paving equipments
1. asphalt batching plant 2. asphalt drum mixing plant 3. mobile
asphalt mixing plant 4. continuous asphalt mixing plan
3) Drum mixer
7) Control van
without dismantling the parts connection, achieve rapid relocation transitions. Installation again,
just use quick line to contact "distributed" power distribution cabinet with total control room)
6.Twin-shaft asphalt mixer owns high mixing efficiency and low consumption, no mixing blind
angle. High wear-resisting scale board, blade and mixing arm greatly reduce replacement of
wearing parts and lower the cost.
7.High strength double bridge bearing suspension, greatly assure the through capacity of various
kinds of road surface. 8 tires provide powerful support and ground friction.
8.Through a lifting installation, the main building of ZAP-M series asphalt mixing station has
become the main building of classic batch asphalt mixing station. Its use, operation and
maintenance are the same with classic batch asphalt mixing station.
as
it
dries
and
mixes
the
material
at
the
same
time.
Since there are no mixing tower or elevators, the system is therefore considerably simplified, with a
consequent
reduction
in
the
cost
of
maintenance.
The absence of the screen however makes it necessary to have precise controls at the beginning of
the production cycle, before the aggregates are fed into the dryer and before they are consequently
discharged from the dryer as asphalt.
in continuous plants the length of the mixing action must necessarily stay constant.
Continuous Plants where low operational costs and continual production are essential, of course
if you have constant quality in the aggregates..
Powder system 1.The powder silo is equipped with dust filter device(silo
top dust filter).
2.The powder silo is equipped with high and low indicator.
3.The screw conveyor adopts the design of varying-pitch an ti-block.
4.High-reliability weighing sensors.
5.Weighing screw conveyor adopts frequency converting control.
DISTRIBUTORS
A distributor is used to apply liquid asphalt material such as prime and tack coats to surfaces to be
paved. The distributor consists of an insulated tank mounted on a truck or trailer. A power-driven
pump forces the asphalt through a system of spray bars and nozzles onto the construction surface. A
burner, usually oil-fired with flues within the tank, is used to heat the asphalt to the proper
application temperature. The major units for a typical distributor are indicated in below Figure.
The distributor is required to:
1) Maintain the liquid asphalt at a
uniform temperature
2) Apply material at a uniform rate
3) Apply material at variable widths
The distributor is required to be
equipped with:
1) A tachometer (Bitumeter) to
measure the speed during
applications
2) Pressure gauges
3) Accurate volume measuring
gauges or a calibrated tank
4) A thermometer for measuring
temperatures
Asphalt Pavers
Hopper
Function: Receive Hot
Mix Asphalt (HMA) from
hauling trucks
Operational
Consideration:
Intermediate stops waiting
for truck loads negatively
impacts the smoothness of
the mat surface, as such ;
Integral or attachable
Windrow Pickup
Elevators are available for continuous hopper loading operations, for a given paving stretch
Material Transfer Devices are also available to receive multiple truckloads of HMA, remix and
deliver to the hopper.
Conveyor Auger
Conveyor: Move the mix
through a
tunnel under the
engine to the auger at the rear
end
Screed
Function: Control the HMA width and depth
Provides Initial mat finishing and compaction
the conveyor
paved
and
spreads
it