Anda di halaman 1dari 16

AE-1/AE/EDC

Prof. FAIZ RANGARI


-8976530729

Exam Questions [EQ]

Module 1: Diodes and its Applications


June
2015

Dec 2014

1. Compare Clipper and Clamper Circuits.

05

1. Write down current equation of Diode and explain significance of 04


each parameters.
2. Draw a required diode clamper circuit to generate the output V o
to from the input V1 as shown in the figure, If
i. V= 0V
ii. V=0.7V where V is cutin voltage of diode.
10

June
2014

3. Write short note on construction and operation of photodiode.

05

1. Explain effect of temperature on characteristics of PN junction 04


diode.
2. Write short note on series and shunt clippers.
07
Dec 2013

3. Write short on construction and operation of varactor diode.

07

1. Draw switching characteristics of a diode and explain reverse 04


recovery time. Faiz Rangari - 8976530729
2.
04

1|Page

AE-1/AE/EDC

Prof. FAIZ RANGARI


-8976530729

Exam Questions [EQ]

Obtain output for the clipper shown in the figure. If a sine wave
of 15sinwt is applied as an input. Assume practical diode with
suitable cutin voltage.

3. Write short note on small signal model of diode.

05

4. Write short note on Construction and operation of schottkey 05


diode.
June
2015

Module 2: Field Effect Transistors


Faiz Rangari - 8976530729

1. Compare Depletion and Enhancement type MOSFET.

Dec
2014

June
2014

Dec
2013

05

2. Explain the basic operation and characteristics of n-channel 10


enhancement type MOSFET.
3. Write short note on Energy Band diagram of MOS capacitor. 05
1. Explain the working of n-channel EMOSFET with the help of
output characteristics, showing clearly effect of channel length 10
modulation. Give equation of drain current in linear and
saturation region along with conditions.
2. Write short note on MOS capacitor.
05
1. Draw and explain energy band diagram of MOS capacitor in 10
accumulation, depletion and inversion region.
2. Write short note in MOSFET operation.
07
1. Draw energy band diagram of MOS capacitor in accumulation, 04
depletion and inversion region for p-substrate.
2. Write short note on regions of operation of FET.
05
2|Page

AE-1/AE/EDC

Prof. FAIZ RANGARI


-8976530729

Exam Questions [EQ]

June
2013

Dec
2012

1. Explain EMOSFET.

05

1. Explain graphical determination of FET parameters.

05

2. Explain with the help of neat diagram the structure of a NChannel FET, and its volt-ampere characteristics. In what way it 10
is different from BJT.

2. Explain transfer characteristics of JFET.

05

Module 3: DC Analysis of Transistor Circuits


June 2015
1. Transistor is current controlled device while FET is voltage
controlled device. Justify.
2. Define Stability factor. Derive the equation for Stability factor.
State which biasing technique is more suitable. Justify your
answer.
3. For a NPN transistor in CE mode voltage divider configuration
determine Vc and Vb. Given Vcc= +20V, VEE= -20V, R1= 8.2K,R2=
2.2 K, Rc= 2.7 K, RE= 1.8 K, C1=C2= 10F and = 120.
4. Write short note on Biasing of JFET for Zero Temperature Drift.
5. Write short note on DC load line and significance of Q point.

6. Determine IDQ, VGSQ, VD and VS for the network shown below.

05
10
10
05
05

10

3|Page

AE-1/AE/EDC

Prof. FAIZ RANGARI


-8976530729

Exam Questions [EQ]

Dec 2014
1. The PNP transistor shown on figure has = 50. Find the value of
Rc to obtain Vc= +5V. What happen when transistor is replaced
with another transistor having = 100.
04

Faiz Rangari - 8976530729

2. Why Common Collector amplifier is used as buffer? Why Buffers 04


are required.
3. For the circuit shown on figure. Find IDS and VDS if VRS= 1.5V.
04

4. Design JFET circuit with voltage divider biasing as shown in


figure with JFET parameters IDSS= 12mA, VP= -3.5V and = 0. Let
R1+R2= 100K, IDSQ= 5mA and VDSQ= 5V.
10

4|Page

AE-1/AE/EDC

Prof. FAIZ RANGARI


-8976530729

Exam Questions [EQ]

5. For the circuit shown in figure, assume =100.


10
i. Find thevenins equivalent voltage Vth and resistance
Rth for base circuit.
ii. Determine ICQ and VCEQ

June 2014

6. What are different biasing techniques used to bias D-MOSFET


and E-MOSFET. Explain with the help of appropriate circuit 10
diagrams.
1. Find RB and Rc for the circuit shown to obtain VCE= 5V and Ic= 04
2mA
2. In n-channel MOSFET VDS= 5V, VGS= 5V, VBS= 0, W=10m,
04
L=5m, kn= 100mA/V2 and VTO= 1V. Calculate its drain current
for channel length modulation factor of 0 and 0.25V-1.
3. Differentiate between BJT and MOSFET.
04
4. Find ICQ and VCEQ for the circuit shown in figure if =100.

10

5|Page

AE-1/AE/EDC

Prof. FAIZ RANGARI


-8976530729

Exam Questions [EQ]

5. The JFET shown in the figure has parameters IDSS= 8mA and Vp=
-4V. Determine VG, IDSQ, VDSQ and VGSQ.
10

Dec 2013
1.
04

Faiz Rangari - 8976530729

Draw the DC load line for the above circuit.

2. Obtain IDQ , VDSQ, VGSQ graphically.

08
3. Derive the expression for Threshold voltage foe Enhancement 10
type N-channel MOSFET.

4.

10

Determine IB, Ic, VCE, and VBE and also SICO for the biasing circuit

6|Page

AE-1/AE/EDC

Prof. FAIZ RANGARI


-8976530729

Exam Questions [EQ]

shown in figure.

5. Explain graphical method to obtain parameters of CE 10


configuration.
6. Calculate IDQ , VDSQ, VGSQ
05

June
2013
1.

For the circuit shown in the figure the JFET parameters are I DSS=
5mA, Vp= -4V

10

Determine the following with ID= 2mA and VDS= 6V


i.
ii.
iii.
iv.
v.

RD
Rs
VD
Vs
VRD

7|Page

AE-1/AE/EDC

Prof. FAIZ RANGARI


-8976530729

Exam Questions [EQ]

2. A CE BJT amplifier is shown in the figure with VCE= 12V, Ic=


2mA, Stability factor 5.1, Vcc= 24V, VBE= 0.7V, = 50 and Rc=
4.7K.
Determine the value of resistors RE, R1 and R2 (Hint: R2= 0.1RE)

10

3.

10
For the network of figure with RD= 2K, RG= 10M and
VDD=12V.
Determine the following
i.
ii.

IDQ
VDSQ

8|Page

AE-1/AE/EDC

Prof. FAIZ RANGARI


-8976530729

Exam Questions [EQ]

Dec 2012
1. Explain BJT as a switch.

05

2. Discuss using the concept of load line superimposed on the


transistor characteristics. How a simple CE circuit can amplify a 10
time varying signal.
3. The following parameters are obtained from certain JFET
datasheet: VGSoff= -8V and IDSS= 5mA. Determine the values of ID,
10
for each value of VGS ranging from 0 to -8 Vin 1V steps. Plot the
transfer characteristics curve for the same data.
4. Explain output characteristics of CE BJT voltage amplifier.

05

Module 4: Small Signal Analysis of BJT Amplifiers


June
2015
1. Derive the equations for Av, Ai, Ri and Ro for a NPN transistor in 10
CE mode voltage divider bias configuration with RE unbypassed.
2. For the network given below determine Zi, Zo and Av.
10

3. Determine Zi, Zo and Av for the circuit shown below.


10

9|Page

AE-1/AE/EDC

Dec 2014

Prof. FAIZ RANGARI


-8976530729

Exam Questions [EQ]

4. Write short note on Small signal equivalent circuit of CC 05


amplifier.
1. Draw circuit diagram of CE amplifier with voltage divider bias
with bypassed emitter resistance and derive expression for
voltage gain, current gain, input resistance and output resistance 10
using Hybrid- model which includes early effect.
2. Write short note on Hybrid- model of BJT.

June
2014

05

3. Write short note on AC and DC load line.

05

1. Draw and explain small signal hybrid-Pi model of BJT including


04
early effect.
2. The parameters of the transistors in the circuit shown in the
figure are = 100 and VA= 100V.
i. Determine the DC voltage at base and emitter terminals
ii. Find Rc such that VCEQ= 3.5V and
iii. Assuming Cc and CE as short circuit, determine small
signal voltage gain Av=Vo/Vs.

10

10 | P a g e

AE-1/AE/EDC

Prof. FAIZ RANGARI


-8976530729

Exam Questions [EQ]

3. For the common base amplifier shown in the figure, derive the
expression for voltage gain, current gain, input resistance and
output resistance using hybrid- model.
10

Dec 2013
1. Compare CB, CC and CE configuration.

2. Determine Ri, Ro, Av and gm for the amplifier circuit shown in


figure.

04

10

3. Determine Hybrid- parameters.


05

4. Write short note on Hybrid- model of BJT.

05

11 | P a g e

AE-1/AE/EDC

Prof. FAIZ RANGARI


-8976530729

Exam Questions [EQ]

June
2013
1. Design a single stage RC coupled CE audio frequency amplifier
employing BC147B BJT to satisfy the following conditions.
, SICO 10, Load resistor RL= 10K and output 15
voltage Vo= 3V.

Dec 2012

2. For the designed amplifier in above question determine,


expected voltage gain, input impedance, output impedance and 05
current supplied by source voltage VCC.
1. Design for supply voltage Vcc, collector resistor Rc,emitter
resistor RE, voltage divider biasing resistor R1 and R2 of a single
stage RC coupled CE audio amplifier with following conditions.
10
, SICO 10, Load resistor RL= 5K and output
voltage Vo= 3V.

2. For the circuit shown below, determine the following with


and = 100
i. ICQ and IEQ
ii. Input and output impedance
iii. Voltage gain
iv.
Current gain
v.
List advantages of circuit shown

10

Faiz Rangari - 8976530729

12 | P a g e

AE-1/AE/EDC

Prof. FAIZ RANGARI


-8976530729

Exam Questions [EQ]

Module 5: Small Signal Analysis of FET Amplifiers


Dec 2014

June
2014

1. Draw small signal model of JFET and Explain significance of each 04


parameters.
2. In n-channel EMOSFET
i. Substrate Doping NA=1016cm-3
ii. Polysilicon Gate doping ND=1020cm-3
iii. Gate oxide thickness tox= 0.5m
iv.
Oxide positive charge interface density= 4x1010cm-2
10
v.
Charge of electron= 1.6x10-19 col
vi.
Permittivity of free space= 8.85x10-14 F/cm
vii. Dielectric constant of Si= 11.9
viii. Dielectric constant of SiO2= 3.9
Find zero bias threshold voltage(VT0)
1. For the common gate circuit shown in figure, the NMOS
transistors parameters are VTN= 1V, kn= 3mA/V2 and = 0.
i. Determine IDSQ and VDSQ
ii. Calculate gm and ro
iii. Find the small- signal gain Av= Vo/Vi. Assume Cc1 and Cc2
acts as short circuit for small signal analysis.

10

2. Derive expression for voltage gain of NMOS source follower 08


circuit.

13 | P a g e

AE-1/AE/EDC

Prof. FAIZ RANGARI


-8976530729

Exam Questions [EQ]

Dec 2013
1.

04

Obtain gm, ro and Av for the amplifier circuit shown in figure. In


which region the device is operating? Justify.

2.

10
VTN= 1V, Kn= 0.5mA/V2, =0.01V-1

Determine VGSQ and VDSQ

Also calculate voltage gain, input and output resistance

14 | P a g e

AE-1/AE/EDC

Prof. FAIZ RANGARI


-8976530729

Exam Questions [EQ]

June 2013
1. Design single stage RC coupled CS audio frequency amplifier
employing JFET BFW-11 to satisfy the following requirements
IDQ= 0.5IDSS, RL= 120K, VDD=20V and output peak 10
voltage Vo=4.5V.

Dec 2012

2. For the above designed circuit with source resistor R S


unbypassed, determine voltage gain, input impedance, output 10
impedance and output voltage for input voltage of 20VPP.

1. Design single stage RC coupled CS audio frequency amplifier


employing JFET BFW-11 to satisfy the following requirements
IDQ= 3mA, RL= 120K, VDD=20V and output peak 10
voltage Vo=4.5V.

2. For the above designed circuit with source resistor R S


unbypassed, determine voltage gain, input impedance, output 10
impedance and output voltage for input voltage of 20VPP.
3. Determine the small signal voltage gain of a MOSFET circuit
with VGSQ= 2.12V, VDD= 5V, Rd= 2.5K, VTN= 1V, Kn= 0.8mA/V2
and = 0.02V-1. Assume transistor is biased in the saturation
region.

10

15 | P a g e

AE-1/AE/EDC

Prof. FAIZ RANGARI


-8976530729

Exam Questions [EQ]

Module 6: Oscillators
June
2015

Dec
2014

June
2014

Dec
2013

1. Explain barkhausen criteria for sustained oscillations.

05

1. Compare Collpits and Clapps Oscillator.

04

2. Draw a neat circuit diagram of Wien bridge oscillator and derive 10


an expression for its output frequency.
3. Write short note on crystal oscillator.
05

2. Explain the working of Wien Bridge Oscillator. Derive the


10
expression for frequency of oscillation and the value of gain
required for sustained oscillation.
3. Write short note on Twin-T oscillator.
05
1. Why LC oscillators are preferred for high frequency 04
applications?
2. Draw and explain working of transistorized Wien bridge 10
oscillator.
3. Write short note on Twin-T oscillator.
07
1. State and Explain barkhausen criteria for oscillations.

04

2. Derive the expression for frequency of oscillation for a 08


transistorized (BJT) RC phase shift oscillator.
3. Write short note on crystal oscillator.
05

16 | P a g e

Anda mungkin juga menyukai