Version 2
1. IDENTIFICATION
Product identifier
Product Name
M00061
UN/ID no
UN3288
1411928; 2245100
Not applicable
Not applicable
Not applicable
Not applicable
None reported
2. HAZARDS IDENTIFICATION
Classification
Regulatory Status
This chemical is considered hazardous by the 2012 OSHA Hazard Communication Standard (29 CFR 1910.1200)
Acute toxicity - Inhalation (Dusts/Mists)
Skin corrosion/irritation
Serious eye damage/eye irritation
Germ cell mutagenicity
Carcinogenicity
Reproductive toxicity
Specific target organ toxicity (single exposure)
Category 3
Category 2
Category 1
Category 2
Category 1B
Category 2
Category 3
Page 1 / 19
Category 1
Hazard statements
H331 - Toxic if inhaled
H315 - Causes skin irritation
H318 - Causes serious eye damage
H341 - Suspected of causing genetic defects
H350 - May cause cancer
H361 - Suspected of damaging fertility or the unborn child
H335 - May cause respiratory irritation
H372 - Causes damage to organs through prolonged or repeated exposure
Precautionary statements
P201 - Obtain special instructions before use
P202 - Do not handle until all safety precautions have been read and understood
P281 - Use personal protective equipment as required
P271 - Use only outdoors or in a well-ventilated area
P264 - Wash face, hands and any exposed skin thoroughly after handling
P260 - Do not breathe dust/fume/gas/mist/vapors/spray
P270 - Do not eat, drink or smoke when using this product
P308 + P313 - IF exposed or concerned: Get medical advice/attention
P304 + P340 - IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for breathing
P311 - Call a POISON CENTER or doctor/physician
P305 + P351 + P338 - IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to
do. Continue rinsing
P310 - Immediately call a POISON CENTER or doctor/physician
P302 + P352 - IF ON SKIN: Wash with plenty of soap and water
P332 + P313 - If skin irritation occurs: Get medical advice/attention
P362 - Take off contaminated clothing and wash before reuse
P405 - Store locked up
P403 + P233 - Store in a well-ventilated place. Keep container tightly closed
P501 - Dispose of contents/ container to an approved waste disposal plant
Other Information
May be harmful if swallowed
Very toxic to aquatic life with long lasting effects
Very toxic to aquatic life
3. COMPOSITION/INFORMATION ON INGREDIENTS
Substance
Not applicable
Mixture
This material is considered hazardous by the OSHA Hazard Communication Standard (29 CFR 1910.1200)
Chemical Name
Tartaric Acid
Sodium Sulfate
1,2-Cyclohexanediaminetetraacetic Acid Trisodium Salt
Cadmium
Copper Dihydrogen Cyclohexanediaminetetraacetic Acid
CAS No
87-69-4
7757-82-6
36679-96-6
7440-43-9
19332-78-6
Weight-%
30.6718
23.4022
9.4605
5.7759
0.3983
HMRIC #
-
In case of accident or unwellness, seek medical advice immediately (show directions for
use or safety data sheet if possible).
Eye contact
IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if
present and easy to do. Continue rinsing. Call a physician immediately.
Skin contact
IF ON SKIN (or hair): Remove/Take off immediately all contaminated clothing. Rinse skin
with water/shower. If symptoms persist, call a physician.
Inhalation
IF INHALED: Remove person to fresh air and keep comfortable for breathing. Call a
physician immediately.
Ingestion
Use personal protective equipment as required. Ensure that medical personnel are aware
of the material(s) involved and take precautions to protect themselves.
Treat symptomatically.
5. FIRE-FIGHTING MEASURES
Suitable Extinguishing Media
Use extinguishing measures that are appropriate to local circumstances and the surrounding environment.
Unsuitable extinguishing media Caution: Use of water spray when fighting fire may be inefficient.
Flammable properties
Substance does not burn.
Specific hazards arising from the chemical
None reported.
Hazardous combustion products
EC Notice
WHMIS Notice
Evacuate personnel to safe areas. Do not touch or walk through spilled material. Ventilate
affected area. Use personal protective equipment as required.
Environmental precautions
Avoid release to the environment. See Section 12 for additional ecological information.
Environmental precautions
Prevent further leakage or spillage if safe to do so. Cover with plastic sheet to prevent
spreading.
Use personal protective equipment as required. Avoid contact with skin, eyes or clothing.
Do not breathe dust/fume/gas/mist/vapors/spray.
Keep container tightly closed in a dry and well-ventilated place. Keep out of the reach of
children.
Flammability class
Not applicable
Incompatible materials
Chemical Name
Cadmium
0 - 10%
ACGIH TLV
TWA: 0.01 mg/m3
TWA: 0.002 mg/m3
Copper Dihydrogen
Cyclohexanediaminetetraacetic Acid
0 - 10%
TWA: 1 mg/m3
Chemical Name
Alberta OEL
Cadmium
TWA: 0.01 mg/m3
0 - 10%
TWA: 0.002 mg/m3
Copper Dihydrogen
NDF
Cyclohexanediaminetetraa
cetic Acid
0 - 10%
Chemical Name
Cadmium
0 - 10%
Copper Dihydrogen
Cyclohexanediaminetetraa
cetic Acid
0 - 10%
NIOSH IDLH
IDLH: 9 mg/m3 dust IDLH: 9
mg/m3 Cd dust and fume
British Columbia
Manitoba OEL
New Brunswick New Foundland &
OEL
OEL
Labrador OEL
TWA: 0.01 mg/m3 TWA: 0.01 mg/m3 TWA: 0.01 mg/m3 TWA: 0.01 mg/m3
TWA: 0.002 mg/m3 TWA: 0.002 mg/m3 TWA: 0.002 mg/m3 TWA: 0.002 mg/m3
NDF
TWA: 1 mg/m3
NDF
TWA: 1 mg/m3
Northwest
Nova Scotia OEL
Territories OEL
TWA: 0.01 mg/m3 TWA: 0.01 mg/m3
TWA: 0.002 mg/m3 TWA: 0.002 mg/m3
STEL: 0.03 mg/m3
STEL: 0.006 mg/m3
NDF
TWA: 1 mg/m3
Chemical Name
Cadmium
0 - 10%
OSHA PEL
TWA: 0.1 mg/m3
TWA: 0.2 mg/m3
TWA: 5 g/m3
(vacated) STEL: 0.3 ppm
Ceiling: 0.3 mg/m3
Ceiling: 0.6 mg/m3
NDF
Quebec OEL
TWA: 0.025 mg/m3
Nunavut OEL
Ontario TWA
Prince Edward
Island OEL
TWA: 0.01 mg/m3
TWA: 0.002 mg/m3
NDF
NDF
TWA: 1 mg/m3
Saskatchewan OEL
TWA: 0.01 mg/m3
TWA: 0.002 mg/m3
STEL: 0.03 mg/m3
STEL: 0.006 mg/m3
Yukon OEL
STEL: 0.15 mg/m3
TWA: 0.05 mg/m3
Other Information
Vacated limits revoked by the Court of Appeals decision in AFL-CIO v. OSHA, 965 F.2d 962
(11th Cir., 1992).
Legend
Showers
Eyewash stations
Ventilation systems
Respiratory protection
Handle in accordance with good industrial hygiene and safety practice. Do not eat, drink or
smoke when using this product. Take off all contaminated clothing and wash it before
reuse. Wash hands thoroughly after handling. Regular cleaning of equipment, work area
Solid
Appearance
powder
Color
blue
metallic
Odor
Odorless
Odor threshold
No data available
Remar
ks Met
hod
Property
Values
Molecular weight
No data available
pH
3.4
No data available
No data available
Evaporation rate
Not applicable
Vapor pressure
Not applicable
Not applicable
0.954
No data available
No data available
Decomposition temperature
No data available
Dynamic viscosity
Not applicable
Kinematic viscosity
Not applicable
5% Solution
No data available
Solubility(ies)
Water solubility
Water solubility classification
Soluble
Solubility in other solvents
Water solubility
> 1000 mg/L
Solubility
No data available
Solubility Temperature
No information available
Other Information
Not classified as corrosive to metal according to GHS criteria
Metal Corrosivity
Steel Corrosion Rate
Not applicable
Not applicable
Not applicable.
Bulk density
No data available
Explosive properties
Explosion data
No data available
No data available
Not classified as flammable according to GHS criteria.
Flammable properties
Flammability Limit in Air
Upper flammability limit:
No data available
No data available
Not applicable
Flash point
No information available
Method
Oxidizing properties
Reactivity propeties
Conditions to avoid
Excess moisture. Excessive heat. Extreme temperatures. Contact with acid or acid fumes. Contact with oxidizers. Incompatibles.
Incompatible materials
Incompatible with:. Oxidizers. powdered metals. hydrazoic acid.
Hazardous Decomposition Products
Heating to decomposition releases toxic and/or corrosive fumes of:. cadmium oxide. Sulfur oxides. carbon dioxide. Carbon
monoxide.
Explosive properties
Not classified according to GHS criteria. Can burn in fire, releasing toxic vapors.
Upper explosion limit
No data available
No data available
Autoignition temperature
No data available
Sensitivity to Static Discharge
None reported
Sensitivity to Mechanical Impact
None reported
Eye contact
Skin contact
Ingestion
Aggravated Medical Conditions
Toxicologically synergistic products
Toxicokinetics, metabolism and distribution
No data available
No data available
No data available
No data available
No data available
The following values are calculated based on chapter 3.1 of the GHS document
3,570.00 mg/kg
0.87 mg/L
ATEmix (oral)
ATEmix (inhalation-dust/mist)
Ingredient Acute Toxicity Data
Oral Exposure Route
Chemical Name
Endpoint
type
Cadmium
Rat
(0 - 10%)
LD50
CAS#: 7440-43-9
Reported
dose
225 mg/kg
Exposure
time
None
reported
Toxicological effects
None reported
No data available
Exposure
time
4 hours
Toxicological effects
None reported
No data available
No data available
Chemical Name
Test method
Species
Reported
dose
Exposure
time
Results
Tartaric Acid
(30 - 40%)
CAS#: 87-69-4
Existing human
experience
Human
None
reported
None
reported
Skin irritant
Key literature
references and
sources for data
Vendor SDS
Chemical Name
Test method
Species
Reported
dose
Exposure
time
Results
Tartaric Acid
(30 - 40%)
CAS#: 87-69-4
Existing human
experience
Human
None
reported
None
reported
Corrosive to eyes
Sensitization Information
Product Sensitization Data
Skin Sensitization Exposure Route
No data available.
Key literature
references and
sources for data
Vendor SDS
No data available.
No data available.
No data available.
No data available.
No data available.
No data available.
Reported
dose
37.5 mg/kg
Exposure
time
30 days
Toxicological effects
Exposure
time
3139 days
Toxicological effects
Kidney, Ureter, or Bladder
Proteinuria
No data available
No data available
Chemical Name
Tartaric Acid
Sodium Sulfate
Sodium Tartrate
1,2-Cyclohexanediaminete
traacetic Acid Trisodium
Salt
Magnesium Sulfate
CAS No
87-69-4
7757-82-6
868-18-8
36679-96-6
ACGIH
-
IARC
-
NTP
-
OSHA
-
7487-88-9
Cadmium
Copper Dihydrogen
Cyclohexanediaminetetraa
cetic Acid
Cationic Acrylamide
Copolymer Salts
7440-43-9
19332-78-6
A2
-
Group 1
-
Known
-
X
-
35429-19-7
Legend
ACGIH (American Conference of Governmental Industrial Hygienists)
IARC (International Agency for Research on Cancer)
NTP (National Toxicology Program)
OSHA (Occupational Safety and Health Administration of the US Department of
Labor)
Product Carcinogenicity Data
No data available
No data available
No data available
No data available
No data available
No data available
No data available
No data available
Exposure
route
20 years
Toxicological effects
No data available
No data available
Test
Cell Strain
Reported
dose
Exposure
time
Cadmium
(0 - 10%)
CAS#: 7440-43-9
DNA damage
Human
lymphocyte
0.25 mmol/L
1 hours
Chemical Name
Test
Cell Strain
Reported
dose
Exposure
time
Cadmium
Micronucleus test
Mouse embryo
0.006 mmol/L
None
Results
Key literature
references and
sources for data
Positive test result for RTECS (Registry
mutagenicity
of Toxic Effects of
Chemical
Substances)
Results
Key literature
references and
sources for data
Positive test result for RTECS (Registry
(0 - 10%)
CAS#: 7440-43-9
No data available
No data available
No data available
No data available
No data available
mutagenicity
of Toxic Effects of
Chemical
Substances)
No data available
No data available
No data available
No data available
No data available
No data available
No data available
No data available
No data available
No data available
Reported
dose
14000 mg/kg
Exposure
time
4 days
23 mg/kg
22 days
Toxicological effects
Effects on Newborn
Other neonatal measures or
effects
Specific Developmental
Abnormalities
Blood and lymphatic systems
(including spleen and marrow)
No data available
No data available
No data available
No data available
Aquatic toxicity
Fish
No data available
Crustacea
No data available
Algae
No data available
Terrestrial toxicity
Soil
No data available
Vertebrates
No data available
Invertebrates
No data available
Exposure
time
96 hours
None reported
Endpoint
type
LC50
Reported
dose
56 mg/L
96 hours
Morone saxatilis
LC50
0.019 mg/L
Exposure
time
96 hours
Species
Pimephales promelas
Endpoint
type
LC50
Reported
dose
7960 mg/L
96 hours
None reported
LC50
7.8 mg/L
Exposure
time
48 Hours
Species
Daphnia magna
Endpoint
type
EC50
Reported
dose
3150 mg/L
48 Hours
None reported
EC50
0.58 mg/L
Exposure
time
96 hours
Species
Endpoint
type
LC50
Reported
Key literature references and
dose
sources for data
0.0016 mg/L PEEN (Pan European Ecological
Network)
Endpoint
type
EC50
Reported
dose
0.132 mg/L
Exposure
time
72 Hours
Species
Mysidopsis bahia
Species
None reported
Terrestrial toxicity
Soil
No data available
Vertebrates
No data available
Invertebrates
No data available
Other Information
Canadian Environmental Protection Act (CEPA) - Domestic Substances List (DSL):
Environmentally Hazardous Substances Categorizations
Chemical Name
Category
Persistent
Yes
Test method
1,2-Cyclohexanediam
inetetraacetic Acid
Trisodium Salt
(0 - 10%)
CAS#: 36679-96-6
None reported
Biodegradation Exposure
time
None reported
None
reported
Results
Not readily
biodegradable
Bioaccumulation
None known.
Product Bioaccumulation Data
No data available.
No data available
Additional information
Product Information
No data available
No data available
Ingredient Information
Chemical Name
Tartaric Acid
(30 - 40%)
CAS#: 87-69-4
Partition Coefficient
(n-octanol/water)
log Kow = -1
Method
Estimation through KOWWIN v1.68 part
of the Estimation Programs Interface
(EPI) Suite
Sodium Sulfate
(20 - 30%)
CAS#: 7757-82-6
Sodium Tartrate
(20 - 30%)
CAS#: 868-18-8
1,2-Cyclohexanediaminetetraacetic Acid
Trisodium Salt
(0 - 10%)
CAS#: 36679-96-6
log Kow = -3
No information available
No information available
Mobility
Mobility in soil: Moderate to high mobility. If available, see ingredient data below.
Product Information
No data available
No data available
Ingredient Information
Chemical Name
Sodium Sulfate
(20 - 30%)
CAS#: 7757-82-6
Sodium Tartrate
(20 - 30%)
CAS#: 868-18-8
1,2-Cyclohexanediaminetetraacetic Acid
Trisodium Salt
(0 - 10%)
CAS#: 36679-96-6
Additional information
Water solubility
Product Information
Water solubility classification
Water solubility
Soluble
25 C / 77 F
Ingredient Information
Chemical Name
Tartaric Acid
(30 - 40%)
CAS#: 87-69-4
Sodium Sulfate
Completely soluble
(20 - 30%)
CAS#: 7757-82-6
Sodium Tartrate
Completely soluble
(20 - 30%)
CAS#: 868-18-8
1,2-Cyclohexanediaminetetraacetic Acid Trisodium
Soluble
Salt
(0 - 10%)
CAS#: 36679-96-6
Cadmium
Insoluble
Water solubility
temperature C
20 C
Water solubility
temperature F
68 F
160000 mg/L
20 C
68 F
100000 mg/L
20 C
68 F
50 C
122 F
25 C
77 F
(0 - 10%)
CAS#: 7440-43-9
Copper Dihydrogen Cyclohexanediaminetetraacetic
Acid
(0 - 10%)
CAS#: 19332-78-6
Soluble
25 C
77 F
Disposal should be in accordance with applicable regional, national and local laws and
regulations.
Contaminated packaging
Working in a well-ventilated area,. Rinse three times with an appropriate solvent. Collect
rinsate and dispose of according to local, state or federal regulations. Dispose of empty
container as normal trash. In the US, rinsate from empty containers is classified as
hazardous waste and should be disposed of at an E.P. A. approved facility. Rinsate from
empty containers may contain sufficient product to require disposal as hazardous waste in
countries other than the US. Improper disposal or reuse of this container may be dangerous
and illegal. Disposal should be in accordance with applicable regional, national and local
laws and regulations.
Chemical Name
RCRA
Cadmium
7440-43-9
RCRA - D Series
Wastes
1.0 mg/L regulatory level
RCRA - U Series
Wastes
-
Dispose of material in an E.P.A. approved hazardous waste facility. Otherwise, Check with
local municipal and state authorities and waste contractors for pertinent local information
regarding the proper disposal of chemicals.
UN3288
Toxic Solid, Inorganic, N.O.S.
(Cadmium mixture)
6.1
III
This product contains a chemical which is listed as a severe marine pollutant according to
DOT.
151
UN3288
Toxic Solid, Inorganic, N.O.S.
6.1
III
This product contains a chemical which is listed as a severe marine pollutant according to
TDG. Lead compounds.
IMDG
UN/ID no
Proper shipping name
Hazard Class
Packing Group
Marine pollutant
UN3288
Toxic Solid, Inorganic, N.O.S.
6.1
III
This material meets the definition of a marine pollutant
Note:
Complies
Complies
TSCA - United States Toxic Substances Control Act Section 8(b) Inventory
DSL/NDSL - Canadian Domestic Substances List/Non-Domestic Substances List
International Inventories
EINECS/ELINCS
ENCS
IECSC
KECL
PICCS
TCSI
AICS
NZIoC
Complies
Complies
Complies
Complies
Does not comply
Complies
Does not comply
Does not comply
EINECS/ELINCS - European Inventory of Existing Chemical Substances/European List of Notified Chemical Substances
ENCS - Japan Existing and New Chemical Substances
IECSC - China Inventory of Existing Chemical Substances
KECL - Korean Existing and Evaluated Chemical Substances
PICCS - Philippines Inventory of Chemicals and Chemical Substances
TCSI - Taiwan Chemical Substances Inventory
AICS - Australian Inventory of Chemical Substances
NZIoC - New Zealand Inventory of Chemicals
US Federal Regulations
SARA 313
2
Chemical Name
Cadmium (CAS #: 7440-43-9)
SARA 311/312 Hazard Categories
Acute health hazard
Chronic Health Hazard
Fire hazard
Sudden release of pressure hazard
Reactive Hazard
No
Yes
No
No
No
Chemical Name
Cadmium
7440-43-9
Copper Dihydrogen
Cyclohexanediaminetetra
acetic Acid
19332-78-6
CWA - Reportable
Quantities
-
CWA - Priority
Pollutants
X
CWA - Hazardous
Substances
-
CERCLA
As supplied, this material does not contain any hazardous substances as regulated under the Comprehensive Environmental
Response Compensation and Liability Act (CERCLA) (40 CFR 302)or the Superfund Amendments and Reauthorization Act
(SARA) (40 CFR 355). T
Chemical Name
Cadmium
7440-43-9
CERCLA/SARA RQ
-
US State Regulations
California Proposition 65
This product contains the following Proposition 65 chemicals
Chemical Name
Cadmium (CAS #: 7440-43-9)
California Proposition 65
Carcinogen
Developmental
Male Reproductive
New Jersey
X
Massachusetts
X
Pennsylvania
X
Health hazards - 3
Flammability - 0
Instability - 0
HMIS
Health hazards - 3
Flammability - 0
Physical hazards - 0
Key or legend to abbreviations and acronyms used in the safety data sheet
NIOSH IDLH
STEL
MAC
Ceiling
Listed
Vacated
SKN*
RSP+
C
M
Skin designation
Respiratory sensitization
Carcinogen
mutagen
SKN+
**
R
Skin sensitization
Hazard Designation
Reproductive toxicant
Prepared By
Issue Date
27-Jul-2016
Revision Date
27-Jul-2016
Revision Note
None
Disclaimer
USER RESPONSIBILITY: Each user should read and understand this information and incorporate it in individual site
safety programs in accordance with applicable hazard communication standards and regulations.
THE INFORMATION CONTAINED HEREIN IS BASED ON DATA CONSIDERED TO BE ACCURATE. HOWEVER, NO
WARRANTY IS EXPRESSED OR IMPLIED REGARDING THE ACCURACY OF THESE DATA OR THE RESULTS TO BE
OBTAINED FROM THE USE THEREOF.
HACH COMPANY 2016