Anda di halaman 1dari 5

Geophysics foundations:

Physical properties:
Magnetic susceptibility of geologic materials
Introduction
Recall that geophysical surveys are done in order to learn about the distribution of some physical
property. Interpreting this distribution in terms of geology is a separate step. For magnetic surveys,
the relevant physical property is magnetic susceptibility, or less commonly, the related property
magnetic permeability. NOTE: citations referenced within this page are at the end of the page.
What is susceptibility? When there is no external magnetic field, individual magnetic zones
("magnetic domains") within rocks, soils or other materials will generally be oriented randomly. The
net effect would be a zero magnetic field. However, when the material is in the presence of an
external magnetic field such as Earths field, the individual magnetic domains become more or less
aligned, resulting in a net non-zero field. This is a secondary field distinct from, but caused by, the
Earths field. The following interactive figure illustrates.
Net effect of all aligned
If an external field H exists,
Magnetic domains
No external field.
fields causes rock sample
Rock sample has zero are oriented randomly. magnetic domains will align to it.
to have a NON-zero
net field.
field, m.

The strength of this so-called "induced" magnetisation is called the "dipole moment per unit volume",
m. It is related to the causative field's strength, H, by
m = KH.
Susceptibility K is a dimensionless number related to the number of individual magnetic dipoles in
the medium that can be aligned with the main field. Note that as the field increases the number of
dipoles that align themselves with the field also increases.
Although unit-less, the value of susceptibility is different in the cgs and SI systems of measurement
because of the way electromagnetic derivations proceed within the two systems. Translation between
cgs and SI systems of units is done via K(SI) = 4 K(cgs) . The SI system is the current preferred
standard amoung most geophysicists, but you will find cgs used in older references and texts. For
more details, see the sub-section on units in the "Geophysical Surveys" chapter, "Magnetics" section.

Is susceptibility linear?
The relation between
ambient magnetic field,
H, and magnetisation, m
(M in the adjacent
figure) is complicated in
general, but is linear for
small H. This is evident
by observing how m
behaves in a cycling H
field. This figure is
adapted from Grant and
West, 1965.

If susceptibility were simple, there would be a straight line with a slope of k (susceptibility).
This is nearly the case for small amplitudes of H. However, there is a hysteresis curve for larger
amplitudes of H. In other words, for large field strengths, k depends on the strength of H, and on
whether H is increasing or decreasing. Furthermore, saturation of m occurs in large magnetic
field strengths.
Evidently induced magnetization does not necessarily depend linearly on H. In fact, k may depend on
the strength of H. Also, susceptibility occasionally can be negative. It can also be anisotropic
(dependant upon direction of measurement), especially in metamorphic rocks which have
pronounced platey crystalline grain structure. Fortunately, most geophysical situations involve
magnetising fields that are small enough that the linear dependance can be assumed, and rocks can be
assumed to have a fixed value of susceptibility, however this is not always true.

Susceptibility of materials
Minerals
Geologically significant magnetic minerals are either in the iron-titanium-oxygen group or in the
iron-sulfur group. In the iron-titanium-oxygen group there are five main minerals, and in the ironsulfur group there are two main minerals. There is apparently much more known about the first
group. Grant and West, 1965, has an excellent summary, with a great deal of information about
magnetism of minerals. The following table gives a simple indication of susceptibilities for specific
magnetic minerals.
Mineral

Chemical formulae

Average susceptibility (SI)

Magnetite

Fe3O4

6000 * 10-3

Ulvospinel

Fe2TiO4.

~0

Ilmenite

FeTiO3

1800 * 10-3

Hematite

Fe2O3

6.5 * 10-3

Maghemite (another form of hematite)

Fe2O3

similar to Magnetite

Pyrite

FeS2

1.5 * 10-3

Pyrrhotite

Fe1-xS (Fe7S8)

1500 * 10-3

Rocks
In rocks, susceptibility is mainly dependent on the volume percent of magnetite. This mineral is
common in igneous and metamorphic rocks, and is present at least in trace amounts in most
sediments. The chart below shows the ranges of magnetic susceptibility and magnetite volume for
common rock types. Note that the susceptibility scale is logarithmic, so there is a huge range of
susceptibilities in geological materials. Some relevant remarks are:
Magnetite is by far the most common geologic magnetic material. The magnetic properties of
most rocks depend on the proportion of magnetite within the rocks. See the approximate
percent of magnetite by volume, highlighted by the red lines.
Igneous rocks tend to be more magnetic than sedimentary rocks, but there is a very wide
range of overlap.
Magnetic minerals include metallic iron, nickel, cobalt, magnetite, pyrrhotite, and ulvospinel.
Magnetite (SG 5) is heavy and often accumulates in sediments and alluvial environments in
the same way that other heavy minerals form placer deposits. So, for example, ancient or
hidden stream paths can sometimes be mapped because magnetite deposition will depend
upon water flow rates.

Maghemite, a magnetic form of hematite, is produced in highly organic soils. Surface soils
can acquire a remanent magnetization that is stronger than the induced magnetization, often as
a result of human interference with fires or other disturbances. Implications are important for
archeology.

Susceptibility of common rock types.


A table summarizing typical susceptibilities of common materials follows:
Adapted from T.M. Boyd of the Colorado School of Mines
The susceptablitlites of various rocks and minerals
Material
Air
Quartz
Rock Salt
Calcite
Sphalerite
Pyrite
Hematite
Illmenite
Magnetite
Limestones
Sandstones
Shales
Schist
Gneiss
Slate
Granite
Gabbro
Basalt
Peridotite

Susceptibility x 10-3 (SI)


about 0
-0.01
-0.01
-0.001 - 0.01
0.4
0.05 - 5
0.5 - 35
300 - 3500
1200 - 19,200
0-3
0 - 20
0.01 - 15
0.3 - 3
0.1 - 25
0 - 35
0 - 50
1 - 90
0.2 - 175
90 - 200

Bulk susceptibility of rocks depends, of course, on what magnetic minerals are present, although
there is no simple relationship. For example anisotropy is often present in metamorphic rocks, with
smaller susceptibility in the direction normal to the textural trends (schistosity or gneissosity) than in
a direction parallel to it. Banded magnetite or pyrrhotite are the most significant examples of rocks
with anisotropic susceptibility. Magnetite is by far the most significant contributor to a rock's
magnetic properties. There are several empirical relations between magnetite content and bulk
susceptibility. Three such relations listed below (Grant and West, 1965) represent bulk susceptibility,
k, as a function of magnetite content by percent volume, V.
1. k = 2.89 x 10-3 V 1.01
2. k = 2.6 x 10-3 V 1.11
3. k = 1.16 x 10-3 V 1.39.
Differences between the three formulae are probably due to the differences in the sample sets and
separation process. Separation tends to overestimate the ferrimagnetic mineral content, while visual
or microscopic examination tends to underestimate it.
Soils
(Summarized from Breiner, 1973) Magnetic susceptibility of soils might be expected to be related to
the magnetite content of parent rocks. However magnetite is more resistant to weathering than other
minerals. It is also denser than average materials and therefore subject to depositional concentration.
In addition, organic action is thought to be responsible for the formation of maghemite from other
non-magnetic forms of iron oxide. For all these reasons, soils have very variable susceptibilities, and
may have higher susceptibilities than suggested by the parent rocks. In any case, soil susceptibility
can significantly impact ground-based surveys, creating noisy results that are often difficult to
explain, or mitigate.
Buried metal
(Summarized from Breiner, 1973) For most iron or steel objects, the susceptibility, k, falls
between 10 and 200 in SI units. However, predicting the response of a magnetometer survey over
metal is complicated for several reasons. Remanent magnetisation is likely to be strong, and pointing
in different directions in the various components of a buried object. For example, a buried pipe will
often show up as a linear set of anomalies with variable character because each segment will have it's
own magnetic signature. It should also be remembered that stainless steel is not magnetic, and that
many potential targets may not even be ferrous (for example, aircraft frame parts are often some alloy
with no magnetic properties).
The maximum induced magnetic field strength (i.e. the maximum anomaly), T, of a 3D object can be
roughly estimated using T = M/r3 (or T = 2M/r3 for latitudes greater than 600), where M is the
magnetic moment estimated from M = k F V (k is susceptibility, F is ambient field strength, and V is
volume). r is the distance to the target. For a 2D object, T = M/r 2 is appropriate.
Organically derived susceptibility
Organic chemistry can be important in understanding magnetic survey results for petroleum
exploration applications. Under certain conditions magnetic anomalies caused by organic chemical
activity can provide indicators of petroleum reservoir in underlying rocks. This is described in a
supplementary article (Stone et al, 2004).

References cited on this page


Rock Physics and Phase Relations: An AGU online reference, by the American Geophysical Union, 1995.
Blakely, R.J. , Potential Theory in Gravity and Magnetic Applications, Cambridge University Press 1995.
Breiner, S, 1973, Applications manual for portable magnetiometers , published by Geometrics.
Emerson, D. W., and The Australian Society Of Exploration Geophysicists, The Geophysics of
the Elura Orebody, Cobar, New South Wales: the Proceedings of the Elura Symposium, Sydney,
1980: a Collection ..., Australian Society of Exploration Geophysicists, 1980, ISBN: 0959413103.
Adams, R.L. and Schmidt, B.L. (1980), "Geology of the Elura Zn-Pb-Ag Deposit" , in
Emerson, D.W., pp1-4.
Blackburn, G. (1980), "Gravity and Magnetic Surveys - Elura Orebody", in Emerson,
D.W., pp17-24.
Emerson, D.W. (1980), "Discussion on exploration, geology, gravity and magneticsElura symposium, Sydney, 1980", in Emerson, D.W., pp188 - 193.
Gidley, P.R. and Stuart, D.C. (1980), "Magnetic property studies and magnetic surveys
of the Elura prospect, Cobar, NSW", in Emerson, D.W., pp25-30.
Grant, F.S. and West, G.F., 1965, Interpretation Theory in Applied Geophysics, McGraw-Hill Book
Co.
Stone, V.C.A., J. Derek Fairhead, W. Heiko Oterdoom, and Petronas Carigali, Micromagnetic
seep detection in the Sudan, The Leading Edge, 2004, Vol.23, #8, p. 734, The Society of Exploration
Geophysicists. (See also the same authors at the Getech website under education or publications.
UBC Earth and Ocean Sciences, F. Jones.

Anda mungkin juga menyukai