1. Connect the cloning cable to the receiving radio, and turn ON the radio.
2. Rotate the main/mother radio CHANNEL to #8,then turn ON the radio with pressing and
holding the <MONI> key till the LED lights orange that means the main radio is under
cloning mode.(see manual for more info regarding KEY).
3. Press main radio <CALL> key to start cloning process. The main radio flashes red,
meanwhile the receiver flashes green. The cloning process is finished when the main radio
lights orange.
4. If you have to clone many radios, turn OFF the cloned radio (receiver) then unplug from
the data cable. Plug the next radio to be clone then press the <CALL> key of the main radio
to start cloning again.
5. Turn ON the radio again after exiting the wired clone. Then it would resume to daily
operation.
1. PRESS and HOLD the alarm key(orange) BEFORE turning ON the MAIN/MOTHER radio.
(CLONING?) should be at the lcd screen of the MOTHER/MAIN radio.
2. Plug the cloning cable at both radios.
3. Turn on normally the RECIEVING radio.
4. PRESS <FUNC> key to the MOTHER radio to start cloning.
5. The receiving radio flashes red when cloning is started.
6. Wait till the receiving radio restarts and the MAIN radio will display <SUCCESS>.
1.
2.
3.
4.
5.
1.
2.
3.
4.
Installing Software
UV-85
1. Open UV-85 software.
2. Double click UV85CPS then click <setup> then click <ok>.
3. Click the ICON to start the installation.
V85
1. Open <V85 software>.
2. Click <V85 setup>
3. Next, next next until finished..
(USB-Serial Controller)
.
6.click Next
8. install successfully
You should see the Prolific USB-to-Serial Comm Port (COM *) device listing. This also means that
Windows has assigned the device to COM * port.