Anda di halaman 1dari 8

Air / Gas loop free energy generator

The Air - Gas loop free energy generator utilizes the


principles of the strong magnetic field affecting
various gasses at various pressures or vacuum.
Getting the abundant free energy directly from air is
also possible, but it may be complicated because of
relatively high atmospheric pressure (around 1013
hPa, 760 Torr or 29.92 inHg). The higher the pressure,
the higher the electric strength. Air pressure therefore
makes it complicated to ignite the arc and thus to start
the air free energy generator in homemade device.
Air - Gas loop free energy generator is a well-looking
and relatively easy to build type of a free energy
generating device. In recent years the do it yourself
(DIY) prototypes of this topology start to emerge. It
belongs to the gaseous environment principle free
energy generator family. It may operate at very low
pressures (nearly vacuum), but we are still talking
about gases as a free energy generation medium, not
the vacuum itself. This family of generators should not
be confused with the more complex free energy
generators harnessing the energy of the vacuum.
For long time, Air / Gas loop free energy generator
designers faced with the problem of the active gas
ignition. Previously, the air at atmospheric pressure
was usually used as a working gas. There was also a
problem with availability of magnets with enough
magnetic induction (B). As already mentioned, the

problem with getting the free energy from the air with
its high dielectric strength was solved using gas
chambers at much lower pressure. Also the progress
of the magnets contributed to the practical
applicability of this free energy generator topology.
The neodymium magnets or even the new generation
of ferrite magnets offers much better magnetic field
than the alnico or old generation ferrite ones.
Therefore, in last few years, first plans and
schematics of the Air / Gas loop free energy generator
homemade constructions appeared. Unfortunately,
most of them is only accessible for closed
communities. Due to copyright issues it is not
possible to publish them directly, so I had to build the
prototype with some modifications and publish only
the results of my own research. I have built a relatively
small prototype, but it is enough to demonstrate the
principle of this free energy generator kind and to
bring you its plans.
My Air - Gas loop free energy generator is using three
low pressure gas chambers in an infinite loop. Each
chamber is under the infuence of a strong radial
magnetic field generated by permanent magnets. The
chambers are connected together into the loop using
copper wires. All the magnets must be attached so
thet the induced electrical current flows in the same
direction due to the Ampere's circuital law. The free
energy generation system is started by inserting the
third magnet. The overutiny circulation starts instantly

without high voltage ignition source. Thanks to the


low ignition voltage of gases at low pressure the
system starts to operate dut to the voltage induced in
the circuit from the magnet being brought near the
third chamber according to Maxwell's equations.
The low pressure gas chambers for this free energy
device are hard to manufacture at home, but on the
other hand, some equipment previously intended for
other purposes can replace them. Especially the light
sources, intended for lihgting purposes, often contain
low pressure gasses, usually in an glass envelope.
For example, the fluorescent tubes, neon lamps or
argon-filled bulbs are good example of easily available
low pressure gas chambers. I use one of each version.
Using chambers with different gases allows to
generate the initial voltage (potential difference) due
to different electronegativity of each gas. The device
operation is stopped by removing one of the magnets
from corresponding gas chamber.
The expected life span of the Air / Gas loop free
energy generator is 10 000 - 20 000 hours of
continuous operation (wearing of the gas chamber
electrodes is the most significant limiting factor). The
advantage of this free energy device is motionles
opertion - it contains no moving parts. This could also
be called motionless perpetual motion or non-mobile
perpetuum mobile :-). This device is good as a free
energy principle demonstration, as a free light source
or even as a free electricity source. The output voltage

is a high voltage at low current, so for most of the


purposes it has to be transformed using step down
(high voltage to low voltage) transformer. The output
low AC voltage can be converted into DC using bridge
rectifier. This topology is capable of delivering low to
medium-high powers, depending of the size of the gas
chambers used. This type of free energy generator
must be handled with care, as it contains high voltage.
The gas chambers also present the risk of implosion.
Before doing anything, read the Disclaimer first.

The startup and shutdown of the Air / Gas loop free


energy generator. It is started by putting the magnet to
the third gas chamber, here formed by the neon lamp.

Air / Gas free energy device in operation. Note the


third magnet being placed and removed using long
non-conductive plastic tool. This is necessary
because the device once started contains dangerous
high voltage.

The fluorescent tube and incadescent bulb as other


two gas chambers. The fluorescent tube produces
enough light to use the device as a light source too.
The light output could be converted into electricity
using solar cell, but using the high - low voltage
transformer I found more efficient.

The light bulb also can work as a nice decoration in


the dark as it produces nice visual effect during
operation. Nikola Tesla would be proud :).

Air / Gas loop free energy overunity self running


generator in operation. You can also download and
use this photo as a plan (scheme) of this generator.

Anda mungkin juga menyukai