Author:
Date:
Landy Liu
06 January 2010
Copyright 2005 AIRCOM International - All rights reserved. No part of this work, which is protected by copyright, may be reproduced in
any form or by any means - graphic, electronic or mechanical, including photocopying, recording, taping or storage in an information
retrieval system without the written permission of the copyright owner.
AIRCOM International
Contents
1
2
3
4
5
Page 2 of 22
AIRCOM International
Document Control
1.1 Revision History
Revision
Number
Date
Name
Revision
1.2 Reviewers
Reviewer
Date
Feedback
Page 3 of 22
AIRCOM International
Install ORACLE9i
Choose Install/Deinstall
Page 4 of 22
AIRCOM International
Page 5 of 22
AIRCOM International
Pls fold all the lists under the Oracle9i Database 9.2.0.1.0just choose NO.1235 to
install the others no need to install.
Page 6 of 22
AIRCOM International
Page 7 of 22
AIRCOM International
Wait for the configuration finishing, Oracle9.2.0.1 has installed. But we need to install
the oracle patch, upgrade the edition to 9.2.0.6, or higher edition.
Page 8 of 22
AIRCOM International
Page 9 of 22
AIRCOM International
Page 10 of 22
AIRCOM International
About this page, it automatic show Home1, we need to change the installation path of patch
softwareand change the Name textbox of OraHome92it showed like the picture as
above. If we dont change the two, the patch cant be installed correct.
Page 11 of 22
AIRCOM International
Set up database
Page 12 of 22
AIRCOM International
Page 13 of 22
AIRCOM International
Point finish is OK. It will be take a long time to set up database , Pls wait~~~
In process of setting up database ,it will be show the error of ORA-29807: specified
operator does not exist, Pls Ignore it.
The last step , we need to input the password of SYS and SYSTEM, the password can be
setup as you like, but you must remember it ,it will be used in database configuration.
So, we finish the database set up .
Install ENTERPRISE
Page 14 of 22
AIRCOM International
In the process of install, the software will clue on Large Array Settings as follow:
Page 15 of 22
AIRCOM International
We need to set up the swap folderand the maximum memorythe most percent .
Maximum memory allowedit based on the physic memory of users computer, cant be
bigger than 50%. Such as, if the physic memory is 1Gyou must set the maximum memory
less than 500Mb(half of 1G),if not ,it will be show you the warning:
Database configuration
Page 16 of 22
AIRCOM International
Point Setup
Page 17 of 22
AIRCOM International
Write down Data Source Nameand choose the database SID that we have seted up in
TNS Service Name textbox, and then OK:
Page 18 of 22
AIRCOM International
Choose the correct Data Source Name in Data Source list input user name (system)and
the password (you have seted up before)
Page 19 of 22
AIRCOM International
We need to set up a administrator account, pls set up the name and password:
Page 20 of 22
AIRCOM International
Point finish, the system will start the configuration, pls waiting
Page 21 of 22
AIRCOM International
It s OK.
The end.
Page 22 of 22