TRAINING REPORT
ON
EMPLOYEE ABSENTEEISM
AT
SUBMITTED IN THE PARTIAL FULFILLMENT OF THE REQUIREMENT FOR THE AWARD OF DEGREE
OF
BACHELOR OF BUSINESS ADMINISTRATION
(SESSION 2015-16)
SUBMITTED TO:
SUBMITTED BY:
KURUKSHETRA UNIVERSITY
KURUKSHETRA
DECLARATION
I
ARVIND YADAV
(PRINCIPAL SIGNATURE)
ARVIND YADAV
ACKNOWLEDGEMENT
Survey is an excellent tool for learning and exploration. No classroom routine can
substitute which is possible while working in real situations. Application of
theoretical knowledge to practical situations is the bonanzas of this survey.
Without a proper combination of inspection and perspiration, its not easy to
achieve anything. There is always a sense of gratitude, which we express to others
for the help and the needy services they render during the different phases of our
lives. I too would like to do it as I really wish to express my gratitude toward all
those who have been helpful to me directly or indirectly during the development of
this project.
I would like to thank MR. ASHOK MITTAL who was always there to help and
guide me when I needed help. Her perceptive criticism kept me working to make
this project more full proof. I am thankful to her for his encouraging and valuable
support. Working under her was an extremely knowledgeable and enriching
experience for me. I am very thankful to her for all the value addition and
enhancement done to me.
No words can adequately express my overriding debt of gratitude to my parents
whose support helps me in all the way. Above all I shall thank my friends who
constantly encouraged and blessed me so as to enable me to do this work
successfully.
INDEX
ARVIND YADAV
S.NO
PARTICULARS
1.
COMPANY PROFILE
2.
INTRODUCTION TO TOPIC
3.
RESEARCH METHODOLOGY
4.
5.
FINDINGS
6.
CONCLUSION
7.
LIMITATIONS
8.
SUGGESTIONS
9.
BIBLIOGRAPHY
INTRODUCTION
1.1 INTRODUCTION TO THE STUDY
Absenteeism is a serious workplace problem and an expensive occurrence for both employers
and employees seemingly unpredictable in nature. A satisfactory level of attendance by
employees at work is necessary to allow the achievement of objectives and targets
by a department. Employee Absenteeism is the absence of an employee from work.
It is a major problem faced by almost all employers of today. Employees are absent
from work and thus the work suffers. Absenteeism of employees from work leads to
back logs, piling of work and thus work delay.
Absenteeism is of two types 1. Innocent absenteeism - Is one in which the employee is absent from work
due to genuine cause or reason. It may be due to his illness or personal
family problem or any other real reason
2. Culpable Absenteeism - is one in which a person is absent from work
without any genuine reason or cause. He may be pretending to be ill or just
wanted a holiday and stay at home.
Many employees will, on occasions, need a few days off work because of illness, however, when
absences become more frequent or long term and reach an unacceptable level, action by
management is necessary. Absence from work can be expensive in both monetary and human
terms. The costs incurred when an employee is absent from work may include:
(i) Replacing the employee or requiring other staff to cover the absence;
(ii) Inability to provide services, or achieve section and departmental objectives;
(iii) Low morale and general dissatisfaction from other staff, particularly if the absence is
perceived as unwarranted
INDUSTRY PROFILE
One of the main problems the industrial world faces now is the scarcity of energy. The
demand is more and supply is less. More research is done to find out alternative sources of
energy. The researches are still in its beginning phase. Till some new alternate energy is found
out, the dependence will be on the existing forms. Electrically being the important among them
plays a major role in almost all industries. Apart from industries, it is the basic form of energy for
household purpose also. Production of electricity has become more expensive which demands
careful utilization and accurate measurement. Keeping this in mind analogue measuring
instruments has been replaced by electronic ones by suppliers of electricity.
The share of electricity consumption of large buildings in the commercial sector is
currently of the order of 7 percent of countrys overall consumption, and it is growing at about 12
percent over the last few years. Annual energy consumption in commercial buildings, which is in
excess of 200 Kwh per square meter of floor area, is expected to be brought down to 120-160
KWh when the standards are implemented. According to Construction Industry Development
Council (CIDC), residential and commercial construction has been growing in excess of 10
percent per annum, and that accounted for nearly 41 million square meters last year.
With escalating power demand in Southeast Asia, most countries in the region are
demanding novel electricity meters. Moreover, as increasingly more electric utilities install
meters at their customers (both small power and large power consumers) site, sales for both
single phase and three phase meters are increasing. Hence, the electricity meters market is
witnessing stable growth. This is likely to further accelerate with the transition of
electromechanical meters to electronic/digital meters.
As electricity metering and billing industry moves ever closer to full automation and
computerization, electronic meters that can communicate with each other and with other
electronic systems are expected to become an essential part of the network. Electromechanical
meters merely measures demand and consumption of energy and are quite simple. However,
with the latest electronic meters one can implement the tariff at which the utilities sell the
electricity, cites the analyst of this research service. Therefore, power distribution electric
utilities can sell electricity at a lesser price when the demand is low and kilowatt-hour (KWh)
pricing can be high when the demand is high.
Manufactures Must Offer Additional and More Advanced Technology Features To stand
Apart from Competition.
The Southeast Asian electrically meters market is highly active, with several public and
private utilities, smaller municipalities and electronic cooperative. There is intense competition
in the electricity meters market attributed by the presence of Chinese and other foreign
manufacturers and suppliers in Southeast Asia. One of the main concerns that affect the local
meters market is the presence of the many meter brands from China. These are typically low
priced and low quality meters, which utilities are sometimes forced to opt for since such meters
would meet their budget especially on household meters segment.
However, companies that offer high quality meters are likely to find greater demand
with certain utilities in the market and may even increase their profit margins due to the end
user confidence in their products, says the analyst, with several software
based and
The main players in the electricity measuring instrument manufacturing in India are:
ECIL, Hyderabad
COMPANY PROFILE
HISTORY
United Electrical Industries Ltd., Kollam was incorporated in the year 1950 in the private
sector. It is the first factory in India to manufacture Electricity House Service Meters. It is
located at 3 km south of Kollam. The Company started its manufacturing activity in technical
collaboration with a world-renowned measuring instrument manufacturer M/s. Aron Meters Ltd.,
England. It initially started with the assembly of single-phase meters with imported components
for subassemblies. The company owes its origin to Shri. K.P.S. Nair, the chief electrical engineer
or Travancore-cochin State and Shri. Abraham Pothen, an eminent industrialist. Major shares of
the company were taken over by the Kerala Government in 1957 and reconstituted as a Public
Limited Company.
As usual most industries, this company also had to face certain troubles like inadequate
working capital, labour unrest etc. The company gradually overcome this and started establishing
steady market for the product. In 1956, a plan of diversification was initiated and manufacturing
of Motor Control Gear was started with technical collaboration from Mysore Electrical Industries
Limited, Bangalore. In the same year, production of poly phase meters commenced. The
company entered into a technical collaboration with General Electrically of India Ltd.. Calcutta,
for manufacturing of oil and air break circuit breaker up to 22 Kv rating.
The Company manufactures Electricity House Service Energy Meters of both electromechanical and static types, Motor Starters and contractors. At present the company is mainly
concentrating on the production of Static type Energy Meters and motor Starters. The annual
turnover of this organization is about Rs.16 crores and more than 90% of the Companys
turnover is from the sales of Energy Meters to KSEB, its employee strength is 140.
The major shareholder is Government of Kerala and is holding 99% of the total share
value. The Board of Directors of the Company comprises government nominees, usually from
the Industries Department and General Manager of the Company and also from among other
shareholders.
The company has been running in profit consistently since 1988 and maintains a positive
net worth and negligible debt equality ratio. The Company has been maintaining excellent
industrial relations and there is no instance of production loss due to labour unrest for the past 30
years.
STRATEGIC INTENT
The mission, vision and quality policy of United Electrical Industries Ltd are stated as
follows :
Mission:
To become the number one supplier of electricity meters and to grab two digit share in
the transformer & water meter markets in India by ensuring customer satisfaction of its
products and services and continuous improvement
Vision:
To become the pioneers through operational effectiveness and
customer satisfaction
Quality Policy:
UEI and its employees are committed to develop, manufacture and marketing of house
service energy meters and motor control gears, ensuring customer satisfaction of its products
and services through continual improvement of the effectiveness of its QMS achieved by
setting and reviewing quality objectives.
Quality Objectives:
UEI shall establish Quality Objectives at relevant functional levels which will bring
continual improvement in the functions and thereby in the organization. The Quality Objectives
focus on strategic advantage to the department as well as performance improvement. The
Quality Objectives established are realistic, quantifiable, and measurable. MPRM shall suitably
review the achievement of Quality Objectives and shall set suitable action plans. Also the
management will assign responsibilities to the concerned managers for achieving the objectives
as targeted in the MPRM.
PRODUCT PROFILE
The main products of United Electrical Industries Ltd. are:
1. Energy meter
2. Oil immersed Ac motor starter
3. Air breaking switches
4. Water meters
1. Energy Meters
Two types of energy meters produced in this firm are:
a. High quality Electro-Mechanical Energy meters
Type KVI-M magnetic suspension bearing meters are designed and manufactured to
satisfy the highest standards of accuracy and reliability of energy measurement in Single Phase
AC Circuits. These are designed for tropical climate and fully complies with IS 13010 (2002)
and its latest amendments.
b. Electronic Energy Meters (Single Phase & Three Phase)
Type UEM static meter is designed and manufactured to satisfy the
highest standard of accuracy and reliability of energy measurement in single phase and three
phase circuits. The meter is designed for tropical climate and fully complies with ISI 3779.
(1999) REC specification.
The salient feature of this starter is its automatic switch over to full rated
voltage. These starting current is minimized to attain higher starting torque with the help of an
auto transformer. Tippling is provided for 40% 60% and 80% of the voltage to be supplied. The
panel consists of a Thermal Overload Relay. Star Contactor with timer (0.30 Sec), a Main
Contactor and a Run Contactor. The starting time can be set by the user depending upon the
application. The temperature of the transformer is set to safe limit using a thermostat.
3. AIR BREAK SWITCHES
Air break switches is isolate 11 KV lines from transformers.
Features
The fixed contact element are made of excursed electrolytic grade copper flat with
flexible ends.
The leakage current passes to earth and not between terminals of the poll or between
polls.
\
4. WATER METERS
Water meters are inferential. Multijet, dry dial. Magnetic type. They have both pointer &
cyclometric reading counters and are duly sealed against tampering. The conform to IS
specification no. IS: 779-1994 Class B (latest amendment) Equivalent to international standard
ISO-4094.
ORGANIZATIONAL STRUCTURE
The company follows a functional organizational structure. There are the
functions or activities the company performs to carry on its activities. It is created by grouping
the activities on the basis of functions required for the achievement or organizational objectives.
For this purpose, all the functions required are classified into basic, secondary, and supporting
function according to their nature and importance. The basic or major functions are those which
are essential for the organization. In a manufacturing organization like United Electrical
Industries, basic functions are production and marketing. If a manager feels that his span of
management is too wide to manage effectively, which invariably happens in large organization,
several department are created on the basis of dividing a basic function into sub-function. For
example, marketing may be subdivided into marketing research, advertising, sale and so on. Thus
the process of functional differentiation may continue through successive levels in the
organization.
Apart from basic and secondary functions, departments are also created to take
advantages of specialization and to support basic and secondary activities. Such department may
be finance accounting personnel, industrial relations etc. These departments may be created and
placed according to their role in the organization.
A BOD constituted by the Governement of Kerala manages the company. The management of
the company is vested with the Secretary of Taxes, Government of Kerala as its chairman. The
other members on board are:
Chairman of KSEB
Unless otherwise determined by the Government. According to the instruction from the
Government the no. of directors should not be less than 2 and not more than 9. The government
appoints all the directors including the full time Director. However the Directions need not be
share holders. The Government and the full time appointed MD will select one among the
Director for this purpose.
R & D Procurement
Establishment
sales masrketing
Production Maintenance
Quality
&
Assurance
Personnel
Accounts
and
Costing
2. MARKETING DEPARTMENT
UNILEC has a separate marketing department for the
marketing of new products. It is the duty of this department to explore new markets for the
company products. Within one year the company will start production of transformers. UEIL
launched water meters on July 2008. The UEIL has already healed discussion with the 14 Kerala
Water Authority (KWA) cooperative e societies for a tie up to market the product.
3. PRODUCTION DEPARTMENT
Production department is the department which looks after the production of the
company.
The various products of UEI are:
1. Energy Meters
2. Oil Immersed AC Motor Starters.
3. Air break Switches.
4. Water Meters.
All Units of UEL are ISO 9001 certified. Certification Agency BVQI (by Bureau
VERITAS Quality International.
Objectives:
The primary objective is to ensure availability of competent and willing work force to the
organization
.
To maintain good relationship between employer and employee.
Assistant
Assistant (Time
(Establishment)
Office)
Officer Personnel
Establishment & Time
Office
Assistant
1.
Manpower Planning
One essential requirement of every manager is his ability to plan because
responsibility for planning extends to every function. It follows that planning for manpower
resources is a major managerial responsibility to ensure adequate supply of personnel at the right
time both in terms of their quality and aptitude and effective utilization these personnel.
Manpower planning involves two stages. The first stage is concerned with the detailed of
planning manpower requirements for all types and levels of employees throughout the period of
the plan and the second stage is concerned with planning of manpower supplies to provide the
organization with the right types of people from all sources to meet the planned requirements
But for last some year demand for the product is steady because of Government policy.
To reduce the loss, the company followed a lean structure policy. It decreased the size of the
company by adopting a Voluntary Retirement Scheme.
.2. Recruitment, Training and Development:
The UNILEC is a Government company, It has to adhere to the Government policies in
recruitment and selection. While vacancies through internal sources can be filled up either
through promotion or transfer, recruiters tend to focus their attention on outside sources. In
UNILEC, public employment agencies are utilized for filling up different positions.
Apart from these, apprenticeship trainees are also there. These people are recruited with
the help of Related Insertion Centre (for ITI diploma holders), Supervisory Development Board
(for Diploma and B. Tech people).
For the development of the employees the UNILEC provide various training and
developmental activities.
Training plays the following roles in an organization:
1. Increase the efficiency
2. Increase the morale of employees
3. Better human relations
4. Reduced supervision
5. Increased organizational viability and flexibility.
The company follows executive development programs as well as workers training. The
concerned manager or supervisor informs the personal department if there arise a need for
training & development. If the program can be conducted with the internal faculty, it is thus
organized and if there need more expert training and development, exteternal faculties are used.
It is decided by the HR department. The duration is also decided as per the report of manager or
supervisor. The external training is given with the help of Kerala State Productivity Council &
Workers Education Centre. The evaluation is done on the basis of feedback from the trainers.
Also, a shop floor evaluation is also done. If the training results are not satisfactory, retraining
programs are conducted
EMPLOYEE PROFILE
Designation
Number
On deputation /long
Total
leave
Manager
Officers office
Officers factory
Staff office
14
1on deputation/1 on
long leave
16
Staff factory
CH/INSP
A Grade
48
3 0n dept/1 0n long
leave
52
B Grade
12
12
C Grade
Lascars
26
26
134
4 on dept/2 on long
leave.
140
Total
3. Performance Appraisal
Performance appraisal refers to the systematic evaluation of the individual with
respect to his performance on the job and his potential for development. Performance appraisal is
concerned with determining the differences among he employees working in the organization.
In UNILEC, the concerned supervisor or manager continuously appraise the
performance of the employees under him/her. The company follows a confidential report
method. In this method, each employee is rated confidentially by one or more senior officers for
his performance. A confidential report by immediate supervisor is still a major determinant of the
subordinates promotion or transfer. This report deals with the years work and general opinion
of the rater towards the employee. The main problem with this method is that it is not data based
and the appraisal is done on the basis of impressions
4. Compensation
The remuneration, incentives and other compensation packages are fixed on the basis of a
long term agreement made between the company and employees. In every four years, a meeting
of trade union representatives, labour commission representatives and management is called
upon to decide on the package.
Objectives of wage and salary administration:
1. Attract and retain the services of desirable employees.
2. Get improved employee moral and productivity.
3. Pay employees according to the importance and difficulty of the job.
4. Incorporate legal requirements.
5. Simplify collective bargaining.
6. Reward employees according to the effect and merit.
5. Fringe Benefits
The fridge benefits are primarily the means in the direction of ensuing, maintaining
and increasing the income of the employees. These fringe benefits can be monetary as well as in
non monetary sense and are given to the employees during and post employment period which
are connected with the employment but not the employees contributions to the organization. The
following are the type of fringe benefits offered by the company.
The Fringe benefits includes: Bonus, Anniversary awards, Public holidays, Medical leave with
Pay, ESI scheme, Canteens, Gratuity etc.
ii.
Absence occurs whenever a person chooses to allocate time to activities that compete
with scheduled work either to satisfy
An individuals lack of physical presence at a given location and time when there is a
social expectation for him or her to be there. (Martocchio & Harrison, 1993)
iv.
v.
TYPES OF ABSENTEEISM
There are two types of absenteeism, each of which requires a different type of approach.
1. Innocent Absenteeism
Innocent absenteeism refers to employees who are absent for reasons beyond their control; like
sickness and injury. Innocent absenteeism is not culpable which means that it is blameless. In a
labour relations context this means that it cannot be remedied or treated by disciplinary
measures.
2. Culpable Absenteeism
Culpable absenteeism refers to employees who are absent without authorization for reasons
which are within their control. For instance, an employee who is on sick leave even though
he/she is not sick, and it can be proven that the employee was not sick, is guilty of culpable
absenteeism.
Initial Counselling
Presuming you have communicated attendance expectations generally and have already
identified an employee as a problem, you will have met with him or her as part of your
attendance program and you should now continue to monitor the effect of these efforts on his or
her attendance.
If the absences are intermittent, meet with the employee each time he/she returns to work. If
absence is prolonged, keep in touch with the employee regularly and stay updated on the status
of his/her condition. (Indicate your willingness to assist.)
You may require the employee to provide you with regular medical assessments. This will enable
you to judge whether or not there is any likelihood of the employee providing regular attendance
in future. Regular medical assessments will also give you an idea of what steps the employee is
taking to seek medical or other assistance. Formal meetings in which verbal warnings are given
should be given as appropriate and documented. If no improvement occurs written warning may
be necessary.
Written Counselling
If the absences persist, you should meet with the
employee formally and provide him/her with a letter of concern. If the absenteeism still
continues to persist then the employee should be given a second letter of concern during another
formal meeting. This letter would be stronger worded in that it would warn the employee that
unless attendance improves, termination may be necessary.
Discharge
Only when all the previously noted needs and conditions have been met and everything has been
done to accommodate the employee can termination be considered. An Arbitrator would consider
the following in ruling on an innocent absenteeism dismissal case.
Has the employee done everything possible to regain their health and return to work?
Has the employer provided every assistance possible? (i.e. counselling, support, time off.)
Has the employer informed the employee of the unworkable situation resulting from their
sickness?
Has the employer attempted to accommodate the employee by offering a more suitable position
(if available) or a reduction of hours?
Has enough time elapsed to allow for every possible chance of recovery?
Has the employer treated the employee prejudicially in any way?
As is evident, a great deal of time and effort must elapse before dismissal can take place.
These points would be used to substantiate or disprove the following two fold test.
The absences must be shown to be clearly excessive.
It must be proven that the employee will be unable to attend work on a regular basis in the future.
Discharge
Verbal Warning
Formally meet with the employee and explain that income
protection is to be used only when an employee is legitimately ill. Advise the employee that
his/her attendance record must improve and be maintained at an improved level or further
disciplinary action will result. Offer any counselling or guidance as is appropriate. Give further
verbal warnings as required. Review the employee's income protection records at regular
intervals. Where a marked improvement has been shown, commend the employee. Where there
is no improvement a written warning should be issued.
Written Warning
Interview the employee again. Show him/her the statistics
and point out that there has been no noticeable (or sufficient) improvement. Listen to the
employee to see if there is a valid reason and offer any assistance you can. If no satisfactory
explanation is given, advise the employee that he/she will be given a written warning. Be
specific in your discussion with him/her and in the counselling memorandum as to the type of
action to be taken and when it will be taken if the record does not improve. As soon as possible
after this meeting provide the employee personally with the written warning and place a copy of
his/her file. The written warning should identify any noticeable pattern
If the amount and/or pattern continues, the next step in progressive discipline may be a second,
stronger written warning. Your decision to provide a second written warning as an alternative to
proceeding to a higher level of discipline (i.e. suspension) will depend on a number of factors.
Such factors are, the severity of the problem, the credibility of the employee's explanations, the
employee's general work performance and length of service.
THEORIES OF ABSENTEEISM
Absence behaviour is discussed in terms of theories on absences such as the notion of the
informal contract, perceived inequity, and withdrawal from stressful work situations, dynamic
conflict,
social
exchange,
withdrawal,
non-attendance,
organizationally
excused
Informal Contract
vs.
had tested this kind of hypothesis; producing evidence of a relationship between absences and
perceived fairness of pay, that is, employees feelings about how fairly they had been treated in
regard to their pay levels and promotions.
Dynamic Conflict
The withdrawal explanation offered by Hill and Trist (1962) had
some subsequent influence on theoretical discussions by s (1962) and Knox (1961). Gadourek
(1965) described the latter as dynamic conflict theories. The conflict is located within the
individual, and whether a person stays or withdraws is the result of a complex in incentives and
stresses.
Social Exchange
Chadwick-Jones(1982) presented a case for the theory of
absenteeism that is social, not individual in emphasis. As a first step Chadwick-Jones (1982)
assumed the interdependency of members of work organisations.
individuals do have some mutual obligations to peers, subordinates, and superiors (as well as
other relationships outside the work situation). In this context the rights and duties of individuals
are both subject to, and representative of, a set of rules about activities in the work situation. What
individuals do is therefore likely to be in answer to, on behalf of, in defence of, as well as
achieving a compromise with the rules of the group.
The second assumption made by Chadwick-Jones (1982), is that under the
employment contract, some form of social exchange is taking place between employers and
employees. Whatever they exchange in this situation whether it be their time, effort, or skill or
money, security, congenial friends, or anything else- it will be only what is possible for employees
in the organisation. Exchanges may be conceived as between individuals and work groups, or
between work groups and management, but it would not be realistic to conceive of the exchange
between the individual and the organisation while disregarding the social conditions and rules.
Chadwick-Jones think of social exchange between employees
and employers as developing in, or as revealed by, a pattern of behaviour in the work situation
that includes absences with all the other factors that constitute the contract, formal and informal,
between employers and employees. Formal factors include pay, hours, disciplinary rules, job
duties, and promotion lines. Informal ones include supervisory styles, peer group relations, and
salient to their analysis absence from work. Chadwick-Jones (1982) however, do point out that
absences may not enter into the exchange at all, insofar as some employees or employee groups,
especially those with higher status supervisors in factories, managers in banks are absent very
little or hardly at all. It is quite possible, however, that managers possess greater control over the
allocation of their working time and may take periods of time out that are not recorded.
Withdrawal
According to Chadwick-Jones (1982), absence from work, where work is
defined by the employees presence at a particular location (office or workshop) for a fixed period
each day, can be interpreted as an individual act of choice between alternative activities; as
withdrawal or escape from surveillance; as individual or group resistance to an inflexible system.
Thus, absence may also be viewed as a stratagem in inter-group relations, as a defensive or
aggressive act in inter-group conflict (Chadwick-Jones et al., 1982). For the purpose of this
research this theory has relevance, as the reasons for absence behaviour could be related to a
Non-attendance
Another definition of absenteeism refers to the non-attendance of
employees for scheduled work (Gibons, 1966; Johns, 1978; Jones, 1971).
The definition
distinguishes absenteeism from other forms of non-attendance that are arranged in advanced (e.g.
vacations) and specifically avoids judgements of legitimacy associated with absent events that are
implied by as sick leave. This definitional emphasis seeks to focus on the key organisational
consequences of unscheduled non-attendance instability in the supply of labour to the
organisation resulting in the disruption of scheduled work processes and the loss of under
utilisation of productive capacity (Allen, 1981; Jones, 1971, Nicholson, 1977). For this research
this definition will be applicable, as the researcher will not take into account absences due to
vacation leave and sick leave taken over more than three days.
beyond the employees immediate control. Hence, voluntary rather than involuntary absences
from work may reflect job dissatisfaction and lack of commitment to the organization.
A four-category taxonomy
Blau and Boal (1987) presented a four-category taxonomy describing the
meanings of absence. These categories are medical, career enhancing, normative and calculative.
In the medical category , absence is viewed as a response to various infrequent and uncontrollable
events (illness, injury, fatigue, and family demands). If such an absence (medical) occurred, it
probably would be operationalised as a sporadically occurring excused absence (Blau & Boal,
1987). In the career-enhancing category , absence is depicted as a mechanism that gives the
employee a further choice to pursue task- and career-related goals.
For the normative category , absence is viewed less as a motivated behaviour and
more as a habitual response to the norms of the work group (organisation) regarding absence
(Blau & Boal, 1987).
consistently occurring excused absence. More importantly, rather than absenteeism appearing as
a random walk, as with the medical category, definite patterns will emerge. Thus, for this group,
it would be expected not only to predict frequency, but also when absenteeism will happen.
Finally the calculative absence is viewed as a coin of exchange (Blau and Boal,
1987; Johns & Nicholson, 1982) in either fulfilling or modifying the implicit social contract
between the employee and employer, and as a time allocation strategy for enhancing non-work
outcomes. This type of absence would be operationalised in terms of the employee using a certain
number of excused and unexcused absences permitted by the organisation, depending on how
much the employee felt he or she should modify the implicit social contract. It could be predicted
that an extremely apathetic employee (low job involvement and organisational commitment)
would take full advantage by using both kinds of absence. Thus, the absolute frequency and total
number of days absent should be greatest for workers who are the most apathetic.
EFFECTS OF ABSENTEEISM
1. Absenteeism reduces workers earnings and adds to his indebtedness, decrease his
purchasing power. Makes it difficult for him to meet necessities of life, leading to
personal problems, and in many cases loss of employment and resultant disaster for his
dependents.
2. It affects both quantity and quality of production. If more number of workers are absent
the total output is affected. If alternative arrangement is made by employing casual
workers who do not posses adequate experience the quality of goods produced is
affected.
3. It affects the efficiency of workers. The workers who joins after a long period of absence
would normally be much less efficient.
4. It affects the discipline of the workers adversely. The worker who is attending to his work
irregularly may not care much about the discipline.
e. The percentege of abasenteeism is much higher in coal ans mining industries than in
organized industries.
f. Absenteeism in India is seasonal in character.
g. It is the highest during March-April-may, when a land has to be prepared for monsoon
saving, and also in the harvest season, when the rate goes as high as 40 percent.
RESEARCH METHODOLOGY
Research methodology is a way to systematically solve the research problem. It deals with the
objective of a research study, the method of defining the research problem, the type of hypothesis
formulated, the type of data collected, method used for data collecting and analyzing the data etc.
The methodology includes collection of primary and secondary data.
5.1 TYPE OF RESEARCH
DESCRIPTIVE RESEARCH
The study follows descriptive research method. Descriptive studies aims at portraying
accurately the characteristics of a particular group or situation. Descriptive research is concerned
with describing the characteristics of a particular individual or a group. Here the researcher
attempts to present the existing facts by collecting data.
Secondary data were collected from the companys annual publications, memorandums
of settlements, newspapers, journals, websites, and from library books
Due to time constraints and busy schedules of the nurses it was difficult to
interact with them completely.
The sample size was limited to 60
The responses may be influenced by personal bias.
Generally do not provide in-depth understanding of underlying issues,
reasons or behavior patterns.
Incorrectly designed surveys may produce invalid and misleading results.
1. Age
Parameters
No: of
Respondents
Percentage
20-30
15
30-40
18
30
40-50
18
30
More than 50
15
25
Total
60
100
AGE GROUP
No: of Respondents
30
Percentage
30
25
18
18
15
15
20-30
30-40
40-50
More than 50
INFERENCE
It has been inferred that 30% of the employees who participated in the survey are of age
group between 30-40 , 30% again come under the category between 40-50 age group and
the rest of them belong to more than 50 (25%) and 20-30(15%) types.
2. SEX
Parameters
No: of
Respondents
Percentage
Male
42
70
Female
18
30
Total
60
100
SEX
No: of Respondents
Percentage
70
42
30
18
male
Female
INFERENCE
It has been inferred that 70% of the employees participated in the survey are male and the
remaining come under the female category.
3. MARITAL STATUS
Parameters
No: of Respondents
Percentage
Single
15
Married
42
70
Divorced
Separated
Widow(er)
10
Total
60
100
MARITAL STATUS
No: of Respondents
70
Percentage
42
15
9
3
Single
Maried
Divorced
Separated
0 0
10
Widow(er)
INFERENCE
It has been inferred that 70% of the employees who participated in the survey are married
and 15% of respondents are bachelors. Rest of them are categorized under the category of
widow and divorce cases.
4 Employee able to communicate their feelings for others
Parameters
No: of Respondents
Percentage
Always
10
Very often
15
25
Often
20
33.33
Rarely
10
16.67
Never
15
Total
60
100
Percentage
33.33
25
20
16.67
15
10
10
15
9
always
Very often
Often
Rarely
Never
INFERENCE
It has been inferred that 33% of employees have an opinion that they can communicate
their feelings to others often, 25% feels it very often. Also we can infer that 17% of the
employees rate it as rarely and 15% of them never had any such feelings, but 10% of them
feel always free enough to communicate with others.
5. Employees - forthright, frank and willingness to stand up for his
rights.
Parameters
No: of Respondents
Percentage
Always
12
20
Frequently
27
45
Occasionally
13
21.67
Rarely
8.33
Never
Total
60
100
Percentage
27
21.67
20
13
12
always
Frequently
Occasionaly
8.33
Rarely
Never
INFERENCE
It has been inferred that 45% of respondents frequently stand up for their rights, 21%
stands for it occasionally. Also we can infer that 20% of the employees always stand up for
their rights and 8% of them are rare, but 5% of them ignore such views.
Parameters
Highly Satisfied
Satisfied
Neutral
Dissatisfied
Highly Dissatisfied
Total
No: of Respondents
4
12
23
18
3
60
Percentage
6.67
20
38.33
30
5
100
20
18
12
4
6.67
INFERENCE
It has been inferred that 38% of employees have neutral opinion on job satisfaction, 30%
are dissatisfied. Also we can infer that 20% of the employees are satisfied and 7% of them
are highly satisfied, but 5% of them experience high level of dissatisfaction.
Parameters
Strongly Agree
Agree
Neutral
Disagree
Strongly Disagree
Total
No: of Respondents
10
30
14
5
1
60
Percentage
16.67
50
23.33
8.33
1.67
100
Perentage
30
23.33
16.67
10
14
5
8.33
1 1.67
INFERENCE
It has been inferred that 50% of respondents agree that stress is part of their work life,
23% of them view it to be neutral. Also we can infer that, 16% of the employees strongly
agree and 8% of them disagree but 2% of them strongly disagree.
Parameters
No: of Respondents
Percentage
Strongly Agree
16
26.67
Agree
26
43.33
Neutral
12
20
Disagree
8.33
Strongly Disagree
1.67
Total
60
100
Percentage
43.33
26.67
26
20
16
12
8.33
5
1 1.67
Strongly Agree
Agree
Neutral
Disagree
Strongly Disagree
INFERENCE
It has been inferred that, 43.33% feel that their work is heavy and tiresome and 26.67%
strongly agree that their work is heavy or tiresome, 20% of their view is neutral,8%
disagree and 2% strongly disagree.
9. Loneliness while working with others
parameters
always
Frequently
Sometimes
Rarely
Never
Total
No: of Respondents
7
23
19
9
2
60
Percentage
11.67
38.33
31.67
15
3.33
100
Percentage
38.33
31.67
23
19
15
11.67
2 3.33
always
Frequently
Sometimes
Rarely
Never
INFERENCE
It has been inferred that 38% of respondents frequently feel lonesome while working with
others, 32% feel it sometimes and also we can infer that 15% of them feel it rarely,
12%always and 3% never felt so.
parameters
No: of Respondents
Percentage
Strongly Agree
15
Agree
23
38.33
Neutral
16
26.67
Disagree
10
16.67
Strongly Disagree
3.33
Total
60
100
26.67
23
15
Percentage
16
16.67
10
2 3.33
INFERENCE
It has been inferred that 38% of respondents agree that they feel bored when engaged in
their routine work, 27% of their view is neutral and also we can infer that 17% disagree,
15%strongly agree and 3% strongly disagree.
parameters
Highly Satisfied
Satisfied
Neutral
Dissatisfied
Highly Dissatisfied
Total
No: of Respondents
2
21
21
10
6
60
Percentage
3.33
35
35
16.67
10
100
21
16.67
10
2 3.33
10
INFERENCE
It has been inferred that 35% of respondents are satisfied with the existing working
condition, 35% seems to be neutral. Also we can infer that 17% are dissatisfied and 10%
are highly dissatisfied. Only 3% are highly satisfied employees.
Parameters
No: of Respondents
Percentage
Always
10
Frequently
18
30
Sometimes
11
18.33
Rarely
12
20
Never
13
21.67
Total
60
100
18
20
18.33
11
10
Percentage
12
21.67
13
always
Frequently
Sometimes
Rarely
Never
INFERENCE
It has been inferred that 30% of respondents frequently get time to do things that are really
important for them, 22% dont agree with this. Also we can infer that 20% who agree are
rare cases and 18% only sometimes. 10% have enough time to deviate for their personal
activities.
13. Satisfied with the welfare measures
Parameter
Highly Satisfied
Satisfied
Neutral
Dissatisfied
Highly Dissatisfied
Total
No: of Respondents
3
15
13
24
5
60
Percentage
5
25
21.67
40
8.33
100
Percentage
40
21.67
13
24
8.33
INFERENCE
It has been inferred that 40% of respondents are dissatisfied with the welfare measures
adopted by the company, 25% are satisfied and also we can infer that 22% seems to be
neutral, 8% are highly dissatisfied and 5% are highly satisfied.
Parameter
No: of Respondents
Percentage
Very Often
Sometimes
18
30
Rarely
31
51.67
No
13.33
Total
60
100
HEALTH PROBLEMS
No: of Respondents
Percentage
51.67
30
31
18
3
13.33
8
Very Often
Sometimes
Rarely
No
INFERENCE
It has been inferred that 52% of respondent have the opinion that sickness makes them
absent from work rarely, 30% says from time to time and also we can infer that 22% says
sickness alone does not make them absent from work. 5% very often are absent due to
health problems.
FINDINGS
On analysing the response it is found that, 35% of the employees are dissatisfied with their
work.
50% of the employees have an opinion that stress is part of their work life.
43% agree and 27% strongly agree that their work is heavy. From this, it can be
It has been found that 40% of the respondents have an opinion that politics have no impact
on the employee absenteeism.
60% of the employees feel that their colleagues did not help them in case of personal
problems.
SUGGESTIONS
The management must intervene in the day to day activities of the employees. They
should provide full-fledged support, guidance and encouragement.
The management must provide training programme to the employees at a frequent basis.
This will help them to enhance their skill and improve their existing performance. The
management must further, scrutinize the response of the employees after the
implementation of the training programme.
Overloaded workaholic atmosphere must be avoided, as it may create a lot of stressrelated problems.
Employees must be encouraged for their creativity and innovative outlook towards their
job assigned.
Welfare measures of the employees should be improved so as to make the employees feel
more satisfied and contended. A satisfied employee will be more committed to the
organization.
Medi-claim policies, weekly or monthly medical checkups etc should be provided to the
employees in order to make them physically fit for the job.
The employees should either be provided with transportation facility or housing facility
so that they would have ample time for recreation in substitute for the time they spend in
traveling.
The management should take necessary action to strengthen the relationship between the
employees.
CONCLUSION
United Electrical Industries Ltd. being one of the reputed electronic meter manufacturing
companies in India is also a victim of absenteeism, as one of the curse their organization is
facing at present. The study tries to reveal the factors influencing the absenteeism of employees
with some suggestions which will be of immense aid for the employees as well as the
organization to reduce the absenteeism level. I earnestly desire that, the study might bring some
descend in the number of absentees in the organization, if taken into consideration practically.
To conclude, employees dissatisfaction towards job & welfare measures, hectic
work schedule, stress, health problems are some of the major causes of absenteeism. This can be
reduced by the management by implementing various employee satisfactory changes in the
organization. People are the major assets of any organization and taking care of their welfare and
satisfaction is their duty as a whole apart from earning profit. As work environment is becoming
more challenging and complex, the management must also see through it that, it is capable of
managing and bringing in changes at the same pace so as to survive in this competitive scenario.
BIBLIOGRAPHY
K.ASWATHAPPA, Human resource and Personnel Management, Tata Mc Graw Hilll, 2003.
REDDY P.N and GULSHAN S.S, Principles Business Organizational Management, Eurasia
http://www.unilecindia.com/
http://www.tau.ac.il
http://etd.unisa.ac.za/ETD-db
www.trainingspotting.com/
NAME :
1. Age
20-30
More Than
2. Sex
30-40
40-50
:
Male
Female
3. Marital status
Single
Married
Living together
Divorced
Separated
Widow(er)
Very often
Often
Never
5. I am forthright, frank and willing to stand up for my rights
Rarely
Always
Frequently
Rarely
Never
Occasionally
Satisfied
Neutral
Dissatisfied
Highly Dissatisfied
7. Stress is a part of my work life
Strongly agree
Agree
Disagree
Neutral
Strongly Disagree
Agree
Disagree
Neutral
Strongly Disagree
Frequently
Sometimes
Rarely
Never
Agree
Disagree
Neutral
Strongly Disagree
Satisfied
Neutral
Dissatisfied
Highly Dissatisfied
12. Do you have time to do things that are really important for you?
Always
Frequently
Sometimes
Rarely
13. Are you satisfied with the welfare measures adopted by the company?
Highly Satisfied
Satisfied
Neutral
Highly Dissatisfied
14. Does sickness makes you absent from work?
Dissatisfied
Never
Very often
sometimes
very seldom
No
15. Does any of the political or social engagement force make you absent from work?
Very often
sometimes
very seldom
No
16. Does the habit of alcoholism make you absent from work?
Often
Very often
Sometimes
Very seldom
No
No To some extent
18. Are you afraid of any occupational hazards which prompt you to take leave?
Yes
No