2.4kN.
Fig 1
QNo2: The curve member shown as shown in fig2.has solid circular cross
section 0.10 m in diameter .If the maximum tensile and compressive
stresses in the member are not to exceed 150MPa and 200MPa
respectively ,determine the value of load P that can safely
to carried by the member.
fig2
fig 3
QNo 4: fig 4 shows a ring carrying a load of 30kN.Calculate the stresses at 1 and 2
fig 4
QNo5:Fig5. shows a crane hook lifting a load of 150 kN. Determine the maximum
compressive stress and tensile stress in the critical section of the crane hook.
Fig 5
QNo7: A ring is made of round steel bar 30cm diameter and mean radius of the ring is
180mm.calculate the maximum tensile and
compressive stresses in the material of the ring if it is
subjected to pull of 12kN.
fig 7
fig8
QNo9: A chain link as shown in fig is made of
round steel rod of 15mm diameter. If
R=45mm,l=75mm and load applied is 1.5kN
determine the maximum compressive stress in
the link and tensile stress in same section.
Fig 9
QNo10: A steel bar 60mm diameter is to be bent to the shape as shown in fig and lower
end is firmly fixed in the ground in a vertical position. A load of 800N is applied at the free end
calculate the vertical deflection of the end, E=200GPa.
fig 10
QNo11: A steel bar 75mm radius is to be bent to the shape as shown in fig and lower
end is firmly fixed in the ground. A load of 5N is applied at the free end .
If the section of the is 12mm wide and 3mm thick, calculate the vertical and horizontal
deflection of the end, E=200GPa
QNo12: A ring with a circular cross-section of 60mm in diameter and mean radius of 90mm is
subjected to a compressive load of 15kN.calculate the deflection of the ring along the load line
and perpendicular to load line.Take E=200GPa
7. A steel bar 38 mm in diameter is bent into a curve of mean radius 31.7 mm. If a
bending moment of 4.6 Nm tending to increase the curvature, acts on the bar find the
intensities of maximum tensile and compressive stresses.
8. A ring with a circular cross-section of 60 mm in diameter and a mean radius of 90
mm is subjected to a compressive load of 15 kN. Calculate the deflection of the ring
along the along line. Take E = 200 GN/m 2 A curved bar of rectangular section 60 mm
(width) x 40 mm (thickness), is bent in the shape of a horse shoe having a mean radius
of 70 mm. Two equal and opposite forces of 10 kN each