1.
A pipe can fill a tank in 6 hours. Due to leak in its bottom it is filled in 7
hours. When the tank is full in how much time it will be emptied by the leak?
a. 42h
b. 49h
c. 36h
d. 49h.
a
2. What is the unit digit in (3547153 x 25172)?
a. 1
b. 9
c. 7
d. 0
c
3. Which of the following cannot be the square of a natural number?
a. 30976
b. 75625
c. 28561
d. 143642
d
4. Find the odd term out : 3,5,7,15,19
a. 19
b. 15
c. 7
b
d. 5
MECHANICS
1. Moment of Inertia of a Rectangular Bar of mass M & length L about its one
end is:
a. ML2/12
b. ML2/2
c. ML2/4
d. ML2/3
d
2. A thin circular ring of mass M and radius R is rotating about its axis with a
constant angular velocity w. Two objects, each of mass m are gently attached
to the opposite ends of the diameter of the ring. The wheel now rotates with
an angular velocity.
a. Wm/(M+m)
b. (M-2m)/(M+2m)W
c. {M/(M+2m)}W
d. {(M+2m)/M}W
c
3. Name the machine element (fastener) shown in the figure
Bolt
AUTOMOBILE
1. What type of transmission is used in TVS Jupiter?
a. Manual gearbox
b. Continuously Variable Transmission
c. Automatic transmission
d. DCT.
b
2. A very famous technology DTSI used by Bajaj auto, stands for.
a. Digital timing spark ignition
b. Digital twin spark ignition
c. Dynamic timing and systematic injection
d. Dynamic timing solenoid injection.
b
3. What are the number of gear ratios in continuously variable transmission?
a. 1
b. 2
c. zero
d. None of these.
d
4. Angle between the vertical axis and axis of wheel is
a. Caster
b. Camber
c. Toe
d. Yaw
b
5. What is the smallest element called in Finite element analysis?
a. Mesh
b. Cell
c. Atom
d. Block
a
6. Which of the following software cannot be used for chassis analysis?
a. CATIA
b. ANSYS
c. INVENTOR
d. ADAMS.
d
7. The code for a ball bearing supporting an axel of OD 25mm is 60___.
05
RULEBOOK
1. How many minimum threads should be visible past the nut in all fasteners
used?
a. 1
b. 2
c. 3
d. 4
b
2. What is the minimum acceptable OD for pipes to be used for the chassis?
a. 1inch
b. 1.5inch
c. 22mm
d. 25mm
a
3. Which of the following institutions certifications are not allowed for the
driver safety gear?
a. SFI
b. SNELL
c. FIA
d. SAE
d
4. The minimum value of wheel track allowed for a kart is _______?
inch or 74.67cm
29.4
ANSWER KEY
GENERAL ABILITY
1
2
3
4
5
A
C
D
B
C
MECHANICS
1
2
3
4
5
6
7
8
AUTOMOBILE
1
2
3
4
5
6
7
8
9
10
11
12
RULEBOOK
1
2
3
4
5