Note: Before proceeding, make sure the following requirements have been fulfilled:
ANC-120e Driver is installed.
Virtual Network adapter is correctly configured to access ANC-120e.
ANC-120e is connected to the computer and DH+ network (Refer to appendix for
Connections instructions and more information)
ANC-120e
USB to DH+ Adapter
Select Remote Devices via Linx Gateway from the Drop down list and then click on
Add New Button
Enter any name you desire for the driver or use the default name and click OK
Enter the IP address of ANC-120e in the indicated field and click OK. (Default
is 192.168.137.2)
ANC-120e
USB to DH+ Adapter
Verify that the Driver has a running status and click on Close button
ANC-120e
USB to DH+ Adapter
Double click on the driver element (In our example is TCP-1) and you will see another
element appear below it in a branch fashion. Double click on that element and continue
until you reach CH A, Data Highway plus, where you should find your DH+ devices.
Appendix
ANC-120e DH+ connection
There are 2 ways to connect to the DH+ network.
-
Connect to Processor 3-pin connector: Daisy chain a cable from the last DH+ node to
the connector of ANC-120e. (Shield cable is not required for ANC120e). Order of
cables is irrelevant, as it is auto-detected by ANC-120e.
Connect using DH+ Prog. Term. On Processor, using the ANC-120e Din Cable if you
have it. Order of cables is irrelevant, as it is auto-detected by ANC-120e.
Connect the DH+ cable to ANC-120e and then connect to a free USB port on your
computer.
When the unit turns on, the USB LED blinks several times.
Note: if AUTO Baudrate and AUTO DH+ Node options are active in ANC-120e. It
will automatically configure the correct DH+ network speed and find a free DH+
node to use as its own address.
ANC-120e
USB to DH+ Adapter
The DH+ side LED should start blinking every 3 seconds if a DH+ connection is
detected and nothing is being transmitted on the DH+ link. When there is data being
transmitted it will blink much faster. It will remain off if the DH+ network is not
connected.
For more information about settings and other options, please refer to ANC-120e User
Manual.