pillar cock with aerator
1144.70
28618
0
20
Each
76291
3814.55
0
Each
97276
16212.68
0
9
Providing and fixing C.P. brass wall mounted type shower mixer
with CP overhead pressure adjustable shower, shower arm and
15mm dia spout complete as required.
Each
15260
3051.98
0
10
Providing and fixing C.P. brass sink mixer with C.P. wall flange,
overhead swinging cast spout complete as required.
Each
2289.40
9158
0
11
Providing & fixing storage type water heater of approved shade with
copper container, glasswool insulation,stove enamelled M.S jacket,
thermostatically controlled inner heater with pilot neon lamps, 15mm
angle stop cock, on inlet connection, 15mm dia C.P flexible
connection pipe in inlet & outlet suitable for test pressure of 5
kg/sqcm complete as required.
a) Capacity 35 litres
b) Capacity 50 litres
3
3
Each
Each
15258.20
19072.75
0
45775
57218
0
DESCRIPTION
Providing and fixing solid state, no touch operating, fully hygienic
hand drier of approved shade with double blower, continous repeat
usage,time delay, summer & winter control 'including providing
necessary brackets, cable from drier to Plug, Plug to key and lock
etc. complete as required (Sleek model)
Quantity
UNIT
16
Each
320436
20027.23
13
27
Each
668.30
14
25
Each
1144.70
15
Each
1144.70
16
16
Each
382.13
17
30
Each
190.22
18
Each
2479.63
19
25
Each
286.18
20
Providing and fixing C.P. brass angle valve with filter for basin mixer
and gyser points of approved quality
a)
21
22
24
24.1
25
25.1
26
26.1
26.2
27
27.1
0
31
Each
45
Each
476.40
12878
0
15
Each
858.53
4
4
Each
Each
228.94
239.04
Providing and fixing white viterous china water closet squatting pan
(Indian Type)
Orissa pattern W.C. pan of size 580 x 440mm
Each
1491.48
17
Each
4
4
Each
Each
1198.57
20376
0
149.82
186.86
599
747
0
Providing and fixing Salem stainless steel A ISI 304 (18/8) kitchen
sink as per IS 13983 with C.I. brackets and stainless steel plug
40 mm including painting of fittings and brackets, cutting and
making good the walls wherev er required.
Kitchen sink with drain board
510 x 1040 bowl depth 178mm
0
1491
0
0
Providing and fixing C.P. cast brass trap for wash basins and sinks
32 mm dia
40 mm dia
0
12878
0
0
0
916
956
0
0
0
14768
0
286.18
Providing and fixing C.P. brass waste for sink or wash basin
a) 32 mm dia
b) 40 mm dia
0
18044
0
28618
0
2289
0
6114
0
5707
0
0
12398
0
7155
0
Each
4127.66
0
0
20638
0
DESCRIPTION
UNIT
Providing and fixing C.P. brass long body bib cock of approved
quality conforming to IS standards and weighing not less than 690
gms
a)
15 mm nominal bore
29
30
Quantity
15 mm nominal bore
Providing and fixing controled flush, low level cistern made of
vitereous china/uPVC with all fittings complete. 10 litres full flush
capacity
23
Each
314.79
0
7240
0
0
20
Each
Each
308.06
0
6161
7730
1932.53
0
31
Each
67.34
337
0
32
Providing and fixing C.P. brass close hole basin mixer pillar of
approved quality and make, weighing not less than 1.970 kg. 15
mm nominal bore of standard back type
Each
4559
1139.65
0
33
Providing and fixing 600 x 120 x 5 mm glass shelf with edges round
of supported on anodised aluminium angle frame with C.P. brass
brackets and guard rail complete fixed with 40 mm long screws, raw
plug etc. complete.
20
Each
5522
276.08
0
34
27
Each
19590
725.54
1189837
DESCRIPTION
Quantity
UNIT
121.86
39.46
166.01
30.34
26.31
62.36
20
10
4.75
metre
metre
metre
metre
metre
metre
metre
metre
metre
286.18
314.79
382.13
476.40
525.22
686.82
829.91
1048.75
1478.01
34874
12422
63437
14454
13819
42830
16598
10488
7021
0
48.5
10
21
42
20
40
20
5
4.75
metre
metre
metre
metre
metre
metre
metre
metre
metre
351.91
metre
8.42
10.10
11.78
11.78
13.47
13.47
15.15
18.52
23.57
0
408
101
247
495
269
539
303
93
112
0
23698
67.34
good the same using 1:1 cement mortar over wire mesh.
0
4
100
metre
47.13
Providing and fixing 6mm thick heatllon tapes insulation over two
coats of bitumen for hot water supply pipes and fittings (in chases)
for the following diameter of pipes
a) 15mm dia to 25mm dia
0
4713
0
0
50
metre
181.81
0
9091
0
DESCRIPTION
2
4
8
4
2
10
Each
Each
Each
Each
Each
Each
668.30
811.39
1087.47
1717.05
2097.50
3242.20
0
1337
3246
8700
6868
4195
32422
0
11
4
Each
Each
4307.78
4959.25
Providing & fixing C.I. wafer type check valve tested to a pressure
of 10 Kg/sqcm. Including rubber gasket, flanges, union, nuts, bolts,
washers & painting complete as required.
a) 50 mm dia
b) 65 mm dia
c) 80 mm dia
Providing & fixing butterfly valve (upto 150mm dia with hand lever
operation & above with gear box operation. Tested to a pressure of
10 Kg/Sq.cm. Including rubber gasket, flanges, nuts, bolts, washers
& painting complete as required.
a) 65 mm dia
b) 80 mm dia
UNIT
Providing & fixing brass ball valve with lever. Tested to a pressure
of 10 Kg / Sqcm. Including flanges/union, nuts, bolts, washer etc.
Complete as required.
a) 15 mm dia
b) 20 mm dia
c) 25 mm dia
d) 32 mm dia
e) 40 mm dia
f) 50 mm dia
Quantity
0
47386
19837
0
0
6
2
1
Each
Each
Each
3624.33
3814.55
4196.68
0
21746
7629
4197
0
10
11
a) 100 mm dia
Providing and fixing double flanged flexicon rubber expansion
joint with unit control as per manufacturers specifications of
standard length complete with all accessories tested to a
pressure of 10 Kg./sqcm. Including rubber gaskets, flanges, nuts,
bolts & washers complete as required.
a) 80 mm dia
Providing and fixing pressure reducing station for cold water supply
comprising of 3 nos Ball valves on inlet, outlet, and bye-pass,1 No
Gun metal pressure reducing valve with flanged connection, 1 No.
`Y' strainer, 2 Nos Pressure 'gauge on inlet & outlet, and 1 No.
15 mm dia safety valve. The complete system is tested to a
pressure of 10 Kg/Sq.cm and suitable to reduce the pressure upto
1.5 Kg/Sq.cm) Including flanges/ unions, nuts, bolts and washers
complete as required.
0
19073
Each
7629.10
0
7629
0
0
Each
8581.90
13
19072.75
Providing & fixing C.I. Pot Strainer (flanged type) with stainless steel
fine wire mesh perforated sheet basket with necessary flange/
unions nuts, bolts and washers complete as required.
a) 100 mm dia
12
Each
0
17164
0
0
4
4
4
Each
Each
Each
7629.10
8516.24
11443.65
0
30516
34065
45775
0
DESCRIPTION
a) 15 mm dia
b) 50 mm dia
c) 65 mm dia
14
UNIT
5
5
5
Each
Each
Each
9257.69
22405.85
28516.54
15
Quantity
40
metre
2861.75
Providing & fixing Auto Air vent for cold water supply risers with ball
valve, suitable for pressure of 10 Kg/Sq.cm.
a) 20 mm dia
TOTAL CARRIED TO SUMMARY
46288
112029
142583
0
0
114470
0
0
10
Each
10490.86
0
104909
1088072
DESCRIPTION
Quantity
UNIT
100
233.5
430.57
291.52
1375.18
857.04
769.37
848.98
1493.82
240.87
metre
metre
metre
metre
metre
metre
metre
metre
metre
metre
476.40
505.02
572.35
668.30
715.44
877.04
1020.13
1430.88
1851.72
2387.35
47640
117922
246437
194823
983859
751658
784857
1214789
2766136
575041
0
Providing & fixing brass ball valve with lever. Tested to a pressure
of 10 Kg / cm. Including flanges/union, nuts, bolts, washer etc.
Complete as required.
a) 15 mm dia
b) 20 mm dia
c) 25 mm dia
d) 32 mm dia
e) 40 mm dia
f) 50 mm dia
Providing and fixing of 20 mm dia brass RQRC lawn hydrant
including 20 mm dia brass key.
50
50
50
50
50
48.45
79.4
52
247
30
metre
metre
metre
metre
metre
metre
metre
metre
metre
metre
52.18
60.60
69.02
77.44
85.85
95.95
112.79
132.99
161.60
198.95
0
2609
3030
3451
3872
4293
4649
8956
6915
39915
5969
0
0
13
71
10
1
5
23
Each
Each
Each
Each
Each
Each
Each
673.35
1094.20
1515.05
1907.28
2289.40
3242.20
1430.88
8754
77688
15151
1907
11447
74571
0
8585
0
DESCRIPTION
UNIT
Quantity
181
2
Each
Each
14305.41
24794.58
0
2589279
49589
0
100
100
100
metre
metre
metre
476.40
572.35
909.03
0
47640
57235
90903
0
Each
Each
Each
3349.94
4196.68
4870.03
Providing & fixing C.I. sluice valve (with cap) complete with bolts,
nuts, rubber insertions etc. (the tail pieces if required will be paid
separately)
100 mm diametre
Class I
4
4
3
Each
3977.84
Providing and fixing brass ferrule with C.I. mouth cover including
boring and tapping the main
a) 15 mm nominal bore
b) 20 mm nominal bore
c) 25 mm nominal bore
TOTAL CARRIED OVER TO SUMMARY
0
13400
16787
14610
0
0
15911
0
0
0
1
1
1
Each
Each
Each
205.32
283.13
371.94
0
205
283
372
10861137
DESCRIPTION
Quantity
UNIT
SECTION 4 : INTERNAL DRAINAGE (SOIL, WASTE, VENT AND RAIN WATER PIPES)
1
Providing, fixing, jointing and testing in position the spun
cast iron pipe for soil, waste and vent installation conforming to
I.S. : 3989 cut to required lengths including all necessary
fittings and specials such as Bends, junctions, offsets, access
pieces (plain or door) & vent cowl. Fixing at wall/ceiling level
supported by clamps
& hangers etc.
Making
proper
connection with refined pig lead joint of required depth including
cutting, chases/holes in floors /walls/ slab etc and making good the
same after pipe have been duly laid and testing complete.
b) 100 mm dia
c) 150 mm dia
2
954.48
1334.92
47724
66746
0
50
50
metre
metre
1144.70
1525.15
Providing and laying 1:2:4 cement conc. 100 mm thick all round
the pipe including 100mm thick bed concrete for the following C.I.
pipes and specials below floor including necessary shuttering and
timbering etc. complete as required.
a) 100 mm dia
b) 150 mm dia
metre
metre
Same as item no. 1 but pipes are running below ground in trenches
(for internal areas upto manhole) upto required depth including
excavation in all kind of soil including hard rock, refilling, watering,
ramming, removing & disposal of the surplus excavated material as
per instructions by site incharge and making good the same.
b) 100 mm dia
c) 150 mm dia
3
50
50
0
57235
76258
0
0
50
50
metre
metre
572.35
668.30
Providing & fixing in position CI "P", S" trap with cockroach trap and
CI extension piece of required length depth of following size for
the embedded areas. Making proper connection with refined pig
lead joints, cutting chase / hole in floors /slabs and bringing the
same in proper condition and shape after placing the trap in right
position complete as required.
0
28618
33415
0
25
Each
Providing and fixing G.I. inlet hopper with two or three inlets fittings
to receive waste pipes from fixtures waste. The hopper shall be
fabricated from 100 mm dia G.I. heavy class pipe and welded G.I.
sockets, fixed to C.I. trap with lead joint and set in cement concrete
mix 1:2:4 complete as required.
25
Each
858.53
0
21463
0
19064
762.57
0
Providing & fixing 100mm x 50mm G.I. waste with G.I. reducer &
nipple including cutting chases, the floor / slab complete as
required.
10
Each
11447
1144.70
0
Providing and fixing heavy class C.P. brass mosquito proof grating
with frame of approved design including setting in floor with cement
mortor to match with floor finish.
a) Size 150mm x 150mm
20
Each
190.22
0
3804
0
30
metre
476.40
14292
DESCRIPTION
Quantity
UNIT
b) 40 mm dia
c) 50 mm dia
20
20
metre
metre
100
metre
10504
13736
0
10437
104.37
0
10
11
70
metre
20
Each
67.34
0
4714
0
6868
343.41
0
12
Providing & fixing M.S. welded rain water head with puddle flange to
fix head in R.C.C. slab specially fabricated from minimum 4mm thick
M.S. sheet. Including removable heavy duty M.S. grating of 50 x
3 mm thick M.S. flats (Round or Square) as per approved
design. Painting with two coats of epoxy paint over a coat of primer
complete as required. The entire fittings shall be hot dipped
galvanised.
0
a) 200 mm dia bell mouth grating suitable
take
20
Each
20
Each
1811.32
36226
0
2479.63
49593
0
13
Providing & fixing CI rain water head of required length with puddle
flange to fix head in R.C.C. slab. Including removable heavy duty
dome type CI grating and CI Jaali with ring of approved design.
a) 200 mm dia bell mouth grating suitable for 100 mm dia down
take
20
Each
20
Each
1811.32
36226
0
2479.63
49593
0
14
92
Each
175470
1907.28
0
15
Providing & fixing cast brassclean out plug with suitable insert keys
for opening in brass cap, male threaded joint with G.I. socket
caucked to pipe/fitting of SCI/ CI(LA) pipe as required complete in
all respects
100 mm dia
TOTAL CARRIED TO SUMMARY
0
25
Each
780.48
19512
792945
DESCRIPTION
Quantity
UNIT
1927.33
metre
161.60
311457
0
Extra for excavating treanches for pipes, cables, etc. in all kinds of
soil for depth exceeding 1.5m, but not exceeding 3 m. (Rate is over
500
metre
105210
210.42
coresponding basic item for depth upto 1.5 metre).(all kinds of soil)
0
3
Extra for excavating treanches for pipes, cables, etc. in all kinds of
soil for depth exceeding 3 m, but not exceeding 4.5 m. (Rate is over
coresponding basic item for depth upto 1.5 metre).
500
metre
269340
538.68
0
Providing and laying jointing glazed stoneware pipes grade 'A' with
stiff mixture of cement mortar in the proportion of 1:1 ( 1 cement : 1
fine sand) including testing of joints etc. complete.
a) 100 mm dia meter
b) 150 mm dia meter
50
50
metre
metre
131.30
188.54
0
6565
9427
0
599.5
200
metre
metre
732.27
915.76
0
438996
183152
0
0
39.04
599.5
200
metre
metre
metre
382.59
461.25
538.68
14936
276519
107736
0
2828.88
4787.89
2292.47
1513.02
1426.1
167.19
metre
metre
metre
metre
metre
metre
646.42
808.02
883.78
949.43
1346.71
1767.55
1828645
3868711
2026039
1436507
1920543
295517
0
DESCRIPTION
Quantity
UNIT
0
1202.1
3325.67
2324.45
1513.02
1426.1
167.19
metre
metre
metre
metre
metre
metre
462.93
539.45
621.70
782.39
860.82
956.47
556488
1794033
1445111
1183772
1227615
159912
0
0
a) Inside size 90 x 80 cm and 60 cm deep
dia SFRC heavy duty cover with frame
including 560mm
90
Each
8061.73
725556
0
57
Each
2686.68
153141
0
24
Each
9622.23
230934
0
24
Each
6068.60
145646
0
10
0
a) 140cmdeep with SFRC coverand frame (heavy duty 56cm
internal diameter cover with frame fixed in cement concrete 1:2:4
(1 cement : 2 coarse sand : 4 graded stone aggregate 20mm
85
Each
1400113
16471.92
0
10.1
Extra depth for circular type manhole 122cm internal dia (at bottom)
with FPS bricks
a) Beyond 140cm to 200cm
0
65
Each
9536.38
0
619865
0
12
DESCRIPTION
Providing and fixing in position the following C.I. / LA drop
connection including providing necessary bend, Tee, plugs etc.
Excavation, refilling, watering, ramming and removing the
excavated surplus material. Including providing 150mm thick
concrete 1:2:4 (1 cement, 2 coarse sand, 4 graded stone
aggregate, 20mm nominal size) in casing all round the pipes
pipes including shuttering and timbering complete as required.
b) 150 mm dia
Constructing grease trap of size 2000 x 1000 mm internal size of
required depth in brick work of class designation 75 with cement
mortar. Inside plastering 12 mm thick with cement mortar 1 : 3 and
rough plaster on outside with floating coat of neat cement detail as
per drawing) 1 : 5 ( one cement 5 fine sand). Including aluminium
bucket as per detail to collect the grease. R.C.C. top slab with
covers, necessary foundation concrete (1:4:8). And necessary
excavation in all kind of soil (including hard rock), dewarting,
refilling, watering, remming, removing & disposal of the surplus
excavated material as per instructions by site incharge and making
good the same complete as required.
Quantity
UNIT
Each
Each
3624.33
7249
0
22860
22860.37
0
13
14
16
Each
14682.75
Providing and fixing square-mouth CI/ S.W. gully trap `A' complete
with C.I. Grating brick masonry chamber with bricks of class
designation 75 and water tight CI cover with frame of 300 x 300 mm
size (inside) the weight of cover to be not less than 4.50 Kg and
frame to be not less than 2.70 Kgs as per standard design. Including
excavation making good the same and removing the surplus
excavated material
180 x 150 mm size P type
With F.P.S. bricks
15
0
0
14683
0
10
Each
1055.48
0
10555
0
0
201
Each
133
Each
2685.00
2129.48
0
539685
0
283221
0
17
DESCRIPTION
Quantity
UNIT
10
Each
61915
6191.49
0
18
10
Each
226954
22695.40
0
19
20
20.1
21
Extra depth of circuar type manhole 0.91 m internal dia (at bottom)
with Beyond 0.91 m to 1.67 m
With F.P.S.Bricks class designation 75
Extra depth of circuar type manhole 1.52 m internal dia (at bottom)
with FPS bricks
Beyond 2.30 m
0
10
Each
3026.73
30267
0
0
10
Each
200
Each
9315.85
93159
0
0
44442
222.21
0
24076473
DESCRIPTION
Quantity
UNIT
Providing and fixing 25mm thick C.I. heavy duty grating including
C.I. / MS angle iron frame fixed with hold fast at 900mm c/c in
flooring for the following sizes:
300 mm wide x 600 mm long
30
Each
841.69
25251
0
Providing & fixing M.S. pipe sleeves 1 mtr long of heavy class
with
cutting the M.S. plates, steel bars & welding MS pipe sleeve to
MS plate from
both
15
4
2
Each
Each
Each
1010.03
1515.05
2188.40
0
15150
6060
4377
0
a) 65 mm dia
b) 100 mm dia
c) 150 mm dia
5
5
5
Each
Each
Each
Each
673.35
831.59
1469.60
0
3367
4158
7348
0
60602
15150.47
0
Providing and fixing in position G.I. vent with brass mosquito proof
coupling and air filter including return bend, complete as required.
a) 100 mm dia
Each
Set
1683.39
0
8417
0
306070
306069.69
0
0
0
0
0
DESCRIPTION
Quantity
UNIT
Set
344328
344327.98
0
0
0
0
0
0
10
11
12
13
0
1
Each
Providing and fixing C.I. Heavy duty rungs in R.C.C. wall of water
tanks etc. Including cutting, chasing the R.C.C. work and making
good the same complete as required.
50
Each
250
Providing & fixing pressure switch for water pumps to start/stop the
pump at set pressure. Including wiring, cabling from pump to panel
& all other accessories as required to operate the system
automatically.
42084.63
42085
0
25251
505.02
Kg
20370
81.48
set
42926
14308.77
set
25251
8416.93
Each
20200.62
0
0
20201
961211
DESCRIPTION
Quantity
UNIT
Lot
2711250.00
2711250
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
Lot
2289500.00
2289500
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
Lot
2952250.00
2952250
0
0
0
0
0
0
DESCRIPTION
Quantity
UNIT
0
0
4
SET
144600.00
144600.00
0
0
0
0
8097600
DESCRIPTION
Quantity
UNIT
Job
Transportation to and from for drilling rig, pipes, flanges and all
other materials at site including erection & dismantling &
demolization of drilling equipment, after completion of work
including levelling, dressing,for erecting the equipment.
4208
4208.46
0
Drilling with Reverse /Direct circulation rig in all kind of strata except
hard strata ie stone/ sand stone/boulders with 400/ 350 MM dia
bore size.
0 - 30 meters
30 - 60 meters
60 - 90 meters
90 - 120 meters
120
60
40
20
metre
metre
metre
metre
841.69
925.86
1010.03
1178.37
Supplying and lowering Blind Class `C' MS pipe with welded ends
including painting with two coats of anticorrosive paint complete as
required.
a) 200 mm dia
b) 150 mm dia
0
0
101003
55552
40401
23567
0
0
50
50
metre
metre
1454.44
1148.07
Supplying and lowering slotted Class 'C' MS pipe with welded ends.
including painting with two coats of anticorrosive paints complete as
required.
0
72722
57404
0
0
a) 200 mm dia
b) 150 mm dia
20
20
metre
metre
Item
1851.72
1515.05
0
37034
30301
0
15302
7650.98
0
Item
11481
2296.14
7
3
5
62
10
Each
Each
Each
Cu.M
Each
Lot
1010.03
841.69
1683.39
1683.39
1683.39
10100.31
0
0
0
7070
2525
8417
104370
16834
0
50502
0
Testing and overpumping (25% of tube well for 16hr to record draw
0
down recovering (yield test) including flushing of both borewells.
a. By compressed air method/pump
10
Lot
Lot
3060.39
0
15302
0
30301
paying all charges and fees, testing etc. completed in all respects as
per direction (As per IS 10500 all parameters
10100.31
0
DESCRIPTION
Quantity
UNIT
Each
Providing sanitary sealing on top as per I.S. with 1:3:6 PCC Block of
size 1m x 1m x 1m
6734
3366.77
0
0
2
Each
3366.77
6734
0
13
Set
22953
7650.98
0
0
14
84169
Set
42084.63
0
0
0
0
Supply & Installation of G.I. Class `C' column pipe with flanges at
0
3m intervals including all fittings, flanges, clamps as required.
a) 65 mm dia
16
17
18
Supplying, fitting and fixing electric water level guard with 2 pole
electrodes.
120
metre
Each
535.32
5356.53
Each
228.94
Each
3826.33
Each
3826.33
Each
1010.03
Incoming
a) 63A TP MCCB - 1 No.
0
64238
0
10713
0
0
0
458
0
0
7653
0
0
7653
0
2020
0
0
0
0
0
0
DESCRIPTION
Quantity
UNIT
0
0
0
0
0
0
0
0
0
0
0
0
0
c) 1 No 96 mm Ammeter of suitable
range with CT's and Ammeter Selector
switch & control MCBs.
Bus Bars
a) 100A TPN Aluminium bus bar
Outgoing
2 Nos. 40 A TP MCB with DOL starter switch for 15 HP motor. Each
compartment shall contain CT operated ammeter with selector
switch / manual selector switch with indicating lamp, ON/OFF status
of motor, level button and level cut off.
i)
19
Set
500
metre
22954.64
0
45909
0
76595
153.19
1020124
DESCRIPTION
Quantity
UNIT
Set
2.1
88212.03
Set
168338.50
2.2
Set
168338.50
2.3
Set
227256.98
3.1
Control Panel for water supply and drainage pumps in pump room
:-
168339
0
0
0
0
168339
0
0
0
0
227257
0
0
0
0
Set
Set
50922.40
88212
0
0
0
0
193589.28
0
101845
0
0
0
0
0
193589
0
DESCRIPTION
Quantity
Design,
manufacture,
supply,
installation,
testing
and
commissioning of the following integrated, cubicle type, dead
front, extensible, sheet steel control panel anchoring the panel to
the foundation. The panel shall be duly powder coated and suitable
for 500 volts, 50 cycles, 4 wire supply. Quoted price shall include
1100 volts grade rubber mats over 50mm thick teak wood platform,
wiring and tinned copper earthing from control panel to various
equipment like motor starters, pump motor, etc. The panel shall
have separate compartments for bus bar and cable alleys. The
following components and accessories shall be mounted within
each control panel.
UNIT
0
a.
1 No. 100 amps 4 pole manual operated on load change over switch
with 1 Nos. 100 amps TPN incoming 25kA MCCB complete with
overcurrent, short circuit release and the following:
i. 0-500 volts 96 x 96mm square digital electronic voltmeter with
selector switch through 415V / 3 : 110V/ 3 PT primary and centre
tapped and earthed secondary with 2 amps protection TP MCB 1
Set
0
0
1 Set
0
0
0
b.
c.
Aluminium bus bar PVC sleeved, rated at 100 amps for three
phase & neutral phase bus bar shall have maximum current
density of 1 amps per sq.mm. and the neutral bus bar of not less
than 50% capacity.
Outgoing:
0
0
0
0
0
0
0
0
0
0
DESCRIPTION
a)
One No. 100 amps TP incoming MCCB complete with the following:
Quantity
UNIT
0
0
0
ii. 0-50 amps 96x96 sqare mm ammeter with 50/5 amps ratio CT's
and selector switch.
1 SET
0
0
0
0
0
0
0
0
0
0
Copper bus bar sleeves type, rated at 200 amps for three phase &
neutral. Phase bus base shall have maximum current depsity of 1
amps per sq.cm. and the neutral bus bar of not less than 50%
capacity.
c)
0
0
0
i.
32A TP MCCB with DOL starter suitable for 5 HP motor for sump
pump
2 SETS
ii.
Spares TP MCCB's
a. 32 Amps - 1 No
Automatic fire protection by powdered Aerosol C
2 Nos. as required "Dynameco 300-EO2"
2 Nos. smoke detectors
1 No. alarm panel
Control Panel as described above.
a.
Notes:
All switch gear / panels shall be suitable for 20 KA rating.
b.
c.
All starter will have spare 10 amps 230 V coil auxilliary contactor for
Building Automation System
d.
All starter units for pumps to be provided with 3 level liquid level
contactor.
e.
f.
Set
92586.18
0
0
0
0
0
0
0
0
0
0
0
92586
0
0
0
0
0
0
0
0
0
0
0
0
0
DESCRIPTION
Quantity
UNIT
g.
h.
0
0
0
0
0
0
0
0
0
10157890
1040166
BOQ(OHT)
ITEM
Quantity
Unit
Rate
Cum
3230.00
Amount
22610
0
1.2
1.2.1
1.2.2
0
120
269
Cum
Cum
3743.10
449172
4201.00
1130069
0
1.3
deleted
0
0
1.4
1.4.1
45
1.4.2
level
109
Part 2 : FORMWORK
2.1
Centring and shuttering including strutting , propping
etc. and removal of form for
2.1.1
Foundations, footings, bases of columns etc. for mass
concrete.
2.1.2
Walls (any thickness) including attached pilasters,
2.1.4
2.1.5
2.1.6
2.1.3
0
Cum
25377
1127.88
122939
0
0
0
sqm
91
106.76
9715
185.91
49452
153.67
51479
237.28
97285
185.91
661.42
19335
66142
sqm
266
sqm
335
sqm
410
Page 26
563.94
Cum
104
100
sqm
sqm
BOQ(OHT)
ITEM
Quantity
Suspended floors, roofs, landings, balconies and access
platform.
Extra for additional height in centring, shuttering
Unit
sqm
96
Rate
194.29
Amount
18652
2.3.1
0
362
Sq.m
469.95
170122
1313.45
660665
1452.03
862506
0
210.88
73808
0
0
0
Sq.m
503
Sq.m
594
Sq.m
350
Part 3 : REINFORCEMENT
3.1
4
4.1
4.2
51
MT
46250.00
2358750
0
0
6
Sqm
241.00
1446
0
40.36
42580
Cum
1055
0
0
4.3
5
5.1
6
6.1
Page 27
sqm
212
135.68
Cum
2583.13
28764
0
0
0
20665
0
3860
Kg
78.33
302354
0
Part 7:
1
BOQ(OHT)
ITEM
Quantity
Providing and fixing hand rail by welding etc. to steel
ladder railing, balcony railing & staircase railing
including applying a priming coat of approved steel
primer
1200
G.I. pipes 40 mm nominal bore (class B)
CARRIED OVER TO SUMMARY
Unit
Rate
Amount
Kg
72.30
86760
0
0
0
0
PLUMBING
Providing & applying injection grouting in RCC wall @ 1
m c/c with 12 mm dia holes & injecting cement & flow
cable 50 of MBT in required proporation at construction
joint
160
Rmt.
301.25
48200
0
135
Sqm.
243.41
32860
0
36
72
72
metre
metre
metre
740.87
1626.00
2476.98
5
5
10
Each
Each
Each
301.77
1192.65
3295.58
2
5
10
Each
Each
Each
382.61
1533.47
3797.05
GI Threded Coupling
a) 50 mm dia
b)100 mm dia
c)150 mm dia
10
5
5
Each
Each
Each
185.68
681.50
1447.30
Hexagonal Nipple
a) 50 mm dia
b)100 mm dia
c)150 mm dia
6
5
5
Each
Each
Each
235.25
731.53
2039.58
Each
688.93
5
10
10
Each
Each
Each
490.05
1086.67
2225.25
10
Nos.
20006.10
11
50
metre
122.87
0
26671
117072
178343
0
0
1509
5963
32956
0
0
765
7667
37971
0
0
1857
3408
7237
0
0
1412
3658
10198
0
0
4134
0
0
2450
10867
22253
0
0
40012
0
6144
TOTAL SUMMARY
Page 28
BOQ(PD Works)
CONTRACT : JP/EW/C-4
BILL OF QUANTITIES OF PROPERTY DEVELOPMENT WORKS ,FOR
BASEMENT ,PARKING & DECK WORK OVER STABLING LINE
BILL OF QUANTITIES - PROPERTY DEVELOPEMENT WORKS (All amounts in INR)
Sl .No.
Description
Quantity
Unit
23585
Cum
96.23
Cum
84.35
Cum
361.50
Rate
1.1
2.1.1
2.2
141145
29
3150
BOQ(PD Works)
Description
Rates of all cement concrete items (Plain &
Quantity
Unit
4327
Cum
3230.00
23512
Cum
4040.00
8240
Cum
5400.00
27096
Cum
5400.00
230
Cum
5500.00
Rate
3.1.1
3.2
3.2.1
3.2.2
3.2.2
3.2.3
30
BOQ(PD Works)
Sl .No.
Description
3.2.4 Vacuum dewatered concrete for grade slabs
using Polypropylene fibers at 1.0 kg of fibers per
cum of Concrete, including machine trovelling for
smooth finish.
Quantity
Unit
2142
Cum
5000.00
50
Cum
271.13
7466
MT
46250.00
569
4715.17
601
1929.21
267
5108.00
a)
19046
Sqm.
602.50
b)
6921
Sqm.
602.50
3.2.5
Rate
6.1
6.2
6.3
6.4
31
BOQ(PD Works)
Description
Quantity
32
Unit
Rate
BOQ(PD Works)
Amount
2269584.55
2269584.55
11905580.75
1138725.00
13044305.75
33
BOQ(PD Works)
Amount
13976210
94988480.00
44496000.00
146318400.00
1265000.00
34
BOQ(PD Works)
Amount
10710000.00
13556.50
311767646.50
345302500.00
345302500.00
2682931.73
1159455.21
0.00
1363836.00
0.00
0.00
11475215.00
4169902.50
35
BOQ(PD Works)
Amount
0.00
0.00
20851340.44
683651822.00
36
Item
Any other DSR 2007
item
Qty
Unit
Rate
L.S
5000000
5000000
Total
5000000
1.1
2.1
2.2
Description of Items
Earthwork in excavation in all kinds of soil, over all areas,
stacking the excavated material at site and backfilling with the
excavated soil, for all the locations like sides of retaining
walls,foundations, trenches, rafts etc. Backfilling with the
excavated soil shall be done in layers not exceeding 200 mm in
thickness and compacting each layer as per specifications, for
all leads and lifts. Rate to include, but not be limited to- extra
excavations required for supporting side shuttering of
foundations/walls etc and that required for making the side
slopes stable, dewatering as required all inclusive to complete
the work as per specifications; for works in
Unit
Qty.
Unit Rate
Amount
cum
2000
96.4
192800.00
0.00
0.00
0.00
Cum
850.00
4040.00
3434000.00
Cum
190.00
5400.00
1026000.00
Cum
350.00
3230.00
1130500.00
7
8
Cum
850.00
4500.00
3825000.00
Cum
480.00
2831.75
1359240.00
0.00
MT
SQ.M
250.00
4700.00
46250
84.35
11562500.00
396445.00
SQ.M
1500.00
30.80
46200.00
10
11
24000
61.95
1486800.00
2100
13.65
28665.00
310
1482.6
459606.00
24754956.00