Shown as Fig.2-53
c ylinder head
valve c age cov er
tent model
Mate rial:
Bolt
cran kshaft
bea ring
co ver
spark p lug
cylinder head
Requirem ent
the uneven degree of the lower surface
0.10mm
insta llation surface of air intake and
exha ust ma nifold: 0.10 m m
Asse mble two orie ntation hole w ith th e
cylin der he ad
ad just cu shion
v alve ta ppet
3025037035 Nm
Tig hten cr osswise from central to two
side s.
proper replacement.
Mode
Standard
IN
EX
L imit
IN
EX
EF
ZLRL
G LGSZS
0.02
23.0 --0.033
- 0.02
23.0 -0.033
22.9
22.9
E xhaust
Air In take
Note :the timing ma rk on the cam shaft gear sho uld be aligned
Figure 2-56 inst allat ion of the air intake and exhaust
m ea s u re t he ri g h t
a ngl e of t he val ve
spring.
[Limit] 1.2mm
2valve
1Check to see if there are some deformations, obvious tears and wearsAs figure :2-58
Item
Wide
Width of valve top
IN
EX
IN
EX
Sta ndardmm
0.851.41
1.071.36
1.00.2
1.00.2
Lim itm m
0.75
0.75
top t hickne ss
oute r diameter me asurem ent
3 5mm
2Checks on the clearance between the throttle guiding pipe and throttle thrusting rod
Use a dial gauge to measure the inner diameter of the throttle guiding pipe, and use a caliper to measure the
outer diameter.
3 Work out the differences of the measured values. If it is above the specified limits, the throttle or the
guiding pipe must be replaced.
Attention The measurement points are shown as the figure2-60. Work out the clearance of the final torn and
worn section
th e inne r diam eter o f valve guide pipemm
Measure point
M easure point
sp ecial to ol
IT EM
h
H
mm
EF
GLZLRLGSZS
IN
13.710.25
EX
12.110.25
Atte ntion
In t he proc ess of driving in the guidin g pipe
into the cylind er cover, th e ope ration
sho uld be carried out slowly u ntil the pipe
gets to the prop er posi tion. N o exc essive
driv ing should be exerte d. Pay attenti on to
the specifications in the operati on.