1. Selector Switches
These switches select the physical tap position on the transformer winding and, because of
their construction, cannot and must not make or break the load current.
2. Reactors
The load current must never be interrupted during a tap change.
Therefore, during each tap change, there is an interval where two voltage taps are spanned.
Reactors (inductors) are used in the circuit to increase the impedance of the selector circuit and
limit the amount of current circulating due to this voltage difference. Under normal load
conditions, equal load current flows in both halves of the reactor windings and the fluxes balance
out giving no resultant flux in the core.
With no flux, there is no inductance and, therefore, no voltagedrop due to inductance. There
will be however, a very small voltage drop due to resistance.
During the tap change, the selector switches are selected to different taps (see Figure 2) and a
circulating current will flow in the reactor circuit. This circulating current will create a flux and the
resulting inductive reactance will limit the flow of circulating current.
3. Vacuum Switch
This device performs the duty of a circuit breaker that makes and breaks current during the tap
changing sequence.
4. Bypass Switch
This switch operates during the tap changing sequence but, at no time, does it make or break
load current, though it does make before break each connection.
An example of the tap changing sequence is detailed in Figure 2 (diagrams 1 through 10). Table
1describes the sequence of operations for the tap changer of Figure 2 to change from tap 1 to
tap 2. Changing to any other tap position is done similarly with the selector switch always moving
sequentially (i.e., it is impossible to go from tap 1 to tap 3 directly, the order must be tap 1, tap 2,
then tap 3).
The operating mechanism for the on-load tap changer is motor driven. Manual operation is used
in the event of motor failure.
The sequence of operation is mechanically linked, orinterlocked, to ensure that all contacts
always operate in their correct order. Any failure of the operating mechanism can result in severe
damage to the transformers and tap changers.
Table 1 - Description of Tap Changing Sequence for Figure 1
Vacuum switch opens, removing load current from lower circuit arm, freeing lower selector
switch for move.
8 As there is no load current on lower arm of selector switch, it moves to tap 2.
9 Vacuum switch closes both selector switches onload, in parallel, on tap 2.
With vacuum switch closed and selector switch on a single tap, the bypass switch can now
10 return to its home position. Both reactor circuits stay normally in parallel. The tap change is
now complete.
7
The previous example describes one type of on-load tap changer. There are several other types
inuse however, which may differ significantly from the type described.
Differences are usually in how the selection of taps is made and the degree of
mechanization. However, most importantly, all on-load tap changers allow voltage changes to
take place without interrupting the power circuit.
Function Principle of the OLTC (Video)
Reference: Science and Reactor Fundamentals Electrical CNSC Technical Training Group
URL of technical article at EEP: 4 Essential Features of Transformer On-Load Tap Changer
(OLTC)
Share with your friends!