March7,2016
ProjectNo.156319
Mr.GeoffreyBrown
EmergencyResponseProgram
OregonDepartmentofEnvironmentalQuality
WesternRegionEugene
165E7thAve,Suite100
Eugene,OR974013049
Re:
PathtoClosureWorkPlan
AT&THallRidgeCellTower
NationalResponseCenterReportNo.1140291
OregonEmergencyResponseSystemReportNo.20160374
Detroit,MarionCounty,Oregon
DearMr.Brown:
CB&IonthebehalfofAT&T,ispleasedtopresentthisPathtoClosureWorkPlanforthepostexcavation
and characterization activities at the AT&Ts Hall Ridge, Detroit, Oregon, cell tower (Site). The
emergencyresponseteam,whichconsistedofCB&I,NRC,NWFF,andSMAF,havecompletedtheinitial
phase of the emergency response including the removal of impacted soil in the release area,
containmentofthedownslopemigrationoffuel,characterizationoftheimpactedsoil,snowremoval,
andinitialroadrepairs.
OnFebruary11,2016,BarryWilliams(AT&T)receivednotificationofareleaseofdieselatthesubject
site.Theinitialinvestigationestimatedtheamountoffuelreleasedfromthetanksystemat550gallons.
It appeared the fuel was pumped from the 800gallon main tank to the 220gallon day tank, which
discharged from the vent located on the roof. Mr. Williams notified the National Response Center to
reportthespillat1740EasternStandardTime(EST).TheNationalResponseCenterassignedReportNo.
1140291tothespill.Mr.WilliamsalsonotifiedtheOregonEmergencyResponseSystemat1750ESTto
reportthespillandwasassignedReportNo.20160374.
ThisWorkPlanwasdevelopedtoprovideguidancefortheimplementationofbiostimulationtreatment
activitiesandpostexcavationandcharacterizationmonitoring.
Mr.GeoffreyBrown
March7,2016
Background
The site and surrounding area are located on the U.S. Geological Survey 7.5minute Detroit, Oregon,
topographic quadrangle map. The site is located at approximately 444309.7 north latitude,
1221303.6 west longitude. A review of the quadrangle map shows the site at an elevation of
approximately 4,400 feet above mean sea level (msl). The nearest surface water to the site is an
unnamed tributary, which is approximately 600 feet northeast of the site. A site vicinity map is
presentedasFigure1.
AccordingtotheUnitedStatesGeologicalSurveysNationalGeologicMapDatabase,thesiteislocated
ontheeasternflankoftheSardineSynclineandtheBreitenbushAnticlineislocatedtotheeast.Bedrock
dips at a shallow angle to the west. Bedrock listed is the Sardine Series, which consists of series of
Miocene age rhyolite, andesite, basalt, tuff, and breccia exposed on Sardine Mountain northwest of
Detroit.
EmergencyResponseTasksCompleted
Thefollowingtaskshavebeencompletedunderthisemergencyresponse:
OnFebruary12,2016,crewsweremobilizedtoinspectthesite.Theimpactedareawas
assessedandabsorbentboomsandpadsplacedinstrategicareastocapturethefreephase
diesel.
FromFebruary13throughFebruary19,2016Roadclearingcontinuedwithadditionalsnow
fall.Severalimpactedareaswerehandexcavated.Absorbentpadsinspectedandreplaced.
Wastewascontainerizedandstagedfordisposal.
OnFebruary22,2016,theORDEQandUSFSprovisionallyapprovedtheSamplingandAnalysis
Plan.
OnFebruary23,2016,theUSFSlocatedandauthorizedNRCtocollectwaterfromasourcenear
thesiteforthepercolationtest.
OnFebruary2425,2016,thepercolationtestcommencedoveratwodayperiodusing
fluorescentdye(BrightDyesFLTYellowGreenPowder)torecreatetheflowpathsofdieselfuel
throughbedrock.
OnFebruary26,2016,soilsampleswerecollectedona20footgridtodelineatetheextentof
thedieselintheshallowsoildownslopefromtherelease.
OnFridayFebruary19,2016,SundayFebruary21,2016,andSundayFebruary28,2016,four
surfacewatersampleswerecollectedfromtheunnamedtributaries(SW01,SW02,SW03,and
SW04)andSW05onThursdayFebruary25,2016.Dailyinspectionsoccuratthefivesurface
waterlocations.
Mr.GeoffreyBrown
March7,2016
DiscussionofSoilSampleResults
On February 26, 2016, soil samples were taken from 21 locations at the release area excavation and
downslope areas. Sample locations were identified using an established downslope grid and biased
wheredieselfuelwasvisuallyobserved(Figure3).Soilsampleswereanalyzedfordieselrangeorganics
byNWTPHDx,RBDMVOCsbyEPA8260B,andPAHsbyEPA8270DSIM.Thelaboratoryanalyticalresults
havebeentabulatedandpresentedinTable1.
The soil sample results were compared against ORDEQ riskbased concentrations (RBCs) for two
exposure pathways: soil ingestion, dermal contact, and inhalation (RBCSS), and soil leaching to
groundwater(RBCSW).ThreesamplelocationsshowedNWTPHDxconcentrationsthatexceedRBCsvia
eitherexposurepathway.Thesethreehotspotlocations(0C,1C,and2C)followthecenterlineofthe
downslopegrid,adjacenttothereleaseareaexcavation.
At sample location 0C, laboratory results show RBC exceedances for NWTPHDx (9,430 milligrams per
kilogram[mg/kg]),Benzene(0.161mg/kg),Ethylbenzene(3.70mg/kg),Naphthalene(2.15mg/kg),and
1,2,4Trimethylbenzene(19.9mg/kg).Atsamplelocation1C,resultsshowRBCexceedanceforNWTPH
Dx(66,400mg/kg).Atsamplelocation2C,resultsshowRBCexceedanceforNWTPHDx(96,800mg/kg).
NWTPHDx concentrations were also observed at sample locations EWSIDEWALLE (184 mg/kg), 0B
(1,090 mg/kg), 1B (44.6 mg/kg), 2B (70.2 mg/kg), and 3A (29.1 mg/kg). These locations are directly
adjacent to the hot spot locations, with the exception of 3A. The NWTPHDx concentrations at all
othersamplelocationswerenondetect.ThelaboratoryanalyticalresultsarepresentedinAppendixA.
OutcropSourceRemoval
Dieselhasaccumulatedontopofabedrockoutcroplocatedapproximately40feetdownslopefromthe
releaseareaasindicatedbysoilanalyticaldata,PIDreadingsandsiteobservation.Impactedsoilontop
of the rock outcrop will be excavated to provide mass removal and eliminate known potential source
areasforfutureleachingofdiesel.Thelimitsoftheexcavationwillextendapproximately4feetupslope
from the rock outcrop, approximately 10 feet across the width of the rock outcrop, and extend
approximately1footdeeptobedrock.Thelimitsoftheexcavationwillbedeterminedinthefieldusing
aPIDandfieldobservations.Duetotheextremesiteconditions,theimpactedsoilwillbeexcavatedby
hand.
Confirmationsoilsampleswillbecollectedonthesidewallsoftheexcavation,estimatedattwosamples
alongthetopwallandonesampleoneachsidewallsoftheexcavation.Theflooranddownslopewall
of the excavation are anticipated to be bedrock; therefore, soil samples are not anticipated at these
locations. Soil samples will be analyzed for diesel range organics by NWTPHDx, RBDM VOCs by EPA
8260B,andPAHsbyEPA8270DSIM.
Mr.GeoffreyBrown
March7,2016
Biostimulation
AT&T proposes to use a combination of two biostimulation products to naturally degrade residual
dieselattheSite.TheseproductsincludeOilSpillEatersInternationalCorporationsproprietaryOSEII
and MicroBlaze NonFormulated. MicroBlaze NonFormulated is a consortium of hydrocarbon
degrading bacteria that will be applied to the individual release areas in a 10% solution following the
application of OSE II. MicroBlaze NonFormulated contains no surfactants or nutrients, just a
consortiumofknownhydrocarbondegradingbacteria.
AT&T proposes to use Oil Spill Eaters International Corporations proprietary OSE II amendment to
breakdown residual diesel LNAPL in the subsurface. OSE II is a biocatalyst that contains enzymes and
nutrients designed to enhance the emulsification of LNAPL and stimulate hydrocarbon consuming
bacteriatodegradehydrocarbonsreleasedintheenvironment.NutrientswithinOSEIIwillincreasethe
rate of biodegradation of the dieselconsuming bacteria present beneath the Site to remove the
dissolveddiesel.OSEIIhasbeenevaluatedbytheEnvironmentalProtectionAgencyandislistedasan
accepted remedial response technology for hydrocarbon releases (Environmental Protection Agency,
2009).TheCaliforniaDepartmentofWildlife(formerlyDepartmentofFishandGame)haslicensedOSE
IIforoilspilltreatmentinCalifornia.DocumentationoftheOSEIIisprovidedinAppendixB.
The application of the OSE II and MicroBlaze NonFormulated is proposed in three areas. The first
application will be applied to a small trench excavated on the upgradient side of the AT&T
communicationbuilding.Thiswillbeconductedtotreatresidualdieselinthebasecoursebeneaththe
building foundation. The second application will be in the release area excavation to introduce these
solutionsintothesubsurfacefollowingasimilarpathwayastheoriginalrelease.Thethirdapplication
willbeasurfaceapplicationofthesesolutionswithinthelimitsofthedownslopeexcavationfollowing
theremovalofimpactedsoilontopoftherockoutcropandthesurfaceapplicationofthesoilbetween
the release area and rock outcrop. Documentation of MicroBlaze NonFormulated is provided in
AppendixB.Eachoftheseapplicationsisdiscussedbelow.
BuildingFoundationApplication
OSE II/MicroBlaze NonFormulated will be applied hydraulically upgradient of the AT&T
Communicationbuildinginanattempttotreatresidualdieselresidinginthebasecoursebeneaththe
building foundation. A small trench will be excavated along the north footing of the building for the
application of the OSE II. The trench will be approximately 1 foot wide and 6 inches deep. Excavated
materialwillbeplacedalongtheoutsideextentofthetrenchtoformaberm.Alicensedarcheologist
willbeonsiteduringallgrounddisturbanceactivities.Approximately300gallonsoftheOSEIIsolution
will be gravity fed into the trench at such a rate as to not overflow the trench, while maintaining a
constantheadinthetrench.Absorbentpadswillbeplacedadjacenttotheexposedbasecoursealong
thesouthsideofthebuildingtocapturedieselthatmaybedisplacedduringthisprocedure.
Mr.GeoffreyBrown
5
March7,2016
ReleaseAreaApplication
OSEIIwillbeappliedwithinthelimitsofthereleaseareainanefforttofollowthesamepathwayasthe
dieselduringtheoriginalrelease.Approximately900gallonsofOSEIIsolutionwillbeappliedontopof
theexposedbedrockinthereleaseareaexcavation.Theapplicationratewillbeconsistentwiththedye
test conducted on February 23, 2016 to evaluate flow pathways and maintained at a rate as to not
overflow the excavation. Absorbent pads located downslope of the excavation will be monitored and
replacedasnecessaryduringthistask.
OutcropExcavationOSEIIApplication
OSEIIwillbeappliedtothesurfaceofthedownslopeoutcropexcavationadjacenttotherockoutcrop
andsurroundingsoil.Approximately100gallonsofOSEIIsolutionwillbeappliedontopofthesoilinthe
areaextendingfromthereleaseareatotherockoutcropusingahose.Thesoilinthisareaispotentially
impactedbasedonsoilanalyticaldataandsiteobservations.Theapplicationrateshouldbemonitored
to prevent surface runoff, but sufficient to promote infiltration and near saturation. If the soil in the
treatment area becomes saturated to the point surface runoff occurs, the application rate will be
reduced. If surface water runoff continues to occur, the remaining volume of OSE II solution will be
applied to the release area. Absorbent pads located downslope of the impacted soil area will be
monitoredandreplacedasnecessaryduringthistask.
MixingProcedure
MicroBlaze NonFormulated will be mixed to a 10% solution using 5 gallons of MicroBlaze to 50
gallonsofwater.Thewaterwillbecollectedfromthesamplesourceusedinthedyetest,pendingUSFS
approval.
The OSE II application system will consist of a bulk mixing tank, one 55 gallon drum of OSE II, a
circulationpump,andassociatedhoses,valves,andfittings.Theapplicationsystemwillbepoweredby
anexistingonsitegenerator.SurfacewaterfromanearbystreamwillbeusedtoblendwiththeOSEIIto
makethe25:1solutionofwatertoOSEII,pendingUSFSapproval.Approximately1,375gallonsofthe
OSE II/surface water solution will be applied in and around the release area. It is anticipated that the
OSE II/surface water solution will be prepared in 300gallon batches for application; therefore, 12
gallonsofOSEIIwillbemixedwith300gallonsofwatertopreparethe25:1solution.
SurfaceWaterSampling
Currently, CB&I performs a daily visual inspection of five unnamed tributaries (SW01, SW02, SW03,
SW04,andSW05)andcollectsweeklysurfacewatersamplesfromtheselocationsonaweeklybasis.
These surface water samples are analyzed for RBDM VOCs by EPA Method 8260B and PAHs by EPA
Method8270DSIM.NoVOCsorPAHshavebeendetectedinanyofthesurfacewatersamplescollected
from the identified streams. The laboratory analytical results have been tabulated and presented in
Table2.SurfacewatersamplelocationsarepresentedinFigure4.
Mr.GeoffreyBrown
6
March7,2016
Surfacewatersampleswillbecollected30days,90days,and180daysfollowingtheapplicationofOSE
II to monitor potential impact to the adjacent surface water streams. Surface water sampling will be
discontinued following the 180 day sampling event if the analytical results remain below laboratory
detectionlimits.ApprovalwillberequestedfromORDEQandUSFStodiscontinuethesamplingprogram
if no VOCs or PAHs have been detected in the surface water following the 180 days of post bio
stimulationsampling.
In the event that any RBDM VOCs and PAHs are detected in the surface water samples above the
applicablestandards,thenthesurfacewatersamplingplanwillbeamendedtocollectsamplesfurther
downstream and/or at the reservoir discharge locations. The new surface water locations and the
numberofcollectedsampleswillbeapprovedbyORDEQandUSFS.
DatafromthesamplingwillbesubmittedtotheORDEQandUSFSinstatusreports.Thestatusreports
willprovideabriefsummaryoftheanalyticalresultsandconfirmthefuturesamplingfrequency.
AbsorbentandWeirMaintenance
Afterexcavationofthesourcearea,crewsestablishedadownslopecatchmentsystemincludingaweir
and trenches containing absorbent booms, and absorbent pads interweaved across the exposed
bedrock seepage areas. Crews are monitoring the absorbents daily and replacing them as needed.
SaturatedabsorbentsarecontainerizedinSuperSacsandremovedoffsitetoalandfill.
FollowingapplicationoftheOSEIItreatment,crewswillcontinuetochangeoutabsorbentpadsand/or
booms along the downslope hillside on a weekly basis. In the event that no color change in the
absorbents is observed for 30 days, then crews will remove absorbents and booms from the site and
backfill the weir, trenches, and potholes. Crews will restore the site as close as possible to pre
disturbancedrainageconditions.
SiteRestoration
Releasearea
The release area excavation and adjacent area will be restored to preexcavation conditions following
thebiostimulationapplication.Approximately4inchlayerofpeatmosswillbeappliedadjacenttothe
exposed building footing and over the exposed bedrock with previously observed contact with diesel.
The diesel readily binds with peat moss until it naturally biodegrades, preventing any residual diesel
frommigratingoffsite.Sufficientgravelwillbeplacedoverthepeatmosstorestorethesitetonearpre
excavation grade. Clean gravel that was excavated during the initial response and temporarily
stockpiled adjacent to the excavation will be used as fill material. Additional gravel from an offsite
sourceconsistingof3/4inchminuswillbeappliedtotheexcavationtorestoretheareatotheoriginal
grade.Fillmaterialwillbeappliedin6inchliftsandcompactedbydrivingoverthefillmaterialwiththe
equipment.Theareawillbegradedtopromotepositivedrainageawayfromthebuilding.
Mr.GeoffreyBrown
7
March7,2016
OutcropExcavation
The outcrop excavation and adjacent area will be restored to preexcavation conditions following the
biostimulation application. Approximately 4inch layer of peat moss will be applied adjacent to the
exposed bedrock with previously observed contact with diesel. Top soil will be applied on top of the
peatmossin6inchliftsandhandcompacteduntiltheelevationofthefillmaterialisconsistentwiththe
surroundingtopography.Grassmattingwillbeappliedoverthetopsoiltominimizeerosion.
Recommendation
Please provide your written approval if this Work Plan is acceptable or let us know if you have any
questions,comments,orrevisions.Ifnecessary,theWorkPlanwillberevisedandresubmittedforyour
approval.Thankyouforyourtimeduringouronsitemeetingsandforyourresponsivenessinworking
withustodevelopthisPlan.
Pleasecontacteitheroftheundersignedifyouhaveanyquestionsconcerningthisreport.
Sincerely:
RonaldMalec,P.G.
IncidentCommander,UnitChief
4123804484
Ron.Malec@CBI.com
MF:KR:RM:lmk
Attachments
cc:LaurenPlunk(AT&T)
BrynThoms(ORDEQ)
GregAitken(ORDEQ)
GradyMcMahan(USFS)
DarrinNeff(USFS)
JamieSheahanAlonso(USFS)
PennyKeen(USFS)
MarkFinney(CB&I)
BryanHolmes(CB&I)
KentRoberts
SeniorOperationsManager
3215431194
Kent.Roberts@cbi.com
Tables
Table1
SoilSampleAnalyticalResults
AT&THallRidge
OregonEmergencyResponseSystemReportNo.20160374
WillametteNationalForest
Detroit,Oregon
SoilSampleAnalyticalResults
RBCsw
Contaminant
PIDReading(ppm)
NWTPHDx:Diesel
NWTPHDx:Oil
Benzene
Toluene
Ethylbenzene
Xylenes
Naphthalene
MTBE
Isopropylbenzene
nPropylbenzene
1,2,4Trimethylbenzene
1,3,5Trimethylbenzene
1,2Dibromoethane(EDB)
1,2Dichloroethane(EDC)
RBCss
(mg/kg) (mg/kg)
9,500
4,600
>Max
11,000
0.10
300
310
28,000
0.94
1,700
49
20,000
0.37
580
0.50
12,000
280
27,000
NoStd. NoStd.
5.6
2,000
110
3,500
0.00056
9
0.013
200
1A
(mg/kg)
5.4
ND
123
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
1B
(mg/kg)
6.4
44.6
159
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
Page1of7
1C
(mg/kg)
397
66,400
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
2A
(mg/kg)
2.7
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
2B
(mg/kg)
1.9
70.2
312
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
2C
(mg/kg)
183
96,800
ND
0.0449
0.887
0.832
4.74
ND
ND
ND
0.642
3.53
1.04
ND
ND
2D
(mg/kg)
33.8
ND
606
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
Table1
SoilSampleAnalyticalResults
AT&THallRidge
OregonEmergencyResponseSystemReportNo.20160374
WillametteNationalForest
Detroit,Oregon
SoilSampleAnalyticalResults
RBCsw
Contaminant
Acenaphthene
Acenaphthylene
Anthracene
Benz(a)anthracene
Benzo(a)pyrene
Benzo(b)fluoranthene
Benzo(k)fluoranthene
Benzo(g,h,i)perylene
Chrysene
Dibenz(a,h)anthracene
Dibenzofuran
Fluoranthene
Fluorene
Indeno(1,2,3cd)pyrene
1Methylnaphthalene
2Methylnaphthalene
Naphthalene
Phenanthrene
Pyrene
RBCss
(mg/kg) (mg/kg)
21,000
NoStd. NoStd.
110,000
2.3
24
1.9
2.4
24
240
NoStd. NoStd.
2,400
2.4
NoStd. NoStd.
10,000
14,000
24
NoStd. NoStd.
NoStd. NoStd.
0.37
580
NoStd. NoStd.
7,500
1A
(mg/kg)
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
1B
(mg/kg)
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
Page2of7
1C
(mg/kg)
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
2A
(mg/kg)
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
2B
(mg/kg)
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
2C
(mg/kg)
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
2D
(mg/kg)
ND
ND
ND
ND
ND
0.0249
ND
ND
ND
ND
ND
ND
0.0229
ND
0.0284
0.0433
0.0502
0.0229
ND
Table1
SoilSampleAnalyticalResults
AT&THallRidge
OregonEmergencyResponseSystemReportNo.20160374
WillametteNationalForest
Detroit,Oregon
SoilSampleAnalyticalResults
RBCsw
Contaminant
PIDReading(ppm)
NWTPHDx:Diesel
NWTPHDx:Oil
Benzene
Toluene
Ethylbenzene
Xylenes
Naphthalene
MTBE
Isopropylbenzene
nPropylbenzene
1,2,4Trimethylbenzene
1,3,5Trimethylbenzene
1,2Dibromoethane(EDB)
1,2Dichloroethane(EDC)
RBCss
(mg/kg) (mg/kg)
9,500
4,600
>Max
11,000
0.10
300
310
28,000
0.94
1,700
49
20,000
0.37
580
0.50
12,000
280
27,000
NoStd. NoStd.
5.6
2,000
110
3,500
0.00056
9
0.013
200
3A
(mg/kg)
3.3
29.1
116
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
3B
(mg/kg)
2.0
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
Page3of7
3C
(mg/kg)
3.3
ND
98.7
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
3D
(mg/kg)
1.7
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
4A
(mg/kg)
3.4
ND
117
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
4B
(mg/kg)
4.8
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
4C
(mg/kg)
1.1
ND
87.2
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
Table1
SoilSampleAnalyticalResults
AT&THallRidge
OregonEmergencyResponseSystemReportNo.20160374
WillametteNationalForest
Detroit,Oregon
SoilSampleAnalyticalResults
RBCsw
Contaminant
Acenaphthene
Acenaphthylene
Anthracene
Benz(a)anthracene
Benzo(a)pyrene
Benzo(b)fluoranthene
Benzo(k)fluoranthene
Benzo(g,h,i)perylene
Chrysene
Dibenz(a,h)anthracene
Dibenzofuran
Fluoranthene
Fluorene
Indeno(1,2,3cd)pyrene
1Methylnaphthalene
2Methylnaphthalene
Naphthalene
Phenanthrene
Pyrene
RBCss
(mg/kg) (mg/kg)
21,000
NoStd. NoStd.
110,000
2.3
24
1.9
2.4
24
240
NoStd. NoStd.
2,400
2.4
NoStd. NoStd.
10,000
14,000
24
NoStd. NoStd.
NoStd. NoStd.
0.37
580
NoStd. NoStd.
7,500
3A
(mg/kg)
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
3B
(mg/kg)
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
Page4of7
3C
(mg/kg)
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
3D
(mg/kg)
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
4A
(mg/kg)
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
4B
(mg/kg)
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
4C
(mg/kg)
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
Table1
SoilSampleAnalyticalResults
AT&THallRidge
OregonEmergencyResponseSystemReportNo.20160374
WillametteNationalForest
Detroit,Oregon
SoilSampleAnalyticalResults
RBCsw
Contaminant
PIDReading(ppm)
NWTPHDx:Diesel
NWTPHDx:Oil
Benzene
Toluene
Ethylbenzene
Xylenes
Naphthalene
MTBE
Isopropylbenzene
nPropylbenzene
1,2,4Trimethylbenzene
1,3,5Trimethylbenzene
1,2Dibromoethane(EDB)
1,2Dichloroethane(EDC)
RBCss
(mg/kg) (mg/kg)
9,500
4,600
>Max
11,000
0.10
300
310
28,000
0.94
1,700
49
20,000
0.37
580
0.50
12,000
280
27,000
NoStd. NoStd.
5.6
2,000
110
3,500
0.00056
9
0.013
200
4D
(mg/kg)
1.2
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
0A
(mg/kg)
0.9
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
Page5of7
0B
(mg/kg)
10.5
1,090
ND
ND
0.224
0.200
1.04
ND
ND
ND
0.162
0.755
0.264
ND
ND
0C
(mg/kg)
36.8
9,430
ND
0.161
2.93
3.70
20.6
2.15
ND
1.03
3.82
19.9
6.59
ND
ND
ExSidewall
S
(mg/kg)
5.0
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ExSidewall
W
(mg/kg)
1.8
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ExSidewall
E
(mg/kg)
6.0
184
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
Table1
SoilSampleAnalyticalResults
AT&THallRidge
OregonEmergencyResponseSystemReportNo.20160374
WillametteNationalForest
Detroit,Oregon
SoilSampleAnalyticalResults
RBCsw
Contaminant
Acenaphthene
Acenaphthylene
Anthracene
Benz(a)anthracene
Benzo(a)pyrene
Benzo(b)fluoranthene
Benzo(k)fluoranthene
Benzo(g,h,i)perylene
Chrysene
Dibenz(a,h)anthracene
Dibenzofuran
Fluoranthene
Fluorene
Indeno(1,2,3cd)pyrene
1Methylnaphthalene
2Methylnaphthalene
Naphthalene
Phenanthrene
Pyrene
RBCss
(mg/kg) (mg/kg)
21,000
NoStd. NoStd.
110,000
2.3
24
1.9
2.4
24
240
NoStd. NoStd.
2,400
2.4
NoStd. NoStd.
10,000
14,000
24
NoStd. NoStd.
NoStd. NoStd.
0.37
580
NoStd. NoStd.
7,500
4D
(mg/kg)
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
0A
(mg/kg)
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
Page6of7
0B
(mg/kg)
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
0.0620
ND
ND
ND
0.114
0.155
ND
0.0489
0.0411
0C
(mg/kg)
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
0.376
ND
0.454
ND
3.29
5.58
2.08
0.740
0.389
ExSidewall
S
(mg/kg)
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ExSidewall
W
(mg/kg)
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ExSidewall
E
(mg/kg)
ND
0.0181
0.0526
0.635
0.219
0.603
0.206
0.0799
0.947
0.0306
ND
1.86
ND
0.116
ND
0.0135
ND
0.0119
1.60
Table1
SoilSampleAnalyticalResults
AT&THallRidge
OregonEmergencyResponseSystemReportNo.20160374
WillametteNationalForest
Detroit,Oregon
Notes:
1
RiskBasedConcentrationsForIndividualChemicals(StateofOregonDepartmentofEnvironmentalQuality),SoilsLeachingtoGroundwater(RBCsw),UrbanResidential
datedNovember1,2015.
2
RiskBasedConcentrationsForIndividualChemicals(StateofOregonDepartmentofEnvironmentalQuality),SoilsLeachingtoSoilIngestion,DermalContact,and
Inhalation(RBCss),ConstructionWorkerdatedNovember1,2015.
Bold=SoilSampleanalyticalresultsexceededapplicablestandard.
AnalyticalResultswerecomparedtotheOregonstandardsfortheSoilsLeachingtoGroundwater(RCBsw)UrbanResidentialandtheSoilLeachingtoSoilIngestion,
DermalContactandInhulation(RCBss)ConstructionWorker.Thelowereofthetwovalueswasselectedforcomparisontotheanalyticresultsforsoils.
mg/kg=milligramsperkilogram.
>Max=TheconstituentRBCforthispathwayiscalculatedasgreaterthan1,000,000mg/kgor1,000,000mg/L.Therefore,thissubstanceisdeemednottoposerisksin
thisscenario.
MTBE=Methyltertbutylether
NoStd.=NostandardlistedinRiskBasedConcentrationsforIndividualChemicalsStateofOregonDepartmentofEnvironmentalQualitydatedNovember1,2015.
PID=Photoionizationdetectorreadingsarereportedinpartspermillion(ppm).
SoilsampleswerecollectedonFebruary26,2016.
ND=Concentrationnotdetectedatthelaboratorymethoddetectionlimit.
NA=NotAnalyzed
=AllRBCvaluesforindirectpathwaysthatexceedalimit(Csat,S,orPv)areremovedfromtheRiskBasedConcentrationsForIndividualChemicalsTable.
Page7of7
Table2
WaterSampleAnalyticalResults
AT&THallRidge
OregonEmergencyResponseSystemReportNo.20160374
WillametteNationalForest
Detroit,Oregon
SW01
UnnamedTributary
Contaminant
NWTPHDx:Diesel
NWTPHDx:Oil
Benzene
Toluene
Ethylbenzene
Xylenes
Naphthalene
MTBE
Isopropylbenzene
nPropylbenzene
1,2,4Trimethylbenzene
1,3,5Trimethylbenzene
1,2Dibromoethane(EDB)
1,2Dichloroethane(EDC)
WaterSampleAnalyticalResults
1
RBCtw
(g/L)
100
300
2.0
4,400
6.7
710
0.78
64
1,800
NoStd.
54
500
0.034
0.78
SW01
02/19/16
(g/L)
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
SW01
02/21/16
(g/L)
NA
NA
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
SW01
02/28/16
(g/L)
NA
NA
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
Page1of11
SW01
SW01
SW01
SW01
(g/L)
(g/L)
(g/L)
(g/L)
Table2
WaterSampleAnalyticalResults
AT&THallRidge
OregonEmergencyResponseSystemReportNo.20160374
WillametteNationalForest
Detroit,Oregon
SW01
UnnamedTributary
Contaminant
Acenaphthene
Acenaphthylene
Anthracene
Benz(a)anthracene
Benzo(a)pyrene
Benzo(b)fluoranthene
Benzo(k)fluoranthene
Benzo(g,h,i)perylene
Chrysene
Dibenz(a,h)anthracene
Dibenzofuran
Fluoranthene
Fluorene
Indeno(1,2,3cd)pyrene
1Methylnaphthalene
2Methylnaphthalene
Naphthalene
Phenanthrene
Pyrene
WaterSampleAnalyticalResults
RBCtw
(g/L)
2,400
NoStd.
0.043
0.011
0.11
NoStd.
0.011
NoStd.
1,400
0.11
NoStd.
NoStd.
0.78
NoStd.
SW01
02/19/16
(g/L)
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
SW01
02/21/16
(g/L)
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
SW01
02/28/16
(g/L)
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
Page2of11
SW01
SW01
SW01
SW01
(g/L)
(g/L)
(g/L)
(g/L)
Table2
WaterSampleAnalyticalResults
AT&THallRidge
OregonEmergencyResponseSystemReportNo.20160374
WillametteNationalForest
Detroit,Oregon
SW02
UnnamedTributary
Contaminant
NWTPHDx:Diesel
NWTPHDx:Oil
Benzene
Toluene
Ethylbenzene
Xylenes
Naphthalene
MTBE
Isopropylbenzene
nPropylbenzene
1,2,4Trimethylbenzene
1,3,5Trimethylbenzene
1,2Dibromoethane(EDB)
1,2Dichloroethane(EDC)
WaterSampleAnalyticalResults
RBCtw
(g/L)
100
300
2.0
4,400
6.7
710
0.78
64
1,800
NoStd.
54
500
0.034
0.78
SW02
02/19/16
(g/L)
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
SW02
02/21/16
(g/L)
NA
NA
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
SW02
02/28/16
(g/L)
NA
NA
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
Page3of11
SW02
SW02
SW02
SW02
(g/L)
(g/L)
(g/L)
(g/L)
Table2
WaterSampleAnalyticalResults
AT&THallRidge
OregonEmergencyResponseSystemReportNo.20160374
WillametteNationalForest
Detroit,Oregon
SW02
UnnamedTributary
Contaminant
Acenaphthene
Acenaphthylene
Anthracene
Benz(a)anthracene
Benzo(a)pyrene
Benzo(b)fluoranthene
Benzo(k)fluoranthene
Benzo(g,h,i)perylene
Chrysene
Dibenz(a,h)anthracene
Dibenzofuran
Fluoranthene
Fluorene
Indeno(1,2,3cd)pyrene
1Methylnaphthalene
2Methylnaphthalene
Naphthalene
Phenanthrene
Pyrene
WaterSampleAnalyticalResults
RBCtw
(g/L)
2,400
NoStd.
0.043
0.011
0.11
NoStd.
0.011
NoStd.
1,400
0.11
NoStd.
NoStd.
0.78
NoStd.
SW02
02/19/16
(g/L)
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
SW02
02/21/16
(g/L)
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
SW02
02/28/16
(g/L)
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
Page4of11
SW02
SW02
SW02
SW02
(g/L)
(g/L)
(g/L)
(g/L)
Table2
WaterSampleAnalyticalResults
AT&THallRidge
OregonEmergencyResponseSystemReportNo.20160374
WillametteNationalForest
Detroit,Oregon
SW03
UnnamedTributary
Contaminant
NWTPHDx:Diesel
NWTPHDx:Oil
Benzene
Toluene
Ethylbenzene
Xylenes
Naphthalene
MTBE
Isopropylbenzene
nPropylbenzene
1,2,4Trimethylbenzene
1,3,5Trimethylbenzene
1,2Dibromoethane(EDB)
1,2Dichloroethane(EDC)
WaterSampleAnalyticalResults
RBCtw
(g/L)
100
300
2.0
4,400
6.7
710
0.78
64
1,800
NoStd.
54
500
0.034
0.78
SW03
02/19/16
(g/L)
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
SW03
02/21/16
(g/L)
NA
NA
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
SW03
02/28/16
(g/L)
NA
NA
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
Page5of11
SW03
SW03
SW03
SW03
(g/L)
(g/L)
(g/L)
(g/L)
Table2
WaterSampleAnalyticalResults
AT&THallRidge
OregonEmergencyResponseSystemReportNo.20160374
WillametteNationalForest
Detroit,Oregon
SW03
UnnamedTributary
Contaminant
Acenaphthene
Acenaphthylene
Anthracene
Benz(a)anthracene
Benzo(a)pyrene
Benzo(b)fluoranthene
Benzo(k)fluoranthene
Benzo(g,h,i)perylene
Chrysene
Dibenz(a,h)anthracene
Dibenzofuran
Fluoranthene
Fluorene
Indeno(1,2,3cd)pyrene
1Methylnaphthalene
2Methylnaphthalene
Naphthalene
Phenanthrene
Pyrene
WaterSampleAnalyticalResults
RBCtw
(g/L)
2,400
NoStd.
0.043
0.011
0.11
NoStd.
0.011
NoStd.
1,400
0.11
NoStd.
NoStd.
0.78
NoStd.
SW03
02/19/16
(g/L)
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
SW03
02/21/16
(g/L)
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
SW03
02/28/16
(g/L)
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
Page6of11
SW03
SW03
SW03
SW03
(g/L)
(g/L)
(g/L)
(g/L)
Table2
WaterSampleAnalyticalResults
AT&THallRidge
OregonEmergencyResponseSystemReportNo.20160374
WillametteNationalForest
Detroit,Oregon
SW04
UnnamedTributary
Contaminant
NWTPHDx:Diesel
NWTPHDx:Oil
Benzene
Toluene
Ethylbenzene
Xylenes
Naphthalene
MTBE
Isopropylbenzene
nPropylbenzene
1,2,4Trimethylbenzene
1,3,5Trimethylbenzene
1,2Dibromoethane(EDB)
1,2Dichloroethane(EDC)
WaterSampleAnalyticalResults
RBCtw
(g/L)
100
300
2.0
4,400
6.7
710
0.78
64
1,800
NoStd.
54
500
0.034
0.78
SW04
02/19/16
(g/L)
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
SW04
02/21/16
(g/L)
NA
NA
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
SW04
02/28/16
(g/L)
NA
NA
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
Page7of11
SW04
SW04
SW04
SW04
(g/L)
(g/L)
(g/L)
(g/L)
Table2
WaterSampleAnalyticalResults
AT&THallRidge
OregonEmergencyResponseSystemReportNo.20160374
WillametteNationalForest
Detroit,Oregon
SW04
UnnamedTributary
Contaminant
Acenaphthene
Acenaphthylene
Anthracene
Benz(a)anthracene
Benzo(a)pyrene
Benzo(b)fluoranthene
Benzo(k)fluoranthene
Benzo(g,h,i)perylene
Chrysene
Dibenz(a,h)anthracene
Dibenzofuran
Fluoranthene
Fluorene
Indeno(1,2,3cd)pyrene
1Methylnaphthalene
2Methylnaphthalene
Naphthalene
Phenanthrene
Pyrene
WaterSampleAnalyticalResults
RBCtw
(g/L)
2,400
NoStd.
0.043
0.011
0.11
NoStd.
0.011
NoStd.
1,400
0.11
NoStd.
NoStd.
0.78
NoStd.
SW04
02/19/16
(g/L)
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
SW04
02/21/16
(g/L)
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
SW04
02/28/16
(g/L)
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
Page8of11
SW04
SW04
SW04
SW04
(g/L)
(g/L)
(g/L)
(g/L)
Table2
WaterSampleAnalyticalResults
AT&THallRidge
OregonEmergencyResponseSystemReportNo.20160374
WillametteNationalForest
Detroit,Oregon
SW05
UnnamedTributary
Contaminant
Benzene
Toluene
Ethylbenzene
Xylenes
Naphthalene
MTBE
Isopropylbenzene
nPropylbenzene
1,2,4Trimethylbenzene
1,3,5Trimethylbenzene
1,2Dibromoethane(EDB)
1,2Dichloroethane(EDC)
WaterSampleAnalyticalResults
RBCtw
(g/L)
2.0
4,400
6.7
710
0.78
64
1,800
NoStd.
54
500
0.034
0.78
SW05
02/25/16
(g/L)
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
SW05
02/28/16
(g/L)
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
SW05
SW05
SW05
SW05
SW05
(g/L)
(g/L)
(g/L)
(g/L)
(g/L)
Page9of11
Table2
WaterSampleAnalyticalResults
AT&THallRidge
OregonEmergencyResponseSystemReportNo.20160374
WillametteNationalForest
Detroit,Oregon
SW05
UnnamedTributary
Contaminant
Acenaphthene
Acenaphthylene
Anthracene
Benz(a)anthracene
Benzo(a)pyrene
Benzo(b)fluoranthene
Benzo(k)fluoranthene
Benzo(g,h,i)perylene
Chrysene
Dibenz(a,h)anthracene
Dibenzofuran
Fluoranthene
Fluorene
Indeno(1,2,3cd)pyrene
1Methylnaphthalene
2Methylnaphthalene
Naphthalene
Phenanthrene
Pyrene
WaterSampleAnalyticalResults
RBCtw
(g/L)
2,400
NoStd.
0.043
0.011
0.11
NoStd.
0.011
NoStd.
1,400
0.11
NoStd.
NoStd.
0.78
NoStd.
SW05
02/25/16
(g/L)
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
SW05
02/28/16
(g/L)
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
ND
SW05
SW05
SW05
SW05
SW05
(g/L)
(g/L)
(g/L)
(g/L)
(g/L)
Page10of11
Table2
WaterSampleAnalyticalResults
AT&THallRidge
OregonEmergencyResponseSystemReportNo.20160374
WillametteNationalForest
Detroit,Oregon
Notes:
1
RiskBasedConcentrationsForIndividualChemicals(StateofOregonDepartmentofEnvironmentalQuality),GroundwaterIngestion&InhalationfromTapwater
(RBCtw),UrbanResidentialdatedNovember1,2015.
(g/L)=microgramsperliter.
MTBE=Methyltertbutylether
NoStd.=NoStandardListed
ND=Concentrationnotdetectedatthelaboratoryreportinglimit.
NA=NotAnalyzed
=AllRBCvaluesforindirectpathwaysthatexceedalimit(Csat,S,orPv)areremovedfromtheRiskBasedConcentrationsForIndividualChemicalsTable.
Page11of11
Figures
AppendixA
DraftLaboratoryAnalyticalResults
Apex Labs
DRAFT REPORT
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 1 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Laboratory ID
Matrix
1A
A6B0900-01
A6B0900-02
A6B0900-03
A6B0900-04
A6B0900-05
A6B0900-06
A6B0900-07
A6B0900-08
A6B0900-09
A6B0900-10
A6B0900-11
A6B0900-12
A6B0900-13
A6B0900-14
A6B0900-15
A6B0900-16
A6B0900-17
A6B0900-18
A6B0900-19
A6B0900-20
A6B0900-21
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
1B
1C
2A
2B
2C
2D
3A
3B
3C
3D
4A
4B
4C
4D
0A
0B
0C
Ex Sidewall S
Ex Sidewall W
Ex Sidewall E
DRAFT REPORT
Date Sampled
Date Received
02/26/16 09:40
02/26/16 09:50
02/26/16 10:00
02/26/16 10:55
02/26/16 11:00
02/26/16 10:10
02/26/16 10:05
02/26/16 10:40
02/26/16 10:45
02/26/16 10:50
02/26/16 10:15
02/26/16 10:35
02/26/16 10:30
02/26/16 10:25
02/26/16 10:20
02/26/16 12:00
02/26/16 12:05
02/26/16 12:10
02/26/16 12:20
02/26/16 12:30
02/26/16 12:40
02/27/16 09:15
02/27/16 09:15
02/27/16 09:15
02/27/16 09:15
02/27/16 09:15
02/27/16 09:15
02/27/16 09:15
02/27/16 09:15
02/27/16 09:15
02/27/16 09:15
02/27/16 09:15
02/27/16 09:15
02/27/16 09:15
02/27/16 09:15
02/27/16 09:15
02/27/16 09:15
02/27/16 09:15
02/27/16 09:15
02/27/16 09:15
02/27/16 09:15
02/27/16 09:15
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 2 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Result
MDL
1A (A6B0900-01)
Reporting
Limit
Dilution
Units
Matrix: Soil
Date Analyzed
Method
Diesel
ND
---
28.6
mg/kg dry
02/27/16 13:53
NWTPH-Dx
Oil
123
---
57.2
"
"
"
"
"
"
"
Recovery: 88 %
1B (A6B0900-02)
Notes
Batch: 6020836
Limits: 50-150 %
Matrix: Soil
F-17
Batch: 6020836
Diesel
44.6
---
32.2
mg/kg dry
02/27/16 14:33
NWTPH-Dx
F-17
Oil
159
---
64.3
"
"
"
"
F-17
"
"
"
Recovery: 90 %
1C (A6B0900-03)
Diesel
Oil
Limits: 50-150 %
Matrix: Soil
Batch: 6020835
66400
---
2040
mg/kg dry
50
02/27/16 13:53
NWTPH-Dx
ND
---
4080
"
"
"
"
"
"
"
Recovery: %
2A (A6B0900-04)
Limits: 50-150 %
Matrix: Soil
Batch: 6020836
Diesel
ND
---
26.1
mg/kg dry
02/27/16 15:12
NWTPH-Dx
Oil
ND
---
52.2
"
"
"
"
"
"
"
Recovery: 90 %
2B (A6B0900-05)
S-01
Limits: 50-150 %
Matrix: Soil
Batch: 6020836
Diesel
70.2
---
35.9
mg/kg dry
02/27/16 15:32
NWTPH-Dx
F-17
Oil
312
---
71.8
"
"
"
"
F-17
"
"
"
Recovery: 83 %
2C (A6B0900-06)
Diesel
Oil
Limits: 50-150 %
Matrix: Soil
Batch: 6020835
96800
---
2490
mg/kg dry
50
02/27/16 14:33
NWTPH-Dx
ND
---
4970
"
"
"
"
"
"
"
Recovery: %
2D (A6B0900-07)
Limits: 50-150 %
Matrix: Soil
Batch: 6020836
Diesel
ND
---
180
mg/kg dry
02/27/16 16:12
NWTPH-Dx
Oil
606
---
360
"
"
"
"
"
"
"
Recovery: 84 %
3A (A6B0900-08)
S-01
Limits: 50-150 %
Matrix: Soil
F-17
Batch: 6020836
Diesel
29.1
---
27.2
mg/kg dry
02/27/16 16:32
NWTPH-Dx
F-17
Oil
116
---
54.4
"
"
"
"
F-17
"
"
"
DRAFT REPORT
Recovery: 90 %
Limits: 50-150 %
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 3 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Result
MDL
3B (A6B0900-09)
Reporting
Limit
Dilution
Units
Matrix: Soil
Date Analyzed
Method
Diesel
ND
---
25.7
mg/kg dry
02/27/16 17:12
NWTPH-Dx
Oil
ND
---
51.5
"
"
"
"
"
"
"
Recovery: 92 %
3C (A6B0900-10)
Limits: 50-150 %
Matrix: Soil
Batch: 6020836
Diesel
ND
---
27.0
mg/kg dry
02/27/16 17:31
NWTPH-Dx
Oil
98.7
---
54.0
"
"
"
"
"
"
"
Recovery: 90 %
3D (A6B0900-11)
Limits: 50-150 %
Matrix: Soil
ND
---
27.6
mg/kg dry
02/27/16 17:12
NWTPH-Dx
Oil
ND
---
55.3
"
"
"
"
"
"
"
Recovery: 90 %
4A (A6B0900-12)
Limits: 50-150 %
Matrix: Soil
Batch: 6020836
Diesel
ND
---
29.8
mg/kg dry
02/27/16 17:31
NWTPH-Dx
Oil
117
---
59.6
"
"
"
"
"
"
"
Recovery: 91 %
4B (A6B0900-13)
Limits: 50-150 %
Matrix: Soil
ND
---
25.0
mg/kg dry
02/27/16 14:52
NWTPH-Dx
Oil
ND
---
50.0
"
"
"
"
"
"
"
Recovery: 94 %
4C (A6B0900-14RE1)
Diesel
Oil
Limits: 50-150 %
Matrix: Soil
Batch: 6020836
ND
---
28.9
mg/kg dry
02/27/16 15:12
NWTPH-Dx
87.2
---
57.7
"
"
"
"
"
"
"
Recovery: 95 %
4D (A6B0900-15)
Limits: 50-150 %
Matrix: Soil
ND
---
25.0
mg/kg dry
02/27/16 15:32
NWTPH-Dx
Oil
ND
---
50.0
"
"
"
"
"
"
"
Recovery: 94 %
0A (A6B0900-16)
Limits: 50-150 %
Matrix: Soil
Batch: 6020836
Diesel
ND
---
34.5
mg/kg dry
02/27/16 12:29
NWTPH-Dx
Oil
ND
---
69.1
"
"
"
"
"
"
"
DRAFT REPORT
Recovery: 90 %
F-17
Batch: 6020836
Diesel
F-17
Batch: 6020836
Diesel
F-17
Batch: 6020836
Diesel
Notes
Batch: 6020836
Limits: 50-150 %
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 4 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Result
MDL
0B (A6B0900-17)
Reporting
Limit
Dilution
Units
Matrix: Soil
Date Analyzed
Method
Diesel
1090
---
33.4
mg/kg dry
02/27/16 15:52
NWTPH-Dx
Oil
ND
---
66.8
"
"
"
"
"
"
"
Recovery: 99 %
0C (A6B0900-18)
Limits: 50-150 %
Matrix: Soil
Batch: 6020836
Diesel
9430
---
186
mg/kg dry
02/27/16 16:32
NWTPH-Dx
Oil
ND
---
372
"
"
"
"
"
"
"
Recovery: 137 %
Ex Sidewall S (A6B0900-19)
Limits: 50-150 %
Matrix: Soil
ND
---
25.0
mg/kg dry
02/27/16 12:49
NWTPH-Dx
Oil
ND
---
50.0
"
"
"
"
"
"
"
Recovery: 95 %
Ex Sidewall W (A6B0900-20)
Limits: 50-150 %
Matrix: Soil
Batch: 6020836
Diesel
ND
---
26.7
mg/kg dry
02/27/16 12:49
NWTPH-Dx
Oil
ND
---
53.5
"
"
"
"
"
"
"
Recovery: 95 %
Ex Sidewall E (A6B0900-21)
Limits: 50-150 %
Matrix: Soil
Batch: 6020836
Diesel
184
---
25.0
mg/kg dry
02/27/16 16:52
NWTPH-Dx
Oil
ND
---
50.0
"
"
"
"
"
"
"
DRAFT REPORT
Recovery: 94 %
S-05
Batch: 6020836
Diesel
Notes
Batch: 6020836
Limits: 50-150 %
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 5 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Analyte
MDL
1A (A6B0900-01)
Reporting
Limit
Dilution
Units
Matrix: Soil
Date Analyzed
Method
Benzene
ND
---
0.0217
mg/kg dry
50
02/27/16 13:54
5035/8260B
Toluene
ND
---
0.108
"
"
"
"
Ethylbenzene
ND
---
0.0542
"
"
"
"
Xylenes, total
ND
---
0.163
"
"
"
"
Naphthalene
ND
---
0.217
"
"
"
"
ND
---
0.108
"
"
"
"
Isopropylbenzene
ND
---
0.108
"
"
"
"
n-Propylbenzene
ND
---
0.0542
"
"
"
"
1,2,4-Trimethylbenzene
ND
---
0.108
"
"
"
"
1,3,5-Trimethylbenzene
ND
---
0.108
"
"
"
"
1,2-Dibromoethane (EDB)
ND
---
0.0542
"
"
"
"
1,2-Dichloroethane (EDC)
ND
---
0.0542
"
"
"
"
Recovery: 106 %
Limits: 70-130 %
"
"
1,4-Difluorobenzene (Surr)
103 %
Limits: 70-130 %
"
"
"
Toluene-d8 (Surr)
100 %
Limits: 70-130 %
"
"
"
97 %
Limits: 70-130 %
"
"
"
4-Bromofluorobenzene (Surr)
1B (A6B0900-02)
Matrix: Soil
Batch: 6020833
Benzene
ND
---
0.0272
mg/kg dry
50
02/27/16 14:51
5035/8260B
Toluene
ND
---
0.136
"
"
"
"
Ethylbenzene
ND
---
0.0680
"
"
"
"
Xylenes, total
ND
---
0.204
"
"
"
"
Naphthalene
ND
---
0.272
"
"
"
"
ND
---
0.136
"
"
"
"
Isopropylbenzene
ND
---
0.136
"
"
"
"
n-Propylbenzene
ND
---
0.0680
"
"
"
"
1,2,4-Trimethylbenzene
ND
---
0.136
"
"
"
"
1,3,5-Trimethylbenzene
ND
---
0.136
"
"
"
"
1,2-Dibromoethane (EDB)
ND
---
0.0680
"
"
"
"
1,2-Dichloroethane (EDC)
ND
---
0.0680
"
"
"
"
Recovery: 104 %
Limits: 70-130 %
"
"
1,4-Difluorobenzene (Surr)
102 %
Limits: 70-130 %
"
"
"
Toluene-d8 (Surr)
100 %
Limits: 70-130 %
"
"
"
98 %
Limits: 70-130 %
"
"
"
02/27/16 15:20
5035/8260B
4-Bromofluorobenzene (Surr)
2A (A6B0900-04)
Benzene
Matrix: Soil
ND
DRAFT REPORT
---
0.0162
Notes
Batch: 6020833
Batch: 6020833
mg/kg dry
50
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 6 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Analyte
MDL
2A (A6B0900-04)
Reporting
Limit
Dilution
Units
Matrix: Soil
Date Analyzed
Method
Toluene
ND
---
0.0812
mg/kg dry
50
"
5035/8260B
Ethylbenzene
ND
---
0.0406
"
"
"
"
Xylenes, total
ND
---
0.122
"
"
"
"
Naphthalene
ND
---
0.162
"
"
"
"
ND
---
0.0812
"
"
"
"
Isopropylbenzene
ND
---
0.0812
"
"
"
"
n-Propylbenzene
ND
---
0.0406
"
"
"
"
1,2,4-Trimethylbenzene
ND
---
0.0812
"
"
"
"
1,3,5-Trimethylbenzene
ND
---
0.0812
"
"
"
"
1,2-Dibromoethane (EDB)
ND
---
0.0406
"
"
"
"
1,2-Dichloroethane (EDC)
ND
---
0.0406
"
"
"
"
Recovery: 109 %
Limits: 70-130 %
"
"
104 %
Limits: 70-130 %
"
"
"
Toluene-d8 (Surr)
99 %
Limits: 70-130 %
"
"
"
4-Bromofluorobenzene (Surr)
96 %
Limits: 70-130 %
"
"
"
1,4-Difluorobenzene (Surr)
2B (A6B0900-05)
Matrix: Soil
Batch: 6020833
Benzene
ND
---
0.0353
mg/kg dry
50
02/27/16 15:48
5035/8260B
Toluene
ND
---
0.177
"
"
"
"
Ethylbenzene
ND
---
0.0883
"
"
"
"
Xylenes, total
ND
---
0.265
"
"
"
"
Naphthalene
ND
---
0.353
"
"
"
"
ND
---
0.177
"
"
"
"
Isopropylbenzene
ND
---
0.177
"
"
"
"
n-Propylbenzene
ND
---
0.0883
"
"
"
"
1,2,4-Trimethylbenzene
ND
---
0.177
"
"
"
"
1,3,5-Trimethylbenzene
ND
---
0.177
"
"
"
"
1,2-Dibromoethane (EDB)
ND
---
0.0883
"
"
"
"
1,2-Dichloroethane (EDC)
ND
---
0.0883
"
"
"
"
Recovery: 105 %
Limits: 70-130 %
"
"
102 %
Limits: 70-130 %
"
"
"
Toluene-d8 (Surr)
99 %
Limits: 70-130 %
"
"
"
4-Bromofluorobenzene (Surr)
95 %
Limits: 70-130 %
"
"
"
1,4-Difluorobenzene (Surr)
2D (A6B0900-07)
Matrix: Soil
Batch: 6020833
Benzene
0.0449
---
0.0391
mg/kg dry
50
02/27/16 16:16
5035/8260B
Toluene
0.887
---
0.195
"
"
"
"
DRAFT REPORT
Notes
Batch: 6020833
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 7 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Analyte
MDL
2D (A6B0900-07)
Reporting
Limit
Dilution
Units
Matrix: Soil
Date Analyzed
Method
Ethylbenzene
0.832
---
0.0976
mg/kg dry
50
"
Xylenes, total
4.74
---
0.293
"
"
"
"
Naphthalene
ND
---
0.391
"
"
"
"
ND
---
0.195
"
"
"
"
Isopropylbenzene
ND
---
0.195
"
"
"
"
n-Propylbenzene
0.642
---
0.0976
"
"
"
"
1,2,4-Trimethylbenzene
3.53
---
0.195
"
"
"
"
5035/8260B
1,3,5-Trimethylbenzene
1.04
---
0.195
"
"
"
"
1,2-Dibromoethane (EDB)
ND
---
0.0976
"
"
"
"
1,2-Dichloroethane (EDC)
ND
---
0.0976
"
"
"
"
Recovery: 108 %
Limits: 70-130 %
"
"
103 %
Limits: 70-130 %
"
"
"
Toluene-d8 (Surr)
93 %
Limits: 70-130 %
"
"
"
4-Bromofluorobenzene (Surr)
96 %
Limits: 70-130 %
"
"
"
1,4-Difluorobenzene (Surr)
3A (A6B0900-08)
Matrix: Soil
Batch: 6020833
Benzene
ND
---
0.0216
mg/kg dry
50
02/27/16 16:45
5035/8260B
Toluene
ND
---
0.108
"
"
"
"
Ethylbenzene
ND
---
0.0539
"
"
"
"
Xylenes, total
ND
---
0.162
"
"
"
"
Naphthalene
ND
---
0.216
"
"
"
"
ND
---
0.108
"
"
"
"
Isopropylbenzene
ND
---
0.108
"
"
"
"
n-Propylbenzene
ND
---
0.0539
"
"
"
"
1,2,4-Trimethylbenzene
ND
---
0.108
"
"
"
"
1,3,5-Trimethylbenzene
ND
---
0.108
"
"
"
"
1,2-Dibromoethane (EDB)
ND
---
0.0539
"
"
"
"
1,2-Dichloroethane (EDC)
ND
---
0.0539
"
"
"
"
Recovery: 105 %
Limits: 70-130 %
"
"
1,4-Difluorobenzene (Surr)
102 %
Limits: 70-130 %
"
"
"
Toluene-d8 (Surr)
100 %
Limits: 70-130 %
"
"
"
97 %
Limits: 70-130 %
"
"
"
4-Bromofluorobenzene (Surr)
3B (A6B0900-09)
Matrix: Soil
Batch: 6020833
Benzene
ND
---
0.0160
mg/kg dry
50
02/27/16 17:13
5035/8260B
Toluene
ND
---
0.0801
"
"
"
"
Ethylbenzene
ND
---
0.0400
"
"
"
"
DRAFT REPORT
Notes
Batch: 6020833
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 8 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Analyte
MDL
3B (A6B0900-09)
Reporting
Limit
Dilution
Units
Matrix: Soil
Date Analyzed
Method
Xylenes, total
ND
---
0.120
mg/kg dry
50
"
5035/8260B
Naphthalene
ND
---
0.160
"
"
"
"
ND
---
0.0801
"
"
"
"
Isopropylbenzene
ND
---
0.0801
"
"
"
"
n-Propylbenzene
ND
---
0.0400
"
"
"
"
1,2,4-Trimethylbenzene
ND
---
0.0801
"
"
"
"
1,3,5-Trimethylbenzene
ND
---
0.0801
"
"
"
"
1,2-Dibromoethane (EDB)
ND
---
0.0400
"
"
"
"
1,2-Dichloroethane (EDC)
ND
---
"
"
"
Recovery: 108 %
Limits: 70-130 %
"
"
1,4-Difluorobenzene (Surr)
103 %
Limits: 70-130 %
"
"
"
Toluene-d8 (Surr)
100 %
Limits: 70-130 %
"
"
"
93 %
Limits: 70-130 %
"
"
"
4-Bromofluorobenzene (Surr)
3C (A6B0900-10)
0.0400
"
Matrix: Soil
Batch: 6020833
Benzene
ND
---
0.0156
mg/kg dry
50
02/27/16 17:41
5035/8260B
Toluene
ND
---
0.0782
"
"
"
"
Ethylbenzene
ND
---
0.0391
"
"
"
"
Xylenes, total
ND
---
0.117
"
"
"
"
Naphthalene
ND
---
0.156
"
"
"
"
ND
---
0.0782
"
"
"
"
Isopropylbenzene
ND
---
0.0782
"
"
"
"
n-Propylbenzene
ND
---
0.0391
"
"
"
"
1,2,4-Trimethylbenzene
ND
---
0.0782
"
"
"
"
1,3,5-Trimethylbenzene
ND
---
0.0782
"
"
"
"
1,2-Dibromoethane (EDB)
ND
---
0.0391
"
"
"
"
1,2-Dichloroethane (EDC)
ND
---
0.0391
"
"
"
"
Recovery: 106 %
Limits: 70-130 %
"
"
1,4-Difluorobenzene (Surr)
103 %
Limits: 70-130 %
"
"
"
Toluene-d8 (Surr)
101 %
Limits: 70-130 %
"
"
"
93 %
Limits: 70-130 %
"
"
"
4-Bromofluorobenzene (Surr)
3D (A6B0900-11)
Matrix: Soil
Batch: 6020833
Benzene
ND
---
0.0199
mg/kg dry
50
02/27/16 18:10
5035/8260B
Toluene
ND
---
0.0994
"
"
"
"
Ethylbenzene
ND
---
0.0497
"
"
"
"
Xylenes, total
ND
---
0.149
"
"
"
"
DRAFT REPORT
Notes
Batch: 6020833
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 9 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Analyte
MDL
3D (A6B0900-11)
Reporting
Limit
Dilution
Units
Matrix: Soil
Date Analyzed
Method
Naphthalene
ND
---
0.199
mg/kg dry
50
"
5035/8260B
ND
---
0.0994
"
"
"
"
Isopropylbenzene
ND
---
0.0994
"
"
"
"
n-Propylbenzene
ND
---
0.0497
"
"
"
"
1,2,4-Trimethylbenzene
ND
---
0.0994
"
"
"
"
1,3,5-Trimethylbenzene
ND
---
0.0994
"
"
"
"
1,2-Dibromoethane (EDB)
ND
---
0.0497
"
"
"
"
1,2-Dichloroethane (EDC)
ND
---
0.0497
"
"
"
"
Recovery: 104 %
Limits: 70-130 %
"
"
102 %
Limits: 70-130 %
"
"
"
Toluene-d8 (Surr)
99 %
Limits: 70-130 %
"
"
"
4-Bromofluorobenzene (Surr)
95 %
Limits: 70-130 %
"
"
"
1,4-Difluorobenzene (Surr)
4A (A6B0900-12)
Matrix: Soil
Benzene
ND
---
Toluene
ND
Ethylbenzene
ND
Xylenes, total
Batch: 6020833
0.0205
mg/kg dry
50
02/27/16 18:38
5035/8260B
---
0.103
"
"
"
"
---
0.0513
"
"
"
"
ND
---
0.154
"
"
"
"
Naphthalene
ND
---
0.205
"
"
"
"
ND
---
0.103
"
"
"
"
Isopropylbenzene
ND
---
0.103
"
"
"
"
n-Propylbenzene
ND
---
0.0513
"
"
"
"
1,2,4-Trimethylbenzene
ND
---
0.103
"
"
"
"
1,3,5-Trimethylbenzene
ND
---
0.103
"
"
"
"
1,2-Dibromoethane (EDB)
ND
---
0.0513
"
"
"
"
1,2-Dichloroethane (EDC)
ND
---
0.0513
"
"
"
"
Recovery: 105 %
Limits: 70-130 %
"
"
1,4-Difluorobenzene (Surr)
102 %
Limits: 70-130 %
"
"
"
Toluene-d8 (Surr)
101 %
Limits: 70-130 %
"
"
"
96 %
Limits: 70-130 %
"
"
"
4-Bromofluorobenzene (Surr)
4B (A6B0900-13)
Matrix: Soil
Batch: 6020833
Benzene
ND
---
0.0162
mg/kg dry
50
02/27/16 19:07
5035/8260B
Toluene
ND
---
0.0809
"
"
"
"
Ethylbenzene
ND
---
0.0404
"
"
"
"
Xylenes, total
ND
---
0.121
"
"
"
"
Naphthalene
ND
---
0.162
"
"
"
"
DRAFT REPORT
Notes
Batch: 6020833
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 10 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Analyte
MDL
4B (A6B0900-13)
Reporting
Limit
Dilution
Units
Matrix: Soil
Date Analyzed
Method
ND
---
0.0809
mg/kg dry
50
"
5035/8260B
Isopropylbenzene
ND
---
0.0809
"
"
"
"
n-Propylbenzene
ND
---
0.0404
"
"
"
"
1,2,4-Trimethylbenzene
ND
---
0.0809
"
"
"
"
1,3,5-Trimethylbenzene
ND
---
0.0809
"
"
"
"
1,2-Dibromoethane (EDB)
ND
---
0.0404
"
"
"
"
1,2-Dichloroethane (EDC)
ND
---
0.0404
"
"
"
"
Recovery: 107 %
Limits: 70-130 %
"
"
1,4-Difluorobenzene (Surr)
102 %
Limits: 70-130 %
"
"
"
Toluene-d8 (Surr)
100 %
Limits: 70-130 %
"
"
"
98 %
Limits: 70-130 %
"
"
"
4-Bromofluorobenzene (Surr)
4C (A6B0900-14)
Matrix: Soil
Batch: 6020834
Benzene
ND
---
0.0140
mg/kg dry
50
02/27/16 14:15
5035/8260B
Toluene
ND
---
0.0702
"
"
"
"
Ethylbenzene
ND
---
0.0351
"
"
"
"
Xylenes, total
ND
---
0.105
"
"
"
"
Naphthalene
ND
---
0.140
"
"
"
"
ND
---
0.0702
"
"
"
"
Isopropylbenzene
ND
---
0.0702
"
"
"
"
n-Propylbenzene
ND
---
0.0351
"
"
"
"
1,2,4-Trimethylbenzene
ND
---
0.0702
"
"
"
"
1,3,5-Trimethylbenzene
ND
---
0.0702
"
"
"
"
1,2-Dibromoethane (EDB)
ND
---
0.0351
"
"
"
"
1,2-Dichloroethane (EDC)
ND
---
"
"
"
Recovery: 97 %
Limits: 70-130 %
"
"
1,4-Difluorobenzene (Surr)
93 %
Limits: 70-130 %
"
"
"
Toluene-d8 (Surr)
97 %
Limits: 70-130 %
"
"
"
4-Bromofluorobenzene (Surr)
97 %
Limits: 70-130 %
"
"
"
4D (A6B0900-15)
0.0351
"
Matrix: Soil
Batch: 6020834
Benzene
ND
---
0.00983
mg/kg dry
50
02/27/16 14:41
5035/8260B
Toluene
ND
---
0.0491
"
"
"
"
Ethylbenzene
ND
---
0.0246
"
"
"
"
Xylenes, total
ND
---
0.0737
"
"
"
"
Naphthalene
ND
---
0.0983
"
"
"
"
ND
---
0.0491
"
"
"
"
DRAFT REPORT
Notes
Batch: 6020833
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 11 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Analyte
MDL
4D (A6B0900-15)
Reporting
Limit
Dilution
Units
Matrix: Soil
Date Analyzed
Method
Isopropylbenzene
ND
---
0.0491
mg/kg dry
50
"
5035/8260B
n-Propylbenzene
ND
---
0.0246
"
"
"
"
1,2,4-Trimethylbenzene
ND
---
0.0491
"
"
"
"
1,3,5-Trimethylbenzene
ND
---
0.0491
"
"
"
"
1,2-Dibromoethane (EDB)
ND
---
0.0246
"
"
"
"
1,2-Dichloroethane (EDC)
ND
---
0.0246
"
"
"
"
Recovery: 96 %
Limits: 70-130 %
"
"
1,4-Difluorobenzene (Surr)
92 %
Limits: 70-130 %
"
"
"
Toluene-d8 (Surr)
97 %
Limits: 70-130 %
"
"
"
4-Bromofluorobenzene (Surr)
97 %
Limits: 70-130 %
"
"
"
0A (A6B0900-16)
Matrix: Soil
Batch: 6020834
Benzene
ND
---
0.0324
mg/kg dry
50
02/27/16 15:08
5035/8260B
Toluene
ND
---
0.162
"
"
"
"
Ethylbenzene
ND
---
0.0810
"
"
"
"
Xylenes, total
ND
---
0.243
"
"
"
"
Naphthalene
ND
---
0.324
"
"
"
"
ND
---
0.162
"
"
"
"
Isopropylbenzene
ND
---
0.162
"
"
"
"
n-Propylbenzene
ND
---
0.0810
"
"
"
"
1,2,4-Trimethylbenzene
ND
---
0.162
"
"
"
"
1,3,5-Trimethylbenzene
ND
---
0.162
"
"
"
"
1,2-Dibromoethane (EDB)
ND
---
0.0810
"
"
"
"
1,2-Dichloroethane (EDC)
ND
---
0.0810
"
"
"
"
Recovery: 97 %
Limits: 70-130 %
"
"
1,4-Difluorobenzene (Surr)
92 %
Limits: 70-130 %
"
"
"
Toluene-d8 (Surr)
96 %
Limits: 70-130 %
"
"
"
4-Bromofluorobenzene (Surr)
98 %
Limits: 70-130 %
"
"
"
02/27/16 15:35
5035/8260B
0B (A6B0900-17)
Benzene
Matrix: Soil
ND
---
0.0272
Batch: 6020834
mg/kg dry
50
Toluene
0.224
---
0.136
"
"
"
"
Ethylbenzene
0.200
---
0.0680
"
"
"
"
Xylenes, total
1.04
---
0.204
"
"
"
"
Naphthalene
ND
---
0.272
"
"
"
"
ND
---
0.136
"
"
"
"
Isopropylbenzene
ND
---
0.136
"
"
"
"
DRAFT REPORT
Notes
Batch: 6020834
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 12 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Analyte
MDL
0B (A6B0900-17)
Reporting
Limit
Dilution
Units
Matrix: Soil
Date Analyzed
Method
n-Propylbenzene
0.162
---
0.0680
mg/kg dry
50
"
1,2,4-Trimethylbenzene
0.755
---
0.136
"
"
"
"
1,3,5-Trimethylbenzene
0.264
---
0.136
"
"
"
"
1,2-Dibromoethane (EDB)
ND
---
0.0680
"
"
"
"
1,2-Dichloroethane (EDC)
ND
---
0.0680
"
"
"
"
5035/8260B
Recovery: 94 %
Limits: 70-130 %
"
"
1,4-Difluorobenzene (Surr)
91 %
Limits: 70-130 %
"
"
"
Toluene-d8 (Surr)
96 %
Limits: 70-130 %
"
"
"
4-Bromofluorobenzene (Surr)
98 %
Limits: 70-130 %
"
"
"
5035/8260B
0C (A6B0900-18)
Matrix: Soil
Batch: 6020834
Benzene
0.161
---
0.0336
mg/kg dry
50
02/27/16 16:29
Toluene
2.93
---
0.168
"
"
"
"
Ethylbenzene
3.70
---
0.0840
"
"
"
"
Xylenes, total
20.6
---
0.252
"
"
"
"
Naphthalene
2.15
---
0.336
"
"
"
"
ND
---
0.168
"
"
"
"
Isopropylbenzene
1.03
---
0.168
"
"
"
"
n-Propylbenzene
3.82
---
0.0840
"
"
"
"
1,2,4-Trimethylbenzene
19.9
---
0.168
"
"
"
"
1,3,5-Trimethylbenzene
6.59
---
0.168
"
"
"
"
1,2-Dibromoethane (EDB)
ND
---
0.0840
"
"
"
"
1,2-Dichloroethane (EDC)
ND
---
0.0840
"
"
"
"
Ex Sidewall S (A6B0900-19)
Recovery: 97 %
Limits: 70-130 %
"
"
93 %
Limits: 70-130 %
"
"
"
101 %
Limits: 70-130 %
"
"
"
98 %
Limits: 70-130 %
"
"
"
Matrix: Soil
ND
---
0.00773
mg/kg dry
50
02/27/16 16:56
5035/8260B
Toluene
ND
---
0.0386
"
"
"
"
Ethylbenzene
ND
---
0.0193
"
"
"
"
Xylenes, total
ND
---
0.0580
"
"
"
"
Naphthalene
ND
---
0.0773
"
"
"
"
ND
---
0.0386
"
"
"
"
Isopropylbenzene
ND
---
0.0386
"
"
"
"
n-Propylbenzene
ND
---
0.0193
"
"
"
"
M-04
Batch: 6020834
Benzene
DRAFT REPORT
Notes
Batch: 6020834
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 13 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Analyte
MDL
Ex Sidewall S (A6B0900-19)
Reporting
Limit
Dilution
Units
Matrix: Soil
Date Analyzed
Method
1,2,4-Trimethylbenzene
ND
---
0.0386
mg/kg dry
50
"
5035/8260B
1,3,5-Trimethylbenzene
ND
---
0.0386
"
"
"
"
1,2-Dibromoethane (EDB)
ND
---
0.0193
"
"
"
"
1,2-Dichloroethane (EDC)
ND
---
0.0193
"
"
"
"
Recovery: 94 %
Limits: 70-130 %
"
"
1,4-Difluorobenzene (Surr)
91 %
Limits: 70-130 %
"
"
"
Toluene-d8 (Surr)
96 %
Limits: 70-130 %
"
"
"
4-Bromofluorobenzene (Surr)
97 %
Limits: 70-130 %
"
"
"
Ex Sidewall W (A6B0900-20)
Matrix: Soil
Batch: 6020834
Benzene
ND
---
0.0119
mg/kg dry
50
02/27/16 17:22
5035/8260B
Toluene
ND
---
0.0594
"
"
"
"
Ethylbenzene
ND
---
0.0297
"
"
"
"
Xylenes, total
ND
---
0.0890
"
"
"
"
Naphthalene
ND
---
0.119
"
"
"
"
ND
---
0.0594
"
"
"
"
Isopropylbenzene
ND
---
0.0594
"
"
"
"
n-Propylbenzene
ND
---
0.0297
"
"
"
"
1,2,4-Trimethylbenzene
ND
---
0.0594
"
"
"
"
1,3,5-Trimethylbenzene
ND
---
0.0594
"
"
"
"
1,2-Dibromoethane (EDB)
ND
---
0.0297
"
"
"
"
1,2-Dichloroethane (EDC)
ND
---
0.0297
"
"
"
"
Recovery: 94 %
Limits: 70-130 %
"
"
1,4-Difluorobenzene (Surr)
92 %
Limits: 70-130 %
"
"
"
Toluene-d8 (Surr)
96 %
Limits: 70-130 %
"
"
"
4-Bromofluorobenzene (Surr)
98 %
Limits: 70-130 %
"
"
"
Ex Sidewall E (A6B0900-21)
Matrix: Soil
Batch: 6020834
Benzene
ND
---
0.00717
mg/kg dry
50
02/27/16 17:49
5035/8260B
Toluene
ND
---
0.0358
"
"
"
"
Ethylbenzene
ND
---
0.0179
"
"
"
"
Xylenes, total
ND
---
0.0538
"
"
"
"
Naphthalene
ND
---
0.0717
"
"
"
"
ND
---
0.0358
"
"
"
"
Isopropylbenzene
ND
---
0.0358
"
"
"
"
n-Propylbenzene
ND
---
0.0179
"
"
"
"
1,2,4-Trimethylbenzene
ND
---
0.0358
"
"
"
"
DRAFT REPORT
Notes
Batch: 6020834
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 14 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Analyte
MDL
Ex Sidewall E (A6B0900-21)
Reporting
Limit
Dilution
Units
Matrix: Soil
Date Analyzed
Method
1,3,5-Trimethylbenzene
ND
---
0.0358
mg/kg dry
50
"
5035/8260B
1,2-Dibromoethane (EDB)
ND
---
0.0179
"
"
"
"
1,2-Dichloroethane (EDC)
ND
---
0.0179
"
"
"
"
Recovery: 93 %
Limits: 70-130 %
"
"
1,4-Difluorobenzene (Surr)
91 %
Limits: 70-130 %
"
"
"
Toluene-d8 (Surr)
97 %
Limits: 70-130 %
"
"
"
4-Bromofluorobenzene (Surr)
98 %
Limits: 70-130 %
"
"
"
DRAFT REPORT
Notes
Batch: 6020834
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 15 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Analyte
MDL
1A (A6B0900-01)
Reporting
Limit
Dilution
Units
Matrix: Soil
Date Analyzed
Method
Acenaphthene
ND
---
0.0143
mg/kg dry
02/27/16 14:05
Acenaphthylene
ND
---
0.0143
"
"
"
"
Anthracene
ND
---
0.0143
"
"
"
"
Benz(a)anthracene
ND
---
0.0143
"
"
"
"
Benzo(a)pyrene
ND
---
0.0143
"
"
"
"
Benzo(b)fluoranthene
ND
---
0.0143
"
"
"
"
Benzo(k)fluoranthene
ND
---
0.0143
"
"
"
"
Benzo(g,h,i)perylene
ND
---
0.0143
"
"
"
"
Chrysene
ND
---
0.0143
"
"
"
"
Dibenz(a,h)anthracene
ND
---
0.0143
"
"
"
"
Dibenzofuran
ND
---
0.0143
"
"
"
"
Fluoranthene
ND
---
0.0143
"
"
"
"
Fluorene
ND
---
0.0143
"
"
"
"
Indeno(1,2,3-cd)pyrene
ND
---
0.0143
"
"
"
"
1-Methylnaphthalene
ND
---
0.0143
"
"
"
"
2-Methylnaphthalene
ND
---
0.0143
"
"
"
"
Naphthalene
ND
---
0.0143
"
"
"
"
Phenanthrene
ND
---
0.0143
"
"
"
"
Pyrene
ND
---
0.0143
"
"
"
"
DRAFT REPORT
Notes
Batch: 6020836
Recovery: 87 %
Limits: 44-115 %
"
"
"
105 %
Limits: 54-127 %
"
"
"
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 16 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Analyte
MDL
1B (A6B0900-02)
Reporting
Limit
Dilution
Units
Matrix: Soil
Date Analyzed
Method
Acenaphthene
ND
---
0.0161
mg/kg dry
02/27/16 14:59
Acenaphthylene
ND
---
0.0161
"
"
"
"
Anthracene
ND
---
0.0161
"
"
"
"
Benz(a)anthracene
ND
---
0.0161
"
"
"
"
Benzo(a)pyrene
ND
---
0.0161
"
"
"
"
Benzo(b)fluoranthene
ND
---
0.0161
"
"
"
"
Benzo(k)fluoranthene
ND
---
0.0161
"
"
"
"
Benzo(g,h,i)perylene
ND
---
0.0161
"
"
"
"
Chrysene
ND
---
0.0161
"
"
"
"
Dibenz(a,h)anthracene
ND
---
0.0161
"
"
"
"
Dibenzofuran
ND
---
0.0161
"
"
"
"
Fluoranthene
ND
---
0.0161
"
"
"
"
Fluorene
ND
---
0.0161
"
"
"
"
Indeno(1,2,3-cd)pyrene
ND
---
0.0161
"
"
"
"
1-Methylnaphthalene
ND
---
0.0161
"
"
"
"
2-Methylnaphthalene
ND
---
0.0161
"
"
"
"
Naphthalene
ND
---
0.0161
"
"
"
"
Phenanthrene
ND
---
0.0161
"
"
"
"
Pyrene
ND
---
0.0161
"
"
"
"
DRAFT REPORT
Notes
Batch: 6020836
Recovery: 89 %
Limits: 44-115 %
"
"
"
107 %
Limits: 54-127 %
"
"
"
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 17 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Analyte
MDL
2A (A6B0900-04)
Reporting
Limit
Dilution
Units
Matrix: Soil
Date Analyzed
Method
Acenaphthene
ND
---
0.0130
mg/kg dry
02/27/16 15:27
Acenaphthylene
ND
---
0.0130
"
"
"
"
Anthracene
ND
---
0.0130
"
"
"
"
Benz(a)anthracene
ND
---
0.0130
"
"
"
"
Benzo(a)pyrene
ND
---
0.0130
"
"
"
"
Benzo(b)fluoranthene
ND
---
0.0130
"
"
"
"
Benzo(k)fluoranthene
ND
---
0.0130
"
"
"
"
Benzo(g,h,i)perylene
ND
---
0.0130
"
"
"
"
Chrysene
ND
---
0.0130
"
"
"
"
Dibenz(a,h)anthracene
ND
---
0.0130
"
"
"
"
Dibenzofuran
ND
---
0.0130
"
"
"
"
Fluoranthene
ND
---
0.0130
"
"
"
"
Fluorene
ND
---
0.0130
"
"
"
"
Indeno(1,2,3-cd)pyrene
ND
---
0.0130
"
"
"
"
1-Methylnaphthalene
ND
---
0.0130
"
"
"
"
2-Methylnaphthalene
ND
---
0.0130
"
"
"
"
Naphthalene
ND
---
0.0130
"
"
"
"
Phenanthrene
ND
---
0.0130
"
"
"
"
Pyrene
ND
---
0.0130
"
"
"
"
DRAFT REPORT
Notes
Batch: 6020836
Recovery: 86 %
Limits: 44-115 %
"
"
"
102 %
Limits: 54-127 %
"
"
"
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 18 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Analyte
MDL
2B (A6B0900-05)
Reporting
Limit
Dilution
Units
Matrix: Soil
Date Analyzed
Method
Acenaphthene
ND
---
0.0180
mg/kg dry
02/27/16 15:54
Acenaphthylene
ND
---
0.0180
"
"
"
"
Anthracene
ND
---
0.0180
"
"
"
"
Benz(a)anthracene
ND
---
0.0180
"
"
"
"
Benzo(a)pyrene
ND
---
0.0180
"
"
"
"
Benzo(b)fluoranthene
ND
---
0.0180
"
"
"
"
Benzo(k)fluoranthene
ND
---
0.0180
"
"
"
"
Benzo(g,h,i)perylene
ND
---
0.0180
"
"
"
"
Chrysene
ND
---
0.0180
"
"
"
"
Dibenz(a,h)anthracene
ND
---
0.0180
"
"
"
"
Dibenzofuran
ND
---
0.0180
"
"
"
"
Fluoranthene
ND
---
0.0180
"
"
"
"
Fluorene
ND
---
0.0180
"
"
"
"
Indeno(1,2,3-cd)pyrene
ND
---
0.0180
"
"
"
"
1-Methylnaphthalene
ND
---
0.0180
"
"
"
"
2-Methylnaphthalene
ND
---
0.0180
"
"
"
"
Naphthalene
ND
---
0.0180
"
"
"
"
Phenanthrene
ND
---
0.0180
"
"
"
"
Pyrene
ND
---
0.0180
"
"
"
"
DRAFT REPORT
Notes
Batch: 6020836
Recovery: 80 %
Limits: 44-115 %
"
"
"
98 %
Limits: 54-127 %
"
"
"
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 19 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Analyte
MDL
2D (A6B0900-07)
Reporting
Limit
Dilution
Units
Matrix: Soil
Date Analyzed
Method
Acenaphthene
ND
---
0.0180
mg/kg dry
02/27/16 13:37
Acenaphthylene
ND
---
0.0180
"
"
"
"
Anthracene
ND
---
0.0180
"
"
"
"
Benz(a)anthracene
ND
---
0.0198
"
"
"
"
Benzo(a)pyrene
ND
---
0.0180
"
"
"
"
Benzo(b)fluoranthene
0.0249
---
0.0180
"
"
"
"
Benzo(k)fluoranthene
ND
---
0.0180
"
"
"
"
Benzo(g,h,i)perylene
ND
---
0.0180
"
"
"
"
Chrysene
ND
---
0.0207
"
"
"
"
Dibenz(a,h)anthracene
ND
---
0.0180
"
"
"
"
Dibenzofuran
ND
---
0.0180
"
"
"
"
Fluoranthene
ND
---
0.0180
"
"
"
"
0.0229
---
0.0180
"
"
"
"
Indeno(1,2,3-cd)pyrene
ND
---
0.0180
"
"
"
"
1-Methylnaphthalene
0.0284
---
0.0180
"
"
"
"
2-Methylnaphthalene
0.0433
---
0.0180
"
"
"
"
Naphthalene
0.0502
---
0.0180
"
"
"
"
Phenanthrene
0.0229
---
0.0180
"
"
"
"
ND
---
0.0180
"
"
"
"
Fluorene
Pyrene
Surrogate: 2-Fluorobiphenyl (Surr)
p-Terphenyl-d14 (Surr)
DRAFT REPORT
Notes
Batch: 6020836
Recovery: 84 %
Limits: 44-115 %
"
"
"
102 %
Limits: 54-127 %
"
"
"
R-02
M-02
R-02
M-02
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 20 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Analyte
MDL
3A (A6B0900-08)
Reporting
Limit
Dilution
Units
Matrix: Soil
Date Analyzed
Method
Acenaphthene
ND
---
0.0136
mg/kg dry
02/27/16 16:21
Acenaphthylene
ND
---
0.0136
"
"
"
"
Anthracene
ND
---
0.0136
"
"
"
"
Benz(a)anthracene
ND
---
0.0136
"
"
"
"
Benzo(a)pyrene
ND
---
0.0136
"
"
"
"
Benzo(b)fluoranthene
ND
---
0.0136
"
"
"
"
Benzo(k)fluoranthene
ND
---
0.0136
"
"
"
"
Benzo(g,h,i)perylene
ND
---
0.0136
"
"
"
"
Chrysene
ND
---
0.0136
"
"
"
"
Dibenz(a,h)anthracene
ND
---
0.0136
"
"
"
"
Dibenzofuran
ND
---
0.0136
"
"
"
"
Fluoranthene
ND
---
0.0136
"
"
"
"
Fluorene
ND
---
0.0136
"
"
"
"
Indeno(1,2,3-cd)pyrene
ND
---
0.0136
"
"
"
"
1-Methylnaphthalene
ND
---
0.0136
"
"
"
"
2-Methylnaphthalene
ND
---
0.0136
"
"
"
"
Naphthalene
ND
---
0.0136
"
"
"
"
Phenanthrene
ND
---
0.0136
"
"
"
"
Pyrene
ND
---
0.0136
"
"
"
"
DRAFT REPORT
Notes
Batch: 6020836
Recovery: 87 %
Limits: 44-115 %
"
"
"
107 %
Limits: 54-127 %
"
"
"
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 21 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Analyte
MDL
3B (A6B0900-09)
Reporting
Limit
Dilution
Units
Matrix: Soil
Date Analyzed
Method
Acenaphthene
ND
---
0.0129
mg/kg dry
02/27/16 16:48
Acenaphthylene
ND
---
0.0129
"
"
"
"
Anthracene
ND
---
0.0129
"
"
"
"
Benz(a)anthracene
ND
---
0.0129
"
"
"
"
Benzo(a)pyrene
ND
---
0.0129
"
"
"
"
Benzo(b)fluoranthene
ND
---
0.0129
"
"
"
"
Benzo(k)fluoranthene
ND
---
0.0129
"
"
"
"
Benzo(g,h,i)perylene
ND
---
0.0129
"
"
"
"
Chrysene
ND
---
0.0129
"
"
"
"
Dibenz(a,h)anthracene
ND
---
0.0129
"
"
"
"
Dibenzofuran
ND
---
0.0129
"
"
"
"
Fluoranthene
ND
---
0.0129
"
"
"
"
Fluorene
ND
---
0.0129
"
"
"
"
Indeno(1,2,3-cd)pyrene
ND
---
0.0129
"
"
"
"
1-Methylnaphthalene
ND
---
0.0129
"
"
"
"
2-Methylnaphthalene
ND
---
0.0129
"
"
"
"
Naphthalene
ND
---
0.0129
"
"
"
"
Phenanthrene
ND
---
0.0129
"
"
"
"
Pyrene
ND
---
0.0129
"
"
"
"
DRAFT REPORT
Notes
Batch: 6020836
Recovery: 92 %
Limits: 44-115 %
"
"
"
109 %
Limits: 54-127 %
"
"
"
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 22 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Analyte
MDL
3C (A6B0900-10)
Reporting
Limit
Dilution
Units
Matrix: Soil
Date Analyzed
Method
Acenaphthene
ND
---
0.0135
mg/kg dry
02/27/16 17:15
Acenaphthylene
ND
---
0.0135
"
"
"
"
Anthracene
ND
---
0.0135
"
"
"
"
Benz(a)anthracene
ND
---
0.0135
"
"
"
"
Benzo(a)pyrene
ND
---
0.0135
"
"
"
"
Benzo(b)fluoranthene
ND
---
0.0135
"
"
"
"
Benzo(k)fluoranthene
ND
---
0.0135
"
"
"
"
Benzo(g,h,i)perylene
ND
---
0.0135
"
"
"
"
Chrysene
ND
---
0.0135
"
"
"
"
Dibenz(a,h)anthracene
ND
---
0.0135
"
"
"
"
Dibenzofuran
ND
---
0.0135
"
"
"
"
Fluoranthene
ND
---
0.0135
"
"
"
"
Fluorene
ND
---
0.0135
"
"
"
"
Indeno(1,2,3-cd)pyrene
ND
---
0.0135
"
"
"
"
1-Methylnaphthalene
ND
---
0.0135
"
"
"
"
2-Methylnaphthalene
ND
---
0.0135
"
"
"
"
Naphthalene
ND
---
0.0135
"
"
"
"
Phenanthrene
ND
---
0.0135
"
"
"
"
Pyrene
ND
---
0.0135
"
"
"
"
DRAFT REPORT
Notes
Batch: 6020836
Recovery: 89 %
Limits: 44-115 %
"
"
"
109 %
Limits: 54-127 %
"
"
"
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 23 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Analyte
MDL
3D (A6B0900-11)
Reporting
Limit
Dilution
Units
Matrix: Soil
Date Analyzed
Method
Acenaphthene
ND
---
0.0138
mg/kg dry
02/27/16 18:09
Acenaphthylene
ND
---
0.0138
"
"
"
"
Anthracene
ND
---
0.0138
"
"
"
"
Benz(a)anthracene
ND
---
0.0138
"
"
"
"
Benzo(a)pyrene
ND
---
0.0138
"
"
"
"
Benzo(b)fluoranthene
ND
---
0.0138
"
"
"
"
Benzo(k)fluoranthene
ND
---
0.0138
"
"
"
"
Benzo(g,h,i)perylene
ND
---
0.0138
"
"
"
"
Chrysene
ND
---
0.0138
"
"
"
"
Dibenz(a,h)anthracene
ND
---
0.0138
"
"
"
"
Dibenzofuran
ND
---
0.0138
"
"
"
"
Fluoranthene
ND
---
0.0138
"
"
"
"
Fluorene
ND
---
0.0138
"
"
"
"
Indeno(1,2,3-cd)pyrene
ND
---
0.0138
"
"
"
"
1-Methylnaphthalene
ND
---
0.0138
"
"
"
"
2-Methylnaphthalene
ND
---
0.0138
"
"
"
"
Naphthalene
ND
---
0.0138
"
"
"
"
Phenanthrene
ND
---
0.0138
"
"
"
"
Pyrene
ND
---
0.0138
"
"
"
"
DRAFT REPORT
Notes
Batch: 6020836
Recovery: 86 %
Limits: 44-115 %
"
"
"
100 %
Limits: 54-127 %
"
"
"
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 24 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Analyte
MDL
4A (A6B0900-12)
Reporting
Limit
Dilution
Units
Matrix: Soil
Date Analyzed
Method
Acenaphthene
ND
---
0.0149
mg/kg dry
02/27/16 18:36
Acenaphthylene
ND
---
0.0149
"
"
"
"
Anthracene
ND
---
0.0149
"
"
"
"
Benz(a)anthracene
ND
---
0.0149
"
"
"
"
Benzo(a)pyrene
ND
---
0.0149
"
"
"
"
Benzo(b)fluoranthene
ND
---
0.0149
"
"
"
"
Benzo(k)fluoranthene
ND
---
0.0149
"
"
"
"
Benzo(g,h,i)perylene
ND
---
0.0149
"
"
"
"
Chrysene
ND
---
0.0149
"
"
"
"
Dibenz(a,h)anthracene
ND
---
0.0149
"
"
"
"
Dibenzofuran
ND
---
0.0149
"
"
"
"
Fluoranthene
ND
---
0.0149
"
"
"
"
Fluorene
ND
---
0.0149
"
"
"
"
Indeno(1,2,3-cd)pyrene
ND
---
0.0149
"
"
"
"
1-Methylnaphthalene
ND
---
0.0149
"
"
"
"
2-Methylnaphthalene
ND
---
0.0149
"
"
"
"
Naphthalene
ND
---
0.0149
"
"
"
"
Phenanthrene
ND
---
0.0149
"
"
"
"
Pyrene
ND
---
0.0149
"
"
"
"
DRAFT REPORT
Notes
Batch: 6020836
Recovery: 86 %
Limits: 44-115 %
"
"
"
102 %
Limits: 54-127 %
"
"
"
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 25 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Analyte
MDL
4B (A6B0900-13)
Reporting
Limit
Dilution
Units
Matrix: Soil
Date Analyzed
Method
Acenaphthene
ND
---
0.0123
mg/kg dry
02/27/16 19:02
Acenaphthylene
ND
---
0.0123
"
"
"
"
Anthracene
ND
---
0.0123
"
"
"
"
Benz(a)anthracene
ND
---
0.0123
"
"
"
"
Benzo(a)pyrene
ND
---
0.0123
"
"
"
"
Benzo(b)fluoranthene
ND
---
0.0123
"
"
"
"
Benzo(k)fluoranthene
ND
---
0.0123
"
"
"
"
Benzo(g,h,i)perylene
ND
---
0.0123
"
"
"
"
Chrysene
ND
---
0.0123
"
"
"
"
Dibenz(a,h)anthracene
ND
---
0.0123
"
"
"
"
Dibenzofuran
ND
---
0.0123
"
"
"
"
Fluoranthene
ND
---
0.0123
"
"
"
"
Fluorene
ND
---
0.0123
"
"
"
"
Indeno(1,2,3-cd)pyrene
ND
---
0.0123
"
"
"
"
1-Methylnaphthalene
ND
---
0.0123
"
"
"
"
2-Methylnaphthalene
ND
---
0.0123
"
"
"
"
Naphthalene
ND
---
0.0123
"
"
"
"
Phenanthrene
ND
---
0.0123
"
"
"
"
Pyrene
ND
---
0.0123
"
"
"
"
DRAFT REPORT
Notes
Batch: 6020836
Recovery: 95 %
Limits: 44-115 %
"
"
"
119 %
Limits: 54-127 %
"
"
"
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 26 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Analyte
MDL
4C (A6B0900-14)
Reporting
Limit
Dilution
Units
Matrix: Soil
Date Analyzed
Method
Acenaphthene
ND
---
0.0144
mg/kg dry
02/27/16 19:29
Acenaphthylene
ND
---
0.0144
"
"
"
"
Anthracene
ND
---
0.0144
"
"
"
"
Benz(a)anthracene
ND
---
0.0144
"
"
"
"
Benzo(a)pyrene
ND
---
0.0144
"
"
"
"
Benzo(b)fluoranthene
ND
---
0.0144
"
"
"
"
Benzo(k)fluoranthene
ND
---
0.0144
"
"
"
"
Benzo(g,h,i)perylene
ND
---
0.0144
"
"
"
"
Chrysene
ND
---
0.0144
"
"
"
"
Dibenz(a,h)anthracene
ND
---
0.0144
"
"
"
"
Dibenzofuran
ND
---
0.0144
"
"
"
"
Fluoranthene
ND
---
0.0144
"
"
"
"
Fluorene
ND
---
0.0144
"
"
"
"
Indeno(1,2,3-cd)pyrene
ND
---
0.0144
"
"
"
"
1-Methylnaphthalene
ND
---
0.0144
"
"
"
"
2-Methylnaphthalene
ND
---
0.0144
"
"
"
"
Naphthalene
ND
---
0.0144
"
"
"
"
Phenanthrene
ND
---
0.0144
"
"
"
"
Pyrene
ND
---
0.0144
"
"
"
"
DRAFT REPORT
Notes
Batch: 6020836
Recovery: 91 %
Limits: 44-115 %
"
"
"
115 %
Limits: 54-127 %
"
"
"
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 27 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Analyte
MDL
4D (A6B0900-15)
Reporting
Limit
Dilution
Units
Matrix: Soil
Date Analyzed
Method
Acenaphthene
ND
---
0.0120
mg/kg dry
02/27/16 19:56
Acenaphthylene
ND
---
0.0120
"
"
"
"
Anthracene
ND
---
0.0120
"
"
"
"
Benz(a)anthracene
ND
---
0.0120
"
"
"
"
Benzo(a)pyrene
ND
---
0.0120
"
"
"
"
Benzo(b)fluoranthene
ND
---
0.0120
"
"
"
"
Benzo(k)fluoranthene
ND
---
0.0120
"
"
"
"
Benzo(g,h,i)perylene
ND
---
0.0120
"
"
"
"
Chrysene
ND
---
0.0120
"
"
"
"
Dibenz(a,h)anthracene
ND
---
0.0120
"
"
"
"
Dibenzofuran
ND
---
0.0120
"
"
"
"
Fluoranthene
ND
---
0.0120
"
"
"
"
Fluorene
ND
---
0.0120
"
"
"
"
Indeno(1,2,3-cd)pyrene
ND
---
0.0120
"
"
"
"
1-Methylnaphthalene
ND
---
0.0120
"
"
"
"
2-Methylnaphthalene
ND
---
0.0120
"
"
"
"
Naphthalene
ND
---
0.0120
"
"
"
"
Phenanthrene
ND
---
0.0120
"
"
"
"
Pyrene
ND
---
0.0120
"
"
"
"
DRAFT REPORT
Notes
Batch: 6020836
Recovery: 92 %
Limits: 44-115 %
"
"
"
115 %
Limits: 54-127 %
"
"
"
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 28 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Analyte
MDL
0A (A6B0900-16)
Reporting
Limit
Dilution
Units
Matrix: Soil
Date Analyzed
Method
Acenaphthene
ND
---
0.0173
mg/kg dry
02/27/16 20:23
Acenaphthylene
ND
---
0.0173
"
"
"
"
Anthracene
ND
---
0.0173
"
"
"
"
Benz(a)anthracene
ND
---
0.0173
"
"
"
"
Benzo(a)pyrene
ND
---
0.0173
"
"
"
"
Benzo(b)fluoranthene
ND
---
0.0173
"
"
"
"
Benzo(k)fluoranthene
ND
---
0.0173
"
"
"
"
Benzo(g,h,i)perylene
ND
---
0.0173
"
"
"
"
Chrysene
ND
---
0.0173
"
"
"
"
Dibenz(a,h)anthracene
ND
---
0.0173
"
"
"
"
Dibenzofuran
ND
---
0.0173
"
"
"
"
Fluoranthene
ND
---
0.0173
"
"
"
"
Fluorene
ND
---
0.0173
"
"
"
"
Indeno(1,2,3-cd)pyrene
ND
---
0.0173
"
"
"
"
1-Methylnaphthalene
ND
---
0.0173
"
"
"
"
2-Methylnaphthalene
ND
---
0.0173
"
"
"
"
Naphthalene
ND
---
0.0173
"
"
"
"
Phenanthrene
ND
---
0.0173
"
"
"
"
Pyrene
ND
---
0.0173
"
"
"
"
DRAFT REPORT
Notes
Batch: 6020836
Recovery: 91 %
Limits: 44-115 %
"
"
"
111 %
Limits: 54-127 %
"
"
"
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 29 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Analyte
MDL
0B (A6B0900-17)
Reporting
Limit
Dilution
Units
Matrix: Soil
Date Analyzed
Method
Acenaphthene
ND
---
0.0167
mg/kg dry
02/27/16 20:49
Acenaphthylene
ND
---
0.0167
"
"
"
"
Anthracene
ND
---
0.0167
"
"
"
"
Benz(a)anthracene
ND
---
0.0167
"
"
"
"
Benzo(a)pyrene
ND
---
0.0167
"
"
"
"
Benzo(b)fluoranthene
ND
---
0.0167
"
"
"
"
Benzo(k)fluoranthene
ND
---
0.0167
"
"
"
"
Benzo(g,h,i)perylene
ND
---
0.0167
"
"
"
"
Chrysene
ND
---
0.0167
"
"
"
"
Dibenz(a,h)anthracene
ND
---
0.0167
"
"
"
"
Dibenzofuran
0.0620
---
0.0167
"
"
"
"
Fluoranthene
ND
---
0.0167
"
"
"
"
Fluorene
ND
---
0.0401
"
"
"
"
Indeno(1,2,3-cd)pyrene
ND
---
0.0167
"
"
"
"
1-Methylnaphthalene
0.114
---
0.0167
"
"
"
"
2-Methylnaphthalene
0.155
---
0.0167
"
"
"
"
ND
---
0.0301
"
"
"
"
Phenanthrene
0.0489
---
0.0167
"
"
"
"
Pyrene
0.0411
---
0.0167
"
"
"
"
Naphthalene
DRAFT REPORT
Notes
Batch: 6020836
Recovery: 100 %
Limits: 44-115 %
"
"
"
118 %
Limits: 54-127 %
"
"
"
R-02
R-02
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 30 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Analyte
MDL
0C (A6B0900-18)
Reporting
Limit
Dilution
Units
Matrix: Soil
Date Analyzed
Method
Notes
Batch: 6020836
Acenaphthene
ND
---
0.208
mg/kg dry
02/27/16 21:16
R-02
Acenaphthylene
ND
---
0.0763
"
"
"
"
R-02
Anthracene
ND
---
0.104
"
"
"
"
R-02
Benz(a)anthracene
ND
---
0.0242
"
"
"
"
R-02
Benzo(a)pyrene
ND
---
0.0186
"
"
"
"
Benzo(b)fluoranthene
ND
---
0.0186
"
"
"
"
Benzo(k)fluoranthene
ND
---
0.0186
"
"
"
"
Benzo(g,h,i)perylene
ND
---
0.0186
"
"
"
"
Chrysene
ND
---
0.0260
"
"
"
"
Dibenz(a,h)anthracene
ND
---
0.0186
"
"
"
"
Dibenzofuran
0.376
---
0.0186
"
"
"
"
Fluoranthene
ND
---
0.0186
"
"
"
"
0.454
---
0.0186
"
"
"
"
ND
---
0.0186
"
"
"
"
Fluorene
Indeno(1,2,3-cd)pyrene
1-Methylnaphthalene
3.29
---
0.0186
"
"
"
"
2-Methylnaphthalene
5.58
---
0.0186
"
"
"
"
Naphthalene
2.08
---
0.0186
"
"
"
"
Phenanthrene
0.740
---
0.0186
"
"
"
"
Pyrene
0.389
---
0.0186
"
"
"
"
DRAFT REPORT
Recovery: 78 %
Limits: 44-115 %
"
"
"
112 %
Limits: 54-127 %
"
"
"
R-02
M-04
M-02
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 31 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Analyte
MDL
Ex Sidewall S (A6B0900-19)
Reporting
Limit
Dilution
Units
Matrix: Soil
Date Analyzed
Method
Acenaphthene
ND
---
0.0107
mg/kg dry
02/27/16 21:43
Acenaphthylene
ND
---
0.0107
"
"
"
"
Anthracene
ND
---
0.0107
"
"
"
"
Benz(a)anthracene
ND
---
0.0107
"
"
"
"
Benzo(a)pyrene
ND
---
0.0107
"
"
"
"
Benzo(b)fluoranthene
ND
---
0.0107
"
"
"
"
Benzo(k)fluoranthene
ND
---
0.0107
"
"
"
"
Benzo(g,h,i)perylene
ND
---
0.0107
"
"
"
"
Chrysene
ND
---
0.0107
"
"
"
"
Dibenz(a,h)anthracene
ND
---
0.0107
"
"
"
"
Dibenzofuran
ND
---
0.0107
"
"
"
"
Fluoranthene
ND
---
0.0107
"
"
"
"
Fluorene
ND
---
0.0107
"
"
"
"
Indeno(1,2,3-cd)pyrene
ND
---
0.0107
"
"
"
"
1-Methylnaphthalene
ND
---
0.0107
"
"
"
"
2-Methylnaphthalene
ND
---
0.0107
"
"
"
"
Naphthalene
ND
---
0.0107
"
"
"
"
Phenanthrene
ND
---
0.0107
"
"
"
"
Pyrene
ND
---
0.0107
"
"
"
"
DRAFT REPORT
Notes
Batch: 6020836
Recovery: 97 %
Limits: 44-115 %
"
"
"
123 %
Limits: 54-127 %
"
"
"
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 32 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Analyte
MDL
Ex Sidewall W (A6B0900-20)
Reporting
Limit
Dilution
Units
Matrix: Soil
Date Analyzed
Method
Acenaphthene
ND
---
0.0134
mg/kg dry
02/27/16 22:10
Acenaphthylene
ND
---
0.0134
"
"
"
"
Anthracene
ND
---
0.0134
"
"
"
"
Benz(a)anthracene
ND
---
0.0134
"
"
"
"
Benzo(a)pyrene
ND
---
0.0134
"
"
"
"
Benzo(b)fluoranthene
ND
---
0.0134
"
"
"
"
Benzo(k)fluoranthene
ND
---
0.0134
"
"
"
"
Benzo(g,h,i)perylene
ND
---
0.0134
"
"
"
"
Chrysene
ND
---
0.0134
"
"
"
"
Dibenz(a,h)anthracene
ND
---
0.0134
"
"
"
"
Dibenzofuran
ND
---
0.0134
"
"
"
"
Fluoranthene
ND
---
0.0134
"
"
"
"
Fluorene
ND
---
0.0134
"
"
"
"
Indeno(1,2,3-cd)pyrene
ND
---
0.0134
"
"
"
"
1-Methylnaphthalene
ND
---
0.0134
"
"
"
"
2-Methylnaphthalene
ND
---
0.0134
"
"
"
"
Naphthalene
ND
---
0.0134
"
"
"
"
Phenanthrene
ND
---
0.0134
"
"
"
"
Pyrene
ND
---
0.0134
"
"
"
"
DRAFT REPORT
Notes
Batch: 6020836
Recovery: 93 %
Limits: 44-115 %
"
"
"
114 %
Limits: 54-127 %
"
"
"
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 33 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Analyte
MDL
Ex Sidewall E (A6B0900-21)
Acenaphthene
Reporting
Limit
Dilution
Units
Matrix: Soil
Date Analyzed
Method
Notes
Batch: 6020836
ND
---
0.0105
mg/kg dry
02/27/16 22:36
Acenaphthylene
0.0181
---
0.0105
"
"
"
"
Anthracene
0.0526
---
0.0105
"
"
"
"
Benz(a)anthracene
0.635
---
0.0105
"
"
"
"
Benzo(a)pyrene
0.219
---
0.0105
"
"
"
"
Benzo(b)fluoranthene
0.603
---
0.0105
"
"
"
"
M-02, Q-42
Benzo(k)fluoranthene
0.206
---
0.0105
"
"
"
"
M-02
Benzo(g,h,i)perylene
0.0799
---
0.0105
"
"
"
"
Chrysene
0.947
---
0.0105
"
"
"
"
Dibenz(a,h)anthracene
0.0306
---
0.0105
"
"
"
"
Dibenzofuran
ND
---
0.0105
"
"
"
"
Fluoranthene
1.86
---
0.0105
"
"
"
"
Fluorene
ND
---
0.0105
"
"
"
"
0.116
---
0.0105
"
"
"
"
Indeno(1,2,3-cd)pyrene
1-Methylnaphthalene
ND
---
0.0105
"
"
"
"
2-Methylnaphthalene
0.0135
---
0.0105
"
"
"
"
ND
---
0.0105
"
"
"
"
0.0119
---
0.0105
"
"
"
"
1.60
---
0.0105
"
"
"
"
Naphthalene
Phenanthrene
Pyrene
Surrogate: 2-Fluorobiphenyl (Surr)
p-Terphenyl-d14 (Surr)
DRAFT REPORT
Recovery: 95 %
Limits: 44-115 %
"
"
"
121 %
Limits: 54-127 %
"
"
"
Q-42
Q-42
Q-42
Q-42
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 34 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Result
MDL
1A (A6B0900-01)
% Solids
Matrix: Soil
65.4
---
57.4
---
44.8
---
72.9
---
1B (A6B0900-02)
% Solids
49.6
---
36.0
---
53.9
---
68.4
---
75.0
---
67.6
---
63.3
---
64.6
---
74.8
---
67.9
---
76.7
---
49.2
---
1.00
Matrix: Soil
0A (A6B0900-16)
% Solids
1.00
Matrix: Soil
4D (A6B0900-15)
% Solids
1.00
Matrix: Soil
4C (A6B0900-14)
% Solids
1.00
Matrix: Soil
4B (A6B0900-13)
% Solids
1.00
Matrix: Soil
4A (A6B0900-12)
% Solids
1.00
Matrix: Soil
3D (A6B0900-11)
% Solids
1.00
Matrix: Soil
3C (A6B0900-10)
% Solids
1.00
Matrix: Soil
3B (A6B0900-09)
% Solids
1.00
Matrix: Soil
3A (A6B0900-08)
% Solids
1.00
Matrix: Soil
2D (A6B0900-07)
% Solids
1.00
Matrix: Soil
2C (A6B0900-06)
% Solids
1.00
Matrix: Soil
2B (A6B0900-05)
% Solids
1.00
Matrix: Soil
2A (A6B0900-04)
% Solids
1.00
Matrix: Soil
1C (A6B0900-03)
% Solids
Reporting
Limit
1.00
Matrix: Soil
DRAFT REPORT
1.00
Dilution
Units
Date Analyzed
Method
02/27/16 13:34
EPA 8000C
02/27/16 13:34
EPA 8000C
02/27/16 13:34
EPA 8000C
02/27/16 13:34
EPA 8000C
02/27/16 13:34
EPA 8000C
02/27/16 13:34
EPA 8000C
02/27/16 13:34
EPA 8000C
02/27/16 13:34
EPA 8000C
02/27/16 13:34
EPA 8000C
02/27/16 13:34
EPA 8000C
02/27/16 13:34
EPA 8000C
02/27/16 13:34
EPA 8000C
02/27/16 13:34
EPA 8000C
02/27/16 13:34
EPA 8000C
02/27/16 13:34
EPA 8000C
02/27/16 13:34
EPA 8000C
Notes
Batch: 6020837
% by Weight
Batch: 6020837
% by Weight
Batch: 6020837
% by Weight
Batch: 6020837
% by Weight
Batch: 6020837
% by Weight
Batch: 6020837
% by Weight
Batch: 6020837
% by Weight
Batch: 6020837
% by Weight
Batch: 6020837
% by Weight
Batch: 6020837
% by Weight
Batch: 6020837
% by Weight
Batch: 6020837
% by Weight
Batch: 6020837
% by Weight
Batch: 6020837
% by Weight
Batch: 6020837
% by Weight
Batch: 6020837
% by Weight
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 35 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Result
MDL
55.4
---
0B (A6B0900-17)
% Solids
Matrix: Soil
0C (A6B0900-18)
% Solids
51.2
---
91.7
---
71.1
---
82.9
---
1.00
Matrix: Soil
Ex Sidewall E (A6B0900-21)
% Solids
1.00
Matrix: Soil
Ex Sidewall W (A6B0900-20)
% Solids
1.00
Matrix: Soil
Ex Sidewall S (A6B0900-19)
% Solids
Reporting
Limit
1.00
Matrix: Soil
DRAFT REPORT
1.00
Dilution
Units
Date Analyzed
Method
02/27/16 13:34
EPA 8000C
02/27/16 13:34
EPA 8000C
02/27/16 13:34
EPA 8000C
02/27/16 13:34
EPA 8000C
02/27/16 13:34
EPA 8000C
Notes
Batch: 6020837
% by Weight
Batch: 6020837
% by Weight
Batch: 6020837
% by Weight
Batch: 6020837
% by Weight
Batch: 6020837
% by Weight
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 36 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Result
Reporting
Limit
MDL
Units
Dil.
Spike
Amount
Source
Result
%REC
%REC
Limits RPD
RPD
Limit
Notes
Soil
Blank (6020835-BLK1)
NWTPH-Dx
Diesel
ND
---
25.0
mg/kg wet
---
---
---
---
---
---
Oil
ND
---
50.0
"
"
---
---
---
---
---
---
---
---
Recovery: 97 %
Limits: 50-150 %
Dilution: 1x
LCS (6020835-BS1)
NWTPH-Dx
Diesel
119
---
25.0
Recovery: 98 %
mg/kg wet
125
Limits: 50-150 %
---
95
76-115%
Dilution: 1x
Duplicate (6020835-DUP1)
QC Source Sample: 1C (A6B0900-03)
NWTPH-Dx
Diesel
Oil
54200
---
2010
mg/kg dry
50
---
66400
---
---
20
30%
ND
---
4030
"
"
---
ND
---
---
---
30%
Recovery: %
Limits: 50-150 %
Dilution: 50x
S-01
Soil
Blank (6020836-BLK1)
NWTPH-Dx
Diesel
ND
---
25.0
mg/kg wet
---
---
---
---
---
---
Oil
ND
---
50.0
"
"
---
---
---
---
---
---
---
---
34
30%
Recovery: 92 %
Limits: 50-150 %
Dilution: 1x
LCS (6020836-BS1)
NWTPH-Dx
Diesel
120
---
25.0
Recovery: 88 %
mg/kg wet
125
Limits: 50-150 %
---
96
76-115%
Dilution: 1x
Duplicate (6020836-DUP1)
QC Source Sample: 1A (A6B0900-01)
NWTPH-Dx
Diesel
33.9
---
DRAFT REPORT
26.9
mg/kg dry
---
24.2
---
---
F-17, Q-05
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 37 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Result
Reporting
Limit
MDL
Units
Dil.
Spike
Amount
Source
Result
%REC
%REC
Limits RPD
RPD
Limit
Notes
42
30%
F-17, Q-05
Soil
Duplicate (6020836-DUP1)
QC Source Sample: 1A (A6B0900-01)
Oil
188
---
53.7
Recovery: 89 %
mg/kg dry
"
---
Limits: 50-150 %
123
---
---
Dilution: 1x
Duplicate (6020836-DUP2)
QC Source Sample: 3C (A6B0900-10)
NWTPH-Dx
Diesel
34.3
---
27.3
mg/kg dry
---
23.7
---
---
36
30%
F-17, Q-05
Oil
122
---
54.6
"
"
---
98.7
---
---
21
30%
F-17
Recovery: 88 %
DRAFT REPORT
Limits: 50-150 %
Dilution: 1x
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 38 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Result
MDL
Reporting
Limit
Units
Dil.
Spike
Amount
Source
Result
%REC
%REC
Limits RPD
RPD
Limit
Notes
Soil
Blank (6020833-BLK1)
5035/8260B
Benzene
ND
---
0.00667
mg/kg wet
50
---
---
---
---
---
---
Toluene
ND
---
0.0333
"
"
---
---
---
---
---
---
Ethylbenzene
ND
---
0.0167
"
"
---
---
---
---
---
---
Xylenes, total
ND
---
0.0500
"
"
---
---
---
---
---
---
Naphthalene
ND
---
0.0667
"
"
---
---
---
---
---
---
ND
---
0.0333
"
"
---
---
---
---
---
---
ND
---
0.0333
"
"
---
---
---
---
---
---
n-Propylbenzene
ND
---
0.0167
"
"
---
---
---
---
---
---
1,2,4-Trimethylbenzene
ND
---
0.0333
"
"
---
---
---
---
---
---
1,3,5-Trimethylbenzene
ND
---
0.0333
"
"
---
---
---
---
---
---
1,2-Dibromoethane (EDB)
ND
---
0.0167
"
"
---
---
---
---
---
---
1,2-Dichloroethane (EDC)
ND
---
0.0167
"
"
---
---
---
---
---
---
---
---
Recovery: 107 %
Limits: 70-130 %
Dilution: 1x
103 %
70-130 %
"
Toluene-d8 (Surr)
98 %
70-130 %
"
4-Bromofluorobenzene (Surr)
97 %
70-130 %
"
1,4-Difluorobenzene (Surr)
LCS (6020833-BS1)
5035/8260B
Benzene
1.08
---
0.0100
mg/kg wet
50
1.00
---
108
65-135%
Toluene
1.02
---
0.0500
"
"
"
---
102
"
---
---
Ethylbenzene
0.979
---
0.0250
"
"
"
---
98
"
---
---
Xylenes, total
2.85
---
0.0750
"
"
3.00
---
95
"
---
---
Naphthalene
0.948
---
0.100
"
"
1.00
---
95
"
---
---
1.01
---
0.0500
"
"
"
---
101
"
---
---
0.982
---
0.0500
"
"
"
---
98
"
---
---
n-Propylbenzene
0.991
---
0.0250
"
"
"
---
99
"
---
---
1,2,4-Trimethylbenzene
0.983
---
0.0500
"
"
"
---
98
"
---
---
1,3,5-Trimethylbenzene
0.996
---
0.0500
"
"
"
---
100
"
---
---
1,2-Dibromoethane (EDB)
1.08
---
0.0250
"
"
"
---
108
"
---
---
DRAFT REPORT
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 39 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Result
MDL
Reporting
Limit
Units
Dil.
Spike
Amount
%REC
%REC
Limits RPD
RPD
Limit
Notes
Soil
LCS (6020833-BS1)
1,2-Dichloroethane (EDC)
Source
Result
0.986
---
0.0250
mg/kg wet
"
"
---
Recovery: 102 %
Limits: 70-130 %
Dilution: 1x
102 %
70-130 %
"
Toluene-d8 (Surr)
97 %
70-130 %
"
4-Bromofluorobenzene (Surr)
97 %
70-130 %
"
1,4-Difluorobenzene (Surr)
99
"
---
---
Duplicate (6020833-DUP1)
QC Source Sample: 1A (A6B0900-01)
5035/8260B
Benzene
ND
---
0.0198
mg/kg dry
50
---
ND
---
---
---
30%
Toluene
ND
---
0.0988
"
"
---
ND
---
---
---
30%
Ethylbenzene
ND
---
0.0494
"
"
---
ND
---
---
---
30%
Xylenes, total
ND
---
0.148
"
"
---
ND
---
---
---
30%
Naphthalene
ND
---
0.198
"
"
---
ND
---
---
---
30%
ND
---
0.0988
"
"
---
ND
---
---
---
30%
ND
---
0.0988
"
"
---
ND
---
---
---
30%
n-Propylbenzene
ND
---
0.0494
"
"
---
ND
---
---
---
30%
1,2,4-Trimethylbenzene
ND
---
0.0988
"
"
---
ND
---
---
---
30%
1,3,5-Trimethylbenzene
ND
---
0.0988
"
"
---
ND
---
---
---
30%
1,2-Dibromoethane (EDB)
ND
---
0.0494
"
"
---
ND
---
---
---
30%
1,2-Dichloroethane (EDC)
ND
---
0.0494
"
"
---
ND
---
---
---
30%
Recovery: 104 %
Limits: 70-130 %
Dilution: 1x
101 %
70-130 %
"
Toluene-d8 (Surr)
99 %
70-130 %
"
4-Bromofluorobenzene (Surr)
93 %
70-130 %
"
1,4-Difluorobenzene (Surr)
Benzene
1.75
---
0.0162
mg/kg dry
50
1.62
ND
108
65-135%
---
---
Toluene
1.64
---
0.0809
"
"
"
ND
101
"
---
---
Ethylbenzene
1.59
---
0.0404
"
"
"
ND
98
"
---
---
DRAFT REPORT
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 40 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Result
MDL
Reporting
Limit
Units
Dil.
Spike
Amount
Source
Result
%REC
%REC
Limits RPD
RPD
Limit
Notes
Soil
Xylenes, total
4.58
---
0.121
mg/kg dry
"
4.86
ND
94
"
---
---
Naphthalene
1.39
---
0.162
"
"
1.62
ND
86
"
---
---
1.63
---
0.0809
"
"
"
ND
101
"
---
---
1.57
---
0.0809
"
"
"
ND
97
"
---
---
n-Propylbenzene
1.55
---
0.0404
"
"
"
ND
96
"
---
---
1,2,4-Trimethylbenzene
1.51
---
0.0809
"
"
"
ND
93
"
---
---
1,3,5-Trimethylbenzene
1.55
---
0.0809
"
"
"
ND
96
"
---
---
1,2-Dibromoethane (EDB)
1.67
---
0.0404
"
"
"
ND
103
"
---
---
1,2-Dichloroethane (EDC)
1.67
---
0.0404
"
"
"
ND
103
"
---
---
Recovery: 103 %
Limits: 70-130 %
Dilution: 1x
1,4-Difluorobenzene (Surr)
99 %
70-130 %
"
Toluene-d8 (Surr)
98 %
70-130 %
"
4-Bromofluorobenzene (Surr)
93 %
70-130 %
"
DRAFT REPORT
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 41 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Result
Reporting
Limit
MDL
Units
Dil.
Spike
Amount
Source
Result
%REC
%REC
Limits RPD
RPD
Limit
Notes
Soil
Blank (6020834-BLK1)
5035/8260B
Benzene
ND
---
0.00667
mg/kg wet
50
---
---
---
---
---
---
Toluene
ND
---
0.0333
"
"
---
---
---
---
---
---
Ethylbenzene
ND
---
0.0167
"
"
---
---
---
---
---
---
Xylenes, total
ND
---
0.0500
"
"
---
---
---
---
---
---
Naphthalene
ND
---
0.0667
"
"
---
---
---
---
---
---
ND
---
0.0333
"
"
---
---
---
---
---
---
ND
---
0.0333
"
"
---
---
---
---
---
---
n-Propylbenzene
ND
---
0.0167
"
"
---
---
---
---
---
---
1,2,4-Trimethylbenzene
ND
---
0.0333
"
"
---
---
---
---
---
---
1,3,5-Trimethylbenzene
ND
---
0.0333
"
"
---
---
---
---
---
---
1,2-Dibromoethane (EDB)
ND
---
0.0167
"
"
---
---
---
---
---
---
1,2-Dichloroethane (EDC)
ND
---
0.0167
"
"
---
---
---
---
---
---
---
---
Recovery: 96 %
Limits: 70-130 %
Dilution: 1x
1,4-Difluorobenzene (Surr)
92 %
70-130 %
"
Toluene-d8 (Surr)
97 %
70-130 %
"
4-Bromofluorobenzene (Surr)
98 %
70-130 %
"
LCS (6020834-BS1)
5035/8260B
Benzene
0.878
---
0.0100
mg/kg wet
50
1.00
---
88
65-135%
Toluene
0.924
---
0.0500
"
"
"
---
92
"
---
---
Ethylbenzene
0.981
---
0.0250
"
"
"
---
98
"
---
---
Xylenes, total
2.96
---
0.0750
"
"
3.00
---
99
"
---
---
Naphthalene
0.940
---
0.100
"
"
1.00
---
94
"
---
---
0.876
---
0.0500
"
"
"
---
88
"
---
---
1.05
---
0.0500
"
"
"
---
105
"
---
---
n-Propylbenzene
0.898
---
0.0250
"
"
"
---
90
"
---
---
1,2,4-Trimethylbenzene
0.988
---
0.0500
"
"
"
---
99
"
---
---
1,3,5-Trimethylbenzene
0.998
---
0.0500
"
"
"
---
100
"
---
---
1,2-Dibromoethane (EDB)
1.00
---
0.0250
"
"
"
---
100
"
---
---
DRAFT REPORT
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 42 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Result
Reporting
Limit
MDL
Units
Dil.
Spike
Amount
%REC
%REC
Limits RPD
RPD
Limit
Notes
Soil
LCS (6020834-BS1)
1,2-Dichloroethane (EDC)
Source
Result
0.848
---
0.0250
mg/kg wet
"
"
---
Recovery: 97 %
Limits: 70-130 %
Dilution: 1x
1,4-Difluorobenzene (Surr)
92 %
70-130 %
"
Toluene-d8 (Surr)
95 %
70-130 %
"
4-Bromofluorobenzene (Surr)
99 %
70-130 %
"
85
"
---
---
Duplicate (6020834-DUP1)
QC Source Sample: 0B (A6B0900-17)
5035/8260B
Benzene
ND
---
0.0288
mg/kg dry
50
---
0.0177
---
---
***
30%
Toluene
0.247
Ethylbenzene
0.220
---
0.144
"
"
---
0.224
---
---
10
30%
---
0.0719
"
"
---
0.200
---
---
10
30%
Xylenes, total
Naphthalene
1.16
---
0.216
"
"
---
1.04
---
---
11
30%
ND
---
0.288
"
"
---
ND
---
---
---
30%
ND
---
0.144
"
"
---
ND
---
---
---
30%
ND
---
0.144
"
"
---
ND
---
---
---
30%
n-Propylbenzene
0.167
---
0.0719
"
"
---
0.162
---
---
30%
1,2,4-Trimethylbenzene
0.698
---
0.144
"
"
---
0.755
---
---
30%
1,3,5-Trimethylbenzene
0.262
---
0.144
"
"
---
0.264
---
---
0.7
30%
1,2-Dibromoethane (EDB)
ND
---
0.0719
"
"
---
ND
---
---
---
30%
1,2-Dichloroethane (EDC)
ND
---
0.0719
"
"
---
ND
---
---
---
30%
Recovery: 93 %
Limits: 70-130 %
Dilution: 1x
1,4-Difluorobenzene (Surr)
91 %
70-130 %
"
Toluene-d8 (Surr)
95 %
70-130 %
"
100 %
70-130 %
"
4-Bromofluorobenzene (Surr)
Benzene
0.642
---
0.00717
mg/kg dry
50
0.710
ND
90
65-135%
---
---
Toluene
0.680
---
0.0358
"
"
"
ND
96
"
---
---
Ethylbenzene
0.718
---
0.0179
"
"
"
ND
101
"
---
---
DRAFT REPORT
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 43 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Result
Reporting
Limit
MDL
Units
Dil.
Spike
Amount
Source
Result
%REC
%REC
Limits RPD
RPD
Limit
Notes
Soil
Xylenes, total
2.16
---
0.0538
mg/kg dry
"
2.13
ND
102
"
---
---
Naphthalene
0.697
---
0.0717
"
"
0.710
ND
98
"
---
---
0.644
---
0.0358
"
"
"
ND
91
"
---
---
0.775
---
0.0358
"
"
"
ND
109
"
---
---
n-Propylbenzene
0.652
---
0.0179
"
"
"
ND
92
"
---
---
1,2,4-Trimethylbenzene
0.721
---
0.0358
"
"
"
ND
102
"
---
---
1,3,5-Trimethylbenzene
0.738
---
0.0358
"
"
"
ND
104
"
---
---
1,2-Dibromoethane (EDB)
0.746
---
0.0179
"
"
"
ND
105
"
---
---
1,2-Dichloroethane (EDC)
0.616
---
0.0179
"
"
"
ND
87
"
---
---
Recovery: 96 %
Limits: 70-130 %
Dilution: 1x
1,4-Difluorobenzene (Surr)
91 %
70-130 %
"
Toluene-d8 (Surr)
96 %
70-130 %
"
4-Bromofluorobenzene (Surr)
99 %
70-130 %
"
DRAFT REPORT
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 44 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Result
Reporting
Limit
MDL
Units
Dil.
Spike
Amount
Source
Result
%REC
%REC
Limits RPD
RPD
Limit
Notes
Soil
Blank (6020836-BLK2)
EPA 8270D (SIM)
Acenaphthene
ND
---
0.00833
mg/kg wet
---
---
---
---
---
---
Acenaphthylene
ND
---
0.00833
"
"
---
---
---
---
---
---
Anthracene
ND
---
0.00833
"
"
---
---
---
---
---
---
Benz(a)anthracene
ND
---
0.00833
"
"
---
---
---
---
---
---
Benzo(a)pyrene
ND
---
0.00833
"
"
---
---
---
---
---
---
Benzo(b)fluoranthene
ND
---
0.00833
"
"
---
---
---
---
---
---
Benzo(k)fluoranthene
ND
---
0.00833
"
"
---
---
---
---
---
---
Benzo(g,h,i)perylene
ND
---
0.00833
"
"
---
---
---
---
---
---
Chrysene
ND
---
0.00833
"
"
---
---
---
---
---
---
Dibenz(a,h)anthracene
ND
---
0.00833
"
"
---
---
---
---
---
---
Dibenzofuran
ND
---
0.00833
"
"
---
---
---
---
---
---
Fluoranthene
ND
---
0.00833
"
"
---
---
---
---
---
---
Fluorene
ND
---
0.00833
"
"
---
---
---
---
---
---
Indeno(1,2,3-cd)pyrene
ND
---
0.00833
"
"
---
---
---
---
---
---
1-Methylnaphthalene
ND
---
0.00833
"
"
---
---
---
---
---
---
2-Methylnaphthalene
ND
---
0.00833
"
"
---
---
---
---
---
---
Naphthalene
ND
---
0.00833
"
"
---
---
---
---
---
---
Phenanthrene
ND
---
0.00833
"
"
---
---
---
---
---
---
Pyrene
ND
---
0.00833
"
"
---
---
---
---
---
---
Recovery: 91 %
Limits: 44-115 %
Dilution: 1x
104 %
54-127 %
"
p-Terphenyl-d14 (Surr)
LCS (6020836-BS2)
EPA 8270D (SIM)
Acenaphthene
0.718
---
0.0100
mg/kg wet
0.800
---
90
40-122%
---
---
Acenaphthylene
0.709
---
0.0100
"
"
"
---
89
32-132%
---
---
Anthracene
0.771
---
0.0100
"
"
"
---
96
47-123%
---
---
Benz(a)anthracene
0.701
---
0.0100
"
"
"
---
88
49-126%
---
---
Benzo(a)pyrene
0.727
---
0.0100
"
"
"
---
91
45-129%
---
---
Benzo(b)fluoranthene
0.729
---
0.0100
"
"
"
---
91
45-132%
---
---
Benzo(k)fluoranthene
0.731
---
0.0100
"
"
"
---
91
47-132%
---
---
DRAFT REPORT
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 45 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Result
Reporting
Limit
MDL
Units
Dil.
Spike
Amount
%REC
%REC
Limits RPD
RPD
Limit
Notes
Soil
LCS (6020836-BS2)
Benzo(g,h,i)perylene
Source
Result
0.657
---
0.0100
"
"
"
---
82
43-134%
---
---
Chrysene
0.698
---
0.0100
"
"
"
---
87
50-124%
---
---
Dibenz(a,h)anthracene
0.691
---
0.0100
"
"
"
---
86
45-134%
---
---
Dibenzofuran
0.721
---
0.0100
"
"
"
---
90
44-120%
---
---
Fluoranthene
0.708
---
0.0100
"
"
"
---
89
50-127%
---
---
Fluorene
0.719
---
0.0100
"
"
"
---
90
43-125%
---
---
Indeno(1,2,3-cd)pyrene
0.653
---
0.0100
"
"
"
---
82
45-133%
---
---
1-Methylnaphthalene
0.677
---
0.0100
"
"
"
---
85
40-120%
---
---
2-Methylnaphthalene
0.715
---
0.0100
"
"
"
---
89
38-122%
---
---
Naphthalene
0.697
---
0.0100
"
"
"
---
87
35-123%
---
---
Phenanthrene
0.722
---
0.0100
"
"
"
---
90
50-121%
---
---
Pyrene
0.719
---
0.0100
"
"
"
---
90
47-127%
---
---
Recovery: 92 %
Limits: 44-115 %
Dilution: 1x
101 %
54-127 %
"
p-Terphenyl-d14 (Surr)
Duplicate (6020836-DUP3)
QC Source Sample: 1A (A6B0900-01)
EPA 8270D (SIM)
Acenaphthene
ND
---
0.0134
mg/kg dry
---
ND
---
---
---
30%
Acenaphthylene
ND
---
0.0134
"
"
---
ND
---
---
---
30%
Anthracene
ND
---
0.0134
"
"
---
ND
---
---
---
30%
Benz(a)anthracene
ND
---
0.0134
"
"
---
ND
---
---
---
30%
Benzo(a)pyrene
ND
---
0.0134
"
"
---
ND
---
---
---
30%
Benzo(b)fluoranthene
ND
---
0.0134
"
"
---
ND
---
---
---
30%
Benzo(k)fluoranthene
ND
---
0.0134
"
"
---
ND
---
---
---
30%
Benzo(g,h,i)perylene
ND
---
0.0134
"
"
---
ND
---
---
---
30%
Chrysene
ND
---
0.0134
"
"
---
ND
---
---
---
30%
Dibenz(a,h)anthracene
ND
---
0.0134
"
"
---
ND
---
---
---
30%
Dibenzofuran
ND
---
0.0134
"
"
---
ND
---
---
---
30%
Fluoranthene
ND
---
0.0134
"
"
---
ND
---
---
---
30%
Fluorene
ND
---
0.0134
"
"
---
ND
---
---
---
30%
Indeno(1,2,3-cd)pyrene
ND
---
0.0134
"
"
---
ND
---
---
---
30%
DRAFT REPORT
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 46 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Result
Reporting
Limit
MDL
Units
Dil.
Spike
Amount
Source
Result
%REC
%REC
Limits RPD
RPD
Limit
Notes
Soil
Duplicate (6020836-DUP3)
QC Source Sample: 1A (A6B0900-01)
1-Methylnaphthalene
ND
---
0.0134
"
"
---
ND
---
---
---
30%
2-Methylnaphthalene
ND
---
0.0134
"
"
---
ND
---
---
---
30%
Naphthalene
ND
---
0.0134
"
"
---
ND
---
---
---
30%
Phenanthrene
ND
---
0.0134
"
"
---
ND
---
---
---
30%
Pyrene
ND
---
"
"
---
ND
---
---
---
30%
0.0134
Recovery: 88 %
Limits: 44-115 %
Dilution: 1x
106 %
54-127 %
"
p-Terphenyl-d14 (Surr)
Duplicate (6020836-DUP4)
QC Source Sample: 3C (A6B0900-10)
EPA 8270D (SIM)
Acenaphthene
ND
---
0.0137
mg/kg dry
---
ND
---
---
---
30%
Acenaphthylene
ND
---
0.0137
"
"
---
ND
---
---
---
30%
Anthracene
ND
---
0.0137
"
"
---
ND
---
---
---
30%
Benz(a)anthracene
ND
---
0.0137
"
"
---
ND
---
---
---
30%
Benzo(a)pyrene
ND
---
0.0137
"
"
---
ND
---
---
---
30%
Benzo(b)fluoranthene
ND
---
0.0137
"
"
---
ND
---
---
---
30%
Benzo(k)fluoranthene
ND
---
0.0137
"
"
---
ND
---
---
---
30%
Benzo(g,h,i)perylene
ND
---
0.0137
"
"
---
ND
---
---
---
30%
Chrysene
ND
---
0.0137
"
"
---
ND
---
---
---
30%
Dibenz(a,h)anthracene
ND
---
0.0137
"
"
---
ND
---
---
---
30%
Dibenzofuran
ND
---
0.0137
"
"
---
ND
---
---
---
30%
Fluoranthene
ND
---
0.0137
"
"
---
ND
---
---
---
30%
Fluorene
ND
---
0.0137
"
"
---
ND
---
---
---
30%
Indeno(1,2,3-cd)pyrene
ND
---
0.0137
"
"
---
ND
---
---
---
30%
1-Methylnaphthalene
ND
---
0.0137
"
"
---
ND
---
---
---
30%
2-Methylnaphthalene
ND
---
0.0137
"
"
---
ND
---
---
---
30%
Naphthalene
ND
---
0.0137
"
"
---
ND
---
---
---
30%
Phenanthrene
ND
---
0.0137
"
"
---
ND
---
---
---
30%
Pyrene
ND
---
0.0137
"
"
---
ND
---
---
---
30%
DRAFT REPORT
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 47 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Result
Reporting
Limit
MDL
Units
Dil.
Spike
Amount
Source
Result
%REC
%REC
Limits RPD
RPD
Limit
Notes
Soil
Duplicate (6020836-DUP4)
QC Source Sample: 3C (A6B0900-10)
Surr: 2-Fluorobiphenyl (Surr)
Recovery: 88 %
Limits: 44-115 %
Dilution: 1x
108 %
54-127 %
"
p-Terphenyl-d14 (Surr)
Acenaphthene
0.751
---
0.0107
mg/kg dry
0.852
ND
88
40-122%
---
---
Acenaphthylene
0.758
---
0.0107
"
"
"
0.0181
87
32-132%
---
---
Anthracene
0.774
---
0.0107
"
"
"
0.0526
85
47-123%
---
---
Benz(a)anthracene
0.752
---
0.0107
"
"
"
0.635
14
49-126%
---
---
Benzo(a)pyrene
0.779
---
0.0107
"
"
"
0.219
66
45-129%
---
---
Benzo(b)fluoranthene
0.795
---
0.0107
"
"
"
0.603
22
45-132%
---
---
Benzo(k)fluoranthene
0.782
---
0.0107
"
"
"
0.206
68
47-132%
---
---
Benzo(g,h,i)perylene
0.580
---
0.0107
"
"
"
0.0799
59
43-134%
---
---
Chrysene
0.753
---
0.0107
"
"
"
0.947
-23
50-124%
---
---
Dibenz(a,h)anthracene
0.665
---
0.0107
"
"
"
0.0306
74
45-134%
---
---
Dibenzofuran
0.777
---
0.0107
"
"
"
0.00750
90
44-120%
---
---
Fluoranthene
0.792
---
0.0107
"
"
"
1.86
-125
50-127%
---
---
Fluorene
0.768
---
0.0107
"
"
"
ND
90
43-125%
---
---
Indeno(1,2,3-cd)pyrene
0.625
---
0.0107
"
"
"
0.116
60
45-133%
---
---
1-Methylnaphthalene
0.727
---
0.0107
"
"
"
0.00568
85
40-120%
---
---
2-Methylnaphthalene
0.765
---
0.0107
"
"
"
0.0135
88
38-122%
---
---
Naphthalene
0.724
---
0.0107
"
"
"
ND
85
35-123%
---
---
Phenanthrene
0.775
---
0.0107
"
"
"
0.0119
90
50-121%
---
---
Pyrene
0.784
---
0.0107
"
"
"
1.60
-96
47-127%
---
---
Recovery: 92 %
Limits: 44-115 %
Dilution: 1x
112 %
54-127 %
"
p-Terphenyl-d14 (Surr)
DRAFT REPORT
Q-04
Q-04
Q-04
Q-04
Q-04
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 48 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Result
MDL
Reporting
Limit
Units
Dil.
Spike
Amount
Source
Result
%REC
%REC
Limits RPD
RPD
Limit
Notes
Soil
Duplicate (6020837-DUP1)
QC Source Sample: 1A (A6B0900-01)
EPA 8000C
% Solids
52.0
---
1.00
% by
Weight
---
65.4
---
---
23
10%
10%
0.7
10%
10%
Q-04
Duplicate (6020837-DUP2)
QC Source Sample: 3C (A6B0900-10)
EPA 8000C
% Solids
64.6
---
1.00
% by
Weight
---
67.6
---
---
Duplicate (6020837-DUP3)
QC Source Sample: Ex Sidewall E (A6B0900-21)
EPA 8000C
% Solids
83.4
---
1.00
% by
Weight
---
82.9
---
---
Duplicate (6020837-DUP4)
QC Source Sample: 0B (A6B0900-17)
EPA 8000C
% Solids
57.3
---
1.00
% by
Weight
---
55.4
---
---
No Client related Batch QC samples analyzed for this batch. See notes page for more information.
DRAFT REPORT
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 49 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Matrix
Method
Sampled
Prepared
Sample
Default
RL Prep
Initial/Final
Initial/Final
Factor
Batch: 6020835
A6B0900-03
A6B0900-06
Soil
Soil
NWTPH-Dx
NWTPH-Dx
02/26/16 10:00
02/26/16 10:10
02/27/16 10:01
02/27/16 10:01
10.94g/5mL
11.18g/5mL
10g/5mL
10g/5mL
0.91
0.89
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
NWTPH-Dx
NWTPH-Dx
NWTPH-Dx
NWTPH-Dx
NWTPH-Dx
NWTPH-Dx
NWTPH-Dx
NWTPH-Dx
NWTPH-Dx
NWTPH-Dx
NWTPH-Dx
NWTPH-Dx
NWTPH-Dx
NWTPH-Dx
NWTPH-Dx
NWTPH-Dx
NWTPH-Dx
NWTPH-Dx
NWTPH-Dx
02/26/16 09:40
02/26/16 09:50
02/26/16 10:55
02/26/16 11:00
02/26/16 10:05
02/26/16 10:40
02/26/16 10:45
02/26/16 10:50
02/26/16 10:15
02/26/16 10:35
02/26/16 10:30
02/26/16 10:25
02/26/16 10:20
02/26/16 12:00
02/26/16 12:05
02/26/16 12:10
02/26/16 12:20
02/26/16 12:30
02/26/16 12:40
02/27/16 10:02
02/27/16 10:02
02/27/16 10:02
02/27/16 10:02
02/27/16 10:02
02/27/16 10:02
02/27/16 10:02
02/27/16 10:02
02/27/16 10:02
02/27/16 10:02
02/27/16 10:02
02/27/16 10:02
02/27/16 10:02
02/27/16 10:02
02/27/16 10:02
02/27/16 10:02
02/27/16 10:02
02/27/16 10:02
02/27/16 10:02
10.7g/5mL
10.83g/5mL
10.51g/5mL
11.24g/5mL
10.31g/5mL
10.74g/5mL
10.36g/5mL
10.97g/5mL
11.43g/5mL
10.38g/5mL
10.86g/5mL
10.21g/5mL
10.87g/5mL
11.77g/5mL
10.8g/5mL
10.49g/5mL
10.19g/5mL
10.53g/5mL
11.5g/5mL
10g/5mL
10g/5mL
10g/5mL
10g/5mL
10g/5mL
10g/5mL
10g/5mL
10g/5mL
10g/5mL
10g/5mL
10g/5mL
10g/5mL
10g/5mL
10g/5mL
10g/5mL
10g/5mL
10g/5mL
10g/5mL
10g/5mL
0.94
0.92
0.95
0.89
0.97
0.93
0.97
0.91
0.88
0.96
0.92
0.98
0.92
0.85
0.93
0.95
0.98
0.95
0.87
Batch: 6020836
A6B0900-01
A6B0900-02
A6B0900-04
A6B0900-05
A6B0900-07
A6B0900-08
A6B0900-09
A6B0900-10
A6B0900-11
A6B0900-12
A6B0900-13
A6B0900-14RE1
A6B0900-15
A6B0900-16
A6B0900-17
A6B0900-18
A6B0900-19
A6B0900-20
A6B0900-21
Matrix
Method
Sampled
Prepared
02/26/16 09:40
02/26/16 09:50
02/26/16 10:55
02/26/16 11:00
02/26/16 10:05
02/26/16 10:40
02/26/16 09:40
02/26/16 09:50
02/26/16 10:55
02/26/16 11:00
02/26/16 10:05
02/26/16 10:40
Sample
Default
RL Prep
Initial/Final
Initial/Final
Factor
Batch: 6020833
A6B0900-01
A6B0900-02
A6B0900-04
A6B0900-05
A6B0900-07
A6B0900-08
Soil
Soil
Soil
Soil
Soil
Soil
5035/8260B
5035/8260B
5035/8260B
5035/8260B
5035/8260B
5035/8260B
DRAFT REPORT
4.67g/5mL
4.4g/5mL
5.47g/5mL
4.01g/5mL
3.04g/5mL
4.31g/5mL
5g/5mL
5g/5mL
5g/5mL
5g/5mL
5g/5mL
5g/5mL
1.07
1.14
0.91
1.25
1.64
1.16
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 50 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
Default
RL Prep
Initial/Final
Initial/Final
Factor
A6B0900-09
A6B0900-10
A6B0900-11
A6B0900-12
A6B0900-13
Matrix
Method
Sampled
Prepared
Soil
Soil
Soil
Soil
Soil
5035/8260B
5035/8260B
5035/8260B
5035/8260B
5035/8260B
02/26/16 10:45
02/26/16 10:50
02/26/16 10:15
02/26/16 10:35
02/26/16 10:30
02/26/16 10:45
02/26/16 10:50
02/26/16 10:15
02/26/16 10:35
02/26/16 10:30
5.25g/5mL
6.83g/5mL
5.61g/5mL
5.14g/5mL
5.22g/5mL
5g/5mL
5g/5mL
5g/5mL
5g/5mL
5g/5mL
0.95
0.73
0.89
0.97
0.96
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
5035/8260B
5035/8260B
5035/8260B
5035/8260B
5035/8260B
5035/8260B
5035/8260B
5035/8260B
02/26/16 10:25
02/26/16 10:20
02/26/16 12:00
02/26/16 12:05
02/26/16 12:10
02/26/16 12:20
02/26/16 12:30
02/26/16 12:40
02/26/16 10:25
02/26/16 10:20
02/26/16 12:00
02/26/16 12:05
02/26/16 12:10
02/26/16 12:20
02/26/16 12:30
02/26/16 12:40
7.9g/5mL
9.59g/5mL
4.61g/5mL
4.71g/5mL
4.05g/5mL
7.98g/5mL
9.02g/5mL
11.83g/5mL
5g/5mL
5g/5mL
5g/5mL
5g/5mL
5g/5mL
5g/5mL
5g/5mL
5g/5mL
0.63
0.52
1.08
1.06
1.23
0.63
0.55
0.42
Batch: 6020834
A6B0900-14
A6B0900-15
A6B0900-16
A6B0900-17
A6B0900-18
A6B0900-19
A6B0900-20
A6B0900-21
Matrix
Method
Sampled
Prepared
02/26/16 09:40
02/26/16 09:50
02/26/16 10:55
02/26/16 11:00
02/26/16 10:05
02/26/16 10:40
02/26/16 10:45
02/26/16 10:50
02/26/16 10:15
02/26/16 10:35
02/26/16 10:30
02/26/16 10:25
02/26/16 10:20
02/26/16 12:00
02/26/16 12:05
02/27/16 10:02
02/27/16 10:02
02/27/16 10:02
02/27/16 10:02
02/27/16 10:02
02/27/16 10:02
02/27/16 10:02
02/27/16 10:02
02/27/16 10:02
02/27/16 10:02
02/27/16 10:02
02/27/16 10:02
02/27/16 10:02
02/27/16 10:02
02/27/16 10:02
Sample
Default
RL Prep
Initial/Final
Initial/Final
Factor
Batch: 6020836
A6B0900-01
A6B0900-02
A6B0900-04
A6B0900-05
A6B0900-07
A6B0900-08
A6B0900-09
A6B0900-10
A6B0900-11
A6B0900-12
A6B0900-13
A6B0900-14
A6B0900-15
A6B0900-16
A6B0900-17
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
DRAFT REPORT
10.7g/5mL
10.83g/5mL
10.51g/5mL
11.24g/5mL
10.31g/5mL
10.74g/5mL
10.36g/5mL
10.97g/5mL
11.43g/5mL
10.38g/5mL
10.86g/5mL
10.21g/5mL
10.87g/5mL
11.77g/5mL
10.8g/5mL
10g/5mL
10g/5mL
10g/5mL
10g/5mL
10g/5mL
10g/5mL
10g/5mL
10g/5mL
10g/5mL
10g/5mL
10g/5mL
10g/5mL
10g/5mL
10g/5mL
10g/5mL
0.94
0.92
0.95
0.89
0.97
0.93
0.97
0.91
0.88
0.96
0.92
0.98
0.92
0.85
0.93
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 51 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
A6B0900-18
A6B0900-19
A6B0900-20
A6B0900-21
Matrix
Soil
Soil
Soil
Soil
Method
Sampled
Prepared
02/26/16 12:10
02/26/16 12:20
02/26/16 12:30
02/26/16 12:40
02/27/16 10:02
02/27/16 10:02
02/27/16 10:02
02/27/16 10:02
Sample
Default
RL Prep
Initial/Final
Initial/Final
Factor
10.49g/5mL
10.19g/5mL
10.53g/5mL
11.5g/5mL
10g/5mL
10g/5mL
10g/5mL
10g/5mL
0.95
0.98
0.95
0.87
Matrix
Method
Sampled
Prepared
02/26/16 09:40
02/26/16 09:50
02/26/16 10:00
02/26/16 10:55
02/26/16 11:00
02/26/16 10:10
02/26/16 10:05
02/26/16 10:40
02/26/16 10:45
02/26/16 10:50
02/26/16 10:15
02/26/16 10:35
02/26/16 10:30
02/26/16 10:25
02/26/16 10:20
02/26/16 12:00
02/26/16 12:05
02/26/16 12:10
02/26/16 12:20
02/26/16 12:30
02/26/16 12:40
02/27/16 10:49
02/27/16 10:49
02/27/16 10:49
02/27/16 10:49
02/27/16 10:49
02/27/16 10:49
02/27/16 10:49
02/27/16 10:49
02/27/16 10:49
02/27/16 10:49
02/27/16 10:49
02/27/16 10:49
02/27/16 10:49
02/27/16 10:49
02/27/16 10:49
02/27/16 10:49
02/27/16 10:49
02/27/16 10:49
02/27/16 10:49
02/27/16 10:49
02/27/16 10:49
Sample
Default
RL Prep
Initial/Final
Initial/Final
Factor
Batch: 6020837
A6B0900-01
A6B0900-02
A6B0900-03
A6B0900-04
A6B0900-05
A6B0900-06
A6B0900-07
A6B0900-08
A6B0900-09
A6B0900-10
A6B0900-11
A6B0900-12
A6B0900-13
A6B0900-14
A6B0900-15
A6B0900-16
A6B0900-17
A6B0900-18
A6B0900-19
A6B0900-20
A6B0900-21
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
Soil
EPA 8000C
EPA 8000C
EPA 8000C
EPA 8000C
EPA 8000C
EPA 8000C
EPA 8000C
EPA 8000C
EPA 8000C
EPA 8000C
EPA 8000C
EPA 8000C
EPA 8000C
EPA 8000C
EPA 8000C
EPA 8000C
EPA 8000C
EPA 8000C
EPA 8000C
EPA 8000C
EPA 8000C
DRAFT REPORT
1N/A/1N/A
1N/A/1N/A
1N/A/1N/A
1N/A/1N/A
1N/A/1N/A
1N/A/1N/A
1N/A/1N/A
1N/A/1N/A
1N/A/1N/A
1N/A/1N/A
1N/A/1N/A
1N/A/1N/A
1N/A/1N/A
1N/A/1N/A
1N/A/1N/A
1N/A/1N/A
1N/A/1N/A
1N/A/1N/A
1N/A/1N/A
1N/A/1N/A
1N/A/1N/A
1N/A/1N/A
1N/A/1N/A
1N/A/1N/A
1N/A/1N/A
1N/A/1N/A
1N/A/1N/A
1N/A/1N/A
1N/A/1N/A
1N/A/1N/A
1N/A/1N/A
1N/A/1N/A
1N/A/1N/A
1N/A/1N/A
1N/A/1N/A
1N/A/1N/A
1N/A/1N/A
1N/A/1N/A
1N/A/1N/A
1N/A/1N/A
1N/A/1N/A
1N/A/1N/A
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
NA
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 52 of 57
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/28/16 12:19
No fuel pattern detected. The Diesel result represents carbon range C12 to C24, and the Oil result represents >C24 to C40.
M-02
Due to matrix interference, this analyte cannot be accurately quantified. The reported result is estimated.
M-04
Due to matrix interference, this analyte cannot be accurately quantified. The reported result may contain a high bias.
Q-04
Spike recovery and/or RPD is outside control limits due to a non-homogeneous sample matrix.
Q-05
Analyses are not controlled on RPD values from sample and duplicate concentrations are below 5 times the reporting level.
Q-42
Matrix Spike and/or Duplicate analysis was performed on this sample. % Recovery or RPD for this analyte is outside laboratory control
limits. (Refer to the QC Section of Analytical Report.)
R-02
The Reporting Limit for this analyte has been raised to account for interference from coeluting organic compounds present in the sample.
S-01
Surrogate recovery for this sample is not available due to sample dilution required from high analyte concentration and/or matrix
interference.
S-05
Surrogate recovery is estimated due to sample dilution required for high analyte concentration and/or matrix interference.
Analyte DETECTED
ND
NR
Not Reported
dry
Sample results reported on a dry weight basis. Results listed as 'wet' or without 'dry'designation are not dry weight corrected.
RPD
MDL
If MDL is not listed, data has been evaluated to the Method Reporting Limit only.
WMSC
Water Miscible Solvent Correction has been applied to Results and MRLs for volatiles soil samples per EPA 8000C.
Batch
QC
Unless specifically requested, this report contains only results for Batch QC derived from client samples included in this report. All
analyses were performed with the appropriate Batch QC (including Sample Duplicates, Matrix Spikes and/or Matrix Spike Duplicates) in
order to meet or exceed method and regulatory requirements. Any exceptions to this will be qualified in this report. Complete Batch QC
results are available upon request. In cases where there is insufficient sample provided for Sample Duplicates and/or Matrix Spikes, a
Lab Control Sample Duplicate (LCS Dup) is analyzed to demonstrate accuracy and precision of the extraction and analysis.
Blank
Policy
Apex assesses blank data for potential high bias down to a level equal to the method reporting limit (MRL), except for conventional
chemistry and HCID analyses which are assessed only to the MRL. Sample results flagged with a B or B-02 qualifier are potentially
biased high if they are less than ten times the level found in the blank for inorganic analyses or less than five times the level found in the
blank for organic analyses.
For accurate comparison of volatile results to the level found in the blank; water sample results should be divided by the dilution factor,
and soil sample results should be divided by 1/50 of the sample dilution to account for the sample prep factor.
Results qualified as reported below the MRL may include a potential high bias if associated with a B or B-02 qualified blank. B and B-02
qualifications are not applied to J qualified results reported below the MRL.
---
QC results are not applicable. For example, % Recoveries for Blanks and Duplicates, % RPD for Blanks, Blank Spikes and Matrix
Spikes, etc.
DRAFT REPORT
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 53 of 57
Apex Labs
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
***
Reported:
02/28/16 12:19
Used to indicate a possible discrepancy with the Sample and Sample Duplicate results when the %RPD is not available. In this case,
either the Sample or the Sample Duplicate has a reportable result for this analyte, while the other is Non Detect (ND).
DRAFT REPORT
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 54 of 57
Apex Labs
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
DRAFT REPORT
Reported:
02/28/16 12:19
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 55 of 57
Apex Labs
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
DRAFT REPORT
Reported:
02/28/16 12:19
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 56 of 57
Apex Labs
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
DRAFT REPORT
Reported:
02/28/16 12:19
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 57 of 57
Apex Labs
DRAFT REPORT
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 1 of 18
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/21/16 15:02
Laboratory ID
Matrix
Date Sampled
Date Received
SW-01
A6B0661-01
A6B0661-02
A6B0661-03
A6B0661-04
Water
Water
Water
Water
02/19/16 07:00
02/19/16 07:30
02/19/16 08:00
02/19/16 08:30
02/19/16 09:30
02/19/16 09:30
02/19/16 09:30
02/19/16 09:30
SW-02
SW-03
SW-04
DRAFT REPORT
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 2 of 18
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/21/16 15:02
Result
MDL
SW-01 (A6B0661-01)
Reporting
Limit
Dilution
Units
Matrix: Water
Date Analyzed
Method
Diesel
ND
104
208
ug/L
2.5
02/19/16 23:07
NWTPH-Dx
Oil
ND
208
417
"
"
"
"
"
"
"
Recovery: 84 %
SW-02 (A6B0661-02)
Limits: 50-150 %
Matrix: Water
Batch: 6020602
Diesel
ND
104
208
ug/L
2.5
02/19/16 23:29
NWTPH-Dx
Oil
ND
208
417
"
"
"
"
"
"
"
Recovery: 85 %
SW-03 (A6B0661-03)
Limits: 50-150 %
Matrix: Water
Diesel
ND
100
Oil
ND
200
200
400
Recovery: 83 %
SW-04 (A6B0661-04)
Batch: 6020602
ug/L
2.5
02/19/16 23:51
NWTPH-Dx
"
"
"
"
"
"
"
Limits: 50-150 %
Matrix: Water
Batch: 6020602
Diesel
ND
97.1
194
ug/L
2.5
02/20/16 00:13
NWTPH-Dx
Oil
ND
194
388
"
"
"
"
"
"
"
DRAFT REPORT
Recovery: 90 %
Notes
Batch: 6020602
Limits: 50-150 %
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 3 of 18
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/21/16 15:02
Analyte
MDL
SW-01 (A6B0661-01)
Reporting
Limit
Dilution
Units
Matrix: Water
Date Analyzed
Method
Benzene
ND
0.100
0.200
ug/L
02/19/16 14:00
EPA 8260B
Toluene
ND
0.500
1.00
"
"
"
"
Ethylbenzene
ND
0.250
0.500
"
"
"
"
Xylenes, total
ND
0.750
1.50
"
"
"
"
Naphthalene
ND
1.00
2.00
"
"
"
"
ND
0.500
1.00
"
"
"
"
Isopropylbenzene
ND
0.500
1.00
"
"
"
"
n-Propylbenzene
ND
0.250
0.500
"
"
"
"
1,2,4-Trimethylbenzene
ND
0.500
1.00
"
"
"
"
1,3,5-Trimethylbenzene
ND
0.500
1.00
"
"
"
"
1,2-Dibromoethane (EDB)
ND
0.250
0.500
"
"
"
"
1,2-Dichloroethane (EDC)
ND
0.250
0.500
"
"
"
"
Recovery: 99 %
Limits: 80-120 %
"
"
"
1,4-Difluorobenzene (Surr)
99 %
Limits: 80-120 %
"
"
"
Toluene-d8 (Surr)
97 %
Limits: 80-120 %
"
"
"
4-Bromofluorobenzene (Surr)
95 %
Limits: 80-120 %
"
"
"
SW-02 (A6B0661-02)
Matrix: Water
Batch: 6020583
Benzene
ND
0.100
0.200
ug/L
02/19/16 14:28
EPA 8260B
Toluene
ND
0.500
1.00
"
"
"
"
Ethylbenzene
ND
0.250
0.500
"
"
"
"
Xylenes, total
ND
0.750
1.50
"
"
"
"
Naphthalene
ND
1.00
2.00
"
"
"
"
ND
0.500
1.00
"
"
"
"
Isopropylbenzene
ND
0.500
1.00
"
"
"
"
n-Propylbenzene
ND
0.250
0.500
"
"
"
"
1,2,4-Trimethylbenzene
ND
0.500
1.00
"
"
"
"
1,3,5-Trimethylbenzene
ND
0.500
1.00
"
"
"
"
1,2-Dibromoethane (EDB)
ND
0.250
0.500
"
"
"
"
1,2-Dichloroethane (EDC)
ND
0.250
0.500
"
"
"
"
Recovery: 100 %
Limits: 80-120 %
"
"
"
100 %
Limits: 80-120 %
"
"
"
Toluene-d8 (Surr)
97 %
Limits: 80-120 %
"
"
"
4-Bromofluorobenzene (Surr)
96 %
Limits: 80-120 %
"
"
"
02/19/16 14:57
EPA 8260B
1,4-Difluorobenzene (Surr)
SW-03 (A6B0661-03)
Benzene
Matrix: Water
ND
DRAFT REPORT
0.100
0.200
Notes
Batch: 6020583
Batch: 6020583
ug/L
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 4 of 18
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/21/16 15:02
Analyte
MDL
SW-03 (A6B0661-03)
Reporting
Limit
Dilution
Units
Matrix: Water
Date Analyzed
Method
Toluene
ND
0.500
1.00
ug/L
"
EPA 8260B
Ethylbenzene
ND
0.250
0.500
"
"
"
"
Xylenes, total
ND
0.750
1.50
"
"
"
"
Naphthalene
ND
1.00
2.00
"
"
"
"
ND
0.500
1.00
"
"
"
"
Isopropylbenzene
ND
0.500
1.00
"
"
"
"
n-Propylbenzene
ND
0.250
0.500
"
"
"
"
1,2,4-Trimethylbenzene
ND
0.500
1.00
"
"
"
"
1,3,5-Trimethylbenzene
ND
0.500
1.00
"
"
"
"
1,2-Dibromoethane (EDB)
ND
0.250
0.500
"
"
"
"
1,2-Dichloroethane (EDC)
ND
0.250
0.500
"
"
"
"
Recovery: 99 %
Limits: 80-120 %
"
"
"
1,4-Difluorobenzene (Surr)
99 %
Limits: 80-120 %
"
"
"
Toluene-d8 (Surr)
95 %
Limits: 80-120 %
"
"
"
4-Bromofluorobenzene (Surr)
97 %
Limits: 80-120 %
"
"
"
SW-04 (A6B0661-04)
Matrix: Water
Batch: 6020583
Benzene
ND
0.100
0.200
ug/L
02/19/16 15:26
EPA 8260B
Toluene
ND
0.500
1.00
"
"
"
"
Ethylbenzene
ND
0.250
0.500
"
"
"
"
Xylenes, total
ND
0.750
1.50
"
"
"
"
Naphthalene
ND
1.00
2.00
"
"
"
"
ND
0.500
1.00
"
"
"
"
Isopropylbenzene
ND
0.500
1.00
"
"
"
"
n-Propylbenzene
ND
0.250
0.500
"
"
"
"
1,2,4-Trimethylbenzene
ND
0.500
1.00
"
"
"
"
1,3,5-Trimethylbenzene
ND
0.500
1.00
"
"
"
"
1,2-Dibromoethane (EDB)
ND
0.250
0.500
"
"
"
"
1,2-Dichloroethane (EDC)
ND
0.250
0.500
"
"
"
"
Recovery: 102 %
Limits: 80-120 %
"
"
"
101 %
Limits: 80-120 %
"
"
"
Toluene-d8 (Surr)
96 %
Limits: 80-120 %
"
"
"
4-Bromofluorobenzene (Surr)
96 %
Limits: 80-120 %
"
"
"
1,4-Difluorobenzene (Surr)
DRAFT REPORT
Notes
Batch: 6020583
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 5 of 18
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/21/16 15:02
Analyte
MDL
SW-01 (A6B0661-01)
Reporting
Limit
Dilution
Units
Matrix: Water
Date Analyzed
Method
Acenaphthene
ND
0.0208
0.0417
ug/L
02/19/16 18:13
Acenaphthylene
ND
0.0208
0.0417
"
"
"
"
Anthracene
ND
0.0208
0.0417
"
"
"
"
Benz(a)anthracene
ND
0.0208
0.0417
"
"
"
"
Benzo(a)pyrene
ND
0.0208
0.0417
"
"
"
"
Benzo(b)fluoranthene
ND
0.0208
0.0417
"
"
"
"
Benzo(k)fluoranthene
ND
0.0208
0.0417
"
"
"
"
Benzo(g,h,i)perylene
ND
0.0208
0.0417
"
"
"
"
Chrysene
ND
0.0208
0.0417
"
"
"
"
Dibenz(a,h)anthracene
ND
0.0208
0.0417
"
"
"
"
Dibenzofuran
ND
0.0208
0.0417
"
"
"
"
Fluoranthene
ND
0.0208
0.0417
"
"
"
"
Fluorene
ND
0.0208
0.0417
"
"
"
"
Indeno(1,2,3-cd)pyrene
ND
0.0208
0.0417
"
"
"
"
1-Methylnaphthalene
ND
0.0417
0.0833
"
"
"
"
2-Methylnaphthalene
ND
0.0417
0.0833
"
"
"
"
Naphthalene
ND
0.0417
0.0833
"
"
"
"
Phenanthrene
ND
0.0208
0.0417
"
"
"
"
Pyrene
ND
0.0208
0.0417
"
"
"
"
DRAFT REPORT
Notes
Batch: 6020602
Recovery: 54 %
Limits: 44-120 %
"
"
"
96 %
Limits: 50-133 %
"
"
"
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 6 of 18
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/21/16 15:02
Analyte
MDL
SW-02 (A6B0661-02)
Reporting
Limit
Dilution
Units
Matrix: Water
Date Analyzed
Method
Acenaphthene
ND
0.0208
0.0417
ug/L
02/19/16 18:39
Acenaphthylene
ND
0.0208
0.0417
"
"
"
"
Anthracene
ND
0.0208
0.0417
"
"
"
"
Benz(a)anthracene
ND
0.0208
0.0417
"
"
"
"
Benzo(a)pyrene
ND
0.0208
0.0417
"
"
"
"
Benzo(b)fluoranthene
ND
0.0208
0.0417
"
"
"
"
Benzo(k)fluoranthene
ND
0.0208
0.0417
"
"
"
"
Benzo(g,h,i)perylene
ND
0.0208
0.0417
"
"
"
"
Chrysene
ND
0.0208
0.0417
"
"
"
"
Dibenz(a,h)anthracene
ND
0.0208
0.0417
"
"
"
"
Dibenzofuran
ND
0.0208
0.0417
"
"
"
"
Fluoranthene
ND
0.0208
0.0417
"
"
"
"
Fluorene
ND
0.0208
0.0417
"
"
"
"
Indeno(1,2,3-cd)pyrene
ND
0.0208
0.0417
"
"
"
"
1-Methylnaphthalene
ND
0.0417
0.0833
"
"
"
"
2-Methylnaphthalene
ND
0.0417
0.0833
"
"
"
"
Naphthalene
ND
0.0417
0.0833
"
"
"
"
Phenanthrene
ND
0.0208
0.0417
"
"
"
"
Pyrene
ND
0.0208
0.0417
"
"
"
"
DRAFT REPORT
Notes
Batch: 6020602
Recovery: 61 %
Limits: 44-120 %
"
"
"
95 %
Limits: 50-133 %
"
"
"
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 7 of 18
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/21/16 15:02
Analyte
MDL
SW-03 (A6B0661-03)
Reporting
Limit
Dilution
Units
Matrix: Water
Date Analyzed
Method
Acenaphthene
ND
0.0200
0.0400
ug/L
02/19/16 19:06
Acenaphthylene
ND
0.0200
0.0400
"
"
"
"
Anthracene
ND
0.0200
0.0400
"
"
"
"
Benz(a)anthracene
ND
0.0200
0.0400
"
"
"
"
Benzo(a)pyrene
ND
0.0200
0.0400
"
"
"
"
Benzo(b)fluoranthene
ND
0.0200
0.0400
"
"
"
"
Benzo(k)fluoranthene
ND
0.0200
0.0400
"
"
"
"
Benzo(g,h,i)perylene
ND
0.0200
0.0400
"
"
"
"
Chrysene
ND
0.0200
0.0400
"
"
"
"
Dibenz(a,h)anthracene
ND
0.0200
0.0400
"
"
"
"
Dibenzofuran
ND
0.0200
0.0400
"
"
"
"
Fluoranthene
ND
0.0200
0.0400
"
"
"
"
Fluorene
ND
0.0200
0.0400
"
"
"
"
Indeno(1,2,3-cd)pyrene
ND
0.0200
0.0400
"
"
"
"
1-Methylnaphthalene
ND
0.0400
0.0800
"
"
"
"
2-Methylnaphthalene
ND
0.0400
0.0800
"
"
"
"
Naphthalene
ND
0.0400
0.0800
"
"
"
"
Phenanthrene
ND
0.0200
0.0400
"
"
"
"
Pyrene
ND
0.0200
0.0400
"
"
"
"
DRAFT REPORT
Notes
Batch: 6020602
Recovery: 52 %
Limits: 44-120 %
"
"
"
93 %
Limits: 50-133 %
"
"
"
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 8 of 18
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/21/16 15:02
Analyte
MDL
SW-04 (A6B0661-04)
Reporting
Limit
Dilution
Units
Matrix: Water
Date Analyzed
Method
Acenaphthene
ND
0.0194
0.0388
ug/L
02/19/16 19:32
Acenaphthylene
ND
0.0194
0.0388
"
"
"
"
Anthracene
ND
0.0194
0.0388
"
"
"
"
Benz(a)anthracene
ND
0.0194
0.0388
"
"
"
"
Benzo(a)pyrene
ND
0.0194
0.0388
"
"
"
"
Benzo(b)fluoranthene
ND
0.0194
0.0388
"
"
"
"
Benzo(k)fluoranthene
ND
0.0194
0.0388
"
"
"
"
Benzo(g,h,i)perylene
ND
0.0194
0.0388
"
"
"
"
Chrysene
ND
0.0194
0.0388
"
"
"
"
Dibenz(a,h)anthracene
ND
0.0194
0.0388
"
"
"
"
Dibenzofuran
ND
0.0194
0.0388
"
"
"
"
Fluoranthene
ND
0.0194
0.0388
"
"
"
"
Fluorene
ND
0.0194
0.0388
"
"
"
"
Indeno(1,2,3-cd)pyrene
ND
0.0194
0.0388
"
"
"
"
1-Methylnaphthalene
ND
0.0388
0.0777
"
"
"
"
2-Methylnaphthalene
ND
0.0388
0.0777
"
"
"
"
Naphthalene
ND
0.0388
0.0777
"
"
"
"
Phenanthrene
ND
0.0194
0.0388
"
"
"
"
Pyrene
ND
0.0194
0.0388
"
"
"
"
DRAFT REPORT
Notes
Batch: 6020602
Recovery: 81 %
Limits: 44-120 %
"
"
"
99 %
Limits: 50-133 %
"
"
"
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 9 of 18
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/21/16 15:02
Result
Reporting
Limit
MDL
Units
Dil.
Spike
Amount
Source
Result
%REC
%REC
Limits RPD
RPD
Limit
Notes
Water
Blank (6020602-BLK2)
NWTPH-Dx
Diesel
ND
90.9
182
ug/L
2.5
---
---
---
---
---
---
Oil
ND
182
364
"
"
---
---
---
---
---
---
---
---
Recovery: 88 %
Limits: 50-150 %
Dilution: 2.5x
LCS (6020602-BS2)
NWTPH-Dx
Diesel
991
100
200
Recovery: 90 %
ug/L
2.5
Limits: 50-150 %
1250
---
79
58-115%
Dilution: 2.5x
Q-19
NWTPH-Dx
Diesel
Surr: o-Terphenyl (Surr)
1060
100
200
Recovery: 93 %
DRAFT REPORT
ug/L
2.5
Limits: 50-150 %
1250
---
84
58-115%
20%
Dilution: 2.5x
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 10 of 18
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/21/16 15:02
Result
Reporting
Limit
MDL
Units
Dil.
Spike
Amount
Source
Result
%REC
%REC
Limits RPD
RPD
Limit
Notes
Water
Blank (6020583-BLK1)
EPA 8260B
Benzene
ND
0.100
0.200
ug/L
---
---
---
---
---
---
Toluene
ND
0.500
1.00
"
"
---
---
---
---
---
---
Ethylbenzene
ND
0.250
0.500
"
"
---
---
---
---
---
---
Xylenes, total
ND
0.750
1.50
"
"
---
---
---
---
---
---
Naphthalene
ND
1.00
2.00
"
"
---
---
---
---
---
---
ND
0.500
1.00
"
"
---
---
---
---
---
---
ND
0.500
1.00
"
"
---
---
---
---
---
---
n-Propylbenzene
ND
0.250
0.500
"
"
---
---
---
---
---
---
1,2,4-Trimethylbenzene
ND
0.500
1.00
"
"
---
---
---
---
---
---
1,3,5-Trimethylbenzene
ND
0.500
1.00
"
"
---
---
---
---
---
---
1,2-Dibromoethane (EDB)
ND
0.250
0.500
"
"
---
---
---
---
---
---
1,2-Dichloroethane (EDC)
ND
0.250
0.500
"
"
---
---
---
---
---
---
---
---
Recovery: 97 %
Limits: 80-120 %
Dilution: 1x
1,4-Difluorobenzene (Surr)
98 %
80-120 %
"
Toluene-d8 (Surr)
97 %
80-120 %
"
4-Bromofluorobenzene (Surr)
97 %
80-120 %
"
LCS (6020583-BS1)
EPA 8260B
Benzene
19.6
0.100
0.200
ug/L
20.0
---
98
70-130%
Toluene
20.3
0.500
1.00
"
"
"
---
102
"
---
---
Ethylbenzene
20.7
0.250
0.500
"
"
"
---
103
"
---
---
Xylenes, total
62.4
0.750
1.50
"
"
60.0
---
104
"
---
---
Naphthalene
18.5
1.00
2.00
"
"
20.0
---
93
"
---
---
18.8
0.500
1.00
"
"
"
---
94
"
---
---
21.8
0.500
1.00
"
"
"
---
109
"
---
---
n-Propylbenzene
20.0
0.250
0.500
"
"
"
---
100
"
---
---
1,2,4-Trimethylbenzene
20.5
0.500
1.00
"
"
"
---
103
"
---
---
1,3,5-Trimethylbenzene
20.4
0.500
1.00
"
"
"
---
102
"
---
---
1,2-Dibromoethane (EDB)
20.4
0.250
0.500
"
"
"
---
102
"
---
---
DRAFT REPORT
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 11 of 18
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/21/16 15:02
Result
Reporting
Limit
MDL
Units
Dil.
Spike
Amount
%REC
Limits RPD
RPD
Limit
Notes
LCS (6020583-BS1)
Surr: Dibromofluoromethane (Surr)
%REC
Water
Source
Result
18.4
0.250
0.500
ug/L
"
"
---
Recovery: 94 %
Limits: 80-120 %
Dilution: 1x
1,4-Difluorobenzene (Surr)
96 %
80-120 %
"
Toluene-d8 (Surr)
96 %
80-120 %
"
4-Bromofluorobenzene (Surr)
97 %
80-120 %
"
DRAFT REPORT
92
"
---
---
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 12 of 18
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/21/16 15:02
Result
Reporting
Limit
MDL
Units
Dil.
Spike
Amount
Source
Result
%REC
%REC
Limits RPD
RPD
Limit
Notes
Water
Blank (6020602-BLK1)
EPA 8270D (SIM)
Acenaphthene
ND
0.0182
0.0364
ug/L
---
---
---
---
---
---
Acenaphthylene
ND
0.0182
0.0364
"
"
---
---
---
---
---
---
Anthracene
ND
0.0182
0.0364
"
"
---
---
---
---
---
---
Benz(a)anthracene
ND
0.0182
0.0364
"
"
---
---
---
---
---
---
Benzo(a)pyrene
ND
0.0182
0.0364
"
"
---
---
---
---
---
-----
Benzo(b)fluoranthene
ND
0.0182
0.0364
"
"
---
---
---
---
---
Benzo(k)fluoranthene
ND
0.0182
0.0364
"
"
---
---
---
---
---
---
Benzo(g,h,i)perylene
ND
0.0182
0.0364
"
"
---
---
---
---
---
---
Chrysene
ND
0.0182
0.0364
"
"
---
---
---
---
---
---
Dibenz(a,h)anthracene
ND
0.0182
0.0364
"
"
---
---
---
---
---
---
Dibenzofuran
ND
0.0182
0.0364
"
"
---
---
---
---
---
---
Fluoranthene
ND
0.0182
0.0364
"
"
---
---
---
---
---
---
Fluorene
ND
0.0182
0.0364
"
"
---
---
---
---
---
---
Indeno(1,2,3-cd)pyrene
ND
0.0182
0.0364
"
"
---
---
---
---
---
---
1-Methylnaphthalene
ND
0.0364
0.0727
"
"
---
---
---
---
---
---
2-Methylnaphthalene
ND
0.0364
0.0727
"
"
---
---
---
---
---
---
Naphthalene
ND
0.0364
0.0727
"
"
---
---
---
---
---
---
Phenanthrene
ND
0.0182
0.0364
"
"
---
---
---
---
---
---
Pyrene
ND
0.0182
0.0364
"
"
---
---
---
---
---
---
---
Recovery: 74 %
Limits: 44-120 %
Dilution: 1x
97 %
50-133 %
"
p-Terphenyl-d14 (Surr)
LCS (6020602-BS1)
EPA 8270D (SIM)
Acenaphthene
6.61
0.0200
0.0400
ug/L
8.00
---
83
47-122%
---
Acenaphthylene
6.67
0.0200
0.0400
"
"
"
---
83
41-130%
---
---
Anthracene
7.42
0.0200
0.0400
"
"
"
---
93
57-123%
---
---
Benz(a)anthracene
7.09
0.0200
0.0400
"
"
"
---
89
58-125%
---
---
Benzo(a)pyrene
7.37
0.0200
0.0400
"
"
"
---
92
54-128%
---
---
Benzo(b)fluoranthene
7.15
0.0200
0.0400
"
"
"
---
89
53-131%
---
---
Benzo(k)fluoranthene
7.57
0.0200
0.0400
"
"
"
---
95
57-129%
---
---
DRAFT REPORT
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 13 of 18
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/21/16 15:02
Result
Reporting
Limit
MDL
Units
Dil.
Spike
Amount
%REC
%REC
Limits RPD
RPD
Limit
Notes
Water
LCS (6020602-BS1)
Benzo(g,h,i)perylene
Source
Result
6.33
0.0200
0.0400
"
"
"
---
79
50-134%
---
---
Chrysene
7.06
0.0200
0.0400
"
"
"
---
88
59-123%
---
---
Dibenz(a,h)anthracene
7.13
0.0200
0.0400
"
"
"
---
89
51-134%
---
---
Dibenzofuran
6.82
0.0200
0.0400
"
"
"
---
85
53-120%
---
---
Fluoranthene
7.26
0.0200
0.0400
"
"
"
---
91
57-128%
---
---
Fluorene
7.07
0.0200
0.0400
"
"
"
---
88
52-124%
---
---
Indeno(1,2,3-cd)pyrene
6.17
0.0200
0.0400
"
"
"
---
77
52-133%
---
---
1-Methylnaphthalene
5.76
0.0400
0.0800
"
"
"
---
72
41-120%
---
---
2-Methylnaphthalene
5.98
0.0400
0.0800
"
"
"
---
75
40-121%
---
---
Naphthalene
5.76
0.0400
0.0800
"
"
"
---
72
"
---
---
Phenanthrene
6.99
0.0200
0.0400
"
"
"
---
87
59-120%
---
---
Pyrene
7.40
0.0200
0.0400
"
"
"
---
93
57-126%
---
---
Recovery: 79 %
Limits: 44-120 %
Dilution: 1x
94 %
50-133 %
"
p-Terphenyl-d14 (Surr)
Q-19
Acenaphthene
6.83
0.0200
0.0400
ug/L
8.00
---
85
47-122%
30%
Acenaphthylene
6.79
0.0200
0.0400
"
"
"
---
85
41-130%
30%
Anthracene
7.61
0.0200
0.0400
"
"
"
---
95
57-123%
30%
Benz(a)anthracene
7.28
0.0200
0.0400
"
"
"
---
91
58-125%
30%
Benzo(a)pyrene
7.59
0.0200
0.0400
"
"
"
---
95
54-128%
30%
Benzo(b)fluoranthene
7.57
0.0200
0.0400
"
"
"
---
95
53-131%
30%
Benzo(k)fluoranthene
7.43
0.0200
0.0400
"
"
"
---
93
57-129%
30%
Benzo(g,h,i)perylene
6.45
0.0200
0.0400
"
"
"
---
81
50-134%
30%
Chrysene
7.30
0.0200
0.0400
"
"
"
---
91
59-123%
30%
Dibenz(a,h)anthracene
7.31
0.0200
0.0400
"
"
"
---
91
51-134%
30%
Dibenzofuran
7.06
0.0200
0.0400
"
"
"
---
88
53-120%
30%
Fluoranthene
7.45
0.0200
0.0400
"
"
"
---
93
57-128%
30%
Fluorene
7.21
0.0200
0.0400
"
"
"
---
90
52-124%
30%
Indeno(1,2,3-cd)pyrene
8.20
0.0200
0.0400
"
"
"
---
103
52-133%
28
30%
1-Methylnaphthalene
6.08
0.0400
0.0800
"
"
"
---
76
41-120%
30%
DRAFT REPORT
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 14 of 18
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/21/16 15:02
Result
Reporting
Limit
MDL
Units
Dil.
Spike
Amount
Source
Result
%REC
%REC
Limits RPD
Q-19
2-Methylnaphthalene
6.25
0.0400
0.0800
"
"
"
---
78
Naphthalene
5.97
0.0400
0.0800
"
"
"
---
75
Phenanthrene
7.12
0.0200
0.0400
"
"
"
---
89
Pyrene
7.53
0.0200
0.0400
"
"
"
---
94
57-126%
Recovery: 81 %
Limits: 44-120 %
Dilution: 1x
94 %
50-133 %
"
p-Terphenyl-d14 (Surr)
DRAFT REPORT
Notes
Water
RPD
Limit
40-121%
30%
"
30%
59-120%
30%
30%
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 15 of 18
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/21/16 15:02
Default
RL Prep
Initial/Final
Initial/Final
Factor
1000mL/5mL
1000mL/5mL
1000mL/5mL
1000mL/5mL
0.42
0.42
0.40
0.39
Matrix
Method
Sampled
Prepared
02/19/16 07:00
02/19/16 07:30
02/19/16 08:00
02/19/16 08:30
02/19/16 12:32
02/19/16 12:32
02/19/16 12:32
02/19/16 12:32
Batch: 6020602
A6B0661-01
A6B0661-02
A6B0661-03
A6B0661-04
Water
Water
Water
Water
NWTPH-Dx
NWTPH-Dx
NWTPH-Dx
NWTPH-Dx
960mL/2mL
960mL/2mL
1000mL/2mL
1030mL/2mL
Default
RL Prep
Initial/Final
Initial/Final
Factor
Matrix
Method
Sampled
Prepared
02/19/16 07:00
02/19/16 07:30
02/19/16 08:00
02/19/16 08:30
02/19/16 12:34
02/19/16 12:34
02/19/16 12:34
02/19/16 12:34
Batch: 6020583
A6B0661-01
A6B0661-02
A6B0661-03
A6B0661-04
Water
Water
Water
Water
EPA 8260B
EPA 8260B
EPA 8260B
EPA 8260B
5mL/5mL
5mL/5mL
5mL/5mL
5mL/5mL
5mL/5mL
5mL/5mL
5mL/5mL
5mL/5mL
1.00
1.00
1.00
1.00
Matrix
Method
Sampled
Prepared
02/19/16 07:00
02/19/16 07:30
02/19/16 08:00
02/19/16 08:30
02/19/16 12:32
02/19/16 12:32
02/19/16 12:32
02/19/16 12:32
Sample
Default
RL Prep
Initial/Final
Initial/Final
Factor
1000mL/2mL
1000mL/2mL
1000mL/2mL
1000mL/2mL
1.04
1.04
1.00
0.97
Batch: 6020602
A6B0661-01
A6B0661-02
A6B0661-03
A6B0661-04
Water
Water
Water
Water
DRAFT REPORT
960mL/2mL
960mL/2mL
1000mL/2mL
1030mL/2mL
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 16 of 18
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/21/16 15:02
Blank Spike Duplicate (BSD) sample analyzed in place of Matrix Spike/Duplicate samples due to limited sample amount available for
analysis.
Analyte DETECTED
ND
NR
Not Reported
dry
Sample results reported on a dry weight basis. Results listed as 'wet' or without 'dry'designation are not dry weight corrected.
RPD
MDL
If MDL is not listed, data has been evaluated to the Method Reporting Limit only.
WMSC
Water Miscible Solvent Correction has been applied to Results and MRLs for volatiles soil samples per EPA 8000C.
Batch
QC
Unless specifically requested, this report contains only results for Batch QC derived from client samples included in this report. All
analyses were performed with the appropriate Batch QC (including Sample Duplicates, Matrix Spikes and/or Matrix Spike Duplicates) in
order to meet or exceed method and regulatory requirements. Any exceptions to this will be qualified in this report. Complete Batch QC
results are available upon request. In cases where there is insufficient sample provided for Sample Duplicates and/or Matrix Spikes, a
Lab Control Sample Duplicate (LCS Dup) is analyzed to demonstrate accuracy and precision of the extraction and analysis.
Blank
Policy
Apex assesses blank data for potential high bias down to a level equal to the method reporting limit (MRL), except for conventional
chemistry and HCID analyses which are assessed only to the MRL. Sample results flagged with a B or B-02 qualifier are potentially
biased high if they are less than ten times the level found in the blank for inorganic analyses or less than five times the level found in the
blank for organic analyses.
For accurate comparison of volatile results to the level found in the blank; water sample results should be divided by the dilution factor,
and soil sample results should be divided by 1/50 of the sample dilution to account for the sample prep factor.
Results qualified as reported below the MRL may include a potential high bias if associated with a B or B-02 qualified blank. B and B-02
qualifications are not applied to J qualified results reported below the MRL.
---
QC results are not applicable. For example, % Recoveries for Blanks and Duplicates, % RPD for Blanks, Blank Spikes and Matrix
Spikes, etc.
***
Used to indicate a possible discrepancy with the Sample and Sample Duplicate results when the %RPD is not available. In this case,
either the Sample or the Sample Duplicate has a reportable result for this analyte, while the other is Non Detect (ND).
DRAFT REPORT
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 17 of 18
Apex Labs
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
DRAFT REPORT
Reported:
02/21/16 15:02
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 18 of 18
Apex Labs
DRAFT REPORT
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 1 of 16
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/22/16 18:29
Laboratory ID
Matrix
Date Sampled
Date Received
SW-01
A6B0703-01
A6B0703-02
A6B0703-03
A6B0703-04
Water
Water
Water
Water
02/21/16 07:30
02/21/16 08:10
02/21/16 08:40
02/21/16 09:00
02/22/16 08:30
02/22/16 08:30
02/22/16 08:30
02/22/16 08:30
SW-02
SW-03
SW-04
DRAFT REPORT
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 2 of 16
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/22/16 18:29
Analyte
MDL
SW-01 (A6B0703-01)
Reporting
Limit
Dilution
Units
Matrix: Water
Date Analyzed
Method
Benzene
ND
0.100
0.200
ug/L
02/22/16 13:47
EPA 8260B
Toluene
ND
0.500
1.00
"
"
"
"
Ethylbenzene
ND
0.250
0.500
"
"
"
"
Xylenes, total
ND
0.750
1.50
"
"
"
"
Naphthalene
ND
1.00
2.00
"
"
"
"
ND
0.500
1.00
"
"
"
"
Isopropylbenzene
ND
0.500
1.00
"
"
"
"
n-Propylbenzene
ND
0.250
0.500
"
"
"
"
1,2,4-Trimethylbenzene
ND
0.500
1.00
"
"
"
"
1,3,5-Trimethylbenzene
ND
0.500
1.00
"
"
"
"
1,2-Dibromoethane (EDB)
ND
0.250
0.500
"
"
"
"
1,2-Dichloroethane (EDC)
ND
0.250
0.500
"
"
"
"
Recovery: 98 %
Limits: 80-120 %
"
"
"
97 %
Limits: 80-120 %
"
"
"
Toluene-d8 (Surr)
100 %
Limits: 80-120 %
"
"
"
4-Bromofluorobenzene (Surr)
100 %
Limits: 80-120 %
"
"
"
1,4-Difluorobenzene (Surr)
SW-02 (A6B0703-02)
Matrix: Water
Batch: 6020629
Benzene
ND
0.100
0.200
ug/L
02/22/16 14:16
EPA 8260B
Toluene
ND
0.500
1.00
"
"
"
"
Ethylbenzene
ND
0.250
0.500
"
"
"
"
Xylenes, total
ND
0.750
1.50
"
"
"
"
Naphthalene
ND
1.00
2.00
"
"
"
"
ND
0.500
1.00
"
"
"
"
Isopropylbenzene
ND
0.500
1.00
"
"
"
"
n-Propylbenzene
ND
0.250
0.500
"
"
"
"
1,2,4-Trimethylbenzene
ND
0.500
1.00
"
"
"
"
1,3,5-Trimethylbenzene
ND
0.500
1.00
"
"
"
"
1,2-Dibromoethane (EDB)
ND
0.250
0.500
"
"
"
"
1,2-Dichloroethane (EDC)
ND
0.250
0.500
"
"
"
"
Recovery: 97 %
Limits: 80-120 %
"
"
"
1,4-Difluorobenzene (Surr)
97 %
Limits: 80-120 %
"
"
"
Toluene-d8 (Surr)
99 %
Limits: 80-120 %
"
"
"
4-Bromofluorobenzene (Surr)
97 %
Limits: 80-120 %
"
"
"
02/22/16 14:44
EPA 8260B
SW-03 (A6B0703-03)
Benzene
Matrix: Water
ND
DRAFT REPORT
0.100
0.200
Notes
Batch: 6020629
Batch: 6020629
ug/L
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 3 of 16
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/22/16 18:29
Analyte
MDL
SW-03 (A6B0703-03)
Reporting
Limit
Dilution
Units
Matrix: Water
Date Analyzed
Method
Toluene
ND
0.500
1.00
ug/L
"
EPA 8260B
Ethylbenzene
ND
0.250
0.500
"
"
"
"
Xylenes, total
ND
0.750
1.50
"
"
"
"
Naphthalene
ND
1.00
2.00
"
"
"
"
ND
0.500
1.00
"
"
"
"
Isopropylbenzene
ND
0.500
1.00
"
"
"
"
n-Propylbenzene
ND
0.250
0.500
"
"
"
"
1,2,4-Trimethylbenzene
ND
0.500
1.00
"
"
"
"
1,3,5-Trimethylbenzene
ND
0.500
1.00
"
"
"
"
1,2-Dibromoethane (EDB)
ND
0.250
0.500
"
"
"
"
1,2-Dichloroethane (EDC)
ND
0.250
0.500
"
"
"
"
SW-04 (A6B0703-04)
Recovery: 99 %
Limits: 80-120 %
"
"
"
97 %
Limits: 80-120 %
"
"
"
100 %
Limits: 80-120 %
"
"
"
98 %
Limits: 80-120 %
"
"
"
Matrix: Water
Batch: 6020629
Benzene
ND
0.100
0.200
ug/L
02/22/16 15:13
EPA 8260B
Toluene
ND
0.500
1.00
"
"
"
"
Ethylbenzene
ND
0.250
0.500
"
"
"
"
Xylenes, total
ND
0.750
1.50
"
"
"
"
Naphthalene
ND
1.00
2.00
"
"
"
"
ND
0.500
1.00
"
"
"
"
Isopropylbenzene
ND
0.500
1.00
"
"
"
"
n-Propylbenzene
ND
0.250
0.500
"
"
"
"
1,2,4-Trimethylbenzene
ND
0.500
1.00
"
"
"
"
1,3,5-Trimethylbenzene
ND
0.500
1.00
"
"
"
"
1,2-Dibromoethane (EDB)
ND
0.250
0.500
"
"
"
"
1,2-Dichloroethane (EDC)
ND
0.250
0.500
"
"
"
"
DRAFT REPORT
Notes
Batch: 6020629
Recovery: 99 %
Limits: 80-120 %
"
"
"
98 %
Limits: 80-120 %
"
"
"
100 %
Limits: 80-120 %
"
"
"
97 %
Limits: 80-120 %
"
"
"
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 4 of 16
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/22/16 18:29
Analyte
MDL
SW-01 (A6B0703-01)
Reporting
Limit
Dilution
Units
Matrix: Water
Date Analyzed
Method
Acenaphthene
ND
0.0196
0.0392
ug/L
02/22/16 16:34
Acenaphthylene
ND
0.0196
0.0392
"
"
"
"
Anthracene
ND
0.0196
0.0392
"
"
"
"
Benz(a)anthracene
ND
0.0196
0.0392
"
"
"
"
Benzo(a)pyrene
ND
0.0196
0.0392
"
"
"
"
Benzo(b)fluoranthene
ND
0.0196
0.0392
"
"
"
"
Benzo(k)fluoranthene
ND
0.0196
0.0392
"
"
"
"
Benzo(g,h,i)perylene
ND
0.0196
0.0392
"
"
"
"
Chrysene
ND
0.0196
0.0392
"
"
"
"
Dibenz(a,h)anthracene
ND
0.0196
0.0392
"
"
"
"
Dibenzofuran
ND
0.0196
0.0392
"
"
"
"
Fluoranthene
ND
0.0196
0.0392
"
"
"
"
Fluorene
ND
0.0196
0.0392
"
"
"
"
Indeno(1,2,3-cd)pyrene
ND
0.0196
0.0392
"
"
"
"
1-Methylnaphthalene
ND
0.0392
0.0784
"
"
"
"
2-Methylnaphthalene
ND
0.0392
0.0784
"
"
"
"
Naphthalene
ND
0.0392
0.0784
"
"
"
"
Phenanthrene
ND
0.0196
0.0392
"
"
"
"
Pyrene
ND
0.0196
0.0392
"
"
"
"
DRAFT REPORT
Notes
Batch: 6020635
Recovery: 75 %
Limits: 44-120 %
"
"
"
106 %
Limits: 50-133 %
"
"
"
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 5 of 16
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/22/16 18:29
Analyte
MDL
SW-02 (A6B0703-02)
Reporting
Limit
Dilution
Units
Matrix: Water
Date Analyzed
Method
Acenaphthene
ND
0.0208
0.0417
ug/L
02/22/16 17:00
Acenaphthylene
ND
0.0208
0.0417
"
"
"
"
Anthracene
ND
0.0208
0.0417
"
"
"
"
Benz(a)anthracene
ND
0.0208
0.0417
"
"
"
"
Benzo(a)pyrene
ND
0.0208
0.0417
"
"
"
"
Benzo(b)fluoranthene
ND
0.0208
0.0417
"
"
"
"
Benzo(k)fluoranthene
ND
0.0208
0.0417
"
"
"
"
Benzo(g,h,i)perylene
ND
0.0208
0.0417
"
"
"
"
Chrysene
ND
0.0208
0.0417
"
"
"
"
Dibenz(a,h)anthracene
ND
0.0208
0.0417
"
"
"
"
Dibenzofuran
ND
0.0208
0.0417
"
"
"
"
Fluoranthene
ND
0.0208
0.0417
"
"
"
"
Fluorene
ND
0.0208
0.0417
"
"
"
"
Indeno(1,2,3-cd)pyrene
ND
0.0208
0.0417
"
"
"
"
1-Methylnaphthalene
ND
0.0417
0.0833
"
"
"
"
2-Methylnaphthalene
ND
0.0417
0.0833
"
"
"
"
Naphthalene
ND
0.0417
0.0833
"
"
"
"
Phenanthrene
ND
0.0208
0.0417
"
"
"
"
Pyrene
ND
0.0208
0.0417
"
"
"
"
DRAFT REPORT
Notes
Batch: 6020635
Recovery: 70 %
Limits: 44-120 %
"
"
"
102 %
Limits: 50-133 %
"
"
"
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 6 of 16
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/22/16 18:29
Analyte
MDL
SW-03 (A6B0703-03)
Reporting
Limit
Dilution
Units
Matrix: Water
Date Analyzed
Method
Acenaphthene
ND
0.0206
0.0412
ug/L
02/22/16 17:26
Acenaphthylene
ND
0.0206
0.0412
"
"
"
"
Anthracene
ND
0.0206
0.0412
"
"
"
"
Benz(a)anthracene
ND
0.0206
0.0412
"
"
"
"
Benzo(a)pyrene
ND
0.0206
0.0412
"
"
"
"
Benzo(b)fluoranthene
ND
0.0206
0.0412
"
"
"
"
Benzo(k)fluoranthene
ND
0.0206
0.0412
"
"
"
"
Benzo(g,h,i)perylene
ND
0.0206
0.0412
"
"
"
"
Chrysene
ND
0.0206
0.0412
"
"
"
"
Dibenz(a,h)anthracene
ND
0.0206
0.0412
"
"
"
"
Dibenzofuran
ND
0.0206
0.0412
"
"
"
"
Fluoranthene
ND
0.0206
0.0412
"
"
"
"
Fluorene
ND
0.0206
0.0412
"
"
"
"
Indeno(1,2,3-cd)pyrene
ND
0.0206
0.0412
"
"
"
"
1-Methylnaphthalene
ND
0.0412
0.0825
"
"
"
"
2-Methylnaphthalene
ND
0.0412
0.0825
"
"
"
"
Naphthalene
ND
0.0412
0.0825
"
"
"
"
Phenanthrene
ND
0.0206
0.0412
"
"
"
"
Pyrene
ND
0.0206
0.0412
"
"
"
"
DRAFT REPORT
Notes
Batch: 6020635
Recovery: 72 %
Limits: 44-120 %
"
"
"
106 %
Limits: 50-133 %
"
"
"
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 7 of 16
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/22/16 18:29
Analyte
MDL
SW-04 (A6B0703-04)
Reporting
Limit
Dilution
Units
Matrix: Water
Date Analyzed
Method
Acenaphthene
ND
0.0198
0.0396
ug/L
02/22/16 17:52
Acenaphthylene
ND
0.0198
0.0396
"
"
"
"
Anthracene
ND
0.0198
0.0396
"
"
"
"
Benz(a)anthracene
ND
0.0198
0.0396
"
"
"
"
Benzo(a)pyrene
ND
0.0198
0.0396
"
"
"
"
Benzo(b)fluoranthene
ND
0.0198
0.0396
"
"
"
"
Benzo(k)fluoranthene
ND
0.0198
0.0396
"
"
"
"
Benzo(g,h,i)perylene
ND
0.0198
0.0396
"
"
"
"
Chrysene
ND
0.0198
0.0396
"
"
"
"
Dibenz(a,h)anthracene
ND
0.0198
0.0396
"
"
"
"
Dibenzofuran
ND
0.0198
0.0396
"
"
"
"
Fluoranthene
ND
0.0198
0.0396
"
"
"
"
Fluorene
ND
0.0198
0.0396
"
"
"
"
Indeno(1,2,3-cd)pyrene
ND
0.0198
0.0396
"
"
"
"
1-Methylnaphthalene
ND
0.0396
0.0792
"
"
"
"
2-Methylnaphthalene
ND
0.0396
0.0792
"
"
"
"
Naphthalene
ND
0.0396
0.0792
"
"
"
"
Phenanthrene
ND
0.0198
0.0396
"
"
"
"
Pyrene
ND
0.0198
0.0396
"
"
"
"
DRAFT REPORT
Notes
Batch: 6020635
Recovery: 78 %
Limits: 44-120 %
"
"
"
106 %
Limits: 50-133 %
"
"
"
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 8 of 16
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/22/16 18:29
Result
Reporting
Limit
MDL
Units
Dil.
Spike
Amount
Source
Result
%REC
%REC
Limits RPD
RPD
Limit
Notes
Water
Blank (6020629-BLK1)
EPA 8260B
Benzene
ND
0.100
0.200
ug/L
---
---
---
---
---
---
Toluene
ND
0.500
1.00
"
"
---
---
---
---
---
---
Ethylbenzene
ND
0.250
0.500
"
"
---
---
---
---
---
---
Xylenes, total
ND
0.750
1.50
"
"
---
---
---
---
---
---
Naphthalene
ND
1.00
2.00
"
"
---
---
---
---
---
---
ND
0.500
1.00
"
"
---
---
---
---
---
---
ND
0.500
1.00
"
"
---
---
---
---
---
---
n-Propylbenzene
ND
0.250
0.500
"
"
---
---
---
---
---
---
1,2,4-Trimethylbenzene
ND
0.500
1.00
"
"
---
---
---
---
---
---
1,3,5-Trimethylbenzene
ND
0.500
1.00
"
"
---
---
---
---
---
---
1,2-Dibromoethane (EDB)
ND
0.250
0.500
"
"
---
---
---
---
---
---
1,2-Dichloroethane (EDC)
ND
0.250
0.500
"
"
---
---
---
---
---
---
---
---
Recovery: 98 %
Limits: 80-120 %
Dilution: 1x
98 %
80-120 %
"
100 %
80-120 %
"
97 %
80-120 %
"
1,4-Difluorobenzene (Surr)
Toluene-d8 (Surr)
4-Bromofluorobenzene (Surr)
LCS (6020629-BS1)
EPA 8260B
Benzene
19.1
0.100
0.200
ug/L
20.0
---
95
70-130%
Toluene
20.1
0.500
1.00
"
"
"
---
100
"
---
---
Ethylbenzene
20.4
0.250
0.500
"
"
"
---
102
"
---
---
Xylenes, total
61.6
0.750
1.50
"
"
60.0
---
103
"
---
---
Naphthalene
17.8
1.00
2.00
"
"
20.0
---
89
"
---
---
18.3
0.500
1.00
"
"
"
---
92
"
---
---
21.5
0.500
1.00
"
"
"
---
107
"
---
---
n-Propylbenzene
19.6
0.250
0.500
"
"
"
---
98
"
---
---
1,2,4-Trimethylbenzene
20.4
0.500
1.00
"
"
"
---
102
"
---
---
1,3,5-Trimethylbenzene
20.3
0.500
1.00
"
"
"
---
102
"
---
---
1,2-Dibromoethane (EDB)
20.3
0.250
0.500
"
"
"
---
102
"
---
---
DRAFT REPORT
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 9 of 16
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/22/16 18:29
Result
Reporting
Limit
MDL
Units
Dil.
Spike
Amount
%REC
Limits RPD
RPD
Limit
Notes
LCS (6020629-BS1)
Surr: Dibromofluoromethane (Surr)
%REC
Water
Source
Result
18.0
0.250
0.500
ug/L
"
"
---
Recovery: 95 %
Limits: 80-120 %
Dilution: 1x
1,4-Difluorobenzene (Surr)
96 %
80-120 %
"
Toluene-d8 (Surr)
99 %
80-120 %
"
4-Bromofluorobenzene (Surr)
98 %
80-120 %
"
DRAFT REPORT
90
"
---
---
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 10 of 16
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/22/16 18:29
Result
Reporting
Limit
MDL
Units
Dil.
Spike
Amount
Source
Result
%REC
%REC
Limits RPD
RPD
Limit
Notes
Water
Blank (6020635-BLK1)
EPA 8270D (SIM)
Acenaphthene
ND
0.0182
0.0364
ug/L
---
---
---
---
---
---
Acenaphthylene
ND
0.0182
0.0364
"
"
---
---
---
---
---
---
Anthracene
ND
0.0182
0.0364
"
"
---
---
---
---
---
---
Benz(a)anthracene
ND
0.0182
0.0364
"
"
---
---
---
---
---
---
Benzo(a)pyrene
ND
0.0182
0.0364
"
"
---
---
---
---
---
-----
Benzo(b)fluoranthene
ND
0.0182
0.0364
"
"
---
---
---
---
---
Benzo(k)fluoranthene
ND
0.0182
0.0364
"
"
---
---
---
---
---
---
Benzo(g,h,i)perylene
ND
0.0182
0.0364
"
"
---
---
---
---
---
---
Chrysene
ND
0.0182
0.0364
"
"
---
---
---
---
---
---
Dibenz(a,h)anthracene
ND
0.0182
0.0364
"
"
---
---
---
---
---
---
Dibenzofuran
ND
0.0182
0.0364
"
"
---
---
---
---
---
---
Fluoranthene
ND
0.0182
0.0364
"
"
---
---
---
---
---
---
Fluorene
ND
0.0182
0.0364
"
"
---
---
---
---
---
---
Indeno(1,2,3-cd)pyrene
ND
0.0182
0.0364
"
"
---
---
---
---
---
---
1-Methylnaphthalene
ND
0.0364
0.0727
"
"
---
---
---
---
---
---
2-Methylnaphthalene
ND
0.0364
0.0727
"
"
---
---
---
---
---
---
Naphthalene
ND
0.0364
0.0727
"
"
---
---
---
---
---
---
Phenanthrene
ND
0.0182
0.0364
"
"
---
---
---
---
---
---
Pyrene
ND
0.0182
0.0364
"
"
---
---
---
---
---
---
---
Recovery: 92 %
Limits: 44-120 %
Dilution: 1x
114 %
50-133 %
"
p-Terphenyl-d14 (Surr)
LCS (6020635-BS1)
EPA 8270D (SIM)
Acenaphthene
7.34
0.0200
0.0400
ug/L
8.00
---
92
47-122%
---
Acenaphthylene
7.43
0.0200
0.0400
"
"
"
---
93
41-130%
---
---
Anthracene
7.74
0.0200
0.0400
"
"
"
---
97
57-123%
---
---
Benz(a)anthracene
7.61
0.0200
0.0400
"
"
"
---
95
58-125%
---
---
Benzo(a)pyrene
7.92
0.0200
0.0400
"
"
"
---
99
54-128%
---
---
Benzo(b)fluoranthene
8.27
0.0200
0.0400
"
"
"
---
103
53-131%
---
---
Benzo(k)fluoranthene
7.91
0.0200
0.0400
"
"
"
---
99
57-129%
---
---
DRAFT REPORT
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 11 of 16
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/22/16 18:29
Result
Reporting
Limit
MDL
Units
Dil.
Spike
Amount
%REC
%REC
Limits RPD
RPD
Limit
Notes
Water
LCS (6020635-BS1)
Benzo(g,h,i)perylene
Source
Result
6.86
0.0200
0.0400
"
"
"
---
86
50-134%
---
---
Chrysene
7.46
0.0200
0.0400
"
"
"
---
93
59-123%
---
---
Dibenz(a,h)anthracene
7.31
0.0200
0.0400
"
"
"
---
91
51-134%
---
---
Dibenzofuran
7.57
0.0200
0.0400
"
"
"
---
95
53-120%
---
---
Fluoranthene
8.05
0.0200
0.0400
"
"
"
---
101
57-128%
---
---
Fluorene
7.68
0.0200
0.0400
"
"
"
---
96
52-124%
---
---
Indeno(1,2,3-cd)pyrene
7.04
0.0200
0.0400
"
"
"
---
88
52-133%
---
---
1-Methylnaphthalene
6.80
0.0400
0.0800
"
"
"
---
85
41-120%
---
---
2-Methylnaphthalene
7.18
0.0400
0.0800
"
"
"
---
90
40-121%
---
---
Naphthalene
6.93
0.0400
0.0800
"
"
"
---
87
"
---
---
Phenanthrene
7.70
0.0200
0.0400
"
"
"
---
96
59-120%
---
---
Pyrene
8.13
0.0200
0.0400
"
"
"
---
102
57-126%
---
---
Recovery: 91 %
Limits: 44-120 %
Dilution: 1x
104 %
50-133 %
"
p-Terphenyl-d14 (Surr)
Q-19
Acenaphthene
7.41
0.0200
0.0400
ug/L
8.00
---
93
47-122%
30%
Acenaphthylene
7.60
0.0200
0.0400
"
"
"
---
95
41-130%
30%
Anthracene
7.78
0.0200
0.0400
"
"
"
---
97
57-123%
0.5
30%
Benz(a)anthracene
7.63
0.0200
0.0400
"
"
"
---
95
58-125%
0.3
30%
Benzo(a)pyrene
8.00
0.0200
0.0400
"
"
"
---
100
54-128%
30%
Benzo(b)fluoranthene
8.28
0.0200
0.0400
"
"
"
---
103
53-131%
0.08
30%
Benzo(k)fluoranthene
7.87
0.0200
0.0400
"
"
"
---
98
57-129%
0.5
30%
Benzo(g,h,i)perylene
7.12
0.0200
0.0400
"
"
"
---
89
50-134%
30%
Chrysene
7.66
0.0200
0.0400
"
"
"
---
96
59-123%
30%
Dibenz(a,h)anthracene
7.62
0.0200
0.0400
"
"
"
---
95
51-134%
30%
Dibenzofuran
7.56
0.0200
0.0400
"
"
"
---
94
53-120%
0.2
30%
Fluoranthene
7.98
0.0200
0.0400
"
"
"
---
100
57-128%
0.8
30%
Fluorene
7.65
0.0200
0.0400
"
"
"
---
96
52-124%
0.4
30%
Indeno(1,2,3-cd)pyrene
7.20
0.0200
0.0400
"
"
"
---
90
52-133%
30%
1-Methylnaphthalene
6.96
0.0400
0.0800
"
"
"
---
87
41-120%
30%
DRAFT REPORT
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 12 of 16
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/22/16 18:29
Result
Reporting
Limit
MDL
Units
Dil.
Spike
Amount
Source
Result
%REC
%REC
Limits RPD
Q-19
2-Methylnaphthalene
7.34
0.0400
0.0800
"
"
"
---
92
Naphthalene
7.22
0.0400
0.0800
"
"
"
---
90
Phenanthrene
7.76
0.0200
0.0400
"
"
"
---
97
Pyrene
8.10
0.0200
0.0400
"
"
"
---
101
57-126%
Recovery: 92 %
Limits: 44-120 %
Dilution: 1x
104 %
50-133 %
"
p-Terphenyl-d14 (Surr)
DRAFT REPORT
Notes
Water
RPD
Limit
40-121%
30%
"
30%
59-120%
0.8
30%
0.4
30%
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 13 of 16
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/22/16 18:29
Default
RL Prep
Initial/Final
Initial/Final
Factor
Matrix
Method
Sampled
Prepared
02/21/16 07:30
02/21/16 08:10
02/21/16 08:40
02/21/16 09:00
02/22/16 12:40
02/22/16 12:40
02/22/16 12:40
02/22/16 12:40
Batch: 6020629
A6B0703-01
A6B0703-02
A6B0703-03
A6B0703-04
Water
Water
Water
Water
EPA 8260B
EPA 8260B
EPA 8260B
EPA 8260B
5mL/5mL
5mL/5mL
5mL/5mL
5mL/5mL
5mL/5mL
5mL/5mL
5mL/5mL
5mL/5mL
1.00
1.00
1.00
1.00
Matrix
Method
Sampled
Prepared
02/21/16 07:30
02/21/16 08:10
02/21/16 08:40
02/21/16 09:00
02/22/16 11:20
02/22/16 11:20
02/22/16 11:20
02/22/16 11:20
Sample
Default
RL Prep
Initial/Final
Initial/Final
Factor
1000mL/2mL
1000mL/2mL
1000mL/2mL
1000mL/2mL
0.98
1.04
1.03
0.99
Batch: 6020635
A6B0703-01
A6B0703-02
A6B0703-03
A6B0703-04
Water
Water
Water
Water
DRAFT REPORT
1020mL/2mL
960mL/2mL
970mL/2mL
1010mL/2mL
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 14 of 16
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/22/16 18:29
Blank Spike Duplicate (BSD) sample analyzed in place of Matrix Spike/Duplicate samples due to limited sample amount available for
analysis.
Analyte DETECTED
ND
NR
Not Reported
dry
Sample results reported on a dry weight basis. Results listed as 'wet' or without 'dry'designation are not dry weight corrected.
RPD
MDL
If MDL is not listed, data has been evaluated to the Method Reporting Limit only.
WMSC
Water Miscible Solvent Correction has been applied to Results and MRLs for volatiles soil samples per EPA 8000C.
Batch
QC
Unless specifically requested, this report contains only results for Batch QC derived from client samples included in this report. All
analyses were performed with the appropriate Batch QC (including Sample Duplicates, Matrix Spikes and/or Matrix Spike Duplicates) in
order to meet or exceed method and regulatory requirements. Any exceptions to this will be qualified in this report. Complete Batch QC
results are available upon request. In cases where there is insufficient sample provided for Sample Duplicates and/or Matrix Spikes, a
Lab Control Sample Duplicate (LCS Dup) is analyzed to demonstrate accuracy and precision of the extraction and analysis.
Blank
Policy
Apex assesses blank data for potential high bias down to a level equal to the method reporting limit (MRL), except for conventional
chemistry and HCID analyses which are assessed only to the MRL. Sample results flagged with a B or B-02 qualifier are potentially
biased high if they are less than ten times the level found in the blank for inorganic analyses or less than five times the level found in the
blank for organic analyses.
For accurate comparison of volatile results to the level found in the blank; water sample results should be divided by the dilution factor,
and soil sample results should be divided by 1/50 of the sample dilution to account for the sample prep factor.
Results qualified as reported below the MRL may include a potential high bias if associated with a B or B-02 qualified blank. B and B-02
qualifications are not applied to J qualified results reported below the MRL.
---
QC results are not applicable. For example, % Recoveries for Blanks and Duplicates, % RPD for Blanks, Blank Spikes and Matrix
Spikes, etc.
***
Used to indicate a possible discrepancy with the Sample and Sample Duplicate results when the %RPD is not available. In this case,
either the Sample or the Sample Duplicate has a reportable result for this analyte, while the other is Non Detect (ND).
DRAFT REPORT
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 15 of 16
Apex Labs
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
DRAFT REPORT
Reported:
02/22/16 18:29
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 16 of 16
Apex Labs
DRAFT REPORT
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 1 of 12
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/26/16 16:36
Laboratory ID
Matrix
Date Sampled
Date Received
SW-05
A6B0868-01
Water
02/25/16 13:00
02/26/16 06:35
DRAFT REPORT
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 2 of 12
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/26/16 16:36
Analyte
MDL
SW-05 (A6B0868-01)
Reporting
Limit
Dilution
Units
Matrix: Water
Date Analyzed
Method
Benzene
ND
---
0.200
ug/L
02/26/16 13:07
EPA 8260B
Toluene
ND
---
1.00
"
"
"
"
Ethylbenzene
ND
---
0.500
"
"
"
"
Xylenes, total
ND
---
1.50
"
"
"
"
Naphthalene
ND
---
2.00
"
"
"
"
ND
---
1.00
"
"
"
"
Isopropylbenzene
ND
---
1.00
"
"
"
"
n-Propylbenzene
ND
---
0.500
"
"
"
"
1,2,4-Trimethylbenzene
ND
---
1.00
"
"
"
"
1,3,5-Trimethylbenzene
ND
---
1.00
"
"
"
"
1,2-Dibromoethane (EDB)
ND
---
0.500
"
"
"
"
1,2-Dichloroethane (EDC)
ND
---
0.500
"
"
"
"
DRAFT REPORT
Notes
Batch: 6020814
Recovery: 100 %
Limits: 80-120 %
"
"
"
99 %
Limits: 80-120 %
"
"
"
102 %
Limits: 80-120 %
"
"
"
98 %
Limits: 80-120 %
"
"
"
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 3 of 12
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/26/16 16:36
Analyte
MDL
SW-05 (A6B0868-01)
Reporting
Limit
Dilution
Units
Matrix: Water
Date Analyzed
Method
Acenaphthene
ND
---
0.0440
ug/L
02/26/16 12:14
Acenaphthylene
ND
---
0.0440
"
"
"
"
Anthracene
ND
---
0.0440
"
"
"
"
Benz(a)anthracene
ND
---
0.0440
"
"
"
"
Benzo(a)pyrene
ND
---
0.0440
"
"
"
"
Benzo(b)fluoranthene
ND
---
0.0440
"
"
"
"
Benzo(k)fluoranthene
ND
---
0.0440
"
"
"
"
Benzo(g,h,i)perylene
ND
---
0.0440
"
"
"
"
Chrysene
ND
---
0.0440
"
"
"
"
Dibenz(a,h)anthracene
ND
---
0.0440
"
"
"
"
Dibenzofuran
ND
---
0.0440
"
"
"
"
Fluoranthene
ND
---
0.0440
"
"
"
"
Fluorene
ND
---
0.0440
"
"
"
"
Indeno(1,2,3-cd)pyrene
ND
---
0.0440
"
"
"
"
1-Methylnaphthalene
ND
---
0.0879
"
"
"
"
2-Methylnaphthalene
ND
---
0.0879
"
"
"
"
Naphthalene
ND
---
0.0879
"
"
"
"
Phenanthrene
ND
---
0.0440
"
"
"
"
Pyrene
ND
---
0.0440
"
"
"
"
DRAFT REPORT
Notes
Batch: 6020786
Recovery: 75 %
Limits: 44-120 %
"
"
"
112 %
Limits: 50-133 %
"
"
"
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 4 of 12
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/26/16 16:36
Result
Reporting
Limit
MDL
Units
Dil.
Spike
Amount
Source
Result
%REC
%REC
Limits RPD
RPD
Limit
Notes
Water
Blank (6020814-BLK1)
EPA 8260B
Benzene
ND
---
0.200
ug/L
---
---
---
---
---
---
Toluene
ND
---
1.00
"
"
---
---
---
---
---
---
Ethylbenzene
ND
---
0.500
"
"
---
---
---
---
---
---
Xylenes, total
ND
---
1.50
"
"
---
---
---
---
---
---
Naphthalene
ND
---
2.00
"
"
---
---
---
---
---
---
ND
---
1.00
"
"
---
---
---
---
---
---
ND
---
1.00
"
"
---
---
---
---
---
---
n-Propylbenzene
ND
---
0.500
"
"
---
---
---
---
---
---
1,2,4-Trimethylbenzene
ND
---
1.00
"
"
---
---
---
---
---
---
1,3,5-Trimethylbenzene
ND
---
1.00
"
"
---
---
---
---
---
---
1,2-Dibromoethane (EDB)
ND
---
0.500
"
"
---
---
---
---
---
---
1,2-Dichloroethane (EDC)
ND
---
0.500
"
"
---
---
---
---
---
---
---
---
Recovery: 99 %
Limits: 80-120 %
Dilution: 1x
99 %
80-120 %
"
Toluene-d8 (Surr)
101 %
80-120 %
"
4-Bromofluorobenzene (Surr)
100 %
80-120 %
"
1,4-Difluorobenzene (Surr)
LCS (6020814-BS1)
EPA 8260B
Benzene
18.8
---
0.200
ug/L
20.0
---
94
70-130%
Toluene
20.2
---
1.00
"
"
"
---
101
"
---
---
Ethylbenzene
20.1
---
0.500
"
"
"
---
101
"
---
---
Xylenes, total
61.4
---
1.50
"
"
60.0
---
102
"
---
---
Naphthalene
17.9
---
2.00
"
"
20.0
---
90
"
---
---
18.2
---
1.00
"
"
"
---
91
"
---
---
20.8
---
1.00
"
"
"
---
104
"
---
---
n-Propylbenzene
19.8
---
0.500
"
"
"
---
99
"
---
---
1,2,4-Trimethylbenzene
20.4
---
1.00
"
"
"
---
102
"
---
---
1,3,5-Trimethylbenzene
20.4
---
1.00
"
"
"
---
102
"
---
---
1,2-Dibromoethane (EDB)
20.5
---
0.500
"
"
"
---
102
"
---
---
DRAFT REPORT
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 5 of 12
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/26/16 16:36
Result
Reporting
Limit
MDL
Units
Dil.
Spike
Amount
%REC
Limits RPD
RPD
Limit
Notes
LCS (6020814-BS1)
Surr: Dibromofluoromethane (Surr)
%REC
Water
Source
Result
17.7
---
0.500
ug/L
"
"
---
Recovery: 96 %
Limits: 80-120 %
Dilution: 1x
95 %
80-120 %
"
Toluene-d8 (Surr)
100 %
80-120 %
"
4-Bromofluorobenzene (Surr)
101 %
80-120 %
"
1,4-Difluorobenzene (Surr)
DRAFT REPORT
88
"
---
---
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 6 of 12
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/26/16 16:36
Result
Reporting
Limit
MDL
Units
Dil.
Spike
Amount
Source
Result
%REC
%REC
Limits RPD
RPD
Limit
Notes
Water
Blank (6020786-BLK1)
EPA 8270D (SIM)
Acenaphthene
ND
---
0.0364
ug/L
---
---
---
---
---
---
Acenaphthylene
ND
---
0.0364
"
"
---
---
---
---
---
---
Anthracene
ND
---
0.0364
"
"
---
---
---
---
---
---
Benz(a)anthracene
ND
---
0.0364
"
"
---
---
---
---
---
---
Benzo(a)pyrene
ND
---
0.0364
"
"
---
---
---
---
---
-----
Benzo(b)fluoranthene
ND
---
0.0364
"
"
---
---
---
---
---
Benzo(k)fluoranthene
ND
---
0.0364
"
"
---
---
---
---
---
---
Benzo(g,h,i)perylene
ND
---
0.0364
"
"
---
---
---
---
---
---
Chrysene
ND
---
0.0364
"
"
---
---
---
---
---
---
Dibenz(a,h)anthracene
ND
---
0.0364
"
"
---
---
---
---
---
---
Dibenzofuran
ND
---
0.0364
"
"
---
---
---
---
---
---
Fluoranthene
ND
---
0.0364
"
"
---
---
---
---
---
---
Fluorene
ND
---
0.0364
"
"
---
---
---
---
---
---
Indeno(1,2,3-cd)pyrene
ND
---
0.0364
"
"
---
---
---
---
---
---
1-Methylnaphthalene
ND
---
0.0727
"
"
---
---
---
---
---
---
2-Methylnaphthalene
ND
---
0.0727
"
"
---
---
---
---
---
---
Naphthalene
ND
---
0.0727
"
"
---
---
---
---
---
---
Phenanthrene
ND
---
0.0364
"
"
---
---
---
---
---
---
Pyrene
ND
---
0.0364
"
"
---
---
---
---
---
---
---
Recovery: 84 %
Limits: 44-120 %
Dilution: 1x
108 %
50-133 %
"
p-Terphenyl-d14 (Surr)
LCS (6020786-BS1)
EPA 8270D (SIM)
Acenaphthene
6.55
---
0.0400
ug/L
8.00
---
82
47-122%
---
Acenaphthylene
6.52
---
0.0400
"
"
"
---
82
41-130%
---
---
Anthracene
7.27
---
0.0400
"
"
"
---
91
57-123%
---
---
Benz(a)anthracene
7.29
---
0.0400
"
"
"
---
91
58-125%
---
---
Benzo(a)pyrene
7.85
---
0.0400
"
"
"
---
98
54-128%
---
---
Benzo(b)fluoranthene
7.84
---
0.0400
"
"
"
---
98
53-131%
---
---
Benzo(k)fluoranthene
7.60
---
0.0400
"
"
"
---
95
57-129%
---
---
DRAFT REPORT
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 7 of 12
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/26/16 16:36
Result
Reporting
Limit
MDL
Units
Dil.
Spike
Amount
%REC
%REC
Limits RPD
RPD
Limit
Notes
Water
LCS (6020786-BS1)
Benzo(g,h,i)perylene
Source
Result
7.13
---
0.0400
"
"
"
---
89
50-134%
---
---
Chrysene
7.26
---
0.0400
"
"
"
---
91
59-123%
---
---
Dibenz(a,h)anthracene
7.46
---
0.0400
"
"
"
---
93
51-134%
---
-----
Dibenzofuran
6.69
---
0.0400
"
"
"
---
84
53-120%
---
Fluoranthene
7.26
---
0.0400
"
"
"
---
91
57-128%
---
---
Fluorene
6.83
---
0.0400
"
"
"
---
85
52-124%
---
---
Indeno(1,2,3-cd)pyrene
7.14
---
0.0400
"
"
"
---
89
52-133%
---
---
1-Methylnaphthalene
5.60
---
0.0800
"
"
"
---
70
41-120%
---
---
2-Methylnaphthalene
5.84
---
0.0800
"
"
"
---
73
40-121%
---
---
Naphthalene
5.78
---
0.0800
"
"
"
---
72
"
---
---
Phenanthrene
7.19
---
0.0400
"
"
"
---
90
59-120%
---
---
Pyrene
7.29
---
0.0400
"
"
"
---
91
57-126%
---
---
Recovery: 83 %
Limits: 44-120 %
Dilution: 1x
100 %
50-133 %
"
p-Terphenyl-d14 (Surr)
Q-19
Acenaphthene
6.86
---
0.0400
ug/L
8.00
---
86
47-122%
30%
Acenaphthylene
6.91
---
0.0400
"
"
"
---
86
41-130%
30%
Anthracene
7.76
---
0.0400
"
"
"
---
97
57-123%
30%
Benz(a)anthracene
7.26
---
0.0400
"
"
"
---
91
58-125%
0.5
30%
Benzo(a)pyrene
7.87
---
0.0400
"
"
"
---
98
54-128%
0.2
30%
Benzo(b)fluoranthene
7.58
---
0.0400
"
"
"
---
95
53-131%
30%
Benzo(k)fluoranthene
7.81
---
0.0400
"
"
"
---
98
57-129%
30%
Benzo(g,h,i)perylene
7.11
---
0.0400
"
"
"
---
89
50-134%
0.4
30%
Chrysene
7.26
---
0.0400
"
"
"
---
91
59-123%
0.05
30%
Dibenz(a,h)anthracene
7.42
---
0.0400
"
"
"
---
93
51-134%
0.5
30%
Dibenzofuran
6.91
---
0.0400
"
"
"
---
86
53-120%
30%
Fluoranthene
7.28
---
0.0400
"
"
"
---
91
57-128%
0.3
30%
Fluorene
7.03
---
0.0400
"
"
"
---
88
52-124%
30%
Indeno(1,2,3-cd)pyrene
7.07
---
0.0400
"
"
"
---
88
52-133%
30%
1-Methylnaphthalene
6.30
---
0.0800
"
"
"
---
79
41-120%
12
30%
DRAFT REPORT
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 8 of 12
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/26/16 16:36
Result
Reporting
Limit
MDL
Units
Dil.
Spike
Amount
%REC
%REC
Limits RPD
RPD
Limit
2-Methylnaphthalene
6.60
Naphthalene
Phenanthrene
Pyrene
Q-19
---
0.0800
"
"
"
---
82
6.56
---
0.0800
"
"
"
---
82
7.24
---
0.0400
"
"
"
---
91
7.39
---
"
"
"
---
92
57-126%
0.0400
Recovery: 91 %
Limits: 44-120 %
Dilution: 1x
100 %
50-133 %
"
p-Terphenyl-d14 (Surr)
DRAFT REPORT
Notes
Water
Source
Result
40-121%
12
30%
"
13
30%
59-120%
0.7
30%
30%
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 9 of 12
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/26/16 16:36
Default
RL Prep
Initial/Final
Initial/Final
Factor
Matrix
Method
Sampled
Prepared
02/25/16 13:00
02/26/16 12:03
Batch: 6020814
A6B0868-01
Water
EPA 8260B
5mL/5mL
5mL/5mL
1.00
Matrix
Method
Sampled
Prepared
02/25/16 13:00
02/26/16 09:16
Sample
Default
RL Prep
Initial/Final
Initial/Final
Factor
910mL/2mL
1000mL/2mL
1.10
Batch: 6020786
A6B0868-01
Water
DRAFT REPORT
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 10 of 12
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/26/16 16:36
Blank Spike Duplicate (BSD) sample analyzed in place of Matrix Spike/Duplicate samples due to limited sample amount available for
analysis.
Analyte DETECTED
ND
NR
Not Reported
dry
Sample results reported on a dry weight basis. Results listed as 'wet' or without 'dry'designation are not dry weight corrected.
RPD
MDL
If MDL is not listed, data has been evaluated to the Method Reporting Limit only.
WMSC
Water Miscible Solvent Correction has been applied to Results and MRLs for volatiles soil samples per EPA 8000C.
Batch
QC
Unless specifically requested, this report contains only results for Batch QC derived from client samples included in this report. All
analyses were performed with the appropriate Batch QC (including Sample Duplicates, Matrix Spikes and/or Matrix Spike Duplicates) in
order to meet or exceed method and regulatory requirements. Any exceptions to this will be qualified in this report. Complete Batch QC
results are available upon request. In cases where there is insufficient sample provided for Sample Duplicates and/or Matrix Spikes, a
Lab Control Sample Duplicate (LCS Dup) is analyzed to demonstrate accuracy and precision of the extraction and analysis.
Blank
Policy
Apex assesses blank data for potential high bias down to a level equal to the method reporting limit (MRL), except for conventional
chemistry and HCID analyses which are assessed only to the MRL. Sample results flagged with a B or B-02 qualifier are potentially
biased high if they are less than ten times the level found in the blank for inorganic analyses or less than five times the level found in the
blank for organic analyses.
For accurate comparison of volatile results to the level found in the blank; water sample results should be divided by the dilution factor,
and soil sample results should be divided by 1/50 of the sample dilution to account for the sample prep factor.
Results qualified as reported below the MRL may include a potential high bias if associated with a B or B-02 qualified blank. B and B-02
qualifications are not applied to J qualified results reported below the MRL.
---
QC results are not applicable. For example, % Recoveries for Blanks and Duplicates, % RPD for Blanks, Blank Spikes and Matrix
Spikes, etc.
***
Used to indicate a possible discrepancy with the Sample and Sample Duplicate results when the %RPD is not available. In this case,
either the Sample or the Sample Duplicate has a reportable result for this analyte, while the other is Non Detect (ND).
DRAFT REPORT
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 11 of 12
Apex Labs
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
DRAFT REPORT
Reported:
02/26/16 16:36
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 12 of 12
Apex Labs
DRAFT REPORT
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 1 of 19
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/29/16 17:54
Laboratory ID
Matrix
Date Sampled
Date Received
SW-01
A6B0905-01
A6B0905-02
A6B0905-03
A6B0905-04
A6B0905-05
Water
Water
Water
Water
Water
02/28/16 07:15
02/28/16 07:30
02/28/16 07:45
02/28/16 08:00
02/28/16 09:15
02/29/16 06:36
02/29/16 06:36
02/29/16 06:36
02/29/16 06:36
02/29/16 06:36
SW-02
SW-03
SW-04
SW-05
DRAFT REPORT
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 2 of 19
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/29/16 17:54
Analyte
MDL
SW-01 (A6B0905-01)
Reporting
Limit
Dilution
Units
Matrix: Water
Date Analyzed
Method
Benzene
ND
---
0.200
ug/L
02/29/16 12:13
EPA 8260B
Toluene
ND
---
1.00
"
"
"
"
Ethylbenzene
ND
---
0.500
"
"
"
"
Xylenes, total
ND
---
1.50
"
"
"
"
Naphthalene
ND
---
2.00
"
"
"
"
ND
---
1.00
"
"
"
"
Isopropylbenzene
ND
---
1.00
"
"
"
"
n-Propylbenzene
ND
---
0.500
"
"
"
"
1,2,4-Trimethylbenzene
ND
---
1.00
"
"
"
"
1,3,5-Trimethylbenzene
ND
---
1.00
"
"
"
"
1,2-Dibromoethane (EDB)
ND
---
0.500
"
"
"
"
1,2-Dichloroethane (EDC)
ND
---
0.500
"
"
"
"
Recovery: 102 %
Limits: 80-120 %
"
"
"
99 %
Limits: 80-120 %
"
"
"
Toluene-d8 (Surr)
101 %
Limits: 80-120 %
"
"
"
4-Bromofluorobenzene (Surr)
100 %
Limits: 80-120 %
"
"
"
1,4-Difluorobenzene (Surr)
SW-02 (A6B0905-02)
Matrix: Water
Batch: 6020841
Benzene
ND
---
0.200
ug/L
02/29/16 13:10
EPA 8260B
Toluene
ND
---
1.00
"
"
"
"
Ethylbenzene
ND
---
0.500
"
"
"
"
Xylenes, total
ND
---
1.50
"
"
"
"
Naphthalene
ND
---
2.00
"
"
"
"
ND
---
1.00
"
"
"
"
Isopropylbenzene
ND
---
1.00
"
"
"
"
n-Propylbenzene
ND
---
0.500
"
"
"
"
1,2,4-Trimethylbenzene
ND
---
1.00
"
"
"
"
1,3,5-Trimethylbenzene
ND
---
1.00
"
"
"
"
1,2-Dibromoethane (EDB)
ND
---
0.500
"
"
"
"
1,2-Dichloroethane (EDC)
ND
---
0.500
"
"
"
"
SW-03 (A6B0905-03)
Benzene
Recovery: 102 %
Limits: 80-120 %
"
"
"
98 %
Limits: 80-120 %
"
"
"
102 %
Limits: 80-120 %
"
"
"
99 %
Limits: 80-120 %
"
"
"
02/29/16 13:39
EPA 8260B
Matrix: Water
ND
DRAFT REPORT
---
0.200
Notes
Batch: 6020841
Batch: 6020841
ug/L
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 3 of 19
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/29/16 17:54
Analyte
MDL
SW-03 (A6B0905-03)
Reporting
Limit
Dilution
Units
Matrix: Water
Date Analyzed
Method
Toluene
ND
---
1.00
ug/L
"
EPA 8260B
Ethylbenzene
ND
---
0.500
"
"
"
"
Xylenes, total
ND
---
1.50
"
"
"
"
Naphthalene
ND
---
2.00
"
"
"
"
ND
---
1.00
"
"
"
"
Isopropylbenzene
ND
---
1.00
"
"
"
"
n-Propylbenzene
ND
---
0.500
"
"
"
"
1,2,4-Trimethylbenzene
ND
---
1.00
"
"
"
"
1,3,5-Trimethylbenzene
ND
---
1.00
"
"
"
"
1,2-Dibromoethane (EDB)
ND
---
0.500
"
"
"
"
1,2-Dichloroethane (EDC)
ND
---
0.500
"
"
"
"
Recovery: 104 %
Limits: 80-120 %
"
"
"
1,4-Difluorobenzene (Surr)
100 %
Limits: 80-120 %
"
"
"
Toluene-d8 (Surr)
102 %
Limits: 80-120 %
"
"
"
98 %
Limits: 80-120 %
"
"
"
4-Bromofluorobenzene (Surr)
SW-04 (A6B0905-04)
Matrix: Water
Batch: 6020841
Benzene
ND
---
0.200
ug/L
02/29/16 14:08
EPA 8260B
Toluene
ND
---
1.00
"
"
"
"
Ethylbenzene
ND
---
0.500
"
"
"
"
Xylenes, total
ND
---
1.50
"
"
"
"
Naphthalene
ND
---
2.00
"
"
"
"
ND
---
1.00
"
"
"
"
Isopropylbenzene
ND
---
1.00
"
"
"
"
n-Propylbenzene
ND
---
0.500
"
"
"
"
1,2,4-Trimethylbenzene
ND
---
1.00
"
"
"
"
1,3,5-Trimethylbenzene
ND
---
1.00
"
"
"
"
1,2-Dibromoethane (EDB)
ND
---
0.500
"
"
"
"
1,2-Dichloroethane (EDC)
ND
---
0.500
"
"
"
"
SW-05 (A6B0905-05)
Recovery: 105 %
Limits: 80-120 %
"
"
"
99 %
Limits: 80-120 %
"
"
"
101 %
Limits: 80-120 %
"
"
"
97 %
Limits: 80-120 %
"
"
"
Matrix: Water
Batch: 6020841
Benzene
ND
---
0.200
ug/L
02/29/16 14:36
EPA 8260B
Toluene
ND
---
1.00
"
"
"
"
DRAFT REPORT
Notes
Batch: 6020841
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 4 of 19
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/29/16 17:54
Analyte
MDL
SW-05 (A6B0905-05)
Reporting
Limit
Dilution
Units
Matrix: Water
Date Analyzed
Method
Ethylbenzene
ND
---
0.500
ug/L
"
EPA 8260B
Xylenes, total
ND
---
1.50
"
"
"
"
Naphthalene
ND
---
2.00
"
"
"
"
ND
---
1.00
"
"
"
"
Isopropylbenzene
ND
---
1.00
"
"
"
"
n-Propylbenzene
ND
---
0.500
"
"
"
"
1,2,4-Trimethylbenzene
ND
---
1.00
"
"
"
"
1,3,5-Trimethylbenzene
ND
---
1.00
"
"
"
"
1,2-Dibromoethane (EDB)
ND
---
0.500
"
"
"
"
1,2-Dichloroethane (EDC)
ND
---
0.500
"
"
"
"
Recovery: 105 %
Limits: 80-120 %
"
"
"
1,4-Difluorobenzene (Surr)
101 %
Limits: 80-120 %
"
"
"
Toluene-d8 (Surr)
101 %
Limits: 80-120 %
"
"
"
99 %
Limits: 80-120 %
"
"
"
4-Bromofluorobenzene (Surr)
DRAFT REPORT
Notes
Batch: 6020841
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 5 of 19
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/29/16 17:54
Analyte
MDL
SW-01 (A6B0905-01)
Reporting
Limit
Dilution
Units
Matrix: Water
Date Analyzed
Method
Acenaphthene
ND
---
0.0392
ug/L
02/29/16 12:57
Acenaphthylene
ND
---
0.0392
"
"
"
"
Anthracene
ND
---
0.0392
"
"
"
"
Benz(a)anthracene
ND
---
0.0392
"
"
"
"
Benzo(a)pyrene
ND
---
0.0392
"
"
"
"
Benzo(b)fluoranthene
ND
---
0.0392
"
"
"
"
Benzo(k)fluoranthene
ND
---
0.0392
"
"
"
"
Benzo(g,h,i)perylene
ND
---
0.0392
"
"
"
"
Chrysene
ND
---
0.0392
"
"
"
"
Dibenz(a,h)anthracene
ND
---
0.0392
"
"
"
"
Dibenzofuran
ND
---
0.0392
"
"
"
"
Fluoranthene
ND
---
0.0392
"
"
"
"
Fluorene
ND
---
0.0392
"
"
"
"
Indeno(1,2,3-cd)pyrene
ND
---
0.0392
"
"
"
"
1-Methylnaphthalene
ND
---
0.0784
"
"
"
"
2-Methylnaphthalene
ND
---
0.0784
"
"
"
"
Naphthalene
ND
---
0.0784
"
"
"
"
Phenanthrene
ND
---
0.0392
"
"
"
"
Pyrene
ND
---
0.0392
"
"
"
"
DRAFT REPORT
Notes
Batch: 6020838
Recovery: 83 %
Limits: 44-120 %
"
"
"
114 %
Limits: 50-133 %
"
"
"
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 6 of 19
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/29/16 17:54
Analyte
MDL
SW-02 (A6B0905-02)
Reporting
Limit
Dilution
Units
Matrix: Water
Date Analyzed
Method
Acenaphthene
ND
---
0.0404
ug/L
02/29/16 13:24
Acenaphthylene
ND
---
0.0404
"
"
"
"
Anthracene
ND
---
0.0404
"
"
"
"
Benz(a)anthracene
ND
---
0.0404
"
"
"
"
Benzo(a)pyrene
ND
---
0.0404
"
"
"
"
Benzo(b)fluoranthene
ND
---
0.0404
"
"
"
"
Benzo(k)fluoranthene
ND
---
0.0404
"
"
"
"
Benzo(g,h,i)perylene
ND
---
0.0404
"
"
"
"
Chrysene
ND
---
0.0404
"
"
"
"
Dibenz(a,h)anthracene
ND
---
0.0404
"
"
"
"
Dibenzofuran
ND
---
0.0404
"
"
"
"
Fluoranthene
ND
---
0.0404
"
"
"
"
Fluorene
ND
---
0.0404
"
"
"
"
Indeno(1,2,3-cd)pyrene
ND
---
0.0404
"
"
"
"
1-Methylnaphthalene
ND
---
0.0808
"
"
"
"
2-Methylnaphthalene
ND
---
0.0808
"
"
"
"
Naphthalene
ND
---
0.0808
"
"
"
"
Phenanthrene
ND
---
0.0404
"
"
"
"
Pyrene
ND
---
0.0404
"
"
"
"
DRAFT REPORT
Notes
Batch: 6020838
Recovery: 82 %
Limits: 44-120 %
"
"
"
115 %
Limits: 50-133 %
"
"
"
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 7 of 19
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/29/16 17:54
Analyte
MDL
SW-03 (A6B0905-03)
Reporting
Limit
Dilution
Units
Matrix: Water
Date Analyzed
Method
Acenaphthene
ND
---
0.0421
ug/L
02/29/16 13:52
Acenaphthylene
ND
---
0.0421
"
"
"
"
Anthracene
ND
---
0.0421
"
"
"
"
Benz(a)anthracene
ND
---
0.0421
"
"
"
"
Benzo(a)pyrene
ND
---
0.0421
"
"
"
"
Benzo(b)fluoranthene
ND
---
0.0421
"
"
"
"
Benzo(k)fluoranthene
ND
---
0.0421
"
"
"
"
Benzo(g,h,i)perylene
ND
---
0.0421
"
"
"
"
Chrysene
ND
---
0.0421
"
"
"
"
Dibenz(a,h)anthracene
ND
---
0.0421
"
"
"
"
Dibenzofuran
ND
---
0.0421
"
"
"
"
Fluoranthene
ND
---
0.0421
"
"
"
"
Fluorene
ND
---
0.0421
"
"
"
"
Indeno(1,2,3-cd)pyrene
ND
---
0.0421
"
"
"
"
1-Methylnaphthalene
ND
---
0.0842
"
"
"
"
2-Methylnaphthalene
ND
---
0.0842
"
"
"
"
Naphthalene
ND
---
0.0842
"
"
"
"
Phenanthrene
ND
---
0.0421
"
"
"
"
Pyrene
ND
---
0.0421
"
"
"
"
DRAFT REPORT
Notes
Batch: 6020838
Recovery: 67 %
Limits: 44-120 %
"
"
"
109 %
Limits: 50-133 %
"
"
"
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 8 of 19
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/29/16 17:54
Analyte
MDL
SW-04 (A6B0905-04)
Reporting
Limit
Dilution
Units
Matrix: Water
Date Analyzed
Method
Acenaphthene
ND
---
0.0408
ug/L
02/29/16 14:19
Acenaphthylene
ND
---
0.0408
"
"
"
"
Anthracene
ND
---
0.0408
"
"
"
"
Benz(a)anthracene
ND
---
0.0408
"
"
"
"
Benzo(a)pyrene
ND
---
0.0408
"
"
"
"
Benzo(b)fluoranthene
ND
---
0.0408
"
"
"
"
Benzo(k)fluoranthene
ND
---
0.0408
"
"
"
"
Benzo(g,h,i)perylene
ND
---
0.0408
"
"
"
"
Chrysene
ND
---
0.0408
"
"
"
"
Dibenz(a,h)anthracene
ND
---
0.0408
"
"
"
"
Dibenzofuran
ND
---
0.0408
"
"
"
"
Fluoranthene
ND
---
0.0408
"
"
"
"
Fluorene
ND
---
0.0408
"
"
"
"
Indeno(1,2,3-cd)pyrene
ND
---
0.0408
"
"
"
"
1-Methylnaphthalene
ND
---
0.0816
"
"
"
"
2-Methylnaphthalene
ND
---
0.0816
"
"
"
"
Naphthalene
ND
---
0.0816
"
"
"
"
Phenanthrene
ND
---
0.0408
"
"
"
"
Pyrene
ND
---
0.0408
"
"
"
"
DRAFT REPORT
Notes
Batch: 6020838
Recovery: 86 %
Limits: 44-120 %
"
"
"
110 %
Limits: 50-133 %
"
"
"
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 9 of 19
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/29/16 17:54
Analyte
MDL
SW-05 (A6B0905-05)
Reporting
Limit
Dilution
Units
Matrix: Water
Date Analyzed
Method
Acenaphthene
ND
---
0.0440
ug/L
02/29/16 14:46
Acenaphthylene
ND
---
0.0440
"
"
"
"
Anthracene
ND
---
0.0440
"
"
"
"
Benz(a)anthracene
ND
---
0.0440
"
"
"
"
Benzo(a)pyrene
ND
---
0.0440
"
"
"
"
Benzo(b)fluoranthene
ND
---
0.0440
"
"
"
"
Benzo(k)fluoranthene
ND
---
0.0440
"
"
"
"
Benzo(g,h,i)perylene
ND
---
0.0440
"
"
"
"
Chrysene
ND
---
0.0440
"
"
"
"
Dibenz(a,h)anthracene
ND
---
0.0440
"
"
"
"
Dibenzofuran
ND
---
0.0440
"
"
"
"
Fluoranthene
ND
---
0.0440
"
"
"
"
Fluorene
ND
---
0.0440
"
"
"
"
Indeno(1,2,3-cd)pyrene
ND
---
0.0440
"
"
"
"
1-Methylnaphthalene
ND
---
0.0879
"
"
"
"
2-Methylnaphthalene
ND
---
0.0879
"
"
"
"
Naphthalene
ND
---
0.0879
"
"
"
"
Phenanthrene
ND
---
0.0440
"
"
"
"
Pyrene
ND
---
0.0440
"
"
"
"
DRAFT REPORT
Notes
Batch: 6020838
Recovery: 78 %
Limits: 44-120 %
"
"
"
115 %
Limits: 50-133 %
"
"
"
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 10 of 19
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/29/16 17:54
Result
MDL
Reporting
Limit
Units
Dil.
Spike
Amount
Source
Result
%REC
%REC
Limits RPD
RPD
Limit
Notes
Water
Blank (6020841-BLK1)
EPA 8260B
Benzene
ND
---
0.200
ug/L
---
---
---
---
---
---
Toluene
ND
---
1.00
"
"
---
---
---
---
---
---
Ethylbenzene
ND
---
0.500
"
"
---
---
---
---
---
---
Xylenes, total
ND
---
1.50
"
"
---
---
---
---
---
---
Naphthalene
ND
---
2.00
"
"
---
---
---
---
---
---
ND
---
1.00
"
"
---
---
---
---
---
---
ND
---
1.00
"
"
---
---
---
---
---
---
n-Propylbenzene
ND
---
0.500
"
"
---
---
---
---
---
---
1,2,4-Trimethylbenzene
ND
---
1.00
"
"
---
---
---
---
---
---
1,3,5-Trimethylbenzene
ND
---
1.00
"
"
---
---
---
---
---
---
1,2-Dibromoethane (EDB)
ND
---
0.500
"
"
---
---
---
---
---
---
1,2-Dichloroethane (EDC)
ND
---
0.500
"
"
---
---
---
---
---
---
---
---
Recovery: 100 %
Limits: 80-120 %
Dilution: 1x
99 %
80-120 %
"
101 %
80-120 %
"
99 %
80-120 %
"
1,4-Difluorobenzene (Surr)
Toluene-d8 (Surr)
4-Bromofluorobenzene (Surr)
LCS (6020841-BS1)
EPA 8260B
Benzene
18.9
---
0.200
ug/L
20.0
---
94
70-130%
Toluene
20.0
---
1.00
"
"
"
---
100
"
---
---
Ethylbenzene
20.2
---
0.500
"
"
"
---
101
"
---
---
Xylenes, total
61.0
---
1.50
"
"
60.0
---
102
"
---
---
Naphthalene
17.1
---
2.00
"
"
20.0
---
86
"
---
---
18.7
---
1.00
"
"
"
---
93
"
---
---
20.5
---
1.00
"
"
"
---
103
"
---
---
n-Propylbenzene
19.6
---
0.500
"
"
"
---
98
"
---
---
1,2,4-Trimethylbenzene
20.2
---
1.00
"
"
"
---
101
"
---
---
1,3,5-Trimethylbenzene
19.9
---
1.00
"
"
"
---
100
"
---
---
1,2-Dibromoethane (EDB)
20.7
---
0.500
"
"
"
---
103
"
---
---
DRAFT REPORT
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 11 of 19
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/29/16 17:54
Result
Reporting
Limit
MDL
Units
Dil.
Spike
Amount
%REC
%REC
Limits RPD
RPD
Limit
Notes
Water
LCS (6020841-BS1)
1,2-Dichloroethane (EDC)
Source
Result
19.0
---
0.500
ug/L
"
"
---
Recovery: 98 %
Limits: 80-120 %
Dilution: 1x
1,4-Difluorobenzene (Surr)
95 %
80-120 %
"
Toluene-d8 (Surr)
99 %
80-120 %
"
4-Bromofluorobenzene (Surr)
99 %
80-120 %
"
95
"
---
---
Duplicate (6020841-DUP1)
QC Source Sample: SW-01 (A6B0905-01)
EPA 8260B
Benzene
ND
---
0.200
ug/L
---
ND
---
---
---
30%
Toluene
ND
Ethylbenzene
ND
---
1.00
"
"
---
ND
---
---
---
30%
---
0.500
"
"
---
ND
---
---
---
30%
Xylenes, total
Naphthalene
ND
---
1.50
"
"
---
ND
---
---
---
30%
ND
---
2.00
"
"
---
ND
---
---
---
30%
ND
---
1.00
"
"
---
ND
---
---
---
30%
ND
---
1.00
"
"
---
ND
---
---
---
30%
n-Propylbenzene
ND
---
0.500
"
"
---
ND
---
---
---
30%
1,2,4-Trimethylbenzene
ND
---
1.00
"
"
---
ND
---
---
---
30%
1,3,5-Trimethylbenzene
ND
---
1.00
"
"
---
ND
---
---
---
30%
1,2-Dibromoethane (EDB)
ND
---
0.500
"
"
---
ND
---
---
---
30%
1,2-Dichloroethane (EDC)
ND
---
0.500
"
"
---
ND
---
---
---
30%
Recovery: 102 %
Limits: 80-120 %
Dilution: 1x
99 %
80-120 %
"
102 %
80-120 %
"
98 %
80-120 %
"
1,4-Difluorobenzene (Surr)
Toluene-d8 (Surr)
4-Bromofluorobenzene (Surr)
Benzene
20.8
---
0.200
ug/L
20.0
ND
104
70-130%
---
---
Toluene
21.5
---
1.00
"
"
"
ND
108
"
---
---
Ethylbenzene
21.8
---
0.500
"
"
"
ND
109
"
---
---
DRAFT REPORT
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 12 of 19
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/29/16 17:54
Result
MDL
Reporting
Limit
Units
Dil.
Spike
Amount
Source
Result
%REC
%REC
Limits RPD
RPD
Limit
Notes
Water
Xylenes, total
65.0
---
1.50
ug/L
"
60.0
ND
108
"
---
---
Naphthalene
16.8
---
2.00
"
"
20.0
ND
84
"
---
---
19.3
---
1.00
"
"
"
ND
96
"
---
---
22.2
---
1.00
"
"
"
ND
111
"
---
---
n-Propylbenzene
20.8
---
0.500
"
"
"
ND
104
"
---
---
1,2,4-Trimethylbenzene
20.8
---
1.00
"
"
"
ND
104
"
---
---
1,3,5-Trimethylbenzene
21.0
---
1.00
"
"
"
ND
105
"
---
---
1,2-Dibromoethane (EDB)
21.6
---
0.500
"
"
"
ND
108
"
---
---
1,2-Dichloroethane (EDC)
20.5
---
0.500
"
"
"
ND
102
"
---
---
Recovery: 100 %
Limits: 80-120 %
Dilution: 1x
1,4-Difluorobenzene (Surr)
97 %
80-120 %
"
Toluene-d8 (Surr)
99 %
80-120 %
"
4-Bromofluorobenzene (Surr)
97 %
80-120 %
"
DRAFT REPORT
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 13 of 19
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/29/16 17:54
Result
Reporting
Limit
MDL
Units
Dil.
Spike
Amount
Source
Result
%REC
%REC
Limits RPD
RPD
Limit
Notes
Water
Blank (6020838-BLK1)
EPA 8270D (SIM)
Acenaphthene
ND
---
0.0364
ug/L
---
---
---
---
---
---
Acenaphthylene
ND
---
0.0364
"
"
---
---
---
---
---
---
Anthracene
ND
---
0.0364
"
"
---
---
---
---
---
---
Benz(a)anthracene
ND
---
0.0364
"
"
---
---
---
---
---
---
Benzo(a)pyrene
ND
---
0.0364
"
"
---
---
---
---
---
-----
Benzo(b)fluoranthene
ND
---
0.0364
"
"
---
---
---
---
---
Benzo(k)fluoranthene
ND
---
0.0364
"
"
---
---
---
---
---
---
Benzo(g,h,i)perylene
ND
---
0.0364
"
"
---
---
---
---
---
---
Chrysene
ND
---
0.0364
"
"
---
---
---
---
---
---
Dibenz(a,h)anthracene
ND
---
0.0364
"
"
---
---
---
---
---
---
Dibenzofuran
ND
---
0.0364
"
"
---
---
---
---
---
---
Fluoranthene
ND
---
0.0364
"
"
---
---
---
---
---
---
Fluorene
ND
---
0.0364
"
"
---
---
---
---
---
---
Indeno(1,2,3-cd)pyrene
ND
---
0.0364
"
"
---
---
---
---
---
---
1-Methylnaphthalene
ND
---
0.0727
"
"
---
---
---
---
---
---
2-Methylnaphthalene
ND
---
0.0727
"
"
---
---
---
---
---
---
Naphthalene
ND
---
0.0727
"
"
---
---
---
---
---
---
Phenanthrene
ND
---
0.0364
"
"
---
---
---
---
---
---
Pyrene
ND
---
0.0364
"
"
---
---
---
---
---
---
---
Recovery: 97 %
Limits: 44-120 %
Dilution: 1x
126 %
50-133 %
"
p-Terphenyl-d14 (Surr)
LCS (6020838-BS1)
EPA 8270D (SIM)
Acenaphthene
6.88
---
0.0400
ug/L
8.00
---
86
47-122%
---
Acenaphthylene
6.99
---
0.0400
"
"
"
---
87
41-130%
---
---
Anthracene
7.45
---
0.0400
"
"
"
---
93
57-123%
---
---
Benz(a)anthracene
7.32
---
0.0400
"
"
"
---
92
58-125%
---
---
Benzo(a)pyrene
7.90
---
0.0400
"
"
"
---
99
54-128%
---
---
Benzo(b)fluoranthene
7.86
---
0.0400
"
"
"
---
98
53-131%
---
---
Benzo(k)fluoranthene
8.18
---
0.0400
"
"
"
---
102
57-129%
---
---
DRAFT REPORT
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 14 of 19
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/29/16 17:54
Result
Reporting
Limit
MDL
Units
Dil.
Spike
Amount
%REC
%REC
Limits RPD
RPD
Limit
Notes
Water
LCS (6020838-BS1)
Benzo(g,h,i)perylene
Source
Result
6.28
---
0.0400
"
"
"
---
78
50-134%
---
---
Chrysene
7.23
---
0.0400
"
"
"
---
90
59-123%
---
---
Dibenz(a,h)anthracene
7.25
---
0.0400
"
"
"
---
91
51-134%
---
-----
Dibenzofuran
7.12
---
0.0400
"
"
"
---
89
53-120%
---
Fluoranthene
7.07
---
0.0400
"
"
"
---
88
57-128%
---
---
Fluorene
7.17
---
0.0400
"
"
"
---
90
52-124%
---
---
Indeno(1,2,3-cd)pyrene
6.66
---
0.0400
"
"
"
---
83
52-133%
---
---
1-Methylnaphthalene
6.48
---
0.0800
"
"
"
---
81
41-120%
---
---
2-Methylnaphthalene
6.84
---
0.0800
"
"
"
---
85
40-121%
---
---
Naphthalene
6.62
---
0.0800
"
"
"
---
83
"
---
---
Phenanthrene
7.43
---
0.0400
"
"
"
---
93
59-120%
---
---
Pyrene
7.02
---
0.0400
"
"
"
---
88
57-126%
---
---
Recovery: 91 %
Limits: 44-120 %
Dilution: 1x
112 %
50-133 %
"
p-Terphenyl-d14 (Surr)
Q-19
Acenaphthene
6.36
---
0.0400
ug/L
8.00
---
80
47-122%
30%
Acenaphthylene
6.48
---
0.0400
"
"
"
---
81
41-130%
30%
Anthracene
7.06
---
0.0400
"
"
"
---
88
57-123%
30%
Benz(a)anthracene
7.19
---
0.0400
"
"
"
---
90
58-125%
30%
Benzo(a)pyrene
7.78
---
0.0400
"
"
"
---
97
54-128%
30%
Benzo(b)fluoranthene
8.07
---
0.0400
"
"
"
---
101
53-131%
30%
Benzo(k)fluoranthene
7.91
---
0.0400
"
"
"
---
99
57-129%
30%
Benzo(g,h,i)perylene
6.03
---
0.0400
"
"
"
---
75
50-134%
30%
Chrysene
7.16
---
0.0400
"
"
"
---
89
59-123%
30%
Dibenz(a,h)anthracene
7.05
---
0.0400
"
"
"
---
88
51-134%
30%
Dibenzofuran
6.67
---
0.0400
"
"
"
---
83
53-120%
30%
Fluoranthene
6.63
---
0.0400
"
"
"
---
83
57-128%
30%
Fluorene
6.79
---
0.0400
"
"
"
---
85
52-124%
30%
Indeno(1,2,3-cd)pyrene
6.49
---
0.0400
"
"
"
---
81
52-133%
30%
1-Methylnaphthalene
5.81
---
0.0800
"
"
"
---
73
41-120%
11
30%
DRAFT REPORT
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 15 of 19
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/29/16 17:54
Result
Reporting
Limit
MDL
Units
Dil.
Spike
Amount
%REC
%REC
Limits RPD
RPD
Limit
2-Methylnaphthalene
6.05
Naphthalene
Phenanthrene
Pyrene
---
0.0800
"
"
"
---
76
5.95
---
0.0800
"
"
"
---
7.07
---
0.0400
"
"
"
---
6.59
---
"
"
"
---
0.0400
Recovery: 83 %
Limits: 44-120 %
Dilution: 1x
113 %
50-133 %
"
p-Terphenyl-d14 (Surr)
DRAFT REPORT
Notes
Water
Source
Result
Q-19
40-121%
12
30%
74
"
11
30%
88
59-120%
30%
82
57-126%
30%
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 16 of 19
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/29/16 17:54
Default
RL Prep
Initial/Final
Initial/Final
Factor
Matrix
Method
Sampled
Prepared
02/28/16 07:15
02/28/16 07:30
02/28/16 07:45
02/28/16 08:00
02/28/16 09:15
02/29/16 11:35
02/29/16 11:35
02/29/16 11:35
02/29/16 11:35
02/29/16 11:35
Batch: 6020841
A6B0905-01
A6B0905-02
A6B0905-03
A6B0905-04
A6B0905-05
Water
Water
Water
Water
Water
EPA 8260B
EPA 8260B
EPA 8260B
EPA 8260B
EPA 8260B
5mL/5mL
5mL/5mL
5mL/5mL
5mL/5mL
5mL/5mL
5mL/5mL
5mL/5mL
5mL/5mL
5mL/5mL
5mL/5mL
1.00
1.00
1.00
1.00
1.00
Matrix
Method
Sampled
Prepared
02/28/16 07:15
02/28/16 07:30
02/28/16 07:45
02/28/16 08:00
02/28/16 09:15
02/29/16 10:09
02/29/16 10:09
02/29/16 10:09
02/29/16 10:09
02/29/16 10:09
Sample
Default
RL Prep
Initial/Final
Initial/Final
Factor
1000mL/2mL
1000mL/2mL
1000mL/2mL
1000mL/2mL
1000mL/2mL
0.98
1.01
1.05
1.02
1.10
Batch: 6020838
A6B0905-01
A6B0905-02
A6B0905-03
A6B0905-04
A6B0905-05
Water
Water
Water
Water
Water
DRAFT REPORT
1020mL/2mL
990mL/2mL
950mL/2mL
980mL/2mL
910mL/2mL
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 17 of 19
Apex Labs
Project: AT&T Hall Ridge
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
Reported:
02/29/16 17:54
Blank Spike Duplicate (BSD) sample analyzed in place of Matrix Spike/Duplicate samples due to limited sample amount available for
analysis.
Analyte DETECTED
ND
NR
Not Reported
dry
Sample results reported on a dry weight basis. Results listed as 'wet' or without 'dry'designation are not dry weight corrected.
RPD
MDL
If MDL is not listed, data has been evaluated to the Method Reporting Limit only.
WMSC
Water Miscible Solvent Correction has been applied to Results and MRLs for volatiles soil samples per EPA 8000C.
Batch
QC
Unless specifically requested, this report contains only results for Batch QC derived from client samples included in this report. All
analyses were performed with the appropriate Batch QC (including Sample Duplicates, Matrix Spikes and/or Matrix Spike Duplicates) in
order to meet or exceed method and regulatory requirements. Any exceptions to this will be qualified in this report. Complete Batch QC
results are available upon request. In cases where there is insufficient sample provided for Sample Duplicates and/or Matrix Spikes, a
Lab Control Sample Duplicate (LCS Dup) is analyzed to demonstrate accuracy and precision of the extraction and analysis.
Blank
Policy
Apex assesses blank data for potential high bias down to a level equal to the method reporting limit (MRL), except for conventional
chemistry and HCID analyses which are assessed only to the MRL. Sample results flagged with a B or B-02 qualifier are potentially
biased high if they are less than ten times the level found in the blank for inorganic analyses or less than five times the level found in the
blank for organic analyses.
For accurate comparison of volatile results to the level found in the blank; water sample results should be divided by the dilution factor,
and soil sample results should be divided by 1/50 of the sample dilution to account for the sample prep factor.
Results qualified as reported below the MRL may include a potential high bias if associated with a B or B-02 qualified blank. B and B-02
qualifications are not applied to J qualified results reported below the MRL.
---
QC results are not applicable. For example, % Recoveries for Blanks and Duplicates, % RPD for Blanks, Blank Spikes and Matrix
Spikes, etc.
***
Used to indicate a possible discrepancy with the Sample and Sample Duplicate results when the %RPD is not available. In this case,
either the Sample or the Sample Duplicate has a reportable result for this analyte, while the other is Non Detect (ND).
DRAFT REPORT
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 18 of 19
Apex Labs
NRC-CB&I
6211 N Ensign St
Portland, OR 97217
DRAFT REPORT
Reported:
02/29/16 17:54
The results provided in this report are PRELIMINARY and are subject to change based
on subsequent analysis, QC validation or final data review. Please use these results
with the understanding that they may have not been finalized by the laboratory
Page 19 of 19
AppendixB
BiostimulationProductInformation
Overview'of'OSE'II!
OSE$II:$
! Invented$in$1989.$$
! Manufactured$in$the$USA.$
! Used$in$more$than$40$countries$across$the$world.$$
! Remediated$more$than$28,000$spills$and$contaminated$sites.$
$
$
Features$of$OSE$II$include:$
! 100%$biodegradable$and$nonItoxic.$
! Effective$in$remediating$all$types$of$hydrocarbons$$fresh$and$weathered.$
! Easily$applied$and$no$need$for$special$protective$clothing.$
! Effective$in$a$large$range$of$temperatures.$
! Enhances$natures$process$for$bioIremediating$hydrocarbons.$
How$OSE$II$works:$
Process'and'benets!
When$combined$with$fresh$or$salt$water,$OSE$II$breaks$down$the$molecular$
structure$of$hydrocarbons$through$the$effects$of$bioIsurfactants,$followed$
by$enzymes$developing$protein$binding$sites$and$acting$as$a$catalyst,$while$
enhancing$indigenous$bacteria$to$rapidly$colonize.$$$
$
The$enhanced$bacteria$use$the$detoxiSied$hydrocarbons$as$a$food$source$via$
the$enzymatic$catalyst,$digesting$the$hydrocarbon$based$material$to$carbon$
dioxide$and$water.$
BeneSits$of$using$OSE$II:$$
!
Remediating$hydrocarbon$contaminated$soil,$water$and$waste.$$
The$toxins$and$contaminants$are$removed$from$the$environment,$
not$transferred.$
Cleaning$up$oil$spills$/$contaminated$areas$without$having$to$
separate$and$dispose$of$hydrocarbon$contaminated$waste.$$$
OSE$II$is$effective$in$cleaning$large$contaminated$sites$enabling$
land$to$be$returned$to$preIspill$conditions$and$re#vegetated$and$
restored$for$beneSicial$use.$$$
Kadhema$ScientiSic$Consultancy$&$Services$will$manage$the$
revegetation$for$the$project.$
Its$ability$to$be$used$in$sensitive$environments$as$it$is$nonI
hazardous$and$can$be$applied$in$a$variety$of$ways$preventing$
physical$damage$as$a$result$of$access$to$difSicult$to$reach$
locations.$
Comparing'OSE'II'with'tradi;onal'methods!
Excavation$
Contaminated$materials$are$
dug$up$and$loaded$into$trucks$
for$transport$I$expensive$
process$and$risks$associated$
with$transporting$hazardous$
waste.$
Dust$is$generated$from$the$
excavation$and$truck$
movements.$
Waste$requires$disposal$at$
facility$licensed$to$receive$
hazardous$waste.$$Expensive$
to$dispose$of$hazardous$waste$
I$limited$facilities$available.$
Equipment$used$for$
extraction$must$be$thoroughly$
cleaned$and$decontaminated$
prior$to$leaving$the$site.$
Digging$up$and$hauling$off$
soil$/$sand$may$have$impacts$
on$local$ecology.$
Incineration$
Requires$extremely$high$
temperatures$(therefore$
energy)$to$break$down$
contaminants$into$nontoxic$
substances,$such$as$water,$
carbon$dioxide,$and$nitrogen$
oxides.$
Unlikely$that$100%$of$the$
hazardous$waste$is$destroyed$
during$the$incineration$
process.$
Leftover$ash$and$material$
removed$from$the$incinerator$
is$hazardous$and$requires$
disposal$at$a$facility$licenced$
to$receive$hazardous$waste.$
Air$emissions$and$odour$
possible$if$process$is$not$
efSicient.$
Thermal$desorption$
Extreme$safety$precautions$
required$due$to$elevated$
heating$at$the$site.$
Responders$need$to$wear$
special$protective$gear.$
Size$of$particles$can$restrict$
clean$up,$or$produce$a$
secondary$required$process.$
Bioremediation$OSE$II$
No$speciSic$precautions$need$
to$be$taken.$
No$speciSic$protective$clothing$
required$when$handling$OSE$
II.$
Particle$size$does$not$affect$
remediation.$
No$vapours$emitted.$
Harmful$vapours$given$off$
that$need$to$be$captured$for$
secondary$processing.$
Soil$needs$reprocessing$to$
complete$removal$of$
contaminants.$
Area$to$be$heated$up,$or$
mobile$unit$has$limitations$of$
size$or$amount$of$soil$to$be$
addressed$at$one$time.$
Potentially$higher$risks$and$
insurance$costs.$
In$relation$to$soil.$$Sterilizes$
soil,$making$it$virtually$
useless.$
OSE$II$is$a$oneItime$
application$and$treats$
contamination$at$the$source.$$
No$disposal$of$waste$is$
required.$
OSE$II$can$be$applied$to$an$
indeSinite$area.$
Emulates$natures$process$
allowing$soil$to$be$returned$to$
pre$contamination$conditions,$
converting$soil$into$a$valuable$
top$soil$for$resale.$
Tes;ng'&'approval'across'the'world'!
Extensive$efSicacy$and$toxicity$testing$have$contributed$to$OSE$II$being$recognized$as$an$effective$oil$spill$and$
bioremediation$product$and$is$approved$for$the$following:$
!
Regional$Organization$for$the$Protection$of$the$Marine$Environment$(ROPME)$Marine$Emergency$Mutual$
Aid$Centre$(MEMAC)$Oil$Spill$Combating$Product$(approval$Ref:$337/12IRHD).$$This$includes:$
o State$of$Kuwait$
o State$of$Oman$
o State$of$Qatar$
$
$
$
$
$
$
o Kingdom$of$Saudi$
o United$Arab$Emirates$
o Kingdom$of$Bahrain$
o Islamic$Republic$of$Iran$
o Republic$of$Iraq$
US$Environmental$Protection$Agencys$National$Contingency$Plan$for$Oil$Spills$(US$EPA$NCP$#$B53).$
UK$Marine$Management$Organization$(ODA$241/2015).$
Australian$Maritime$Safety$Authoritys$National$Plan$to$Combat$the$Pollution$of$the$Sea$by$Oil$and$Other$
Noxious$and$Hazardous$Substances$(#OBA$Bioremediation$Oil$Spill$Control$Agent).$
New$Zealand$Environment$Protection$Authority,$Status$of$Substance$(SOS$#1001797).$
Greece$(ID$no:$17554);$Philippines$(accreditation$#PCGI14I06I112);$Nigeria$(NOSDRA$cert:$189);$Mexico;$
Israel;$Trinidad$and$Tobago;$and$South$Korea$(cert$no:$SI007).$$
$$
Business'case'for'OSE'II!
OSE$II$is$suited$to$large$contaminated$areas$due$to$the$ease$of$application$and$ability$to$treat$
contaminated$soil$at$the$source.$
$$
The$following$expenses$are$eliminated$when$OSE$II$is$used:$
! Clean$up$and$/$or$disposal$of$equipment$and$material$contaminated$with$hydrocarbons.$
! Treatment$of$contaminated$soil,$contaminated$water,$oily$sludge$or$mud$prior$to$disposal.$
! Extraction,$transport$and$disposal$of$contaminated$soil$(including$mud,$sludge)$and$water.$
$$
The$following$risks$are$eliminated$when$OSE$II$is$used:$
! Accidental$release$and$spill$during$transit$to$waste$facility.$
! Contaminants$not$completely$removed$from$the$environment$resulting$in$long$term$impact.$
! Having$to$relocate$the$contaminated$soil$for$treatment$at$another$facility.$
$$
Conclusion!
Clean$up$using$OSE$II$will$return$contaminated$land$to$pre$spill$conditions,$suitable$for$reI
vegetating$and$restoring.$$
Page 1 of 4
Emergency Management
You are here: EPA Home Emergency Management
Schedule OIL SPILL EATER II
NCP Subpart J
NCP Product
IV. SPECIAL HANDLING AND WORKER PRECAUTIONS FOR STORAGE AND FIELD
APPLICATION
1. Flammability: Water-based, non-flammable
2. Ventilation: Needs no ventilation; aqueous-based product; does not emit hazardous
vapors
3. Skin and eye contact; protective clothing; treatment in case of contact: OSE II is not a
primary dermal irritant. Avoid eye contact, and wear goggles if possible for the spray to
come in direct contact with eyes. Facilities for quick and copious eye flushing should be
provided and prompt medical attention should be sought if exposure and irritation persists.
Protective rubber gloves are suggested during handling. Before mixing the product has a
smell of fermentation. The product does not give off any harmful vapors.
4.a. Maximum storage temperature: 120F
http://www.epa.gov/emergencies/content/ncp/products/oseater.htm
4/3/2011
Page 2 of 4
4.b. Minimum storage temperature: None; OSE II can freeze and thaw without adverse
effects
4.c. Optimum storage temperature range: 72F
4.d. Temperatures of phase separations and chemical changes: 120F
V. SHELF LIFE
OSE II has a recommended shelf life of 5 years. After 5 years at optimum storage
temperature, there is an approximate 10% decrease per year in product capability.
VI. RECOMMENDED APPLICATION PROCEDURE
1. Application Method:
A. Use surface spray apparatus, such as small hand held tanks, back pack, large mixing
tanks with mechanical pumping devices, vessels with booms for spraying wide paths, or
spray devices on airplanes or helicopters.
B. OSE II can be applied by eductor systems from vessels, fire trucks, etc. Set the eductor
system to 2% and apply 1 gallon of mixed OSE II to each spilled gallon of hydrocarbon.
2. Concentration/Application Rate:
General - OSE II generally takes 3 to 30 minutes to penetrate the molecular walls of
hydrocarbons. However, once you spray OSE II on the hydrocarbons, OSE II attaches itself
and will eventually engulf the hydrocarbons regardless of where the hydrocarbons may
spread on the surface of salt or fresh water. Additionally, once you spray OSE II, the
hydrocarbons cannot attach itself to the shoreline, rocks, or any equipment in its path. OSE
II breaks down the adhesion properties of hydrocarbons and causes hydrocarbons to float,
thereby, eliminating secondary contamination of the water column or any other areas, and
holding the contaminated area to the waters surface, the original contaminated area.
If OSE II is to be used on ocean spills or on intertidal zones OSE II should be mixed
with ocean water.
If OSE II is to be used on lakes, rivers, streams, ponds, or on land mix the product
with water from a lake, stream, or pond.
If you are performing a clean up, make sure the water used to mix with OSE II, and
the water used to keep the area saturated, is the type of water normally associated
with that area.
If you use fresh water in an area normally contacted with salt water or vice versa,
the different types of bacteria and competition could occur, not to mention the
problems with salinity for fresh water organisms.
[Note: Do not mix tap water with OSE II if possible: Chlorine in tap water slows bacterial
enhancement]
Spills on Water:
Dilute each gallon of OSE II with 50 gallons of fresh, brackish, or salt water - depending on
the water associated with the area that has been impacted by the spill. Apply OSE II at a
ratio of 1 gallon mixed OSE II to each gallon of hydrocarbon spilled. Apply using hand held
sprayers, tank sprayers, booms from vessels, helicopters, or airplanes; by spraying the
perimeter first then working toward the middle of the spilled area. Next spray the entire
surface of the spill. If the spill is very heavy (more than 2 inches thick) it is recommended
that OSE II be applied every day until you have met a 1:1 ratio of OSE II and water
mixture to spilled oil/hydrocarbons.
Use 1 gallon OSE II for every 50 gallons of hydrocarbons.
Use 1 drum of OSE II for every 2,750 gallons of hydrocarbons.
If you know gallons of hydrocarbons spilled, multiply gallons of hydrocarbons by
0.02 to get amount of OSE II needed [gallons of hydrocarbons x 0.02 = gallons of
OSE II].
If you know barrels of crude oil spilled, multiply barrels of crude oil by 0.015 to get
drums of OSE II needed [barrels of crude oil x 0.015 = drums of OSE II].
If you do not know gallons of hydrocarbons or barrels of crude oil, multiply size of
spill by 0.0023 to get drums of OSE II needed or by 0.12 to get gallons of OSE II
http://www.epa.gov/emergencies/content/ncp/products/oseater.htm
4/3/2011
Page 3 of 4
needed [(yards long x yards wide x inches thick) x 0.0.0023 = drums of OSE II or
(yards long x yards wide x inches thick) x 0.015 = gallons of OSE II].
Intertidal Zone:
Mix each 55 gallon drum of OSE II with 2,750 gallons of fresh, brackish, or salt water. The
water used is determined by the type of water associated with the site. OSE II should be
applied as the tide recedes (if there is a tide) and once the tide comes in the application
should cease until the tide recedes again. Additional applications should only be warranted
if spill has been allowed time to percolate into the depths of the soil.
If there is no tide, but waves have pushed the spill into the intertidal zone, then there will
be direct access to the spill at all times. If possible use string or stakes to grid off the beach
or intertidal zone area, and then you can calculate how much premixed OSE II to apply to a
given area. If unable to grid off an area then calculate how much OSE II to apply and then
determine how much premixed OSE II will flow through a nozzle (gallons per minute) then
let application technician know how many gallons to apply in a given area and this can be
determined by applying product for a certain time period to get the correct amount of OSE
II applied to gain the 1:1 ratio.
Note: If the intertidal zone is associated with the sea then mix OSE II with salt water. If the
spill area is in an area of brackish water then mix OSE II with brackish water. If the
intertidal zone is associated with fresh water such as lakes, rivers, streams, ponds, creeks,
aquifers, or drinking water wells then use fresh water to mix OSE II.
3. Conditions for Use:
OSE II can remediate hydrocarbon-based material including chlorinated
hydrocarbons, PCB's, dioxins, and some pesticides.
As the age of spilled hydrocarbons increases, the time necessary for bioremediation
increases. In general, fresh crude, gasoline of BTEX takes from 72 hours to 30 days
to completely bioremediate.
Variations of sea water salinity should have no effect, but as long as microbial life
can exist, then OSE II will be effective.
OSE II bioremediation slows somewhat at temperatures below 40F. OSE II
however, will continue to work at any liquid water temperature that will sustain
microbial life.
RED%
28
DAYS
TOTAL MEAN
AROMATICS
(ppm)
RED%
28
DAYS
CONTROL
NUTRIENT
OSE II
43,170
40,569
41,730
11,435
11,785
12,155
CONTROL
NUTRIENT
OSE II
39,250
34,815
26,316
9.1
14.2
36.9
10,355
9,898
8,072
9.4
16.0
33.6
28
CONTROL
NUTRIENT
OSE II
35,797
26,507
4,273
17.1
34.7
89.8
9,534
8,938
1,268
16.6
24.2
89.6
http://www.epa.gov/emergencies/content/ncp/products/oseater.htm
4/3/2011
Control: 16.5%
Nutrient: 52.0%
Product: 85.4%
Page 4 of 4
http://www.epa.gov/emergencies/content/ncp/products/oseater.htm
Last updated on Thursday, January 27, 2011
pH: 7.0
Temperature: 72F
Salinity Ranges: Fresh water to salt water
Maximum and Minimum pH: 3.5 - 8.0
Maximum and Minimum Temperature: 28F - 128F
Maximum and Minimum Salinity Levels - Salinity level above that will support
microbial activity will adversely effect OSE II's performance
g. Enzyme Shelf Life: Up to 5 years when properly stored
h. Enzyme Optimal Storage Conditions: 72F is optimal, enzyme range is freezing to
120F, never leave OSE II in direct sunlight for more than a couple of hours
http://www.epa.gov/emergencies/content/ncp/products/oseater.htm
4/3/2011
23
3821000000
Product Type:
Supplier:
Address:
Contact Numbers:
Telephone:
(972) 669-3390
Fax:
(469)241-0896
E-mail:
oseicorp@msn.com
(972) 669-3390
Emergency Covers:
2. HAZARDOUS IDENTIFICATION
Human Health Hazards:
Safety Hazards:
Environmental Hazards:
Advice to Physicians:
Extinguishing Media:
Personal Protection:
Environmental Precautions:
Storage:
Storage Temperatures:
Recommended Materials:
Unsuitable Materials:
None known.
Other Information:
Hygiene Measures:
Respiratory Protection:
Hand Protection:
Eye Protection:
Body Protection:
Color:
Amber to brown .
Odor:
Vapor Pressure:
Same as H20.1.0215
Density:
Vapor Density:
Dropping Point:
Same as H20.
Flash Point:
Nonflammable.
Nonflammable.
Auto-ignition Temperature:
Non-igniting
Solubility in Water:
100%
Elements Content:
None.
Stable.
Conditions to Avoid:
Materials to Avoid:
None.
Eye Irritation:
Skin Irritation:
Respiratory Irritation:
Virtually none.
Skin Sensitization:
None expected.
Carcinogenicity:
Not a carcinogen.
Mutagenicity:
Not a mutagenic.
Human Effects:
None expected.
Other Information:
Not applicable.
PersistencelDegradability:
Bioaccumulation:
None
Ecotoxicity:
US EAP
100% soluble.
LC50 Brine shrimp: >1,900
mg/l up to 10,000 mg/l.
LC50 Fundulus Heterocletus
96 hour: 5,258 mg/l.
Environment Canada
LC50 Rainbow Trout:10,000
mg/l.
OSEI with the city of Plano Tx LC50 Fathead Minnows
(Pimephale promelas): 9,300
mg/l.
Australia NATA test results:
IC10(milky oyster,
Saccostrea echinata): 11.0
(10.0-11.9)mg/l/48h
EC50(milky oyster,
Saccostrea echinata): 16.5
(16.0-17.1)mg/l/48h
NOEC(milky oyster,
Saccostrea echinata):
10.0mg/l
LOEC(milky oyster,
Saccostrea echinata):
20.0mg/l
EC10(mussel, Mytilus
galloprovincialis):
>20.0mg/l/72h
EC50(mussel, Mytilus
galloprovincialis):
>20.0mg/l/72h
NOEC(mussel, Mytilus
galloprovincialis):
20.0mg/l
LOEC(mussel, Mytilus
galloprovincialis):
>20.0mg/l
Waste Disposal:
No special disposal.
Product Disposal:
No special disposal.
Container Disposal:
No special disposal.
Local Legislation:
Not applicable.
EC Classification:
Not Known.
EC Symbols:
Not Known.
EC Risk Phrases:
Not Known.
EINECS (EC):
Not Known.
TSCA (USA):
Other Information:
Dangerous Constituents:
None.
!!
!
!
!
!
!
US!EPA!NCP!#!B53,!!
New!Zealand!EPA!SOS # 1001797,
Australia #OBA
Oil Spill Control agent Greek registration ID
no:17554
Gulf States MEMAC approval Ref:337/12RHD,
Philippine accreditation #PCG-14-06-112
Nigeria NOSDRA cert: 189,
Mexico Coatzacoalcos.Ver.,a 30 de Julio de
2014,
Israel approval,
UK approval #ODA 241/2015 ,
Trinidad and Tobago approval#
MEEA:12.1.5 Vol. XXXXII, South Korea cert
no: S-007 !
Steven Pedigo
(972) 669-3390
Fax Number:
(469) 241-0896
E-Mail:
oseicorp@msn.com
SDS History:
Not Applicable
Revisions Highlighted
None.
20
LC 50 = Lethal concentration values in parts per million measuring level in which there is mortality with 50 percent of
species being tested over a specific period of time. Higher # = less toxic, lower # = greater toxicity in ppm.
Sample Toxic ity Com par ison, Envi ronment Canada and US EPA Tests,
Bioremediation vs. Corexits 34
xiii. surfactant. A substance that lowers the surface tension of water, making it easier for organic compounds to be dissolved in the water.
There are toxic and nontoxic surfactants; i.e., chemical based with various degrees of toxicity, and plant/living-organism based = nontoxic.
22
Our research found that an EA Type bioremediation technology that meets the above
criteria exists today and is being used in over
30 countries. Its results contrast strongly with
those derived from dispersants predominantly
used in US navigable waters. Additionally,
it costs a fraction of the other methods and
would therefore represent an economic boon,
not only to the responsible parties, who could
avoid damage claims and heavy nes, but also
to those living in the environment, reducing
business disruptions with rapid cleanup,
bringing a quick return to their livelihoods.
In other words, in addition to preserving the
health and safety of the waters, there would
23
IDENTITY)
Micro-Blaze
Non-Formulated
Section I
Manufacturers name
Address
800 / 626-6598
713 / 691-6468
01/01/13
Signature of Preparer
William L. Scogin, President
CAS Number:
NONE
OSHA PEL
N/A
Other Limits
Recommended
ACGIH TLV
N/A
% (optional)
N/A
100C
Equiv. water
Melting Point
N/A
Equiv. water
N/A
1.0
100%
Opaque liquid, slight odor
Extinguishing Media
N/A
Non-flammable
LEL
UEL
----
----
Non-flammable
None
None - NON-FLAMMABLE
OSHA 174 Sept. 1985
Unstable
Conditions to Avoid
Stable
Incompatibility (Materials to Avoid)
XXXX
Hazardous
Polymerization
Conditions to Avoid
XXXX
Section VIHealth Hazard Data
Route(s) of Entry
Inhalation?
Skin?
Ingestion?
Organisms used are non-pathogenic. These organisms are susceptible to commonly used antibiotics.
Carcinogenicity
NTP?
N/A
IARC Monographs?
N/A
N/A
OSHA Regulated?
N/A
Skin: slight redness on hands and forearms if individual has a history of dermal allergic
reaction. Inhalation: if inhaled, remove victim to fresh air. Give oxygen or artificial respiration as needed. Obtain
emergency medical attention.
Medical Conditions
Generally Aggravated by Exposure Dermal
Emergency and First Aid Procedures
May mop up spills; may flush down sanitary drain into waste water
treatment lines.
Waste Disposal Method
Disposal of this product or its residue must be done in accordance with all local, state and
federal requirements.
Precautions to Be Taken in Handling and Storing
Other Precautions
To maintain shelf life, avoid temperatures under 32 F or over 120 F for long periods of time.
Microbes are viable up to 180 F. KEEP FROM PROLONGED FREEZING.
Section VIIControl Measures
Respiratory Protection (Specify Type
Ventilation
Local Exhaust
Special
Mechanical (General)
Other
Protective Gloves
Eye Protection
Non-Formulated
Non-Formulated
Product Details
Appearance:
Light brown
pH:
7.0 8.0
Shelf Life:
10 Years
Storage:
Remediation
of
ground
water
contamination
Packaging:
1-Gallon Pail
5-Gallon Pail
55-Gallon Drum
275-Gallon Tote
SURFACTANT FREE
* Always obtain regulatory approval prior to putting any
product into a waterway
0912