Anda di halaman 1dari 4

DISCUSSION

6. Discuss the importance and relevance of the test, the parameters obtained, shortcoming and possible ways of
improvement.

This experiment was carried out to determine the coefficient of permeability (k) for a given soil sample
using falling head method. The falling head permeability test is a common laboratory testing method used to
determine the permeability of fine grained soils with intermediate and low permeability such as silts and
clays. The falling head test was found to be more suitable than the constant head test because of its
simplicity and the inability of the latter to allow water flow at measurable pressure heads.
The falling head permeability test involves flow of water through a relatively short soil sample connected
to a standpipe which provides the water head and also allows measuring the volume of water passing
through the sample. Before starting the flow measurements, the soil sample is saturated and the
standpipes are filled with de-aired water to a given level. The test then starts by allowing water to flow
through the sample until the water in the standpipe reaches a given lower limit. The height of water in the
glass standpipe is recorded in every 5 minutes time interval for about 50 minutes. Using the recorded
readings the graph

ln

h0
h1

( )

against

(t 1t 0 ) was plotted. Then the coefficient of permeability, k was

found by the gradient of the graph.

The Importance and Relevance of the Test


The knowledge of permeability is important for the following engineering problems:

To find out the rate of consolidation and settlement of a saturated soil under load
To compare the permeability of two soils or in comparing the permeability of a soil in horizontal and
vertical directions in designing of projects where vertical sand drains are used.
Estimating the quantity of underground seepage through earthen dams and canals.
Investigating problems involving pumping seepage of water for underground constructions.
Analyzing the stability of earth dams, earth retaining walls, upstream and downstream slopes and
retaining structures.
To estimate ground water flow.
To plan the method of lowering the ground water table.
To calculate the uplift pressure and piping.
To design the grouting.
For soil freezing tests.

The factors which affect the permeability are:

Properties of pore fluid


Size and shape of particles
Void ratio of soil
Structural arrangement of soil particles
Degree of saturation
Adsorbed water
Stratification

Error Analysis
Shortcomings

Parallax error is occurred where the observers eyes are not perpendicular to the scale while reading the height
To overcome this error, the observers eye must be 90o perpendicular to the water level in order to get the
accurate measurement.
Possible Ways of Improvement.

1
2

The saturation of the specimen is important in obtaining consistent results.


During test,
there should be no volume change in the soil
there should be no compressible air present in the voids of soil i.e. soil should be completely saturated.
The flow should be laminar and in a steady state condition.

Determination of the coefficient of permeability


There are several ways for determining the coefficient of permeability k. They grouped as follows:
.i)Laboratory methods
A)Constant head permeability test
The coefficient of permeability of a coarse-grained soil can be determined in the
laboratory using a constant-head permeability test.
The test includes a cylindrical soil specimen that is subjected to a constant head
as shown in Figure

The length of the soil specimen is L and its cross-sectional area is A.

The total head loss (hL) along the soil specimen is equal to the constant head,
which is the difference in elevation between the water levels in the upper and
lower reservoirs as shown in the figure.

A constant head implies that we have reached a steady-state condition in which


the flow rate is constant (i.e., does not vary with time).

Using a graduated flask, we can collect a volume of water (V) in a period of time
(t ).

From this we can calculate the flow rate

( q= V/t).

Coefficient of permeability K = ql/Ah

B)Falling head permeability test


This is further discussed under theory
ii) Field methods
A field permeability test consists of pumping out water from a main well and
observing the resulting drawdown surface of the original horizontal water table from
at least two observation wells. When a steady state of flow is reached, the flow
quantity and the levels in the observation wells are noted.
Two important field tests for determining permeability are:
A)Unconfined flow pumping test
B) confined flow pumping test

Advantages.
The advantages of laboratory testing for measuring the permeability of soils are:
a. The water content and density of the soil to be tested can be carefully controlled.
b. Samples can be saturated prior to testing more readily in laboratory tests.
c. High hydraulic gradients may be employed, which permits measurement of lower
permeabilities in a shorter time.
d. Laboratory methods are usually much more economical than field methods, especially for
slowly permeable soils where long testing times are required to measure low volumes of flow.

2. Disadvantages.
The disadvantages of laboratory testing are:

a. Important macro-features of natural soil deposits, such as drying cracks and alluvial soil
stratification, are difficult to model with small laboratory scale specimens. Laboratory
specimens are limited in size.
b. To test undisturbed or in situ soils, samples must be obtained, shipped, and handled by the
laboratory. Undisturbed samples are expensive to obtain. Sample disturbance may affect test
results.
c. Horizontal permeability is difficult to measure in laboratory specimens. Usually, vertical
permeability is measured.

CONCLUSION
Permeability can be defined as the ability of a porous medium to allow the flow of a fluid through it,
typically expressed as the coefficient of permeability (k). This property is necessary for the
calculations such as seepage through earth dams or under sheet pile walls, the seepage rate from waste
storage facilities (landfills, ponds, etc.) and the rate of settlement of clayey soil deposits.
6

In this experiment, the coefficient of permeability (k) is found to be 2 .169 10 ms


h1
ln
gradient of the graph
h2

( )

from the

t t
against ( 2 1 ) .

Finally we can conclude that this experiment was carried out successfully with the use of Falling Head
Permeability Apparatus and the objective to determine the coefficient of permeability (k) for a given
soil sample was achieved.

Anda mungkin juga menyukai