Anda di halaman 1dari 2

PDPM

INDIAN INSTITUTE OF INFORMATION TECHNOLOGY, DESIGN & MANUFACTURING


JABALPUR (M.P.)

Assignment # 1

EC 311b - Power Electronics


Last Date of Submission: 02/02/2015

Q.1

A diode is connected in series with LC circuit as shown in figure. If switch is turned on at t=0,
derive expression for current i and voltage across capacitor c. Initial capacitor voltage at t=0 is
-co. Sketch waveforms for i, c and D (voltage across diode).

Vs

+
-

Switch

Q.2

If the circuit has Vs=230V, co=50V, L=0.2 mH


c

and C=10F, determine the diode conduction

time and final steady state voltage across the


capacitor.

The reverse recovery time of a diode is trr = 3 sec and the rate of fall of the diode current is
di/dt = 30 A/sec. Determine (a) the storage charge QRR and (b) the peak reverse current IRR.

Q.3

The storage time ts of a diode is 5S and di/dt=40A/S. If storage charge QRR is 1.5 mC, find
out IRR and softness factor.

Q.4

The characteristics of three series connected diodes each rated for 3000V are shown in figure.
If 4mA reverse current is flowing in the circuit, calculate string efficiency. What values of
equalizing resistances are to be connected to improve the string efficiency to 100%?
-4000

-3500

D1
D2
D3

Q.5

-3000

-2500

-2000

-1500

-1000

-500

0
0
-2
-4
-6
-8
-10
-12
-14
-16
-18
-20

A diode whose internal resistance is 20 is to supply power to a 1000 load from 230V (rms)
source of supply. Calculate (a) the peak load current (b) the dc load current (c) the dc diode
voltage (d) the percentage regulation from no load to given load.

VIIIth Semester ECE, Year-2015


F:\My Academics\...\EC311b_Power Electronics\Assignment\Assignment#1.doc

PDPM

INDIAN INSTITUTE OF INFORMATION TECHNOLOGY, DESIGN & MANUFACTURING


JABALPUR (M.P.)

Q.6

A single-phase full bridge diode rectifier is supplied from 230V, 50Hz source. The load
consists of R=10 and a large inductance so as to render the load current constant. Determine:
(a) average values of output voltage and output current,
(b) average and rms values of diode currents,
(c) rms values of output and input currents and supply power factor.

Q.7

A battery is charged by a 1-phase half wave uncontrolled rectifier. The supply is 30V, 50 Hz
and the battery emf is constant at 6V. Find the resistance to be inserted in series with the
battery to limit the charging current to 4 Amp. Consider voltage drop across diode as 1V. Find
PIV and draw waveform of voltage across diode.

Q.8

A three-phase bridge rectifier needs to supply 16KW power to a 10 resistive load. Determine
voltage and current ratings of the diodes and transformer. Also find out Form Factor and peak
load current.

Q.9

Draw and describe output voltage waveform and voltage across any one diode of three phase
bridge rectifier circuit and indicate the diode conduction period. Derive expression for DC
output voltage and find out ripple contents (Ripple Factor) in the output voltage.

Q.10

A three-phase bridge rectifier charges a 240V battery. Input voltage to rectifier is 3-, 230V,
50Hz. Current limiting resistance in series with battery is 8 and an inductor makes the load
current almost ripple free. Determine: (a) power delivered to battery and the load (b) input
displacement factor (c) input power factor (d) input THD and (e) Transformer Rating.

VIIIth Semester ECE, Year-2015


F:\My Academics\...\EC311b_Power Electronics\Assignment\Assignment#1.doc

Anda mungkin juga menyukai