0 penilaian0% menganggap dokumen ini bermanfaat (0 suara)
5 tayangan1 halaman
RO plants started auto mode operations at 10:00 am with two mechanical contractors but no electrical contractors on site. PLC programming was completed to interlock ORP transmitters on RO units I and II with automatic dump valves based on feed water quality. Instruments for pH, conductivity 1, and TDS 2 were calibrated, but ORP calibration is pending due to unavailable solution. Conductivity meter 2 is not working, TDS meter 1 is low range for feed water above 7000 TDS, and mechanical works included changing all cock valves and rubber gaskets on high pressure flange joints. Pending works include changing TDS, conductivity, and pH meters and calibrating the ORP meter.
RO plants started auto mode operations at 10:00 am with two mechanical contractors but no electrical contractors on site. PLC programming was completed to interlock ORP transmitters on RO units I and II with automatic dump valves based on feed water quality. Instruments for pH, conductivity 1, and TDS 2 were calibrated, but ORP calibration is pending due to unavailable solution. Conductivity meter 2 is not working, TDS meter 1 is low range for feed water above 7000 TDS, and mechanical works included changing all cock valves and rubber gaskets on high pressure flange joints. Pending works include changing TDS, conductivity, and pH meters and calibrating the ORP meter.
RO plants started auto mode operations at 10:00 am with two mechanical contractors but no electrical contractors on site. PLC programming was completed to interlock ORP transmitters on RO units I and II with automatic dump valves based on feed water quality. Instruments for pH, conductivity 1, and TDS 2 were calibrated, but ORP calibration is pending due to unavailable solution. Conductivity meter 2 is not working, TDS meter 1 is low range for feed water above 7000 TDS, and mechanical works included changing all cock valves and rubber gaskets on high pressure flange joints. Pending works include changing TDS, conductivity, and pH meters and calibrating the ORP meter.
Today, RO Plants start at 10:00 am and run in auto mode.
There is Two Mechanical and no Electrical Contractor Man Power in RO plant PLC Work:Today, as per your trail mail, programme of these works in PLC Completed. 1. ORP Transmitter to check RO-I and RO-II feed quality interlocking with auto operated Dump Valve. Instrument Work: Instruments PH,cond1, TDS2 are calibrated. and Now Calibration ORP meter Pending due to not available solution .one cond2 meter not working. One TDS 1 metre at feed is of low range ,TDS meter range should be of above 7000. Mechanical Work:1. Changed all cock valve. 2. Change Rubber Gasket valve at high pressure joints of flanges Pending Work:Change TDS Conductivity and PH meter. Meter Calibration (ORP meter ) Thanks and Regards Donesh