Volume Calculations
Stratigraphic
Modeling
Interface
Studio
Pillar Gridding
Fault Modeling
3D Grid
Construction
Structural
Framework
3D Grid
Construction
Structural Gridding
Property Modeling
Well Log
Upscale
Facies &
Petrophysical
Modeling
Make Horizons
Zones & Layering
Make contacts &
Volume Calculation
Workflow Editor
Intro to Petrel
Introduction
Make Contacts/Volumetrics
Objectives
Define fluid contacts
Visualize fluid contacts
Create a fluid contact property
Principles of Volume Calculation
Make Contacts
Volumetrics
Visualize Contacts
1. After running the Make contacts process, the new contact set is stored in a
Fluid Contacts folder in the 3D grid.
2. Click the Style tab under Settings for the Fluid Contacts folder
to control visualization settings.
Note: It is possible to convert contacts to surfaces and point sets stored in the Input pane.
Make Contacts/Volumetrics:
Volume Calculation Objectives
Principles of Volume Calculation
Triangulation and Exact Volume calculation
Cases pane and Results pane,
Create a new case using these inputs:
Contacts and General properties
Oil and Gas properties
Filters and well boundaries,
Create and use outputs
Volume properties
Reports
Volume maps.
Volume Calculations
The Volume calculation process accurately calculates the various volumes
(bulk, pore, and fluid) in a 3D grid.
Data you can use:
Boundary, license block
Zones, Segments
Properties (Net/Gross, porosity, Sw)
Constants (Bo, Bg, Rs, Rv)
Contacts (GOC, OWC, GWC)
Recovery factors (REC).
Exact volume calculation
Each side of the cell is triangulated. Cells are split exactly where they are cut.
Results Pane
Acts as a filter for outputs of the Volume Calculation.
Standard parameters are calculated for all volume
calculations if the appropriate input is supplied.
Note: Simulation cases also are stored in the Cases and Results panes.
5.2
5.1
Generate a Report
1. Filter settings are stored in the Results
pane. Right-click on the Volumetric folder
> Settings.
or save
it
EXERCISE