Whereas the Parliament of India has set out to provide a practical regime of right to
information for citizens to secure access to information under the control of public authorities,
in order to promote transparency and accountability in the working of every public authority,
and whereas the attached publication of the Bureau of Indian Standards is of particular interest
to the public, particularly disadvantaged communities and those engaged in the pursuit of
education and knowledge, the attached public safety standard is made available to promote the
timely dissemination of this information in an accurate manner to the public.
1 +, 1 +
01 ' 5
Jawaharlal Nehru
! $ ' +-
Satyanarayan Gangaram Pitroda
! > 0 B
BharthariNtiatakam
( Reaffirmed xxxxxx
2001 )
2010
IS : 826 - 1986
Indian Standard
SPECIFICATION FOR
AMMONIUM SULPHATE, FERTILIZER GRADE
( Second Revision )
Fertilizers
Sectional
Committee,
Representing
Chairman
*SHRI
PCDC 20
Madras Fertilizers
V. R. R. GUPTA
Ltd, Madras
Members
DR T. S. VISWANATHAN ( Alternate to
Shri V. R. R. Gupta )
Pradesh
Agricultural
University,
AQRICULTURAL
CHEMIST
Andhra
Hyderabad
Indian Sugar Mills Association, Calcutta
SHRI BARUBALI GULABCRAND
SI~RI P. C. SAWIINEY ( Alternate )
National Test House, Calcutta
SHRI M. L. BHAMBANI
Directorate
General of Technical
Development,
SHRI A. K. BOSE
New Delhi
SHEI M. S. GROVER ( Alternate )
Indian
Chemical
Manufacturers
Association,
SHRI N. C. BRAHMA
Calcutta
SRRI P. S. BHAR~A (Alternate)
Ministry of Chemicals and Fertilizers
Swr S. CHAERA~O~TY
National Fertilizers Ltd, New Delhi
SHRI P. P. CHANDNA
Planning Commission
SHRI S. CHANDRASEEHAR
Department of Agriculture, Government of Uttar
DR R. K. S. CHAUHAN
Pradesh. Lucknow
Directorate General of Supplies & Disposals, New
SERI D. S. CHOWDHURY
Delhi
Punjab Agricultural University, Ludhiana
DR G. DEV
Ministry of Agriculture and Irrigation ( Fertilizer
Dn B. K. DHAR
Division )
SHRI K. R. AGOARWAL ( dlternate )
Ministry of Agriculture
and Irrigation (Crops
SARI A. C. GARB
Division )
*ShrS V. Ft. FL Gupta was Chairmanfor the meeting in which this standard
was flnslieed.
( Continued on page i
@
INDIAN
Copyright
STANDARDS
1980
INSTITUTION
This publication is protected under the Indian Copyright Act ( XIV of 1957 ) and
reproduction in whole or in part by any means except with written permission of the
publisher shall be deemed to be an infringement of copyright under the said Act.
IS:826-1980
( Continued
from fiuge1)
Representing
Members
Indian
Agricultural
Research
Institute,
New
Delhi; and Indian Council of Agricultural
Research, New Delhi
Director of Agriculture, Government of Punjab,
Chandiearh
Agricultural
Chemist
to the Government
of
Maharashtra, Bombay
DR A.B. GHOSH
DR K. S. GILL
Hn AD OB AGRICULTURAL
CHIZMISTRY & SOIL SCIENCE,
MAHATMA PH~JLEKRISHI VIDYAPEETII, RAHURI
E. I. D.-Parry ( India) Ltd, Madras
SHRI JOHN K. JOIIN
SHRI N. S. PARTIIASARATHY ( Alternate )
The Fertilizers and Chemicals Travancore
Ltd,
DR JOSEPH XAVIER
Udyogamandal
SHRI T. NATARAJAN ( Alternate )
Indian Farmers Fertilizers Co-operative Ltd, New
SIIRI S. D. KOI~PAL
Delhi
SHRI H. C. MALHOTRA ( Alternate )
Coromandel Fertilizers Ltd, Vishakhapatnam
SHRI M. R. KRISHNAIAH
SHRI K. R. K. MURTEY ( Alternate)
Directorate of Agriculture and Food Production,
SHRI U. C. PADIII
Government of Orissa, Bhubaneshwar
Rubber Board, Kottayam
DR S. NARAYANAN POTTY
SHRI M. V. PUSHPA DAS ( Alternate )
Shaw Wallace
SARI P. C. RAMAKRISI~NAN
SHRI D. MEENA~SHI SUNDARAM
( Alternale )
SIIRI A. K. RAO
SHRI B. K. WAHI ( Alternate )
SHRI SATYA NAND
SIIRI B. K. JAIN ( Alternate )
SHRI M. THEYIJNNI
DR M. S. VAIDYA
SHRI P. V. S. RAO (Alternate )
DR S. VERONA
Do K. M. VERIVIA( Alternate )
DR J. S. P. YADAV
Da I. P. ABROL (Alternate)
SHRI M. S. SAXENA,
Director ( P & C)
The D. C. M. Chemicals
The Fertilizer
Association
Works,
General,
New Delhi
Co Ltd, Bombay
& Development
Research
IS1 ( Ex-oficio
) India
Institute, Karnal
Member )
Secretary
DR R. A. KHAN
Assistant Director ( P & C ), ISI
( Continued on page 6 )
(FAD 7)
IS:826-1980
Indian Standard
SPECIFICATION FOR
AMMONIUM SULPHATE, FERTILIZER GRADE
( Second Revision )
0.
FOREWORD
of sampling
II Determination
VI Determination
of nitrogen.
of impurities.
fS:826-1980
1955 of Government
of India. However, this standard
provisions imposed under this Order wherever applicable.
is subject
to the
particular
requirement
of this
observed or calculated,
exprebe rounded off in accordance
places retained
in the rounof the specified value in this
1. SCOPE
1.1 This standard prescribes the requirements
and the methods of sampling and test for ammonium
sulphate, fertilizer grade. The material
may
also be used for other industrial
purposes.
2. REQUIREMENTS
2.1 Description
- The material
shall be in the form
crystals, and shall be free from extraneous
material.
2.2 The
Table I.
material
TABLE
shall
1
with
(2)
of sampling
given
in
SULPHATE,
1.0
0.025t
5.1 of Part VI
7 of Part VI
0.01
8 of Part VI
Part II Determination
Part VI Determination
TO.04 for material
requirements
nitrogen,
percent
by mass, lMin
Rloisture, percent by mass, MUX
Free acidity ( as HsS04 ), percent
by mass, Max
Arsenic ( as AssOs ), percent
by
mass, Max
*Methods
the
REQUIREMENTS
FOR AMMONIUM
FERTILIZER
GRADE
(1)
i) Ammoniacal
iv)
comply
CJURACTEKISTIC
5
i+:.
ii)
iii)
also
of free-flowing
of nitrogen.
of impurities.
ammonia
and by-product
gypsum.
*Specification for test sieves: Part I Wire cloth test sieves ( second revision).
tRules for rounding off numerical values ( revised ).
IS : 826 - 1980
3. PACKING
AND MARKING
and indelibly
,
a) Name of the fertilizer;
b) Name of the manufacturer
and his recognized
any;
c) Percentage
of ammoniacal
nitrogen by mass; and
d) Gross and net mass in kg.
3.2.1
Mark.
Each container
may
also be marked
with
the
the
following
trade-mark,
if
IS1 Certification
4. SAMPLING
4.1 Representative
test samples of the material
bed in IS : 6092 ( Part I )-1971.
shall
be drawn
as prescri-
of the lot
4.2 Criteria
for Conformity
- For declaring the conformity
to the requirements
of this specification,
the test results on the composite
sample shall satisfy all the requirements
specified in 2.
5. TEST
METHODS
IS:826.1980
( Continuedfrom
page 2 )
Fertilizers
& Allied
Convener
SHRI M. R. A~GARWAL
Members
Products
Subcommittee,
Rashtriya
PCDC 20 : 1
Representing
Chemicals & Fertilizers Ltd, Bombay
DR R. NATARAJAN
Southern Petrochemical
Industries Corporation
(SPIC ), Madras
SFIRI C. K. PANDARINATHAN
(Alternate)
E. I. D.-Parry ( India ) Ltd, Madras
SHRI N. S. PARTHASARATHY
SHRJ A. G. KJ~IP~L SINGE (. Alternate 1
Indian Sugar Mills Association, New Delhi
SHRI K. D. PURI
SHRI P. C. RAMAXRISHNAN
Shaw Wallace & Co Ltd, Madras
SHRI D. MEI~NAKSFIISUNDARAM ( Alternate )
Neyveli Lignite Corporation, Neyveli
SHRI P. T. RANRACHARI
SRRI H. B. RUDRAPPA ( Alternate )
Gujarat State Fertilizers Co Ltd, Vadodara
SHRI V. A. SANG~ANI
SHRI M. D. PATEL ( Alternate )
SHRI SATYA NAND
The Fertilizer Association of India, New Delhi
SHRI V. S. SIVAEHANKARAN( Alternate )
Haryana Agricultural University, Hissar
DR U. C. SHUKLA
DR M. L. CHOKJDHARY( Alterzate )
SHEI D. V. SINGH
Department
of Agriculture,
Government
of
Madhya Pradesh, Bhopal
Indian Farmers Fertilizers Co-operative Ltd, New
SHRI L. R. TALWAR
Delhi
SHRI S. JACOB ( Alternate)
SHRI ABRAHAM THOMAS
The Fertilizers
& Chemicals Travancore
Ltd,
Udyogamandal
SHRI D. PANIQRAHI II Alternate J
DR S. VERMA
The Fertilizer ( Planning & Development ) India
Ltd, Sindri
DR K. M. VERMA ( Alternate)