constructive solutions
Chemical resistance
Cicol ET Screed provides an extremely hard wearing antiskid surface to a variety of substrates including concrete
and timber, ideally suited for car parks, walkways, wet
work industrial areas etc.
Advantages
Application instructions
Hard wearing.
Surface preparation
corrosion
protection
to
Description
Cicol ET Screed is a four component system based upon
solvent free, coal tar modified epoxy resins, amine curing
agents, chemically inert, graded silica fillers and a
specially selected silica aggregate of high crushing
strength. The components of Cicol ET Screed are
supplied in pre-weighed quantities ready to use on site.
Asphalt substrates
Cicol ET Screed can be applied onto asphalt substrates
provided they are clean, sound and dry. It is also
recommended that asphalt should be at least 12 months
old. The asphalt should be lightly grit blasted and/or
thoroughly degreased to remove any weakly bonded or
contaminated material to provide the desired surface. No
primer is required on asphalt.
Technical support
Fosroc offers a comprehensive range of high
performance, high quality flooring, jointing and repair
products for both new and existing floor surfaces. In
addition, the company offers a technical support package
to specifiers, end-users and contractors.
Wooden substrates
Cicol ET Screed can be applied directly on to clean, dry
timber substrates.
Design criteria
Mixing
Properties
Pot life at 25oC:
at 35oC:
Specific gravity:
Curing time at 25oC:
at 35oC:
40 minutes
25 minutes
2.0 approximately
24 hours for foot traffic
48 hours for vehicular traffic
16 hours for foot traffic
36 hours for vehicular traffic
Page 1
Cicol ET Screed
Laying
Coverage
Cicol ET Screed:
Nitoprime Primer 30/31:
Storage
Precautions
at
mm
Joints
Expansion joints in the existing substrate must be
maintained through the Cicol ET Screed.
Cleaning
All tools can be cleaned immediately after use with Fosroc
Solvent 102.
Limitations
Application temperature range:
Substrate temperature:
3.1 m2/pack
thickness
2
5 m /kg
o
o
5 C to 40 C
o
3C
above
dewpoint
Fire
Fosroc Solvent 102 is flammable.
Ensure adequate
ventilation. Do not use near a naked flame and do not
smoke during use.
Estimating
Supply
Cicol ET Screed is supplied in packs containing preweighed components:
Binder:
Filler:
Aggregate:
Total:
Nitoprime primer:
4.5 kg
10.50 kg
16.00 kg
31.00 kg
1 and 5 kg packs
Important note:
Fosroc products are guaranteed against defective materials and manufacture and are sold subject to its standard Conditions
for the Supply of Goods and Services, copies of which may be obtained on request. Whilst Fosroc endeavours to ensure that
any advice, recommendation, specification of information it may give is accurate and correct, it cannot, because it has no direct
or continuous control over where or how its products are applied, accept any liability either directly or indirectly arising from the
use of its products, whether or not in accordance with any advice, specification, recommendation of information given by it.
www.fosroc.com
email: fosam@fosroc.com
Regional Offices
Jeddah Sales Office
Jeddah Showroom
Riyadh
Dammam
Khamis Mushayt
Registered Office: Industrial Area, Phase 4, Road No. 414, Street No. 407
Page 2
FO SA/Cicol ET Screed/05/A