EXPLANATION
The PI section linear model has a finite number of states that permit you to compute a
linear state-space model. The number of sections to be used depends on the frequency
range to be represented.
The over al rated frequency is 60 Hz but as for Pakistan we use 50 Hz in this PI model
Resistance per unit length
The resistance per unit length of the line, in ohms/km (/km). which is 50 in this
nominal PI model.
Inductance per unit length
The inductance per unit length of the line, in henries/km (H/km). This parameter
can not be zero, because it would result in an invalid propagation speed
computation.
Capacitance per unit length
The capacitance per unit length of the line, in farads/km (F/km). This parameter
can not e zero, because it would result in an invalid propagation speed
computation.
Measurements
Select Input and output voltages to measure the sending end (input port) and
receiving end (output port) voltages of the line model.
The user can connect multiple pi section in series to form an equivalent for a long
transmission line.
Resistor
Capacitor
Voltage Measurement
Current Measurement
Scope
RL Load
Ac voltage source
POWERGUI:
Graphical user interface for the analysis of circuits and systems
Library:
Powerlib ( in Simulink)
Procedure:
Required values:
Capacitor= 10e-6
Nominal voltage = 500
Inductance= 10e3
BLOCK REPRESENTATION:
Frequency=50
Resistance=60
GRAPHICAL REPRESENTATION:
Steady state:-