Anda di halaman 1dari 193

A Course Material on

Electronic Circuits I

By
Mr. J.SHANMUGASUNDARAM
ASSISTANT PROFESSOR

DEPARTMENT OF ELECTRONICS AND COMMUNICATION ENGINEERING


SASURIE COLLEGE OF ENGINEERING
VIJAYAMANGALAM 638 056

QUALITY CERTIFICATE

This is to certify that the e-course material


Subject Code : EC6304
Subject

: Electronic Circuits I

Class

: II Year ECE

Being prepared by me and it meets the knowledge requirement of the university curriculum.

Signature of the Author


Name : Mr. J. SHANMUGA SUNDARAM
Designation: Assistant Professor

This is to certify that the course material being prepared by Mr. J. SHANMUGA SUNDARAM is of
adequate quality. He has referred more than five books among them minimum one is from abroad author.

Signature of HD
Name: Dr. K.PANDIARAJAN
SEAL

EC6304- ELECTRONIC CIRCUITS I


OBJECTIVES:
The student should be made to
Learn about biasing of BJTs and MOSFETs
Design and construct amplifiers
Construct amplifiers with active loads
Study high frequency response of all amplifiers
UNIT I - BIASING OF DISCRETE BJT AND MOSFET
DC Load line, operating point, Various biasing methods for BJT-Design-Stability-Bias
compensation, Thermal stability, Design of biasing for JFET, Design of biasing for MOSFET
UNIT II - BJT AMPLIFIERS
Small signal Analysis of Common Emitter-AC Loadline, Voltage swing limitations, Common
collector and common base amplifiers Differential amplifiers- CMRR- Darlington AmplifierBootstrap technique - Cascaded stages - Cascode Amplifier,
UNIT III - JFET AND MOSFET AMPLIFIERS
Small signal analysis of JFT amplifiers- Small signal Analysis of MOSFET and JFET, Common
source amplifier, Voltage swing limitations, Small signal analysis of MOSFET and JFET Source
follower and Common Gate amplifiers, - BiMOS Cascode amplifier
UNIT IV - FREQUENCY ANALYSIS OF BJT AND MOSFET AMPLIFIERS
Low frequency and Miller effect, High frequency analysis of CE and MOSFET CS amplifier,
Short circuit current gain, cut off frequency f and f unity gain and Determination of
bandwidth of single stage and multistage amplifiers
UNIT V - IC MOSFET AMPLIFIERS
IC Amplifiers- IC biasing Current steering circuit using MOSFET- MOSFET current sourcesPMOS and NMOS current sources. Amplifier with active loads - enhancement load, Depletion
load and PMOS and NMOS current sources load- CMOS common source and source followerCMOS differential amplifier- CMRR.
TOTAL (L: 45+T: 15): 60 PERIODS
OUTCOMES:
Upon Completion of the course, the students will be able to:
Design circuits with transistor biasing.
Design simple amplifier circuits.
Analyze the small signal equivalent circuits of transistors.
Design and analyze large signal amplifiers.

TEXT BOOK:
1. Donald .A. Neamen, Electronic Circuit Analysis and Design 2nd Edition,Tata Mc Graw
Hill, 2009.
REFERENCES:
1. Adel .S. Sedra, Kenneth C. Smith, Micro Electronic Circuits, 6th Edition, Oxford University
Press, 2010.
2. David A., Bell Electronic Devices and Circuits, Oxford Higher Education Press, 5th Editon,
2010
3. Behzad Razavi, Design of Analog CMOS Integrated Circuits, Tata Mc Graw Hill, 2007.
4. Paul Gray, Hurst, Lewis, Meyer Analysis and Design of Analog Integrated Circuits,
4thEdition ,John Willey & Sons 2005
5. Millman.J. and Halkias C.C, Integrated Electronics, Mc Graw Hill, 2001. 6. D.Schilling and
C.Belove, Electronic Circuits, 3rd Edition, Mc Graw Hill, 1989.

Sl.No
UNIT 1
1.1
1.2
1.3
1.4
1.5
1.6
1.7
1.8
1.9
1.10
1.11
1.12
1.12.1
1.12.2
1.13
1.14
UNIT 2
2.1
2.2
2.3
2.4
2.5
2.6
2.7
2.8
2.9
2.9.1
2.9.2
2.10
2.11
2.12
2.13
2.14
2.14.1
2.14.2

Contents
Biasing of Discrete BJT and MOSFET
Introduction
Need for Biasing
Load line and Variation of quiescent
point
Biasing Methods
Fixed Bias (Base Resistor Bias)
Requirements of a biasing circuit
Method of stabilizing the Q point
Stability Factors
Collector to Base Bias circuit
Modified collector to base bias circuit
Voltage divider bias circuit
Compensation technique
Diode Compensation Techniques
Thermistor Compensation
FET Biasing
Biasing of MOSFET
BJT Amplifiers
Introduction
Common Emitter Amplifier
Common Collector Amplifier
Common Base Amplifier
Small Signal Low Frequency
H-parameter Model
h-Parameters for all three configurations
Midband analysis of BJT Single
Stage Amplifiers
Introduction of Differential
Amplifier
Transistorised Differential Amplifier
Differential Mode Operation
Common Mode Operation
Configurations of Differential
Amplifier
D.C. Analysis of Differential Amplifier
A.C. Analysis of Differential
Amplifier using h-Parameters
Common Mode rejection Ratio (CMRR)
Techniques of Improving Input Impedance
Darlington Transistors
Bootstrap Emitter Follower

Page No

01
02
02
09
10
14
15
15
17
18
20
25
25
28
30
37
52
53
54
54
55
56
59
69
71
73
74
74
75
77
81
82
82
87

UNIT 3
3.1
3.2
3.3
3.4
3.5
3.6
3.7
3.8
3.9
3.10
3.11
3.12

JFET and MOSFET Amplifiers


JFET Amplifiers
JFET low frequency a.c Equivalent
Circuit
Common Source Amplifier with Fixed Bias
Common Source Amplifier with Self Bias
(Bypassed Rs)
Common Source Amplifier with Self Bias
(Un bypassed Rs)
Common source amplifier with Voltage
divider bias (bypassed Rs)
Common source amplifier with Voltage
divider bias (unbypassed Rs)
Common Drain Amplifier
Common Gate Amplifier
Multistage Amplifiers
Small signal Analysis of MOSFET
Cascaded Amplifiers

UNIT 4 Frequency Analyses of BJT and MOSFET Amplifiers


4.1
General shape of frequency response
of Amplifiers
4.2
Definition of cut-off frequencies and
Bandwidth
4.3
Low frequency analysis of amplifier to
obtain lower cut-off frequency
4.4
Effect of various capacitors on
frequency response
4.5
Miller Theorem
4.6
Low frequency analysis of BJT
4.7
Low frequency analysis of FET
amplifier
4.8
Hybrid - equivalent circuits of BJTs
4.9
High frequency analysis of FET
4.10
Frequency Response of Multistage
Amplifiers
4.11
Rise time and its Relation to Upper
Cut-off Frequency
4.12
Relation between Bandwidth and Rise time
UNIT 5
5.1
5.2
5.3
5.4

IC MOSFET Amplifiers
Integrated Circuit Amplifier
IC Design
Biasing - Basic MOSFET current
source
MOS current-steering circuits

101
101
101
102
104
105
107
107
110
113
115
119
122
122
123
126
126
127
131
133
147
154
156
158
162
162
162
163

5.5
5.6
5.7

NMOS Current Sources and Sinks


PMOS Current Source
MOSFET Differential amplifier

165
166
166

EC6304

Electronic Circuits I

UNIT I BIASING OF DISCRETE BJT AND MOSFET


1.1 Introduction
BJT consists of 2 PN junctions. It has three terminals: emitter, base and collector.
Transistorcan be operated in three regions, namely cut-off, active and saturation by applying
proper biasing conditions.

Region of Operation Emitter Base Junction


Collector Base Junction
Cut-off
Reverse biased
Reverse biased
Active
Forward biased
Reverse biased
Saturation
Forward biased
Forward biased
Active:
Most important mode, e.g. for amplifier operation and switching application
The region where current curves are practically flat.
Saturation:
Barrier potential of the junctions cancels each other out causing a virtual short.
Ideal transistor behaves like a closed switch.
Cutoff:
Current reduced to zero
Ideal transistor behaves like an open switch.
In order to operate transistor in the desired region we have to apply external d.c.
voltages of correct polarity and magnitude to the two junctions of the transistor. This is nothing
but the biasing of the transistor.
When we bias a transistor we establish a certain current and voltage conditions for the
transistor. These conditions are known as operating conditions or d.c. operating point or
quiescent point. The operating point must be stable for proper operation of the transistor.
However, the operating point shifts with changes in transistor parameters such as , Ico and
VBE. As transistor parameters are temperature dependent, the operating point also varies with
changes in temperature.

SCE

Dept of ECE

EC6304

Electronic Circuits I

1.2 Need for biasing

Fig.1.1 (a)
Bias establishes the DC operating point for proper linear operation of an amplifier. If an
amplifier is not biased with correct DC voltages on the input and output, it can go into
saturation or cutoff when an input signal is applied. Figure 1.1 shows the effects of proper and
improper DC biasing of an inverting amplifier. In part (a), the output signal is an amplified
replica of the input signal except that it is inverted, which means that it is 1800 out of phase
with the input. The output signal swings equally above and below the dc bias level of the
output, VDC(out).

Fig.1.1 (b), (c)


Improper biasing can cause distortion in the output signal, as illustrated in parts (b) and
(c). Part (b) illustrates limiting of the positive portion of the output voltage as a result of a Qpoint (dc operating point) being too close to cutoff.
Part (c) shows limiting of the negative portion of the output voltage as a result of a de
operating point being too close to saturation.
1.3 Load line and Variation of quiescent point
Biasing is the application of dc voltages to establish a fixed level of current and voltage.
For transistor amplifiers the resulting dc current and voltage establish an operating point on the
characteristics that define the region that will be employed for amplification of the applied
signal. Since the operating point is a fixed point on the characteristics, it is also called the
quiescent point (abbreviated Q-point). The operating point of a device, also known as bias

SCE

Dept of ECE

EC6304

Electronic Circuits I

point, quiescent point, or Q-point, is the point on the output characteristics that shows the DC
collectoremitter voltage (Vce) and the collector current (Ic) with no input signal applied.
Consider the fixed bias circuit,

Fig 1.2
We have,

We can draw a straight line on the graph of IC versus VCE which is having slope -1/Rc.To
determine the two points on the line we assume VCE = VCC and VCE =0
a) When VCE =VCC ; IC =0
and we get a point A
b) When VCE=0
; IC=VCC/RC and we get a point B
The figure below shows the output characteristic curves for the transistor in CE mode. The DC
load line is drawn on the output characteristic curves. Load line - To draw load line, we have
to find saturation current and the cutoff voltage.
Saturation point - The point at which the load line intersects the characteristic curve near the
collector current axis is referred to as the saturation point. At this point of time, the current
through the transistor is maximum and the voltage across collector is minimum for a given
value of load. So, saturation current for the fixed bias circuit, Ic (sat) =Vcc/Rc .
Cutoff point -The point where the load line intersects the cutoff region of the collector curves
is referred as the cutoff point (i.e. end of load line). At this point, collector current is
approximately zero and emitter is grounded for fixed bias circuit. so, Vce (cut) = Vc = Vcc
Operating point - The "Q point" for a transistor amplifier circuit is the point along its
operating region in a "quiescent ", where no input signal gets amplified.
The figure below shows the output characteristic curves for the transistor in CE mode with
points A and B, and line drawn between them. The line drawn between points A and B is
called d.c load line. The d.c word indicates that only d.c conditions are considered, i.e input
signal is assumed to be zero.

SCE

Dept of ECE

EC6304

Electronic Circuits I

Fig 1.3
The d.c load line is a plot of IC versus VCE. For a given value of Rc and a given value of
Vcc. So, it represents all collector current levels and corresponding collector emitter voltages
that can exist in the circuit. Knowing any one of Ic, IB, or VCE , it is easy to determine the other
two from the load line. The slope of the d.c load line depends on the value of RC. It is the
negative and equal to reciprocal of the RC.
Applying KVL to the base circuit, we get

The intersection of curves of different values IB of with d.c load line gives different operating
points. For different values of IB, we have different intersection points such as P, Q and R.
Selection of operating point
The operating point can be selected at different positions on the d.c load line, near
saturation region, near cut-off region or at the centre, i.e in the active region. The selection of
operating point will depend on its application. When transistor is used as an amplifier, the Q
point should be selected at the center of the d.c. load line to prevent any possible distortion in
the amplified output signal.
Case 1
Biasing circuit is designed to fix a Q point at point P which is very near to the
saturation region. It results collector current is clipped at the positive half cycle. i.e. distortion
is present at the output. Therefore, point P is not a suitable operating point.

SCE

Dept of ECE

EC6304

Electronic Circuits I

Fig 1.4
Case 2
Biasing circuit is designed to fix a Q point at point R as shown in Fig. Point R is very
near to the cut-off region. Here, the collector current is clipped at the negative half cycle. So,
point R is also not a suitable operating point.

.
Fig 1.5
Case 3
Biasing circuit is designed to fix a Q point at point Q as shown in Fig.. The output signal is
sinusoidal waveform without any distortion. Thus point Q is the best operating point.

SCE

Dept of ECE

EC6304

Electronic Circuits I

Fig 1.6
DC Load Line (Example)

Fig 1.7
The figure 1.7 shows the biasing of transistor in common emitter configuration.
In Figure 1.8, we assign three values to IB and observe what happens to IC and VCE.
First, VBB is adjusted to produce an IB of 200 A, as shown in Figure 1.8(a), Since IC = DC IB,
the collector current is 20 mA, as indicated, and
VCE = VCC - IcRc = 10 V - (20 mA) (220 ) = 10 V - 4.4 V = 5.6 V
This Q-point is shown on the graph of Figure 1.3(b) as Q1.
Next, as shown in Figure 1.8(b), VBB is increased to produce an IB of 300 A and an Ic of
30mA.
VCE = 10 V - (30 mA) (220 ) = 10V 6.6 V = 3.4 V
The Q-point for this condition is indicated by Q2 on the graph.
Finally. as in Figure 1.8 (c), VBB is increased to give an IB of 400 A and an Ic of 40 mA.
VCE = 10 V - (40 mA) (220 ) = 10 V - 8.8 V = 1.2 V
Q3 is the corresponding Q-point on the graph.

SCE

Dept of ECE

EC6304

Electronic Circuits I

Figure 1.8
increases,
Ic
increases
and VCE decreases. When IB decreases, Ic
Notice that when IB
decreases and VCE increases. As VBB is adjusted up or down, the dc operating point of the
transistor moves along a sloping straight line, called the DC load line, connecting each
separate Q-point.

Figure 1.9
SCE

Dept of ECE

EC6304

Electronic Circuits I

At any point along the line, values of IB, Ic, and VCE can be picked off the graph, as shown in
Figure1.9.
The dc load line intersects the VCE axis at 10 V. The point where VCE = VCC. This is the
transistor cutoff point because IB and IC are zero (ideally). Actually, there is a small leakage
current, ICBO , at cutoff as indicated, and therefore VCE is slightly less than 10 V but normally
this can be neglected.
The dc load line intersects the IC axis at 45.5 mA ideally. This is the transistor saturation point
because IC is maximum at the point where VCE = 0 V and IC = VCC / RC.
Actually, there is a small voltage (VCE (sat)) across the transistor, and IC(sat) is slightly
less than 45.5 mA, as indicated in Figure 1.4. Note that Kirchhoff's voltage law applied around
the collector loop gives,
VCC - ICRC - VCE = 0.
These results in a straight line equation for the load line of the form y = mx + b as follow:
IC = - (1/RC) VCE +VCC / RC
Where, - (1/RC) is the slope and VCC / RC is the y-axis intercept point.
Variation of quiescent point due to hFE variation within manufacturers tolerance
It is clear that the biasing circuit should be designed to fix the operating point or Q
point at the center of the active region. But only fixing of the operating point is not sufficient.
While designing the biasing circuit, care should be taken so that the operating point will not
shift into an undesirable region (i.e. into cut-off or saturation region). Designing the biasing
circuit to stabilize the Q point is known as bias stability.
Two important factors are to be considered while designing the biasing circuits which
are responsible for, shifting the operating point.
I. Temperature
1) Ico: The flow of current in the circuit produces heat at the junctions. This heat
increases the temperature at the junctions". We know that the minority carriers are temperature
dependent. They increase with the temperature. The increase in the minority carriers increases
the leakage current ICE0,
Specifically, ICB0 doubles for every 10C rise in temperature. Increase in ICE0 in turn increases
the collector current
The increase in IC further raises the temperature at the collector junction and the same cycle
repeats. This excessive increase in IC shifts the operating point into the saturation region,
changing the operating condition set by biasing circuit.
As the power dissipated within a transistor is predominantly the Power dissipated at its
collector base junction, the power dissipation is given as
The increase in the collector current increases the power dissipated at the collector junction.
This, in turn further increases the temperature of the junction and hence increases
SCE

Dept of ECE

EC6304

Electronic Circuits I

the collector current. The process is cumulative. The excess heat produced at the collector
base junction may even burn and destroy the transistor. This situation is called 'Thermal
runaway of the transistor. For any transistor, maximum Power dissipation is always a fixed
value. That is known as maximum power dissipation rating of a transistor. This value is
specified by the manufacturer in data sheet. If this limit is crossed, the device will fail.
2) VBE : Base to emitter voltage VBE changes with temperature at the rate of 2.5mV/C
Base current, IB depends upon VBE .As base current IB depends on VBE, and Ic depends on IB, Ic
depends on VBE. Therefore collector current Ic. Change with temperature due to change in VBE.
The change in collector current change the operating point.
3)dc: dc of the transistor is also temperature dependent. As dc varies, Ic also
varies, since Ic = IB. The change in collector current change the operating point.
Therefore, to avoid thermal instability, the biasing circuit should be designed to provide a
degree of temperature stability i.e. even though there are temperature changes, the changes in
the transistor parameters (VCE , ICQ , PDmax )should be very less so that the operating point
shifting is minimum in the middle of the active region.
II) Transistor current gain hFE/
Eventhough there is tremendous advancement in semiconductor technology, there are
changes in the transistor parameters among different units of the same type, same number. This
means if we take two transistor units of same fire (i.e. same number, construction, parameter
specified etc.) and use them in the circuit, there is change in the value in actual practice. The
biasing circuit is designed according to the required value. But due to change in from unit
to unit, the operating point may shift
Figure shows the common emitter output characteristics for two transistors of the same type.
The dashed characteristics are for a transistor whose p is much larger than that of the transistor
represented by the solid curves.
So for stabilizing the operating point the factors discussed so far should be considered while
designing the biasing circuit.

Figure: Common emitter output characteristics


1.4 BIASING METHODS
The common biasing circuits used in the bipolar transistor amplifiers are
1. Fixed bias
2. Collector-to-base bias
3. Fixed bias with emitter resistor

SCE

Dept of ECE

EC6304

Electronic Circuits I
4. Voltage divider bias
5. Emitter bias

1.5 Fixed Bias (Base Resistor Bias)

The Figure shows the fixed bias circuit. It is the simplest d.c. bias configuration. For the d.c.
analysis we can replace capacitor with an open circuit because the reactance of a capacitor for
d.c. is
In the base circuit,
Apply KVL, we get
Therefore,

VCC = IBRB + VBE

IB = (VCC - VBE)/RB
For a given transistor, VBE does not vary significantly during use. As VCC is of fixed value, on
selection of RB, the base current IB is fixed. Therefore this type is called fixed bias type of
circuit.
In the Collector circuit
Apply KVL, we get
VCC = ICRC + VCE
Therefore,
VCE = VCC - ICRC
The common-emitter current gain of a transistor is an important parameter in circuit design,
and is specified on the data sheet for a particular transistor. It is denoted as .
IC = IB

In this circuit VE =0

SCE

10

Dept of ECE

EC6304

Electronic Circuits I

Stability factor S for Fixed bias circuit

Merits:
It is simple to shift the operating point anywhere in the active region by merely
changing the base resistor (RB).
A very small number of components are required.
Demerits:
The collector current does not remain constant with variation in temperature or power
supply voltage. Therefore the operating point is unstable.
Changes in Vbe will change IB and thus cause RE to change. This in turn will alter the
gain of the stage.
When the transistor is replaced with another one, considerable change in the value of
can be expected. Due to this change the operating point will shift.
For small-signal transistors (e.g., not power transistors) with relatively high values of
(i.e., between 100 and 200), this configuration will be prone to thermal runaway. In
particular, the stability factor, which is a measure of the change in collector current
with changes in reverse saturation current, is approximately +1. To ensure absolute
stability of the amplifier, a stability factor of less than 25 is preferred, and so smallsignal transistors have large stability factors.
Usage:
Due to the above inherent drawbacks, fixed bias is rarely used in linear circuits (i.e., those
circuits which use the transistor as a current source). Instead, it is often used in circuits where
transistor is used as a switch. However, one application of fixed bias is to achieve crude
automatic gain control in the transistor by feeding the base resistor from a DC signal derived
from the AC output of a later stage.
Problems
1. Design the fixed bias circuit from the load line given in the figure.

SCE

11

Dept of ECE

EC6304

Electronic Circuits I

2. For the circuit shown in figure. Calculate IB,IC,VCE,VB,VC and VBC. Assume VBE= 0.7V
and =50.

3. Design a fixed biased circuit using a silicon transistor having value of 100. Vcc is 10 V
SCE

12

Dept of ECE

EC6304

Electronic Circuits I

and dc bias conditions are to be VCE = 5 V and IC = 5 mA,

Solution
Applying KVL to collector circuit,

Applying KVL to base circuit,

4. Calculate the operating point (Q-point)

Base biased CE connection

IC = dc * IB = 100 * 29A = 2.9 mA


VCE = VCC - (IC * RC) = 15V - (2.9 mA * 3K) = 6.3V
By plotting IC (2.9 mA) and VCE (6.3V), we get the operation point ----> Q-point (quiescent
point).

SCE

13

Dept of ECE

EC6304

Electronic Circuits I

Collector curve with load line and Q point


5. Draw the load line and Q-point.

base biased CE connection, =50


Solution:

IC = IB * = 2.15 mA
VCE = VCC - (RC * IC)= 5.7V

VCE (cut) = VCC = 3.0V

1.6 Requirements of a biasing circuit


1. Emitter base junction must be forward biased and collector base junction
must be reverse biased. That means the transistor should be operated in the
middle of the active region or Q point should be fixed at the centre of the
active region.
2. Circuit design should provide a degree of temperature stability.
3. Q point should be made independent of the transistor parameters such as .

SCE

14

Dept of ECE

EC6304

Electronic Circuits I

To maintain the Q point stable by keeping IC and VCE constant so that the transistor will always
work in active region, the following techniques are normally used,
1. Stabilization technique
2. Compensation technique
1.7 Method of stabilizing the Q point
Stabilization technique:
It refers to the use of resistive biasing circuits which allow IB to vary so as to keep IC
relatively constant with variations in ICO, and VBE.
Compensation technique:
It refers to the use of temperature sensitive devices such as diodes, transistors,
thermistors which provide compensating voltage and current to maintain Q point stable.
1.8 Stability Factors
It is defined as the degree of change in operating point due to variation in temperature.
There are three variables which are temperature dependent. Three stability factors are defined
as follows,

Stability factor S:

SCE

15

Dept of ECE

EC6304

Electronic Circuits I

The above equation can be considered as a standard equation for the derivation of
stability factors of other biasing circuits.
Stability factor S:

Stability factor S:

Relation between S and S:


We know that S = 1+ and S = IC/
Multiplying numerator and denominator by (1+),
S = IC(1+)
______
(1+)
S = IC S
______
(1+)

SCE

16

Dept of ECE

EC6304

Electronic Circuits I

1.9 Collector to Base Bias

Figure shows the dc bias with voltage feedback. It is also called as collector to base bias
circuit. It is an improvement over fixed bias method. In this, biasing resistor is connected
between collector and base of the transistor to provide feedback path.
Circuit analysis:
Base circuit:
Consider the base circuit and applying voltage law then we get,

Only the difference between the equation for IB and that obtained for fixed bias
configuration is RC, so the feedback path results in a reflection of the resistance RC to the
input circuit.
Collector circuit:
Applying KVL to the collector circuit,
VCC (IC + IB) RC VCE = 0
VCE = VCC (IC + IB) RC
If there is a change in due to piece to piece variation between transistors or if there is
a change in and ICO due to the change in temperature. So collector current tends to increase.
As a result, voltage drop across RC increases. Due to reduction in VCE, IB reduces. The result is
that the circuit tends to maintain a stable value of collector current, keeping the Q point fixed.
In this circuit, RB appears directly across input and output. A part of output is feedback
to the input. And increase in collector current decreases the base current. So negative feedback
exists in the circuit. It is also called as voltage feedback bias circuit.

SCE

17

Dept of ECE

EC6304

Electronic Circuits I

1.10 Modified collector to base bias circuit:

To improve the level of stability, emitter resistance is connected in this circuit.


Base circuit:
Applying KVL to base circuit,
VCC (IC + IB) RC IBRB VBE IERE = 0
VCC VBE
IB =
__________________
RB + (1+) (RC + RE)
IB =

VCC VBE
__________________
RB + (RC + RE)
Only difference between the equation for IB and that obtained for the fixed bias
configuration is the term (RC + RE).So feedback path results in a reflection of the resistance
RC back to the input circuit.
In general,
V
IB =
________
RB + R
Where V = VCC - VBE
R = 0 for fixed bias
R = RE for emitter bias
R = RC for collector to base bias
R = RC + RE for collector to base bias with RE
Collector circuit:
Applying KVL to collector circuit,
VCC (IC+IB) RC VCE IERE = 0
VCE = VCC IE (RC+RE)
Stability factor S for collector to base bias circuit:
VCC = IC RC IB(RB+RC) + VBE
When ICBO, IB and IC changes with no effect on VCC and VBE, the equation becomes,

SCE

18

Dept of ECE

EC6304

Electronic Circuits I

S=

1+
______________
1+ (RC/ (RC+RB))
Collector to base bias circuit is having lesser stability factor than for fixed bias circuit.
So this circuit provides better stability than fixed bias circuit.
Problem 1:
Locate the operating point of the given circuit with VCC = 15V, hfe = 200.

Solution:
IBQ = VCC - VBE
___________
RB+ (1+) (RC+RE)
= 15-0.7
________________________
630*103 + (1+200) (4.7*103+680)
ICQ = IBQ = 200*8.356*10-6
= 1.6712mA
IEQ = ICQ + IBQ = 1.6712*10-3 + 8.356*10-6
= 1.68mA
VCEQ = VCC IE (RC+RE)
= 15-1.68*10-3 (4.7*103 + 680)
= 5.96V

SCE

19

Dept of ECE

EC6304

Electronic Circuits I

1.11 Voltage divider bias circuit:

Figure shows the voltage divider bias circuit. In this, biasing is provided by three
resistors R1, R2 and RE. The resistors R1 & R2 act as a potential divider giving a fixed voltage to
base. If collector current increases due to change in temperature or change in , emitter current
IE also increases and voltage drop across RE increases thus reducing the voltage difference
between base and emitter. Due to reduction in base emitter voltage, base current and collector
current reduces. So we can say that negative feedback exists in emitter bias circuit. This
reduction in collector current compensates for the original change in IC.
Circuit analysis:
Base circuit:

Fig. Base circuit


Let us consider the base circuit as shown in above figure. Voltage across R2 is base
voltage VB. Applying voltage divider rule to find VB,

SCE

20

Dept of ECE

EC6304

Electronic Circuits I

VB =

R2 (I)
______________ * VCC
R1 (I+IB) +R2 (I)
=
R2
with I>>IB
_______________ * VCC
R1+R2
Collector circuit:

Fig. Divider biased


Let us consider the collector circuit as shown in above figure. Voltage across RE can be
obtained as,
VE = IERE = VB - VBE
IE = VB-VBE
______
RE
Apply KVL to collector circuit,
VCE = VCC ICRC - IERE
Simplified circuit of voltage divider bias:

Fig. Thevenins equivalent circuit for voltage divider bias


From above figure, R1 and R2 are replaced by RB and VT.
Where RB is the parallel combination of R=1 and R2
VT is the thevenins voltage

Apply KVL,

SCE

21

Dept of ECE

EC6304

Electronic Circuits I

Problem 1:
For the given circuit =100 for silicon transistor. Calculate VCE and IC.

Solution:

Problem 2:
For the given figure find Q point with VCC = 15V, VBE = 0.7V and = 100.

SCE

22

Dept of ECE

EC6304

Electronic Circuits I

Solution:

Stability factor for voltage divider bias:


Stability factor S:

Fig. Thevenins equivalent circuit for voltage divider bias


For determining stability factor S for voltage divider bias, consider the equivalent circuit.
Thevenins voltage is given by,

R1, R2 are replaced by RB which is the parallel combination of R1 and R2.

Apply KVL to base circuit,


Differentiating with respect to IC and considering VBE to be independent of IC,

SCE

23

Dept of ECE

EC6304

Electronic Circuits I

Stability factor S is given by,

From above equation, the following points are observed.


1. The ratio RB/RE controls value of stability factor S. If RB/RE << 1 then it is reduced to S =
(1+). 1/ (1+) = 1
Practically RB/RE not equal to zero. But to have better stability factor S , we have to keep ratio
RB/RE as small as possible.
2. To keep RB/RE small, it is necessary to keep RB small. Due to small value of R1 and R2,
potential divider circuit will draw more current from VCC reducing the life of the battery.
Another important aspect is that reducing RB will reduce input impedance of the circuit, since
RB comes in parallel with the input. This reduction of input impedance in amplifier circuit is
not desirable and hence RB cannot be made very small.
3. Emitter resistance RE is another parameter, it is used to decrease the ratio RB/RE. Drop
across RC will reduce. This shifts the operating point Q which is not desirable and hence there
is limit for increasing RE.
While designing voltage divider bias circuit, the following conditions are to be satisfied,
S
Small
RB
- Reasonably small
RE
- Not very large
4. If ratio RB/RE is fixed, S increases with . So stability decreases with increasing
.
5. Stability factor S is essentially independent of for small value of S.
Substituting the differentiation value of IB/IC,

Dividing each term by RE,

Problem 1:
For the given circuit, VCC = 20V, RC = 2K, = 50, VBE = 0.2V, R1 = 100K, RE = 100.
Calculate IB, VCE, IC and stability factor S.

SCE

24

Dept of ECE

EC6304

Electronic Circuits I

Solution:
R2 is not given. So assume R2 = 10K

RB = R1*R2
______ = 9.09K
R1+R2
IB =
VT-VBE
_____________ = 114A
RB+ (1+)RE
IC = IB = 5.7Ma
VCE = VCC ICRC (1+)IBRE
= 8V
S = 1+
__________________
1+ (RE / (RE+RB))
S = 33
1.12 Compensation technique:
It refers to the use of temperature sensitive devices such as diodes, transistors, thermistors
which provide compensating voltage and current to maintain Q point stable.

1.12.1 Diode Compensation Techniques


Compensation for VBE:
a) Diode in Emitter Circuit
Diagram shows the voltage divider bias with bias compensation technique.Here, separate
supply VDD is used to keep diode in forward If biased condition. If the diode used in the circuit
is of same material and type as the transistor, the voltage across the diode will have the same
temperature coefficient as the base to emitter voltage VBE . So when VBE changes by
with change in temperature, VD changes by

VBE

VD and

, the changes tend to cancel each other.


Apply*g KVL to the base circuit of Fig. ,we have
SCE

25

Dept of ECE

EC6304

Electronic Circuits I

Figure: Stabilization by means of voltage divider bias and diode Compensation Technique

As VD tracks VBE with respect to temperature it is clear that IC will be insensitive to variations
in VBE.

SCE

26

Dept of ECE

EC6304

Electronic Circuits I

Diode in voltage divider circuit

Diode is connected in series with resistance R2 in the voltage divider circuit and
it is forward biased condition.
For voltage divider bias,

When VBE changes with temperature, IC also changes


To cancel the changes in IC , one diode is used in the circuit for compensation
The voltage at the base VB is give as
Substituting this value in equation IC, we get,

The changes cancel each other , so the collector current is given as

The changes in VBE. Due to temperature are compensated by changes in the


diode voltage which keeps IC stable at Q point.
Compensation for ICO
* In germanium transistor changes in ICO with temperature plays an important
role collector current stability
* The diode is kept at reverse bias condition ,so only leakage current flows
* Io increases then ICO also increases

SCE

27

Dept of ECE

EC6304

Electronic Circuits I

As I is constant , IC also remains constant. We can say that changes by ICO with
temperature are compensated by diode and collector current remains constant
1.12.2 Thermistor Compensation

SCE

28

Dept of ECE

EC6304

Electronic Circuits I

With increase of temperature ,RT decreases. Hence the voltage drop across it
also decreases. That is VBE decreases which reduces IB . this will offset the
increased collector current with temperature.
The equation shows if there is increase in ICO and decrease in IB
almost constant.

keeps IC

Fig (b)
shows another thermistor
compensation technique . Here, thermistor is connected between emitter and
Vcc to minimize the increase in collector current due to changes in ICO, VBE,
or beta with temperature .IC increases with temperature and RT decreases with
increase in temperature. Therefore, current flowing through RE increases, which
increases the voltage drop across it. E - B junction is forward biased. But due to
increase in voltage drop across RE, emitter is made more positive, which
reduces the forward bias voltage VBE. Hence, bias current reduces.

As Ico increases with temperature, IB decreases and hence. IC remains constant


Sensistor Compensation technique

SCE

29

Dept of ECE

EC6304

Electronic Circuits I

This method of transistor compensation uses temperature sensitive resistive


element, sensistors rather than diodes or transistors. It has a positive temperature
coefficient, its resistance increases exponentially with increasing temperature as
shown in the Fig
Slope of this curve =
is the temperature coefficient for thermistor and the slope is positive So we
can say that sensistor has positive temperature coefficient of resistance (PTC).
Fig. shows sensistor compensation R1 is replaced by sensistor RT in self bias circuit. Now, RT
and R2 resistors of the potential divider. As temperature increases, RT increases which
decreases the current flowing through it. Hence current through R2 decreases which reduces
the voltages drop across it. Voltage drop across R2 is the voltage between base and ground. So
VBE reduces which decreases 16. It means, when ICBO increases with increase in temperature, IB
reduces due to reduction in VBE, maintaining IC fairly constant.
1.13 FET Biasing

The Parameters of FET is temperature dependent .When temperature increases


drain resistance also increases, thus reducing the drain current.

Unlike BJTs, thermal runaway does not occur with FETs

However, the wide differences in maximum and minimum transfer


characteristics make ID levels unpredictable with simple fixed-gate bias voltage.

Different biasing circuits of FET are


1)
Fixed bias circuits
2)
Self bias circuits
3)
Voltage bias circuits
Fixed bias circuits
DC bias of a FET device needs setting of gate-source voltage VGS to give desired drain
current ID . For a JFET drain current is limited by the saturation current IDS. Since the FET
has such a high input impedance that no gate current flows and the dc voltage of the gate
set by a voltage divider or a fixed battery voltage is not affected or loaded by the FET.

Fixed dc bias is obtained using a battery VQG. This battery ensures that the gate
is always negative with respect to source and no current flows through resistor

SCE

30

Dept of ECE

EC6304

Electronic Circuits I

RG and gate terminal that is IG =0. The battery provides a voltage VGS to bias the
N-channel JFET, but no resulting current is drawn from the battery VGG.
Resistor RG is included to allow any ac signal applied through capacitor C to
develop across RG. While any ac signal will develop across RG, the dc voltage
drop across RG is equal to IG RG i.e. 0 volt.
Calculate VGS
For DC analysis IG =0., applying KVL to the input circuits
VGS+ VGG=0
VGS= - VGG
As VGS is a fixed dc supply, hence the name fixed bias circuit
Calculate IDQ
IDQ= IDss(1- VGS/VGp)2
Calculate VDS
This current IDQ then causes a voltage drop across the drain resistor RD and is
given as
VDSQ = VDD ID RD
Disadvantage
The fixed bias circuit of FET requires two power supplies.
Self-Bias circuits
Self-Bias circuits is the most common method for biasing a JFET. Self-bias
circuit for N-channel JFET is shown in figure

The gate source junction of JFET must be always in reverse biased


condition .No gate current flows through the reverse-biased gate-source, the
gate current IG = 0 and, therefore,vG = iG RG = 0

With
a
drain
current
ID
the
voltage
at
the
S
is
Vs= ID Rs
1)The gate-source voltage is then
VGS = VG - Vs = 0 ID RS = ID RS
So voltage drop across resistance Rs provides the biasing voltage VGg and no external
source is required for biasing and this is the reason that it is called self-biasing.
2)Calculate IDQ
SCE

31

Dept of ECE

EC6304

Electronic Circuits I

ID= IDSS(1- VGS/ VP)2


Substituting the value of VGS
ID= IDSS (1+ID RS / VP)2
3)The operating point (that is zero signal ID and VDS) can easily be determined from
equation given below :
VDS = VDD ID (RD + RS)
Self biasing of a JFET stabilizes its quiescent operating point against any change in its
parameters like transconductance. Any increase in voltage drop across RS, therefore,
gate-source voltage, VGS becomes more negative and thus increase in drain current is
reduced.
Voltage -Divider Bias circuits

The resistors RGl and RG2 form a potential divider across drain supply VDD. The voltage
V2 across RG2 provides the necessary bias. The additional gate resistor RGl from gate to
supply voltage facilitates in larger adjustment of the dc bias point and permits use of
larger valued RS.
The coupling capacitors are assumed to be open circuit for DC analysis
1) The gate is reverse biased so that IG = 0 and gate voltage
VG =V2 = (VDD/R G1 + R G2 ) *RG2
2) Applying KVL to the input circuit we get
VGS = VG VS = VG - ID RS
3) IDQ= IDSS(1- VGS/ VP)2
4) VDS = VDD ID (RD + RS)
The operating point of a JFET amplifier using the Voltage -Divider Bias is
determined by
IDQ= IDSS(1- VGS/ VP)2
VDSQ = VDD ID (RD + RS)
VGSQ = VG ID RS
Example Problems
1)Determine IDQ, VGSQ, VD, VS, VDS, and VDG

SCE

32

Dept of ECE

EC6304

Electronic Circuits I

Solution

SCE

33

Dept of ECE

EC6304

SCE

Electronic Circuits I

34

Dept of ECE

EC6304

SCE

Electronic Circuits I

35

Dept of ECE

EC6304

Electronic Circuits I

Example for Practice:

*Example 4

Example Problem

SCE

36

Dept of ECE

EC6304

Electronic Circuits I

1.14 Biasing of MOSFET


*N-channel enhancement mode MOSFET circuit shows the source terminal at
ground potential and is common to both the input and output sides of the circuit.
*The coupling capacitor acts as an open circuit to d.c. but it allows the signal
voltage to be coupled to the gate of the MOSFET.

As Ig = 0 in VG is given as,

Assume VG > VT , MOSFET is biased in the saturation region, the drain current is,

SCE

37

Dept of ECE

EC6304

Electronic Circuits I

If VDS > VDS(sat)


Biased in the nonsaturation region, and the drain current is given by, ID
Example problem-1

SCE

38

Dept of ECE

EC6304

Electronic Circuits I

Load Line and Modes of Operation


The load line gives a graphical picture showing the region in whichthe MOSFET is
biased. Consider the common-source circuit shown in Fig. (a).
Writing Kirchhoff's voltage law around the drain-source loop results VDs = VDD -IDRD,
which is the load line equation. It shows a linear relationship between the drain current
and drain-to-source voltage. Fig. (b) shows the VDS(sat) characteristic for the MOSFET

SCE

39

Dept of ECE

EC6304

Electronic Circuits I

The load line is given by

The two end points of the load line are determine in the usual manner. If the drain
current = 0, then VDS= 10 v; if VDS = 0, then drain current = 10/40 = 0.25 mA. The Qpoint of the MOSFET is given by the d.c. drain current (ID) and drain-to-source voltage
(VDS) and it is always on the load line, as shown in the Fig. b).
If the gate-to-source voltage is less than V1, the drain current is zero and the MOSFET
is in cut-off. As the gate-to-source voltage becomes just greater than the threshold
voltage, the MOSFET turns ON and is biased in the saturation region. As V GS
increases, the Q-point moves up the load line. The transition point is the boundary
between the saturation and non-saturation regions. It is the point where,

Common Source circuit for EMOSFET with source resistor

SCE

40

Dept of ECE

EC6304

Electronic Circuits I

Voltage Divider Bias


As

SCE

41

Dept of ECE

EC6304

Electronic Circuits I

Because ID = IS
Biasing Circuit for D MOSFET
Biasing circuits for depletion type MOSFET are quite similar to the circuits
used for JFET biasing. The primary difference between the two is the fact that depletion
type MOSFETs also permit operating points with positive value of V6s for n-channel
and negative values of V6s for p-channel MOSFET. To have positive value of V GS for
n-channel and negative value of V6s for p-channel self bias circuit is unsuitable.
Example problem-1

SCE

42

Dept of ECE

EC6304

Electronic Circuits I

Example 2

SCE

43

Dept of ECE

EC6304

SCE

Electronic Circuits I

44

Dept of ECE

EC6304

Electronic Circuits I

Example-3

SCE

45

Dept of ECE

EC6304

Electronic Circuits I

Example-4

SCE

46

Dept of ECE

EC6304

SCE

Electronic Circuits I

47

Dept of ECE

EC6304

Electronic Circuits I

QUESTIONS
2 MARK
1. What is DC load line? Draw the DC load line of the circuit shown in fig.

2. Find the collector and base current of circuit diagram given in fig, having hfe = 100,
VBE(on) = 0.7V

SCE

48

Dept of ECE

EC6304

Electronic Circuits I

3. Why do we choose Q point at the center of the load line?


4. What is operating point?
5. Distinguish between dc and ac load line with suitable diagram.
6. Name the two techniques used in the stability of the q point .explain.
7. Define the stability factor.
8. Define three stability factors.
9. List out the different types of biasing.
10. What is the need for the biasing the transistor amplifier?
11. What is the requirements for biasing circuits?
12. Define the term biasing.
13. Draw the fixed bias single stage transistor circuit.
14. Derive the stability factor S for a fixed bias circuit.
15. What are the advantages of fixed bias circuit?
16. Draw a single stage self biased circuit using pnp transistor.
17. What are the factors against which an amplifier needs to be stabilized?
18. What is thermal runway? How it can be avoided.
19. Why the transistor is called a current controlled device?
20. Define current amplification factor?
21. What is the necessary of the coupling capacitor?
22. Draw the any two biasing circuit for a JFET.
23. Draw any one biasing circuit for depletion type MOSFET.
24. Draw the any two biasing circuit for an enhancement type MOSFET.
25. Explain how an FET is used as a voltage variable resistor.
16 MARK
1. Explain the voltage divider bias method & derive an expression for stability factors.
2. Why biasing is necessary in BJT amplifier? Explain the concept of DC & AC load line
with neat diagram.
3. How will you select the operating point, explain it using CE amplifier characteristics?
4. Explain the collector feedback bias amplifier & derive an expression for stability factors.
5. Explain the fixed bias method & derive an expression for stability factors.
6. Derive an expression for all stability factors & CE configuration S equation.
7. Explain about common source self- bias & voltage divider bias for FET.
8. Explain in details about biasing MOSFET.
9. Discuss the various types of bias compensation.
10. Explain constant current biasing used in JFET amplifier.
(May,06)
11. Draw and explain voltage divider bias using FET and derive for its stability factors. Also
mention its advantages.
(May,11)
12. How is a JFET used as a voltage variable resistance? Explain. (Nov,07) (May,07)
13. Explain the bias circuit for enhancement MOSFET and explain its operation.
(Nov,14; Nov,13)
14. With circuit diagram explain biasing of FET and MOSFET.
(Nov,07)
15. Discuss the various techniques of stabilization of Q- point in a transistor. (Nov,09; May,13)

SCE

49

Dept of ECE

EC6304

Electronic Circuits I

16. The fixed bias circuit as shown in figure is subjected to an increase in junction temperature
from 25oC to 75oC. If is 125 at 75oC, determine the percentage change in Q point values
(VCE, IC) over temperature change. Neglect any change in VBE.
17. A self bias circuit has RE=1 k, R1=130 k, R2=10 k. If VCC and RC are adjusted to give
IC=1mA at 10oC. Calculate the variation in Ic over temperature change of 10oC to 100oC.
The transistor used has the parameters given below,

18. Design a collector to base bias circuit to have operating point (10v, 4mA). The circuit is
supplied with 20v and uses a silicon transistor of hfe is 250.
19. Design a voltage divider bias circuit for the specified conditions. VCC=12v, VCE=6v,
IC=1mA, S=20, =100 and VE=1v.
20. The parameters for each transistor in the circuit in figure, are hfe = 100, and VBE(on) = 0.7V.
Determine the Q-point values of base collector and emitter currents in Q1 and Q2
(8)[AU, MAY,2015]

21. Determine the change in collector current produced in each bias referred to in fig 1 and 2,
when the circuit temperature raised from 25oC to 105oC and ICBO = 15nA @ 25oC
(8)[AU, MAY,2015]

SCE

50

Dept of ECE

EC6304

Electronic Circuits I

22. Determine the quiescent current and voltage values in a P-Channel JFET circuit shown in
fig.
(8)[AU, MAY,2015]

23. The circuit shown in Fig, let hfe = 100, (1). Find VTH and RTH for the base circuit. (2).
(8)[AU, MAY,2015]
Determine ICEQ and VCEQ. (3). Draw the DC load line.

SCE

51

Dept of ECE

EC6304

Electronic Circuits I
UNIT II BJT AMPLIFIERS

2.1 Introduction
An amplifier is used to increase the signal level. It is used to get a larger signal
output from a small signal input. Assume a sinusoidal signal at the input of the amplifier.
At the output, signal must remain sinusoidal in waveform with frequency same as that of
input. To make the transistor work as an amplifier, it is to be biased to operate in active
region. It means base-emitter junction is forward biased and base-collector junction is
reverse biased.
Let us consider the common emitter amplifier circuit using voltage divider bias.

In the absence of input signal, only D.C. voltage is present in the circuit. It is
known as zero signal or no signal condition or quiescent condition. D.C. collector-emitter
voltage VCE, D.C. collector current IC and base current IB is the quiescent operating point
for the amplifier. Due to this base current varies sinusoidaly as shown in the below figure.
Fig. IBQ is quiescent DC base current
If the transistor is biased to operate in active region, output is linearly proportional
to the input. The collector current is times larger than the input base current in CE
configuration. The collector current will also vary sinusoidally about its quiescent value
ICQ. The output voltage will also vary sinusoidally as shown in the below figure.

SCE

52

Dept of ECE

EC6304

Electronic Circuits I

Variations in the collector current and voltage between collector and emitter due
to change in base current are shown graphically with the help of load line in the above
figure.
2.2 Common Emitter Amplifier Circuit

Fig. Practical common-emitter amplifier circuit


From above circuit, it consists of different circuit components. The functions of these
components are as follows:
1. Biasing Circuit:
Resistors R1, R2 and RE forms the voltage divider biasing circuit for CE amplifier and
it sets the proper operating point for CE amplifier.
2. Input Capacitor C1:
C1 couples the signal to base of the transistor. It blocks any D.C. component present
in the signal and passes only A.C. signal for amplification.
3. Emitter Bypass Capacitor CE:
CE is connected in parallel with emitter resistance RE to provide a low reactance path
to the amplified A.C. This will reduce the output voltage and reducing the gain value.
4. Output Coupling Capacitor C2:
C2 couples the output of the amplifier to the load or to the next stage of the amplifier.
It blocks D.C. and passes only A.C. part of the amplified signal.
Need for C1, C2, and CE:
The impedance of the capacitor is given by,
XC = 1/ (2fc)
Phase reversal:
The phase relationship between the input and output voltages can be determined by
considering the effect of positive and negative half cycle separately. The collector
current is times the base current, so the collector current will also increases. This
increases the voltage drop across RC.
VC = VCC - ICRC

SCE

53

Dept of ECE

EC6304

Electronic Circuits I

Increase in IC results in a drop in collector voltage VC, as VCC is constant. Vi


increases in a positive direction, Vo goes in negative direction and negative half cycle
of output voltage can be obtained for positive half cycle at the input.
In negative half cycle of input, A.C. and D.C. voltage will oppose each other.
This will reduce the base current. Accordingly collector current and drop across RC
both will reduce and it increases the output voltage. So positive half cycle at the
output for negative half cycle at the input can be obtained. So there is a phase shift of
180 between input and output voltages for a common emitter amplifier.
2.3 Common Collector Amplifier Circuit:

From above circuit, D.C. biasing is provided by R1, R2 and RE. The load resistance is
capacitor coupled to the emitter terminal of the transistor. When a signal is applied to
base of the transistor, VB is increased and decreased as the signal goes positive and
negative respectively.
From figure, VE = VB - VBE
Consider VBE is constant, so the variation in VB appears at emitter and emitter voltage VE
will vary same as base voltage VB. In common collector circuit, emitter terminal follows
the signal voltage applied to the base. It is also known as emitter follower.
2.4 Common Base Amplifier Circuit:

SCE

54

Dept of ECE

EC6304

Electronic Circuits I

From above circuit, the signal source is coupled to the emitter of the
transistor through C1. The load resistance RL is coupled to the collector of the transistor
through C2. The positive going pulse of input source increases the emitter voltage. As
base voltage is constant, forward bias of emitter-base junction reduces. This reduces Ib, Ic
and drop across Rc.
Vo = VCC - ICRC
Reduction in IC results in an increase in Vo. Positive going input produces positive going
output and vice versa. So there is no phase shift between input and output in common
base amplifier.
2.5 Small Signal Low Frequency h-parameter Model:
Let us consider the transistor amplifier as a block box.

Where, Ii input current to the amplifier


Vi - input voltage to the amplifier
Io output current of the amplifier
Vo output voltage of the amplifier
Input current is an independent variable. Input voltage and output current are dependent
variables. Input current and output voltage are independent variables.

This can be written in the equation form as,

The above equation can also be written using alphabetic notations,

Definitions of h-parameter:
The parameters in the above equations are defined as follows:

SCE

55

Dept of ECE

EC6304

Electronic Circuits I

h11 input resistance with output short-circuited in ohms


h12 fraction of output voltage at input with input open circuited, it is unitless
h21 forward current transfer ratio or current gain with output short circuited, it is
unitless
h22 output admittance with input open circuited in mhos
Benefits of h-parameters:
1. Real numbers at audio frequencies
2. Easy to measure
3. Can be obtained from the transistor static characteristic curve
4. Convenient to use in circuit analysis and design
5. Most of the transistor manufacturers specify the h-parameters

2.6 h-Parameters for all three configurations:


Transistor can be represented as two port network by making anyone
terminal common between input and output. There are three possible configurations in
which a transistor can be used, there is a change in terminal voltage and current for
different transistor configurations. To designate the type of configuration another
subscript is added to h-parameters.
hie = h11e input resistance in CE configuration
hfb = h21b short circuit current gain in CB configuration
Table: Summarizes h-parameters for all three configurations

SCE

56

Dept of ECE

EC6304

Electronic Circuits I

The basic circuit of hybrid model is same for all three configurations, only parameters
are different.

The circuit and equations are valid for either NPN or PNP transistor and are
independent of the type of load or method of biasing.
Determination of h-parameters from characteristics:
Consider CE configuration, its functional relationship can be defined from
the following equations:

The input characteristic curve gives the relationship between input voltage
VBE and input current IB for different values of output voltage VCE. The following figure
shows the typical input characteristic curve for CE configuration.
SCE

57

Dept of ECE

EC6304

Electronic Circuits I

Determination of hie and hre from characteristic curve:


Parameter hie:

Parameter hre:

The output characteristic curve gives the relationship between output current IC and
output voltage VCE for different values of input current IB.

Determination of hfe and hoe from output characteristic curve:


Parameter hfe:

SCE

58

Dept of ECE

EC6304

Electronic Circuits I

Parameter hoe:

hoe =

2.7 Midband analysis of BJT Single Stage Amplifiers:


Consider the basic amplifier circuit. To form a transistor amplifier
only is is necessary to connect an external load and signal source along with proper
biasing.

We can replace the transistor circuit as shown in the following figure.

Let us analyze the hybrid model to find current gain, input resistance, voltage gain and
output resistance.
Current gain (Ai):
It is defined as the ratio of output to input current. It is given by,

Here IL and I2 are equal in magnitude but opposite in sign. IL = -I2


From above circuit,

SCE

59

Dept of ECE

EC6304

Electronic Circuits I

Substituting V2 = -I2RL in the equation, then equation become,

Current gain (AIS):


It is given by,

From above figure, using current divider rule,

SCE

60

Dept of ECE

EC6304

Electronic Circuits I

Input Impedance (Zi):


Ri is the input resistance looking into the amplifier input terminals ( 1, 1). It is given by,

From the input circuit,

Substituting V2 = -I2RL = Ai I1 RL in the above equation,

Substituting

Then we get,

Dividing numerator and denominator by RL we get,

From this equation, note that the input impedance is a function offload impedance.
Voltage gain (Av):
It is the ratio of output voltage to input voltage. It is given by,

By substituting V2 = -I2RL = Ai I1 RL

Since

SCE

61

Dept of ECE

EC6304

Electronic Circuits I

Voltage gain (Avs):


It is voltage gain including the source. It is given by,

From above figure, applying potential divider rule, then we get,

Substituting the value of V1/Vs in the equation of

We get,

Output Admittance (Yo):


It is the ratio of output current to output voltage. It is given by,

From equation,
Dividing above equation by V2, We get,
SCE

62

Dept of ECE

EC6304

Electronic Circuits I

From transistor amplifier in h-parameter model circuit, with Vs = 0,


RsI1 + hiI1 +hrV2 = 0
(Rs + hi) I1 = -hr V2

Substituting the value of I1/V2 from above equation in the equation of Yo. We obtain,

From this equation, note that the output admittance is a function of source resistance.
Power gain (Ap):
It is the ratio of average power delivered to the load to the input power. Output
power is given as,
Since the input power is P1 = V1I1
The operating power gain Ap of the transistor is given as,

Relation between Avs and AIS:


From equation,

Avs =

and

We have,

&
Taking ratio of above two equations we get,

SCE

63

Dept of ECE

EC6304

Electronic Circuits I

Table: Summarizes small signal analysis of a transistor amplifier

Method for analysis of a transistor circuit:


The analysis of transistor circuits for small signal behaviour can be made by following
simple guidelines. These guidelines are,
1.
2.
3.
4.

Draw the actual circuit diagram


Replace coupling capacitors and emitter bypass capacitor by short circuit
Replace D.C. source by a short circuit
Mark the points B, E, C on the circuit diagram and locate these points as the start
of the equivalent circuit
5. Replace the transistor by its h-parameter model
Problem 1:
For the common base circuit shown in figure, transistor parameters are hib = 22,
hfb = -0.98, hob = 0.49A/V, hrb = 2.9*10-4. Calculate the values of input resistance,
output resistance, current gain and voltage gain for the given circuit.

SCE

64

Dept of ECE

EC6304

Electronic Circuits I

Solution:
Change the given figure into h-parameter equivalent model.

a) Current gain

b) Input Resistance

c) Voltage gain

d) Overall voltage gain

e) Overall current gain


SCE

65

Dept of ECE

EC6304

Electronic Circuits I

f) Output Resistance

Ro = Ro || RL = 1.21M || 5.45K = 5.425K


Problem 2:
Consider a single stage CE amplifier with Rs = 1K, RL = 1.2K. Calculate Ai, Ri,
Av, Ais, power gain and Ro if hie = 1.1k, hre = 2.5*10-4, hfe = 50 and hoe = 25A/V.
Solution:

Ai =

SCE

66

Dept of ECE

EC6304

Electronic Circuits I

Ri =

Av =
Avs =

Ais =

Yo =

Ro =
Problem 3:
Consider a single stage CE amplifier with Rs = 1k, R1 = 50k, R2 = 2k, Rc = 2k, RL =
2K, hie = 1.1k, hoe = 25A/V, hfe = 50 and hre = 2.5*10-4 as shown in the figure.
Find Ai, Ri, Av, Ai, Avs and Ro.

Solution:
Since hoe RL = 25*10-6*(2K || 2K) = 0.25, which is less than 0.1, so use approximate
analysis.
Consider the simplified hybrid model for the given circuit.

SCE

67

Dept of ECE

EC6304

Electronic Circuits I

a) Current gain

b) Input Impedance

c) Voltage gain

d) Output Impedance

e) Overall voltage gain

f) Overall current gain

SCE

68

Dept of ECE

EC6304

Electronic Circuits I

From above figure,

Comparison of Transistor Configurations:

2.8 Introduction of Differential Amplifier


A device which accepts an input signal and produces an output signal proportional
to the input, is called an amplifier. An amplifier which amplifies the difference between.
the two input signals is called differential amplifier. The differential amplifier
configuration is used in variety of analog circuits. The. differential amplifier is an
essential and basic building block in modern IC amplifier .The Integrated Circuit (IC)

SCE

69

Dept of ECE

EC6304

Electronic Circuits I

technology is well known now a days, due to which the design of complex circuits
become very simple. The IC version of operational amplifier is inexpensive, takes up less
space and consumes less power. The. differential amplifier is the basic building block of
such IC operational amplifier.
Basics of Differential Amplifier
The Differential Amplifier amplifies the difference between two input voltage
signal. Hence it is also called as difference amplifier.
Consider an ideal differential amplifier shown in the Fig. A

V1 and V2 are the two input signals while Vo is the output. Each signal is measured with
respect to the ground.
In an ideal differential amplifier, the output voltage Vo is proportional to the
difference between the two input signals. Hence we can write,

From Equation 1 we can write,

where AD is the constant of proportionality. The AD is the gain with which differential
amplifier amplifies the difference between two input signals. Thus it is called differential
gain of the differential amplifier.
Thus, Ad = Differential gain
The difference between the two inputs (V1 - V2) is generally called difference
voltage and denoted as Vd.
...(3)
Hence the differential gain can be expressed as,
...(4)
Generally the differential gain is expressed in its decibel (dB) value as,
...(5)

Common Mode Gain Ac


If we apply two input voltages which are equal in all the respects to the
differential amplifier i.e. V1 = Vz then ideally the output voltage Vo = (V1 - V2) Ad,
must be zero.But the output voltage of the practical differential amplifier not only
SCE

70

Dept of ECE

EC6304

Electronic Circuits I

depends on thedifference voltage but also depends on the average common level of the
two inputs.
Such an average level of the two input signals is called common mode signal denoted
as VC
...(6)
Practically, the differential amplifier produces the output voltage proportional to such
common mode signal, also. The gain with which it amplifies the common mode signal to
produce the output is called common mode gain of the differential amplifier AC.\
..(7)
Thus there exists some finite output for V1 = V2 due to such common mode gain AC,
in case of practical differential amplifiers.
So the total output of any differential amplifier can be expressed as,
..(8)
For an ideal differential amplifier, the differential gain Ad, must be infinite
while the common mode gain must be zero.
But due to mismatch in the internal circuitry, there is some output available for
V1 = V2 and gain AC is not practically zero. The value of such common mode gain AC
very small while the value of the differential gain Ad is always very large.
Common Mode Rejection Ratio (CMRR)
When the same voltage is applied to both the inputs, the differential amplifier is
said to be operated in a common mode configuration. Many disturbance signals, noise
signal appear as a common input signal to both the input terminals of the differential
amplifier. Such a common signal should be rejected by the differential amplifier. The
ability of a differential amplifier to reject a common mode signal is expressed by a ratio
called common mode rejection ratio denoted as CMRR. It is defined as the ratio of the
differential voltage gain Ad to common mode voltage gain AC
.(9)
..(10)

2.9 Transistorised Differential Amplifier


The transistorised differential amplifier basically uses the emitter biased circuits
which are identical in characteristics. Such two identical emitter biased circuits are

SCE

71

Dept of ECE

EC6304

Electronic Circuits I

The two transistors Q1 and Q2 have


exactly matched characteristics. The
two collector
Resistors R C1 and R C2
are equal
while the two emitter resistances R E1
and R E2
are equal.

The magnitudes of + Vcc and V EE are also same. The differential amplifier can be
obtained by using such two emitter biased circuits. This is achieved by connecting emitter
E1 of Q1 to the emitter E2 of Q2. Due to this, R E1 appears in parallel with R E2 and the
combination can be replaced by a single resistance denoted as R E. The base B1 of Q1 is
connected to the input 1 which is V S1 while the base B 2 of Q2 is connected to the input 2
which is Vs2. The supply voltages are measured with respect to ground. The balanced
output is taken between the collector C1 of Q1 and the collector C2 of Q 2. Such an
amplifier is called emitter coupled differential amplifier. The two collector resistances are
same hence can be denoted as R C..
The output can be taken between two collectors or in between one of the two
collectors and the ground. When the output is taken between the two collectors, none of
them is grounded then it is called balanced output, double ended output or floating output.
When the output is taken between any of the collectors and the ground, it is called
unbalanced output or single ended output. The complete circuit diagram of such a basic
dual input, balanced output differential amplifier is shown in the Fig.

As the output is taken between two output terminals, none of them is grounded, it is
called balanced output differential amplifier.

SCE

72

Dept of ECE

EC6304

Electronic Circuits I

Let us study the circuit operation in the two modes namely


Differential mode operation
Common mode operation

2.9.1 Differential Mode Operation


In the differential mode, the two input signals are different from each other.
Consider the two input signals which are same in magnitude but 180" out of phase. These
signals, with opposite phase can be obtained from the center tap transformer. The circuit
used in differential mode operation is shown in the Fig..

Assume that the sine wave on the base of Q 1is positive going while on the base of
Q 2 is negative going. With a positive going signal on the base of Q 1, m amplified
negative going signal develops on the collector of Q1. Due to positive going signal,
current through R E also increases and hence a positive going wave is developed across R
E. Due to negative going signal on the base of Q2, an amplified positive going signal
develops on the collector of Q 2. And a negative going signal develops across R E,
because of emitter follower action of Q 2. So signal voltages across R E, due to the effect
of Q1 and Q2 are equal in magnitude and 180o out of phase, due to matched pair of
transistors. Hence these two signals cancel each other and there is no signal across the
emitter resistance. Hence there is no a.c. signal current flowing through the emitter
resistance. Hence R E in this case does not introduce negative feedback. While Vo is the
output taken across collector of Q1 and collector of Q 2. The two outputs on collector L
and 2 are equal in magnitude but opposite in polarity. And Vo is the difference between
these two signals, e.g. +10 - (-10) = + 20.
Hence the difference output Vo is twice as large as the signal voltage from
either collector to ground

SCE

73

Dept of ECE

EC6304

Electronic Circuits I

2.9.2 Common Mode Operation


In this mode, the signals applied to the base of Q1 and Q2 are derived from the
same source. So the two signals are equal in magnitude as well as in phase. The circuit
diagram is shown in the Fig.
In phase signal voltages at the bases of Q1 and Q2 causes in phase signal voltages
to appear across R E, which add together. Hence R E carries a signal current and provides
a negative feedback. This feedback reduces the common mode gain of differential
amplifier.

While the two signals causes in phase signal voltages of equal magnitude to appear across
the two collectors of Q 1 and Q2. Now the output voltage is the difference between the
two collector voltages, which are equal and also same in phase, Eg. (20) - (20) = 0. Thus
the difference output Vo is almost zero, negligibly small. ideally it should be zero.
2.10 Configurations of Differential Amplifier
The differential amplifier, in the difference amplifier stage in the op-amp, can be
used in four configurations :
Dual input balanced output differential amplifier.
Dual input, unbalanced output differential amplifier.
Single input, balanced output differential amplifier.
Single input, unbalanced output differential amplifier.
The differential amplifier uses two transistors in common emitter configuration. If
output is taken between the two collectors it is called balanced output or double ended
output. While if the output is taken between one collector with respect to ground it is
called unbalanced output or single ended output. If the signal is given to both the input
terminals it is called dual input, while if the signal is given to only one input terminal and
other terminal is grounded it is called single input or single ended input. Out of these four
configurations the dual input, balanced output is the basic differential amplifier
configuration. This is shown in the Fig. (a). The dual input, unbalanced output
differential amplifier is shown in the Fig.(b). The single input, balanced output

SCE

74

Dept of ECE

EC6304

Electronic Circuits I

differential amplifier is shown in the Fig (c) and the single input, unbalanced output
differential amplifier is shown in the Fig. (d).

2.11 D.C. Analysis of Differential Amplifier


The d.c. analysis means to obtain the operating point values i.e. I Cq and V CEQ for
the transistors used. The supply voltages are d.c. while the input signals are a.c., so d.c
equivalent circuit can be obtained simply by reducing the input a.c. signals to zero. The
d.c. equivalent circuit thus obtained is shown in the Fig.. Assuming Rs 1 = R S2, the
source resistance is simply denoted by Rs ,

SCE

75

Dept of ECE

EC6304

Electronic Circuits I

.
The transistors Q1 and Q 2 are matched transistors and hence for such a matched pair
we can assume :
i) Both the transistors have the same characteristics.
ii) R E1 = R E2 hence R E= R E1 ll R E2.
iii) R C1 = R c 2 hence denoted as R C.
iv) lV CCI = lV EE I and both are measured with respect to ground.
As the two transistors are matched and circuit is symmetrical, it is enough to find out
operating point I CQ and V CEQ, for any one of the two transistors. The same is applicable
for the other transistor.
Apply-g KVL to base-emitter loop of the transistor Q1,
.(1)

.(2)

.(3)

SCE

76

Dept of ECE

EC6304

Electronic Circuits I

2.12 A.C. Analysis of Differential Amplifier using h-Parameters


In the a.c. analysis, we will calculate the differential gain A d, common mode gain
A C, input resistance Ri and the output resistance R 0 of the differential amplifier circuit,
using the h-parameters.
1. Differential Gain (A d)
For the differential gain calculation, the two input signals must be different from
each other. Let the two a.c. input signals be equal in magnitude but having 180" phase
difference in between them. The magnitude of each a.c. input voltage V S1 and V S2 beVs
/2. The two a.c. emitter currents I e1 and I e2 are equal in magnitude and 180' out of phase.
Hence they cancel each other to get resultant a.c. current through the emitter as zero. For
the a.c. purposes emitter terminal can be grounded. The a.c. small signal differential
amplifier circuit with grounded emitter terminal is shown in the Fig1 As the two
transistors are matched, the a.c. equivalent circuit for the other transistor is identical to
the one shown in the Fig..1. Thus the circuit can be analyzed by considering only one
transistor. This is called as half circuit concept of analysis. The approximate hybrid
model for the above circuit can be shown as in the Fig.2, neglecting hoe,

SCE

77

Dept of ECE

EC6304

Electronic Circuits I

The negative sign indicates the phase difference between input and output. Now two
input signal magnitudes are VS /2 but they are opposite in polarity, as 180" out of phase.

SCE

78

Dept of ECE

EC6304

Electronic Circuits I

the expression for A d with balanced output changes as

This is the differential gain for balanced output dual input differential amplifier
circuit.
2. Common Mode Gain (A C)
Let the magnitude of both the a.c. input signals be VS and are in phase with each
other. Hence the differential input Vd = 0 while the common mode input Vc is the
average value of the two.

But now both the emitter currents flows through R E in the Same direction. Hence the
total current flowing through R E is 2I e. considering only one transistor, as in the Fig

SCE

79

Dept of ECE

EC6304

Electronic Circuits I

The emitter resistance is shown 2 RE in the Fig

SCE

80

Dept of ECE

EC6304

Electronic Circuits I

2.13 Common Mode rejection Ratio (CMRR)


Once the differential and common mode gains are obtained, the expression for the CMRR
can be obtained as,

SCE

81

Dept of ECE

EC6304

Electronic Circuits I

2.14 Techniques of Improving Input Impedance


Among three configurations (CB, CC and CE), common collector or emitter
follower circuit has high input impedance. Typically it is 200 K to 300 K. A single
stage emitter follower circuit can give input impedance upto 500 K. However, the input
impedance considering biasing resistors is
Figure shows the direct coupling of two stages of emitter follower significantly less.
Because Ri = R1 ll R2 ll Ri The input impedance of the circuit can be improved by direct
coupling of two stages of emitter follower amplifier. The input impedance can be
increased using two techniques :
Using direct coupling (Darlington connection)
Using Bootstrap technique
2.14.1 Darlington Transistors
Figure shows the direct coupling of two stages of emitter follower amplifier. This
cascaded connection of two emitter followers is called the Darlington connection.

Assume that the load resistance RL is such that RL hoe < 0.1, therefore we can use
approximate analysis method for analyzing second stage.

Figure shows approximate h-parameter (AC) equivalent circuit for common emitter
configuration. The same circuit can be redrawn by making collector common to have
approximate h-parameter equivalent circuit for common collector configuration.
SCE

82

Dept of ECE

EC6304

Electronic Circuits I

Analysis of second stage :

Analysis of first stage :


Load resistance of the first stage is the input resistance of the second stage i.e. Ri2. As Ri2
is high, usually it does not meet the requirement hoe Ri2 < 0.1, and hence we have to use
the exact analysis method for analysis of the first stage.
Figure shows the h-parameter equivalent circuit for common emitter configuration.

The same circuit can be redrawn by making collector common to have h-parameter
equivalent circuit for common collector for configuration.

SCE

83

Dept of ECE

EC6304

SCE

Electronic Circuits I

84

Dept of ECE

EC6304

Electronic Circuits I

Overall current gain(Ai)

From table, we can say that Darlington connection improves input impedance as well as
current gain of the circuit
Overall Voltage gain

We know that

By subtracting 1 on both sides we get

SCE

85

Dept of ECE

EC6304

Electronic Circuits I

We know that the overall voltage gain in multistage amplifier is a product of individual
voltage gain

As we know, input resistance Ri1 >> Ri2 we can neglect term 3 and term 4 in the above
equation.

Output Impedance (Ro2) :

From equation, Yo of the transistor is given as

Since

And

Looking at Figure we can see that the Ri1 of the first stage is the source resistance
for second stage, i.e. RS2= RO1

SCE

86

Dept of ECE

EC6304

Electronic Circuits I

Key Point:
In above analysis we have assumed that the h-parameter of T1 and T2 are
identical,
From the above analysis we have seen that Darlington connection of two
transistorimproves current gain and input resistance of the circuit.

2.14.2 Bootstrap Emitter Follower

In emitter follower, the input resistance of the amplifier is reduced because of the
shunting effect of the biasing resistors. To overcome this problem the emitter follower
circuit is modified, as shown in the Figure. Here, two additional components are used,
resistance R, and capacitor C .The capacitor, is connected between the emitter and the
junction of R1,R2 and R3.
For d.c. signal, capacitor C acts as a open circuit and therefore resistance R1,R2
and R3 provides necessary biasing to keep the transistor in active region.
For ac signal, the capacitor acts as a short circuit. Its value is chosen such that it
provides very low reactance nearly short circuit at lowest operating frequency. Hence for
ac, the bottom of R3 is effectively connected to the output(the emitter), whereas the top
of R3 is at the -input. (the base). In other words, R3 is connected between input node and
output node. For such connection effective input resistance is given by Miller's theorem.
The two components are

SCE

87

Dept of ECE

EC6304

Electronic Circuits I

R3 is the impedance between output voltage and input voltage and K is the
voltage gain.

These are

Since, for an emitter follower, Av, approaches unity, then RM2 becomes extremely large.

The above effect, when Av tends to unity is called bootstrapping. The name arises from
the fact that, if one end of the resistor R3 changes in voltage, the other end of R3 moves
through the same potential difference; it is as if R3 is pulling itself up by its bootstraps.

The effective load on the emitter follower can be given as

SCE

88

Dept of ECE

EC6304

Electronic Circuits I

Because of the capacitor, biasing resistances R1 and R2, come on output side shunting
effective load resistance. The resistance RM2 is very large and hence it is often neglected.

Problem
1. For the circuit shown in Figure calculate RLeff , Ri, and Ri

2. Analyze the following circuit for the following values of resistors and h-parameters

SCE

89

Dept of ECE

EC6304

Electronic Circuits I

Solution
Analysis of second stage

SCE

90

Dept of ECE

EC6304

Electronic Circuits I

Multistage Amplifiers
In practice, we need amplifier which can amplify a signal from a very weak source such
as a microphone, to a level which is suitable for the operation of another transducer
such as loudspeaker . This is achieved by cascading number of amplifier stages, known as
multistage amplifier
Need for Cascading
For faithful amplification amplifier should have desired voltage gain, current gain and it
should match its input impedance with the source and output impedance with the load.
Many times these primary requirements of the amplifier can not be achieved with single
stage amplifier, because of the limitation of the transistor/FET parameters. In such
situations more than one amplifier stages are cascaded such that input and output stages
provide impedance matching requirements with some amplification and remaining
middle stages provide most of the amplification.
We can say that,
SCE

91

Dept of ECE

EC6304

Electronic Circuits I

When the amplification of a single stage amplifier is not sufficient, or,


When the input or output impedance is not of the correct magnitude, for a
particular application two or more amplifier stages are connected, in cascade.
Such amplifier,with two or more stages is also known as multistage amplifier.
Two Stage Cascaded Amplifier

Vi1 is the input of the first stage and Vo2 is the output of second stage.
So,Vo2/Vi1 is the overall voltage gain of two stage amplifier.

n-Stage Cascaded Amplifier

Voltage gain :
The resultant voltage gain of the multistage amplifier is the product of voltage gains of
the various stages.
Av = Avl Av2 ... Avn
Gain in Decibels
In many situations it is found very convenient to compare two powers on logarithmic
scale rather than on a linear scale. The unit of this logarithmic scale is called decibel
(abbreviated dB). The number N decibels by which a power P2 exceeds the power P1 is
defined by

SCE

92

Dept of ECE

EC6304

Electronic Circuits I

Decibel, dB denotes power ratio. Negative values of number of dB means that the power
P2 is less than the reference power P1 and positive value of number of dB means the
power P2 is greater than the reference power P1.
For an amplifier, P1 may represent input power, and P2 may represent output power.
Both can be given as

Where Ri and Ro are the input and output impedances of the amplifier respectively.Then,

If the input and output impedances of the amplifier are equal i.e. Ri = Ro= R, then

Gain of Multistage Amplifier in dB


The gain of a multistage amplifier can be easily calculated if the gain of the individual
stages are known in dB, as shown below
20 log10 Av = 20 log10 Avl + 20 log10Av2 + + 20 log10 Avn
Thus, the overall voltage gain in dB of a multistage amplifier is the decibel voltage gains
of the individual stages. It can be given as
AvdB = AvldB + Av2dB + ... + AvndB
Advantages of Representation of Gain in Decibels
Logarithmic scale is preferred over linear scale to represent voltage and power gains
because of the following reasons :
In multistage amplifiers, it permits to add individual gains of the stages to
calculate overall gain.
It allows us to denote, both very small as well as very large quantities of linear,
scale by considerably small figures.
For example, voltage gain of 0.0000001 can be represented as -140 dB and
voltage gain of 1,00,000 can be represented as 100 dB.
Many times output of the amplifier is fed to loudspeakers to produce sound which
is received by the human ear. It is important to note that the ear responds to the
sound intensities on a proportional or logarithmic scale rather than linear scale.
Thus use of dB unit is more appropriate for representation of amplifier gains.
Methods of coupling Multistage Amplifiers
In multistage amplifier, the output signal of preceding stage is to be coupled to the input
circuit of succeeding stage. For this interstage coupling, different types of coupling
elements can be employed. These are :
1. RC coupling
2. Transformer coupling
3. Direct coupling
RC coupling
Figure shows RC coupled amplifier using transistors. The output signal of first stage is
coupled to the input of the next stage through coupling capacitor and resistive load at the
output terminal of first stage

SCE

93

Dept of ECE

EC6304

Electronic Circuits I

The coupling does not affect the quiescent point of the next stage since the coupling
capacitor Cc blocks the d.c. voltage of the first stage from reaching the base of the
second stage. The RC network is broadband in nature. Therefore, it gives a wideband
frequency response without peak at any frequency and hence used to cover a complete
A.F amplifier bands. However its frequency response drops off at very low frequencies
due to coupling capacitors and also at high frequencies due to shunt capacitors such as
stray capacitance.

Transformer Coupling
Figure shows transformer coupled amplifier using transistors. The output signal of
first stage is coupled to the input of the next stage through an impedance matching
transformer

SCE

94

Dept of ECE

EC6304

Electronic Circuits I

This type of coupling is used to match the impedance between output and input cascaded
stage. Usually, it is used to match the larger output resistance of AF power amplifier to a
low impedance load like loudspeaker. As we know, transformer blocks d.c, providing d.c.
isolation between the two stages. Therefore, transformer coupling does not affect the
quiescent point of the next stage. Frequency response of transformer coupled amplifier is
poor in comparison with that an RC coupled amplifier. Its leakage inductance and inter
winding capacitances does not allow amplifier to amplify the signals of different
frequencies equally well. Inter winding capacitance of the transformer coupled may give
rise resonance at certain frequency which makes amplifier to give very high gain at that
frequency. By putting shunting capacitors across each winding of the transformer, we can
get resonance at any desired RF frequency. Such amplifiers are called tuned voltage
amplifiers. These provide high gain at the desired of frequency, i.e. they amplify selective
frequencies. For this reason, the transformer-coupled amplifiers are used in radio and TV
receivers for amplifying RF signals. As d.c. resistance of the transformer winding is very
low, almost all d.c. voltage applied by Vcc is available at the collector. Due to the
absence of collector resistance it eliminates unnecessary power loss in the resistor.

Direct Coupling
Figure shows direct coupled amplifier using transistors. The output signal of first
stage is directly connected to the input of the next stage. This direct coupling allows the
quiescent d.c. collector current of first stage to pass through base of the next stage,
affecting its biasing conditions.

SCE

95

Dept of ECE

EC6304

Electronic Circuits I

Due to absence of RC components, frequency response is good but at higher frequencies


shunting capacitors such as stray capacitances reduce gain of the amplifier.
The transistor parameters such as VBE and change with temperature causing the
collector current and voltage to change. Because of direct coupling these changes appear
at the base of next stage, and hence in the output. Such an unwanted change in the output
is called drift and it is serious problem in the direct coupled amplifiers.

SCE

96

Dept of ECE

EC6304

SCE

Electronic Circuits I

97

Dept of ECE

EC6304

SCE

Electronic Circuits I

98

Dept of ECE

EC6304

Electronic Circuits I

QUESTIONS
2 MARKS
1. What are the advantages of Darlington amplifier?
2. Explain Millers theorem. (May/jun 2103)
3. What are the limitations of h parameters?
What are practical limitations in selecting very high R E?
4.
5. Define i) Differential gain ii) Common mode gain
6. State Millers Theorem. (May,15)
7. How can a DC equivalent circuit of an amplifier be obtained?
8. Draw the Darlington emitter follower circuit. (May,14,13)
9. What does bootstrapping mean? Why bootstrapping is done in a buffer amplifier?
10. Define Common Mode Rejection Ratio. (Nov,09)
11. What is the coupling schemes used in multistage amplifiers? (May,10)
12. What are the advantages of Representation of Gain in Decibels.
13. What is the typical value of CMRR? How the constant current circuit is used to
improve the CMRR?
(Nov,14)
14. Find the value of dc when Ic=8.2mA and Ie=8.7mA.
15. What are the advantages of h-parameters? (Nov,14)
16. What is the role of coupling network in multistage amplifiers?
17. Define voltage & current gain of an emitter follower.
18. Why CE amplifier better than CC & CB amplifiers?
19. What is the difference between cascade and cascode amplifier?
20. Mention two importance characteristics of CC circuit.
21. State Bisection Theorem. (Nov,12)
22. Draw the small signal equivalent circuit of CE amplifier.
23. If CMMR of amplifier is 100dB, calculate CM gain if difference gain is1000.
24. Two identical amplifiers are cascaded, having 10dBgain each other. Calculate
output voltage if the input of 1mv

SCE

99

Dept of ECE

EC6304

Electronic Circuits I

16 MARKS
1. Draw a CE amplifier & its small signal equivalent. Derive its Avs, Ai, Rin, Ro.
2. For the CC amplifier circuit, Find the expressions for input impedance and
voltage gain. Assume suitable model for transistor.
3. Explain with circuit diagram of Darlington connection and derive the expression
for Ai, Av, Ri &Ro.
4. Explain the emitter coupled differential amplifier with neat diagram & Derive
expression for CMRR.
5. Discuss transfer characteristics of differential amplifier. Explain the methods used
to improve CMRR.
6. Derive the expressions for the common mode and differential mode gains of a
differential amplifier in terms of h-parameters.
7. Compare CE, CB, CC amplifiers.
8. Derive the expressions for the voltage gain, current gain, input and output
impedance of emitter follower amplifier.
9. Derive expression for voltage gain of CS & CD amplifier under small signal low
frequency condition.
10. Draw a two stage RC coupled amplifier and explain. Compare cascade and
cascode amplifier?
11. Consider a single stage CE amplifier with Rs=1k, R1=50K, R2=2K,
RC=2K, RL=2K, hfe=50, hie=1.1 K, hoe=25mho, hre=2.510-4. Find
Ai,Ri,Av,Ais,Avs and R0.
12. The Darlington amplifier has the following parameters, Rs=3k, RE=3k,
hie=1.1 K, hfe=50, hre=2.510-4, hoe=25mho. Then calculate Ai, Ri, Av and
R0.
13. The dual input balanced output differential amplifier having Rs=100,
RC=4.7K, RE=6.8K, hfe=100, Vcc=+15v and VEE=-15v. Calculate operating
point values, differential & common mode gain, CMRR, and output if VS1=
70mV(p-p) at 1 KHz & VS2= 40mV(p-p) at 1 KHz

SCE

100

Dept of ECE

EC6304

Electronic Circuits I
UNIT 3
JFET AND MOSFET AMPLIFIERS

3.1 JFET Amplifiers


It provides an excellent voltage gain with high input impedance. Due to these
characteristics, it is often preferred over BJT.
Three basic FET configurations
Common source, common drain and common gate
3.2 JFET low frequency a.c Equivalent circuit
Figure shows the small signal low frequency a.c Equivalent circuit for n-channel JFET.

Fig3.1 small signal model of JFET


3.3 Common Source Amplifier With Fixed Bias
Figure shows Common Source Amplifier With Fixed Bias. The coupling capacitor C1
and C2 which are used to isolate the d.c biasing from the applied ac signal act as short circuits
for ac analysis.

Fig3.2 Common source circuit of JFET


The following figure shows the low frequency equivalent model for Common Source Amplifier
With Fixed Bias. It is drawn by replacing
All capacitors and d.c supply voltages with short circuit
JFET with its low frequency a.c Equivalent circuit

Fig3.3 small signal model of CS JFET amplifier


Input Impedance Zi

SCE

101

Dept of ECE

EC6304

Electronic Circuits I

Zi = RG
Output Impedance Zo

Fig3.4 Equivalent circuit model of JFET for output


It is the impedance measured looking from the output side with input voltage Vi equal to Zero.
As Vi=0,Vgs =0 and hence gmVgs =0 . And it allows current source to be replaced by an open
circuit.
So,
If the resistance rd is sufficiently large compared to RD, then

3.4 Common source amplifier with self bias (Bypassed Rs)

SCE

102

Dept of ECE

EC6304

Electronic Circuits I

Figure shows Common Source Amplifier With self Bias. The coupling capacitor C1 and
C2 which are used to isolate the d.c biasing from the applied ac signal act as short circuits for ac
analysis. Bypass capacitor Cs also acts as a short circuits for low frequency analysis.

Fig3.5 Common source amplifier model of JFET


The following figure shows the low frequency equivalent model for Common Source Amplifier
With self Bias.

Fig3.6 Small signal model for Common source amplifier model of JFET

The negative sign in the voltage gain indicates there is a 180o phase shift between input and
output voltages.

SCE

103

Dept of ECE

EC6304

Electronic Circuits I

3.5 Common source amplifier with self bias (unbypassed Rs)

Fig3.7 Common source amplifier model of JFET


Now Rs will be the part of low frequency equivalent model as shown in figure.

Fig3.8 Small signal model for Common source amplifier model of JFET
Input Impedance Zi
Zi = RG
Output Impedance Zo
It is given by

Voltage gain (Av)


It is given by

SCE

104

Dept of ECE

EC6304

Electronic Circuits I

3.6 Common source amplifier with Voltage divider bias (Bypassed Rs)
Figure shows Common Source Amplifier With voltage divider Bias. The coupling capacitor C1
and C2 which are used to isolate the d.c biasing from the applied ac signal act as short circuits
for ac analysis. Bypass capacitor Cs also acts as a short circuits for low frequency analysis.

SCE

105

Dept of ECE

EC6304

Electronic Circuits I

Fig3.9 Common source amplifier with Voltage divider bias(Bypassed Rs)


The following figure shows the low frequency equivalent model for Common Source Amplifier
With voltage divider Bias

Fig3.10 small model of Common source amplifier with Voltage divider bias(Bypassed Rs)
The parameters are given by

The negative sign in the voltage gain indicates there is a 180o phase shift between input and
output voltages.

SCE

106

Dept of ECE

EC6304

Electronic Circuits I

3.7 Common source amplifier with Voltage divider bias (unbypassed Rs)

Fig3.11 small model of Common source amplifier with Voltage divider bias(without
Bypassed Rs)
Now Rs will be the part of low frequency equivalent model as shown in figure.

3.8 Common Drain Amplifier


In this circuit, input is applied between gate and source and output is taken between source and
drain.

SCE

107

Dept of ECE

EC6304

Electronic Circuits I

Fig3.12 Circuit of Common Drain amplifier


In this circuit, the source voltage is
Vs = VG+VGS
When a signal is applied to the JFET gate via C1 ,VG varies with the signal. As VGS is fairly
constant and Vs = VG+VGS, Vs varies with Vi.
The following figure shows the low frequency equivalent model for common drain circuit.

Fig3.13 small model of Common Drain amplifier


Input Impedance Zi

Fig3.13 Simplified small model of Common Drain amplifier


Zi = RG
Output Impedance Zo
It is given by

SCE

108

Dept of ECE

EC6304

Electronic Circuits I

But Vgs = Vo, so

Voltage gain (Av)


It is given by

But

Substitute the value Vo and Vi. Then

SCE

109

Dept of ECE

EC6304

Electronic Circuits I

Common drain circuit does not provide voltage gain.& there is no phase shift between input and
output voltages.
Table summarizes the performance of common drain amplifier

3.9 Common Gate Amplifier


In this circuit, input is applied between source and gate and output is taken between drain and
gate.

Fig3.14 Circuit diagram of Common gate amplifier


In CG Configuration, gate potential is at constant potential. so, increase in input voltage Vi in
positive direction increase the negative gate source voltage. Due to ID reduces, reduces, reducing
the drop IDRD. Since VD= VDD-IDRD, the reduction in ID results in an increase in output voltage.

SCE

110

Dept of ECE

EC6304

Electronic Circuits I

Fig3.15 small signal model for Common gate amplifier


1. Input Impedance (Zi)
It is given by

And

After substituting and simplification,

And

SCE

111

Dept of ECE

EC6304

Electronic Circuits I

2. Output Impedance Zo

It is given by

3. Voltage gain (Av)


It is given by

Using KVL to the outer loop, after simplification

Table summarizes the performance of common gate amplifier

SCE

112

Dept of ECE

EC6304

Electronic Circuits I

3.10 Multistage Amplifiers


In practice, we need amplifier which can amplify a signal from a very weak source such as a
microphone, to a level which is suitable for the operation of another transducer
such as loudspeaker . This is achieved by cascading number of amplifier stages, known as
multistage amplifier
1. Need for Cascading
For faithful amplification amplifier should have desired voltage gain, current gain and it should
match its input impedance with the source and output impedance with the load. Many times these
primary requirements of the amplifier can not be achieved with single stage amplifier, because of
the limitation of the transistor/FET parameters. In such situations more than one amplifier stages
are cascaded such that input and output stages provide impedance matching requirements with
some amplification and remaining middle stages provide most of the amplification.
We can say that,
When the amplification of a single stage amplifier is not sufficient, or,
When the input or output impedance is not of the correct magnitude, for a particular
application two or more amplifier stages are connected, in cascade. Such amplifier,
with two or more stages is also known as multistage amplifier.

2. Two Stage Cascaded Amplifier

Fig3.16 Cascaded amplifier


Vi1 is the input of the first stage and Vo2 is the output of second stage.
So,Vo2/Vi1 is the overall voltage gain of two stage amplifier.

SCE

113

Dept of ECE

EC6304

Electronic Circuits I

3. n-Stage Cascaded Amplifier

Fig3.17 Multistage amplifier


Voltage gain :
The resultant voltage gain of the multistage amplifier is the product of voltage gains of the
various stages.
Av = Avl Av2 ... Avn
Gain in Decibels
In many situations it is found very convenient to compare two powers on logarithmic scale rather
than on a linear scale. The unit of this logarithmic scale is called decibel (abbreviated dB). The
number N decibels by which a power P2 exceeds the power P1 is defined by

Decibel, dB denotes power ratio. Negative values of number of dB means that the power P2 is
less than the reference power P1 and positive value of number of dB means the power P2 is
greater than the reference power P1.
For an amplifier, P1 may represent input power, and P2 may represent output power.
Both can be given as

Where Ri and Ro are the input and output impedances of the amplifier respectively.Then,

SCE

114

Dept of ECE

EC6304

Electronic Circuits I

If the input and output impedances of the amplifier are equal i.e. Ri = Ro= R, then

4. Gain of Multistage Amplifier in dB


The gain of a multistage amplifier can be easily calculated if the gain of the individual stages are
known in dB, as shown below
20 log10 Av = 20 log10 Avl + 20 log10Av2 + + 20 log10 Avn
Thus, the overall voltage gain in dB of a multistage amplifier is the decibel voltage gains of the
individual stages. It can be given as
AvdB = AvldB + Av2dB + ... + AvndB
Advantages of Representation of Gain in Decibels
Logarithmic scale is preferred over linear scale to represent voltage and power gains because of
the following reasons :
In multistage amplifiers, it permits to add individual gains of the stages to calculate
overall gain.
It allows us to denote, both very small as well as very large quantities of linear, scale by
considerably small figures.
For example, voltage gain of 0.0000001 can be represented as -140 dB and voltage
gain of 1,00,000 can be represented as 100 dB.
Many times output of the amplifier is fed to loudspeakers to produce sound which is
received by the human ear. It is important to note that the ear responds to the sound
intensities on a proportional or logarithmic scale rather than linear scale. Thus use of dB
unit is more appropriate for representation of amplifier gains.
3.11 Small signal Analysis of MOSFET
Common-Source Configuration

SCE

115

Dept of ECE

EC6304

Electronic Circuits I
Fig3.17 Common-Source Configuration of MOSFET

Fig3.18 small signal model of Common-Source Configuration of MOSFET

This configuration serves as the gain stage. The disadvantage is high output impedance.
Capacitor CS is included such that the stage is connected to a current source for biasing
Common-Gate Configuration

SCE

116

Dept of ECE

EC6304

Electronic Circuits I

Fig3.18 Common-gate Configuration of MOSFET

Fig3.18 small signal model of Common-gate Configuration of MOSFET

SCE

117

Dept of ECE

EC6304

Electronic Circuits I

This amplifier provides gain and is useful when a specific (low) Rin is required. This is,
e.g., the case when the impedance needs to be matched, as with transmission lines (e.g. to 50 ).
Another application of the CG configuration is that it acts as a current buffer (current gain close
to unity, small Rin, large Rout).
Source Follower (Common-Drain Configuration)

Fig3.19 Common-drain Configuration of MOSFET

Fig3.20 small signal model of Common-drain Configuration of MOSFET

SCE

118

Dept of ECE

EC6304

Electronic Circuits I

This configuration acts as a voltage buffer. It provides no gain, but has low output
impedance. It is typically the last stage in a multi-stage amplifier.

3.12 Cascaded Amplifiers

Fig3.21 Cascaded amplifier Configuration of MOSFET

SCE

119

Dept of ECE

EC6304

Electronic Circuits I
Fig3.20 small signal model of Cascaded Configuration of MOSFET

By grouping the different factors in this expression, we can find a physical interpretation
for the cascading. This physical interpretation can be used to guide simulation or analysis of the
different stages separately, before combining them into a cascaded amplifier.

QUESTIONS
2 MARKS
1. What is meant by small signal?
2. What is the physical meaning of small signal parameter ro?
3. Write the equation for small signal condition that must be satisfied for linear amplifiers.
4. Draw the small signal equivalent circuit common source NMOS.
5. What is another name for common drain amplifier?
6. Draw the source follower amplifier circuit.
7. List the applications of MOSFET amplifiers.
8. Compare the characteristics of three MOSFET amplifier configurations.
9. Draw the small signal equivalent JFET common source circuit.
10. How does a transistor width-to-length ratio affect the small signal voltage gain of a common
source amplifier?
11. How a MOSFET can be used to amplify a time varying voltage?
12. How does body effect change the small signal equivalent of the MOSFET?
13. Why in general the magnitude of the voltage gain of a common source amplifier relatively
small?
14. What is voltage swing limitation?
15. What is the general condition under which a common gate amplifier would be used?

SCE

120

Dept of ECE

EC6304

Electronic Circuits I

16. State the general advantage of using transistors in place of resistors in integrated circuits.
17. Give one reason why a JFET might be used as an input device in a circuit as proposed to a
MOSFET.
18. What are features of cascode amplifiers?
19. What are the applications of BiCMOS?
20. Discuss one advantage of BiCMOS circuit.
16 MARKS
1. Describe the operation and analyze the basic JFET amplifier circuits.
2. Derive the small signal analysis of common source amplifier.
3. Develop a small signal model of JFET device and analyze basic JFET amplifiers.
4. Explain graphically the amplification process in a simple MOSFET amplifier circuit.
5. Describe the small signal equivalent circuit of the MOSFET and determine the values of small
signal parameters?
6. Sketch the small signal high frequency circuit of a common source amplifier & derive the
expression for a voltage gain, input & output admittance and input capacitance.
7. Sketch a simple source-follower amplifier circuit and discuss the general ac circuit
characteristics.
8. Characterize the voltage gain and output resistance of a common-gate amplifier.
9. Apply the MOSFET small signal equivalent circuit in the analysis of multistage amplifier
circuits.
10. Explain common source amplifier with source resistor and source bypass capacitor.
11. Write short notes Voltage swing limitations, general conditions under which a source
follower amplifier would be used.
12. Describe the characteristics of and analyze BiCMOS circuits.

SCE

121

Dept of ECE

EC6304

Electronic Circuits I

UNIT IV
FREQUENCY ANALYSIS OF BJT AND MOSFET AMPLIFIERS
4.1 General shape of frequency response of amplifiers
An audio frequency amplifier which operates over audio frequency range
extending from 20 Hz to 20 kHz. Audio frequency amplifiers are used in radio receivers,
large public meeting and various announcements to be made for the passengers on
railway platforms. Over the range of frequencies at which it is to be used an amplifier
should ideally provide the same amplification for all frequencies. The degree to which
this is done is usually indicated by the curve known as frequency response curve of the
amplifier.

To plot this curve, input voltage to the amplifier is kept constant and frequency of
input signal is continuously varied. The output voltage at each frequency of input signal
is noted and the gain of the amplifier is calculated. For an audio frequency amplifier, the
frequency range is quite large from 20 Hz to 20 kHz. In this frequency response, the gain
of the amplifier remains constant in mid-frequency while the gain varies with frequency
in low and high frequency regions of the curve. Only at low and high frequency ends,
gain deviates from ideal characteristics. The decrease in voltage gain with frequency is
called roll-off.
4.2 Definition of cut-off frequencies and bandwidth:
The range of frequencies can be specified over which the gain does not deviate
more than 70.7% of the maximum gain at some reference mid-frequency.

122

EC6304

Electronic Circuits I

From above figure, the frequencies f1 & f2 are called lower cut-off and upper cut-off
frequencies.
Bandwidth of the amplifier is defined as the difference between f2 & f1.
Bandwidth of the amplifier = f2 - f1
The frequency f2 lies in high frequency region while frequency f1 lies in low
frequency region. These two frequencies are also called as half-power frequencies since
gain or output voltage drops to 70.7% of maximum value and this represents a power
level of one half the power at the reference frequency in mid-frequency region.
4.3 Low frequency analysis of amplifier to obtain lower cut-off frequency:
4.3.1 Decibel Unit:
The decibel is a logarithmic measurement of the ratio of one power to another or
one voltage to another. Voltage gain of the amplifier is represented in decibels (dBs). It is
given by,
Voltage gain in dB = 20 log Av
Power gain in decibels is given by,
Power gain in dB = 10 log Ap
Where Av is greater than one, gain is positive and when Av is less than one, gain
is negative. The positive and negative gain indicates that the amplification and
attenuation respectively. Usually the maximum gain is called mid frequency range gain is
assigned a 0 db value. Any value of gain below mid frequency range can be referred as 0
db and expressed as a negative db value.
Example:
Assume that mid frequency gain of a certain amplifier is 100. Then,
Voltage gain = 20 log 100 = 40 db
At f1 and f2 Av = 100/2 = 70.7
Voltage gain at f1 = Voltage gain at f2 = 20 log 70.7 = 37 db

123

EC6304

Electronic Circuits I

Fig. Normalized voltage gain vs frequency


From above figure, it shows that the voltage gain at f1 and f2 is less than 3db of the
maximum voltage gain. Due to this the frequencies f1 and f2 are also called as 3 db
frequencies. At f1 & f2 power gain drops by 3 db. For all frequencies within the
bandwidth, amplifier power gain is at least half of the maximum power gain. This
bandwidth is also referred to as 3 db bandwidth.
4.3.2 Significance of octaves and decades:
The octaves and decades are the measures of change in frequency. A ten
times change in frequency is called a decade. Otherwise, an octave corresponds to a
doubling or halving of the frequency.
Example:
An increase in frequency from 100 Hz to 200 Hz is an octave.
A decrease in frequency from 100 kHz to 50 kHz is also an octave.

Fig. Frequency response showing significance of decade and octave


At lower and higher frequencies the decrease in the gain of amplifiers is often indicated
in terms of db/decades or db/octaves. If the attenuation in gain is 20 db for each decade,
then it is indicated by line having slope of 20 db/decade. A rate of -20 db/decade is

124

EC6304

Electronic Circuits I

approximately equivalent to -6db/octave. A rate of -40 db/decade is approximately


equivalent to -12db/octave.
4.3.3 Midband gain:
It is defined as the band of frequencies between 10 f1 and 0.1 f2. It is denoted as
midband gain or Amid.
The voltage gain of the amplifier outside the midband is approximately given as,

In midband,
Midband:
Below the midband,
As a result, the equation becomes,
Below midband:

Above midband,
As a result, the equation becomes,
Above midband:

Problem:
For an amplifier, midband gain = 100 and lower cutoff frequency is 1 kHz. Find the gain
of an amplifier at frequency 20 Hz.
Solution:
Below midband:

125

EC6304

Electronic Circuits I

4.4 Effect of various capacitors on frequency response:


4.4.1 Effect of coupling capacitors:
The reactance of the capacitor is Xc = 1/2fc
At medium and high frequencies, the factor f makes Xc very small, so that all
coupling capacitors behave as short circuits. At low frequencies, Xc increases. This
increase in Xc drops the signal voltage across the capacitor and reduces the circuit gain.
As signal frequencies decrease, capacitor reactance increase and gain continues to fall,
reducing the output voltage.
4.4.2 Effect of Bypass capacitors:
At lower frequencies, bypass capacitor CE is not a short. So emitter is not at ac
ground. Xc in parallel with RE creates an impedance. The signal voltage drops across this
impedance reducing the circuit gain.
4.4.3 Effect of internal transistor capacitances:
At high frequencies, coupling and bypass capacitors act as short circuit and do
not affect the amplifier frequency response. At high frequencies, internal capacitances,
commonly known as junction capacitances. The following figure shows the junction
capacitances for both BJT and FET. Incase of BJT, Cbe is the base emitter junction
capacitance and Cbc is the base collector junction capacitance. Incase of FET, Cgs is the
internal capacitance between gate and source and Cgd is the internal capacitance between
gate and drain.

Fig. Internal transistor capacitances


4.5 Miller Theorem:
In transistor amplifiers, it is necessary to split the capacitance between input
and output. It can be achieved by using millers theorem. In the following figure, Av

126

EC6304

Electronic Circuits I

represents absolute voltage gain of the amplifier at midrange frequencies and C


represents either Cbc (incase of BJT) or Cgd (incase of FET).

Fig. Splitting of capacitor using Millers theorem


4.6 Low frequency analysis of BJT:

Fig. Typical RC coupled common emitter amplifier


From above figure, it has three RC networks that affect its gain as the frequency is
reduces below midrange. These are,
1. RC network formed by the input coupling capacitor C1 and input impedance of
the amplifier.
2. RC network formed by the output coupling capacitor C2, resistance looking in at
the collector and load resistance.
3. RC network formed by the emitter bypass capacitor CE and resistance looking in
at the emitter.
Input RC network:
The following figure shows the input RC network formed by C1 and the
input impedance of the amplifier.
The resistance value is Rin = R1 || R2 || Rin(base)

127

EC6304

Electronic Circuits I

Applying voltage divider rule,

A critical point in the amplifier response is generally accepted to occur when the output
voltage is 70.7 % of the input. At critical point,

At this condition, Rin = Xc1


Overall gain is reduced due to attenuation provided by the input RC network. The
reduction in overall gain is given by,

The frequency fc at this condition is called lower critical frequency and it is given by,

If the resistance of input source is taken into account the above equation becomes,

The phase angle in an input RC circuit is expressed as

Output RC network:

The above figure shows the output RC network formed by C2, resistance looking in at the
collector and load resistance.

128

EC6304

Electronic Circuits I

The critical frequency for this RC network is given by,

The phase angle in output RC network is given as,

Bypass network:

From above figure,

is the resistance looking in at the emitter. It is derived as follows,


R= (Vb / Ib) + hie /

Where RTH = R1 || R2 || Rs. It is the thevenins equivalent resistance looking from the base
of the transistor towards the input.
The critical frequency for the bypass network is

Problem:
Determine the low frequency response of the amplifier circuit shown in the figure.

129

EC6304

Electronic Circuits I

Solution:
It is necessary to analyze each network to determine the critical frequency of the
amplifier.

The above analysis shows that the input network produces the dominant lower critical
frequency. Then the low frequency response of the given amplifier is shown in the
following figure.

130

EC6304

Electronic Circuits I

4.7 Low frequency analysis of FET amplifier:

From above figure, it has two RC networks that affect its gain as the frequency is reduced
below midrange. These are,
1. RC network formed by the input coupling capacitor C1 and input impedance of
the amplifier.
2. RC network formed by the output coupling capacitor and the output impedance
looking in at the drain.
`Input RC network:
Lower critical frequency of this network is given as,

The value of Rin(gate) can be determined from the data sheet as follows:

131

EC6304

Electronic Circuits I

The phase shift in low frequency input RC circuit is = tan-1 (XC1 / Rin )
Output RC network:
Lower critical frequency of this network is given as,

The phase shift in low frequency output RC circuit is = tan-1 (XC2 / RD + RL)
4.8 Hybrid - equivalent circuits of BJTs:
At low frequencies, we can analyze the transistor using h-parameters. But
for high frequency, analysis of h-parameter model is not suitable for following
reasons.
1. The values of h-parameters are not constant at high frequencies. So it is necessary
to analyze transistor at each and every frequency which is impractical.
2. At high frequency h-parameters become complex in nature.
Due to the above reasons, modified T model and hybrid models are used for high
frequency analysis of the transistor. These models give a reasonable compromise
between accuracy and simplicity to do high frequency analysis of the transistor.
4.4.1 Hybrid - common emitter transistor model:
Common emitter circuit is most important practical configuration and this
is useful for the analysis of transistor using hybrid - model. The following figure
shows the hybrid - model for a transistor in CE configuration. For this model, all
parameters are assumed to be independent of frequency. But they may vary with the
quiescent operating point.

Fig. Hybrid - model for a transistor in CE configuration


4.8.1 Elements in hybrid model:
Cbe and Cbc : Forward biased PN junction exhibits a capacitive effect called diffusion
capacitance. This capacitive effect of normally forward biased base-emitter junction of
the transistor is represented by Cbe or Ce. The diffusion capacitance is connected between
b and e represents the excess minority carrier storage in the base.
The reverse bias PN junction exhibits a capacitive effect called transition capacitance.
This capacitive effect of normally reverse biased collector base junction of the transistor
is represented by Cbc or Cc.

132

EC6304

Electronic Circuits I

rbb: The internal node b is physically not accessible bulk node b represents external base
terminal.
rbe: It is the portion of the base emitter which may be thought of as being in series with
the collector junction. This establishes a virtual base b for junction capacitances to be
connected instead of b.
rbc: Due to early effect, varying voltages across collector to emitter junction results in
base-width modulation. A change in the effective base-width causes the emitter current to
change. This feedback effect between output and input is taken into account by
connecting gbc or rbc between b and c.
gm: Due to small changes in voltage Vbe across emitter junction, there is excess minority
carrier concentration injected into the base which is proportional to Vbe. So resulting
small signal collector current with collector shorted to the emitter is also proportional to
Vbe.
gm is also called as transconductance and it is given as,

rce: It is the output resistance. It is also the result of early effect.


4.4.1.2 Hybrid parameter values:
The following table shows the typical values for hybrid - parameters at room
temperature and for Ic = 1.3mA.
Parameter
Meaning
Value
gm
rbb
rbe or gbe
rbc or gbc

rce or gce
Ce
Cc

Mutual conductance
Base spreading resistance
Resistance between b and e
Conductance between b and e
Resistance of reverse biased PN junction
between base and collector
Conductance of reverse biased PN junction
between base and collector
Output resistance between c and e
Conductance between c and e
Junction capacitance between b and e
Junction capacitance between base and
collector

4.8.2 Hybrid conductances:


4.8.2.1 Transistor Transconductance gm:

133

50mA/V
100
1k
1m mho
4M
0.25*10-6 mho
80k
12.5*10-6 mho
100pF
3pF

EC6304

Electronic Circuits I

Let us consider a p-n-p transistor in CE configuration with Vcc bias in the collector circuit
as shown in the above figure.
Transconductance gm is given as,

The collector current in active region is given as,

134

EC6304

Electronic Circuits I

For Ic = 1.3mA, gm = 0.05mho or 50 mA/V. For Ic = 7.8mA, gm = 0.3mho or 300mA/V.


These values are much larger than the transconductances obtained with FETs.
4.8.2.2 Input Conductance gbe:

First consider h-parameter model for CE configuration. Applying KCL to output circuit,

Making Vce = 0, the short circuit current gain hfe is defined as,

135

EC6304

Electronic Circuits I

Substituting the value of IC / Ib,

4.8.2.3 Feedback Conductance gbc:


Let us consider h-parameter model for CE configuration with input open circuit
(Ib = 0), Vi is given as,

Fig. Hybrid model for CE configuration


With Ib = 0, Vce is given as,

136

EC6304

Electronic Circuits I

Vce =

I1 =
Voltage between b and e, Vbe can be given as,
Vbe =

With Ib = 0,
Vi = Vbe

Substituting the value of Vi,

hreVce =

rbc =

Substituting the value of rbe,

137

EC6304

Electronic Circuits I

4.8.2.4.Base Spreading Resistance rbb:

Substituting the value of rbe,

4.8.2.5 Output Resistance gce:


Using h-parameters output conductance is given as,

Applying KCL to the output circuit,

1/rce = gce =
Relation between hybrid- and h-parameters:

138

EC6304

Electronic Circuits I

4.4.3 Hybrid capacitances:

Ce = gm
-------2ft
4.4.4 CE short circuit current gain using hybrid- model:

Fig. Hybrid- model for a single transistor with a resistive load RL

139

EC6304

Electronic Circuits I

The current gain for the circuit is,

Fig. Frequency vs current gain

f (Cutoff frequency):

140

EC6304

Electronic Circuits I

It is the frequency at which the transistor short circuit CE current gain drops by
3dB or 1/2 times from its value at low frequency. It is given as,

f (Cut-off frequency):
It is the frequency at which the transistor short circuit CB current gain drops
by 3dB or 1/2 times from its value at low frequency.
The current gain for CB configuration is given as,

Parameter fT:
It is the frequency at which short circuit CE current gain becomes unity.
At f = fT,

141

EC6304

Electronic Circuits I

The ratio of fT / f is quite large compared to 1.


fT = gm / 2Ce
Problem:
Short circuit CE current gain of transistor is 25 at a frequency of 2MHz if f = 200 kHz.
Calculate (i) fT (ii) hfe (iii) Find |Ai| at a frequency of 10 MHz and 100 MHz.
Solution:

4.4.5 Current gain with resistive load:

For further simplification,


At output circuit value of Cc can be calculated as,

142

EC6304

Electronic Circuits I

Fig. Simplified hybrid model for CE with RL


Z = Vbe
------Ib

Ai =

fH is the frequency at which the transistor gain drops by 3dB or 1/2 times from its value
at low frequency. It is given as,
143

EC6304

Electronic Circuits I

4.8.6 Current gain including source resistance:

Ais at low frequency =

= - hfe RS
_______
Rs + hie
144

EC6304

Electronic Circuits I

4.8.7 Voltage gain including source resistance:

4.8.8 Cutoff frequency including source resistance:

For RL = 0,

145

EC6304

Electronic Circuits I

4.8.9 Gain Bandwidth Product:


4.8.9.1 Gain Bandwidth Product for Voltage:

= RL
fT
-------- * -------Rs + rbb
1 + 2fTCCRL
4.8.9.2 Gain Bandwidth Product for current:

146

EC6304

Electronic Circuits I

4.9 High frequency analysis of FET


4.9.1 Common source amplifier at high frequencies:

Voltage gain:

Input Admittance:

147

EC6304

Electronic Circuits I

Input capacitance (Miller Effect):

This increase in input capacitance Ci over the capacitance from gate to source is called
Miller effect.
This input capacitance affects the gain at high frequencies in the operation of cascaded
amplifiers. In cascaded amplifiers, the output from one stage is used as the input to a
second amplifier. The input impedance of a second stage acts as a shunt across output of
the first stage and Rd is shunted by the capacitance Ci.
Output Admittance:
From above figure, the output impedance is obtained by looking into the drain with the
input voltage set equal to zero. If Vi = 0 in figure, rd , Cds and Cgd in parallel. Hence the
output admittance with RL considered external to the amplifier is given by,
4.9.2 Common Drain Amplifier at High Frequencies:

Fig. Common Drain Amplifier Circuit & Small signal equivalent circuit at high
frequencies
Voltage gain:
The output voltage Vo can be found from the product of the short circuit
and the impedance between terminals S and N. Voltage gain is given by,

148

EC6304

Electronic Circuits I

Input Admittance:
It is given by,

Input Admittance Yi can be obtained by applying Millers theorem to Cgs.

Output Admittance:
given by,

Output Admittance Yo with Rs considered external to the amplifier, it is

At low frequencies, output resistance Ro is given by,

4.9.3 Frequency Response of Common Source Amplifier:

149

EC6304

Electronic Circuits I

Let us consider a typical common source amplifier as shown in the above figure.

From above figure, it shows the high frequency equivalent circuit for the given amplifier
circuit. It shows that at high frequencies coupling and bypass capacitors act as short
circuits and do not affect the amplifier high frequency response. The equivalent circuit
shows internal capacitances which affect the high frequency response.
Using Miller theorem, this high frequency equivalent circuit can be further simplified as
follows:
The internal capacitance Cgd can be splitted into Cin(miller) and Cout(miller) as shown in the
following figure.

150

EC6304

Electronic Circuits I

Where

From simplified high frequency equivalent circuit, it has two RC networks which affect
the high frequency response of the amplifier. These are,
1. Input RC network
2. Output RC network
Input RC network:

Fig. Input RC network


From above figure,

This network is further reduced as follows since Rs << RG

151

EC6304

Electronic Circuits I

Fig. Reduced input RC network


The critical frequency for the reduced input RC network is,

Output RC network:

Fig. Output RC network


The critical frequency for the above circuit is,

fc =
It is not necessary that these frequencies should be equal. The network which has lower
critical frequency than other network is called dominant network.

152

EC6304

Electronic Circuits I

The phase shift in high frequency is


Problem:
Determine the high frequency response of the amplifier circuit shown in the following
figure.

Solution:
Before calculating critical frequencies it is necessary to calculate mid frequency gain of
the given amplifier circuit. This is required to calculate Cin(miller) and Cout(miller).
Av = -gmRD
Here RD should be replaced by RD || RL
Av=

Cin(miller)=

Cout(miller)=

Cgs = Ciss Crss = 4pF


Now analyze the input and output network for critical frequency,

153

EC6304

Electronic Circuits I

fc(input)

The above analysis shows that the output network produces the dominant higher critical
frequency. High frequency response of the given amplifier is shown in the following
figure.

Fig. High frequency response of the amplifier


4.10 Frequency Response of Multistage Amplifiers:
The bandwidth of multistage amplifier is always less than that of the
bandwidth of single stage amplifier.
4.10.1 Overall Lower Cut-off Frequency of Multistage Amplifier:

154

EC6304

Electronic Circuits I

Let us consider the lower 3dB frequency of n identical cascaded stages as


fL (n). It is the frequency for which the overall gain falls to 1/2 (3dB) of its midband
value.

Squaring on both the sides &

Taking square root on both the sides,

155

EC6304

Electronic Circuits I

4.10.2 Overall Higher Cut-off Frequency of Multistage Amplifier:


Let us consider the upper 3dB frequency of n identical cascaded stages as
fH(n). It is the frequency for which the overall gain falls to 1/2 (3dB) of its midband
value.

Squaring both the sides,

Taking nth root on both the sides,


21/n = 1 + [ fH(n)/fH ]2
21/n -1 = [ fH(n)/fH ]2
Taking square root on both the sides,
21/n -1 = fH(n)/fH
fH(n) = fH 21/n -1
In multistage amplifier fL(n) is always greater than fL and fH(n) is always less than fH. So
the bandwidth of multistage amplifier is always less than single stage amplifier.

4.11 Rise time and its Relation to Upper Cut-off Frequency:


4.11.1 Upper 3 dB Frequency:

156

EC6304

Electronic Circuits I

When a step input is applied, amplifier high frequency RC network


prevent the output from responding immediately to the step input. The output voltage
starts from zero and rises towards the steady state value V, with a time constant R2C2 as
shown in the above figure.
The output voltage is given by,
The time required for Vo to reach one-tenth of its final value is calculated as,

The difference between these two values is called as rise time tr of the circuit. The rise
time is given as,

The Upper 3dB frequency is given as,


Upper 3dB frequency in terms of rise time is given as,

157

EC6304

Electronic Circuits I

From above equation, it shows that upper 3dB frequency is inversely proportional to the
rise time tr.
4.12 Relation between Bandwidth and Rise time:
The frequency range from fL to fH is called bandwidth of the amplifier. Usually fL << fH.
So we can approximate the equation for bandwidth as follows,

The relation between rise time with upper frequency as,

So we can relate bandwidth with rise time as follows,

Problem:
If the rise time of BJT is 35ns, what is the bandwidth that can be obtained using this BJT.
Solution:
tr = 0.35 / f2 = 0.35 / BW
BW = 0.35 / tr = 0.35 / (35 * 10-9) = 10MHz
4.9 Sag and its Relation to Lower Cut-off Frequency:
The amplifier low frequency RC network consists of coupling and bypass
capacitors make amplifier output to decrease with large time constant. As a result, the
output voltage has sag or tilt associated with it as shown in the following figure.

The tilt or sag in time t1 is given by,

The lower 3 dB frequency can be determined from the output response by carefully
measuring the tilt.
The lower 3 dB frequency is given as,

158

EC6304

Electronic Circuits I

So, the lower 3 dB frequency can be represented in terms of tilt is measured from the
following figure.

= fL / f * 100
fL = Pf
____
100
Problem 1:
For a circuit shown in the following figure, calculate percentage tilt. Assume approximate
h-parameter circuit for the transistor.

Solution:
159

EC6304

Electronic Circuits I

Equivalent h-parameter circuit for the given circuit is,

Here R1 = RC + RL = 4K + 2K
= 6K

fL =

fL =
We know that, P = (fL / f) * 100
Assuming
f = 200 Hz
P = ( * 2.65 / 200) * 100
P = 4.1%

QUESTIONS
2 MARKS
1. Draw the frequency response curve of an amplifier.
2. What is the bandwidth of an amplifier?
3. Define rise time.
4. What kind of techniques required increasing the input impedance?
5. Give relation between rise time and bandwidth.
6. Give the main reason for the drop in gain at the low frequency region & high
frequency region.
7. If the rise time of BJT is 35nS, what is the bandwidth that can be obtained using this
BJT?
8. For an amplifier, mid band gain is 100 & lower cutoff frequency is 20KHz. Find the
gain of an amplifier at frequency 20Hz.
9. For an amplifier, 3dB gain is 200 & higher cutoff frequency is 20KHz. Find the gain of
an amplifier at frequency 100KHz.
10. Why common base amplifier is preferred for high frequency signal when compared to
CE amplifier?
11. Draw the hybrid equivalent circuit of BJTs.
12. What is the difference between small signal equivalent & hybrid equivalent circuit.
160

EC6304

Electronic Circuits I

13. What is high frequency effect?


14. What are the causes for occurrence of upper cutoff frequency in BJT?
15. What is Millers effect? What is gain bandwidth product?
16. Give equation of overall lower and upper cutoff frequency of multistage amplifier.
17. What is significance of octaves and decades in frequency response?
18. What are the causes for occurrence of upper cutoff frequency in BJT?
19. What is the major contribution to the Miller capacitance in a MOSFET?
20. Define cut off frequency for a MOSFET.
16 MARKS
1. With neat sketch explain hybrid CE transistor model. Derive the expression for
various components in terms of h parameters.
2. Discuss the frequency response of multistage amplifiers. Calculate the overall upper &
lower cutoff frequencies.
3. Discuss the low frequency response & the high frequency response of an amplifier.
Derive its cutoff frequencies.
4. Discuss the terms rise time and sag.
5. Write short notes on high frequency amplifier.
6. Derive the gain bandwidth for high frequency FET amplifiers.
7. Derive the expression for the CE short circuit current gain of transistor at high
frequency
8. What is the effect of Cbe on the input circuit of a BJT amplifier at High frequencies?
Derive the equation for gm which gives the relation between gm, Ic and temperature.
9. Explain the high frequency analysis of JFET with necessary circuit diagram & gain
bandwidth product.
10. Discuss the frequency response of MOSFET CS amplifier.
11. Determine the bandwidth of CE amplifier with the following specifications.
R1=100k, R2=10k, RC=9k, RE=2k, C1= C2=25F, CE=50F, rbb=100,
rbe=1.1K, hfe=225, Cbe=3pF and Cbc=100pF.
12. At Ic=1mA & VCE=10v, a certain transistor data shows Cc=Cbc=3pF, hfe=200, &
T=-500M rad/sec. Calculate gm, rbe, Ce=Cbe & .

161

EC6304

ElectronicCircuitsI

UNIT -V IC MOSFET AMPLIFIERS


5.1 Integrated Circuit Amplifier
An integrated circuit amplifier is a compactly packaged collection of active and passive
devices that may boost the voltage or current level of a signal. The active components are
transistors, three-terminal semiconductor devices that are capable of current gain, wherein a
small change in current produces a pro-rated change in the integrated circuit amplifier output.
5.1.1 IC Design Philosophy
Integrated circuits
More and more electronics circuits are integrated in a single chip
More complicated functions
Smaller size and lower cost
Suitable for mass-production
Implementation cost depends on device area rather than device count
Large/moderate-value resistors should be avoided
Larger/moderate-value capacitors should be avoided
Preferable to use transistors due to chip-area consideration
Design Philosophy
The design philosophy for ICs is different from that of discrete-component circuits
Realize as many of functions as possible by using transistors only
Rely on device matching or size ratios for circuit design
Active loads are typically used for amplifier designs
5.2 IC Biasing - Basic MOSFET current source
Using the transistors geometries (W/L)1and (W/L)2as design parameters, we want to
create a DC current Io, as long as transistor Q2is in Saturation Mode The Drain of transistor Q2is
connected to a load circuit, not necessarily a resistor. The load circuit typically involves one or
more additional MOSFET transistors. Depending on the load, transistor Q2may be in any of
three modes: Saturation, Triode or Cutoff. Of course, only when it is in Saturation it will work
as originally planned (DC current source) The current Io always goes away from the load circuit
and into Q2. Such a DC current source is said to be a sink.
MOSFET current mirror is widely used for ICs with good device matching.
Q1 and Q2 are identical and in saturation:

Fig5.8: MOSFET Current Source

SCE162DeptofECE

EC6304

ElectronicCircuitsI

Current gain or current transfer ratio:

Effect of VO on IO
Current mismatch due to channel-length modulation

Fig5.8: VI characteristics of NMOS current source


5.4 MOS current-steering circuits
A current mirror may consist of many MOSFET current sources This circuit is particularly
useful in integrated circuit design, where one resistor R is used to make multiple current sources
the current mirror simply ensures that the gate to source voltages of each transistor is equal to
the gate to source voltage of the reference
Current sink: pulls a dc current from a circuit
Current source: pushes a dc current into a circuit
All transistors should be operated in saturation
Current mismatch exists for a finite VA (channel-length modulation)

SCE163DeptofECE

EC6304

ElectronicCircuitsI

Fig5.8: MOS current-steering circuits

VGSref = VGS 1 =VGS 2 =VGS 3 = "


ref
Therefore, if each transistor is identical (i.e., K ref = K1 = " , andVt
=Vt 1 =Vt 2 = " )
then:

Iref = Kref (VGSref Vt ref )

= Kn (VGSn Vtn ) = IDn


2

if the MOSFETS are not identical. Specifically, consider the case where

Vtn = Vt ref ).

we know that VGSn

=VGSref

now be:

still, even when Kn

K ref .

Kn K ref

Thus, the drain current

IDn

will

IDn = Kn (VGSn Vtn )

= Kn VGSref Vt ref
I
= Kn ref
K
ref
K
= n
K
ref

Iref

I ref
(i.e., K1 = 2 K ref ), then ID 1 will be twice as large as

The drain current is a scaled value of

I ref

if K1 is twice that of K ref


(i.e.,

I1 = 2 I ref ).

SCE164DeptofECE

(but

EC6304

ElectronicCircuitsI

From the standpoint of integrated circuit design, we can change the value of K by
modifying the MOSFET channel width-to-length ratio (W/L) for each transistor.

( )
( )

1 k W
Kn
2
L
=
1 kW
Kref
2
L

ref

W )
(
L
=
(W L )

ref

5.5 NMOS Current Sources and Sinks


Characteristics of Current Sources
A well controlled output current
Supplied current does not depend on output voltage and has High Norton
Resistance
Connect a voltage source to the gate of another MOSFET:

Fig5.9:NMOS current Source

Hence, IREF depends on the supply voltage VDD. If the supply is a battery or similar
device, then this will change over time, causing the reference current to also vary with time.
IOUT scales with IREF by W/L ratios of two MOSFETs
SCE165DeptofECE

EC6304

ElectronicCircuitsI

Fig5.10:I-V characteristics of NMOS current source


5.6 PMOS Current Source
NMOS current source sinks current to ground
PMOS current source sources current from positive supply

Fig5.11 :PMOS Current Mirror:


Same operation and characteristics as NMOS voltage source. PMOS needs to be larger to
attain the same Rout.
5.7 MOSFET Differential amplifier

SCE166DeptofECE

EC6304

ElectronicCircuitsI

SCE167DeptofECE

EC6304

ElectronicCircuitsI

SCE168DeptofECE

EC6304

ElectronicCircuitsI

SCE169DeptofECE

EC6304

ElectronicCircuitsI

Problem
1.Find the CMRR for the circuit with given data.

SCE170DeptofECE

EC6304

ElectronicCircuitsI

2 MARKS
1. What are the basic processes in integrated circuit fabrication?
2. Define common mode rejection ration? What is the ideal value?
3. Sketch the DC transfer characteristics of a MOSFET differential amplifier.
4. What are the advantages of an active load?
5. What is the impedance seen looking into a simple active load?
6. How the reference portion of the circuit can be designed with MOSFETs only.
7. How should a MOSFET be biased so as to operate as a stable current source?
8. Draw the circuit of MOSFET differential amplifier with active load.
9. What is the need for MOSFET differential amplifier with cascode active load?
10. What is meant by matched transistors?
11. Define common mode and differential mode input resistance and voltages.
12. What are the limiting factors for the maximum current in MOSFET?
13. Define enhancement and depletion mode of MOSFET.
14. Define saturation and non- saturation bias regions.
15. How do you prove that a MOSFET is biased in the saturation region?
16. Draw MOSFET cascode current source circuit.
17. What is another name of two transistor current source?
18. Draw the two transistor MOSFET current source.
19. What is Widlar current source
20. What is cascode current mirror?
SCE171DeptofECE

EC6304

ElectronicCircuitsI

16 MARKS
1. Describe the operation of an NMOS amplifier with either an enhancement load, a
depletion load, or a PMOS load.
2. Explain the basic MOSFET two transistor current circuits and discuss its operation.
3. Draw the MOSFET cascode current source circuit, explain and discuss the
advantage of this design.
4. Sketch and describe the advantages of a MOSFET cascode current source used
with a MOSFET differential amplifier.
5. Explain CMOS differential amplifier and derive CMRR.
7. Draw a Widlar current source and explain the operation.
8. Describe the operation of a PMOS amplifier with an enhancement load, a depletion
load.
9. Explain the CMOS common source and source follower with neat diagram.
10. Explain the large signal behavior of MOSFETs and compare the operating regions of Bipolar
and MOS transistors.
11. Discuss the operation of active load and discuss the advantages of MOSFET cascode current
circuit.
12. Explain in detail about CMOS common source and source follower with neat diagram.

ALL THE BEST

SCE172DeptofECE

EC6304

ElectronicCircuitsI

UNIT I - BIASING OF DISCRETE BJT AND MOSFET


PART A
1. Define operating point. (May,15)

The zero signal values of Ic & Vce are known as operating point. It is also
called so because the variations of Ic and Vce take place about this point, when the signal
is applied.
2. Why the operating point is selected at the centre of the active region?
The operating point of a transistor is kept fixed usually at the center of the active region
in order that the input signal is well amplified. If the point is fixed in the saturation region or
the cut off region the positive and negative half cycle gets clipped off respectively.
3. What is DC load line?

It is the line on the output characteristics of a transistor circuit which gives the
values of Ic & Vce corresponding to zero signal (or) DC Conditions.
4. What is the need for biasing in transistor amplifier?

The proper flow of zero signal collector current and the maintenance of proper
collector emitter voltage during the passage of signal is known as transistor biasing.
When a transistor is biased properly, it works efficiently and produces no distortion in
the output signal and thus operating point can be maintained stable.
5. What are the factors to be considered to design a biasing circuit? (May,15)

9 It should ensure proper zero signal collector current.


9 The emitter base junction must be forward biased and collector base junction must be
reversing biased.
9 The transistor should be operated in the middle of the active region or operation point
should be fixed at the centre of the active region.
9 The operating point should be made independent of the transistor parameters (such as ).
9 It should ensure that VCE does not fall below 0.5 V for Ge transistors and 1 V for
9 silicon transistors at any instant.
6. List out different type of biasing.

Voltage divider bias


Fixed bias
Emitter feedback bias
Collector feedback bias

7. Define stability factor of an amplifier. What is ideal value?

The rate of change of collector current IC w.r.t. the collector leakage current *ICO at constant
and IB is called stability factor i.e.
Stability factor, S = dIC / dIco
dI at constant IB and

SCE173DeptofECE

EC6304

8. What is thermal run away in a transistor?

ElectronicCircuitsI

(Nov/Dec 2006) (Nov/Dec 2008)


The collector current, being equal increases with increase in temperature. This leads to
increased power dissipation with further increase in temperature. .Being accumulative process it
can lead to thermal runaway resulting in burn out of transistor. Self destruction of an unstabilized transistor is called thermal runaway.
9. Why thermal runaway is not there in FETs?

The FET has a positive temperature coefficient of resistivity. In FET, as temperature


increases its drain resistance also increases, reducing the drain current. Thus, unlike BJT, thermal
runaway does not occur with FET.
10. What are the advantages and disadvantages of fixed bias circuits?

Merits:
It is simple to shift the operating point anywhere in the active region by merely changing
the base resistor (RB).
A very small number of components are required.
Demerits:
The collector current does not remain constant with variation in temperature or power
supply voltage. Therefore the operating point is unstable.
Changes in Vbe will change IB and thus cause RE to change. This in turn will alter the gain
of the stage.
When the transistor is replaced with another one, considerable change in the value of
can be expected. Due to this change the operating point will shift.
For small-signal transistors (e.g., not power transistors) with relatively high values of
(i.e., between 100 and 200), this configuration will be prone to thermal runaway. In
particular, the stability factor, which is a measure of the change in collector current with
changes in reverse saturation current, is approximately +1. To ensure absolute stability
of the amplifier, a stability factor of less than 25 is preferred, and so small-signal
transistors have large stability factors.
11. How self-bias circuit is used as constant current source?

In the self bias circuit if Ic tends to increase because of ICO has increasing as a
result of temperature, the current in RE increases. As consequences of the increase in
voltage drop across RE that provides negative feedback, the base current is decreased.
Hence constant IC value is maintained in the self bias circuit.
12. How FET is known as Voltage variable resistor?

In the region before pinch off, where VDS is small, the drain to source resistance rd can
be controlled by the bias voltage VGS. Therefore FET is useful as voltage variable
resistor (VVR) or Voltage dependent Resistor (VDR)

SCE174DeptofECE

EC6304

ElectronicCircuitsI

UNIT II - BJT AMPLIFIERS


PART A
1. What are the advantages of Representation of Gain in Decibels.
Logarithmic scale is preferred over linear scale to represent voltage and power gains because of
the following reasons :
In multistage amplifiers, it permits to add individual gains of the stages to calculate
overall gain.
It allows us to denote, both very small as well as very large quantities of linear, scale by
considerably small figures.
For example, voltage gain of 0.0000001 can be represented as -140 dB and voltage
gain of 1,00,000 can be represented as 100 dB.
Many times output of the amplifier is fed to loudspeakers to produce sound which is
received by the human ear. It is important to note that the ear responds to the sound
intensities on a proportional or logarithmic scale rather than linear scale. Thus use of dB
unit is more appropriate for representation of amplifier gains.
2. What is the coupling schemes used in multistage amplifiers? (May,10)
In multistage amplifier, the output signal of preceding stage is to be coupled to the input
circuit of succeeding stage. For this interstage coupling, different types of coupling elements can
be employed.
These are :
1. RC coupling
2. Transformer coupling
3. Direct coupling
3. Define Common Mode Rejection Ratio. (Nov,09)
CommonModeRejectionRatioisthefigureofmeritofadifferentialamplifiertoreject
commonmodesignalandisgivenby,

4. What does bootstrapping mean? Why bootstrapping is done in a buffer amplifier?


(Nov, 10)
In the emitter follower amplifier AV tends to unity. If a resistor is connected between input and
output of the emitter follower, the change in the voltage at one end of the resistor changes the
voltage at the other end of the resistor by same value. It is as if resistor is pulling itself up by its
bootstraps. Such effect is known as boot strapping.

SCE175DeptofECE

EC6304

ElectronicCircuitsI

5. Draw the Darlington emitter follower circuit. (May,14,13)

6. How can a DC equivalent circuit of an amplifier be obtained?


The analysis of transistor circuits for small signal behaviour can be made by following simple
guidelines. These guidelines are,
Draw the actual circuit diagram
Replace coupling capacitors and emitter bypass capacitor by short circuit
Replace D.C. source by a short circuit
Mark the points B, E, C on the circuit diagram and locate these points as the start of the
equivalent circuit
Replace the transistor by its h-parameter model
7. State Millers Theorem. (May,15)
It states that the effect of resistance Z on the input circuit is a ratio of input voltage to the
current which flows from the input to the output.
Z1 =
It states that the effect of resistance Z on the output circuit is the ratio of output
voltage to the current which flows from the output to input.

Z2 =
8. Define i) Differential gain ii) Common mode gain
The gain with which differential amplifier amplifies the difference between two input
signals is called differential gain of the differential amplifier denoted as A D. The gain with
which it amplifies the common mode signal to produce the output is called common mode gain
of the differential amplifier denoted as A C.
9. What are practical limitations in selecting very high R E?
1. Large R E needs higher biasing voltage to set the operating point of the transistors.
2. This increases the overall chip area. Hence practically R E can not be selected very
high.
SCE176DeptofECE

EC6304

ElectronicCircuitsI

10.Whatarethelimitationsofhparameters?
Thehparametershasthefollowinglimitations,
a.Theaccuratecalculationofhparametersisdifficult.
b.Atransistorbehavesasatwoportnetworkforsmallsignalsonly,hencehparameters
canbeusedtoanalyzeonlythesmallsignalamplifiers.
11.WhataretheadvantagesofDarlingtonamplifier?
ADarlingtontransistorconnectionprovidesatransistorhavingaverylargecurrentgain,
typicallyafewthousand.ThemainfeaturesoftheDarlingtonconnectionisthatthecomposite
transistor acts as a single unit with a current gain that is the product of current gains of the
individualtransistors.
D=12
D=Darlingtonconnectioncurrentgain
1and2Currentgainofthetransistors1&2intheDarlingtonpair
12. Methods of coupling multistage amplifiers
RC coupling
Transformer coupling
Direct coupling
13. Features of differential amplifier.
High differential voltage gain
Low common mode gain
High CMRR
Two input terminals
High input impedance
Large bandwidth
Low offset voltages and currents
Low output impedance
14. List the configuration of differential amplifiers.
Dual input, balanced output differential amplifier
Dual input, unbalanced output differential amplifier
Single input, balanced output differential amplifier
Single input, unbalanced output differential amplifier
15. State Bisection Theorem. (Nov, 12)
A particular network which has mirror symmetry with respect to an imaginary
line. If the entire network is denoted as N then it can be divided into two half networks N/2 about
the line of symmetry is called bisection theorem or Bartletts bisection theorem.
16. Methods of improving CMRR
To improve the CMRR, the common mode gain Ac must be reduced. The common mode
gain Ac approaches zero as RE tends to infinity. This is because RE introduces a negative
feedback in the common mode operation which reduces the common mode gain Ac. Thus higher
SCE177DeptofECE

EC6304

ElectronicCircuitsI

the value of RE, lesser is the value of Ac and higher is the value of CMRR. The differential gain
Ad is not dependent on RE
17. What are the other methods to improve CMRR without RE?
Constant current bias method
Current mirror circuit.
18. List the advantage of current mirror circuit?
Provides very high emitter resistance RE.
Requires fewer components than the constant current bias.
Simple to design
Easy to fabricate.
With properly matched transistors, collector current thermal stability is
achieved.
19. Draw the small signal equivalent circuit of CE amplifier.

20. Define Miller effect input capacitance.[Dec-2006, Dec2007, May-2008]


For any inverting amplifier, the input capacitance will be increased by a miller effect
capacitance, sensitive to the gain of the amplifier and the inter electrode capacitance connected
between the input and output terminals of the active device. CMi = (1- AV) Cf CM0 = Cf Cf =
Inter electrode capacitance between input and output.

UNIT III - JFET AND MOSFET AMPLIFIERS


PART A
1. State the reason for fall in gain at low frequencies.
The coupling capacitance has very high reactance at low frequency. Therefore it will
allow only a small part of signal from one stage to next stage and in addition to that the bypass
capacitor cannot bypass or shunt the emitter resistor effectively. As a result of these factors, the
voltage gain rolls of at low frequency.
2. State the reason for fall in gain at higher frequencies?
SCE178DeptofECE

EC6304

ElectronicCircuitsI

At high frequency the reactance of coupling capacitor is very low. Therefore it behaves like
a short circuit. As a result of this the loading effect of the next stage increase which reduces the
voltage gain. Hence the voltage gain rolls off at high frequencies.
3. Why the electrolytic capacitor is not used for coupling?
Electrolytic capacitor is a polarized capacitor. So it cannot be used for coupling and also in
electrolytic capacitor, the dielectric is not an insulating material but it conducting material which
will change the capacitance effect.
4. Write a note on effects of coupling capacitor.
The coupling capacitor Co transmits AC Signal. But blocks Dc. This prevents DC
interferences between various stages and the shifting of operating point.
It prevents the loading effect between adjacent stages.
5. What is the significance of gain bandwidth product?
It is very helpful in the preliminary design of a multistage wideband amplifier. This can be
used to setup a tentative circuit, which is often used for this purpose.
6. Why N-channel FETs have a better response than P-channel FETs?
N-channel FET have a better high frequency response than P-channel FET due to the
following reason. Mobility of electrons is large in N-channel FET whereas the mobility of holes
is poor in P-channel FET. The input noise is less in N-channel FET that that of the P-channel
FET. The trains conductance is larger in N-channel FET that that of P-channel Fet.
7. Define Miller effect in input capacitance?
For any inverting amplifier, the input capacitance will be increased by a miller effect
capacitance, sensitive to the gain of the amplifier and the inter electrode capacitance connected
between the input and output terminals of the active device.
CMi = (1-Av) Cf ;
CMo = Cf
Cf = Inter electrode capacitance between input and output.
8. What is a Darlington connection in the amplifiers?
A Darlington transistor connection provides a transistor having a very large current gain,
typically a few thousand. The main features of the Darlington connection is that the composite
transistor acts as a single unit with a current gain, that is the product of current gains of the
individual transistors.
9. Give the Applications of JFET
FET is used as a
(1) Buffer amplifier (2) Low Noise Amplifier (3) Cascaded Amplifier (4) Analog Switch
(5) Chopper (6) Phase Shift Oscillator circuits (7) Voltage Variable Resistors in Operational
Amplifiers and tone controls etc., (8) For Mixer operation on FM and TV receivers
10. Give the Applications of MOSFET

SCE179DeptofECE

EC6304

ElectronicCircuitsI

MOSFETs can also be used for most applications where JFET is used. MOSFETs have
become very popular for digital logic circuits due to high density of fabrication and low power
dissipation.
(1) MOSFET is used in Sample and Hold circuit as a switch.
(2) P-MOSFET and N-MOSFET are used in digital logic circuits
(3) C-MOSFET is very popular in fabricating of MSI and LSI
technology.
11. Draw a single stage amplifier circuit using JFET
The circuit of a Single Stage Common Source N-channel JFET amplifier using self bias
is shown in fig

12. What is the purpose of input capacitor, Cin in single stage common source JFET
amplifier?
An ac signal is supplied to the gate of the FET through an electrolytic capacitor called input
capacitor Cin. This capacitor allows only ac signal enter the gate but isolates the signal source
from RG. If this capacitor is not used, the signal source resistance will come across the resistor
RG and thus changing the biasing conditions.
13. What is the purpose of Biasing Network (Rs and Cs) in single stage common source
JFET amplifier?
The JFET is self-biased by using the biasing network Rs- Cs. The desired bias voltage is
obtained when dc component of drain current flows through the source-biasing resistor Rs.
whereas, the capacitor Cs bypasses the ac component of drain current.
14. What is the purpose of Coupling Capacitor (Cc) in single stage common source JFET
amplifier?
It is an electrolytic capacitor used to couple one stage of amplification to the next stage or
load. It allows only amplified ac signal to pass to the other side but blocks the dc voltage. If this
capacitor is not used, the biasing conditions of the next stage will be drastically changed due to
the shunting effect of Rd.
15. Give the expression for ID for E-MOSFET.
ID = (K(VGS - VT)2
16. What are the different biasing circuits of FET?
Fixed bias circuits
SCE180DeptofECE

EC6304

ElectronicCircuitsI

Self bias circuits


Voltage bias circuits

UNIT IV - FREQUENCY ANALYSIS OF BJT AND MOSFET AMPLIFIERS


PART A
1. Draw the low frequency simplified h-parameter model of an amplifier with a un
bypassed emitter resistor.

2. Why an NPN transistor has a better high frequency response than the PNP transistor?
An NPN transistor has a better frequency response than the PNP transistor because the
mobility of electron is more and capacitive effect is less.
3. Define fT and f.
Unity gain frequency (fT) or frequency parameter. It is defined as the frequency at
which the common emitter shirt circuit current gain has dropped to unity and is denoted by the
symbol (fT)
4. Beta cut-off frequency (fT).
It is defined as the high frequency at which -of a CE transistor drops to 0.707 or 3dB
from its lower frequencies
5. What is the need for having a high value of fT?
Bandwidth of the amplifier is directly proportional to fT. Hence tp have larger bandwidth, the
value of fT should be high.
6. Why N-channel FETs have a better response than P-channel FETs?
N-channel FET has a better high frequency response than P-channel FET due to the
following reason.
a. Mobility of electrons is large in N-channel FET whereas the mobility of holes is
poor in P-channel FET
b. The input noise is less in N-channel FET that that of the P-channel FET
c. The transconductance is larger in N-channel FET that that of P-channel FET
7. Write the relation between the sag and lower cutoff frequency?
SCE181DeptofECE

EC6304

ElectronicCircuitsI

fH = 2.2 / (2tr) = 0.35/tr


8. What is dominant network?
In high frequency analysis of an amplifier, the network having lower critical
frequency is called dominant network.
9. What is the function of Miller input capacitance of an amplifier?
The Miller input capacitance of an amplifier is a function of Bypass capacitor.
10. What is the use of source bypass capacitor in CS amplifier?
Source bypass capacitor in CS amplifier is used for improving the voltage gain.
11. Give two advantages of common source FET amplifier?
a. Good voltage gain
b. High input impedance.
12. What are the advantages of representation of gain in decibels?
a. In multistage amplifier, it permits to add individual gains of the stages to
calculate overall gain.
b. It allows us to denote, both very small as well as very large quantities of linear
scale by considerably small figures.
13. Write the relation between the sag and lower cut-off frequency.
The tilt of sag in time t1 is given by
fL = Pf
___
100
P = Y of tilt
F = input signal frequency
14. Give the voltage gain for CE configuration including source resistance.
Avs =

15. Why thermal runaway is not there in MOSFETs? (NOV/DEC-2005)


MOSFET is temperature dependent. In MOSFET, as temperature increases drain
resistance also increases, reducing the drain current. So thermal runaway does not occur in
MOSFET.
16. Define transconductance?
The change in the drain current due to change in gate to source voltage can be determined
using the transconductance factor gm. Id=gm VGS
17. Define emitter bypass capacitor?
An emitter bypass capacitor CE is connected in parallel with the emitter resistance,
REto provide a low reactance path to the amplified ac signal. If it is not inserted, the amplified ac
SCE182DeptofECE

EC6304

ElectronicCircuitsI

signal passing through REwill cause a voltage drop across it. This will reduce the output voltage,
reducing the gain of the amplifier.
18. Define coupling capacitor?
The coupling capacitor cs, couples the output of the amplifier to the load or to the next
stage of the amplifier. It blocks dc and passes only ac part of the amplified signal.
19. Define current gain
The ratio of output current to input current is called current gain, AI, of the
amplifier. AI= I2 / I1.
20. Define voltage gain
The ratio of output voltage to input voltage is called voltage gain AV , of the
amplifier. AV= V2/ V1
21. Define benefits of h-parameter.
Real numbers at audio frequencies
Easy to measure
Can be obtained from the transistor static characteristic curves
Convenient to use in circuit analysis and design.
Most of the transistor manufacturers specify the h-parameter.
.
22. What are the techniques used to improve input impedance.
Using direct coupling (Darlington connection)
Using Bootstrap techniques
23. Why the Darlington connection is not possible for more number of stages?
In Darlington connection of two transistors, emitter of the first transistor is directly
connected to the base of the second transistor. Because of direct coupling dc output current of
the first stage is (1+hfe)Ib1. If Darlington connection for n stage is (1+hfe)n times Ib1. Due to
very large amplification factor even tow stage Darlington connection has large output current
and output stage may have to be a power stage. As power amplifiers are not used in the amplifier
circuits it is not possible to use more than two transistors in the Darlington connection.
24. Briefly explain why dominant pole high frequency compensation method used in
amplifiers.
(May,07)
As the noise frequency components are outside the smaller bandwidth, the noise
immunity of the system improves.
Adjusting value of fd adequate phase margin and stability of the system is assured.
25. Write the equation for the output voltage and voltage gain for CS amplifier.
The output voltage is given by
Vo = -RD Vgs
RD + rd
Where is the amplification factor,
Rd is the drain resistance
Vgs = Vi, the input voltage
SCE183DeptofECE

EC6304

ElectronicCircuitsI

The voltage gain for CS amplifier is given by


Av = (Vo|Vi) = -RD
RD + rd
26. Write the equations for the output voltage and voltage gain for CD amplifier.
The output voltage is given by
Vo =
RsVgd
( + 1)Rs + rd
Where Vgd = Vi, the input voltage.
The voltage gain for CD amplifier is given by
Av =
Rs
( + 1)Rs + rd
27. Write the equations for the output voltage and voltage gain for CG amplifier.
The output voltage is given by
Vo =
-Vo
+ gm Vi rd + Vi
Rd
The voltage gain for CG amplifier is given by
Av = (gmrd + 1) RD
RD + rd

UNIT V - IC MOSFET AMPLIFIERS


PART - A
1. Define an Integrated circuit.
An integrated circuit(IC) is a miniature ,low cost electronic circuit consisting of active
and passive components fabricated together on a single crystal of silicon.The active components
are transistors and diodes and passive components are resistors and capacitors.
2. What are the advantages of ICs over discrete circuits.?
1. Minimization & hence increased equipment density.
2. Cost reduction due to batch processing.
3. Increased system reliability
4. Improved functional performance.
5. Matched devices.
6. Increased operating speeds
7. Reduction in power consumption
3. List the disadvantages of ICs
Inductors cannot be fabricated
IC function at very low voltage
Limited amount of power
Excessive heat

SCE184DeptofECE

EC6304

ElectronicCircuitsI

4. Define steering current. (May/June 2007)


In integrated circuit designs circuits use constant sources.here the constant d.c current
called reference current is generated at one location and is then replicated at various other
locations for biasing the various stages of amplifier present in the circuit. this process is known
as current steering.
5. State the advantages of current steering? (Nov/Dec 2006)
The external components such as precision resistors required to generate a predictable
and stable reference current,need not be repeated for every amplifier stage.
The bias currents of the various stages track each other when there is any change due to
power supply voltage or temperature.
6. Define cascade current mirror circuit. (May/Jun 2010)
MOSFET current source circuits the output resistance is a measure of stability of Io with
respect to the changes in the output voltage. Here MOSFET T3 andT4 are included to provide
higher output resistance. This circuit is known as cascade current mirror circuit.
7. Define Wilson current mirror circuit? (Nov/Dec 2008)
MOSFET Wilson current source the VDS values of T1 and T2 are not equal. Since is not
zero, the ratio Io/Iref is slightly different from the aspect ratio.
8. State the advantages of Wilson current mirror circuit.
The advantages of these circuits are the increase in output resistance and hence increase the
stability of output current.
9. List the various types of active loads?
There are three types of load devices:
N-channel enhancement mode device
N-channel depletion-mode device
P-channel enhancement mode device
10. State the advantages of NMOS amplifier with depletion load over enhancement load.
The voltage gain of NMOS amplifier with depletion load is significantly larger than that
with the enhancement load, however, like NMOS amplifier with enhancement load, the body
effect lowers the small-signal voltage gain.
11. Define and . (May/Jun 2010)
is a current gain which is the ratio of collector current to the base current.
is a forward current gain which is the ratio of collector current to the emitter current.
12. What is meant by over drive factor?
The over drive factor is defined as the ratio of IB and IBS. Where, IB is the base current
and IBS is the base current that produces the saturation.
13. Define delay time.

SCE185DeptofECE

EC6304

ElectronicCircuitsI

During the delay time period, base emitter voltage VBE is applied, the base current IB rises
to IBS and the collector current IC is equal to zero or collector emitter leakage current ICEO. The
time required to charge the base emitter capacitance to, VBES=0.7 V.
14. Define rise time. (May/June 2010)
During the rise time period, collector current IC raises to steady state values ICS and the
collector emitter voltage falls from VCC to VCES the rise time depends on the input capacitance.
15. What is the need of driver circuit?
9 It provides amplified voltage and current to the device.
9 It provides isolation between control circuit and power circuit.
16. State methods which are used to provide effect of increased RE.
Constant current bias method
Use of current mirror circuit
Use of an active load.
17. What is current mirror ? Dec-04
The circuit in which the output current is forced to equal the input current is called as
current mirror circuit. In a current mirror circuit, the output current is the mirror image of input
current.
18. State advantages of current mirror circuit.
1)Provides very high emitter resistance RE.
2)Easy to fabricate.
3)Requires less components then constants current bias.
4)Simple to design
5)With properly matched transistors,collector current thermal stability is achieved.
19. What are the types of internal capacitance in the MOSFET?
There two types of
1.Gate capacitance
2.junction capacitance
20.Define gate capacitance.
It is a parallel plate capacitance formed by a gate electrode with the channel with the
oxide layer acts as a capacitor dielectric. It is denoted as Cox.
21. List the advantage of active load.
provides very high ac resistance
provides high differential mode voltage gain
Ad High
CMRR High

SCE186DeptofECE

Anda mungkin juga menyukai