Anda di halaman 1dari 4

Federal Register / Vol. 71, No.

23 / Friday, February 3, 2006 / Notices 5843

adjust the existing ways to comply with exemption (TME), and to publish collection of materials that is available
any previously applicable instructions periodic status reports on the chemicals for public viewing at the EPA Docket
and requirements; train personnel to be under review and the receipt of notices Center, Rm. B102-Reading Room, EPA
able to respond to a collection of of commencement to manufacture those West, 1301 Constitution Ave., NW.,
information; search data sources; chemicals. This status report, which Washington, DC. The EPA Docket
complete and review the collection of covers the period from January 1, 2006 Center is open from 8:30 a.m. to 4:30
information; and transmit or otherwise thru January 13, 2006, consists of the p.m., Monday through Friday, excluding
disclose the information. With regard to PMNs pending or expired, and the legal holidays. The EPA Docket Center
the new form, which is included in the notices of commencement to Reading Room telephone number is
public docket for this action, EPA manufacture a new chemical that the (202) 566–1744, and the telephone
specifically solicits comments and Agency has received under TSCA number for the OPPT Docket, which is
information to enable it to: section 5 during this time period. located in the EPA Docket Center, is
1. Evaluate whether the proposed DATES: Comments, identified by the (202) 566–0280.
form is necessary for the proper docket ID number EPA–HQ–OPPT– 2. Electronic access. You may access
performance of the functions of the 2006–0051 and the specific PMN this Federal Register document
Agency, including whether the number or TME number, must be electronically through the EPA Internet
information EPA intends to collect will received on or before March 6, 2006. under the ‘‘Federal Register’’ listings at
have practical utility. http://www.epa.gov/fedrgstr/.
ADDRESSES: Comments/may be
2. Evaluate the accuracy of the EDOCKET, EPA’s electronic public
submitted electronically, by mail, or docket and comment system was
Agency’s estimates of the burdens of the through hand delivery/courier. Follow
proposed collections of information. replaced on November 25, 2005 by an
the detailed instructions as provided in enhanced federal-wide electronic docket
3. Enhance the quality, utility, and Unit I. of the SUPPLEMENTARY
clarity of the information to be management and comment system
INFORMATION. located at http://www.regulations.gov/.
collected.
4. Minimize the burden of the FOR FURTHER INFORMATION CONTACT: Follow the on-line instructions.
collections of information on those who Colby Lintner, Regulatory Coordinator, An electronic version of the public
are to respond, including through the Environmental Assistance Division, docket is available through EPA’s
use of appropriate automated or Office of Pollution Prevention and electronic public docket and comment
electronic collection technologies or Toxics (7408M), Environmental system, EPA Dockets. You may use EPA
other forms of information technology, Protection Agency, 1200 Pennsylvania Dockets at http://www.epa.gov/edocket/
e.g., permitting electronic submission of Ave., NW., Washington, DC 20460– to submit or view public comments,
responses. 0001; telephone number: (202) 554– access the index listing of the contents
1404; e-mail address: TSCA- of the official public docket, and to
List of Subjects Hotline@epa.gov. access those documents in the public
Environmental protection, Pesticides docket that are available electronically.
SUPPLEMENTARY INFORMATION:
and pests. Although not all docket materials may
I. General Information be available electronically, you may still
Dated: January 23, 2006. access any of the publicly available
A. Does this Action Apply to Me? docket materials through the docket
Susan B. Hazen,
Acting Assistant Administrator, Office of This action is directed to the public facility identified in Unit I.B.1. Once in
Prevention, Pesticides and Toxic Substances. in general. As such, the Agency has not the system, select ‘‘search,’’ then key in
[FR Doc. E6–1511 Filed 2–2–06; 8:45 am] attempted to describe the specific the appropriate docket ID number.
BILLING CODE 6560–50–S
entities that this action may apply to. Certain types of information will not
Although others may be affected, this be placed in the EPA Dockets.
action applies directly to the submitter Information claimed as CBI and other
ENVIRONMENTAL PROTECTION of the premanufacture notices addressed information whose disclosure is
AGENCY in the action. If you have any questions restricted by statute, which is not
regarding the applicability of this action included in the official public docket,
[EPA–HQ–OPPT–2006–0051; FRL–7761–2] to a particular entity, consult the person will not be available for public viewing
listed under FOR FURTHER INFORMATION in EPA’s electronic public docket. EPA’s
Certain New Chemicals; Receipt and policy is that copyrighted material will
CONTACT.
Status Information not be placed in EPA’s electronic public
B. How Can I Get Copies of this docket but will be available only in
AGENCY: Environmental Protection
Document and Other Related printed, paper form in the official public
Agency (EPA).
Information? docket. To the extent feasible, publicly
ACTION: Notice.
1. Docket. EPA has established an available docket materials will be made
SUMMARY: Section 5 of the Toxic official public docket for this action available in EPA’s electronic public
Substances Control Act (TSCA) requires under docket identification (ID) number docket. When a document is selected
any person who intends to manufacture EPA–HQ–OPPT–2006–0051. The from the index list in EPA Dockets, the
(defined by statute to include import) a official public docket consists of the system will identify whether the
new chemical (i.e., a chemical not on documents specifically referenced in document is available for viewing in
the TSCA Inventory) to notify EPA and this action, any public comments EPA’s electronic public docket.
comply with the statutory provisions received, and other information related Although not all docket materials may
hsrobinson on PROD1PC70 with NOTICES

pertaining to the manufacture of new to this action. Although a part of the be available electronically, you may still
chemicals. Under sections 5(d)(2) and official docket, the public docket does access any of the publicly available
5(d)(3) of TSCA, EPA is required to not include Confidential Business docket materials through the docket
publish a notice of receipt of a Information (CBI) or other information facility identified in Unit I.B.1. EPA
premanufacture notice (PMN) or an whose disclosure is restricted by statute. intends to work towards providing
application for a test marketing The official public docket is the electronic access to all of the publicly

VerDate Aug<31>2005 16:43 Feb 02, 2006 Jkt 208001 PO 00000 Frm 00043 Fmt 4703 Sfmt 4703 E:\FR\FM\03FEN1.SGM 03FEN1
5844 Federal Register / Vol. 71, No. 23 / Friday, February 3, 2006 / Notices

available docket materials through due to technical difficulties or needs DCO is open from 8 a.m. to 4 p.m.,
EPA’s electronic public docket. further information on the substance of Monday through Friday, excluding legal
For public commenters, it is your comment. EPA’s policy is that EPA holidays. The telephone number for the
important to note that EPA’s policy is will not edit your comment, and any DCO is (202) 564–8930.
that public comments, whether identifying or contact information
submitted electronically or in paper, D. How Should I Submit CBI to the
provided in the body of a comment will
will be made available for public be included as part of the comment that Agency?
viewing in EPA’s electronic public is placed in the official public docket, Do not submit information that you
docket as EPA receives them and and made available in EPA’s electronic consider to be CBI electronically
without change, unless the comment public docket. If EPA cannot read your through EPA’s electronic public docket
contains copyrighted material, CBI, or comment due to technical difficulties or by e-mail. You may claim
other information whose disclosure is and cannot contact you for clarification, information that you submit to EPA as
restricted by statute. When EPA EPA may not be able to consider your CBI by marking any part or all of that
identifies a comment containing comment. information as CBI (if you submit CBI
copyrighted material, EPA will provide i. EPA Dockets. Your use of EPA’s on disk or CD ROM, mark the outside
a reference to that material in the electronic public docket to submit of the disk or CD ROM as CBI and then
version of the comment that is placed in comments to EPA electronically is identify electronically within the disk or
EPA’s electronic public docket. The EPA’s preferred method for receiving CD ROM the specific information that is
entire printed comment, including the comments. Go directly to EPA Dockets CBI). Information so marked will not be
copyrighted material, will be available at http://www.epa.gov/edocket/, and disclosed except in accordance with
in the public docket. follow the online instructions for procedures set forth in 40 CFR part 2.
Public comments submitted on submitting comments. Once in the In addition to one complete version of
computer disks that are mailed or system, select ‘‘search,’’ and then key in the comment that includes any
delivered to the docket will be docket ID number EPA–HQ–OPPT– information claimed as CBI, a copy of
transferred to EPA’s electronic public 2006–0051. The system is an the comment that does not contain the
docket. Public comments that are ‘‘anonymous access’’ system, which information claimed as CBI must be
mailed or delivered to the docket will be means EPA will not know your identity, submitted for inclusion in the public
scanned and placed in EPA’s electronic e-mail address, or other contact docket and EPA’s electronic public
public docket. Where practical, physical information unless you provide it in the docket. If you submit the copy that does
objects will be photographed, and the body of your comment. not contain CBI on disk or CD ROM,
photograph will be placed in EPA’s ii. E-mail. Comments may be sent by mark the outside of the disk or CD ROM
electronic public docket along with a e-mail to oppt.ncic@epa.gov, Attention: clearly that it does not contain CBI.
brief description written by the docket Docket ID Number EPA–HQ–OPPT– Information not marked as CBI will be
staff. 2006–0051 and PMN Number or TME included in the public docket and EPA’s
Number. In contrast to EPA’s electronic electronic public docket without prior
C. How and To Whom Do I Submit
public docket, EPA’s e-mail system is notice. If you have any questions about
Comments?
not an ‘‘anonymous access’’ system. If CBI or the procedures for claiming CBI,
You may submit comments you send an e-mail comment directly to please consult the technical person
electronically, by mail, or through hand the docket without going through EPA’s listed under FOR FURTHER INFORMATION
delivery/courier. To ensure proper electronic public docket, EPA’s e-mail CONTACT.
receipt by EPA, identify the appropriate system automatically captures your e-
docket ID number and specific PMN mail address. E-mail addresses that are E. What Should I Consider as I Prepare
number or TME number in the subject automatically captured by EPA’s e-mail My Comments for EPA?
line on the first page of your comment. system are included as part of the You may find the following
Please ensure that your comments are comment that is placed in the official suggestions helpful for preparing your
submitted within the specified comment public docket, and made available in comments:
period. Comments received after the EPA’s electronic public docket. 1. Explain your views as clearly as
close of the comment period will be iii. Disk or CD ROM. You may submit possible.
marked ‘‘late.’’ EPA is not required to comments on a disk or CD ROM that 2. Describe any assumptions that you
consider these late comments. If you you mail to the mailing address used.
wish to submit CBI or information that identified in Unit I.C.2. These electronic 3. Provide copies of any technical
is otherwise protected by statute, please submissions will be accepted in information and/or data you used that
follow the instructions in Unit I.D. Do WordPerfect or ASCII file format. Avoid support your views.
not use EPA Dockets or e-mail to submit the use of special characters and any 4. If you estimate potential burden or
CBI or information protected by statute. form of encryption. costs, explain how you arrived at the
1. Electronically. If you submit an 2. By mail. Send your comments to: estimate that you provide.
electronic comment as prescribed in this Document Control Office (7407M), 5. Provide specific examples to
unit, EPA recommends that you include Office of Pollution Prevention and illustrate your concerns.
your name, mailing address, and an e- Toxics (OPPT), Environmental 6. Offer alternative ways to improve
mail address or other contact Protection Agency, 1200 Pennsylvania the notice or collection activity.
information in the body of your Ave., NW., Washington, DC 20460– 7. Make sure to submit your
comment. Also include this contact 0001. comments by the deadline in this
information on the outside of any disk 3. By hand delivery or courier. Deliver document.
hsrobinson on PROD1PC70 with NOTICES

or CD ROM you submit, and in any your comments to: OPPT Document 8. To ensure proper receipt by EPA,
cover letter accompanying the disk or Control Office (DCO) in EPA East Bldg., be sure to identify the docket ID number
CD ROM. This ensures that you can be Rm. 6428, 1201 Constitution Ave., NW., assigned to this action and the specific
identified as the submitter of the Washington, DC. Attention: Docket ID PMN number you are commenting on in
comment and allows EPA to contact you Number EPA–HQ–OPPT–2006–0051 the subject line on the first page of your
in case EPA cannot read your comment and PMN Number or TME Number. The response. You may also provide the

VerDate Aug<31>2005 15:00 Feb 02, 2006 Jkt 208001 PO 00000 Frm 00044 Fmt 4703 Sfmt 4703 E:\FR\FM\03FEN1.SGM 03FEN1
Federal Register / Vol. 71, No. 23 / Friday, February 3, 2006 / Notices 5845

name, date, and Federal Register of commencement to manufacture those information that is not included in the
citation. chemicals. This status report, which following tables, you may contact EPA
covers the period from January 1, 2006 as described in Unit II. to access
II. Why is EPA Taking this Action?
thru January 13, 2006, consists of the additional non-CBI information that
Section 5 of TSCA requires any PMNs pending or expired, and the may be available.
person who intends to manufacture notices of commencement to
(defined by statute to include import) a In Table I of this unit, EPA provides
manufacture a new chemical that the
new chemical (i.e., a chemical not on the following information (to the extent
Agency has received under TSCA
the TSCA Inventory to notify EPA and section 5 during this time period. that such information is not claimed as
comply with the statutory provisions CBI) on the PMNs received by EPA
pertaining to the manufacture of new III. Receipt and Status Report for PMNs during this period: the EPA case number
chemicals. Under sections 5(d)(2) and This status report identifies the PMNs assigned to the PMN; the date the PMN
5(d)(3) of TSCA, EPA is required to pending or expired, and the notices of was received by EPA; the projected end
publish a notice of receipt of a PMN or commencement to manufacture a new date for EPA’s review of the PMN; the
an application for a TME and to publish chemical that the Agency has received submitting manufacturer; the potential
periodic status reports on the chemicals under TSCA section 5 during this time uses identified by the manufacturer in
under review and the receipt of notices period. If you are interested in the PMN; and the chemical identity.

I. 21 PREMANUFACTURE NOTICES RECEIVED FROM: 01/01/06 TO 01/13/06


Projected
Received
Case No. Notice Manufacturer/Importer Use Chemical
Date End Date

P–06–0220 01/03/06 04/02/06 CBI (G) Raw material used in the manu- (G) Methacrylic acid, polymer with
facture of lithographic printing acrylic and methacrylic acid deriva-
plates tives
P–06–0221 12/30/05 03/29/06 CBI (S) Curing agent for epoxy coating (G) Phenol-(methylethylidene)bis-,
systems polymer with n-aminoethyl-n’-
[(phenylmethyl)amino]ethyl]-
ethanediamine, n-(aminoethyl)-n’-
(phenylmethyl)-ethanediamine, n,n’-
bis[(phenylmethyl)amino]ethyl]-
ethanediamine,
(chloromethyl)oxirane, .alpha.-
hydro-.omega.-hydroxypoly(oxy-
ethanediyl) and n-(phenylmethyl)-n’-
[(phenylmethyl)amino] ethyl]-
ethanediamine
P–06–0222 01/04/06 04/03/06 CBI (G) Surfactant (G) Cyclic alcohol alkoxylate sulfate
ammonium salt
P–06–0223 01/04/06 04/03/06 CBI (G) Lubricating oil additive (G) Heteromonocyclic, 2-mercapto-
5,5-dimethyl-, 2oxide
P–06–0224 01/06/06 04/05/06 CBI (G) Textile treatment additive (G) Fluoroalkylacrylate copolymer
P–06–0225 01/06/06 04/05/06 CBI (G) Flow additive (G) Methyl-pyrrolidone distn. residues
P–06–0226 01/06/06 04/05/06 CBI (G) Flow additive (G) Butynediol distn. residues
P–06–0227 01/09/06 04/08/06 CIBA Specialty Chemi- (G) Sizing agent (G) Unsaturated branched and linear
cals Corporation alkyl and alkylidene-2-oxetanone
P–06–0228 01/09/06 04/08/06 CBI (G) Precusor for high temperature ad- (G) Alkylcarbosilane polymer
vanced ceramics, composites and
coatings
P–06–0229 01/10/06 04/09/06 CBI (G) Open non-dispersive (coatings) (G) Unsaturated aliphatic urethane
acrylate
P–06–0230 01/10/06 04/09/06 Syngenta Crop protec- (G) Raw material used in a closed re- (G) Substituted aniline
tion, Inc. action process to produce a chem-
ical intermediate
P–06–0231 01/10/06 04/09/06 Montana (S) Biodegradable plastic; surfactant; (S) Levan
Polysaccharides adhesive; personal car products
Corp.
P–06–0232 01/10/06 04/09/06 CBI (G) Open, non-dispersive use (G) Substituted polyaeryl sulfonium
compound
P–06–0233 01/10/06 04/09/06 CBI (S) Site limited intermediate (G) Alklyloxypropyloxypropylnitrile
P–06–0234 01/10/06 04/09/06 CBI (G) Clay modifier in asphalt roof coat- (G) Alklyloxypropyloxypropylamine ac-
ing etate
P–06–0235 01/09/06 04/08/06 CBI (G) Monomer mixture (G) Product 1: Alkoxylated chloro-
substituted alkylchlorosilane,
hsrobinson on PROD1PC70 with NOTICES

chloro-substituted alkyl alkoxysilane


P–06–0236 01/09/06 04/08/06 CBI (G) Monomer mixture (G) Product 2: Alkoxylated chloro-
substituted alkylchlorosilane,
chloro-substituted alkyl alkoxysilane
P–06–0237 01/11/06 04/10/06 CBI (G) Industrial adhesive (G) Isocyanate functional urethane
prepolymer

VerDate Aug<31>2005 15:00 Feb 02, 2006 Jkt 208001 PO 00000 Frm 00045 Fmt 4703 Sfmt 4703 E:\FR\FM\03FEN1.SGM 03FEN1
5846 Federal Register / Vol. 71, No. 23 / Friday, February 3, 2006 / Notices

I. 21 PREMANUFACTURE NOTICES RECEIVED FROM: 01/01/06 TO 01/13/06—Continued


Projected
Received
Case No. Notice Manufacturer/Importer Use Chemical
Date End Date

P–06–0238 01/12/06 04/11/06 Incorez Corporation (S) Binder, coatng or modified resin (S) Fatty acids, C18-unsaturated,
used in the manufacture of coatings dimers, hydrogenated, polymers
for wood, plastic and cementitious with adipic acid, 1,6-
substrates hexanediol,.alpha.-hydro.omega.-
hydroxypoly (oxy-1,4-butanediyl),3-
hydroxy-2-(hydroxymethyl)-2-
methylpropanoic acid, 5-isocyanato-
1-(isocyanatomethyl-1,3,3-
trimethycyclohexane, 2-methyl-1,5-
pentanediamine and 3-oxepanone,
compounds with triethylamine
P–06–0239 01/12/06 04/11/06 Incorez Corporation (S) Curing agent for epoxy coatings (S) Phenol, 4,4′-(1-
methylethylidene)bis-, polymers
with 1,3-benzenedimethanamine,
bisphenol a diglycidyl ether,
epichlorohydrin, formaldehyde-phe-
nol polymerglycidyl ether, oxirane
mono[(C12–14-
alkyloxy)methyl]derivates, poly-
propylene glycol, polypropylene gly-
col diglycidyl ether and
tetraethylenepentamine

In Table II of this unit, EPA provides CBI) on the Notices of Commencement


the following information (to the extent to manufacture received:
that such information is not claimed as

II. 13 NOTICES OF COMMENCEMENT FROM: 01/01/06 TO 01/13/06


Commencement
Case No. Received Date Chemical
Notice End Date

P–02–0563 01/05/06 12/15/05 (S) 2-propenoic acid, 2-methyl-, oxiranylmethyl ester, polymer with
ethenylbenzene
P–02–1005 01/11/06 12/13/05 (G) Mixed phosphate esters
P–04–0792 01/06/06 12/12/05 (G) Halo substituted hydroxy nitrophenyl amide
P–04–0896 01/04/06 12/16/05 (S) Oils, gardenia tahitensis
P–05–0159 01/09/06 12/23/05 (G) Copolymer of acrylic and methacrylic esters
P–05–0247 01/05/06 12/16/05 (G) 3-phenylimino-6-oxo-1,4-cyclohexadiene derivative
P–05–0248 01/05/06 12/16/05 (G) 5-amino-4-nitrophenylazo-1-phenylpirazole derivative
P–05–0360 01/05/06 12/16/05 (G) 7h-pyrazolo [1,5-b] [1,2,4] triazole derivative
P–05–0467 01/04/06 12/18/05 (G) Fluoriated vinyl ester polymer
P–05–0541 12/30/05 12/19/05 (G) Aliphatic polyurethane resin
P–05–0579 01/06/06 12/28/05 (G) 2-[4-(4,6-bis-biphenyl]-4-yl-[1,3,5]triazin-2-yl)-3-hydroxy-phenoxy]-, alkyl acid
isoalkyl ester
P–05–0646 01/11/06 12/12/05 (G) Rape oil fatty acids
P–05–0736 01/05/06 12/23/05 (S) 2,6,10-dodecatrien-1-ol, 3,7,11-trimethyl-, (2e,6e)-

List of Subjects FEDERAL COMMUNICATIONS Impact of Hurricane Katrina on


COMMISSION Communications Networks (Panel or
Environmental Protection, Chemicals, Independent Panel) is providing an
Premanufacturer Notices. Federal Advisory Committee Act; opportunity for interested persons to
Dated: January 27, 2006. Independent Panel Reviewing the make oral presentations to the Panel at
Carolyn Thornton,
Impact of Hurricane Katrina on its next meeting. The specific date, time
Communications Networks and location of the next meeting will be
Acting Director, Information Management
Division, Office of Pollution Prevention and
announced in a subsequent notice.
AGENCY: Federal Communications
Toxics. DATES: February 17, 2006.
Commission.
[FR Doc. E6–1514 Filed 2–2–06; 8:45 am] ADDRESSES: Lisa M. Fowlkes,
ACTION: Notice of opportunity to provide
hsrobinson on PROD1PC70 with NOTICES

Designated Federal Office of the


BILLING CODE 6560–50–S oral presentations. Independent Panel,
SUMMARY: This notice advises interested lisa.fowlkes@fcc.gov.
persons that the Federal FOR FURTHER INFORMATION CONTACT: Lisa
Communications Commission’s (FCC) M. Fowlkes, Designated Federal Officer
Independent Panel Reviewing the of the FCC’s Independent Panel at 202–

VerDate Aug<31>2005 16:43 Feb 02, 2006 Jkt 208001 PO 00000 Frm 00046 Fmt 4703 Sfmt 4703 E:\FR\FM\03FEN1.SGM 03FEN1

Anda mungkin juga menyukai