Access Door
Encoder Strip
2 Sided Printing
Module
Rear Access
Cleanout
Assemby
Print cartridges OK
Black print cartridge low on ink
Color print cartridge low on ink
Problem with black print cartridge
Problem with color print cartridge
Print Cartridge Light
Resume Light
Power Light
Output Tray
Input Tray
Power Button
Resume Button
Cancel Button
Length Adjuster
Width Adjuster
Check the print cartridge nozzles for ink and debris. Clean the nozzles using a lint
Free swab moistened with distilled water.
Connect the printer to a host PC and execute the cleaning routine found in the
Printer Services" tab in the "HP DeskJet Series Toolbox"
Remove power from the printer for 15 seconds and restore power. Ensure the
Power cord is firmly plugged into the printer and an active power source.
Turn the printer off and on twice.
Connect the printer to a host PC and execute the cleaning routine found in the
Printer Services" tab in the "HP DeskJet Series Toolbox".
Open the access door and verify the carriage moves and points to the
If the carriages points at the
If the carriage points at the
or
or
icon.
Ensure that the correct print cartridges are installed in the printer.
Check that the proper media (paper) is loaded and press the Resume (center)
Button to tell the printer to pick paper again. Try using a larger stack of paper.
This error can be caused by a paper jam, wrong printer driver, or bad computer to
printer connection. Ensure the carriage movement is not blocked.
This error can be caused by a defective computer, wrong printer driver, or bad
interface cable.
Make sure the access door or 2-sided printing module (duplexer) is fully closed
Ensure the input tray is not overloaded. Load a few sheets to the input tray to
test the paper path. Ensure the input tray is fully forward (inserted). Pull the input
tray out and push it back in. Note that the last few inches of the tray should be
automatically pulled in by the printer if there are no obstructions. Ensure the length
adjuster is all the way forward and touching the paper. Ensure the paper is under
the tab on the length adjuster.
Paper partially ejected and the Remove the rear access cleanout or the 2 sided printing module and pull out any
lights are flashing.
damaged (curled/wrinkled) paper from between the rollers. Ensure paper is
properly loaded in the input tray and press the Resume (center) button.
Does not eject paper fully or
Press the Resume (center) button to eject the paper and re- initiate a paper pick.
delays ejecting the paper.
Turn the printer and computer on in proper sequence as prescribed by the
computer manual.
Feeds multiple sheets.
Ensure the paper is not stuck together and meets the user manual specifications.
Fan the paper to free any attached sheets. Ensure the input tray is not
overloaded and contains the same type, size and weight of media.
Envelopes will not feed.
Ensure only one envelope is inserted into the single feed slot on the output tray.
Ensure envelopes have no bends or curls. Ensure envelopes are not overloaded.
Paper feed problems with
Open the 2-sided printing module door and verify there are no obstructions in the
2-sided printing module.
paper path or excessive ink on the rollers. Remove and firmly re-install the
2-sided printing module, making sure that it is fully seated in the printer.
Rev 0209