MAINTAINING A BALANCE
Chapter 2 Transportdissolved nutrients and gases
i`>
,7>}>i," -"
-i>i"-
HSC COURSE
perform a first-hand
first-hand investigation using the light
microscope and prepared slides to gather information to
estimate the size of red and white blood cells and draw
scaled diagrams of each
")/,/'9
). &/#53
Linked to
page 38
Figure 2.4 Sequence of steps to estimate the size of the field of view
1
field of view
grid line
at edge
of field
diameter of
field of view
1 mm
0.6 mm
1
Copyright 2008 McGraw-Hill Australia. Permission is granted to reproduce for classroom use.
BIOLOGY IN FOCUS
2
Copyright 2008 McGraw-Hill Australia. Permission is granted to reproduce for classroom use.
BIOLOGY IN FOCUS
Results
Estimation of size of red and white blood cells.
Scale diagrams of red and white blood cells.
Record your results at the end of this worksheet under the section Results. You are required
to record all estimates, show your working for any calculations and follow the rules for drawing
scientic diagrams, a skill learnt in the Preliminary Course.
Safety:
Method:
1. Place the mini-grid (or transparent ruler) on the microscope stage and view under the 10
objective. This gives a magnication of 100 times (eyepiece objective = 10 10 = 100).
2. Estimate the eld of view under low power.
Use the grid or ruler to estimate the diameter of the eld of view in mm and m (1 mm =
1000 m) (see Fig. 2.4, steps 1 and 2).
3. Calculate the eld of view under high power.
Using the 40 objective, calculate the eld of view ( the size of your low power eld of view).
4. View a prepared slide of blood and estimate the size (length) of red and white blood cells.
Estimate the size of a red blood cell. Count or estimate the approximate number of red blood
cells that would t across the diameter (imaginary centre line) of the eld of view (using 400
magnication). Using this number and the known diameter for the eld of view, calculate the
size of each blood cell (see Fig. 2.5).
Repeat this process three times and nd an average size for red blood cells.
Estimate the size of white blood cells compared with the red cell. Use this estimate to
calculate the size. Repeat with three different white blood cells and obtain an average.
5. Draw a scale diagram of each type of blood cell as follows:
(a) Draw a your scale bar that represents 10 m.
(b) Using this scale, draw a red blood cell and a white blood cell. Label all parts of each cell.
3
Copyright 2008 McGraw-Hill Australia. Permission is granted to reproduce for classroom use.
BIOLOGY IN FOCUS
Results
1. Field of view 40 = _______mm or _______ m
Field of view 100 = _______mm or _______ m
Field of view 400 = _______mm or _______ m
2.
Blood cell type
Estimate 1
Estimate 2
Estimate 3
Average
Conclusion
4
Copyright 2008 McGraw-Hill Australia. Permission is granted to reproduce for classroom use.
BIOLOGY IN FOCUS
Discussion questions
1. Describe how you could distinguish between red cells and white cells under the microscope.
3. Compare the size of a red blood cell and a white blood cell. Assess the reliability of the
measurements that you obtained.
4. Explain why it was necessary to repeat the estimation process three times and nd an average
for each cell type
5. Assess the accuracy of your results for each cell type and justify. (Re-read the background
information on measurement in science before attempting to answer this question.)
6. Discuss and report on the difculties you had in carrying out this investigation.
7. Describe how you could improve the accuracy and reliability of your investigation.
8. From this investigation and your knowledge of biology, prepare a table to outline the similarities
and differences in structure between red blood cells and white blood cells.
5
Copyright 2008 McGraw-Hill Australia. Permission is granted to reproduce for classroom use.
BIOLOGY IN FOCUS
Extension work
1. Describe the ratio that Anton Van Leeuwenhoek used to estimate the size of red blood cells (see
the background information on pages 3738 of the textbook).
2. Outline the method he would have had to use to arrive at this conclusion.
3. Using your knowledge of the actual size of a red blood cell, calculate the size of the grain of
sand that he used for comparison with a red blood cell. Show your working. For this to be true,
what assumptions do you need to make?
6
Copyright 2008 McGraw-Hill Australia. Permission is granted to reproduce for classroom use.
BIOLOGY IN FOCUS
Answers
Discussion questions
1. Describe how you could distinguish between red cells and white cells under the microscope.
Colour: white blood cells have no pigmentation, whereas red blood cells are red (appear
pale pink under the microscope).
Nucleus: white blood cells have a nucleus that may be irregular in shape and stained purple,
whereas red blood cells do not have a nucleus.
Size and shape: white blood cells are larger and round or slightly irregular in shape; red
blood cells are smaller and atter with a biconcave shape.
2. Which are more numerous, red cells or white cells? Explain
Explain, using evidence gathered in the
investigation.
Red cells are more numerous.
Evidence: within the high power microscopic eld, there are many hundreds of red blood cells
and only one or two white cells visible.
3. Compare the size of a red blood cell and a white blood cell. Assess the reliability of the
measurements that you obtained.
White blood cells are largerapproximately one and a half times the size of red blood cells.
The reliability of the results is increased by obtaining three sets of results for red cells and
averaging this, then obtaining three sets for white cells and nding an average for each. These
results were similar and so the results are fairly reliable.
4. Explain why it was necessary to repeat the estimation process three times and nd an average
for each cell type.
Repetition of the process gives more reliable results because several estimates give a greater
percentage coverage of the eld of view.
5. Assess the accuracy of your results for each cell type and justify. (Re-read the background
information on measurement in science before attempting to answer this question.)
(Students should compare their results with those found in scientic literature and then comment
on the accuracy. The degree of condence in the estimate also affects accuracy and students
should mention this). A sample answer is given below.
The accuracy using this method is not very highit is simply an estimate of the size of red blood
cells, based on the number across the diameter of the eld. Our estimate of the size of a red
blood cell was 10 m, whereas scientic literature shows that it should be closer to 7.5 m.
Limitations in the accuracy of our measurements arose when:
measuring the eld of view (use of a ruler was less accurate than use of a mini-gridsmaller
calibrations would have given a more accurate estimate of the diameter eld of view, so our
less precise measurements led to some inaccuracy
counting/estimating the number of cells across the diameter of the eldwe are not very
condent that we counted correctly as the cells are very small and we had some gaps
across the diameter and had to estimate the number of cells that would ll them
comparing the size and proportion of white blood cells with that of red blood cells.
6. Discuss and report on the difculties you had in carrying out this investigation.
Difculties could include:
how precisely the diameter of the eld of view could be measured (e.g. ruler, no mini-grids
availalble)
difculties trying to observe and count how many red blood cells t across the diameter
cells are very small and we had some gaps across the diameter and had to estimate the
number of cells that would ll them.
7. Describe how you could improve the accuracy and reliability of your investigation.
Reliability can be increased further by comparing results with other students in the class, or
even averaging the results of all students in the class.
7
Copyright 2008 McGraw-Hill Australia. Permission is granted to reproduce for classroom use.
BIOLOGY IN FOCUS
Cell type
Density (per
mL blood)
Size (diameter)
Where produced
Structure
Function
56 million
78 m
Bone marrow
(destroyed in liver and
spleen)
Small, round,
flattenedbiconcave,
no nucleus, red
(contain haemoglobin
250 million molecules
in each RBC)
Transport oxygen:
4 oxygen molecules
combine with each
haemoglobin to form
oxyhaemoglobin
White blood
cells
4 000
11 000
~ 12 m
Bone marrow
(destroyed in liver and
spleen)
Function as part of
the immune system
in defence against
disease
Platelets
400 000
~ 3 um
Bone marrow
Disc-shaped cell
fragments, 50%
smaller than red blood
cells, non-pigmented
Release a
clotting enzyme,
thromboplastin, to
seal blood vessels
and prevent excessive
blood loss
Extension work
9. Describe the ratio that Anton Van Leeuwenhoek used to estimate the size of red blood cells
(see background information at the beginning of this investigation).
25,000 times smaller than a ne grain of sand, i.e. 1: 25 000.
10. Outline the method he would have had to use to arrive at this conclusion.
To do this, he would have had to understand the magnifying power of the microscope and
lenses that he was using: estimate the eld of view, count how many grains of sand t across
the eld of view, then divide the size of the eld of view by the number of grains of sand to get
the size of each grain of sand.
11. Using your knowledge of the actual size of a red blood cell, calculate the size of the grain of
sand that he used for comparison with a red blood cell. Show your working. For this to be true,
what assumptions does one need to make?
Red blood cell = 7.5 m.
Grain of sand is 25 000 times larger, i.e. 7.5 25 = 187.5 m.
8
Copyright 2008 McGraw-Hill Australia. Permission is granted to reproduce for classroom use.