FVT110(M,S)1/BO
The FVT110/BO is a video transmitter and data transceiver that supports the
simultaneous transmission of short haul quality 10-bit EIA RS250C digital video and
Bosch Biphase and Bilinx camera control signals over one single mode or multimode
optical fiber.
The FVT110/BO in-dome module supports Bosch Bilinx up-the-coax camera control
over its entire specified fiber distance. The series features a unique time-base
correction algorithm that removes the usual distance limitations associated with
up-the-coax control.
Bi-color (Red/Green) LED indicators are provided for rapidly ascertaining equipment
operating status. Figure 2 on Page 3 describes the LED indicators for each light on the
receiver unit.
The FVT110/BO is intended for mounting within the Bosch dome. See Page 2 for
mounting instructions.
INS_FVT110/BO_REV
2/15/12
PAGE 1
FVT110(M,S)1/BO
SINGLE MODE
OR MULTIMODE
OPTICAL FIBER
3. C onnect video to
module at J4 (2-pin
male connector with
white plastic backing)
with ComNets 2-pin to
BNC cable, connecting
the other end to the
Dome BNC.
Video LED D1 should
illuminate green.
5. A ttach the
FVT110/BO module to
the accessory insert with
white plastic stand-offs.
The stand-offs will snap
into the gold mounting
holes in the module as
shown.
* NOTE: Data LED D2 will flash green when Bosch Biphase data is received.
INS_FVT110/BO_REV
2/15/12
PAGE 2
FVT110(M,S)1/BO
GREEN
RED
OFF
LINK
VIDEO
DATA IN
POWER
Communication link
Unit powered up
connector.
Communication
link has not been
established.
INS_FVT110/BO_REV
2/15/12
PAGE 3
FVT110(M,S)1/BO
GND
DIN ()
DIN (+)
DOUT ()
DOUT (+)
Switch
UTC Control
Bi-phase
Customer
Equipment
FVT110/BO
FVR110
VIDEO IN
VIDEO OUT
Customer
Equipment
FVT110/BO
FVR110
Customer
Equipment
Data In (+)
DOUT(+)
DIN(+)
Data In ()
DOUT()
DIN()
Data Out ()
Up-the-Coax
Control Receiver
Up-the-Coax
Control Transmitter
Installation Considerations
This fiber-optic link is supplied as an in-dome module. Units should be installed in dry locations protected from extremes of temperature and humidity.
CAUTION: Take care not to press on any of the LEDs.
IMPORTANT SAFEGUARDS:
A) Elevated Operating Ambient - Consideration should be given to installing the equipment in an environment compatible with the maximum ambient temperature
(Tma) specified by the manufacturer.
B) Reduced Air Flow - Installation of the equipment should be such that the amount of air flow required for safe operation
of the equipment is not compromised.
INS_FVT110/BO_REV
2/15/12
PAGE 4