2.
IDENTIFICATION
Company:
Address:
Telephone No.:
Product Use:
Packages:
NFPA Rating:
PIN (Canada):
Revision Date:
MAGNAFLUX
3624 West Lake Avenue, Glenview, Illinois 60026
847-657-5300 (Off-Hour Emergency Number - CHEMTREC - 1-800-424-9300).
Inspection penetrant
55 gallon drum.
Health 1, Flammability 1, Reactivity 0
None
October 26, 2004
HAZARDOUS INGREDIENTS
Ingredient
Wt./Wt.
%
5-10
5-10
3.
60-100
5 10
CAS #
TLV
PEL
LD50
LC50
8042-47-5
or 64742-47-8 not avail. not avail. not avail. not avail.
2.6 g/kg
69227-21-0
not avail. not avail. (oral/rat) not avail.
Not
Not
Not
Not
68412-54-4
avail.
avail.
avail.
avail.
Not
Not
Not
Not
84133-50-6
avail.
avail.
avail.
avail.
HAZARDS IDENTIFICATION
EMERGENCY OVERVIEW
Bland oily liquid which may irritate the skin and eyes. Difficult to ignite,
but will burn vigorously if engulfed in fire.
FIRST AID
Skin Contact:
Wash off with soap and water. Use soothing lotion.
Eyes:
Rinse carefully under upper and lower eyelids using plenty of water.
Inhalation:
Remove to fresh air if dizzy or nauseated.
Ingestion:
Do not induce vomiting. Accidental ingestion of a single mouthful is not expected to cause significant harm.
NOTE: In all severe cases, contact physician immediately. Local telephone operators can furnish number of regional poison control center.
5.
FIRE HAZARD
Conditions of flammability:
Flash point (Bulk):
Flammable limits in air:
Extinguishing media:
Special fire fighting procedures:
Hazardous combustion products:
Unusual fire hazards:
6.
7.
Page 1 of 2 (Foilcheck)
8.
9.
PHYSICAL PROPERTIES
Initial boiling point (bulk):
Percent volatile:
Density/sp. gravity:
Water solubility:
pH:
Stable
None
Soot, oxides of carbon if heated to combustion temperature.
None
10.
11.
TOXICOLOGICAL INFORMATION
Carcinogenicity:
Threshold limit value:
WHMIS information (Canada):
Vapor pressure:
Vapor density:
Evaporation rate:
Appearance:
Odor:
<0.10mm @ 70F(21C)
Heavier than air
Negligible
Clear,colorless, oily liquid
Oily odor
Contains no known or suspected carcinogens listed with OSHA, IARC, NTP, or ACGIH.
5 mg/m; for oily mist.
According to available information, the ingredients have not been found to show reproductive toxicity,
teratogenicity, mutagenicity, skin sensitization, or synergistic toxic effects with other materials.
12.
ECOLOGICAL INFORMATION
No data is available on Foilcheck. It emulsifies into water and is biodegradable. Its low bulk vapor pressure may exempt it from VOC restrictions.
13.
DISPOSAL
As a non-hazardous oily waste, incinerate or send to waste handler who can blend it into secondary fuels.
RCRA:
U.S. EPA Waste Number:
14.
TRANSPORTATION
U.S. DOT: 49 CFR 172.101 Hazardous Materials Table
Non-Aerosol
Proper shipping name:
None, not restricted
Hazard class or division:
None
Identification No.:
None
Packing Group:
None
15.
REGULATORY INFORMATION
TSCA:
Canadian DSL:
CERCLA:
SARA TITLE III, Section 313:
California Proposition 65:
16.
OTHER INFORMATION
Revision Statement:
Sections 2 and 15
Supersedes:
October 26, 2001
Prepared by:
Tamie Simmons, R&D Manager
Page 2 of 2 (Foilcheck)